Monitoring of low concentrations of glucose in fermentation broth

A highly sensitive glucose sensor, operating in flow-injection analysis (FIA) mode, was developed for the detection of glucose in fermentation broth. The assay system is based upon the post-column reaction of the peroxide formed in the glucose-oxidase-catalysed reaction and subsequent spectrophotometric detection of the coloured product formed. The sensor system was characterised and calibrated using standard solutions, and later used for quantification of glucose in fermentation media. Two types of enzyme column were used: one operated in packed-bed mode and the other in expanded-bed mode. Both columns were integrated into a FIA system and were found to give good analytical results. Glucose concentrations as low as 0.1 mg/l and 5 mg/l could be detected in packed- and expanded-bed modes respectively. Glucose concentrations were measured during typical fed-batch fermentation conditions in this system, and the results are presented.     

Production and utilization of polyclonal antibodies against nisin in an ELISA and for immuno-location of nisin in producing and sensitive bacterial strains

Specific nisin polyclonal antibodies (PAb) were produced in rabbits using nisin Z produced by Lactococcus lactis subsp. lactis biovar diacetylactis UL 719. Antisera were obtained from white female New Zealand rabbits that were first immunized with a nisin Z-keyhole limpet haemocyanin conjugate and boosted with free nisin Z. Nisin-specific PAb were purified by affinity chromatography with a yield of 15 mg specific antinisin 100 ml-1 serum. The detection limit of the ELISA test for nisin Z was 0.75 ng ml-1 in buffer but was 1.7 and 3.5 ng ml-1 in milk and complex media broth spiked (5, 10, 20 microg ml-1) with nisin Z, respectively. In nisin Z-spiked samples, the average concentration was between 90 and 107% of actual added amount. In contrast, when the bioassay (microtitration method) was used, only 50-63% of nisin Z biological activity could be detected. In addition, the affinity-purified nisin PAb, antirabbit IgG gold conjugate and transmission electron microscopy were successfully used to locate nisin Z on producing cells and to observe its bactericidal effects against sensitive cells.     

Enhancement of Nisin Production by <Emphasis Type="Italic">Lactococcus lactis</Emphasis> subsp. <Emphasis Type="Italic">lactis</Emphasis>

Lactococcus lactis subsp lactis BSA (L. lactis BSA) was isolated from a commercial fermented product (BSA Food Ingredients, Montreal, Canada) containing mixed bacteria that are used as starter for food fermentation. In order to increase the bacteriocin production by L. lactis BSA, different fermentation conditions were conducted. They included different volumetric combinations of two culture media (the Man, Rogosa and Sharpe (MRS) broth and skim milk), agitation level (0 and 100 rpm) and concentration of commercial nisin (0, 0.15, and 0.30 µg/ml) added into culture media as stimulant agent for nisin production. During fermentation, samples were collected and used for antibacterial evaluation against Lactobacillus sakei using agar diffusion assay. Results showed that medium containing 50 % MRS broth and 50 % skim milk gave better antibacterial activity as compared to other medium formulations. Agitation (100 rpm) did not improve nisin production by L. lactis BSA. Adding 0.15 µg/ml of nisin into the medium-containing 50 % MRS broth and 50 % skim milk caused the highest nisin activity of 18,820 AU/ml as compared to other medium formulations. This activity was 4 and ~3 times higher than medium containing 100 % MRS broth without added nisin (~4700 AU/ml) and 100 % MRS broth with 0.15 µg/ml of added nisin (~6650 AU/ml), respectively.     

生物合成乳链菌肽及其螯合物的研究

从酸奶中筛选到一株乳链菌肽产生菌A1-06,研究了各种条件因素对其合成能力的影响。通过发酵培养基的优化,在以质量分数2.0%的蔗糖为唯一碳源、0.25%的酵母膏为唯一氮源条件下,A1-06合成乳链菌肽的产率为0.3 g.L-1,效价为1.018×106U.L-1,比在基础培养基中合成的活性提高17%。Mn2+对A1-06的合成能力有抑制作用,而吐温-80则有促进作用。对乳链菌肽及其Zn2+和Fe2+的螯合物的抑菌效果进行了比较,结果表明,乳链菌肽螯合Fe(Ⅱ)对G-菌有抑制作用,6 h的抑菌率为50.3%,而乳链菌肽、乳链菌肽螯合Zn(Ⅱ)对G-菌无明显的抑制作用。     

The combined effects of high pressure and nisin on germination and inactivation of Bacillus spores in milk

Aims:  The aim of this work was to investigate the germination and inactivation of spores of Bacillus species in buffer and milk subjected to high pressure (HP) and nisin.
Methods and Results:  Spores of Bacillus subtilis and Bacillus cereus suspended in milk or buffer were treated at 100 or 500 MPa at 40°C with or without 500 IU ml⁻¹ of nisin. Treatment at 500 MPa resulted in high levels of germination (4 log units) of B. subtilis spores in both milk and buffer; this increased to >6 logs by applying a second cycle of pressure. Viability of B. subtilis spores in milk and buffer was reduced by 2·5 logs by cycled HP, while the addition of nisin (500 IU ml⁻¹) prior to HP treatment resulted in log reductions of 5·7 and 5·9 in phosphate buffered saline and milk, respectively. Physical damage of spores of B. subtilis following HP was apparent using scanning electron microscopy. Treating four strains of B. cereus at 500 MPa for 5 min twice at 40°C in the presence of 500 IU ml⁻¹ nisin proved less effective at inactivating the spores of these isolates compared with B. subtilis and some strain-to-strain variability was observed.
Conclusions:  Although high levels of germination of Bacillus spores could be achieved by combining HP and nisin, complete inactivation was not achieved using the aforementioned treatments.
Significance and Impact of the Study:  Combinations of HP treatment and nisin may be an appealing alternative to heat pasteurization of milk.     

A novel combined thermometric and amperometric biosensor for lactose determination based on immobilised cellobiose dehydrogenase

A novel method for lactose determination in milk is proposed. It is based on oxidation of lactose by cellobiose dehydrogenase (CDH) from the basidiomycete Phanerochaete chrysosporium, immobilised in an enzyme reactor. The reactor was prepared by cross-linking CDH onto aminopropyl-silanised controlled pore glass (CPG) beads using glutaraldehyde. The combined biosensor worked in flow injection analysis (FIA) mode and was developed for simultaneous monitoring of the thermometric signal associated with the enzymatic oxidation of lactose using p-benzoquinone as electron acceptor and the electrochemically generated current associated with the oxidation of the hydroquinone formed. A highly reproducible linear response for lactose was obtained between 0.05 mM and 30 mM. For a set of more than 500 samples an R.S.D. of less than 10% was achieved. The assay time was ca. 2 min per sample. The sensor was applied for the determination of lactose in dairy milk samples (milk with a fat content of 1.5% or 3% and also "lactose free" milk). No sample preparation except dilution with buffer was needed. The proposed method is rapid, suitable for repeated use and allows the possibility to compare results from two different detection methods, thus providing a built-in quality assurance. Some differences in the response observed between the methods indicate that the dual approach can be useful in mechanistic studies of redox enzymes. In addition, a dual system opens up interesting possibilities for studies of enzyme properties and mechanisms.     

Immunodot detection of nisin Z in milk and whey using enhanced chemiluminescence

A highly specific antisera was produced in New Zealand white rabbits against nisin Z, a 3400 Da bacteriocin produced by Lactococcus lactis ssp. lactis biovar. diacetylactis UL 719. A dot immunoblot assay was then developed to detect nisin Z in milk and whey. As few as 1·5 10⁻¹ international units per ml (IU ml⁻¹), corresponding to 0·003 μg ml⁻¹ of pure nisin Z, were detected in carbonate-bicarbonate buffer within 6 h using chemiluminescence. When milk and whey samples were tested, approximately 0·155 μg ml⁻¹ (7·9 IU ml⁻¹) of nisin Z was detected. The detection limit obtained was lower than that of traditional methods including microtitration and agar diffusion.     

High-performance liquid chromatography method for the simultaneous determination of sulfamethoxazole and trimethoprim in bovine milk using an on-line clean-up column

A bidimensional HPLC method for the simultaneous determination of sulfamethoxazole (SMX) and trimethoprim (TMP) in bovine milk has been developed and validated. After centrifugation, aliquots (150 microl) of milk samples were directly injected to a column-switching HPLC system. At the first step a RAM octyl-BSA column was employed to automatically remove proteins that otherwise would interfere with milk analysis. The mobile phase 0.01 M phosphate buffer pH 6.0:acetonitrile (95:5, v/v) was used in the first 5 min for the elution of milk proteins and then 0.01 M phosphate buffer pH 6.0:acetonitrile (83:17, v/v) for transfer SMX and TMP to the analytical column. The separation of SMX and TMP from one another and from other remaining milk components was performed on an octyl column using the mobile phase 0.01 M phosphate buffer pH 5.0:acetonitrile (82:18, v/v), which were detected by UV at 265 nm. The calibration graphs were linear in the concentration ranges of 25-800 ng/ml and 50-400 ng/ml for SMX and TMP, respectively. The intra- and inter-assay coefficients of variation were less than 15% for both drugs. The validated method was applied to the analysis of milk samples of twelve (two groups of six) cows after administration (intramuscular or subcutaneous) of a single recommended therapeutic dose of the SMX-TMP combination.     

Nisin production in a chitin-including continuous fermentation system with Lactococcus lactis displaying a cell wall chitin-binding domain

The limiting factors in the continuous production of nisin are high amount of biomass loss and low dilution rate application. In this study, a chitin-including continuous nisin fermentation system (CICON-FER) was constructed for high volumetric nisin production using nisin producer L. lactis displaying cell wall chitin-binding domain (ChBD) together with chitin in the reactor. In this respect, the highest binding conditions of relevant L. lactis cells to chitin were determined. Then the chitin flakes carrying nisin-producing L. lactis cells were used within the CICON-FER system at different dilution rates (0.1–0.9 h^?1) and initial glucose concentrations (20–60 g l^?1). The results revealed that the pH 7 conditions and the use of 100 mM sodium phosphate buffer with 0.1 % Tween 20 and Triton X-100 significantly increased the binding capacity of ChBD displaying L. lactis cells to chitin. The constructed CICON-FER system maintained the presence of the ChBD surface displaying L. lactis cells in the reactor system until 0.9 h^?1 dilution rate that resulted in a considerably high level of volumetric nisin production and productivity (10,500 IU ml^?1 and 9,450 IU ml^?1 h^?1, respectively) with the combination of a 0.9-h^?1 dilution rate and a 40-g l^?1 initial glucose concentration. In conclusion, an innovative nisin fermentation system that yielded the highest nisin production thus far and that was feasible for industrial application was created.     

Analysis of glutathione and glutathione disulfide in human saliva using hydrophilic interaction chromatography with mass spectrometry

A sensitive method for the determination of glutathione (GSH) and glutathione disulfide (GSSG) in human saliva was developed and validated. GSH was captured and stabilized by the addition of N-ethylmaleimide (NEM). Solid-phase extraction (SPE) using an Oasis MAX extraction cartridge was employed for sample preparation and analysis was performed on a Shimadzu LCMS-2010 A that was operated in the single ion monitoring mode using positive ion electrospray ionization (ESI) as the interface. The monitored ion for GSH-NEM was m/z 433 and that for GSSG was m/z 613. Chromatography was carried out on an Atlantis HILIC silica column (150 mm x 2.1 mm, 5 microm) with acetonitrile and formate buffer as the mobile phase at the flow rate of 0.2 ml/min. The calibration curve was linear over the range of 0.1-100 microM for GSH-NEM. The extraction recoveries of GSH-NEM spiked at concentrations of 25 and 50 microM were 97.1 and 104.4%, respectively. Similar results were obtained for GSSG. The newly developed hydrophilic interaction chromatography with mass spectrometry (HILIC/MS) method showed superior sensitivity for the determination of GSH and GSSG in human saliva samples.     

A Comparative Study Between the Antibacterial Effect of Nisin and Nisin-Loaded Chitosan/Alginate Nanoparticles on the Growth of Staphylococcus aureus in Raw and Pasteurized Milk Samples

The aim of this study was to evaluate the antibacterial effect of nisin-loaded chitosan/alginate nanoparticles as a novel antibacterial delivery vehicle. The nisin-loaded nanoparticles were prepared using colloidal dispersion of the chitosan/alginate polymers in the presence of nisin. After the preparation of the nisin-loaded nanoparticles, their physicochemical properties such as size, shape, and zeta potential of the formulations were studied using scanning electron microscope and nanosizer instruments, consecutively. FTIR and differential scanning calorimetery studies were performed to investigate polymer–polymer or polymer–protein interactions. Next, the release kinetics and entrapment efficiency of the nisin-loaded nanoparticles were examined to assess the application potential of these formulations as a candidate vector. For measuring the antibacterial activity of the nisin-loaded nanoparticles, agar diffusion and MIC methods were employed. The samples under investigation for total microbial counts were pasteurized and raw milks each of which contained the nisin-loaded nanoparticles and inoculated Staphylococcus aureus (ATCC 19117 at 10⁶ CFU/mL), pasteurized and raw milks each included free nisin and S. aureus (10⁶ CFU/mL), and pasteurized and raw milks each had S. aureus (10⁶ CFU/mL) in as control. Total counts of S. aureus were measured after 24 and 48 h for the pasteurized milk samples and after the time intervals of 0, 6, 10, 14, 18, and 24 h for the raw milk samples, respectively. According to the results, entrapment efficiency of nisin inside of the nanoparticles was about 90–95%. The average size of the nanoparticles was 205 nm, and the average zeta potential of them was ?47 mV. In agar diffusion assay, an antibacterial activity (inhibition zone diameter, at 450 IU/mL) about 2 times higher than that of free nisin was observed for the nisin-loaded nanoparticles. MIC of the nisin-loaded nanoparticles (0.5 mg/mL) was about four times less than that of free nisin (2 mg/mL). Evaluation of the kinetic of the growth of S. aureus based on the total counts in the raw and pasteurized milks revealed that the nisin-loaded nanoparticles were able to inhibit more effectively the growth of S. aureus than free nisin during longer incubation periods. In other words, the decrease in the population of S. aureus for free nisin and the nisin-loaded nanoparticles in pasteurized milk was the same after 24 h of incubation while lessening in the growth of S. aureus was more marked for the nisin-loaded nanoparticles than the samples containing only free nisin after 48 h of incubation. Although the same growth reduction profile in S. aureus was noticed for free nisin and the nisin-loaded nanoparticles in the raw milk up to 14 h of incubation, after this time the nisin-loaded nanoparticles showed higher growth inhibition than free nisin. Since, generally, naked nisin has greater interactions with the ingredients present in milk samples in comparison with the protected nisin. Therefore, it is concluded that the antibacterial activity of nisin naturally decreases more during longer times of incubation than the protected nisin with the chitosan/alginate nanoparticles. Consequently, this protection increases and keeps antibacterial efficiency of nisin in comparison with free nisin during longer times of storage. These results can pave the way for further research and use of these nanoparticles as new antimicrobial agents in various realms of dairy products.     

Multimethod assessment of commercial nisin preparations

Nisin is a GRAS preservative effective against several Gram-positive organisms including Listeria monocytogenes. Commercial preparations are usually fermentation products containing 2.5% pure nisin along with insoluble material which, in this study, was found to influence the quantification and activity of nisin under different conditions. Commercially available samples of nisin were tested for efficacy using various methods, such as well diffusion, time to turbidity, and GUS (where a reporter compound is induced in response to nisin). SDS-PAGE detected a single peptide band, corresponding with the molecular weight of nisin. Protein quantified using the Bradford method indicated that the carrier of some samples was proteinaceous. Though the activity of commercially available nisin preparations is indicated on the label, end users should determine the effect of changing their source of nisin. Received 13 February 2002/ Accepted in revised form 26 July 2002     

Quantification of lactose content in human and cow's milk using UPLC-tandem mass spectrometry

A sensitive, accurate, and specific quantitative UPLC-MS/MS method was developed for lactose measurement of cow's and human milk and validated with cow's milk samples certified by an external laboratory. The new method employs only a dilution of raw cow's and human milk for simple preparation with no need to remove protein and fat prior to analysis with UPLC-MS/MS. It was operated in negative mode to detect lactose molecules and labeled (13)C(12)-lactose with the highest sensitivity. The principle advantages of the new LC-MS/MS method were: completed lactose determination in 5 min, absolute recovery of 97-107%, lower limit of detection <5 ng/L, and 99% linearity over the concentration range of 0.7-4.4 mg/L for both cow's and human milk. The mean lactose concentration of 51 human milk samples was measured as 56.8 ± 5.5 g/L ranging from 43 to 65 g/L. The described method represents validated lactose analysis with high accuracy and precision for a routine lactose determination in raw human milk.     

Online recovery of nisin during fermentation and its effect on nisin production in biofilm reactor

An online removal of nisin by silicic acid coupled with a micro-filter module was proposed as an alternative to reduce detrimental effects caused by adsorption of nisin onto producer, enzymatic degradation by protease, and product inhibition during fermentation. In this study, silicic acid was successfully used to recover nisin from the fermentation broth of Lactococcus lactis subsp. lactis NIZO 22186. The effect of pH (at 6.8 and 3.0) during adsorption process and several eluents (deionized water, 20% ethanol, 1 M NaCl, and 1 M NaCl + 20% ethanol) for desorption were evaluated in a small batch scale. Higher nisin adsorption onto silicic acid was achieved when the adsorption was carried out at pH 6.8 (67% adsorption) than at pH 3.0 (54% adsorption). The maximum recovery was achieved (47% of nisin was harvested) when the adsorption was carried out at pH 6.8 and 1 M NaCl + 20% ethanol was used as an eluent for desorption. Most importantly, nisin production was significantly enhanced (7,445 IU/ml) when compared with the batch fermentation without the online recovery (1,897 IU/ml). This may possibly be attributed to preventing the loss of nisin due the detrimental effects and a higher biomass density achieved during online recovery process, which stimulated production of nisin during fermentation.     

Development of a low-cost medium for production of nisin from Lactococcus lactis subsp. lactis

The goal of this project was to develop a lower-cost medium for nisin production, so this bacteriocin could be used in a broader range of industrial fermentation processes. The objectives included: (1) evaluating methods for controlling the inhibitory effect of lactic acid produced during fermentation, and (2) comparing two inexpensive complex media for nisin production. Lactococcus lactis subsp. lactis was cultured in shake flasks on Laurel–Tryptose broth to evaluate a range of buffers for pH control. NaHCO₃ proved to be an effective buffer for increasing nisin production. Subsequent trials then evaluated condensed corn soluble (CCS, a fuel ethanol production byproduct) and cheese whey as inexpensive growth media. CCS was shown to be an efficient, low-cost medium for high nisin titers and yields. These modifications reduced the medium costs for nisin production from $600/kg nisin (based on Laurel–Tryptose broth medium) to $35–40/kg nisin for the corn solubles medium.     

A simple,optimized method for the determination of sulphide in whole blood by GC-mS as a marker of bowel fermentation processes

Hydrogen sulphide is produced in human large intestine by anaerobic fermentation and may play a pathogenic role. An analytical method for determination of sulphide in whole blood using an extractive alkylation technique was optimised and validated for this purpose. The sample was mixed with organic phase containing pentafluorobenzyl bromide as an alkylating agent. The benzalkonium chloride was used as a phase-transfer catalyst. The quantitative determination was performed using GC-MS technique in selected ion monitoring mode. The blood levels of sulphide of healthy controls were measured (35-80 microM/l). The method is versatile, reproducible (RSD=2.7%) and suitable for research of anaerobic fermentation in vivo.     

Using drug-loaded pH-responsive poly(4-vinylpyridine) microspheres as a new strategy for intelligent controlling of <Emphasis Type="Italic">Lactobacillus plantarum</Emphasis> contamination in bioethanol fermentation

Bioethanol fermentation is usually contaminated by bacteria, especially lactic acid bacteria (LAB), thereby leading to decrease of bioethanol yield and serious economic losses. Nisin is safer for controlling of bacterial contamination than antibiotics that are widely applied in industry. Moreover, in LAB contaminative bioethanol fermentation system, consistently decreased pH value provides opportunity to realize pH value responsive material-based release of anti-bacteria substances for intelligent and persistent controlling of bacterial contamination. In this study, nisin was embedded into pH-sensitive poly(4-vinylpyridine) (P4VP) microspheres synthesized by suspension polymerization to realize intelligent controlling of Lactobacillus plantarum contamination in bioethanol fermentation. Chloramphenicol with the highest antimicrobial activity and excellent stability was chosen as the model drug to be embedded into P4VP microspheres to test the drug release behavior. The drug release curve of chloramphenicol-loaded P4VP microspheres showed sustained and pH-responsive release properties. The diameters of the microspheres ranged from 40 to 100 µm. The encapsulation efficiency of nisin into P4VP microspheres was 47.67% and the drug-loading capacity of nisin was 2.5%. Nisin-loaded P4VP microspheres were added into the simulated contaminative fermentation system, and successfully reversed the decline of bioethanol yield secondary to L. plantarum contamination. The results in this study indicated that L. plantarum contamination in bioethanol fermentation could be effectively controlled by nisin-loaded P4VP microspheres.     

固定化乳酸乳球菌连续生产Nisin的研究

以海藻酸钙为材料 ,固定乳酸乳球菌 (Lactococcuslactissubsp .lactis)SM5 2 6 ,研究不同条件对Nisin合成的影响。结果表明 ,利用 2 %海藻酸钠在 1 0mmol LCaCl2 条件下 ,得到的固定化细胞颗粒稳定性较好 ,可维持 90h无破裂 ;在发酵过程中SYS3培养基中的无机盐成分尤其磷酸盐对固定化颗粒有破坏作用 ;用mSYS3培养基代替SYS3 ,通过 72h三批次循环的半连续培养 ,Nisin活性为 85 0IU mL ,无明显的细胞渗漏现象。连续化生产 70h ,Nisin活性达 1 1 5 0IU mL ,相当于游离细胞的发酵水平。     

Inhibition of Listeria innocua in cheddar cheese by addition of nisin Z in liposomes or by in situ production in mixed culture

The effect of addition of purified nisin Z in liposomes to cheese milk and of in situ production of nisin Z by Lactococcus lactis subsp. lactis biovar diacetylactis UL719 in the mixed starter on the inhibition of Listeria innocua in cheddar cheese was evaluated during 6 months of ripening. A cheese mixed starter culture containing Lactococcus lactis subsp. lactis biovar diacetylactis UL719 was selected for high-level nisin Z and acid production. Experimental cheddar cheeses were produced on a pilot scale, using the selected starter culture, from milk with added L. innocua (10(5) to 10(6) CFU/ml). Liposomes with purified nisin Z were prepared from proliposome H and added to cheese milk prior to renneting to give a final concentration of 300 IU/g of cheese. The nisin Z-producing strain and nisin Z-containing liposomes did not significantly affect cheese production and gross chemical composition of the cheeses. Immediately after cheese production, 3- and 1.5-log-unit reductions in viable counts of L. innocua were obtained in cheeses with encapsulated nisin and the nisinogenic starter, respectively. After 6 months, cheeses made with encapsulated nisin contained less than 10 CFU of L. innocua per g and 90% of the initial nisin activity, compared with 10(4) CFU/g and only 12% of initial activity in cheeses made with the nisinogenic starter. This study showed that encapsulation of nisin Z in liposomes can provide a powerful tool to improve nisin stability and inhibitory action in the cheese matrix while protecting the cheese starter from the detrimental action of nisin during cheese production.     

Nisin production of Lactococcus lactis N8 with hemin‐stimulated cell respiration in fed‐batch fermentation system

In this study, nisin production of Lactococcus lactis N8 was optimized by independent variables of glucose, hemin and oxygen concentrations in fed‐batch fermentation in which respiration of cells was stimulated with hemin. Response surface model was able to explain the changes of the nisin production of L. lactis N8 in fed‐batch fermentation system with high fidelity (R² 98%) and insignificant lack of fit. Accordingly, the equation developed indicated the optimum parameters for glucose, hemin, and dissolved oxygen were 8 g L^?1 h^?1, 3 μg mL^?1 and 40%, respectively. While 1711 IU mL^?1 nisin was produced by L. lactis N8 in control fed‐batch fermentation, 5410 IU mL^?1 nisin production was achieved within the relevant optimum parameters where the respiration of cell was stimulated with hemin. Accordingly, nisin production was enhanced 3.1 fold in fed‐batch fermentation using hemin. In conclusion the nisin production of L. lactis N8 was enhanced extensively as a result of increasing the biomass by stimulating the cell respiration with adding the hemin in the fed‐batch fermentation. © 2015 American Institute of Chemical Engineers Biotechnol. Prog., 31:678–685, 2015