Chemical manipulation of the heat resistance of Clostridium botulinum spores.

The chemical forms of Clostridium botulinum 62A and 213B were prepared, and their heat resistances were determined in several heating media, including some low-acid foods. The heat resistance of C. botulinum spores can be manipulated up and down by changing chemical forms between the resistant calcium form and the sensitive hydrogen form. The resistant chemical form of type B spores has about three times the classical PO4 resistance at 235 F (112.8 C). As measured in peas and asparagus, both types of C. botulinum spores came directly from the culture at only a small fraction of the potential heat resistance shown by the same spores when chemically converted to the resistant form. The resistant spore form of both types (62A and 213B), when present in a low-acid food, can be sensitized to heating at the normal pH of the food.     

Influence of postirradiation incubation temperature on recovery of radiation-injured Clostridium botulinum 62A spores.

The number of colonies formed by unirradiated Clostridium botulinum 62A spores was independent of temperature, in the range from 20 to 45 degrees C (in 5 degrees C increments); no colonies developed at 50 degrees C. Spores irradiated at 1.2 or 1.4 Mrads produced more macrocolonies at 40 degrees C than at higher or lower temperatures. Apparently, radiation-injured spores were capable of repair of 40 degrees C than at the other temperatures studied. More than 99% of the radiation (1.2 Mrads) survivors were injured and were unable to form macrocolonies in the presence of 5% NaCl. The germinated radiation-injured spores were also sensitive to dilution, resulting in the loss of viability of 77 to 79% of the radiation survivors. At 30 and 40 degrees C, the irradiated spores did not differ significantly in the extent of germination (greater than 99% at both 30 and 40 degrees C), emergence (64% at 30 degrees C and 67% at 40 degrees C), and the maximum number of emerged cells that started to elongate (69% at 30 degrees C and 79% at 40 degrees C). However, elongation was remarkably more extensive at 40 degrees C than at 30 degrees C. Many elongated cells lysed within 48 h at 30 degrees C, indicating an impaired repair mechanism. If the radiation-injured spores were incubated at 40 degrees C in the recovery (repair) medium for 8 to 10 h, they germinated, emerged, and elongated extensively and were capable of repair. If, after 8 to 10 h at 40 degrees C, these cultures were shifted to 30 degrees C, the recovery at 30 increased by more than eightfold, resulting in similar colony counts at 30 and 40 degrees C. Thus, repair appeared to be associated with outgrowth. Repair did not occur in the presence of chloramphenicol at 40 degrees C, whereas penicillin had no effect, suggesting that the repair involved protein synthesis but did not require multiplication.     

Heat resistance of Clostridium sordellii spores

The thermal destruction kinetics of Clostridium sordellii spores was studied in this research. Decimal reduction times (D values) for C. sordellii ATCC 9714 spores ranged between 175.60 min for D₈₀ (the D value for spore suspensions treated at 80 °C) and 11.22 min for D₉₅. The thermal resistance (Z) and temperature coefficient (Q₁₀) values of spores were calculated to be as high as 12.59 °C and 6.23, respectively. At 95 °C, the relative thermal death rate and relative thermal death time of C. sordellii ATCC 9714 spores were found to be 0.0085/min and 118 min, respectively, indicating that the death rate of spores was 118 times lower at 95 °C than at 121.1 °C. Heat treatments at up to 85 °C for 120 min failed to cause a 100-fold destruction in spore populations of C. sordellii ATCC 9714. By contrast, spore counts were reduced by 2log₁₀ cycles within 73 min and 23 min at 90 °C and 95 °C, respectively. This is the first published report of thermal inactivation of C. sordellii spores; however, further studies are needed to confirm these results in real food samples.     

The effect of temperature on the germination of single spores of Clostridium botulinum 62A

Phase-contrast microscopy coupled with image analysis has been used to study the germination of single spores of Clostridium botulinum and to investigate the variation of germination lag of individual spores in a population (biovariability). The experiment was repeated at five different temperatures between 20°C and 37°C to look at the effect of temperature on the biovariability of the spore germination. Data analysis shows that the germination lag distribution is skewed, with a tail, and that its shape is affected by the temperature. The origin of this biovariability is not exactly known, but could be due to a distribution of characteristics (e.g. permeabilities) or molecules (e.g. lytic enzymes) in the spore population. The method developed in this study will help us to describe and better understand the kinetics of spore germination and how this is influenced by different environmental factors such as temperature and other factors that influence germination.     

Inhibition of Clostridium botulinum 62A by fumarates and maleates and relationship of activity to some physicochemical constants.

A series of n-monoalkyl maleates and n-mono-, di-, and methyl n-alkyl fumarates were prepared, 18 esters of each, with R = CH3 to C18H37. Their activity against Clostridium botulinum was determined in culture medium. The n-monoalkyl maleates and fumarates possessed significant activity, particularly those esterified with higher C13 to C18 alcohols. Somewhat lower activity was exhibited by methyl n-alkyl fumarates, while symmetrical esters, di-n-alkyl fumarates, were almost inactive. An attempt was made to correlate the activity of n-monoalkyl maleates and fumarates with chain length, solubility in water, apparent dissociation constant (pKa'), and infrared and UV absorption frequencies. The active esters may have potential as preservatives in foods.     

Hypochlorite injury of Clostridium botulinum spores alters germination responses.

Clostridium botulinum spores were sublethally damaged by exposure to 12 or 28 micrograms of available chlorine per ml for 2 min at 25 degrees C and pH 7.0. The damaging dose was 2.7 x 10(-6) to 3.1 x 10(-6) micrograms of available chlorine per spore. Damage was manifested by a consistent 1.6 to 2.4 log difference between the most probable number enumeration of spores (modified peptone colloid medium) and the colony count (modified peptone yeast extract glucose agar); this did not occur with control spores. Damaged spores could be enumerated by the colony count procedure. Germination responses were measured in several defined and nondefined media. Hypochlorite treatment altered the rate and extent of germination in some of the media. Calcium lactate (9 mM) permitted L-alanine (4.5 mM) germination of hypochlorite-treated spores in a medium containing 12 or 55 mM sodium bicarbonate, 0.8 mM sodium thiosulfate, and 100 mM Tris-hydrochloride (pH 7.0) buffer. Tryptose inhibited L-alanine germination of the spores. Treatments with hypochlorite and with hydrogen peroxide (7%, 25 degrees C, 2 min) caused similar enumeration and germination responses, indicating that the effect was due to a general oxidation phenomenon.     

Mechanism of chemical manipulation of the heat resistance of Clostridium perfringens spores

The mechanism(s) of chemical manipulation of the heat resistance of Clostridium perfringens type A spores was studied. Spores were converted to various ionic forms by base-exchange technique and these spores were heated at 95°C. Of the four ionic forms, i.e. Ca²⁺, Na⁺, H⁺ and native, only hydrogen spores appeared to have been rapidly inactivated at this temperature, when survivors were enumerated on the ordinary plating medium. However, the recovery of the survivors was improved when the plating medium was supplemented with lysozyme, and more dramatically when the heated spores were pretreated with alkali followed by plating in the medium containing lysozyme. In contrast to crucial damage to germination, in particular to spore lytic enzyme, no appreciable amount of DPA was released from the heat-damaged H-spores. These results suggest that a germination system is involved in the thermal inactivation of the ionic forms of spores, and that exchangeable cation load plays a role in protection from thermal damage of the germination system within the spore. An enhancement of thermal stability of spore lytic enzyme in the presence of a high concentration of NaCl was consistent with the hypothesis.     

Comparative dose-survival curves of representative Clostridium botulinum type F spores with type A and B spores.

Radiation survival data of proteolytic (Walls 8G-F) and non-proteolytic (Eklund 83F) type F spores of Clostridium botulinum were compared with dose-response data of radiation-resistant type A (33A) and B (40B) spores. Strain Eklund 83F was as resistant as strain 33A, whereas strain Walls 8G-F was the most sensitive of the four strains tested. The methods suggested for computing both an initial shoulder and a D value for the dose-survival curves yielded results comparable to the graphic techniques used to obtain these two parameters.     

Comparative dose-survival curves of representative Clostridium botulinum type F spores with type A and B spores.

Radiation survival data of proteolytic (Walls 8G-F) and non-proteolytic (Eklund 83F) type F spores of Clostridium botulinum were compared with dose-response data of radiation-resistant type A (33A) and B (40B) spores. Strain Eklund 83F was as resistant as strain 33A, whereas strain Walls 8G-F was the most sensitive of the four strains tested. The methods suggested for computing both an initial shoulder and a D value for the dose-survival curves yielded results comparable to the graphic techniques used to obtain these two parameters.     

Inhibition of Clostridium botulinum 62A by fumarates and maleates and relationship of activity to some physicochemical constants

A series of n-monoalkyl maleates and n-mono-, di-, and methyl n-alkyl fumarates were prepared, 18 esters of each, with R = CH3 to C18H37. Their activity against Clostridium botulinum was determined in culture medium. The n-monoalkyl maleates and fumarates possessed significant activity, particularly those esterified with higher C13 to C18 alcohols. Somewhat lower activity was exhibited by methyl n-alkyl fumarates, while symmetrical esters, di-n-alkyl fumarates, were almost inactive. An attempt was made to correlate the activity of n-monoalkyl maleates and fumarates with chain length, solubility in water, apparent dissociation constant (pKa'), and infrared and UV absorption frequencies. The active esters may have potential as preservatives in foods.     

Germination of spores from Clostridium botulinum B-aphis and Ba410.

The germination of spores from Clostridium botulinum B-aphis and Ba410 was examined. In a complex medium, heat activation of spores from both strains doubled the germination rates and was required for germination in the presence of 2% NaCl. In a defined medium (CTB [D. B. Rowley and F. Feeherry, J. Bacteriol. 104:1151-1157, 1970]), the parent strain B-aphis germinated at a rate of 0.77% min-1 in the absence of NaCl and was not affected by 2% NaCl. A salt-tolerant derivative, strain Ba410, germinated at rates of 0.16% min-1 in CTB and 0.04% min-1 in CTB containing 2% NaCl. L-Alanine-triggered spores germinated faster than did L-cysteine-triggered spores from both strains. When both amino acids were present, B-aphis germinated rapidly in the absence of NaCl and had biphasic kinetics in the presence of NaCl. Strain Ba410 had biphasic kinetics in the absence of NaCl and germinated slowly with single-phase kinetics in the presence of NaCl. L-Alanine- and L-cysteine-triggered germinations were each inhibited by both D-alanine and D-cysteine, indicating a common germinant-binding site for both alanine and cysteine. Attempts to select for variants with amino acid-specific germinant-binding sites were unsuccessful. Differences in the germination kinetics of both strains could not be explained by ultrastructural differences. Transmission electron micrographs revealed striking similarities between the strains.     

Influence of transition metals added during sporulation on heat resistance of Clostridium botulinum 113B spores.

Sporulation of Clostridium botulinum 113B in a complex medium supplemented with certain transition metals (Fe, Mn, Cu, or Zn) at 0.01 to 1.0 mM gave spores that were increased two to sevenfold in their contents of the added metals. The contents of calcium, magnesium, and other metals in the purified spores were relatively unchanged. Inclusion of sodium citrate (3 g/liter) in the medium enhanced metal accumulation and gave consistency in the transition metal contents of independent spore crops. In citrate-supplemented media, C. botulinum formed spores with very high contents of Zn (approximately 1% of the dry weight). Spores containing an increased content of Fe (0.1 to 0.2%) were more susceptible to thermal killing than were native spores or spores containing increased Zn or Mn. The spores formed with added Fe or Cu also appeared less able to repair heat-induced injuries than the spores with added Mn or Zn. Fe-increased spores appeared to germinate and outgrow at a higher frequency than did native and Mn-increased spores. This study shows that C. botulinum spores can be sensitized to increased thermal destruction by incorporation of Fe in the spores.     

Interaction of pH and NaCl on culture density of Clostridium botulinum 62A.

Clostridium botulinum 62A growth rates declined with decreasing pH and increasing salt levels. Lysis rates, however, were affected only by pH. Due to competition between growth and lysis rates, an accurate assessment of interactive effects was obtained only when optical density determinations were made at multiple intervals.     

Proposed role of lactate in germination of hypochlorite-treated Clostridium botulinum spores.

Clostridium botulinum 12885A spores treated with hypochlorite required added DL-calcium lactate for L-alanine germination. Lactate was the active component of calcium lactate. Equimolar concentrations of L-malate, but not of DL-propionate, could replace lactate, suggesting that the alpha-hydroxy acid structure is important. Neither lactate nor malate was an effective germinant for buffer-treated or hypochlorite-treated spores. If the L-alanine concentration was increased 100-fold (to 450 mM), the lactate germination requirement was overcome. The data suggest that the L-alanine germination sites were modified by hypochlorite so that a higher concentration of alanine was required for activity. Lactate appeared to be an activator of modified or non-hypochlorite-modified L-alanine germination sites.     

Proposed mechanism for sensitization by hypochlorite treatment of Clostridium botulinum spores.

Hypochlorite-treated Clostridium botulinum 12885A spores, but not buffer-treated spores, could be germinated with lysozyme, indicating that their coats are made permeable to lysozyme by hypochlorite treatment so that the cortex is accessible. Hypochlorite-treated spores and spores extracted with 8 M urea-2-mercaptoethanol (pH 3.0) were sensitive to certain components of recovery media, but spores sensitized to lysozyme by other treatments were not. These data indicate that hypochlorite does more than increase coat permeability to lysozyme. Scanning electron microscopy revealed a more open-appearing surface of hypochlorite-treated spores, and sodium dodecyl sulfate-polyacrylamide gel electrophoresis indicated that a greater amount of protein was removed from hypochlorite-treated and other lysozyme-sensitized spores than from buffer-treated spores. The data suggest that spore coat proteins may be removed by hypochlorite treatment, and this may be responsible for the sensitivity of spores and for their observed ability to germinate in lysozyme.