Nitrile Hydratase and Amidase from Rhodococcus rhodochrous Hydrolyze Acrylic Fibers and Granular Polyacrylonitriles

Rhodococcus rhodochrous NCIMB 11216 produced nitrile hydratase (320 nkat mg of protein⁻¹) and amidase activity (38.4 nkat mg of protein⁻¹) when grown on a medium containing propionitrile. These enzymes were able to hydrolyze nitrile groups of both granular polyacrylonitriles (PAN) and acrylic fibers. Nitrile groups of PAN40 (molecular mass, 40 kDa) and PAN190 (molecular mass, 190 kDa) were converted into the corresponding carbonic acids to 1.8 and 1.0%, respectively. In contrast, surfacial nitrile groups of acrylic fibers were only converted to the corresponding amides. X-ray photoelectron spectroscopy analysis showed that 16% of the surfacial nitrile groups were hydrolyzed by the R. rhodochrous enzymes. Due to the enzymatic modification, the acrylic fibers became more hydrophilic and thus, adsorption of dyes was enhanced. This was indicated by a 15% increase in the staining level (K/S value) for C.I. Basic Blue 9.     

Surface hydrolysis of polyacrylonitrile with nitrile hydrolysing enzymes from Micrococcus luteus BST20

A new Micrococcus luteus strain BST20 was isolated with ability to metabolize PAN polymers as sole carbon source. Out of seven synthetized PAN copolymers containing different moieties of acrylic acid and/or vinyl acetate the polymer with lowest crystallinity (PAN with 5% vinyl acetate) was most easily metabolized. (13)C labelled PAN was completely converted to the acrylic acid by this strain. M. luteus BST20 produced membrane-bound nitrile hydrolysing enzymes able to convert nitrile groups on PAN powder surface to the corresponding acids. Similarly, nitrile groups on PAN fabrics were transformed to the corresponding acid as indicated by an K/S increased after dying with Methylene blue and the released ammonia. On small soluble substrates the enzyme system showed a preference for aliphatic and aromatic substituted aliphatic nitriles.     

Surface modification of polyacrylonitrile with nitrile hydratase and amidase from Agrobacterium tumefaciens

A new strain of Agrobacterium tumefaciens (BST05) was found to grow on polyacrylonitrile (PAN; ¹³C labelled) converting the polymer to polyacrylic acid as shown by solid state NMR. When cultivated in a medium containing acetonitrile the bacterium produced nitrile hydratase and amidase activity. Activity recovery after lyophilisation and enzyme stability was significantly enhanced in the presence of 5% sorbitol leading to half life times of 12, 72 and 154 days at 25°C, 4°C and -20°C. The enzymes were able to convert 1.1% of the nitrile groups of PAN-powder to the corresponding acids. PAN fabrics were mainly converted to the amides as shown by an 80% increase of the O/C ratio in ESCA analysis. These data were confirmed by cationic dyeing and FTIR-ATR analysis.     

Surface modification of polyacrylonitrile with nitrile hydratase and amidase from Agrobacterium tumefaciens

A new strain of Agrobacterium tumefaciens (BST05) was found to grow on polyacrylonitrile (PAN; ¹³C labelled) converting the polymer to polyacrylic acid as shown by solid state NMR. When cultivated in a medium containing acetonitrile the bacterium produced nitrile hydratase and amidase activity. Activity recovery after lyophilisation and enzyme stability was significantly enhanced in the presence of 5% sorbitol leading to half life times of 12, 72 and 154 days at 25°C, 4°C and –20°C. The enzymes were able to convert 1.1% of the nitrile groups of PAN-powder to the corresponding acids. PAN fabrics were mainly converted to the amides as shown by an 80% increase of the O/C ratio in ESCA analysis. These data were confirmed by cationic dyeing and FTIR-ATR analysis.     

Characterization of a new cobalt-containing nitrile hydratase purified from urea-induced cells of Rhodococcus rhodochrous J1

A new cobalt-containing nitrile hydratase was purified from extracts of urea-induced cells from Rhodococcus rhodochrous J1 in seven steps. At the last step, the enzyme was crystallized by adding ammonium sulfate. Nitrile hydratase was a 500-530-kDa protein composed of two different subunits (alpha subunit 26 kDa, beta subunit 29 kDa). The enzyme contained approximately 11-12 mol cobalt/mol enzyme. A concentrated solution of highly purified nitrile hydratase exhibited a broad absorption spectrum in the visible range, with an absorption maxima at 410 nm. The enzyme had a wide substrate specificity. Aliphatic saturated or unsaturated nitriles as well as aromatic nitriles, were substrates for the enzyme. The optimum pH of the hydratase was pH 6.5-6.8. The enzyme was more stable than ferric nitrile hydratases. The amino-terminal sequence of each subunit of R. rhodochrous J1 enzyme was determined and compared with that of ferric nitrile hydratases. Prominent similarities were observed with the beta subunit. However, the amino acid sequence of the alpha subunit from R. rhodochrous J1 was quite different from that of the ferric enzymes.     

Enantioselective hydration of 2-arylpropionitriles by a nitrile hydratase from Agrobacterium tumefaciens strain d3

The enantioselective nitrile hydratase from the bacterium Agrobacterium tumefaciens d3 was purified and completely separated from the amidase activity that is also present in cell extracts prepared from this strain. The nitrile hydratase had an activity optimum at pH 7.0 and a temperature optimum of 40 °C. The holoenzyme had a molecular mass of 69 kDa, the subunits a molecular mass of 27 kDa. The enzyme hydrated various 2-arylpropionitriles and other aromatic and heterocyclic nitriles. With racemic 2-phenylpropionitrile, 2-phenylbutyronitrile, 2-(4-chlorophenyl)propionitrile, 2-(4-methoxy)propionitrile or ketoprofen nitrile the corresponding (S)-amides were formed enantioselectively. The highest enantiomeric excesses (ee >90% until about 30% of the respective substrates were converted) were found for the amides formed from 2-phenylpropionitrile, 2-phenylbutyronitrile and ketoprofen nitrile. For the reaction of the purified nitrile hydratase, higher ee values were found than when whole cells were used in the presence of an inhibitor of the amidase activity. The enantioselectivity of the whole-cell reaction was enhanced by increasing the reaction temperature. Received: 20 June 1997 / Received revision: 28 August 1997 / Accepted: 29 August 1997     

Poly(ethylene oxide)-grafted thermoplastic membranes for use as cellular hybrid bio-artificial organs in the central nervous system

Poly(acrylonitrile-co-vinyl chloride) (PAN/VC) anisotropic membranes were chemically modified with poly(ethylene oxide) (PEO) (5000 and 20,000 g/mol) by one of two aqueous reactions: (a) acid hydrolysis of the nitrile group to a carboxylic acid with which amine-terminated PEO (PEO-NH(2)) reacted or (b) base reduction of the nitrile group to an amine with which PEO-succinimide (PEO-SC) reacted. Approximately 1.3% of the bulk material was modified with PEO-NH(2) whereas 1.8 to 3.5% was modified with PEO-SC as determined by proton nuclear magnetic resonance ((1)H NMR) and attenuated total reflectance Fourier transform infrared (ATR FTIR) spectra. Approximately 50 to 75% less bovine serum albumin (BSA) adsorbed to PEO-grafted single skin fibers than to unmodified PAN/VC. Transport properties of modified and unmodified fibers were compared by passive diffusion, convective nominal molecular weight cutoff, and hydraulic permeability. Neither hydraulic permeability nor nominal molecular weight cutoff of BSA changed appreciably after surface modification with PEO indicating that pore structure was not adversely affected by the chemistry involved in grafting poly(ethylene oxide). However, in the absence of any membrane conditioning, the apparent diffusion of alpha-chymotrypsinogen (24,000 g/mol) was enhanced in PEO-grafted PAN/VC fibers possibly as a result of reduced sorption of the permeating protein. In vivo biocompatibility in the brain tissue of rats was judged by histological assessment of the host's cellular response to fibers implanted for 30 days; biocompatibility of both PAN/VC and PAN/VC-g-PEO was satisfactory but improved slightly with PEO grafting. (c) 1994 John Wiley & Sons, Inc.     

Screening for pectinolytic activity of wood-rotting basidiomycetes and characterization of the enzymes

Seventy-five fungal strains from different groups of basidiomycetes, newly isolated from rotten wood, were screened for pectinolytic activity. Despite the fact that basidiomycetes are scarcely referred to as pectinase producers, the polygalacturonase (PG) activity was detected in 76% of the strains; 16% with activity higher than 40 nkat/g, 40% between 13.3 and 40 nkat/g, and 44% with activity lower than 13.3 nkat/g. The highest productions were obtained among the fungi from order Aphyllophorales, family Polyporaceae. The characterization of the enzymes from the highest PG producers (Lentinus sp., Gloeophyllum striatum, Pycnoporus sanguineus, Schizophyllum commune) showed optimum temperature for catalytic activity at 60-70 degrees C and two peaks of pH optimum (3.5-4.5 and 8.5-9.5). The enzymes exhibited high pH stability (3.0-11.0) but after incubation at 40 degrees C for 1 h their activity dropped by 18-73%.     

Nitrilase of Rhodococcus rhodochrous J1. Purification and characterization

Nitrilase was purified from an extract of isovaleronitrile-induced cells of Rhodococcus rhodochrous J1 in seven steps. In the last step, the enzyme was crystallized by adding ammonium sulfate. The crystallized enzyme appeared to be homogeneous by polyacrylamide electrophoresis, ampholyte electrofocusing and double immunodiffusion in agarose. The enzyme has a molecular mass of about 78 kDa and consists of two subunits identical in molecular mass. The purified enzyme exhibits a pH optimum of 7.6 and a temperature optimum of 45 degrees C. The enzyme catalyzed stoichiometrically the hydrolysis of benzonitrile to benzoic acid and ammonia, and no formation of amide was detected. The enzyme required thiol compounds such as dithiothreitol, L-cysteine or reduced glutathione to exhibit maximum activity. The enzyme was specific for nitrile groups attached to an aromatic or heteroaromatic ring, e.g. benzonitrile, 3-chlorobenzonitrile, 4-tolunitrile, 2-furonitrile and 2-thiophenecarbonitrile. The comparison of the properties of the enzyme with other nitrilases and nitrile hydratases has been also discussed.     

Adaptation of acrylamide producer Rhodococcus rhodochrous M8 to change in ammonium concentration in medium

The mechanism of adaptation of the acrylamide producing strain Rhodococcus rhodochrous M8 to changes in ammonium concentrations in the medium was studied. An increase in the content of ammonium in the medium changed the activity of glutamine synthetase (GS) (EC 6.3.1.2) and glutamine dehydrogenase (GD) (EC 1.4.1.4), the enzymes of ammonium assimilation, as well as the activities of enzymes responsible for nitrile utilization: nitrile hydratase (EC 4.2.1.84) and amidase (EC 3.5.1.4). This also caused inhibition of activation of GS induced by phosphodiesterase (EC 3.1.4.1). Increases in the activities of nitrile hydratase and amidase and resistance of these enzymes to ammonium were observed in mutant of R. rhodichrous resistant to phosphotricine, an inhibitor of GS. An important role of GS in the mechanism of adaptation is suggested.     

Expression of the Aspergillus aculeatus endo-beta-1,4-mannanase encoding gene (man1) in Saccharomyces cerevisiae and characterization of the recombinant enzyme

The endo-beta-1,4-mannanase encoding gene man1 of Aspergillus aculeatus MRC11624 was amplified from mRNA by polymerase chain reaction using sequence-specific primers designed from the published sequence of man1 from A. aculeatus KSM510. The amplified fragment was cloned and expressed in Saccharomyces cerevisiae under the gene regulation of the alcohol dehydrogenase (ADH2(PT)) and phosphoglycerate kinase (PGK1(PT)) promoters and terminators, respectively. The man1 gene product was designated Man5A. Subsequently, the FUR1 gene of the recombinant yeast strains was disrupted to create autoselective strains: S. cerevisiae Man5ADH2 and S. cerevisiae Man5PGK1. The strains secreted 521 nkat/ml and 379 nkat/ml of active Man5A after 96 h of growth in a complex medium. These levels were equivalent to 118 and 86 mg/l of Man5A protein produced, respectively. The properties of the native and recombinant Man5A were investigated and found to be similar. The apparent molecular mass of the recombinant enzyme was 50 kDa compared to 45 kDa of the native enzyme due to glycosylation. The determined K(m) and V(max) values were 0.3 mg/ml and 82 micromol/min/mg for the recombinant and 0.15 mg/ml and 180 micromol/min/mg for the native Man5A, respectively. The maximum pH and thermal stability were observed within the range of pH 4-6 and 50 degrees C and below. The pH and temperature optima and stability were relatively similar for recombinant and native Man5A. Hydrolysis of an unbranched beta-1,4-linked mannan polymer released mannose, mannobiose, and mannotriose as the main products.     

Purification and biochemical characterization of a mycelial alkaline phosphatase without DNAase activity produced by<Emphasis Type="Italic">Aspergillus caespitosus</Emphasis>

Biochemical properties of a termostable alkaline phosphatase obtained from the mycelium extract of A. caespitosus were described. The enzyme was purified 42-fold with 32% recovery by DEAE-cellulose and concanavalin A-Sepharose chromatography. The molar mass estimated by Sephacryl S-200 or by 7% SDS-PAGE was 138 kDa and 71 kDa, respectively, indicating a homodimer. Temperature and pH optima were 80 degrees C and pH 9.0. This enzyme was highly glycosylated (approximately 74% saccharide content). The activity was enhanced by Mg2+ (19-139%), NH4+ (64%), Na+ (51%) and Mn2+ (38%). 4-Nitrophenyl phosphate (4-NPP) was preferentially hydrolyzed, but glucose 1-phosphate (93%), UTP (67%) and O-phosphoamino acids also acted as substrates. V(lim) and K(m) were 3.78 nkat per mg protein and 270 micromol/L in the absence of Mg2+ and 7.35 nkat per mg protein and 410 micromol/L in the presence of Mg2+, using 4-NPP as substrate. The purified alkaline phosphatase removed the 5'-phosphate group of a linearized plasmid without showing DNAase activity, indicating its potential for recombinant DNA technology.     

Expression and identification of the RfbE protein from Vibrio cholerae O1 and its use for the enzymatic synthesis of GDP-D-perosamine

The 4-amino-6-deoxy-monosaccharide D-perosamine is an important element in the glycosylation of interesting cell products, such as antibiotics and lipopolysaccharides (LPS) of Gram-positive and Gram-negative bacteria. The biosynthetic pathway of the precursor molecule, GDP-D-perosamine, in Vibrio cholerae O1 starts with an isomerisation of fructose-6-phosphate catalyzed by the bifunctional enzyme phosphomannose isomerase-guanosine diphosphomannose pyrophosphorylase (RfbA; E.C. 2.7.7.22) creating the intermediate mannose-6-phosphate, which is subsequently converted by the phosphomanno-mutase (RfbB; E.C. 5.4.2.8) and further by RfbA to GDP-D-mannose, to GDP-4 keto-6-deoxymannose by a 4,6-dehydratase (RfbD; E.C. 4.2.1.47) and finally to GDP-D-perosamine by an aminotransferase (RfbE; E.C. not yet classified). We cloned the rfbD and the rfbE genes of V. cholerae O1 in Escherichia coli expression vectors. Both biosynthetic enzymes were overproduced in E. coli BL21 (DE3) and their activities were analyzed. The enzymatic conversion from GDP-D-mannose to GDP-D-perosamine was optimized and the final product, GDP-D-perosamine, was purified and identified by nuclear magnetic resonance, mass spectrometry, and chromatography. The catalytically active form of the GDP-4-keto-6-deoxy-D-mannose-4-aminotransferase seems to be a tetramer of 170 kDa. The His-tag RfbE fusion protein has a Km of 0.06 mM and a Vmax value of 38 nkat/mg protein for the substrate GDP-4-keto-6-deoxy-D-mannose. The Km and Vmax values for the cosubstrate L-glutamate were 0.1 mM and 42 nkat/mg protein, respectively. The intention of this work is to establish a basis for both the in vitro production of GDP-D-perosamine and for an in vivo perosaminylation system in a suitable bacterial host, preferably E. coli.     

Cobalt-dependent transcription of the nitrile hydratase gene in Rhodococcus rhodochrous M8

Abstract The effects of cobalt ions on the activities of Rhodococcus rhodochrous M8 enzymes for nitrile utilization, nitrile hydratase and amidase, were investigated. In contrast to amidase, synthesis of nitrile hydratase and its activity required cobalt ions in the growth medium. Northern blot analysis showed that in the presence of cobalt ions, the level of mRNA for nitrile hydratase genes was several times higher than that under cobalt-limited conditions. It was assumed that the low nitrile hydratase activity in cells grown in the absence of cobalt ions is connected either with the weak expression of nitrile hydratase genes or with the rapid degradation of nitrile hydratase mRNA.     

Chitinolytic activities of <Emphasis Type="Italic">Clostridium</Emphasis> sp. JM2 isolated from stool of human administered per orally by chitosan

The novel chitinolytic bacterium Clostridium beijerinckii strain JM2 was isolated from the stool of healthy volunteers supplied daily per orally with 3 g of chitosan. The bacterium grown on colloidal chitin produced a complete array of chitinolytic enzymes. Significant activities of endochitinase, exochitinase and chitosanase were excreted into the medium (301, 282 and 268 nkat/μg protein, respectively). The high cellular activity of N-acetyl-β-glucosaminidase (NAGase) and chitosanase were detected (732.4 and 154 nkat/μg protein, respectively). NAGase activity represented the main activity associated with the cellular fraction. The activities of both enzymes tested increased from 20 to 50 °C; the optimum reaction temperature estimated being 50 °C. Endochitinase as well as NAGase showed an activity in the pH interval of 4.0–8.0; the optimum pH values were 6.5 and 6.0, respectively. The extracellular endochitinase complex consisted of six isoenzymes with molar mass of 32–76 kDa; in the cellular fraction five bands with molar mass of 45–86 kDa were detected. Exochitinase activity was demonstrated in the form of three bands (with molar mass of 30–57 kDa), NAGase activity displayed one band of 45 kDa.     

Cloning and characterization of 1-deoxy-D-xylulose 5-phosphate synthase from Streptomyces sp. Strain CL190, which uses both the mevalonate and nonmevalonate pathways for isopentenyl diphosphate biosynthesis

In addition to the ubiquitous mevalonate pathway, Streptomyces sp. strain CL190 utilizes the nonmevalonate pathway for isopentenyl diphosphate biosynthesis. The initial step of this nonmevalonate pathway is the formation of 1-deoxy-D-xylulose 5-phosphate (DXP) by condensation of pyruvate and glyceraldehyde 3-phosphate catalyzed by DXP synthase. The corresponding gene, dxs, was cloned from CL190 by using PCR with two oligonucleotide primers synthesized on the basis of two highly conserved regions among dxs homologs from six genera. The dxs gene of CL190 encodes 631 amino acid residues with a predicted molecular mass of 68 kDa. The recombinant enzyme overexpressed in Escherichia coli was purified as a soluble protein and characterized. The molecular mass of the enzyme was estimated to be 70 kDa by sodium dodecyl sulfate-polyacrylamide gel electrophoresis and 130 kDa by gel filtration chromatography, suggesting that the enzyme is most likely to be a dimer. The enzyme showed a pH optimum of 9.0, with a V(max) of 370 U per mg of protein and K(m)s of 65 microM for pyruvate and 120 microM for D-glyceraldehyde 3-phosphate. The purified enzyme catalyzed the formation of 1-deoxyxylulose by condensation of pyruvate and glyceraldehyde as well, with a K(m) value of 35 mM for D-glyceraldehyde. To compare the enzymatic properties of CL190 and E. coli DXP synthases, the latter enzyme was also overexpressed and purified. Although these two enzymes had different origins, they showed the same enzymatic properties.     

Improved mannan-degrading enzymes' production by Aspergillus niger through medium optimization

The effect of different carbon and nitrogen sources on the production of mannan-degrading enzymes, focussing on β-mannanase, by Aspergillus niger was investigated using shake flask culture. The β-mannanase activity obtained during growth of A. niger on guar gum (GG, 1495 nkat mL(-1)) was much higher than those observed on other carbon substrates, locust bean gum (1148 nkat mL(-1)), α-cellulose (10.7 nkat mL(-1)), glucose (8.8 nkat mL(-1)) and carboxymethylcellulose (4.6 nkat mL(-1)). For fermentation using GG as a carbon source, bacteriological peptone gave the highest β-mannanase activity (1744 nkat mL(-1)) followed by peptone from meat (1168 nkat mL(-1)), yeast extract (817 nkat mL(-1)), ammonium sulphate (241 nkat mL(-1)), ammonium nitrate (113 nkat mL(-1)) and ammonium chloride (99 nkat mL(-1)) when used as a nitrogen source. The composition of bacteriological peptone and initial pH of the medium were further optimized using response surface methodology (RSM). Medium consisted of 21.3 g L(-1) GG and 57 g L(-1) peptone with initial culture pH of 5.5 was optimum for β-mannanase production (2063 nkat mL(-1)) by A. niger. The β-mannanase production obtained in this study using A. niger was significantly higher than those reported in the literature.     

Site-directed mutagenesis for cysteine residues of cobalt-containing nitrile hydratase

Three cysteine residues, which are completely conserved among alpha-subunits in all nitrile hydratases, are thought to be the ligands of a metal ion in the catalytic center of this enzyme. These cysteine residues (i.e. alpha C102, alpha C105 and alpha C107) in the high-molecular-mass nitrile hydratase (H-NHase) of Rhodococcus rhodochrous J1 were replaced with alanine by site-directed mutagenesis using the R. rhodochrous ATCC12674 host-vector system, and the resultant transformants were investigated. Sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE) for the cell-free extracts of each mutant transformant revealed that four mutant transformants (i.e. alpha C105A, alpha C107A, alpha C102A/C105A and alpha C105A/C107A) showed predominant alpha- and beta-subunit protein bands with a mobility identical to those of the native H-NHase, while three mutant transformants (i.e. alpha C102A, alpha C102A/C107A and alpha C102A/C105A/C107A) did not produce the corresponding proteins. The purified former four mutant enzymes showed neither enzymatic activity nor the maximum absorption at 410 nm which was detected in the wild type H-NHase. They also did not contain cobalt ions. Based upon these findings, these three cysteine residues were found to be essential for the active expression of H-NHase.     

Cloning the amidase gene from Rhodococcus rhodochrous M18 and its expression in Escherichia coli

The amidase gene from Rhodococcus rhodochrous M18 was cloned by PCR amplification with primers developed by use of peptide amino acid sequences obtained after treating amidase with trypsin. Nucleotide sequence analysis of this gene revealed high homology with aliphatic amidases from R. erythropolis R312 and Pseudomonas aeruginosa. Considering the substrate specificity and the results of DNA analysis, amidase from R. rhodochrous M8 was assigned to the group of aliphatic amidases preferentially hydrolyzing short-chain aliphatic amides. The amidase gene was expressed in cells of Escherichia coli from the self promoter and from the lac promoter. To clone a fragment of R. rhodochrous M8 chromosome (approximately 9 kb), containing the entire structural gene and its flanking regions, plasmid pRY1 that can be integrated into the chromosome via homology regions was used. No sequences of the nitrile hydratase gene, the second key gene of nitrile degradation in strain R. rhodochrous M8, were detected. Thus, genes encoding amidase and nitrile hydratase in strain R. rhodochrous M8 are not organized into a single operon despite their common regulation.     

Purification and characterisation of two extremely halotolerant xylanases from a novel halophilic bacterium

The present work reports for the first time the purification and characterisation of two extremely halotolerant endo-xylanases from a novel halophilic bacterium, strain CL8. Purification of the two xylanases, Xyl 1 and 2, was achieved by anion exchange and hydrophobic interaction chromatography. The enzymes had relative molecular masses of 43 kDa and 62 kDa and pI of 5.0 and 3.4 respectively. Stimulation of activity by Ca²⁺, Mn²⁺, Mg²⁺, Ba²⁺, Li²⁺, NaN₃ and isopropanol was observed. The K_m and V_max values determined for Xyl 1 with 4-O-methyl-d-glucuronoxylan are 5 mg/ml and 125,000 nkat/mg respectively. The corresponding values for Xyl 2 were 1 mg/ml and 143,000 nkat/mg protein. Xylobiose and xylotriose were the major end products for both endoxylanases. The xylanases were stable at pH 4–11 showing pH optima around pH 6. Xyl 1 shows maximal activity at 60°C, Xyl 2 at 65°C (at 4 M NaCl). The xylanases showed high temperature stability with half-lives at 60°C of 97 min and 192 min respectively. Both xylanases showed optimal activity at 1 M NaCl, but substantial activity remained for both enzymes at 5 M NaCl.Communicated by W.D. Grant