The Effect of High Sugar Concentrations on the Heat Resistance of Vegetative Micro-organisms

S ummary . The effect of sucrose or mixtures of sucrose and glucose, in the heating menstruum, on the heat resistance of 4 organisms, Salmonella senftenberg, Salm. typhimurium, Saccharomyces rouxii and Torulopsis globosa , was investigated and the results have been expressed in terms of D and z values against water activity ( a_w ). The effect on the cell of sucrose solutions, both with and without heat, was also investigated. Measurements of cell volume obtained from phase contrast micrographs and of O.D. showed that as the sucrose concentration increased, the volume of the cell decreased. The increased heat resistance exhibited by cells in sucrose solutions of low a_w is thought to be the result of a dehydration of the cell together with a reduction in the pore size of the cell wall.     

Effect of Water Activity on Heat Survival of Staphylococcus aureus, Salmonella typhimurium and Salm. senftenberg

The viability of Staphylococcus aureus heated at 55° in phosphate buffer was determined on recovery media of different water activity ( a_w ) levels. The basal recovery medium, tryptone–soya agar ( a_w 0.997) was adjusted to lower a_w levels by the addition of NaCl, glycerol or sucrose. Maximum survival occurred at a_w 0.997. Viability was reduced to 1/10 of the maximum at a_w 0.98 when a_w , was controlled by sucrose or NaCl but not until a_w 0.93 with glycerol. To eliminate effects such as incomplete mixing or post-heating dilution and in order to use conditions comparable to those occurring in foods, a solid medium heating/recovery method was also used. This involved heating, by immersion, of surface-inoculated agar plates and recovery of survivors in situ . Heat resistance studies could thus only be carried out at a_w levels permitting growth on the heating/recovery medium. Staphylococcus aureus, Salmonella typhimurium and Salm. senftenberg 775W were heated at 55° and recovered in situ on tryptone-soya agar adjusted to lower a_w levels as above. Maximum survival of Staph. aureus occurred at a higher a_w with glycerol ( a_w 0.965) than with NaCl (0.92) or sucrose (0.90). The maximum survival of both Salm. typhimurium and Staph. aureus heated at 55° occurred at the same a_w (0.965) with glycerol. This maximum was not affected by the duration of heating. As a contrast, heat resistance of Salm. senftenberg 775W was virtually unaffected by reduction in the a_w of the heating/recovery medium.     

The effect of copper on the death rate of Salmonella typhimurium DT104:30 in food substrates acidified with organic acids

AIMS: The objective of this study was to investigate the effect of copper ions on the survival of Salmonella typhimurium DT104:30 in acidified liquid food substrates. METHODS AND RESULTS: The decimal reduction time (Dvalue) of Salm. typhimurium DT104:30 was determined in acidified liquid pig feed (LPF) and skimmed milk (SM) containing a range of copper concentrations (0-50 ppm). As copper concentration increased, the death rate of Salm. typhimurium DT104:30 increased. In LPF acidified with 150 mmol l-1 lactic acid the presence of 50 ppm copper resulted in a 10-fold increase in the death rate. CONCLUSIONS: The presence of copper salts in acidic liquid food substrates significantly increases the death rate of Salm. typhimurium DT104:30. SIGNIFICANCE AND IMPACT OF THE STUDY: This finding could influence policy on levels of copper in pig feed.     

Cell-cell interactions influence resistance and survival of Salmonella serotype Typhimurium to environmental stress

AIMS: The aim of this work was to study the effects of prolonged nutrient stress on survival, cell interactions and resistance to inimical processes in Salmonella serotype Typhimurium. METHODS AND RESULTS: Salmonella Typhimurium cells were subjected to prolonged incubation in the stationary phase of growth and the properties of starved cells (old) were investigated with reference to those of exponentially-growing cells (young). Competition experiments between old and young cells revealed cell-cell interactions that influenced stationary phase survival and response of the bacterium to heat stress. During prolonged incubation of cells, cycles of resistance and sensitivity to heat stress were identified. Competition experiments between old and young cells revealed that the resistance of young cells to heat increased to levels more like those of stationary phase cells than growing cells. The presence of old cells influenced the phenotype of young cells, possibly by means of cell-cell interactions. There was no evidence for the involvement of any extracellularly-produced factors in this phenomenon, but a requirement that the old competitor cells be viable could be demonstrated. CONCLUSIONS: It is proposed that the complex interactions within stationary phase cultures of Salm. Typhimurium may be due to cycles of mutation in concert with an as yet undefined interaction between old cells and growing ones. SIGNIFICANCE AND IMPACT OF THE STUDY: This study provides evidence for active and diverse responses to nutrient stress within populations of Salm. Typhimurium that promote survival and that may be important for the success of this bacterium as a pathogen.     

Protective effect of casein toward Salmonella typhimurium in acid-milk

Lactic acid is the inhibitory agent in yoghurt responsible for the inhibition of Salmonella typhimurium. Casein, however, may exert a protective effect toward the survival of the salmonella in acid-milk products. Salmonella typhimurium was found to die-off 21.2% more rapidly in 18-h yoghurt-whey than in 18-h yoghurt at 37 C with a pH of 3.85 and 1.42% lactic acid. When casein was added to yoghurt-whey, the die-off rate of the salmonellas was reduced to that found in yoghurt. The rate remained unchanged when 4.8% sodium caseinate was added to the whey. When 0 to 14% casein was added to the acid-whey the die-off rate changed from 9.7 to 24.0 min/log reduction of cells, respectively. There was a direct correlation between the increase in casein concentration and length of survival of the salmonellas. At a pH of 3.85, 4.2 or 4.5, the die-off rate was 6.5, 13.0 or 40 min/log reduction of cells in milk containing 1.42% lactic acid, and was 4.0, 10.0 or 33.3 min/log reduction, respectively, in whey with 1.42% lactic acid. Thus, the protective effect of casein toward Salm. typhimurium incieased as the pH increased. This indicated that casein exerts a protective effect on Salm. typhimurium in acid dairy products and the degree of protection depends on the casein concentration, the form of the casein molecule and the pH.     

Protective effect of casein toward Salmonella typhimurium in acid-milk

Lactic acid is the inhibitory agent in yoghurt responsible for the inhibition of Salmonella typhimurium. Casein, however, may exert a protective effect toward the survival of the salmonella in acid-milk products. Salmonella typhimurium was found to die-off 21.2% more rapidly in 18-h yoghurt-whey than in 18-h yoghurt at 37 degrees C with a pH of 3.85 and 1.42% lactic acid. When casein was added to yoghurt-whey, the die-off rate of the salmonellas was reduced to that found in yoghurt. The rate remained unchanged when 4.8% sodium caseinate was added to the whey. When 0 to 14% casein was added to the acid-whey the die-off rate changed from 9.7 to 24.0 min/log reduction of cells, respectively. There was a direct correlation between the increase in casein concentration and length of survival of the salmonellas. At a pH of 3.85, 4.2 or 4.5, the die-off rate was 6.5, 13.0 or 40 min/log reduction of cells in milk containing 1.42% lactic acid, and was 4.0, 10.0 or 33.3 min/log reduction, respectively, in whey with 1.42% lactic acid. Thus, the protective effect of casein toward Salm. typhimurium increased as the pH increased. This indicated that casein exerts a protective effect on Salm. typhimurium in acid dairy products and the degree of protection depends on the casein concentration, the form of the casein molecule and the pH.     

Heat Resistance of Salmonellae in Concentrated Milk

The heat resistance of Escherichia coli, Salmonella typhimurium, and Salmonella alachua in milk solutions containing 10, 30, 42, and 51% (w/w) skim milk for total solids was determined. Increased milk-solids level effected a significant increase in the heat resistance of each organism. Although E. coli was more heat-resistant than both strains of Salmonella in 10% milk, the situation was reversed in 42 and 51% milk. Prior growth temperature was found to exert a profound effect on the heat resistance of S. typhimurium. Growth of S. typhimurium in 42% milk solids for 24 hr did not greatly enhance the thermal resistance of the organism when heated in a fresh 42% solids concentrate. Application of a partial vaccum during heating greatly diminished the decimal reduction times of S. typhimurium and E. coli and, in addition, virtually eliminated the protective effect of increased solids level.     

Effects of storage and the presence of a beef microflora on the thermal resistance of Salmonella Typhimurium DT104 in beef and broth systems

AIMS: To investigate the effects of storage and the presence of a beef microflora on the thermal resistance of Salmonella serotype Typhimurium DT104 on beef surfaces and in a broth system during subsequent heat treatments after extended low-temperature storage (4 degrees C for 14 days) or mild temperature abuse (10 degrees C for 7 days). METHODS AND RESULTS: Surviving Salm. Typhimurium DT104 cells were estimated after heating in a water bath (55 degrees C) by plating beef and broth samples on tryptone soya agar and overlaying with xylose-lysine-deoxycholate agar. In beef and broth systems, D(55) values for Salm. Typhimurium DT104 stored at 4 degrees C or 10 degrees C in the presence or absence of a beef microflora were significantly lower (P < 0.01) than the D values for this organism heat-treated immediately after inoculation. In beef systems, the D(55) values were significantly lower (P < 0.05) in the presence of a beef microflora than the D(55) values obtained in 'pure' culture under all temperature/storage combinations. However, in broth systems, there was no significant difference between the D(55) values obtained in 'pure' culture and the D(55) values obtained from systems containing beef microflora. CONCLUSIONS: Storage of Salm. Typhimurium DT104 significantly reduced the thermal resistance of the pathogen in beef and broth systems. In the presence of high numbers of a Gram-negative beef microflora, the heat sensitivity of the pathogen was further increased on beef surfaces but not in broth. SIGNIFICANCE AND IMPACT OF THE STUDY: Studies investigating the survival of Salm. Typhimurium DT104 in different food systems will help define safe food preservation processes and will aid in the elimination this pathogen from the food production environments.     

Premature Salmonella Typhimurium growth inhibition in competition with other Gram-negative organisms is redox potential regulated via RpoS induction

AIMS: To identify the role of oxidation-reduction (redox) potential in the premature growth inhibition and RpoS induction in Salmonella serotype Typhimurium in competitive growth experiments. METHODS AND RESULTS: Oxidation-reduction potential was measured throughout the growth of a minority population of Salm. Typhimurium in mixed cultures with other Gram-negative and Gram-positive organisms. A lux-based reporter was also used to evaluate RpoS activity in Salm. Typhimurium in competitor studies. In a mixed culture, the multiplication of a minority population of Salm. Typhimurium was inhibited when competing Gram-negative organisms entered the stationary phase. This was not seen when the competing flora was Gram-positive. The change in redox potential during growth in mixed cultures was closely linked to the inhibition of Salm. Typhimurium growth by Gram-negative competitors. An artificially induced drop in redox potential earlier during growth in mixed cultures with Gram-negative organisms reduced the time to RpoS induction in Salm. Typhimurium and thus inhibited its multiplication prematurely. In contrast, RpoS induction and growth inhibition were prevented under high redox potential conditions. CONCLUSIONS: This work shows that the inhibitory activity of competitive organisms can be mediated through their effect on redox potential-regulated RpoS induction. SIGNIFICANCE AND IMPACT OF THE STUDY: Redox potential is shown to be an important determinant of Salm. Typhimurium growth, an observation with practical implications both for its control and detection.     

Survival of dehydrated cells of Salmonella typhimurium LT2 at high temperatures

Cells of Salmonella typhimurium LT2 were dehydrated on hydrophobic membranes (Millipore FGLP2500) placed in a controlled atmosphere chamber held at 57% equilibrium relative humidity (ERH) and 37 degrees C. Dehydration for 48 h under the above conditions increased the heat resistance of Salm. typhimurium LT2 when measured as the surviving fraction after a heat challenge of 135 degrees C for 30 min. Results also showed that little or no death occurred during heat challenges of 1 h at temperatures of up to 100 degrees C. The survival of Salm. typhimurium LT2 was measured as the ability to form colonies on solid media tryptone soy broth plus 1.2% agar (TSBA) after 24 h at 37 degrees C. Incorporation of sodium pyruvate, at a concentration of (TSBA) after 24 h at 37 degrees C. Incorporation of sodium pyruvate, at a concentration of 0.2% into the recovery medium, did not enhance the recovery of heated Salm. typhimurium LT2. Dehydrated cells of S. typhimurium LT2 showed a triphasic death curve. Increasing the period of dehydration from 48 h to 34 d, reduced initial numbers due to die off but did not alter the shape of the subsequent survival curve.     

The relationship between concentration of a dual marker strain of Salmonella Typhimurium in bovine faeces and its probability of detection by immunomagnetic separation and culture

AIMS: To modify a strain of Salmonella serotype Typhimurium to express unique marker traits and then define how the concentration of the marker in bovine faeces affects the probability of its detection by culture preceded by immunomagnetic separation (IMS). METHODS AND RESULTS: DNA encoding for the production of green fluorescent protein (gfp) and resistance to kanamycin was inserted into the bacterial chromosome of Salm. Typhimurium. Transposon insertion was demonstrated by Southern blot hybridization. Varying amounts of one electroporant (gfpSal-1) were inoculated into suspensions of bovine faeces and attempts made to isolate gfpSal-1 using a protocol based on pre-enrichment incubation, IMS and enrichment in selective media. Isolates of gfpSal-1 were differentiated from wild strains of Salmonella using fluorescence under u.v. light and expression of kanamycin resistance. A logistic and Gompertz function each derived from the dose-response data partially explained the observations with the fit of the Gompertz function judged to be superior. The 10, 50 and 90% limits of detection from the Gompertz function were estimated to be 1.92, 2.03 and 2.27 CFU g(-1) respectively. CONCLUSIONS: Reliance on the traditional concept of 'limit of detection' could introduce unacceptable errors in the interpretation of test findings when the concentration of Salm. Typhimurium in bovine faeces (pooled or individual) is below ca 3 CFU g(-1) of faeces. SIGNIFICANCE AND IMPACT OF THE STUDY: The dose-response curve can be used to aid the design of protocols for detecting Salmonella in individual and pooled faecal specimens. The experiments demonstrate that both reporter genes in tandem are useful for studying the performance of culture-based methods for detecting pathogens in faeces.     

Survival of dehydrated cells of Salmonella typhimurium LT2 at high temperatures

Cells of Salmonella typhimurium LT2 were dehydrated on hydrophobic membranes (Millipore FGLP2500) placed in a controlled atmosphere chamber held at 57% equilibrium relative humidity (ERH) and 37°C. Dehydration for 48 h under the above conditions increased the heat resistance of Salm. typhimurium LT2 when measured as the surviving fraction after a heat challenge of 135°C for 30 min. Results also showed that little or no death occurred during heat challenges of 1 h at temperatures of up to 100°C. The survival of Salm. typhimurium LT2 was measured as the ability to form colonies on solid media tryptone soy broth plus 1.2% agar (TSBA) after 24 h at 37°C. Incorporation of sodium pyruvate, at a concentration of 0.2% into the recovery medium, did not enhance the recovery of heated Salm. typhimurium LT2. Dehydrated cells of S. typhimurium LT2 showed a triphasic death curve. Increasing the period of dehydration from 48 h to 34 d, reduced initial numbers due to die off but did not alter the shape of the subsequent survival curve. and accepted 22 June 1989     

Prevalence of bacterial faecal pathogens in separated and unseparated stored pig slurry

AIMS: To examine the prevalence and diversity of bacterial faecal pathogens in unseparated slurry, separated solids and liquid fractions from a commercial pig farm. METHODS: A total of 43 stored slurry specimens originating from a fattening house over the period February-April 2002 were analysed, consisting of unseparated (n = 14) slurry, separated solids (n = 16) and separated liquid (n = 13). Specimens were examined for the presence of five bacterial pathogens including Salmonella spp., Shigella spp., Campylobacter spp., Escherichia coli O157 and Yersinia enterocolitica. Selective enrichment and plating methods were employed for detection of Salmonella spp. and Campylobacter spp. and conventional selective plating techniques for the remaining genera. Antibiogram profiles to 12 antibiotic agents were obtained for all Salmonella isolates obtained. RESULTS: Salmonella spp. were identified in all components of the slurry specimens, whereas Campylobacter spp. was only recovered from the unseparated and separated liquid fractions. In both cases, the separated liquid fraction had the highest prevalence of pathogens and the separated solid fraction had the lowest prevalence. None of the slurry specimens examined were positive for E. coli O157:H7, Shigella spp. or Y. enterocolitica. Twenty-nine isolates of Salmonella were recovered from the slurry specimens, comprising seven serovars, of which Salmonella manhattan was the most prevalent, accounting for over half [15 of 29 (51.7%)] of all Salmonella isolates. Salmonella anatum, Salm. derby, Salm. give, Salm. heidelberg, Salm. simi and Salm. stanley serovars were also recovered. All Salmonella isolates were sensitive to ampicillin, augmentin (amoxicillin/clavulanic acid), chloramphenicol, ciprofloxacin, gentamicin, kanamycin and trimethoprim, but has variable resistance to tetracycline (100%), sulphonamides (84.6%), furazolidone (38.5%), nalidixic acid (15.4%) and streptomycin (15.4%). The majority (57.7%) of isolates displayed antibiotic resistance to at least two antibiotic agents, followed by 34.6% of isolates being resistant to three agents and the remainder (7.7%) being resistant to four antibiotics. SIGNIFICANCE AND IMPACT OF THE STUDY: This study demonstrated a marked reduction in the prevalence of Campylobacter and Salmonella in the solids component of separated pig slurry. The adoption of control processes such as aeration of slurry prior to its spread onto agricultural land and newer approaches to pathogen reduction should be investigated, to reduce the transmission of pathogens from pig slurry to the environment.     

Identification of Salmonella enteritidis outer membrane proteins expressed during attachment to human intestinal epithelial cells

AIMS: To express and identify the Salmonella enterica ser. Enteritidis outer membrane proteins that are involved in the attachment to human intestinal epithelial cells. METHODS AND RESULTS: Salmonella Enteritidis attachment proteins were expressed by infection of human intestinal epithelial cells (int-407) with Salm. Enteritidis strain SE28, followed by pulse labelling with [35S]-methionine. Outer membrane proteins were separated by TritonX-114 phase partitioning, and were detected by Salm. Enteritidis-specific polyclonal antibody. Outer membrane proteins of molecular weights 82.3, 75.6, 49.3, 35.5 and 19.3 kDa were newly synthesized. Expression of 31.2 and 16 kDa proteins was up-regulated, whereas the expression of 40.7 kDa protein was down-regulated. Polyclonal antibodies against the 82.3 and 75.6 kDa proteins significantly (P < 0.05) reduced the binding of Salm. Enteritidis to int-407 cells in vitro. CONCLUSIONS: Outer membrane proteins 82.3 and 75.6 kDa are potentially involved in the attachment of Salm. Enteritidis to the intestinal mucosa. SIGNIFICANCE AND IMPACT OF THE STUDY: Outer membrane proteins 82.3 and 75.6 kDa identified in this study could be used as potential vaccines to block or reduce Salm. Enteritidis colonization in chickens.     

Isolation of salmonellas by immunomagnetic separation

A.E.M. VERMUNT, A.A.J.M. FRANKEN AND R.R. BEUMER. 1992. Magnetisable particles, coated with anti-salmonella serum, were used to isolate Salmonella livingstone from pure cultures, mixed cultures and food samples. Beads (10⁷) were generally incubated with 10⁴ Salm. livingstone cells/ml for 60 min at room temperature. The incubation and washing medium (0.01 mol/l phosphate-buffered saline; PBS) contained 0.1% bovine serum albumin (BSA) and 0.1% Tween 20, respectively. This method gave a recovery for Salm. livingstone of 51.9±7.8%. However, other micro-organisms such as Aeromonas hydrophila interfered with this test because of non-specific reactions (recovery 50.9±12.7%). These non-specific reactions could be decreased by using 4% skim milk instead of 0.1% BSA in the incubation medium. The ratio of the recovery of Salim. livingstone relative to the recovery of Aer. hydrophila changed from 0.9 when PBS with 0.1% BSA was used, to 13.4 when PBS with 4% skim milk was used. Immunomagnetic separation of Salmonella spp. from food samples offers good prospects for concentrating salmonella cells from heterogeneous bacterial suspensions, such as enrichment broths.     

Salmonella must be viable in order to attach to the surface of prepared vegetable tissues

Aims: The aims of the current study were to explore the site of bacterial attachment to vegetable tissues and to investigate the hypothesis that Salmonella must be living in order to attach to this site(s). Methods and Results: Scanning electron micrographs of intact potato cells showed that Salm. serotype Typhimurium attached to cell-wall junctions; suggesting a high-level of site selectivity. Inactivation of Salm. Typhimurium using heat, ethanol, formalin or Kanamycin resulted in cells that could be no longer attached to these sites. Attachment of a Gfp⁺ strain of Salm. Typhimurium to cell-wall material (CWM) was examined via flow cytometric analysis. Only live Salm. Typhimurium attached to the CWM. Conclusions: Salmonella serotype Typhimurium must be metabolically active to ensure attachment to vegetable tissues. Attachment preferentially occurs at the plant cell-wall junction and the cell-wall components found here, including pectate, may provide a receptor site for bacterial attachment. Significance and Impact of the Study: Further studies into individual plant cell-wall components may yield the specific bacterial receptor site in vegetable tissues. This information could in turn lead to the development of more targeted and effective decontamination protocols that block this site of attachment.     

Induction of rpoS in Salmonella typhimurium by nutrient-poor and depleted media is slower than that achieved by a competitive microflora

The presence of a viable competitive microflora, at greater than 10(8) cfu ml-1, is known to advance the induction of RpoS-mediated gene expression in a sub-population of Salmonella typhimurium. As starvation is known to induce RpoS, one action of the competitive microflora could be to cause depletion of essential nutrients. The aim of the current experiments was to determine whether this was the case by examining RpoS induction in Salm. typhimurium in reduced nutrient media. RpoS-mediated gene expression in Salm. typhimurium was not advanced so significantly in 'conditioned' or diluted medium as it was in the presence of competitors, which indicates that nutrient depletion was not the responsible mechanism. The effect of a competitive microflora has implications for models of bacterial survival during food processing, as RpoS ultimately regulates both stress resistance and virulence.     

New biological function of bovine alpha-lactalbumin: protective effect against ethanol- and stress-induced gastric mucosal injury in rats.

Although several studies have shown that milk protein components have a wide range of biological activities, the potential role of these proteins in the gastrointestinal mucosal defense system is less well elucidated. In this study, we investigated the effect of the major proteins in cow's milk on gastric mucosal injury by using two acute ulcer models in Wistar rats. Gastric mucosal injury was induced by either intragastric 60% ethanol-HCl or water-immersion restraint stress (23 degrees C, 7 h). Each test milk protein was orally administered 30 min before the induction of gastric injury. Among the major milk proteins, alpha-lactalbumin (alpha-LA) is demonstrated to have a marked protective effect against ethanol-induced gastric injury, with the same potency as that of the typical antiulcer agent, Selbex. Whey protein isolate (WPI), which contained 25% alpha-LA, also protected against gastric injury, while casein showed no effect. Comparative studies on the protective effect of the four major components of WPI, beta-lactoglobulin, alpha-LA, bovine serum albumin and gamma-globulins (immunoglobulins), on the basis of their contents in WPI revealed that alpha-LA was responsible for the protective effect of WPI, being about 4-fold more effective than WPI itself. Alpha-LA showed dose-dependent protection against gastric injury induced by stress as well as ethanol. Pretreatment with indomethacin (10 mg/kg body weight, s.c.), which is a potent inhibitor of endogenous prostaglandin synthesis, resulted in a significant reduction in the protective effect of alpha-LA. These results indicate that alpha-LA has marked antiulcer activity as an active component of cow's milk protein, and suggest that alpha-LA intake may serve to protect against gastric mucosal injury, in part through endogenous prostaglandin synthesis.     

The effect of summer and winter seasons on the survival of Salmonella typhimurium and indicator micro-organisms during the storage of solid fraction of pig slurry

AIMS: Investigations were carried out to observe the influence of winter/spring and summer periods on the survival of Salmonella typhimurium and indicator bacteria (psychrophilic, mesophilic, coliform and faecal coliform bacteria and faecal streptococci) in the solid fraction of pig slurry from agricultural wastewater treatment plant. METHODS AND RESULTS: Leather squares and PVC bottles with openings served as test carriers. They were inoculated with broth culture of Salm. typhimurium and introduced directly into the solid fraction. During the experiment, quantitative and qualitative examinations were carried out to determine the presence of Salm. typhimurium and observe the dynamics of indicator bacteria in the solid fraction. CONCLUSIONS: Salmonella typhimurium survived for 26 d in summer and for 85 d in winter/spring. The T90 values of indicator bacteria in summer ranged from 35.44 d (coliform bacteria) up to 100.29 d (mesophilic bacteria). The winter T90 values of indicator bacteria ranged from 74.58 d (faecal coliform bacteria) to 233.07 d (coliform bacteria). SIGNIFICANCE AND IMPACT OF THE STUDY: The present study demonstrated that it is necessary to pay increased attention to the manipulation of slurry solid fraction.     

Heat resistance of Paenibacillus polymyxa in relation to pH and acidulants

The efficacy of different organic acids in decreasing the heat resistance of Paenibacillus polymyxa spores was assessed. The relationship between concentration of the undissociated form of different organic acids and decrease in heat resistance was also investigated. The heat resistance of P. polymyxa spores was tested in distilled water at 85, 90 and 95 degrees C, at pH4 and in the presence of 50, 100 and 200 mmol l(-1) of the undissociated form of lactic, citric or acetic acid and sodium citrate or acetate. The undissociated form of organic acids was responsible for increasing the heat sensitivity of spores. The most effective acid was lactic acid. The D values of the spores decreased rapidly (between 74 and 43%) in the presence of 50 mmol l(-1) of the undissociated form of organic acid, and increasing concentrations of these forms affected the heat resistance of spores less than proportionally. The heat resistance of the spores in milk was approximately threefold lower than in distilled water. This work has shown that the undissociated fraction of organic acids increases, albeit non-linearly, the sensitivity of spores to heat, even in complex substrates such as milk. By knowing the amount of organic acids added to a given substrate, their dissociation constants and the final pH, it could be possible to estimate the concentration of undissociated forms and the corresponding increase in lethality of heat treatments. This would help the food industry to maximize the lethality achieved by heat processes and/or safely reduce the heat treatments already in use.