CANON and Anammox in a gas-lift reactor

Anoxic ammonium oxidation (Anammox) and Completely Autotrophic Nitrogen removal Over Nitrite (CANON) are new and promising microbial processes to remove ammonia from wastewaters characterized by a low content of organic materials. These two processes were investigated on their feasibility and performance in a gas-lift reactor. The Anammox as well as the CANON process could be maintained easily in a gas-lift reactor, and very high N-conversion rates were achieved. An N-removal rate of 8.9 kg N (m(3) reactor)(-1) day(-1) was achieved for the Anammox process in a gas-lift reactor. N-removal rates of up to 1.5 kg N (m(3) reactor)(-1) day(-1) were achieved when the CANON process was operated. This removal rate was 20 times higher compared to the removal rates achieved in the laboratory previously. Fluorescence in situ hybridization showed that the biomass consisted of bacteria reacting to NEU, a 16S rRNA targeted probe specific for halotolerant and halophilic Nitrosomonads, and of bacteria reacting to Amx820, specific for planctomycetes capable of Anammox.     

Introduction of Exogenous Activated Sludge as a Way to Enhance the Efficiency of Nitrogen Removal in the Anammox Process

Microbiology - The effect of introduction of exogenous activated sludge (bioaugmentation) on the activity and composition of the microbial consortium carrying out the nitritation-anammox process in...     

Inhibition of Nitrification in the Activated Sludge Process of Sewage Disposal

S ummary . A simple method is described for determining the short term effects of sewages, effluents and individual substances on the nitrifying ability of activated sludge and the results of screening many substances are listed. The effects of mixtures of inhibitors and the possibility of formation of complexes between some of those inhibitors were investigated. The long term effects of inhibitors often differ from their immediate effects, one of the most important factors being the ability of activated sludge to become adapted to the inhibitor.     

活性污泥总DNA提取方法的研究

采用冻融＋玻璃珠、溶菌酶＋SDS和冻融＋玻璃珠＋溶菌酶＋SDS的方法提取活性污泥的微生物总DNA,并对以上三种方法进行比较,从中确定最佳的方法,以实现普通实验条件下成功提取符合PCR扩增要求的DNA。经紫外光度分析及电泳结果表明,冻融＋玻璃珠＋溶菌酶＋SDS方法所得的DNA的OD260/OD280为1．81,电泳结果显示,所提DNA片段分子量大于10kb,适于酶解和PCR扩增要求,为PCR技术应用于活性污泥的研究提供了一种简便、可靠的DNA提取方法。     

Glyphosate-Degrading Microorganisms from Industrial Activated Sludge

A plating medium was developed to isolate N-phosphonomethylglycine (glyphosate)-degrading microorganisms, with glyphosate as the sole phosphorus source. Two industrial biosystems treating glyphosate wastes contained elevated microbial counts on the medium. One purified isolate metabolized glyphosate to aminomethylphosphonic acid, mineralizing this accumulating intermediate during log growth. This microorganism has been identified as a Flavobacterium species.     

Bioaugmentation of Anammox Activated Sludge with a Nitrifying Bacterial Community as a Way to Increase the Nitrogen Removal Efficiency

Microbiology - Bioaugmentation, i.e., increasing the abundance of certain microorganisms in the community by adding appropriate cells or establishing the conditions promoting their growth, is...     

Isolation and Characterization of Cellulolytic Bacteria from Activated Sludge

Cellulolytic aerobic bacteria were isolated from activated sludge systems. Of the media tested for enumeration, only filter paper media gave reliable counts. Five isolates were studied further for characterization. It was found that one strain (DK) belonged to the genus Cellulomonas. The other four strains expressed similarity to the genus Pseudomonas. The different characteristics that were studied, however, do not permit them to be identified with any recognized species. Based on certain characters we believe that they are alcaligenes-like pseudomonads.     

Viscous Product from Activated Sludge by Methanol Fermentation

Aeration of activated sludge with 3 to 4% added methanol for 5 to 7 days yields an odorless, highly viscous (5,000 to 10,000 centipoise), black, pudding-like product containing glycan(s) linked other than α-1-4 or β-1-3. Backseeding gives maximum thickening in 3 to 4 days. Incomplete acid hydrolysis of the black product gives a 0.27% solution of reducing sugars (75% glucose) which is an 11.4% yield from the added methanol. Backseeding into either centrifuge supernatant or 0.1% yeast extract in tap water gives a light-colored polymer. Viscosity decreases during extended sterile cold storage. A 5% salt addition lowers viscosity one-half. From 6 to 12 colony types appear on plating backseeded media, but none of these isolates is a reliable polymer former.     

Coaggregation among Nonflocculating Bacteria Isolated from Activated Sludge

Thirty-two strains of nonflocculating bacteria isolated from sewage-activated sludge were tested by a spectrophotometric assay for their ability to coaggregate with one other in two-membered systems. Among these strains, eight showed significant (74 to 99%) coaggregation with Acinetobacter johnsonii S35 while only four strains coaggregated, to a lesser extent (43 to 65%), with Acinetobacter junii S33. The extent and pattern of coaggregation as well as the aggregate size showed good correlation with cellular characteristics of the coaggregating partners. These strains were identified by sequencing of full-length 16S rRNA genes. A. johnsonii S35 could coaggregate with strains of several genera, such as Oligotropha carboxidovorans, Microbacterium esteraromaticum, and Xanthomonas spp. The role of Acinetobacter isolates as bridging organisms in multigeneric coaggregates is indicated. This investigation revealed the role of much-neglected nonflocculating bacteria in floc formation in activated sludge.     

Application of Image Analysis Techniques in Activated Sludge Wastewater Treatment Processes

Image analytical techniques have been extensively developed to evaluate complex microbial aggregates such as sludge flocs and biofilms. This review covers the latest contributions concerning the application of image analysis to the activated sludge systems with respect to the most frequently used morphological parameters and relations between them and traditional wastewater treatment parameters. Recent developments have indicated that image analysis can be successfully used for the quantification of flocs and filamentous bacteria in the operating wastewater treatment plants, which enables prediction of bulking events and pinpoint flocs formation.     

Application of the Fluorescent-Antibody Technique for the Detection of Sphaerotilus natans in Activated Sludge

Sphaerotilus natans, one of the most widely reported causes of bulking in activated sludge, can exist both within and outside of a sheath. It can easily be confused with similar activated sludge bacteria and thus can be overlooked when present in low numbers. Fluorescent antiserum was successfully prepared against the nonfilamentous form and was shown to be highly specific, showing no reaction with either pure cultures of similar filamentous bacteria or entirely unrelated organisms. It did, however, show a lack of strain specificity since it reacted with S. natans isolates from the Federal Republic of Germany and the United States and with filamentous bacteria in South African activated sludges. Fluorescent antibody is capable of penetrating the filaments of S. natans to stain the cells individually. The use of fluorescent antiserum in the identification of S. natans filaments obscured by activated sludge flocs and other suspended matter was simple since the cells stained brightly and could be observed through the less dense matter, while the use of other microscope techniques would be hampered by these obstructions. The use of fluorescent antibody will facilitate ecological studies of S. natans in activated sludge and other aqueous environments.     

Enrichment and granulation of Anammox biomass started up with methanogenic granular sludge

A sequencing batch reactor (SBR) seeded with methanogenic granular sludge was started up to enrich Anammox (Anaerobic Ammonium Oxidation) bacteria and to investigate the feasibility of granulation of Anammox biomass. Research results showed that hydraulic retention time (HRT) was an important factor to enrich Anammox bacteria. When the HRT was controlled at 30 days during the initial cultivation, the SBR reactor presented Anammox activity at t = 58 days. Simultaneously, the methanogenic granular sludge changed gradually from dust black to brown colour and its diameter became smaller. At t = 90 days, the Anammox activity was further improved. NH₄⁺-N and NO₂⁻N were removed simultaneously with higher speed and the maximum removal rates reached 14.6 g NH₄⁺-N /(m³ _reactor·day) and 6.67 g NO₂⁻-N /(m³ _reactor·day), respectively. Between t = 110 days and t = 161 days, the nitrogen load was increased to a HRT of 5 days (70 mg/l NH₄⁺ and 70 mg/l NO₂), the removal rates of ammonium and nitrite were 60.6% and 62.5% respectively. The sludge changed to red and formed Anammox granulation with high nitrogen removal activity.     

有机农药活性污泥中表面活性剂产生菌的筛选及鉴定

目的:筛选表面活性剂产生菌,用于降解有机农药,提高氧化塘处理效率.方法:以液体石蜡为惟一碳源进行选择性培养,通过测定发酵液的排油活性和表面张力,对有机农药厂的活性污泥进行产生物表面活性剂细菌筛选,并对筛得的细菌进行形态学、生理生化及 16SrDNA 试验和鉴定.结果:筛选出 3 株产生物表面活性剂的细菌,经鉴定均属于不动杆菌属.结论:证实了有机农药活性污泥中存在表面活性剂的产生菌,对有机农药降解存在助溶作用.     

可用于微生物群落分子生态学研究的活性污泥总DNA提取方法研究

活性污泥样品经液氮速冻、沸水浴融化、溶菌酶处理和 SDS裂解后 ,99%以上细胞裂解。所提取的 DNA经琼脂糖凝胶电泳检测和荧光法浓度测定 ,其片断大小在 2 0 kb左右 ,产量可达 1 .75 6± 0 .1 mg/g MLSS。样品 ABS2 6 0 nm/ABS2 80 nm的比值为 1 .96± 0 .2。以提取的总 DNA为模板 ,进行细菌核糖体小亚基 1 6Sr DNA基因 V3区和多组分苯酚羟化酶大亚基基因 (Lm PHs)的 PCR扩增 ,均获得成功 ,为活性污泥中微生物群落的分子生态学研究提供了一种简便、可靠的 DNA提取方法。     

生物淋滤法去除污泥中的重金属

本研究从剩余活性污泥中分离得到两株土著硫杆菌。对两株菌进行了分类鉴定。确立二者分别为嗜酸性氧化亚铁硫杆菌(Acidithiobacillus ferrooxidans, A. f)和嗜酸性氧化硫硫杆菌(Acidithiobacillus thiooxidans, A. t)。将二者的单菌和混合菌分别接种于剩余活性污泥中, 进行了为期9 d的生物淋滤, 对淋滤过程中的pH变化、氧化还原电位(ORP)以及重金属含量进行了检测。结果表明, 生物淋滤9 d混合菌对于As、Cr、Cu、Ni和Zn的去除效果最好; 去除率分别达到了96.09%、93.47%、98.32%、97.88%和98.60%。对于Cd和Pb混合菌生物淋滤的去除率在第6天之后迅速下降, 但是A. t单菌淋滤保持较高的去除率。     

污泥中重金属的生物淋滤

生物淋滤法(Bioleaching)是指利用自然界中一些微生物(硫细菌)的直接作用或其代谢产物的间接作用,产生氧化、还原、络合、吸附或溶解反应,将固相中某些不溶性成分(如重金属、硫及其他金属)分离浸提出来的技术.在生物淋滤中,嗜酸性氧化亚铁硫杆菌(Acidithiobacillus ferrooxidans,A.f)和嗜酸性氧化硫硫杆菌(Acidithiobacillus thiooxidans,A.f)被用作有效的淋滤载体[1].这种嗜酸性的化能自养型细菌以大气中的CO2为碳源,以无机物铁或硫为能源来维持生长,不需要提供外来的碳源和电子供体.另外,由于pH值很低,抑制了其他细菌的生长,所以在实际的操作过程中不需要严格的无菌条件.氧化亚铁硫杆菌和氧化硫硫杆菌去除重金属适宜于污水处理厂的开放系统,采用土著嗜酸性氧化亚铁硫杆菌(A.f)和氧化硫硫杆菌(A.f)进行重金属去除.也就是说,处理什么地方的污泥,就在什么地方分离A.f和A.t,这样分离的微生物在生物淋滤过程中能发挥较好的作用.这也是微生物在自然界生长繁殖的特点之一.本期介绍了王聪、宋存江等[2]从剩余活性污泥中分离得到两株土著硫杆菌,对两株菌进行了分类鉴定,确定二者分别为嗜酸性氧化亚铁硫杆菌杆(Acidithiobacillus ferrooxidans,A.f)和嗜酸性氧化硫硫杆菌(Acidithiobacillus thiooxidans,A.t),将二者的单菌和混合菌分别接种于剩余活性污泥中,进行了为期9 d的生物淋滤,对淋滤过程中的pH变化、氧化还原电位(ORP)以及重金属含量进行了检测.结果表明,生物淋滤9 d的混合菌对于As、Cr、Cu、Ni和Zn的去除效果最好,去除率分别达到了96.09%、93.47%、98.32%、97.88%和98.60%.混合菌生物淋滤对于Cd和Pb的去除率在第6天之后迅速下降,但是A.t单菌淋滤保持较高的去除率,此结果为进一步的应用打下了良好的基础.     

Bioelectricity Generation and Bioremediation of an Azo-Dye in a Microbial Fuel Cell Coupled Activated Sludge Process

Simultaneous bioelectricity generation and dye degradation was achieved in the present study by using a combined anaerobic-aerobic process. The anaerobic system was a typical single chambered microbial fuel cell (SMFC) which utilizes acid navy blue r (ANB) dye along with glucose as growth substrate to generate electricity. Four different concentrations of ANB (50, 100, 200 and 400 ppm) were tested in the SMFC and the degradation products were further treated in an activated sludge post treatment process. The dye decolorization followed pseudo first order kinetics while the negative values of the thermodynamic parameter ∆G (change in Gibbs free energy) shows that the reaction proceeds with a net decrease in the free energy of the system. The coulombic efficiency (CE) and power density (PD) attained peak values at 10.36% and 2,236 mW/m² respectively for 200 ppm of ANB. A further increase in ANB concentrations results in lowering of cell potential (and PD) values owing to microbial inhibition at higher concentrations of toxic substrates. Cyclic voltammetry studies revealed a perfect redox reaction was taking place in the SMFC. The pH, temperature and conductivity remain 7.5–8.0, 27(±2°C and 10.6–18.2 mS/cm throughout the operation. The biodegradation pathway was studied by the gas chromatography coupled with mass spectroscopy technique, suggested the preferential cleavage of the azo bond as the initial step resulting in to aromatic amines. Thus, a combined anaerobic-aerobic process using SMFC coupled with activated sludge process can be a viable option for effective degradation of complex dye substrates along with energy (bioelectricity) recovery.