Lipoamide dehyrogenase immobilized on porous glass.

Lipoamide dehydrogenase (NADH:lipoamide oxidoreductase, EC 1.6.4.3) isolate from pig heart and Escherichia coli was covalently coupled by both diazonium and amide bonds to controlled pore glass beads (96% silica). When the enzyme was immobilized in the presence of NAD+, the enzyme no longer exhibited its normal requirement for NAD+ for full activity. If the immobilized enzyme was then treated with NADase, the requirement for NAD+ was restored. Enzyme immobilized in the absence of NAD+ exhibited normal NAD+ dependence both prior to an after NADase treatment. These results are discussed in terms of co-immobilization of NAD+ at or near the allosteric site of the enzyme.     

聚乙烯醇-明胶复合膜固定化重组大肠杆菌NAD激酶的研究

为提高烟酰胺腺嘌呤二核苷酸(NAD)激酶的稳定性,采用复合膜对NAD激酶进行固定化研究。选用聚乙烯醇(PVA)、聚乳酸(PLA)、海藻酸钠(SA)和明胶(GEL)膜材料固定化NAD激酶。通过单因素实验确定最佳固定化条件为:PVA∶GEL为4∶1,加酶量为0.6 mL,固定化时间为6h,固定化温度为35℃,此时酶活力回收率达到最高值84%。固定化酶酶学性质分析结果表明,与游离酶进行比较,固定化后NAD激酶的最适温度由50℃提高至55℃,最适pH由8.0降至7.0,NAD激酶的热稳定性和pH稳定性均得到显著提高,但固定化酶的亲和力降低。固定化NAD激酶重复利用6次后,酶活性依然可维持初始酶活性的75%以上,表明聚乙烯醇-明胶复合膜固定化酶具有良好的操作稳定性。     

An Affinity Chromatographic Reactor for Highly Efficient Turnover of Dissociable Cofactors

A conjugated enzyme system of alcool dehydrogenase and lactate dehydrogenase was immobilized in an ultrafiltration hollow fiber tube, which was inserted in a fine nylon tube to form a hollow-fiber-capillary reactor. To this reactor, the substrates, pyruvate and ethanol, were supplied continuously. The necessary cofactor, NAD, was supplied as a pulse for a short time. The retention time of NAD in the reactor, estimated from the response curve of lactate produced, was much longer than those of the other substrates and products because of the strong adsorption of NAD to the immobilized enzymes through affinity. Therefore, the reactor could produce lactate from pyruvate for a long time without any more NAD. As a typical case, when the enzyme concentration is sufficiently high, the estimated retention time of NAD was 50 times as long as those of other materials so that the NAD turnover obtained was 412,000. The effects of NAD pulse concentration and the immobilized enzyme concentration on the retention time of NAD and NAD turnover were investigated experimentally and theoretically.     

Immobilized flounder muscle glyceraldehyde 3-phosphate dehydrogenase

Summary Partially purified flounder muscle (Pseudopleuronectus americanus) glyceraldehyde 3-phosphate dehydrogenase was immobilized on cyanogen bromide-activated Sepharose. The catalytic properties of the immobilized preparation were studied to determine if immobilization alters the kinetic properties of the native holoenzyme. The results indicate that the pH activity profile of immobilized glyceraldehyde 3-phosphate dehydrogenase did not differ from that of the native enzyme. The Michaelis constants (Km) for NAD and glyceraldehyde 3-phosphate were somewhat altered. The enzyme stability toward various inactivation treatments in the presence and absence of NAD was characterized and compared to that of he native enzyme. When either form of the enzyme was incubated with urea at concentrations greater than 2m, inactivation occurred very rapidly. Incubation in 0.1% trypsin for 60 minutes decreased the activity of immobilized glyceraldehyde 3-phosphate dehydrogenase by 45% and of the native soluble enzyme by 70%. The immobilized enzyme also exhibited considerably more stability than the native soluble enzyme when exposed to a temperature of 50° or to 20 mm ATP. In all cases NAD either greatly reduced the rate of inactivation or completely protected the enzyme from inactivation.     

NAD recycling in the collagen membrane.

NAD recycling in the collagen membrane was investigated as follows: (1) Alcohol dehydrogenase and lactate dehydrogenase were co-immobilized in the collagen membrane and the rate of lactate production by immobilized enzymes was compared with that of free enzymes by using free NAD. An increased rate was observed in the case of immobilized enzyme. (2) The soluble high molecular weight derivatives of NAD (dextran-NAD) were immobilized in the collagen membrane with the two dehydrogenases and recycling of dextran-NAD in the membrane was examined. Lactate was produced by the membrane without adding free NAD. The interaction between the high molecular weight NAD derivatives and enzymes are also discussed.     

A chemiluminescence automatic analyser for the measurement of biological compounds

A compact automated analyser which could analyse constituents in biological fluids with a small sample volume and in a short time has been developed. The instrument was composed of a flow injection analysis system equipped with chemiluminometric detection and an immobilized enzyme column reactor used in combination. Chemiluminescence has high sensitivity, and its reaction proceeds very quickly. Furthermore, an immobilized enzyme column reactor can produce a sufficient amount of hydrogen peroxide from compounds in serum in a short time. When enzymes are used as reagents for the analysis of substances in blood or blood serum, the final signals emitted by different enzyme reactions are usually not only hydrogen peroxide but also ammonia, NAD(P)H and so on. However, the practical chemiluminescence method for ammonia and NAD(P)H has not been established. We have discovered a new practical method for ammonia and NAD(P)H using an enzyme column reactor consisting of both immobilized L -glutamate dehydrogenase and L -glutamate oxidase. The determinations of glucose and uric acid in serum by chemiluminometry after production of hydrogen peroxide by the respective oxidases are presented. A newly chemiluminometric determination of ammonia, NAD(P)H and its applications to other enzymatic analyses that give ammonia and NAD(P)H as a final signal are also described.     

Dynamic affinity between dissociable coenzyme and immobilized enzyme in an affinity chromatographic reactor with single enzyme

The affinity chromatographic reactor (ACR) is a bioreactor which utilizes the dynamic interaction or the dynamic affinity between a free coenzyme and immobilized enzymes for the highly efficient regeneration of dissociable coenzymes. Dynamic affinity between free NAD and immobilized alcohol dehydrogenase (ADH) in ACR was investigated by three different methods. ADH catalyzed both oxidation and reduction of NAD, consuming propionaldehyde and ethanol. The theoretical model under consideration elucidated a criterion for the expression of the dynamic affinity as a relationship among the affinity constants and the concentrations of a coenzyme and immobilized enzyme. This criterion was confirmed experimentally by the measurements of the retention time of NAD and the half-life period of the reactor activity after one-shot pulse injection of NAD to ACR. In the stability measurement of the immobilized enzyme, it became clear that ADH was more stable at the higher concentration in immobilization. Although the present case of coenzyme cycling by a single enzyme is very special, with limited chance for the direct application, the results obtained here provide a theoretical basis for ACR with multienzymes-which is of more general use.     

Comparative study of immobilized and soluble NADH:FMN-oxidoreductase-luciferase coupled enzyme system

The properties of a coupled enzyme system (NAD(P)H:FMN-oxidoreductase and luciferase) from luminous bacteria were studied. The enzymes and their substrates were immobilized in polymer gels of different types: starch (polysaccharide) and gelatin (polypeptide). Maximum activity yield (100%) was achieved with the enzymes immobilized in starch gel. An increase in K _{m app} was observed in both immobilized systems as compared with the soluble coupled enzyme system. Immobilization in starch and gelatin gels increased the resistance of the NAD(P)H:FMN-oxidoreductase and luciferase coupled enzyme system to the effects of external physical and chemical factors. The optimum pH range expanded both to the acidic and alkaline regions. The resistance to concentrated salt solutions and high temperature also increased. The coupled enzyme system immobilized in starch gel (with activation energy 30 kJ/mol) was characterized by the best thermostability. The immobilized coupled enzyme system can be used to produce a stable and highly active reagent for bioluminescent analysis.     

Synthesis of a highly substituted N(6)-linked immobilized NAD(+) derivative using a rapid solid-phase modular approach: suitability for use with the kinetic locking-on tactic for bioaffinity purification of NAD(+)-dependent dehydrogenases

This study is concerned with further development of the kinetic locking-on strategy for bioaffinity purification of NAD(+)-dependent dehydrogenases. Specifically, the synthesis of highly substituted N(6)-linked immobilized NAD(+) derivatives is described using a rapid solid-phase modular approach. Other modifications of the N(6)-linked immobilized NAD(+) derivative include substitution of the hydrophobic diaminohexane spacer arm with polar spacer arms (9 and 19.5 A) in an attempt to minimize nonbiospecific interactions. Analysis of the N(6)-linked NAD(+) derivatives confirm (i) retention of cofactor activity upon immobilization (up to 97%); (ii) high total substitution levels and high percentage accessibility levels when compared to S(6)-linked immobilized NAD(+) derivatives (also synthesized with polar spacer arms); (iii) short production times when compared to the preassembly approach to synthesis. Model locking-on bioaffinity chromatographic studies were carried out with bovine heart l-lactate dehydrogenase (l-LDH, EC 1.1.1.27), bakers yeast alcohol dehydrogenase (YADH, EC 1.1.1.1) and Sporosarcinia sp. l-phenylalanine dehydrogenase (l-PheDH, EC 1.4.1.20), using oxalate, hydroxylamine, and d-phenylalanine, respectively, as locking-on ligands. Surprisingly, two of these test NAD(+)-dependent dehydrogenases (lactate and alcohol dehydrogenase) were found to have a greater affinity for the more lowly substituted S(6)-linked immobilized cofactor derivatives than for the new N(6)-linked derivatives. In contrast, the NAD(+)-dependent phenylalanine dehydrogenase showed no affinity for the S(6)-linked immobilized NAD(+) derivative, but was locked-on strongly to the N(6)-linked immobilized derivative. That this locking-on is biospecific is confirmed by the observation that the enzyme failed to lock-on to an analogous N(6)-linked immobilized NADP(+) derivative in the presence of d-phenylalanine. This differential locking-on of NAD(+)-dependent dehydrogenases to N(6)-linked and S(6)-linked immobilized NAD(+) derivatives cannot be explained in terms of final accessible substitutions levels, but suggests fundamental differences in affinity of the three test enzymes for NAD(+) immobilized via N(6)-linkage as compared to thiol-linkage.     

Continuous production of NADP by immobilized Achromobacter aceris cells.

Several microorganisms having higher nicotinamide adenine dinucleotide kinase (NAD kinase, EC 2.7.1.23) activity were immobilized into polyacrylamide gel lattices. The enzyme activity field by immobilization was highest in Achromobacter aceris AKU 0120. By the incubation of the immobilized A. aceris cells at pH 4.0, the NAD kinase activity increased and the adenosine triphosphate (ATP)-degradation activity disappeared completely. Enzymatic properties of the immobilized A. aceris cells were investigated and compared with those of intact cells. The optimal pH and the optimal temperature of immobilized cells were the same as those of intact cells. Immobilized cell NAD kinase was more stable than that of intact cells. The operational half-life of immobilized cells was 20 days when the substrate solution was passed through a column packed with immobilized cells at a flow rate which gives a space velocity (SV) of 0.1 hr-1 at 37 degrees C. On the other hand, the half-life of the intact cells was only 6 hr.     

Immobilization of lactate dehydrogenase on polyacrylamide beads

Pig muscle lactate dehydrogenase (L-lactate:NAD oxidoreductase, EC 1.1.1.27) was covalently immobilized on polyacrylamide beads containing carboxylic functional groups activated by water-soluble carbodiimide. The effects of immobilization on the catalytic properties and stability of the lactate dehydrogenase were studied. There was no shift in the pH optimum of the immobilized enzyme compared to that of the soluble one. The apparent optimum temperature of the soluble enzyme was 65 degrees C, while that of the immobilized enzyme was between 50 and 65 degrees C. The apparent Km values of the immobilized enzyme with pyruvate and NADH substrates were higher than those of the soluble enzyme. As a result of immobilization, enhanced stabilities were found against heat treatment, changes in pH, and urea denaturation.     

Production of NADP by immobilized cells with NAD kinase

By the radiation-copolymerization method with polyethylene glycoldimethacrylate (PGD) as a main polymerizable reagent, microbial cells of Brevibacterium ammoniagenes were immobilized with high specific activity of NAD kinase and high mechanical strength. The reagents used for the immobilization such as PGD, polyvinyl alcohol (PVA), and N,N'-methylenebisacrylamide (Bis) did not inversely affect the enzyme activity. Freezing and irradiation treatment of the cell-reagent solution did not inactivate the enzyme either, but longer freezing time or a lower irradiation dose (less than 400 krad) resulted in the unsatisfactory mechanical strength of the immobilized cells. Almost all of NAD and ATP consumed were converted into NADP within three hours reaction time. The drum reactor was found to be ideal for the reaction of immobilized cells, since it gave little mechanical stress to the immobilized cells for the effective mixing of the cells and the substrates. The immobilized cells were subjected to three hours reaction repeatedly for 30 times without any activity loss.     

Kinetics of yeast alcohol dehydrogenase and its coenzyme coimmobilized in a tubular flow reactor

Yeast alcohol dehydrogenase and nicotinamide adenine dinucleotide (NAD) were coimmobilized, with covalent attachment, to the interior surface of a nylon tube. The NAD was attahed at the N(6) group of the adenine moiety; an NAD derivative was prepared and attached to free carboxyl groups at a partially hydrolyzed nylon surface. The enzyme was attached, through glutaraldehyde residues, to free amino groups on the surface. Kinetic studies were carried out in which the reduced NAD was recycled by means of phenazine ethosulfate and 2,6-dichlorophenol indophenol. The reaction was studied over a range of flow rates and ethanol concentrations. The variation of rate with flow rate suggested that there was little diffusion control with respect to ethanol and that there was no observable inhibition by the reaction products. These conclusions were confirmed by evidence based on dimensionless parameters for the reaction and by direct inhibition experiments. The apparent Michaelis constant was lower than when only the enzyme was immobilized, suggesting that the immobilized enzyme-coenzyme system is of high efficiency. Overall rates of reaction were lower than when there was saturation with NAD. The tube showed no measurable loss of catalytic activity over a period of one month.     

D-glyceraldehyde-3-phosphate dehydrogenase subunit cooperativity studied using immobilized enzyme forms

Tetrameric D-glyceraldehyde-3-phosphate dehydrogenase (EC 1.2.1.12) isolated from rabbit skeletal muscle was covalently bound to CNBr-activated Sepharose 4B via a single subunit. Catalytically active immobilized dimer and monomeric forms of the enzyme were prepared after urea-induced dissociation of the tetramer. A study of the coenzyme-binding properties of matrix-bound tetrameric, dimeric and monomeric species has shown that: (1) an immobilized tetramer binds NAD+ with negative cooperativity, the dissociation constants being 0.085 microM for the first two coenzyme molecules and 1.3 microM for the third and the fourth one; (2) coenzyme binding to the dimeric enzyme form also displays negative cooperativity with Kd values of 0.032 microM and 1.1 microM for the first and second sites, respectively; (3) the binding of NAD+ to a monomer can occur with a dissociation constant of 1.6 microM which is close to the Kd value for low-affinity coenzyme binding sites of the tetrameric or dimeric enzyme forms. In the presence of NAD+ an immobilized monomer acquires a stability which is not inferior to that of a holotetramer. The catalytic properties of monomeric and tetrameric enzyme forms were compared and found to be different under certain conditions. Thus, the monomers of rabbit muscle D-glyceraldehyde-3-phosphate dehydrogenase displayed a hyperbolic kinetic saturation curve for NAD+, whereas the tetramers exhibited an intermediary plateau region corresponding to half-saturating concentrations of NAD+. At coenzyme concentrations below half-saturating a monomer is more active than a tetramer. This difference disappears at saturating concentrations of NAD+. Immobilized monomeric and tetrameric forms of D-glyceraldehyde-3-phosphate dehydrogenase from baker's yeast were also used to investigate subunit interactions in catalysis. The rate constant of inactivation due to modification of essential arginine residues in the holoenzyme decreased in the presence of glyceraldehyde 3-phosphate, probably as a result of conformational changes accompanying catalysis. This effect was similar for monomeric and tetrameric enzyme forms at saturating substrate concentrations, but different for the two enzyme species under conditions in which about one-half of the active centers remained unsaturated. Taken together, the results indicate that association of D-glyceraldehyde-3-phosphate dehydrogenase monomers into a tetramer imposes some constraints on the functioning of the active centers.(ABSTRACT TRUNCATED AT 400 WORDS)     

Fundamental differences in bioaffinity of amino acid dehydrogenases for N6- and S6-linked immobilized cofactors using kinetic-based enzyme-capture strategies

Five different immobilized NAD+ derivatives were employed to compare the behavior of four amino acid dehydrogenases chromatographed using kinetic-based enzyme capture strategies (KBECS): S6-, N6-, N1-, 8'-azo-, and pyrophosphate-linked immobilized NAD+. The amino acid dehydrogenases were NAD+-dependent phenylalanine (EC 1.4.1.20), alanine (EC 1.4.1.1), and leucine (EC 1.4.1.9) dehydrogenases from various microbial species and NAD(P)+-dependent glutamate dehydrogenase from bovine liver (GDH; EC 1.4.1.3). KBECS for bovine heart L-lactate dehydrogenase (EC 1.1.1.27) and yeast alcohol dehydrogenase (EC 1.1.1.1) were also applied to assist in a preliminary assessment of the immobilized cofactor derivatives. Results confirm that the majority of the enzymes studied retained affinity for NAD+ immobilized through an N6 linkage, as opposed to an N1 linkage, replacement of the nitrogen with sulfur to produce an S6 linkage, or attachment of the cofactor through the C8 position or the pyrophosphate group of the cofactor. The one exception to this was the dual-cofactor-specific GDH from bovine liver, which showed no affinity for N6-linked NAD+ but was biospecifically adsorbed to S6-linked NAD+ derivatives in the presence of its soluble KBEC ligand. The molecular basis for this is discussed together with the implications for future development and application of KBECS.     

Affinity and stability modifications of immobilized alcohol dehydrogenase through multipoint copolymerization

Yeast alcohol dehydrogenase (alcohol:NAD+ oxidoreductase, EC 1.1.1.1), a potentially useful enzyme for cofactor regeneration processes, was covalently immobilized in a multipoint fashion by activation with acryloyl chloride and subsequent copolymerization in a polyacrylamide gel. Several properties such as the activity and stability were systematically studied for the free enzyme, the acryloate-enzyme and the immobilized enzyme. The activation energy was significantly lowered upon immobilization. The thermal stability of the immobilized enzyme was, however, greatly increased. But its maximum activity was observed at a lower temperature. These results suggest an important effect of the diffusional restrictions and of the mode of activation and immobilization on the activity and the stability of the enzyme.     

Regeneration of NADH in a bioreactor using yeast cells immobilized in alginate fiber: I. Method and effect of reactor variables

Saccharomyces cerevisiae cells immobilized in a calcium alginate fiber reactor were used as a source of alcohol dehydrogenase for the NAD(+)-to-NADH reaction. The reaction was catalyzed by enzyme in cells on the surface of the fiber. Internal diffusional effects were present. The enzyme cell concentration was optimized by harvesting cells finally grown under anaerobic conditions. The results were expressed as an apparent reaction rate constant that was independent of NAD(+) and excess ethanol concentration, was slightly affected by flow rate above a minimum value, and increased with immobilized cell concentration in the fiber. The reaction was complete after 6 to 7 h under optimal conditions of 36 degrees C and 9.5 pH. The latter was 0.5 pH units above the free enzyme optimum, indicating that microenvironmental effects were in evidence. (c) 1993 John Wiley & Sons, Inc.     

Specific immobilization of in vivo biotinylated bacterial luciferase and FMN:NAD(P)H oxidoreductase.

Bacterial bioluminescence, catalyzed by FMN:NAD(P)H oxidoreductase and luciferase, has been used as an analytical tool for quantitating the substrates of NAD(P)H-dependent enzymes. The development of inexpensive and sensitive biosensors based on bacterial bioluminescence would benefit from a method to immobilize the oxidoreductase and luciferase with high specific activity. Toward this end, oxidoreductase and luciferase were fused with a segment of biotin carboxy carrier protein and produced in Escherichia coli. The in vivo biotinylated luciferase and oxidoreductase were immobilized on avidin-conjugated agarose beads with little loss of activity. Coimmobilized enzymes had eight times higher bioluminescence activity than the free enzymes at low enzyme concentration and high NADH concentration. In addition, the immobilized enzymes were more stable than the free enzymes. This immobilization method is also useful to control enzyme orientation, which could increase the efficiency of sequentially operating enzymes like the oxidoreductase-luciferase system.     

Immobilized active monomers of D-glyceraldehyde-3-phosphate dehydrogenase from rabbit skeletal muscles and their coenzyme-binding properties

Experimental conditions favouring the dissociation of tetrameric rabbit muscle D-glyceraldehyde-3-phosphate dehydrogenase into active monomers were elaborated. The urea-induced dissociation of the tetramer was shown to be a stepwise process (in 2 M urea only dimers are formed; an increase in urea concentration up to 3 M causes the splitting of the dimers into monomers). The specific activity of immobilized monomers in the glyceraldehyde-3-phosphate oxidation reaction does not differ from that of the parent immobilized tetrameric form. The tetrameric enzyme molecule binds the coenzyme with a negative cooperativity (the first two NAD+ molecules bind with KD below 0.1 microM; for the third and fourth molecules the dissociation constant was determined to be equal to 5.5 +/- 1.5 microM (50 mM medinal buffer, 10 mM sodium phosphate, pH 8.2). The cooperativity of NAD+ binding is preserved in the immobilized preparation of tetrameric dehydrogenase. The immobilized monomers bind NAD+ with KD of 1.6 +/- 1.0 microM. The experimental results are consistent with the hypothesis according to which the association of catalytically active subunits into a tetramer changes their coenzyme-binding properties in such a way that the first two NAD+ molecules bind more firmly to a tetramer than to a monomer, whereas the third and the fourth NAD+ molecules bind less firmly.     

Electrochemical evaluation of lactate dehydrogenase immobilized in polyacrylamide gels

Lactate dehydrogenase (EC 1.1.1.27) has been immobilized in polyacrylamide gels over a platinum grid matrix. The immobilized enzyme is used to oxidize L-lactate in the presence of nicotinamide adenine dinucleotide (NAD+) and ferricyanide. The NADH produced is then chemically oxidized back to NAD+ by ferricyanide. The coupled reduction of ferricyanide ions to ferrocyanide ions results in a measurable electrochemical potential. This measurable zero-current potential is found to be Nernstian in nature and directly proportional to the logarithm values of L-lactate concentration over the range of 2 X 10(-5) to 5 X 10(-2)M. The results indicate that immobilized lactate dehydrogenase can be incorporated into a system to detect L-lactate acid in aqueous solutions.