Detection and characterization of a bacteriocin produced by Lactococcus lactis subsp. cremoris R isolated from radish

Bacteria isolated from radish were identified as Lactococcus lactis subsp. cremoris R and their bacteriocin was designated lactococcin R. Lactococcin R was sensitive to some proteolytic enzymes (proteinase-K, pronase-E, proteases, pepsin, α-chymotrypsin) but was resistant to trypsin, papain, catalase, lysozyme and lipase, organic solvents, or heating at 90 °C for 15, 30 and 60 min, or 121 °C for 15 min. Lactococcin R remained active after storage at −20 and −70 °C for 3 months and after exposure to a pH of 2–9. The molecular weight of lactococcin R was about 2·5 kDa. Lactococcin R was active against many food-borne pathogenic and food spoilage bacteria such as Clostridium, Staphylococcus, Listeria, Bacillus, Micrococcus, Enterococcus, Lactobacillus, Leuconostoc, Streptococcus and Pediococcus spp., but was not active against any Gram-negative bacteria. Lactococcin R was produced during log phase and reached a maximum activity (1600 AU ml⁻¹) at early stationary phase. The highest lactococcin R production was obtained in MRS broth with 0·5% glucose, at 6·5–7·0 initial pH values, 30 °C temperature and 18–24-h incubation times. Lactococcin R adsorbed maximally to its heat-killed producing cells at pH 6–7 (95%). Crude lactococcin R at 1280 AU ml⁻¹ was bactericidal, reducing colony counts of Listeria monocytogenes by 99·98% in 3 h. Lactococcin R should be useful as a biopreservative to prevent growth of food-borne pathogenic and food spoilage bacteria in ready-to-eat, dairy, meat, poultry and other food products. Lactococcin R differs from nisin in having a lower molecular weight, 2·5 kDa vs 3·4 kDa, and in being sensitive to pepsin and α-chymotrypsin to which nisin is resistant.     

The Behaviour of a Food Poisoning Strain of Clostridium welchii in Beef

S ummary : An inoculum of 10⁵ spores of Clostridium welchii F2985/50 in meat survived steaming at 100° for 5 h, the number being reduced sevenfold for every hour of steaming. They also survived for at least 6 months in frozen meat stored at -5° and -20°, whereas vegetative cells died more rapidly at -5° than at -20°. In beef stored for 13 days at 1°, 5°, 10° and 15° there was no multiplication but a slow destruction of vegetative cells, but there was little change in the spore count. Slow multiplication occurred at 20° but at 25° and 37° growth was rapid. Only about 3% of the spores germinated without prior heat shock, so the majority failed to germinate in raw meat stored at any temperature, but did so once the meat had been heated. In meat which had been heated and allowed to cool almost all of the spores had lost their heat resistance.
It was found that the minimal growth temperature was related to pH and medium, so that meat with a pH higher than that used in these experiments (pH 5°7–5°8) would probably have a lower minimal growth temperature for these organisms and would thus be more susceptible to spoilage.     

Factors affecting the production of hydrogen sulphide by Lactobacillus sake L13 growing on vacuum-packaged beef

Lactobacillus sake L13 produced hydrogen sulphide during growth at 0°C on vacuum-packaged beef of normal pH (5·6–5·8) when the packaging films used had oxygen permeabilities as high as 200 ml/m²/24 h/atm (measured at 25°C and 98% relative humidity. No hydrogen sulphide was detected when the film permeability was 300 ml/m²/24 h/atm. Sulphmyoglobin was formed whenever hydrogen sulphide was present except when the film permeability was very low (1 ml of oxygen/m²/24 h/atm). Lactobacillus sake L13 also produced hydrogen sulphide when grown on beef under anaerobic conditions at 5°C. When meat pH was high (6·4–6·6) hydrogen sulphide was first detected after incubation for 9 d. When 250 μg of glucose was added to each g of high pH meat, or when meat pH was normal (5·6–5·8), hydrogen sulphide was first detected after incubation for 18 d. The spoilage of beef by hydrogen sulphide-producing lactobacilli is more rapid when the pH of the meat is high because high-pH meat contains less glucose. Sulphmyoglobin formation and greening can be prevented by the use of packaging films of very low oxygen permeability.     

The combined effect of sub-optimal temperature and sub-optimal pH on growth and toxin formation from spores of Clostridium botulinum

Low-acid foods (pH ≥ 4.5) are not sufficiently acidic to prevent growth of Clostridium botulinum in otherwise optimal conditions. The combination of sub-optimal pH and sub-optimal temperature may, however, result in a very significant reduction in the risk of growth of this bacterium compared with the risk in optimal conditions. The combined effect of incubation temperatures of 12° and 16°C and pH values between 5·2 and 5·5 on growth and toxin production from spores of Cl. botulinum during incubation for 28 d has been investigated. Growth and formation of toxin (type B) were detected only in medium at pH 5·5 and incubated at 16°C, corresponding to a probability of growth from a single spore within 14 d of 1·6 × 10^-5. The probability of growth in 28 d in the remaining conditions was <9 × 10^-6. After transfer of inoculated media from 12° to 30°C growth occurred at pH 5·2–5·5 within 19 d. After transfer of inoculated media from 12° to 20°C growth occurred at pH 5·5 and 5·4 but not at pH 5·3 or 5·2 in 40 d. Growth at pH 5·2–5·5 was accompanied by formation of toxin, in most cases of types A or B. In addition to the effect of sub-optimal temperature and pH, chelation of divalent metal ions by citrate may have contributed to inhibition.     

The Development of Aerobic Spoilage Flora on Meat Stored at Chill Temperatures

In meat juice medium, aerobic spoilage bacteria utilized the following substrates in the order shown: Pseudomonos , glucose, amino acids, lactic acid; Acinetobacter , amino acids, lactic acid: Enterobacter , glucose, glucose-6-phosphate, amino acids; Microbacterium thermosphactum , glucose, glutamate. All the bacteria grew at their maximum rate utilizing the first and second substrates, but the growth rates declined when these were exhausted. The growth rate of Acinetobacter was reduced at pH 5·7 and below. All other species grew at their maximum rate within the pH range 5·5–7·0. On meat pseudomonads grew faster than the other species at all temperatures between 2° and 15°C. Interactions between any two species were observed only when one organism had attained its maximum cell density. Substrate exhaustion at the meat surface did not limit bacterial growth and it is suggested that the maximum cell density of aerobic spoilage cultures is determined by oxygen limitation of growth.     

Effect of Iysozyme concentration, heating at 90°C, and then incubation at chilled temperatures on growth from spores of non-proteolytic Clostridium botulinum

The heat treatment necessary to inactivate spores of non-proteolytic Clostridium botulinum in refrigerated, processed foods may be influenced by the occurrence of lysozyme in these foods. Spores of six strains of non-proteolytic Cl. botulinum were inoculated into tubes of an anaerobic meat medium, to give 10⁶ spores per tube. Hen egg white lysozyme (0–50 μg ml^-1) was added, and the tubes were given a heat treatment equivalent to 19·8 min at 90°C, cooled, and incubated at 8°, 12°, 16° and 25°C for up to 93 d. In the absence of added lysozyme, neither growth nor toxin formation were observed. A 6–D inactivation was therefore achieved. In tubes to which lysozyme (5–50 μg ml^-1) had been added prior to heating, growth and toxin formation were observed. With lysozyme added at 50 μg ml^-1, growth was first observed after 68 d at 8°C, 31 d at 12°C, 24 d at 16°C, and 9 d at 25°C. Thus, in these circumstances, a heat treatment equivalent to 19·8 min at 90°C was not sufficient, on its own, to give a 6–D inactivation. A combination of the heat treatment, maintenance at less than 12°C, and a shelf-life not more than 4 weeks reduced the risk of growth of non-proteolytic Cl. botulinum by a factor of 10⁶.     

Fate of low temperature and acid-adapted Yersinia enterocolitica and Listeria monocytogenes that contaminate lactic acid decontaminated meat during chill storage

Pathogens found in the environment of abattoirs may become adapted to lactic acid used to decontaminate meat. Such organisms are more acid tolerant than non-adapted parents and can contaminate meat after lactic acid decontamination (LAD). The fate of acid-adapted Yersinia enterocolitica and Listeria monocytogenes, inoculated on skin surface of pork bellies 2 h after LAD, was examined during chilled storage. LAD included dipping in 1%, 2% or 5% lactic acid solutions at 55°C for 120 s. LAD brought about sharp reductions in meat surface pH, but these recovered with time after LAD at ≈1–1·5 pH units below that of water-treated controls. Growth permitting pH at 4·8–5·2 was reached after 1% LAD in less than 0·5 d (pH 4·8–5·0), 2% LAD within 1·5 d (pH 4·9–5·1) and after 5% LAD (pH 5·0–5·2) within 4 d. During the lag on 2% LAD meat Y. enterocolitica counts decreased by 0·9 log₁₀ cfu per cm² and on 5% LAD the reduction was more than 1·4 log₁₀ cfu per cm². The reductions in L. monocytogenes were about a third of those in Y. enterocolitica . On 1% LAD the counts of both pathogens did not decrease significantly. The generation times of Y. enterocolitica and L. monocytogenes on 2–5% LAD meats were by up to twofold longer than on water-treated controls and on 1% LAD-treated meat they were similar to those on water-treated controls. Low temperature and acid-adapted L. monocytogenes and Y. enterocolitica that contaminate skin surface after hot 2–5% LAD did not cause an increased health hazard, although the number of Gram-negative spoilage organisms were drastically reduced by hot 2–5% LAD and intrinsic (lactic acid content, pH) conditions were created that may benefit the survival and the growth of acid-adapted organisms.     

Effects of gaseous environment and temperature on the storage behaviour of Listeria monocytogenes on chicken breast meat

Portions of skinless chicken breast meat (pH 5·8) were inoculated with a strain of Listeria monocytogenes and stored at 1, 6 or 15°C in (1) aerobic conditions; (2) 30% CO₂+ air; (3) 30% CO₂+ N₂; and (4) 100% CO₂. When samples were held at 1°C the organism failed to grow under any of the test conditions, despite marked differences between treatments in spoilage rate and ultimate microflora. At 6°C counts of L. monocytogenes increased ca 10-fold in aerobic conditions before spoilage of the meat, but only when the inoculum culture was incubated at 1°C rather than 37°C. In CO₂ atmospheres growth of L. monocytogenes was inhibited on meat held at 6°C, especially under 100% CO₂. By contrast, storage at 15°C led to spoilage of the meat within 2 d, in all gaseous environments, and listeria levels increased up to 100-fold. Differences in the behaviour of L. monocytogenes on poultry and red meats are discussed.     

Effect of salinity and temperature on the growth of yearling Arctic cisco (Coregonus autumnalis) of the Alaskan Beaufort Sea

The growth of 1-year-old Arctic cisco ( Coregonus autumnalis ) was monitored under laboratory conditions for fish acclimated to one of two temperatures (5 and 10° C) and one of five salinities (6, 12, 18,24, 30‰). Fish were maintained for 43 days at rations of 3% wet body weight per day at 5° C and 5% wet body weight per day at 10° C, with rations adjusted for weight gain every 7–12 days. Fish increased 9–11% in length and 55–71% in weight at 5° C, and 23–27% in length and 141–161% in weight at 10° C. Length and weight increased linearly over 43 days. There was a statistically significant effect of temperature on growth but no statistically significant effect of salinity. Higher growth rates at 10° C were partially attributable to significantly greater gross conversion efficiency at the higher temperature. Over the course of the experiment, the condition (weight per unit length) of all fish increased by 3·2 to 63·6% at 5° C and by 5·6 to 46·0% at 10° C. There was no discernible effect of salinity on condition at either temperature. These results demonstrate that, with salinity acclimation and high food ration, 1-year-old Arctic cisco can grow at equivalent rates across salinities ranging from 6 to 30‰. The ecological implications of the results are discussed.     

Incidence and Spoilage Potential of Isolates from Vacuum-packaged Meat of High pH Value

Meat of high pH value (6·6) showing dark-cutting characteristics was vacuum-packaged and stored for up to 8 weeks at 0–2°C. 'Off'-odours were detected on opening the packages after 6 weeks of storage. Total counts at this stage were ca. 10⁷/cm² of which lactobacilli were the major component, with ca. 10⁶/cm² Gram negative organisms. Psychrotrophic Enterobacteriaceae represented a major proportion of the microflora only after the full 8 weeks of storage and were not detected previously. Aerobic storage of steaks cut from the vacuum packaged meat stored for 8 weeks resulted in a predominantly Gram negative spoilage flora.
Inoculation studies on meat of normal pH value (5·4) and appearance using representative isolates from the vacuum-packaged meat microflora indicated that most of the test organisms were capable of causing spoilage under aerobic conditions but few under vacuum-packaging when incubated at 4°C. On meat of higher pH value (6·15) many of the Gram negative isolates did not grow as well, whereas the Gram positive isolates grew better than on meat of normal pH value when held under aerobic conditions. Under vacuum-packaging all but one isolate grew as well or better on meat of high pH value than on normal meat at 4°C and objectionable odours were more marked.     

Effect of pH and NaCl on growth from spores of non-proteolytic Clostridium botulinum at chill temperature

The effect of combinations of temperature (2°, 3°, 4°, 5°, 8° and 10°C), pH (5·0–7·2) and NaCl (0·1–5·0% w/w) on growth from spores of non-proteolytic Clostridium botulinum types B, E and F was determined using a strictly anaerobic medium. Inoculated media were observed weekly for turbidity, and tests were made for the presence of toxin in conditions that approached the limits of growth. Growth and toxin production were detected at 3°C in 5 weeks, at 4°C in 3/4 weeks and at 5°C in 2/3 weeks. The resulting data define growth/no growth boundaries with respect to low temperature, pH, NaCl and incubation time. This is important in assessment of the risk of growth and toxin production by non-proteolytic Cl. botulinum in minimally processed chilled foods.     

Isolation and growth physiology of novel thermoactinomycetes

A total of 34 thermophilic isolates identified as members of the genus Thermoactinomyces by a range of chemotaxonomic, microscopic and determinativebiochemical tests, were isolated from two acid soils. Growth studies in shake flask and fermenteridentified the isolates to be moderately acidophilic with growth occurring between pH4·5 and 6·0 with optima at pH 5·0. The isolates differed considerablyfrom known Thermoactinomyces cultures in their pH profile, colony morphology andin several biochemical tests.Extracellular enzyme activities are identified and partiallycharacterized in termsof their thermostability, pH and temperature profiles from crude supernatantfluid samples. Optimal protease, amylase and pullulanase activity was observed at pH5·0–5·5 and 75–80 °C with each showing T ₍₅₀₎ values of 10, 30 and 30 min, respectively. A highly thermotolerant extracellularesterase was also identified which retained 50% activity after 8 h at 90°C . This is the firstreport of an acidophilic member of the genus Thermoactinomyces.     

Modelling the growth of Weissella cibaria as a function of fermentation conditions

Aims:  To investigate the effect of pH, water activity ( a _w) and temperature on the growth of Weissella cibaria DBPZ1006, a lactic acid bacterium isolated from sourdoughs.
Methods and Results:  The kinetics of growth of W. cibaria DBPZ1006 was investigated during batch fermentations as a function of pH (4·0–8·0), a _w (0·935–0·994) and temperature (10–45°C) in a rich medium. The growth curve parameters (lag time, growth rate and asymptote) were estimated using the dynamic model of Baranyi and Roberts (1994. A dynamic approach to predicting bacterial growth in food. Int J Food Microbiol 23, 277–294). The effect of pH, a _w and temperature on maximum specific growth rate (μ_max) were estimated by fitting a cardinal model. μ_max under optimal conditions (pH = 6·6, a _w = 0·994, T  = 36·3°C) was estimated to be 0·93 h⁻¹. Minimum and maximum estimated pH and temperature for growth were 3·6 and 8·15, and 9·0°C and 47·8°C, respectively, while minimum a _w was 0·918 (equivalent to 12·2% w/v NaCl).
Conclusions:  Weissella cibaria DBPZ1006 is a fast-growing heterofermentative strain, which could be used in a mixed starter culture for making bread.
Significance and Impact of the Study:  This is the first study reporting the modelling of the growth of W. cibaria , a species that is increasingly being used as a starter in sourdough and vegetable fermentations.     

Effects of environmental factors on survival, growth, and production of American shad larvae

Episodic increases in temperature of 5°C above 20° C, over 48 h or declines in pH of 1·0 unit from pH 7·0 reduced survival of yolk-sac and feeding-stage larvae of American shad Alosa sapidissima . Over 16 days all measures of survival, growth, and production were more favourable at each higher temperature in the 15–25° C range. More favourable responses were also obtained at the higher prey level (500 v . 50 Artemia nauplii l^-1) and at the higher pH (7·5 v . 6·5). Combinations of high temperature and high prey levels, at pH 7·5, led to highest larval production. Little growth or production occurred at 15° C, regardless of pH or prey level. The effect of pH was strong with respect to survival, but weak with respect to growth. In attempts to restore American shad populations by larval stocking, release times and sites can be critical to optimize survival and eventual returns. Releases of larvae potentially will be most effective when made at temperatures >20° C, pH>7·0, and prey levels >50 1^-1. These conditions are most likely to occur in Maryland tributaries of Chesapeake Bay between mid-May and early June.     

Isolation of Yersinia enterocolitica-resembling Organisms and Alteromonas putrefaciens from Vacuum-Packed Chilled Beef Cuts

Yersinia enterocolitica -resembling organisms were found at levels of 10⁷/g on a high pH (pH ≧ 6·0) vacuum-packaged beef striploin held for 6 weeks at 0·2°C, but did not exceed 10⁵/g on normal pH (pH < 6·0) striploins held for 10 weeks. Gram negative bacteria that produced H₂S on peptone iron agar were isolated from high pH vacuum packed striploins. These organisms were identified as Alteromonas putrefaciens . They attained levels of about 10⁷/g in 6 weeks at 0–2°C, at which time greening of the fat surface and 'drip'had occurred. On meat of normal pH, counts of A. putrefaciens were less than 10⁴/g after 6 weeks and no greening was evident.     

Production and stability of pediocin N5p in grape juice medium

The production and stability of pediocin N5p from Pediococcus pentosaceus , isolated from wine, were examined in grape juice medium. Maximum growth and higher titre (4000 U ml^-1) were observed at a initial pH of 7·5 and 30°C. The activity of the inhibitory substance was stable between pH values from 2·0 to 5·0 at 4° and 30°C. At pH 10·0 it was completely inactivated. When submitted to 30 min at 80°, 100° and 115°C, maximal stability was observed at pH 2·0. Ethanol up to 10% did not affect pediocin activity at acid pH, nor did 40–80 mg 1^-1 SO₂, independently or combined with different ethanol concentrations, affect inhibitory activity.     

Influence of different rations and water temperatures on the growth rates of shortfinned eels and longfinned eels

Juvenile (12–152 g) shortfinned eels Anguilla australis and longfinned eels A. dieffenbachia caught in New Zealand streams were fed squid mantle Nototodarus spp. 4 days per week in laboratory experiments. A linear multiple regression equation showed the amount of food eaten (0–2·7% w day⁻¹) explained 77·7% of the variation in specific growth rates (–0·60 to +1·07% w day⁻¹) among individual eels, while previous growth rates, water temperature (10·0–20·6°C), and eel weight (12–152 g) explained a further 5·6, 1·4 and 0·8%, respectively. Growth in length ranged from –0·3 to +0·9 mm day⁻¹. Eels which were starved and then given high rations grew substantially faster than expected. Once growth rates were adjusted for differences in ration and other factors, there were no significant differences in growth rates between species or individual fish. Growth of shortfinned eels fed maximum rations of commercial eel food depended on fish size and water temperatures and ceased below 9·0°C. Growth rates in the wild were substantially less than the maximum possible, after seasonal changes in water temperatures were taken into account, indicating that food supplies and not low water temperatures were controlling growth rates in the wild.     

Proteolytic activity from a thermophilic Streptomyces megasporus strain SDP4

Multiple proteases secreted by a thermophilic actinomycete Streptomyces megasporus SDP4 after 18 h of growth at 55 °C are reported. The enzyme preparation exhibited activity over a broad pH and temperature range of pH 6–12 and 25–85 °C, respectively. Optimum activity was observed at pH 8·0, pH 10·0 and 55 °C and was calcium independent. Thermostability was enhanced in the presence of 0·01 mol l⁻¹ calcium ions and half-life was 30 min at 85 °C. The enzyme was active in the presence of SDS. Both, EDTA and PMSF were partially inhibitory, indicating the presence of serine and metal requiring proteases. Three active zones in the range of 90–30 kDa were detected post-electrophoretically.     

Effects of essential oil from mint (Mentha piperita) on Salmonella enteritidis and Listeria monocytogenes in model food systems at 4° and 10°C

The effect of mint ( Mentha piperita ) essential oil (0·5, 1·0, 1·5 and 2·0%, v/w) on Salmonella enteritidis and Listeria monocytogenes in a culture medium and three model foods; tzatziki (pH 4·5), taramosalata (pH 5·0) and pâté (pH 6·8), inoculated at 10⁷ cfu g^-1, at 4° and 10°C for ca 1 week was studied. In the culture medium supplemented with the essential oil, no growth was observed over 2 d at 30°C determined by a conductance method with a Malthus 2000 growth analyser. Salmonella enteritidis died in tzatziki in all treatments and declined in the other foods except for pâté at 10°C as judged with viable counts. Listeria monocytogenes populations showed a declining trend towards the end of the storage period but was increased in pâté. Mint essential oil antibacterial action depended mainly on its concentration, food pH, composition, storage temperature and the nature of the micro-organism.     

Purification and characterization of thermophilin T, a novel bacteriocin produced by Streptococcus thermophilus ACA-DC 0040

ACA-DC 0040 produced an antimicrobial agent, which was named thermophilin T, active against several lactic acid bacteria strains of different species and food spoilage bacteria, such as Clostridium sporogenes C22/10 and Cl. tyrobutyricum NCDO-1754. The crude antimicrobial compound is sensitive to proteolytic enzymes and α-amylase, heat-stable (100 °C for 30 min), resistant to pH exposure at pH 1–12 and demonstrates a bactericidal mode of action against the sensitive strain Lactococcus cremoris CNRZ-117. The production of bacteriocin was optimized approximately 10-fold in an aerobic fermenter held at constant pH 5·8 and 6·2. Ultrafiltration experiments with culture supernatant fluids containing the bacteriocin, and further estimation of molecular weight with gel filtration chromatography, revealed that bacteriocin in the native form has a molecular weight in excess of 300 kDa. SDS-gel electrophoresis of partially purified thermophilin T showed that bacteriocin activity was associated with a protein band of approximately 2·5 kDa molecular mass.