Milk Clotting Enzyme from Microorganisms

Out of some 800 strains of microorganisms, a potent fungus for milk clotting enzyme was isolated from soil during the course of screening tests and was identified as one of strains of Mucor pusillus Lindt. Satisfactory results were obtained in cheese making experiments with this enzyme which could be produced effectively by solid culture on wheat bran at 30°C for about 70 hrs.

The balance between milk clotting activity and proteolytic activity of this enzyme resembled very much to that of rennet.

Microbial rennet from Mucor pusillus F-27 was obtained with high productivity by solid culture followed by water extraction. The enzyme could be precipitated by salting out with ammonium sulfate and also by mixing with various water-miscible organic solvents such as ethanol, methanol or acetone.

This enzyme is one of acid proteases having its optimal pH for milk casein digestion around 3.5. The ratio of milk clotting activity to proteolytic activity of this enzyme resembled that of calf rennet than those of other proteases of fungal origin. This was more heat stable and more resistant against pH changes than animal rennet. Apparent activity of milk clotting was more affected by Ca ion concentration in milk than that of calf rennet.

The liberation of 12% TCA soluble nitrogen from casein fraction was a little less specific than that of calf rennet. The optimal temperature for milk clotting lay around 56°C.

Electrophoretic patterns of α-peak of casein treated with this enzyme showed the weak proteolysis which resembled that with rennet.     

CRYSTALLINE CHYMO-TRYPSIN AND CHYMO-TRYPSINOGEN : I. ISOLATION,CRYSTALLIZATION, AND GENERAL PROPERTIES OF A NEW PROTEOLYTIC ENZYME AND ITS PRECURSOR

A new crystalline protein, chymo-trypsinogen, has been isolated from acid extracts of fresh cattle pancreas. This protein is not an enzyme but is transformed by minute amounts of trypsin into an active proteolytic enzyme called chymo-trypsin. The chymo-trypsin has also been obtained in crystalline form. The chymo-trypsinogen cannot be activated by enterokinase, pepsin, inactive trypsin, or calcium chloride. There is an extremely slow spontaneous activation upon standing in solution. The activation of chymo-trypsinogen by trypsin follows the course of a monomolecular reaction the velocity constant of which is proportional to the trypsin concentration and independent of the chymotrypsinogen concentration. The rate of activation is a maximum at pH 7.0–8.0. Activation is accompanied by an increase of six primary amino groups per mole but no split products could be found, indicating that the activation consists in an intramolecular rearrangement. There is a slight change in optical activity but no change in molecular weight. The physical and chemical properties of both proteins are constant through a series of fractional crystallizations. The activity of chymo-trypsin decreases in proportion to the destruction of the native protein by pepsin digestion or denaturation by heat or acid. Chymo-trypsin has powerful milk-clotting power but does not clot blood plasma and differs qualitatively in this respect from the crystalline trypsin previously reported. It hydrolyzes sturin, casein, gelatin, and hemoglobin more slowly than does crystalline trypsin but the hydrolysis of casein is carried much further. The hydrolysis takes place at different linkages from those attacked by trypsin. The optimum pH for the digestion of casein is about 8.0–9.0. It does not hydrolyze any of a series of dipeptides or polypeptides tested. Several chemical and physical properties of both proteins have been determined.     

Specificity of a Nuclease from Penicillium citrinum

The enzyme with high milk clotting activity produced by Irpex lacteus was partially purified by a CM-cellulose chromatography. Throughout the over-all process, the enzyme was purified approximately 9-fold from a crude powder with about 22.8% recovery of the original activity. The MCA/PU ratio of this fraction was 2.51 and the specific milk clotting activity was 188.7.

The purified enzyme is a sort of acid protease with optimum pH of 2.5 for casein digestion and 4.0 for hemoglobin digestion. The Lineweaver-Burk plot, when casein was used as a substrate, showed that the Km value of the enzyme was about 0.07% and the V_max value was 0.4. The molecular weight of the enzyme is about 34,000, the isoelectric point is pH 5.2 and a ultraviolet absorption maximum is at 277 mμ. The enzyme has not yet been crystalized but seems to be a sort of glycoprotein, because the Molish reaction was positive at the present purification stage.

Some enzymological properties of the enzyme was studied and compared with those of a calf rennet and Mucor rennet. In some respects such as pH optima, pH stability, thermostability and temperature optima, the enzyme is Mucor rennet alike. On the other hand, as to the increase in activity along with decrease in pH of milk and the increase in activity along with the addition of Ca ion, the enzyme is not very different from the calf rennet. However, proteolysis of milk casein by the enzyme was fairly higher than by the calf rennet.

As to the production of enzymes, I. lacteus can produce at least three types of proteases into liquid media. When, for example, R medium was used, only one type of protease, that is the fraction A, could mainly be produced and it was this enzyme that assumed to be a rennet like enzyme.     

Production of highly active fungal milk-clotting enzyme by solid-state fermentation

Abstract

Cheese production is projected to reach 20 million metric tons by 2020, of which 33% is being produced using calf rennet (EC 3.4.23.4). There is shortage of calf rennet, and use of plant and microbial rennets, hydrolyze milk proteins non-specifically resulting in low curd yields. This study reports fungal enzymes obtained from cost effective medium, with minimal down streaming, whose activity is comparable with calf and Mucor rennet. Of the fifteen fungi that were screened, Mucor thermohyalospora (MTCC 1384) and Rhizopus azygosporus (MTCC 10195) exhibited the highest milk-clotting activity (MCA) of 18,383?±?486?U/ml and 16,373?± 558?U/ml, respectively. Optimization exhibited a 33% increase in enzyme production (30?g wheat bran containing 6% defatted soy meal at 30?°C, pH 7) for M. thermohyalospora. The enzyme was active from pH 5–10 and temperature 45–55?°C. Rhizopus azygosporus exhibited 31% increase in enzyme production (30?g wheat bran containing 4% defatted soy meal at 30?°C, pH 6) and the enzyme was active from pH 6–9 at 50?°C. Curd yields prepared from fungal enzyme extract decreased (5–9%), when compared with calf rennet and Mucor rennet. This study describes the potential of fungal enzymes, hitherto unreported, as a viable alternative to calf rennet     

Immobilization of rennet from Mucor miehei via its sugar chain. Its use in milk coagulation

A successful strategy for the immobilization of rennet from Mucor miehei has been developed. The strategy is based on the immobilization of the enzyme, via their sugar chains at high ionic strength on aminated supports having primary amino groups with a very low pK value. The rennet was covalently immobilized via sugar chains (previously oxidized with periodate), which act as natural spacer arms and allow a very high percentage of rennet activity to be kept against small (H-Leu-Ser-p-nitro-Phe-Nle-Ala-Leu-OMe.TFA (98%)) and macromolecular substrates (k-casein) (78%). The use of tailor-made aminated support was critical to obtain good stability values, because using fully aminated supports achieved much lower thermostability values than using 50% aminated supports. The optimized derivative was utilized to hydrolyze casein in milk. To prevent the coagulation of the milk in the presence of the derivative, the reaction was performed at 4 degrees C (where hydrolyzed casein did not precipitate). Then the hydrolyzed milk was filtered and latter on heated to 30 degrees C, achieving a similar aggregate to the one achieved with soluble rennet.     

Further purification and characterization of a thermophilic rennet

Further work on a thermophilic rennet synthesized by a thermophilic actinomycete is reported. It was produced by growth in fermentor of 50-or-200-L volume and was purified by membrane filtration of a cell-free supernatant and then molecular filtration and ion exchange chromatography. Its stability under various conditions was determined: The enzyme is a true rennet requiring calcium ions for activity. Experiment shows that it resembles neither pepsin, trypsin, nor chymotrypsin. It is freeze-labile with a molecular weight of 9700 from amino acid composition. When skim milk powder was added to the growth medium, a rennet with different properties was obtained.     

Application and validation of the lattice Boltzmann method for modelling flow-related clotting

The purpose of this paper is to present a simple clotting model, based on residence time and shear stress distribution, that can simulate the deposition over time of enzyme-activated milk in an in vitro system. Results for the model are compared with experiments exhibiting clot deposition in the region of a sharp-edged stenosis. The milk experiments have been shown to be a valuable analogue for the experimental representation of flow-induced blood clotting, particularly in the context of separation of hydrodynamic from biochemical factors. The facility to predict the flow-induced clotting of the blood analogue, in which the chemistry reduces to what is effectively a zeroth order reaction, gives confidence in this physics-based approach to simulation of the final part of the coagulation cascade. This type of study is a necessary precursor to the development of a complex, multi-factorial, biochemical model of the process of thrombosis. In addition to the clotting simulations, comparisons are reported between the computed flow patterns prior to clot deposition and flow visualisation studies. Excellent agreement of hydrodynamic parameters is reported for a Reynolds number of 100, and qualitative agreement is seen for the complex, disturbed flow occurring at a physiologically relevant Reynolds number of 550. The explicit, time-stepping lattice Boltzmann approach may have particular merit for the transitional flow at this higher Reynolds number.     

Surface display of acid protease on the cells of Yarrowia lipolytica for milk clotting

The acid protease structural gene was amplified from the genomic DNA of Saccharomycopsis fibuligera A11. When the gene was cloned into the multiple cloning site of the surface display vector pINA1317-YlCWP110 and expressed in the cells of Yarrowia lipolytica, the cells displaying the acid protease could form clear zone on the plate-containing milk indicating that they had extracellular acid protease activity. The cells displaying the acid protease can be used to effectively clot skimmed milk. The highest clotting milk activity (1,142.9 U/ml) was observed under the conditions of pH 3.0, 40 °C, 20 mM of CaCl₂, and 10% skimmed milk powder. We found that the acid protease displayed on the cells of Y. lipolytica which has generally regarded as safe status could be easily isolated and concentrated compared to the free acid protease. Therefore, the displayed acid protease may have many potential applications in food and cheese industries. This is the first report that the yeast cells displaying the acid protease were used to clot milk.     

Characterization of recombinant camel chymosin reveals superior properties for the coagulation of bovine and camel milk

Enzymatic milk coagulation for cheese manufacturing involves the cleavage of the scissile bond in kappa-casein by an aspartic acid protease. Bovine chymosin is the preferred enzyme, combining a strong clotting activity with a low general proteolytic activity. In the present study, we report expression and enzymatic properties of recombinant camel chymosin expressed in Aspergillus niger. Camel chymosin was shown to have different characteristics than bovine chymosin. Camel chymosin exhibits a 70% higher clotting activity for bovine milk and has only 20% of the unspecific protease activity for bovine chymosin. This results in a sevenfold higher ratio of clotting to general proteolytic activity. The enzyme is more thermostable than bovine chymosin. Kinetic analysis showed that half-saturation is achieved with less than 50% of the substrate required for bovine chymosin and turnover rates are lower. While raw camel milk cannot be clotted with bovine chymosin, a high clotting activity was found with camel chymosin.     

A flow cytometry method for rapid detection and enumeration of total bacteria in milk

Application of flow cytometry (FCM) to microbial analysis of milk is hampered by the presence of milk proteins and lipid particles. Here we report on the development of a rapid (/= 0.98) between the FCM assay and the more conventional methods of plating and direct microscopic counting was achieved. Raw milk data showed a significant correlation (P < 0.01) and a good agreement (r = 0.91) between FCM and standard plate count methods. The detection limit of the FCM assay was 相似文献   

Kinetics of milk coagulation: III. Mathematical modeling of the kinetics of curd formation following enzymatic hydrolysis of kappa-casein--parameter estimation

A step function model of milk micelle agglomeration is proposed to explain the observed kinetics of milk clotting following rennet addition. The model ties together the primary and secondary phases of coagulation. The basis of the model is that no micelle flocculation takes place until ca. 75% of the kappa-casein in the milk is hydrolyzed, at which time flocculation occurs rapidly and the rate limiting step for the clotting process shifts to the kappa-casein hydrolysis reaction. Using such a model, it is possible to explain the clotting kinetics for both rapidly denaturing enzymes and stable enzyme systems. The average rate of the flocculation reaction can be obtained from clotting time-versus-reciprocal-enzyme-concentration data by extrapolating the data to infinite enzyme concentration. The critical conversion required for imminent flocculation can be found by extrapolating the enzyme concentration to zero. This approach indicates that the critical conversion necessary for gelation is temperature dependent changing from a limiting value of essentially 100% hydrolysis at temperatures below 15 degrees C to only 60% conversion at temperatures above 30 degrees C.     

Purification and characterization of milk clotting enzyme from goat (Capra hircus)

Chymosin, the major component of rennet (milk clotting enzyme), is an acid protease produced in the fourth stomach of milk-fed ruminants including goat and sheep in the form of an inactive precursor prochymosin. It is responsible for hydrolysis of kappa-casein chain in casein micelles of milk and therefore, used as milk coagulant in cheese preparation. The present investigation was undertaken to purify and characterize goat (Capra hircus) chymosin for its suitability as milk coagulant. The enzyme was extracted from abomasal tissue of kid and purified nearly 30-fold using anion exchanger and gel filtration chromatography. Goat chymosin resolved into three major active peaks, indicating possible heterogeneity when passed through DEAE-cellulose ion exchange column. The purified enzyme had a molecular mass of 36 kDa on SDS-PAGE, which was further confirmed by Western blot analysis. The purified enzyme preparation was stable up to 55 degrees C with maximum activity at 30 degrees C. The milk clotting activity was decreased steadily as pH is increased and indicated maximum activity at pH 5.5. Proteolytic activity of goat chymosin increased with incubation time at 37 degrees C. Goat chymosin was found to be more thermostable than cattle chymosin and equally stable to buffalo chymosin.     

Breast-feeding patterns, maternal milk output and lactational infecundity.

Breast feeding can serve as a contraceptive up to 6 months after birth with 98% effectiveness. The so-called suckling reflex arc is a sensitive mechanism conveying messages about nutritional needs of the child, stimulating the release of prolactin responsible for milk production, suppressing ovarian activity by hypothalamic beta-endorphin production leading to reduction in the pulsatile release of gonadotrophic hormones. Increased suckling produces more milk, but only in well-fed women. In Bangladesh, malnourished children required more suckling time than better-fed infants. Increasing the amounts of weaning food lowers feed urgency and suckling intensity thereby relaxing ovarian suppression. Breast-milk consumption can be measured by test weighing the infant before and after feeding, but it is subject to error, especially in developing countries where up to 20 feeds are required to deliver 800 ml of milk. Thus, weighing over 2-5 days is more accurate. The method of giving deuterium oxide tracer to the mother, and measuring its disappearance from the mother's milk and the infant's saliva for 2 weeks is precise and noninvasive. The Doppler ultrasound technique measures milk flow through an artificial teat for research purposes. Manual or mechanical pump measurement of milk transfer separates the mother from the child, thus it is not useful for normal conditions. It can be used for estimating the amount of milk left and the rate of milk secretion by using a breast pump along with oxytocin for full emptying of milk. Accurate estimation of suckling intensity and milk transfer is essential for the determination of the relationship of breast feeding and lactational infecundity.     

Preservation of rennet producing Rhizomucor miehei strain

Summary Different methods are compared for the preservation of a Rhizomucor miehei strain used for the production of rennet, which is used in the dairy industry. The best method was found to be preservation under mineral oil, After 2 years of storage, R. miehei kept its original milk clotting activity, had a lowered non-specific proteolytic activity and therefore a higher specific activity.     

Engineering of a staphylokinase-based fibrinolytic agent with antithrombotic activity and targeting capability toward thrombin-rich fibrin and plasma clots

Current clinically approved thrombolytic agents have significant drawbacks including reocclusion and bleeding complications. To address these problems, a staphylokinase-based thrombolytic agent equipped with antithrombotic activity from hirudin was engineered. Because the N termini for both staphylokinase and hirudin are required for their activities, a Y-shaped molecule is generated using engineered coiled-coil sequences as the heterodimerization domain. This agent, designated HE-SAKK, was produced and assembled from Bacillus subtilis via secretion using an optimized co-cultivation approach. After a simple in vitro treatment to reshuffle the disulfide bonds of hirudin, both staphylokinase and hirudin in HE-SAKK showed biological activities comparable with their parent molecules. This agent was capable of targeting thrombin-rich fibrin clots and inhibiting clot-bound thrombin activity. The time required for lysing 50% of fibrin clot in the absence or presence of fibrinogen was shortened 21 and 30%, respectively, with HE-SAKK in comparison with staphylokinase. In plasma clot studies, the HE-SAKK concentration required to achieve a comparable 50% clot lysis time was at least 12 times less than that of staphylokinase. Therefore, HE-SAKK is a promising thrombolytic agent with the capability to target thrombin-rich fibrin clots and to minimize clot reformation during fibrinolysis.     

CONCENTRATION AND PURIFICATION OF BACTERIOPHAGE

1. A method for isolating a nucleoprotein from lysed staphylococci culture is described. 2. It is homogeneous in the ultracentrifuge and has a sedimentation constant of 650 x 10^–13 cm. dyne^–1 sec.^–1, corresponding to a molecular weight of about 300,000,000. 3. The diffusion coefficient varies from about 0.001 cm.²/day in solutions containing more than 0.1 mg. protein/ml. to 0.02 in solutions containing less than 0.001 mg. protein/ml. The rate of sedimentation also decreases as the concentration decreases. It is suggested, therefore, that this protein exists in various sized molecules of from 500,000–300,000,000 molecular weight, the proportion of small molecules increasing as the concentration decreases. 4. This protein is very unstable and is denatured by acidity greater than pH 5.0, by temperature over 50°C. for 5 minutes. It is digested by chymo-trypsin but not by trypsin. 5. The loss in activity by heat, acid, and chymo-trypsin digestion is roughly proportional to the amount of denatured protein formed under these conditions. 6. The rate of diffusion of the protein is the same as that of the active agent. 7. The rate of sedimentation of the protein is the same as that of the active agent. 8. The loss in activity when susceptible living or dead bacteria are added to a solution of the protein is proportional to the loss in protein from the solution. Non-susceptible bacteria remove neither protein nor activity. 9. The relative ultraviolet light absorption, as determined directly, agrees with that calculated from Gates'' inactivation experiments in the range of 2500–3000 Å. u. but is somewhat greater in the range of 2000–2500 Å. u. 10. Solubility determinations showed that most of the preparations contained at least two proteins, one being probably the denatured form of the other. Two preparations were obtained, however, which had about twice the specific activity of the earlier ones and which gave a solubility curve approximating that of a pure substance. 11. It is suggested that the formation of phage may be more simply explained by analogy with the autocatalytic formation of pepsin and trypsin than by analogy with the far more complicated system of living organisms.     

Production and characterization of a milk-clotting enzyme from Aspergillus oryzae MTCC 5341

Microbial milk-clotting enzymes are valued as calf rennet substitutes in the cheese industry. Aspergillus oryzae MTCC 5341 was identified to produce the highest milk-clotting activity during screening of 16 fungal strains. Solid state fermentation using wheat bran along with 4% defatted soy flour and 2% skim milk powder as substrate was optimal for growth of A. oryzae and production of the enzyme. Nearly 40,000 U/g bran of milk-clotting activity was present at the end of 120 h. The enzyme could be recovered by percolating the bran with 0.1 M sodium chloride for 60 min at 4°C. The decolorized enzyme preparation had high ratio of milk clotting to proteolytic activity. Affinity precipitation with alginate and subsequent elution with 0.5 M sodium chloride containing 0.2 M CaCl₂ resulted in an enzyme preparation with specific activity of 3,500 U/mg and 72% yield. Optimum pH and temperature for activity of the enzyme were characterized as 6.3 and 55°C, respectively. Milk-clotting enzyme showed differential degree of hydrolysis on casein components. High ratio of milk clotting to proteolytic activity coupled with low thermal stability strengthens the potential usefulness of milk-clotting enzyme of A. oryzae MTCC 5341 as a substitute for calf rennet in cheese manufacturing.     

Rennet-Induced Aggregation and Curd Formation from Skimmed Milk Powders Prepared under Different Sterilizing Conditions

Heat treatment during the production of skimmed milk powder causes denaturation of proteins, thereby affecting the physicochemical properties of the skimmed milk powder. To understand the effects of heat treatment on the sensitivity of the casein micelles in skimmed milk powders, low heating type (L), normal heating type (N), high heating type (H), and super-high heating type (SH), to reaction with rennet, rennet-induced curd formation was investigated. A well-developed network structure with wide spaces was observed only in the curd derived from the solution of type L skimmed milk powder. SDS–PAGE suggested that there was no difference in the amount of glycomacropeptide generated from κ-casein in the four types of skimmed milk powder, but casein micelles in the solution of type L skimmed milk powder formed aggregates most effectively. These results are discussed with respect to the thermal denaturation of proteins in skimmed milk powder.     

Partial purification of new milk-clotting enzyme produced by Nocardiopsis sp

Numerous attempts have been made to replace calf rennet with other milk clotting proteases because of limited supply and increasingly high prices. The aim of this work was to investigate the characteristic of the milk-clotting enzyme from Nocardiopsis sp. The partial purification extract was obtained by fractional precipitation with ammonium sulphate. Of the fractions obtained by precipitation, 40-60% possessed the milk-clotting activity (156.25 U/mg). The chromatography of 40-100% ammonium sulphate fraction in DEAE-cellulose yielded four fractions (F4, F5, F6, F7) with milk-clotting activity. The F5 yielded the best milk-clotting activity (20 U/ml). Both crude and partially purified extract were active at the range pH 4.5-11.0, however, optimum activity was displayed at pH 11.0 and pH 7.5, respectively. The milk-clotting activity was highest at 55 degrees C for both crude and partially purified extract. The crude and partial purification extract were inactivated at 65 and 75 degrees C after 30 min.     

Preparation and characterization of milk calcium salts by using casein phosphopeptide

Milk calcium salt solution was prepared by the following procedures using casein phosphopeptides (CPP). To CPP solution, 1 M citric acid, 1 M CaCl2 and 1 M K2HPO4 were added with stirring, while adjusting the pH to 6.7. The prepared solution was left for 12 hr at 25 degrees C and then used for subsequent experiments, or lyophilized. The concentrations of organic phosphate of CPP, calcium, inorganic phosphate, and citrate in the typical milk salt solution were 7, 30, 22, and 10 mM, respectively, which were close to those in bovine milk. The lyophilized sample was easily dissolved in water. No crystal structure of hydroxyapatite was shown in the lyophilized milk calcium salts by X-ray diffraction analysis, although the pattern of KCl crystal was observed. The X-ray diffraction pattern of commercial whey mineral, which was prepared by precipitation at alkaline pH from rennet whey, was similar to that of hydroxyapatite. It was confirmed by high-performance gel chromatographic analysis that the form of calcium phosphate in the milk calcium salts was similar to that of casein micelles.