Extraction conditions affecting supercritical fluid extraction (SFE) of lycopene from watermelon

Lycopene, a carotenoid linked to protection against certain forms of cancer, is found in produce such as papaya, red-fleshed tomatoes, grapefruit and watermelon. The preparation of a supercritical CO2 (SC-CO2) watermelon-lycopene extract could serve as a food grade source of this carotenoid. This study established preliminary conditions for enhancing SC-CO2 extraction of lycopene from watermelon. Freeze-dried watermelon was extracted with SC-CO2 and ethanol as an organic co-solvent. The lycopene concentration was determined by HPLC, with absorbance measured at 503 nm. In an initial set of experiments, the effects of extraction temperature (70-90 degrees C), pressure (20.7-41.4 MPa) and co-solvent ethanol addition (10-15%) were evaluated. A lycopene yield of 38 microg per gram of wet weight was obtained at 70 degrees C, 20.7 MPa, and 15% by volume ethanol. The extraction of fresh (non-freeze-dried) watermelon yielded 103+/-6 microg lycopene per gram fresh fruit weight. Of the parameters tested, temperature had the most effect on lycopene yield. Thus, in another set of experiments, the temperature was varied from 60-75 degrees C at an extraction pressure of 20.7 MPa in the presence of 15% ethanol. Studies showed that freeze-dried watermelon flesh loses lycopene in storage. In accounting for lycopene storage losses, lycopene yields at 60 degrees C extraction temperature were 14% greater than those obtained at 70 degrees C.     

硅藻金色奥杜藻色素的HPLC分析与超临界CO2萃取研究

以硅藻金色奥杜藻(Odontella aurita)为实验材料,利用高效液相色谱法分析了其色素组成与含量,采取超临界CO2萃取技术研究了从干藻粉内提取岩藻黄素的条件。结果表明,该藻主要含有岩藻黄素、硅甲藻黄素、β-胡萝卜素、硅藻黄素等类胡萝卜素以及叶绿素a和叶绿素c1,其中岩藻黄素为该藻含量最高的类胡萝卜素。色素的萃取率与压强、温度、夹带剂含量以及萃取时间呈正相关,夹带剂含量对萃取率影响最大,CO2流速的影响最小;与有机溶剂法相比,超临界CO2萃取岩藻黄素效率略低,而更利于岩藻黄素的选择性萃取及分离提纯;岩藻黄素的SFE-CO2适宜条件为压强400 bar、温度50℃、CO2流速0.2 L/min、夹带剂比例10%、萃取时间2～3 h。     

Purification of synthetic all-E lycophyll (psi,psi-carotene-16,16'-diol)

An efficient purification of synthetic all-trans (all-E) lycophyll is described. The synthetic preparation of the rare xanthophyll lycophyll produces a mixture of geometric isomers. Purification by HPLC using reverse-phase C30 silica affords milligram quantities of the desired all-trans isomer in >95% purity, as confirmed by (1)H NMR and LC/MS. Most recently, a facile work-up of the geometric mixture formed during total synthesis was found to provide multigrams of the targeted all-E geometric isomer of lycophyll. The acquisition of modest quantities of this specific lycopene analog allows its therapeutic potential to be explored.     

Extraction of cashew (Anacardium occidentale) nut shell liquid using supercritical carbon dioxide

This work investigated the extraction of cashew nut shell liquid (CNSL) using supercritical carbon dioxide (SC-CO(2)). Effects of process parameters such as extraction pressure, temperature and flow rate of SC-CO(2) were investigated. The yield of CNSL increased with increase in pressure, temperature and mass flow rate of SC-CO(2). However, under different operating conditions, the composition of CNSL varied. The study of physical properties and chemical composition of the oil obtained through super critical fluid extraction (SCFE) showed better quality as compared to the CNSL obtained through thermal route. Experimental results were compared with diffusion based mass transfer model. Based on this simple model, extraction time was optimized.     

SC-CO2和乙酸乙酯萃取芸香中活性成分的比较分析

为了探讨超临界二氧化碳(supercritical carbon dioxide, SC-CO2)技术与提取物的分级分离在萃取芸香活性成分的应用价值,本研究采用SC-CO2和乙酸乙酯萃取芸香中植物蜡和活性成分,并调查粒径和CO2流量对提取产量的影响。在250 bar、40℃条件下提取,并使第一个分离器冷却到-10℃,可获得较好的提取效率。当粒径较小时,提取过程更快,即内部传质控制该过程。分级分离可选择性去除表皮植物蜡,约占由SC-CO2处理产生的总提取物的77.5%W/W。第二分离器中的获得的提取物中活性化合物可达86.3%W/W。随后采用气相色谱-质谱联用仪(gas chromatography-mass spectrometry, GC-MS)分析表明,乙酸乙酯提取物低于SC-CO2提取物的萃取效率,主要是由于提取物中含有大量的植物蜡。本研究为超临界二氧化碳技术在萃取芸香活性成分方面的提供技术参考。     

Sequential substitution of 1,2-dichloro-ethene: a convenient stereoselective route to (9Z,11E)-, (10E,12Z)- and (10Z,12Z)-

Conjugated linoleic acid (CLA) isomers are present in human foods derived from milk or ruminant meat. To study their metabolism, (9Z,11E)-, (10E,12Z)- and (10Z,12Z)-[1-(14)C]-octadecadienoic acids with high radiochemical and isomeric purities (>98%) were prepared by stereoselective multi-step syntheses involving sequential substitution of 1,2-dichloro-ethene. In the case of the (9Z,11E) isomer, a first metal-catalyzed cross-coupling reaction between (E)-1,2-dichloro-ethene and 2-non-8-ynyloxy-tetrahydro-pyran, obtained from 7-bromo-heptan-1-ol, gave a conjugated chloroenyne. A second coupling reaction with hexylmagnesium bromide provided a heptadecenynyl derivative. Stereoselective reduction of the triple bond and bromination afforded (7E,9Z)-17-bromo-heptadeca-7,9-diene. Formation of the Grignard reagent and carbonation with 14CO(2) gave (9Z,11E)-[1-(14)C]-octadeca-9,11-dienoic acid (overall yield from 7-bromo-heptan-1-ol, 14.4%). (10E,12Z)- and (10Z,12Z)-[1-(14)C]-octadeca-10,12-dienoic acids were synthesized by the same methodology using 1-heptyne, 8-bromo-octan-1-ol and, respectively, (E)-1,2-dichloro-ethene and its (Z) isomer (overall yield from 8-bromo-octan-1-ol, 13.1% (10E,12Z); 17.2% (10Z,12Z)). Impurities (<2% if present) were identified as being (E,E) CLA isomers and were removed by RP-HPLC. Metabolism studies in animal are in progress.     

Simulated moving bed chromatography with supercritical fluids for the resolution of bi-naphthol enantiomers and phytol isomers

The combination of the simulated moving bed (SMB) technique with supercritical fluid chromatography (SFC) leads to a process with unique features. Besides the known advantages of the SMB process, the use of supercritical carbon dioxide as the mobile phase offers the advantages of reduction in organic solvents and an easy eluent/solute separation. Because of the low viscosity and high diffusion coefficients of supercritical fluids, a high efficiency is possible. The steps of process development for SMB SFC are presented using the separations of the bi-naphthol enantiomers and phytol isomers as examples. The development of a packed column SFC method at an analytical scale is shown for the separation of the bi-naphthol enantiomers on a chiral stationary phase and CO(2) with a modifier as the mobile phase. The influence of the modifier, modifier content, and column configuration on productivity of the SMB SFC process was investigated by simulation. The first set of experiments was performed in the SMB separation of phytol isomers at low concentration to test the feasibility of the SMB SFC high purity separation of the binary mixtures. In the second set of experiments, the productivity of the process was increased by increasing the feed concentration up to 54 grams feed per liter stationary phase (SP) and hour (g(feed)/l(SP) h).     

Identification of carotenoids in Erwinia herbicola and in a transformed Escherichia coli strain

The yellow pigments of Erwinia herbicola Eho 10 and of a transformed Escherichia coli LE392 pPL376 have been identified as carotenoids. HPLC separation, spectra and in some cases mass spectroscopy demonstrated the presence of phytoene (15-cis isomer), beta-carotene (all-trans, 9-cis and 15-cis), beta-cryptoxanthin ( = 3-hydroxy beta-carotene), zeaxanthin (3,3'-dihydroxy beta-carotene) and corresponding carotene glycosides. In addition, lycopene and gamma-carotene accumulated in the presence of the inhibitor 2-(4-chlorophenylthio)-triethylamine.HCl. Carotenoid content in the transformed E. coli was two-fold higher than in E. herbicola. The pattern of the carotenoids was similar in the two organisms. Inactivation of the katF gene in E. coli resulted in an 85% lowering of carotenoid formation, as did the addition of 0.5% glucose to the medium. Suppression of carotenoid formation by inactivation of the katF gene lowered, but did not abolish, the protection offered by carotenoids against inactivation by alpha-terthienyl plus near-ultraviolet light (320-400 nm).     

Application of supercritical fluid extraction in biotechnology

In the present paper recent investigations on the applications of supercritical fluid extraction (SCE) from post fermentation biomass or in situ extraction of inhibitory fermentation products as a promising method for increasing the yield of extraction have been reviewed. Although supercritical CO2 (SC-CO2) is unfriendly, or even toxic, for some living cells and precludes direct fermentation in dense CO2, it does not rule out other useful applications for in situ extraction of inhibitory fermentation products and fractional extraction of biomass constituents. This technique is a highly desirable method for fractional extraction of biomass constituents, and intracellular metabolites due to the potential of system modification by physical parameters and addition of co-solvents to selectively extract compounds of different polarity, volatility and hydrophilicity without any contamination.     

Enzymatic dipeptide synthesis by surfactant-coated alpha-chymotrypsin complexes in supercritical carbon dioxide

Enzymatic dipeptide synthesis by surfactant-coated alpha-chymotrypsin complexes was performed in supercritical CO(2) and liquid CO(2) at 308.2 and 333.2 K at pressures of 6.1 and 10.1 MPa. The enzymatic activity of coated alpha-chymotrypsin complexes for dipeptides synthesis at 10.1 MPa in supercritical CO(2) (SC-CO(2)) was higher than that in a liquid CO(2) and ethyl acetate solution at 6.1 MPa. The behavior of alpha-chymotrypsin in SC-CO(2) was similar to that in liquid ethyl acetate. And increasing the pressure and temperature increased the maximum conversion and the enzymatic reaction rate in SC-CO(2). Furthermore, the control of the water content in the reaction media had a dominant effect on the enzymatic activity. The maximum conversion for the dipeptide synthesis by the surfactant-coated alpha-chymotrypsin was obtained at 4% water content. The alpha-chymotrypsin complexes exhibited a higher enzymatic activity than native alpha-chymotrypsin in SC-CO(2). The nonionic surfactants l-glutamic acid dialkyl ester ribitol amide and sorbitan monostearate were more favored than the anionic surfactant sodium bis(2-ethylhexyl)sulfosuccinate.     

cis-trans isomers of lycopene and beta-carotene in human serum and tissues.

Since cis or trans isomers of carotenoids may have different biological reactivities, the isomeric composition of lycopene and beta-carotene was measured in serum and seven human tissues. In addition to all-trans lycopene, at least three cis-isomers (9-, 13-, and 15-cis) were present, accounting for more than 50% of total lycopene. 13- and 15-cis-beta-carotene, however, were present at only 5% of the all-trans isomer. In addition, 9-cis-beta-carotene was present in tissue samples but not in serum. There were interindividual differences in carotenoid levels of the different tissue types, but liver, adrenal gland, and testes always contained significantly higher amounts of the carotenoids than kidney, ovary, and fat; carotenoids in brain stem tissue were below the detection limit. beta-Carotene was the major carotenoid in liver, adrenal gland, kidney, ovary, and fat, whereas lycopene was the predominant carotenoid in testes.     

Effect of salinity on the quantity and quality of carotenoids accumulated by Dunaliella salina (strain CONC-007) and Dunaliella bardawil (strain ATCC 30861) Chlorophyta

Dunaliella salina and D. bardawil are well-known microalgae accumulating high levels of beta-carotene under growth-limiting conditions. In both taxa, this pigment is primarily composed of the isomers 9-cis and all-trans. The 9-cis beta-carotene occurs only in natural sources and is the most attractive from a commercial point of view. The conditions that enhance the preferred accumulation of 9-cis beta-carotene in D. salina are controversial and they have not been well established yet. This study examined the effect of salinity on the quantity and quality of total carotenoids and beta-carotene isomers accumulated by D. salina (strain CONC-007) and D. bardawil (strain ATCC 30861) grown in two media with different nutritional compositions (PES and ART) and at salt concentrations of 1M, 2M and 3M NaCl. Total carotenoids were determined by spectrophotometry and beta-carotene isomers, by HPLC. The highest carotenoid contents per cell were obtained at 2M NaCl in both taxa. In both media, an increase of the 9-cis/all-trans beta-carotene ratio was observed in D. bardawil when the salt concentration increased, with a maximum value of 2.6 (in ART medium at 3M NaCl). In D. salina this ratio did not exhibit the same pattern, and the salt concentrations for maximal ratios were different in both media. The highest ratio obtained for this strain was 4.3 (in ART medium at 2M NaCl).     

A novel procedure for the isolation of glycolipids from Bifidobacterium adolescentis 94 BIM using supercritical carbon dioxide

This study describes a novel isolation procedure for major glycolipids from Bifidobacterium adolescentis 94 BIM. The procedure consists of the use of supercritical carbon dioxide (scCO(2)) with hydro-methanolic solution as co-solvent. The major glycolipids were isolated using the following operating conditions: pressure, 30 MPa, co-solvent concentration, 10% (9:1, methanol/water, v/v), CO(2) flow rate, 5 g/min, extraction time and temperature, 2h and 55 degrees C, respectively. The reference glycolipids sample was prepared by classical organic solvent extraction followed by chromatographic purification. All isolates were characterized by TLC and the major glycolipids additionally by enzyme linked immunosorbent (ELISA). Sixty milligrams of glycolipids with similar immunoreactivity as the reference glycolipids were isolated from 1g of freeze-dried biomass (6% of yield).     

An ecofriendly approach to process rice bran for high quality rice bran oil using supercritical carbon dioxide for nutraceutical applications

An integrated approach to extraction and refining of RBO using supercritical carbon dioxide (SC-CO2) in order to preserve the nutritionally important phytochemicals is reported here. Process variables such as pressure, temperature, time, solvent flow rate and packing material on extraction yield and quality of RBO were investigated using a pilot model SC-CO2 extraction system. Three isobaric (350, 425 and 500 bar), three isothermal temperatures (50, 60 and 70 degrees C), three extraction times (0.5, 1 and 1.5h), at 40/min CO2 flow rate and three packing materials (pebbles, glass beads and structured SS rings) were employed. The RBO yield with SC-CO2 extraction increased with temperature and time under isobaric conditions. At the 60 degrees C isotherm, an increase in the RBO yield was obtained with an increase in the pressure and time. The RBO yield increased significantly with structured SS rings used as packing material. The RBO extracted with SC-CO2 had negligible phosphatides, wax and prooxidant metals (Fe and Cu) and was far superior in color quality when compared with RBO extracted with hexane. At the optimum condition of extraction at 500 bar, 60 degrees C for 1.5h, with structured SS rings used as packing material, the yield of RBO was comparable with that of hexane extraction (22.5%). The phytochemical contents of the RBO under the optimum conditions were in the range of tocols, 1500-1800 ppm; sterols, 15,350-19,120 ppm and oryzanol 5800-11,110 ppm.     

Geometrical E/Z isomers of (6R)- and (6S)-neoxanthin and biological implications

9'Z-(3S,5R,6R,3'S,5'R,6'S)-Neoxanthin reisolated from spinach (Spinacea oleracea) and characterized by HPLC, VIS, MS, and 2D (1)H NMR, has been submitted to photoinduced stereomutation in the presence of iodine or diphenyl diselenide at conditions not involving isomerization of the allenic bond. The six individual geometrical isomers, all-E,9Z,9'Z,13Z,13'Z,15Z and three minor di-Z-isomers, presumably 9,9'-di-Z,9',13-di-Z and 9',13'-di-Z, present in the equilibrium mixture have been characterized by HPLC, VIS data, 1H NMR and reversibility tests. Judged by the quantitative composition of the equilibrium mixture the naturally occurring 9'Z-isomer is thermodynamically less stable than the all-E-isomer. The availability of these isomers facilitates future search in natural sources. 9'Z-(6R90% of total neoxanthin in spinach and broccoli (Brassica oleracea var. italica), consistent with previous findings of its abundance in chloroplasts. all-E90% of total violaxanthin in the same sources. It is postulated that a neoxanthin Delta9'-isomerase is present and involved in the biosynthesis of abscisic acid in higher plants. Allenic S-isomers are of interest as postulated biosynthetic precursors of R-allenes. All-E-(6S)- and 9'Z-(6S)-neoxanthin were available as semi-synthetic model compounds. The allenic (6S)-diastereomers could not be detected in spinach or broccoli.     

Isolation of chlorophylls and carotenoids from freshwater algae using different extraction methods

Usually marine algae are an excellent source of pigments for different commercial sectors. Freshwater macroalgae can be exploited as a good source of biologically active compounds provided an appropriate extraction method is developed. The efficiency of four methods, like microwave‐assisted (MAE), ultrasound‐assisted extraction (UAE), supercritical fluid extraction (SFE) with ethanol as a co‐solvent, as well as conventional Soxhlet extraction were studied in the same conditions (time, solvent and temperature) for the recovery of chlorophylls and carotenoids from three freshwater green algae species: Cladophora glomerata, Cladophora rivularis and Ulva flexuosa. UV‐Vis spectrophotometry was used to determine chlorophyll a, chlorophyll b and total carotenoid content in obtained extracts. The results of this study showed that the advantages of novel extraction techniques (MAE and UAE) include higher yield and, in consequence, lower costs compared to traditional solvent extraction techniques. These methods were much more efficient in freshwater green algae pigment recovery than the classic Soxhlet extraction as well as SFE.     

Alpha-chymotrypsin catalysis in imidazolium-based ionic liquids

The transesterification reaction of N-acetyl-L-phenylalanine ethyl ester with 1-propanol catalyzed by alpha-chymotrypsin was examined in the ionic liquids 1-butyl-3-methylimidazolium hexafluorophosphate ([bmim][PF(6)]) and 1-octyl-3-methylimidazolium hexafluorophosphate ([omim][PF(6)]), and in combination with supercritical carbon dioxide (SC-CO(2)). The activity of alpha-chymotrypsin was studied to determine whether trends in solvent polarity, water activity, and enzyme support properties, observed with this enzyme in conventional organic solvents, hold for the novel environment provided by ionic liquids. alpha-Chymotrypsin freeze-dried with K(2)HPO(4), KCl, or poly(ethylene glycol) demonstrated no activity in [bmim][PF(6)] or [omim][PF(6)] at very low water concentrations, but moderate transesterification rates were observed with the ionic liquids containing 0.25% water (v/v) and higher. However, the physical complexation of the enzyme with poly(ethylene glycol) or KCl did not substantially stimulate activity in the ionic liquids, unlike that observed in hexane or isooctane. Activities were considerably higher in [omim][PF(6)] than [bmim][PF(6)]. Added water was not necessary for enzyme activity when ionic liquids were combined with SC-CO(2). These results indicate that [bmim][PF(6)] and [omim][PF(6)] provide a relatively polar environment, which can be modified with nonpolar SC-CO(2) to optimize enzyme activity.     

Beta-carotene from cassava (Manihot esculenta Crantz) leaves improves vitamin A status in rats

The bioavailability of beta-carotene from cassava (Manihot esculenta Crantz) leaves was assayed in vitamin A deficient Wistar rats (Rattus norvegicus). Rats were separated into three groups and fed with a modified AIN-93G--vitamin A deficient--diet. Deficient rat received this diet without any additional vitamin A source. Controls received the diet with 7200 microg of synthetic beta-carotene (control), while experimentals (test) received 19.5 g of cassava leaves powder per kg of diet. The cassava leaves with beta-carotene promotes similar growth and tissue weight in rats to the synthetic beta-carotene. The relative bioavailability, estimated as the Retinol Accumulation Factor (RAF), was 16.5 and 27.5 for control and test groups, respectively, indicating that control and test rats should have an intake of 16.5 microg or 27.5 microg of beta-carotene from synthetic form or cassava leaves powder for each 1 microg of hepatic retinol stored, respectively. The cassava leaves beta-carotene bioavailability was lower than the synthetic beta-carotene probably because the beta-carotene from the leaf matrix may be bounded to protein complex or inside organelles, which impair carotenoid absorption. Our findings showed that beside the hepatic retinol recovery, cassava leaf beta-carotene could maintain rat growth and avoid vitamin A deficient symptoms.     

超临界CO2萃取去除蛋黄粉中胆固醇和甘油三酯的研究

采用超临界CO2萃取,对去除蛋白黄粉中胆固醇和甘油三酯进行了研究,市购鲜鸡蛋去壳、分别收集湿蛋白和蛋黄,在45℃下分别真空干燥,得蛋白粉和蛋黄粉,取蛋黄粉装入高压釜中,进行超临界CO2循环萃取,通过正交试验得最佳工艺条件是：A萃取压力为31.5MPa,B萃取温度40℃,C被萃取蛋黄粉重300g,D萃取时间3h,所得蛋黄粉中胆固醇和甘油三酯等中性脂的残留量质量分数仅为0.019%,与不含此类旨质的蛋白粉混合,制成几乎不含胆固醇和甘油三酯的高级绿色保健营养食品－－鸡蛋粉。     

Effect of process variables on supercritical fluid disruption of Ralstonia eutropha cells for poly(R-hydroxybutyrate) recovery

This research focuses on the disruption of the gram-negative bacterium Ralstonia eutropha cells by supercritical CO2 for poly(R-hydroxybutyrate) (PHB) recovery. The variables affecting cell disruption such as drying strategy, type of modifier, and cultivation time, as well as operating pressure, temperature, and repeated release of supercritical CO2 pressure, have been studied. Effect of this disruption technique on PHB molecular mass was also investigated. PHB recovery was examined using a combination of this method and chemical pretreatments. For salt pretreatment, the cells were exposed to 140 mM NaCl and heat (60 degrees C, 1 h). The cells were also exposed to 0.2-0.8% (w/w) NaOH to examine the effect of alkaline pretreatment. Bacterial cells treated in growth phase exhibited less resistance to disruption than nutrient-limited cells in the stationary phase. It was also found that the wet cells could be utilized to recover PHB, but purity of the product was lower than that obtained from freeze-dried cells. Pretreatment with a minimum of 0.4% (w/w) NaOH was necessary to enable complete disruption with two times pressure release. Salt pretreatment was less effective; however, disruption was improved by the application of alkaline shock. The proposed method is economic and comparable with other recovery methods in terms of the percentage of PHB recovery and energy consumption, while it is environmentally more benign.