Identification of T-2 Toxin in Moldy Corn Associated with a Lethal Toxicosis in Dairy Cattle

Over a 5-month period during the winter of 1970-71, 20% of the lactating Holstein cows in a Wisconsin dairy herd died after prolonged ingestion of a diet containing 60% moldy corn infested with Fusarium tricinctum (2 x 10(5) propagules per g of moldy corn). Ethyl acetate extracts of the ground dried corn induced severe dermal reactions when applied to the skin of shaved 60-g albino rats and killed four of five 100-g rats that were force fed 1 ml in 2 ml of pure corn oil. T-2 toxin (3-hydroxy-4, 15-diacetoxy-8-[3-methylbutyryloxy]-12, 13-epoxy-Delta(9)-trichothecene) at concentrations of 2 mg per kg of dry corn was identified in purified extracts of the moldy corn by means of gas-liquid chromatography and mass spectrometry. This concentration of T-2 toxin in the moldy feed and the nature of the toxic effects observed strongly suggest a major causal relationship.     

Swine refusal factors elaborated by Fusarium strains and identified as trichothecenes.

Fusarium poae (Peck) Wollenw. NRRL 3287, F. nivale (Fr.) Ces. NRRL 3289, and F. moniliforme Sheldon NRRL 3197, each grown on cracked corn (13 days at 28 degrees C), produced refusal factors in pig bioassays. Substantial quantities of trichothecenes were detected in the refused corn: T-2 toxin (30 micrograms/g) was detected in corn fermented with the F. poae strain; the level of vomitoxin (1 microgram/g) in corn cultured with F. nivale did not account for the 48% refusal response in the pigs tested. The F. moniliforme concomitantly produced T-2 toxin (33 micrograms/g) and vomitoxin (1.5 micrograms/g). This strain's taxonomic position was reexamined, and it is shown to be a cultural variant of the species F. tricinctum (Cda.) Sacc.     

镰刀菌毒素的研究II．T-2毒素的提取、纯化及结构鉴定

本文报道了三线镰刀菌M-20(Fusarium tricinctum)接种于已灭菌的玉米粒培养基中,于13℃培养30天后,提取培养物所得粗毒素。经二次硅胶柱层析纯化后,经丙酮-正己烷结晶,可获得白色针状结晶。根据它的熔点(151—2℃)R_f0.56,LD_(50)2.5,mg/kg。分子量466,FD质谱测定,~1H核磁共振谱及EI质谱,确证结晶为T-2毒素。     

New process for T-2 toxin production.

Strains of Fusarium produced high levels of T-2 toxin when cultured on certain media absorbed into vermiculite. Modified Gregory medium was nutritionally complex (2% soya meal, 0.5% corn steep liquor, 10% glucose) and, when inoculated with the appropriate fungal strain, yielded maximum T-2 toxin within 24 days of incubation at 19 degrees C. On Vogel synthetic medium N (H. J. Vogel, Microb. Genet, Bull. 13:42-43, 1956) supplemented with 5% glucose, optimal toxin levels were synthesized after incubation for 12 to 14 days at 15 degrees C. Fusarium tricinctum T-340 produced 714 and 353 mg/liter on modified Gregory medium and Vogel synthetic medium N plus 5% glucose, respectively. Improved analytical procedures were developed and involved aqueous methanol extraction, purification by liquid-liquid partitions, and gas-chromatographic quantitation.     

Production of Trichothecene Mycotoxins by Fusarium Species in Shake Culture

Twelve T-2 toxin-producing isolates and four fusarenon-X-producing isolates of Fusarium species were examined for their ability to produce trichothecene mycotoxins in shake culture and jar fermentation. T-2 toxin producers such as Fusarium solani, F. sporotrichiodes, and F. tricinctum produced T-2 toxin and neosolaniol in semisynthetic medium. F. solani M-1-1 produced the largest amount of the mycotoxins in a nutrient medium consisting of 5% glucose (or sucrose), 0.1% peptone, and 0.1% yeast extract in either shake culture or jar fermentation at 24 to 27 C for 5 days. None of the isolates produced significant amount of fusarenon-X in shake cultures.     

Biological Assays for Two Mycotoxins Produced by Fusarium tricinctum

A survey was made to detect microorganisms useful for assaying butenolide [4-acetamido-4-hydroxy-2-butenoic acid gamma-lactone] and T-2 toxin [4beta, 15-diacetoxy-8alpha-(3-methylbutyryloxy)-12,13-epoxytricothec -9-en-3alpha-ol]. These mycotoxins produced by strains of Fusarium tricinctum have been implicated in mycotoxicosis of livestock. Although butenolide proved to be a very weak antibiotic, assay discs containing 100 mug of this toxin inhibited Sprillum serpens NRRL B-2052, Vibrio tyrogenus NRRL B-1033, and Xanthomonas campestris NRRL B-1459. T-2 toxin had no effect on 54 bacterial strains but inhibited 6 of 11 fungi. Growth of Rhodotorula rubra NRRL Y-7222 and Penicillium digitatum NRRL 1202 was retarded by assay discs containing 4 mug of T-2 toxin. Solutions with less than 1 mug of T-2 per ml toxin were readily detected by a pea seed germination test. Germination was reduced more than 50% when seeds imbibed solutions of 0.5 mug of T-2 toxin per ml. Butenolide had no effect on pea seed germination at concentrations as high as 200 mug/ml.     

Natural Occurrence of 16 Fusarium Toxins in Grains and Feedstuffs of Plant Origin from Germany

A total of 220 samples comprising cereals, cereal byproducts, corn plants and corn silage as well as non-grain based feedstuffs was randomly collected during 2000 and 2001 from sources located in Germany and analysed for 16 Fusarium toxins. The trichothecenes scirpentriol (SCIRP), 15-monoacetoxyscirpenol (MAS), diacetoxyscirpenol (DAS), T-2 tetraol, T-2 triol, HT-2 and T-2 toxin (HT-2, T-2), neosolaniol (NEO), deoxynivalenol (DON), 3-acetyldeoxynivalenol (3-ADON), 15-acetyldeoxynivealenol (15-ADON), nivalenol (NIV) and fusarenon-X (FUS-X) were determined by gas chromatography/mass spectrometry. Zearalenone (ZEA) and α- and β-zearalenol (α- and β-ZOL) were analysed by high performance liquid chromatography with fluorescence and UV-detection. Detection limits ranged between 1 and 19 μg/kg. Out of 125 samples of a group consisting of wheat, oats, corn, corn byproducts, corn plants and corn silage only two wheat samples did not contain any of the toxins analysed. Based on 125 samples the incidences were at 2–11% for DAS, NEO, T-2 Triol, FUS-X, α- and β-ZOL, at 20–22% for SCIRP, MAS, T-2 tetraol and 3-ADON, at 44–74% for HT-2, T-2, 15-ADON, NIV and ZEA, and at 94% for DON. Mean levels of positive samples were between 6 and 758 μg/kg. Out of 95 samples of a group consisting of hay, lupines, peas, soya meal, rapeseed meal and other oilseed meals, 64 samples were toxin negative. DAS, T-2 triol, NEO and FUS-X were not detected in any sample. The incidences of DON and ZEA were at 14 and 23% respectively, those of the other toxins between 1–4%, mean levels of positive samples were between 5 and 95 μg/kg.     

Biosynthesis of radiolabeled T-2 toxin by Fusarium tricinctum.

Incubation of Fusarium tricinctum NRRL 3299 on a solid rice medium in the presence of [1-14C]sodium acetate, [2-3H]mevalonic acid, [2-14C]mevalonic acid, or [5-3H]mevalonic acid yielded preparations of radiolabeled T-2 toxin with specific activities of 1.008, 1.64, 0.656, and 7.35 muCi/mmol, respectively.     

Heterokaryosis in Fusarium tricinctum and F. sporotrichioides

Heterokaryons were formed in intra- and interspecific crosses between Fusarium sporotrichioides and F. tricinctum auxotrophs. Segregant homokaryons were evaluated for trichothecene toxin production in culture. Results were consistent with nuclear control of toxin synthesis. The sexual compatibility of auxotrophs and 30 additional F. tricinctum sensu Snyder & Hansen strains was tested. Perithecial production was restricted to crosses between Florida isolates pathogenic to English ivy (Hedera helix). The linkage of several auxotrophic markers was determined by analysis of progeny of certain crosses. No T-2 toxin was produced by sexually compatible F. tricinctum isolates.     

In vitro metabolism of T-2 toxin in rats.

T-2 toxin was rapidly converted in the 9,000 X g supernatant fraction of rat liver homogenate into HT-2 toxin, T-2 tetraol, and two unknown metabolites designated as TMR-1 and TMR-2. TMR-1 was characterized as 4-deacetylneosolaniol (15-acetoxy-3 alpha, 4 beta, 8 alpha-trihydroxy-12,13-epoxytrichothec-9-ene) by spectroscopic analyses. Since the same metabolites were also obtained from HT-2 toxin used as substrate, it was concluded that T-2 toxin was hydrolyzed preferentially at the C-4 position to give HT-2 toxin, which was then metabolized to T-2 tetraol via 4-deacetylneosolaniol. In addition to HT-2 toxin, 4-deacetylneosolaniol and T-2 tetraol, a trace amount of neosolaniol was transformed from T-2 toxin by rat intestinal strips. In vitro metabolic pathways for T-2 toxin in rats are proposed.     

Effect of γ-irradiation on F-2 and T-2 toxin production in corn and rice

Fusarium graminearum andF. tricinctum were grown on moistened corn and rice. After inoculation the substrates were exposed to γ-irradiation and growth rate together with mycotoxin production were measured. A delay in mycelium growth and an increase in F-2 and T-2 toxin production occurred after irradiation with 1 and 3 kGy. The maximum F-2 production was 10.7 mg/kg on rice at 3 kGy, whereas T-2 was 735 μg/kg on rice at 3 kGy. At 9 kGy neither growth nor toxin production could be detected in any inoculated corn and rice substrate.     

Immunochemical analysis of trichothecenes produced by various fusaria

The production of type A trichothecene mycotoxins by 19 Fusaria, including 12Fusarium sporotrichioides, 4F. chlamydosporum and 3F. graminearum at 15°C and 25°C over a 35-day period was analyzed by ELISA using antibodies cross-reactive with most type A trichothecenes after conversion to T-2 tetraol tetraacetate. The toxin production peaked at 20–25 days of incubation with maximum yield between 4–6 mg type A trichothecene/ml of culture medium for 5F. sporotrichioides cultures and between 1 to 2 mg/ml for 6F. sporotrichioides cultures. OneF. sporotrichioides produced 700 µg type A trichothecenes/ml of culture medium. Detectable type A trichothecene was also found in the culture extracts ofF. chlamydosporum andF. graminearum, but the yield was very low (less than 100 µg/ml). Quantitative determination of individual trichothecenes was achieved by separation of different toxin in HPLC and followed by ELISA analysis. Eight to 10 immunoreactive peaks, corresponding to various type A trichothecenes, were detected in all the fungal extracts. T-2 tetraol (T-2-4ol), 4-acetyl-T-2 tetraol (4-Ac-T-2-4ol), neosolaniol (NEOS), diacetoxyscirpenol (DAS), HT-2 and T-2 toxin accounted for more than 85% of the total toxins. In general, low temperature was preferred for total type A trichothecene production. More T-2-4ol, 4-Ac-T-2-4ol, HT-2 and DAS were produced at 25°C. In contrast, more T-2 toxin and NEOS were produced at 15°C. Transformation of T-2 toxin and NEOS to polar metabolites such as T-2-4ol, 4-acetyl-T-2-4ol and HT-2 by various strains were observed at both temperatures after 25 days incubation.     

T-2 metabolites in the excreta of broiler chickens administered 3H-labeled T-2 toxin.

A method for the detection of T-2 metabolites was developed and applied to analysis of metabolites in excreta of broiler chickens administered 3H-labeled T-2 toxin. The method used acetonitrile extraction and partitioning with petroleum ether followed by chromatography on Amberlite XAD-2, Florisil, and Sep-Pak C18. The recovery of T-2 toxin added to the chicken excreta was 73% at a concentration of 0.2 microgram/g. About 80% of orally administered 3H-labeled T-2 toxin was rapidly metabolized to more polar derivatives and eliminated in the excreta within 48 h. T-2 toxin, HT-2 toxin, neosolaniol, and T-2 tetraol were detected at 0.06 to 1.13% of the total dose, 48 h after administration. Eight unknown derivatives, named TB-1 to TB-8, were quantitatively more significant than the metabolites above. TB-3 and TB-9 represented about 12 and 25% of the total dose, respectively. One of the metabolites (TB-6), 1.5% of the total dose, was identified as 4-deacetylneosolaniol (15-acetyl-3 alpha, 4 beta, 8 alpha-trihydroxy-12, 13-epoxytrichothec-9-ene).     

Acceptance by swine and rats of corn amended with trichothecenes.

Swine and rats demonstrated the same response factor (i.e., the average amount of corn amended with trichothecenes consumed by animals per the average amount of uncontaminated corn consumed by animals) for consumption of corn amended with 40 ppm of either T-2 toxin or diacetoxyscirpenol Rat response factor for corn containing 40 ppm of vomitoxin was 1.8 times more than corn containing either T-2 toxin or diacetoxyscirpenol at 40 ppm. For the corn containing 40 ppm of vomitoxin, swine response factor was 1.8 times greater than rat response factor.     

Acceptance by swine and rats of corn amended with trichothecenes

Swine and rats demonstrated the same response factor (i.e., the average amount of corn amended with trichothecenes consumed by animals per the average amount of uncontaminated corn consumed by animals) for consumption of corn amended with 40 ppm of either T-2 toxin or diacetoxyscirpenol Rat response factor for corn containing 40 ppm of vomitoxin was 1.8 times more than corn containing either T-2 toxin or diacetoxyscirpenol at 40 ppm. For the corn containing 40 ppm of vomitoxin, swine response factor was 1.8 times greater than rat response factor.     

Production and characterization of a generic antibody against group A trichothecenes

An antibody against group A trichothecenes was produced after immunization of rabbits with an immunogen prepared by conjugation of T-2 toxin to bovine albumin at the C-8 position. T-2 toxin was first converted to 3-acetylneosolaniol (3-Ac-NEOS) and then to its hemisuccinate (HS) before conjugation to the protein. The rabbits showed a quick immune response after immunization of the new conjugate. The antibody produced bound with tritiated T-2 toxin, T-2 tetraol tetraacetate, and diacetoxyscirpenol (DAS) and showed good cross-reactivities with most of the group A trichothecenes. The concentrations causing 50% inhibition of binding of 3H-T-2 toxin to the new antibody by unlabeled T-2, acetyl-T-2, 3'-OH-T-2, DAS, 3-Ac-NEOS-HS, 3'-OH-Ac-T-2, T-2 tetraol tetraacetate, iso-T-2, 3-Ac-NEOS, Ac-DAS, and 3,4,15-triacetyl-7-deoxynivalenol were found to be 0.34, 0.34, 0.6, 2.5, 4, 10, 18, 24, 100, 200, and 300 ng/assay, respectively; for HT-2, T-2 triol, and T-2 tetraol, the concentration was greater than 1000 ng/assay. Nivalenol, deoxynivalenol (DON), 15-acetyl-DON, and triacetyl-DON, did not inhibit the binding at 1000 ng/assay. The practical application of using this new antibody for radioimmunoassay (RIA) of trichothecene was tested by spiking T-2 toxin to corn. T-2 toxin was then extracted with acetone, subjected to a simple Sep-Pak C-18 reversed-phase treatment, and analyzed by RIA. The overall recovery for 18 samples spiked with 10 to 50 ppb of T-2 toxin was 94.22%.     

Detection of T-2 toxin in Fusarium sporotrichioides-infected corn by enzyme-linked immunosorbent assay.

A competitive enzyme-linked immunosorbent assay was used to screen for T-2 toxin in Fusarium sporotrichioides -infected corn. The assay detected T-2 toxin in diluted methanol extracts of corn samples at concentrations of 0.05 ng/ml. In infected corn samples, enzyme-linked immunosorbent assay and gas-liquid chromatography estimations of T-2 toxin concentrations were similar.     

Neural Disturbances in Chickens Caused by Dietary T-2 Toxin

Graded concentrations of dietary T-2 toxin (0, 1, 2, 4, 8, and 16 mug/g) were fed to groups of 40 chickens. T-2 toxin was found to cause an abnormal positioning of the wings, hysteroid seizures, and impaired righting reflex in young chickens. The abnormal wing positioning occurred spontaneously or as the result of dropping from a height of 1 meter. The seizures could be elicited by rough handling or loud noises. The seizures and the abnormal wing posture would not occur again when the stimulus was repeated unless a rest period of 3 to 6 h was allowed. The loss of righting reflex could be demonstrated at any time. The total incidence of neural symptoms was dependent on the length of exposure to T-2 toxin and to its concentration. Neural toxicity occurred at dosages of 4, 8, and 16 mug per g of diet, which are the same doses that retard growth. This neural toxicity of T-2 toxin in chickens is similar to the neural disturbances associated with alimentary toxic aleukia, a nutritional toxicosis of humans produced by eating moldy grain. T-2 toxin has been implicated also in moldy corn toxicosis which has neural manifestations in horses and swine.     

Trichothecene Production in Liquid Stationary Cultures of Fusarium tricinctum NRRL 3299 (Synonym: F. sporotrichioides): Comparison of Quantitative Brine Shrimp Assay with Physicochemical Analysis

Stationary liquid cultures of Fusarium tricinctum NRRL 3299 (synonym: F. sporotrichioides) produce T-2 toxin, neosolaniol, diacetoxyscirpenol, and HT-2 toxin when cultured on peptone-enriched Czapek Dox medium. At 15 and 27°C, maximum T-2 toxin yield (265 and 50 μg/ml) was found after 10 to 14 and 7 days, respectively. The T-2 toxin in the culture medium was metabolized rapidly at 27°C and slowly at 15°C. Addition of 0.025% (wt/vol) sorbic acid to the medium resulted in an increased production of trichothecenes at 15°C (400 μg of T-2 per ml after 14 days). Trichothecenes in the culture liquid were determined by the brine shrimp bioassay and physicochemical analysis. The brine shrimp assay was improved by using modern bioassay equipment, including tissue culture trays and multipipettes, and by a standardized approach with positive and negative controls. The physicochemical analysis was based on adsorption of the trichothecenes onto Amberlite XAD-2 columns, derivatization with trifluoroacetic anhydride followed by capillary gas chromatography, and identification by mass spectrometry (as many as 17 trichothecenes were detected in the culture medium). The brine shrimp assay offers an interesting monitoring system for the quantitation of T-2 toxin and should be useful for studies on production of this toxin in culture. Specific information on less toxic trichothecenes, however, requires a more time-consuming chemical analysis.