Selective extraction of succinic acid from binary mixture of succinic acid and acetic acid

In production of succinic acid by fermentation, succinic acid and acetic acid are co-produced. To purify the succinic acid from binary-acid mixture of succinic acid and acetic acid, the tertiary amine-based extraction was used. In 1-octanol, the selectivity for succinic acid was proportional to the chain length of tertiary amine. But, the distribution of acids into organic phase was low in n-heptane. These results are due to the different degree of intramolecular hydrogen bonding of succinic acid and hydrophobicity of each acid.     

Enzymatic preparation of radiolabeled succinic semialdehyde

[U-14C]Succinic semialdehyde was prepared with yields of 30-40% by oxidation of purified [U-14C]4-aminobutyric acid with commercially available bovine plasma monoamine oxidase. [U-14C]Succinic semialdehyde was purified by cation-exchange chromatography and quantified as the oxime and methoxime derivatives using liquid partition chromatography on silicic acid. The availability of [U-14C]succinic semialdehyde permits the reliable assay of succinic semialdehyde dehydrogenase in crude cell extracts of lymphocytes isolated from human blood, cultured human lymphoblasts, and other tissues where 4-aminobutyric acid metabolism is known to occur.     

Anxiolytic-like effect of succinic acid in mice

The putative anxiolytic activity of succinic acid was examined in male mice by using a number of experimental paradigms of anxiety and compared with that of the known anxiolytic compound diazepam. Use of the elevated plus-maze test revealed that diazepam (1.0, 2.0 and 4.0 mg/kg, PO) or succinic acid (3.0 or 6.0 mg/kg, PO) increased the percentage of entries into open arms and of time spent on open arms. In novel food consumption test, succinic acid (3.0, 6.0, and 12.0 mg/kg, IP) caused significant increases in food intake during 5 min when compared with the vehicle. In the stress-induced hyperthermia test, 40 min after drug administration rectal temperature was measured, succinic acid at dose of 1.5 mg/kg, inhibited stress-induced hyperthermia. Thus, these findings indicated that, in contrast with diazepam, succinic acid exhibits anxiolytic-like effect.     

Systems approaches to succinic acid-producing microorganisms

Succinic acid is a cellular metabolite belonging to the C4-dicarboxylic acid family, and the fermentative production of succinic acid via the use of recombinant microorganisms has recently become the focus of an increasing amount of attention. Considering the difficulty inherent to the direct application of natural succinic acid producers to the industrial process, a variety of systems biology studies have been conducted regarding the development of enhanced succinic acid production systems. This review shows how the metabolic processes of microorganisms, includingEscherichia coli andMannheimia succiniciproducens, have been optimized in order to achieve enhanced succinic acid production. First, their metabolic networks were constructed on the basis of complete genome sequences, after which their metabolic characteristics were estimated viain silico computer modeling. Metabolic engineering strategies were designed in accordance with the results ofin silico modeling and metabolically engineered versions of bothE. coli andM. succiniciproducens have been constructed. The succinic acid productivity and yield obtained using metabolically engineered bacteria was significantly higher than that obtained using wild-type bacteria.     

微生物发酵生产丁二酸研究进展

丁二酸是微生物三羧酸循环中重要的代谢中间产物,广泛用于生物高分子、食品与医药等行业,市场潜在需求量巨大。文中从3个方面归纳了国内外生物基丁二酸研究进展：能够过量积累丁二酸的微生物的发现和筛选,产丁二酸工程菌构建中所采用的基因工程策略及代谢工程技术,丁二酸发酵过程控制与优化。最后,讨论了微生物法生产丁二酸今后的研究方向。     

Downstream processing of biotechnological produced succinic acid

Succinic acid is a promising chemical which has a wide range of applications and can be biologically produced. The separation of succinic acid from fermentation broth makes more than 50?% of the total costs in their microbial production. This review summarizes the present state of methods studied for the recovery and purification of biologically produced succinate. Previous studies on the separation of succinic acid primarily include direct crystallization, precipitation, membrane separation, extraction, chromatography, and in situ separation. No single method has proved to be simple and efficient, and improvements are especially needed with regard to yield, purity, and energy consumption. It is argued that separation technologies coupled with upstream technology, in situ product removal, and biorefining strategy deserve more attentions in the future.     

Recovery of succinic acid from fermentation broth

Succinic acid is of high interest as bio-feedstock for the chemical industry. It is a precursor for a variety of many other chemicals, e.g. 1,4-butandiol, tetrahydrofuran, biodegradable polymers and fumaric acid. Besides optimized production strains and fermentation processes it is indispensable to develop cost-saving and energy-effective downstream processes to compete with the current petrochemical production process. Various methods such as precipitation, sorption and ion exchange, electrodialysis, and liquid–liquid extraction have been investigated for the recovery of succinic acid from fermentation broth and are reviewed critically here.     

Rapid screening procedures for identification of succinic acid producers

Succinic acid, an intermediate of tricarboxylic acid cycle, is produced and accumulated by anaerobic microorganisms. The long-standing interest in the production of this organic acid is because it is a key compound in producing more than 30 commercially important products. The detection of succinic acid is generally carried out by gas chromatography (GC), enzymatic assays, ion-exclusion chromatography (IEC) or by high performance liquid chromatography (HPLC). However, these methods are time consuming, require sophisticated instrumentation and are expensive. In the present investigation we are reporting two rapid, cost effective screening methods for the detection of this important organic acid. These methods can be utilized to screen a large number of microbes producing succinic acid in a very short span of time.     

The role of succinic acid in the biosynthesis of levorin

The influence of succinic acid as a component of media for biosynthesis of levorin, a polyenic antibiotic was studied. It was shown that with the use of the soybean-corn medium supplemented with succinic acid (0.05-0.4 per cent) the antibiotic content in the fermentation broth was higher than that in the control. The highest stimulating effect (135 per cent) was observed with addition of 0.1 per cent of succinic acid. For providing optimal antibiotic production in the synthetic medium supplemented with succinic acid (0.4 per cent) addition of acetic acid (0.05 per cent) was required. Studies with the soybean-corn medium with and without succinic acid revealed differences in the level of p-aminoacetophenone, an aromatic fragment of the levorin molecule. Under the conditions of the medium with succinic acid the content of p-aminoacetophenone in the mycelium was higher by 10 to 18 per cent as compared to that in the control and depended on the fermentation period. The role of succinic acid in biosynthesis of levorin is discussed.     

Role of succinic acid in chemical evolution

Succinic acid is converted into other carboxylic acids by ionizing radiation. The results obtained have been correlated with the ready formation of this compound in prebiotic experiments. Its role in biological systems may be related to its prebiotic occurrence.     

Metabolism of the anaerobic formation of succinic acid bySaccharomyces cerevisiae

1. Succinic acid is formed in amounts of 0.2–1.7 g/l by fermenting yeasts of the genusSaccharomyces during the exponential growth phase. No differences were observed between the various species, respiratory deficient mutants and wild type strains.
2. At low glucose concentrations the formation of succinic acid depended on the amount of sugar fermented. However, the nitrogen source was found to be of greater importance than the carbon source.
3. Of all nitrogen sources, glutamate yielded the highest amounts of succinic acid. Glutamate led to an oxidative and aspartate to a reductive formation of succinic acid.
4. A reductive formation of succinic acid by the citric acid cycle enzymes was observed with malate. This was partially inhibited by malonate. No evidence was obtained that the glyoxylate cycle is involved in succinic acid formation by yeasts.
5. Anaerobically grown cells ofSaccharomyces cerevisiae contained α-ketoglutarate dehydrogenase. Its activity was found in the 175000 x g sediment after fractionated centrifugation. The specific activity increased 6-fold after growth on glutamate as compared with cells grown on ammonium sulfate.
6. The specific activities of malate dehydrogenase, fumarase, succinate dehydrogenase, succinylcoenzymeA synthetase, α-ketoglutarate dehydrogenase and glutamate dehydrogenase (nicotinamide adenine dinucleotide dependent) were determined in yeast cells grown on glutamate or ammonium sulfate. Similar results were obtained with a wild type strain and a respiratory deficient mutant. The latter did not contain succinate dehydrogenase.
7. In fermenting yeasts succinic acid is mainly formed from glutamate by oxidation.

     

Maintaining high anaerobic succinic acid productivity by product removal

During dual-phase fermentations using Escherichia coli engineered for succinic acid production, the productivity and viable cell concentration decrease as the concentration of succinic acid increases. The effects of succinic acid on the fermentation kinetics, yield, and cell viability were investigated by resuspending cells in fresh media after selected fermentation times. The cellular succinic acid productivity could be restored, but cell viability continuously decreased throughout the fermentations by up to 80% and subsequently the volumetric productivity was reduced. Omitting complex nutrients in the resuspension media had no significant effect on cellular succinate productivity and yield, although the viable cell concentration and thus the volumetric productivity was reduced by approximately 20%. By resuspending the cells, the amount of succinate produced during a 100-h fermentation was increased by more than 60%. The results demonstrate that by product removal succinic acid productivity can be maintained at high levels for extended periods of time.     

Feed-control development for succinic acid production with Anaerobiospirillum succiniciproducens

The aim of this work was the development of a feed-control for a succinic acid production fed-batch process. The performed batch trials indicated a correlation between succinic acid production and base consumption pH control. Based on the metabolism of Anaerobiospirillum succiniciproducens, a theoretical correlation between base consumption and glucose feed was established and proved in cultivation trials. With the established fed-batch process, the succinic acid yield could be increased to 0.875 (g/g glucose) in comparison to batch processes (0.60) with similar glucose concentrations. Additionally, the results indicate that the osmolarity of the medium has a significant influence on succinic acid production.     

Genome-based metabolic engineering of Mannheimia succiniciproducens for succinic acid production

Succinic acid is a four-carbon dicarboxylic acid produced as one of the fermentation products of anaerobic metabolism. Based on the complete genome sequence of a capnophilic succinic acid-producing rumen bacterium, Mannheimia succiniciproducens, gene knockout studies were carried out to understand its anaerobic fermentative metabolism and consequently to develop a metabolically engineered strain capable of producing succinic acid without by-product formation. Among three different CO2-fixing metabolic reactions catalyzed by phosphoenolpyruvate (PEP) carboxykinase, PEP carboxylase, and malic enzyme, PEP carboxykinase was the most important for the anaerobic growth of M. succiniciproducens and succinic acid production. Oxaloacetate formed by carboxylation of PEP was found to be converted to succinic acid by three sequential reactions catalyzed by malate dehydrogenase, fumarase, and fumarate reductase. Major metabolic pathways leading to by-product formation were successfully removed by disrupting the ldhA, pflB, pta, and ackA genes. This metabolically engineered LPK7 strain was able to produce 13.4 g/liter of succinic acid from 20 g/liter glucose with little or no formation of acetic, formic, and lactic acids, resulting in a succinic acid yield of 0.97 mol succinic acid per mol glucose. Fed-batch culture of M. succiniciproducens LPK7 with intermittent glucose feeding allowed the production of 52.4 g/liter of succinic acid, with a succinic acid yield of 1.16 mol succinic acid per mol glucose and a succinic acid productivity of 1.8 g/liter/h, which should be useful for industrial production of succinic acid.     

Effect of succinic acid on 2,3-butanediol production by Klebsiella oxytoca

Summary The effect of succinic acid on the growth of Klebsiella oxytoca and its production of 2,3-butanediol was studied. Increasing succinic acid from 0 g/L to 30 g/L increased the final butanediol concentration. The maximum butanediol productivity occurred at an initial succinic acid concentration of approximately 10 g/L.     

Salting-out extraction and crystallization of succinic acid from fermentation broths

In this study, salting-out extraction (SOE) and crystallization were combined to recover succinic acid from fermentation broths. Of the different SOE systems investigated, the system consisting of organic solvents and acidic salts appeared to be more favorable. A system using acetone and ammonium sulfate was investigated to determine the effect of phase composition and pH. The highest partition coefficient (8.64) and yield of succinic acid (90.05%) were obtained by a system composed of 30% (w/w) acetone and 20% (w/w) ammonium sulfate at a pH of 3.0. Additionally, 99.03% of cells, 90.82% of soluble proteins, and 94.89% of glucose could be simultaneously removed from the fermentation broths. Interestingly, nearly 40% of the pigment was removed using the single-step salting-out extraction process. The analysis of the effect of pH on salting-out extraction indicates that a pH lower than the pK of succinic acid is beneficial for the recovery of succinic acid in an SOE system. Crystallization was performed for the purification of succinic acid at 4 °C and pH 2.0. By combining salting-out extraction with crystallization, an identical total yield (65%) and a higher purity (97%) of succinic acid were obtained using a synthetic fermentation broth compared with the actual fermentation broth (65% and 91%, respectively).     

琥珀酸放线杆菌发酵培养基的优化

对琥珀酸放线杆菌(Actinobacillus succinogenes)CGMCC1593发酵产生琥珀酸培养基的主要成分,及其含量进行优化。通过单因素试验,得出发酵培养基中葡萄糖、酵母膏和玉米浆的含量对产生琥珀酸有显著影响;采用响应面法(RSM),得出多元二次回归方程拟合的三种因素与琥珀酸含量间的函数关系,并根据优化结果与实验,CGMCC1593产琥珀酸达到41.69g/L。     

Economical succinic acid production from cane molasses by Actinobacillus succinogenes

In this work, production of succinic acid by Actinobacillus succinogenes CGMCC1593 using cane molasses as a low cost carbon source was developed. In anaerobic bottles fermentation, succinic acid concentration of 50.6+/-0.9 g l(-1) was attained at 60 h using an optimum medium containing molasses pretreated with sulfuric acid, resulting in a succinic acid yield of 79.5+/-1.1% and sugar utilization of 97.1+/-0.6%. When batch fermentation was carried out in a 5-l stirred bioreactor with pretreated molasses, 46.4 g l(-1) of succinic acid was attained at 48 h and faster cells growth was also observed. Fed batch fermentation was performed to minimize the substrate (sugar) inhibition effect, giving 55.2 g l(-1) of succinic acid and 1.15 g l(-1)h(-1) of productivity at 48 h. The present study suggests that the inexpensive cane molasses could be utilized for the economical and efficient production of succinic acid by A. succinogenes.     

Modification of tetrodotoxin with succinic anhydride

With an aim toward the synthesis of physiologically active derivatives of the powerful neurotoxin tetrodotoxin and the use of such derivatives in biochemical studies of the molecular makeup of the tetrodotoxin binding site in nerve, the modification of tetrodotoxin with succinic anhydride has been examined. A new toxin derivative, 11-succinylanhydrotetrodotoxin, is described which contains a remote carboxylic acid grouping suitable for subsequent modification or attachment to an affinity column. High voltage electrophoresis and radiochemical techniques served to establish the purity of the derivative and its relative toxicity, namely, 0.4% that of tetrodotoxin (frog nerve assay). Structure assignment was made on the basis of the FT 100 MHz nmr spectrum.     

循环利用重组大肠杆菌细胞转化合成丁二酸

研究了回收丁二酸发酵液中的大肠杆菌进行细胞转化的可行性,以转化率和生产效率为指标,考察了不同菌体浓度、底物浓度、pH调节剂对细胞转化的影响。发酵结果表明大肠杆菌可以在仅含有葡萄糖和pH调节剂的水环境中转化生产丁二酸,并确定了最佳的转化条件为:细胞浓度(OD600)50,底物浓度40g/L,缓冲盐为MgCO3。基于优化好的条件,在7L发酵罐中进行重复批次转化,第1次转化的转化率和生产效率分别达到91%和3.22g/(L·h),第2次转化的生产效率和转化率达到了86%和2.04g/(L·h),第3次转化的转化率和生产效率分别达到了83%和1.82g/(L·h)。