Enhanced production of human monoclonal antibodies by the use of fructose in serum-free hybridoma culture media

It was found that the production of human monoclonal antibodies (MoAbs) by human-human hybridomas can be significantly enhanced by replacing glucose with fructose in the dish culture medium. Optimization of initial concentrations of fructose and glutamine, another influencing factor for MoAb production, enabled an enhanced production of human MoAb 2.1 times higher than that obtained using the conventional culture media employing glucose. It was shown by kinetic analysis that enhanced MoAb production at the optimum fructose concentration can be attributed to the retention of high specific antibody production rates and diminished time lag during the course of culture.These dish culture results with fructose-containing medium were successfully applied to the continuous perfusion culture with a slight modification, where 2.9- and 1.9-fold enhancements in specific antibody production rate and MoAb concentration, respectively, were attained as compared with the conventional glucose-containing medium.An inverse relationship was observed between the secreted concentrations of lactic acid and MoAb when the hybridoma was cultured in the media containing varying concentrations of fructose, i.e., the lower the lactic acid concentration, the higher the MoAb production andvice versa, suggesting that fructose at appropriate concentrations in the medium can serve as an alternative sugar for the efficient production of human MoAbs, with reduced pH shifts, for the serum-free culture of human-human hybridomas.     

Effects of carbohydrates and nitrogen on the development of anthocyanins of a red leaf peach (Prunus persica (L.) Batsch) in vitro

Heterozygous red leaf peach (Prunus persica (L.) Batsch) shoots were implanted on media with varying nitrogen and carbohydrate regimes to identify a combination which elicited maximum anthocyanin production in explants. A medium with relatively low nitrogen (5 mM NH₄₊ and 10 mM NO_3-) and high sucrose (234 mM) was most effective in stimulating anthocyanin production. Sucrose was more effective as a carbon source than glucose, fructose, or starch under given nitrogen levels. The major anthocyanin in red leaf peach was tentatively identified as cyanidin 3-glucoside based on PC and HPLC analysis.     

The Growth of Acer pseudoplatanus Cells in a Synthetic Liquid Medium: Response to the Carbohydrate, Nitrogenous and Growth Hormone Constituents

A synthetic culture medium which supports a high level of growth of a scrially propagated cell suspension culture of Acer pseudoplatanus is described. The sucrose of this medium can be effectively replaced by glucose or fructose or a mixture of glucose and fructose or galactose or maltose or soluble starch. When the carbohydrate is glucose or fructose no other sugars appear in the culture medium in significant amounts. Glucose is absorbed in greater quantity than fructose from an equimolar mixture of these sugars. When sucrose is supplied both glucose and fructose appear in the medium. Glucose appears in maltose medium, and maltose and glucose in soluble starch medium. Under the standard conditions of culture, media containing 2 % sucrose or 2 % glucose become depleted of sugar before the 25th day of incubation. Enhanced yield of the cultures can be obtained by raising the initial sucrose concentration to 6 %. – A supply of nitrate is essential for maximum yield and healthy growth. Growth, in the presence of nitrate, is significantly enhanced by a supply of urea. Addition of casein hydrolysate or of a mixture of amino acids enhances growth in the presence of nitrate and urea and particularly when nitrate is omitted. – When kinetin is omitted or incorporated at the standard level (0.25 mg/I), 2,4-dichlorophenoxyacetic acid (2,4-D) at 1.0 mg/l is essential for continuation of growth at a high level. It cannot be replaced by indol-3yl-acetic acid (IAA). 1-naphthaleneacetic acid (NAA) at 10 mg/l permits of a low level of growth with abnormal aggregation. When the level of kinetin is raised to 10 mg/l a high level of growth occurs in the absence of added auxin but the cultures become brown and tend to show increasing aggregation on subculture.     

米贝链霉菌DSM41911的米尔贝霉素生物合成的初步研究

对米贝链霉菌DSM41911进行初步研究,通过对16S rRNA及相关功能基因序列进行生物信息学分析,表明米贝链霉菌DSM41911与冰城链霉菌具有较高同源性。设计16种固体和液体培养基对菌株的发酵条件进行筛选,在MB4、MB6培养基中成功检测到milbemycin B5、milbemycin E、milbemycin VM44864和milbemycin B1。参考近似菌株冰城链霉菌的合成基因并结合文献推测出米尔贝霉素在米贝链霉菌DSM41911中的合成途径,为后续高产菌株的筛选提供参考。     

Influence of fructose and glucose on the production of exopolysaccharides and the activities of enzymes involved in the sugar metabolism and the synthesis of sugar nucleotides in Lactobacillus delbrueckii subsp. bulgaricus NCFB 2772

 The effect of fructose and glucose on the growth, production of exopolysaccharides and the activities of enzymes involved in the synthesis of sugar nucleotides in Lactobacillus delbrueckii subsp. bulgaricus grown in continuous culture was investigated. When grown on fructose, the strain produced 25 mg l^-1 exopolysaccharide composed of glucose and galactose in the ratio 1:2.4. When the carbohydrate source was switched to a mixture of fructose and glucose, the exopolysaccharide production increased to 80 mg l^-1, while the sugar composition of the exopolysaccharide changed to glucose, galactose and rhamnose in a ratio of 1:7.0:0.8. A switch to glucose as the sole carbohydrate source had no further effect. Analysis of the enzymes involved in the synthesis of sugar nucleotides indicates that in cell-free extracts of glucose-grown cells the activity of UDP-glucose pyrophosphorylase was higher than that in cell-free extracts of fructose-grown cells. The activities of dTDP-glucose pyrophosphorylase and the rhamnose synthetic enzyme system were very low in glucose-grown cultures but could not be detected in fructose-grown cultures. Cells grown on a mixture of fructose and glucose showed similar enzyme activities as cells grown on glucose. Analysis of the intracellular level of sugar nucleotides in glucose-grown cultures of L. delbrueckii subsp. bulgaricus showed the presence of UDP-glucose and UDP-galactose in a ratio of 3.3:1, respectively, a similar ratio and slightly lower concentrations were found in fructose-grown cultures. The lower production of exopolysaccharides in cultures grown on fructose may be caused by the more complex pathway involved in the synthesis of sugar nucleotides. The absence of activities of enzymes leading to the synthesis of rhamnose nucleotides in fructose-grown cultures appeared to result in the absence of rhamnose monomer in the exopolysaccharides produced on fructose. Received: 1 February 1996/Received revision: 31 May 1996/Accepted: 2 June 1996     

Analysis of carbohydrate metabolism enzymes and cellular contents of sugars and proteins during spruce somatic embryogenesis suggests a regulatory role of exogenous sucrose in embryo development.

Carbohydrate metabolism was investigated during spruce somatic embryogenesis. During the period of maintenance corresponding to the active phase of embryogenic tissue growth, activities of soluble acid invertase and alkaline invertase increased together with cellular glucose and fructose levels. During the same time, sucrose phosphate synthase (SPS) activity increased while sucrose synthase (SuSy) activity stayed constant together with the cellular sucrose level. Therefore, during maintenance, invertases were thought to generate the hexoses necessary for embryogenic tissue growth while SuSy and SPS would allow cellular sucrose to be kept at a constant level. During maturation on sucrose-containing medium, SuSy and SPS activities stayed constant whereas invertase activities were high during the early stage of maturation before declining markedly from the second to the fifth week. This decrease of invertase activities resulted in a decreased hexose:sucrose ratio accompanied by starch and protein deposition. Additionally, carbohydrate metabolism was strongly modified when sucrose in the maturation medium was replaced by equimolar concentrations of glucose and fructose. Essentially, during the first 2 weeks, invertase activities were low in tissues growing on hexose-containing medium while cellular glucose and fructose levels increased. During the same period, SuSy activity increased while the SPS activity stayed constant together with the cellular sucrose level. This metabolism reorganization on hexose-containing medium affected cellular protein and starch levels resulting in a decrease of embryo number and quality. These results provide new knowledge on carbohydrate metabolism during spruce somatic embryogenesis and suggest a regulatory role of exogenous sucrose in embryo development.     

Effect of the cultivation conditions on alkaloid biosynthesis by Penicillium gorlenkoanum

The effect of a carbohydrate component of the medium, trace elements and aeration on biosynthesis of the alkaloids costaclavine and epicostaclavine was studied with Penicillium gorlenkoanum. Alkaloid biosynthesis was shown to depend on the nature of a carbohydrate component: virtually no alkaloids were accumulated in media with glucose and fructose although these were synthesized at a high rate in a medium with mannitol. The quantity of synthesized alkaloids and the dynamics of the biosynthesis depended on carbohydrate concentration. The growth and alkaloid synthesis were influenced by traces of zinc, iron, copper and manganese. A more intensive aeration stimulated biomass accumulation but suppressed alkaloid biosynthesis.     

Enhancement and Cultural Characteristics of Leucomycin Production by Streptomyces kitasatoensis in the Presence of Magnesium Phosphate

Stimulation of leucomycin production with Streptomyces kitasatoensis by magnesium phosphate (MgP), and a concomitant decrease of ammonium ion concentration in the culture supernatant have been reported from this laboratory. Cultural characteristics of the MgP-supplemented culture were further examined in relation to the stimulation of leucomycin production. When the leucomycin titer increased 4- to 5-fold in the presence of MgP, mycelial growth level and assimilation rate of a major carbon source (glycerol) increased about 2-fold. MgP-grown mycelia were not appreciably different in shape or in carbon and nitrogen contents from the control mycelia. Magnesium and phosphate ions were released from MgP into the medium, while the addition of magnesium or phosphate salts to the control medium was rather inhibitory for leucomycin production. The pH values of MgP-supplemented cultures were lower than those of the control culture. When modifications of the basal media and culture conditions were done so as to permit the pH-change almost identical with that of the control media, the leucomycin titer was still higher in the presence of MgP than in its absence. When uric acid, an insoluble compound, was used as the sole nitrogen source, the leucomycin production increased to a high level even in the absence of MgP, which was comparable to that seen when MgP was added to the ammonium lactate-containing medium. The ammonium ion concentration in the culture supernatant of the uric acid-containing medium was maintained at a considerably low level. While in the ammonium lactate-containing medium, leucomycin production was low and ammonium ion concentration remained at a high level. Thus, it was demonstrated that the stimulation of leucomycin production by MgP is related to the lowering of ammonium ion level, but not to the other factors examined such as growth level, carbon or phosphate regulation and pH-effect.     

金微菌的生理与金微素的生产Ⅲ.磷酸盐对于金微菌的醣的利用和金微素综合的影响

金霉菌 Streptomyces aureofaciens 菌株 A3能利用淀粉、葡萄糖、蔗糖、果糖为碳源,但不能利用麦芽糖、乳糖、甘露糖和山梨糖。培养基中磷酸盐浓度的增加,促进菌体对醣类的氧化和抑止金霉素的产量。一般而论磷酸盐促使淀粉或葡萄糖的氧化较大,同时亦以这二种醣类进行酦酵时,磷酸盐抑止金霉素的产量比较显著。磷酸盐对金霉素产量的影响,除因利用不同醣类酦酵而不同外,培养基的组合成分特别是有机碳氮源的含量和比率起着首要的作用。     

Mutagenesis of echinocandin B overproducing Aspergillus nidulans capable of using starch as main carbon source

Abstract

Echinocandin B, a kind of antimycotic with cyclic lipo-hexapeptides, was produced by fermentation with Aspergillus nidulans using fructose as main carbon source. The objective of this study was to screen a high-yield mutant capable of using cheap starch as main carbon source by atmospheric and room temperature plasma (ARTP) treatment in order to decrease the production cost of echinocandin B. A stable mutant A. nidulans ZJB19033, which can use starch as optimal carbon source instead of expensive fructose, was selected from two thousands isolates after several cycles of ARTP mutagenesis. To further increase the production of echinocandin B, the optimization of fermentation medium was performed by response surface methodology (RSM), employing Plackett-Burman design (PBD) followed by Box-Behnken design (BBD). The optimized fermentation medium provided the optimal yield of echinocandin B, 2425.9?±?43.8?mg/L, 1.3-fold compared to unoptimized medium. The results indicated that the mutant could achieve high echinocandin B production using cheap starch as main carbon source, and the cost of carbon sources in fermentation medium reduced dramatically by about 45%.     

Activation of pyrophosphate:fructose-6-phosphate 1-phosphotransferase by fructose 2,6-bisphosphate stimulates conversion of hexose phosphates to triose phosphates but does not influence accumulation of carbohydrates in phosphate-deficient tobacco cells

The aim of this work was to investigate the contribution of fructose 2,6-bisphosphate to the regulation of carbohydrate metabolism under phosphate stress. The study exploited heterotrophic tobacco callus lines expressing a modified mammalian 6-phosphofructo-2-kinase/fructose 2,6-bisphosphatase that increased the fructose 2,6-bisphosphate content of the tissue. The phosphate status of two transgenic and one untransformed cell line was perturbed by incubation with 2-deoxyglucose, a phosphate-sequestering agent, and by growth of callus on phosphate-depleted media. 31P-NMR spectroscopy confirmed that both treatments decreased cellular levels of inorganic phosphate and phosphorylated metabolites. Despite large decreases in the amounts of phosphate esters, UDPglucose and adenylates in response to phosphate deficiency, the fructose 2,6-bisphosphate content of each line was unaffected by 2-deoxyglucose and increased during growth on phosphate-limited media. Short-term treatment of callus with 2-deoxyglucose had only minor effects on the carbohydrate status of each line, whereas long-term phosphate deficiency caused an increase in starch and a decrease in soluble sugar content in both transgenic and control lines. There were no consistent differences between the three callus lines in metabolism of [U-14C]glucose in response to incubation with 2-deoxyglucose. In contrast, there was a decrease in partitioning of label into glycolytic products (particularly organic acids) in untransformed callus during growth on phosphate-depleted medium. This decrease was greatly attenuated in the transgenic lines with increased fructose 2,6-bisphosphate content. This suggests that the conversion of hexose phosphates to triose phosphates is constrained under phosphate-deficient conditions, and that this restriction can be relieved by activation of pyrophosphate:fructose-6-phosphate 1-phosphotransferase. However, since the transgenic and control lines did not differ in the extent to which the carbohydrate content changed in response to growth on phosphate-depleted media, it is concluded that an increase in flux through pyrophosphate:fructose-6-phosphate 1-phosphotransferase is not a major component of the metabolic response of heterotrophic tobacco cells to phosphate deficiency.     

Staphylococcus aureus growth and type 5 capsular polysaccharide production in synthetic media

The production of type 5 capsular polysaccharide by Staphylococcus aureus in synthetic media was investigated. The influence of medium components on capsular polysaccharide synthesis appeared to relate to the presence or absence of the component rather than to concentration gradient. The production of type 5 capsular polysaccharide was linked to energy availability and energy source, but not to carbohydrate concentration or carbon/nitrogen ratio. Regulation of capsular polysaccharide production by S. aureus in response to medium changes would appear to differ from that typically displayed in other organisms that produce polysaccharides.     

Staphylococcus aureus growth and type 5 capsular polysaccharide production in synthetic media.

The production of type 5 capsular polysaccharide by Staphylococcus aureus in synthetic media was investigated. The influence of medium components on capsular polysaccharide synthesis appeared to relate to the presence or absence of the component rather than to concentration gradient. The production of type 5 capsular polysaccharide was linked to energy availability and energy source, but not to carbohydrate concentration or carbon/nitrogen ratio. Regulation of capsular polysaccharide production by S. aureus in response to medium changes would appear to differ from that typically displayed in other organisms that produce polysaccharides.     

Conversion of starch into ethanol by Clostridium thermohydrosulfuricum

Summary Production of ethanol from starch by Clostridium thermohydrosulfuricum was compared with that from glucose, fructose or maltose in batch fermentations. Optimal substrate concentration and pH for ethanol production were determined. The rate of ethanol production on starch was about the same as that on glucose or fructose and overall yields were also similar (about 1.6 mol ethanol per mol glucose or glucose equivalent). Maltose was not an effective substrate for growth and ethanol production.When a mixture of starch and glucose in equal amounts was used, breakdown of starch and utilization of glucose were simultaneous. When starch and fructose were supplied together, the fructose was utilized but no hydrolysis of starch was observed. With a mixture of glucose and fructose, uptake of fructose preceeded that of glucose.     

Influence of carbon source on growth and mycotoxin production by isolates of Pyrenophora tritici-repentis from wheat

The fungus Pyrenophora tritici-repentis can infect wheat kernels, causing red smudge, and has been shown to produce the anthraquinone mycotoxins emodin, catenarin, and islandicin. The growth of 8 fungal isolates from diverse regions was evaluated on various culture media and was found to be generally slowest on the semisynthetic Fries medium. The choice of carbon source had a significant effect on mycotoxin production, as assessed by high-performance liquid chromatography. The highest emodin concentration (194.18 ± 16.26 μg/g medium) was observed for isolate Alg 3-24 on Fries medium supplemented with fructose, while the highest catenarin concentration (302.54 ±13.92 μg/g medium) was observed for TS93-71B on Fries medium supplemented with starch. Islandicin was not produced by any isolate under the conditions tested. Evaluation of the dynamics of mycotoxin production by isolate 331-2 on V8-potato dextrose agar medium revealed a rapid accumulation of emodin and catenarin during the first week of incubation, followed by a large decline by 14 days. Differences in the growth of and mycotoxin production by isolates of P. tritici-repentis likely resulted from the differential composition of the media and (or) intraspecies variability. Accordingly, the optimization of growth medium should be considered when evaluating the potential of specific isolates for mycotoxin production.     

The role of sucrose during maturation of black spruce (Picea mariana) and white spruce (Picea glauca) somatic embryos

The present study was conducted to understand the role of sucrose in the medium on the maturation of black spruce and white spruce somatic embryos. A maturation medium containing 6% sucrose, which hydrolyzed into glucose and fructose, gave significantly more embryos than a medium containing 3.16% of each glucose and fructose. Preventing the complete sucrose hydrolysis by a daily transfer of the tissues onto fresh medium significantly decreased the yield of somatic embryos compared to when sucrose was allowed to complete its hydrolysis. This reduction was not due to the manipulation of the tissues during the transfer, since a daily in situ transfer did not affect embryo production. To verify if the better embryo production observed on a medium containing 6% sucrose was due to the increasing osmotic pressure of the medium, this increasing osmotic pressure was simulated with a sequence of media containing different concentrations of glucose and fructose. Unexpectedly and for both species, this simulation did not improve somatic embryo production, which stayed similar to the one obtained on constant osmotic pressure. To understand these results, embryos produced on the different treatments were analyzed in terms of sucrose, glucose, fructose and starch levels and protein contents. The embryo carbohydrate content was independent from the carbohydrate used in the maturation medium. However, embryos matured on 6% sucrose allowed to hydrolyze during the maturation period contained significantly more soluble and insoluble proteins than embryos matured on any other treatment. Furthermore, embryos with a higher protein content also exhibited a higher epicotyl appearance frequency. The role of sucrose as a regulatory factor during the maturation of spruce somatic embryos is discussed.     

Effect of dietary carbohydrates and copper status on blood pressure of rats

Copper deficiency was induced in rats by feeding diets containing either 62% starch, fructose or glucose deficient in copper for 6 weeks. All copper deficient rats, regardless of the dietary carbohydrate, exhibited decreased ceruloplasmin activity and decreased serum copper concentrations. Rats fed the fructose diet exhibited a more severe copper deficiency as compared to rats fed either starch or glucose. The increased severity of the deficiency was characterized by reduced body weight, serum copper concentration and hematocrit. In all rats fed the copper adequate diets, blood pressure was unaffected by the type of dietary carbohydrate. Significantly reduced systolic blood pressure was evident only in rats fed the fructose diet deficient in copper. When comparing the three carbohydrate diets, the physiological and biochemical lesions induced by copper deprivation could be magnified by feeding fructose.     

Effect of calcium carbonate on conversion of starch to ethanol by Schwanniomyces castellii

Conversion of starch to ethanol without its prior hydrolysis is of special interest in the treatment of the starch containing waste-waters. In this work the effect of calcium carbonate on the growth and ethanol production from soluble starch by Schwanniomyces castellii NRC 2676 was studied. When the medium was supplemented with 0.1% calcium carbonate the biomass yield and the total starch consumption were increased by 20% and 22%, respectively, while the ethanol yield decreased for 28% in comparison with the control. The rate of biomass production, measured for the period of time between 0 and 24 h, was the highest in the medium with 0.06% calcium carbonate while the rates of ethanol production and starch consumption decreased with and increase in the concentration of that salt; the media with 0.5% and 0.7% calcium carbonate had 3.5 and 5.5 times lower ethanol production rates, and 2.3 and 3.8 times lower rates of starch consumption than the control medium which was not supplemented with calcium carbonate, respectively. The obtained results also showed that the percentage of starch consumed was higher in the media supplemented with calcium carbonate than in the control. Empirical mathematical expressions are given for the relationship of the biomass and ethanol yields to the concentration of calcium carbonate in the medium.     

圆红冬孢酵母利用生物乙醇废水-木薯粉水解液发酵产油

【目的】获得能够高效降解生物乙醇废水化学需氧量(COD)的圆红冬孢酵母菌株,评估废水初始COD浓度对驯化菌株生长的影响,将木薯粉生产微生物油脂和高浓度有机废水降解过程整合,以生物乙醇废水为水源制备生物乙醇废水-木薯粉水解液培养基,明确产油效率高、生物乙醇废水COD降解率高的初始还原糖浓度。【方法】采用在高浓度的生物乙醇废水中进行多次驯化的方法,获得能够适应废水环境的圆红冬孢酵母菌株;采用双酶水解法对加入乙醇废水中的木薯粉进行水解;采用重量法监测生物量浓度变化,采用酸热法提取油脂,重铬酸钾法监测COD,DNS法测定废水还原糖浓度,凯氏定氮法测定总氮,钼酸铵比色法测定总磷。【结果】通过驯化筛选得到一株能耐受高浓度生物乙醇废水的优势菌株Rhodosporidium toruloides D5。以未稀释的废水为培养基,驯化菌株的最终生物量浓度和COD降解率分别为3.8 g/L和75.0%。采用生物乙醇废水-木薯粉水解液发酵时,控制初始还原糖浓度低于30 g/L时,生物量浓度和油脂浓度随初始还原糖浓度的升高而升高,均在120 h时达到最高COD降解率,初始还原糖浓度对达到的最大COD降解率无明显影响,废水N、P去除率分别达到99%和92%以上。【结论】在未经稀释的高浓度生物乙醇废水中可获得较高的生物量浓度;采用高浓度生物乙醇废水-木薯粉水解液培养基发酵产油,初始还原糖浓度为30 g/L,可在保证高油脂产量的同时,实现废水COD的高效降解,有效回收利用废水中残余的N、P源,从而降低微生物油脂生产和废水处理成本,研究结果可为开发廉价微生物油脂生产技术提供有用的参考。     

Fermentation Studies with Streptomyces griseus: I. Carbohydrate Sources for the Production of Protease and Streptomycin

The effects of four carbon sources and inorganic phosphate on the production of streptomycin and protease by a strain of Streptomyces griseus were studied. Protease production was increased in fermentations with comparatively rapid consumption of carbohydrate, and streptomycin was produced under conditions of moderately slow consumption. Starch was consumed more rapidly than glucose, and, in fermentations with starch as a carbon source, good yields of protease were associated with poor yields of streptomycin. The effect of the concentration of inorganic phosphate varied with the sugar source; the rate of consumption of glucose or fructose increased with the addition of inorganic phosphate, and the utilization of starch or maltose was not affected.