Facile Syntheses of C-Glycosides of Aromatic Compounds

Aspartokinase (ATP: l-aspartate 4-phosphotransferase) was extracted and partially purified 11-fold from an extreme thermophile, Thermus flavus AT–62. The enzyme has a temperature optimum near 75°C and a pH optimum of 7 to 8. The enzyme activity was feedback inhibited 80% by l-threonine at the concentration of 0.1 mm at 60°C. No concerted effect of l-threonine with any other aspartate family amino acids was observed. The aspartokinase and homoserine dehydrogenase activities were eluted at different concentrations of KCl from DEAE-cellulose column. The aspartokinase was not inactivated after 30 min at 70°C, but 30% of the original activity was lost after 30 min at 80°C and rapid inactivation occurred above 85°C. The allosteric sensitivity of the enzyirie was maintained even at 60~80°C but was reduced with the increase of temperature, accompanying desensitization above 80°C. The heat stability of the enzyme activity and of the allosteric sensitivity was discussed in comparison with other allosteric enzymes of thermophiles.     

Microbial Production of l-Threonine

l-Threonine production by strain BB-69, which was derived from Brevibacterium flavum No. 2247 as a α-amino-β-hydroxyvaleric acid resistant mutant and produced about 12 g/liter of l-threonine, was reduced by the addition of l-lysine or l-methionine in the culture medium. Many of lysine auxotrophs but not methionine auxotrophs derived from strain B–2, which produced about 7 g/liter of l-threonine, produced more l-threonine than the parental strain. Except only one methionine auxotroph (BBM–21), none of lysine and methionine auxotrophs derived from BB–69 produced more l-threonine than the parental strain. Homoserine dehydrogenase of crude extract from strain B–2 was inhibited by l-threonine more strongly than that from BB–69. Strain BBM–21, a methionine auxotroph derived from BB–69, produced about 18 g/liter of l-threonine, 50% more than BB–69, while accumulation of homoserine decreased remarkably as compared with BB–69. l-Threonine production by BBM–21 was increased by the addition of l-homoserine, a precursor of l-threonine, while that by BB–69 was not. No difference was found among BBM–21, BB–69 and No. 2247 in the degree of inhibition of homoserine kinase by l-threonine. l-Threonine production by revertants of BBM–21, that is, mutants which could grow without methionine, were all lower than that of BBM–21. Correlation between l-threonine production and methionine or lysine auxotrophy was discussed.     

Production of L-Threonine by Mutants Resistant to Both α-Amino-β-hydroxyvaleric Acid and S-(2-Aminoethyl)-L-cysteine Derived from Brevibacterium flavum

Growth of Brevibacterium flavum FA-1-30 and FA-3-115, L-lysine producers derived from Br. flavum No. 2247 as S-(2-aminoethyl)-L-cysteine (AEC) resistant mutants, was inhibited by α-amino-β-hydroxyvaleric acid (AHV), and this inhibition was reversed by L-threonine. All the tested AHV resistant mutants derived from FA-1-30 accumulated more than 4 g/liter of L-threonine in media containing 10% glucose, and the best producer, FAB-44, selected on a medium containing 5 mg/ml of AHV produced about 15 g/liter of L-threonine. Many of AHV resistant mutants selected on a medium containing 2 mg/ml of AHV accumulated L-lysine as well as L-threonine, AHV resistant mutants derived from FA-3-115 produced 10.7 g/liter of L-threonine maximally. AEC resistant mutants derived from strains BB–82 and BB–69, which were L-threonine producers derived from Br. flavum No. 2247 as AHV resistant mutants, did not produce L-threonine more than the parental strains, and moreover, many of them did not accumulate L-threonine but L-lysine. Homoserine dehydrogenases of crude extracts from L-threonine producing AHV resistant mutants derived from FA–1–30 and FA–3–115 were insensitive to the inhibition by L-threonine, and those of L-threonine and L-lysine producing AHV resistant mutants from FA–1–30 were partially sensitive.

Correlation between L-threonine or L-lysine production and regulations of enzymatic activities of the mutants was discussed.     

Mechanism of l-Threonine and l-Lysine Production by Analog-resistant Mutants of Corynebactemum glutamicum

Homoserine dehydrogenases and aspartokinases in l-threonine- or l-threonine and l-lysine-producing mutants derived from Corynebacterium glutamicum KY 9159 (Met^?) were studied with respect to the sensitivity to the inhibition by end products, l-threonine and l-lysine. The activities of homoserine dehydrogenases in the mutants which produced l-threonine or l-threonine and l-lysine were slightly less susceptible to the inhibition by l-threonine than the activity in the parent strain, KY 9159. The aspartokinases in the threonine-producing mutants, KY 10484 and KY 10230, which were resistant to α-amino-β-hydroxylvaleric acid (AHV, a threonine analog) and more sensitive to thialysine (a lysine analog) than the parent, were sensitive to the concerted feedback inhibition by l-lysine and l-threonine by about the same degree as KY 9159. The aspartokinase in an AHV- and thialysine-resistant mutant, KY 10440, which was derived from KY 10484 and produced about 14 mg/ml of l-threonine in a medium containing 10% glucose was less susceptible to the concerted feedback inhibition than KY 10484 or KY 9159, although the activity was still under the feedback control. In the parent strain, l-threonine activated aspartokinase activity in the absence of ammonium sulfate, an activator of the enzyme, but partially inhibited the activity in the presence of the salt. On the other hand, the enzyme of KY 10440 was activated by l-threonine either in the presence or in the absence of the salt. In another AHV- and thialysine-resistant mutant, KY 10251, which was derived from KY 10230 and produced both 9 mg/ml of l-threonine and 5/5 mg/ml of l-lysine, l-threonine and l-lysine simultaneously added hardly inhibited the activity of aspartokinase.

Implications of these results are discussed in relation to l-threonine or l-lysine production, AHV or thialysine resistance and regulation of l-threonine biosynthesis in these mutants.     

Production of L-Isoleucine by AHV Resistant Mutants of Brevibacterium flavum

The growth of Brevibacterium flavum No. 2247A was inhibited by α-amino-β-hydroxy-valeric acid (AHV), and the inhibition was partially reversed by L-isoleucine.

AHV resistant strain ARI-129, which was isolated on a medium supplemented with 2 mg/ml of AHV, produced 11 g/liter of L-isoleucine.

No difference was observed in threonine dehydratase between No. 2247A and ARI–129. Homoserine dehydrogenase from ARI–129 was insensitive to the feedback inhibition by L-isoleucine and L-threonine.

O-Methyl-L-threonine resistant mutant, strain AORI–126, which was derived from ARI–129, produced 14.5 g/liter of L-isoleucine. Specific activity of threonine dehydratase from AORI–126 increased about two-fold higher than those from No. 2247A and ARI–129, whereas degree of inhibition of the enzyme by L-isoleucine was the same among three strains.

Among auxotrophic mutants derived from ARI–129, adenine and lysine auxotrophs produced more L-isoleucine than the parent did.

In the adenine auxotroph, L-isoleucine production was markedly reduced by the addition of excess adenine.     

L-Threonine Production by a Mutant of Arthrobactev paraffineus

An isoleucine leaky auxotroph of Arthrobacter paraffineus, which was isolated by Takayama et al.³⁾ as a mutant producing L-threonine and L-valine from n-paraffin, was subjected to further mutagenesis in an attempt to obtain better L-threonine producers. Some of the double auxotrophs derived from the isoleucine auxotroph and some of their revertants with respect to isoleucine requirement produced more L-threonine than the original isoleucine auxotroph. In contrast to the original isoleucine auxotroph, a revertant derived from a methionine plus isoleucine double auxotroph, KY7135, produced an increased amount of L-threonine and a decreased amount of L-valine. The optimum level of L-methionine for L-threonine production in KY7135 was much higher (1000 ~ 2000 μg/ml) with n-paraffin medium than with sorbitol or mannitol medium (10 ~ 50 μg/ml). L-Threonine production reached a maximum level (11.5 mg/ml) in 7 days incubation with the medium containing 10% n-paraffin (C₁₂ ~ C₁₄ rich). Several mutants which produce L-threonine more than 12 mg/ml were obtained from KY 7135 by monocolony isolation procedure.     

Biosynthesis of Vitamin B6 in Rhizobium: In Vitro Synthesis of Pyridoxine from 1-Deoxy-D-xylulose and 4-Hydroxy-L-threonine

Pyridoxine (vitamin B₆) in Rhizobium is synthesized from 1-deoxy-D-xylulose and 4-hydroxy-L-threonine. To define the pathway enzymatically, we established an enzyme reaction system with a crude enzyme solution of R. meliloti IFO14782. The enzyme reaction system required NAD⁺, NADP⁺, and ATP as coenzymes, and differed from the E. coli enzyme reaction system comprising PdxA and PdxJ proteins, which requires only NAD⁺ for formation of pyridoxine 5′-phosphate from 1-deoxy-D-xylulose 5-phosphate and 4-(phosphohydroxy)-L-threonine.     

Functional Characterization of D-Galacturonic Acid Reductase,a Key Enzyme of the Ascorbate Biosynthesis Pathway,from Euglena gracilis

D-Galacturonic acid reductase, a key enzyme in ascorbate biosynthesis, was purified to homogeneity from Euglena gracilis. The enzyme was a monomer with a molecular mass of 38–39 kDa, as judged by SDS–PAGE and gel filtration. Apparently it utilized NADPH with a Km value of 62.5±4.5 μM and uronic acids, such as D-galacturonic acid (Km=3.79±0.5 mM) and D-glucuronic acid (Km=4.67±0.6 mM). It failed to catalyze the reverse reaction with L-galactonic acid and NADP⁺. The optimal pH for the reduction of D-galacturonic acid was 7.2. The enzyme was activated 45.6% by 0.1 mM H₂O₂, suggesting that enzyme activity is regulated by cellular redox status. No feedback regulation of the enzyme activity by L-galactono-1,4-lactone or ascorbate was observed. N-terminal amino acid sequence analysis revealed that the enzyme is closely related to the malate dehydrogenase families.     

Preparation of Optically Active Allothreonine by Separating from a Diastereoisomeric Mixture with Threonine

A simple procedure is described to obtain D- and L-allothreonine (D- and L-aThr). A mixture of N-acetyl-D-allothreonine (Ac-D-aThr) and N-acetyl-L-threonine (Ac-L-Thr) was converted to a mixture of their ammonium salts and then treated with ethanol to precipitate ammonium N-acetyl-L-threoninate (Ac-L-Thr·NH₃) as the less-soluble diastereoisomeric salt. After separating Ac-L-Thr·NH₃ by filtration, Ac-D-aThr obtained from the filtrate was hydrolyzed in hydrochloric acid to give D-aThr of 80% de, recrystallized from water to give D-aThr of >99% de. L-aThr was obtained from a mixture of the ammonium salts of Ac-L-aThr and Ac-D-Thr in a similar manner.     

Reverse Reaction of Malic Enzyme for HCO3 − Fixation into Pyruvic Acid to Synthesize L-Malic Acid with Enzymatic Coenzyme Regeneration

Malic enzyme [L-malate: NAD(P)⁺ oxidoreductase (EC 1.1.1.39)] catalyzes the oxidative decarboxylation of L-malic acid to produce pyruvic acid using the oxidized form of NAD(P) (NAD(P)⁺). We used a reverse reaction of the malic enzyme of Pseudomonas diminuta IFO 13182 for HCO₃ ^? fixation into pyruvic acid to produce L-malic acid with coenzyme (NADH) generation. Glucose-6-phosphate dehydrogenase (EC1.1.1.49) of Leuconostoc mesenteroides was suitable for coenzyme regeneration. Optimum conditions for the carboxylation of pyruvic acid were examined, including pyruvic acid, NAD⁺, and both malic enzyme and glucose-6-phosphate dehydrogenase concentrations. Under optimal conditions, the ratio of HCO₃ ^? and pyruvic acid to malic acid was about 38% after 24 h of incubation at 30 °C, and the concentration of the accumulated L-malic acid in the reaction mixture was 38 mM. The malic enzyme reverse reaction was also carried out by the conjugated redox enzyme reaction with water-soluble polymer-bound NAD⁺.     

Production of l-rhamnulose,a rare sugar,from l-rhamnose using commercial immobilized glucose isomerase

Abstract

A commercial immobilized d-glucose isomerase from Streptomyces murines (Sweetzyme) was used to produce l-rhamnulose from l-rhamnose in a packed-bed reactor. The optimal conditions for l-rhamnulose production from l-rhamnose were determined as pH 8.0, 60?°C, 300?g L^?1 l-rhamnose as a substrate, and 0.6?h^?1 dilution rate. The half-life of the immobilized enzyme at 60?°C was 809?h. Under the optimal conditions, the immobilized enzyme produced an average of 135?g L^?1 l-rhamnulose from 300?g L^?1 l-rhamnose after 16 days at pH 8.0, 60?°C, and 0.6?h^?1 dilution rate, with a productivity of 81?g/L/h and a conversion yield of 45% in a packed-bed reactor.     

Reactions of O-Substituted L-Homoserines Catalyzed by L-Methionine γ-Lyase and Their Mechanism

L-Methionine γ-lyase (EC 4.4.1.11) catalyzes α,γ-elimination of O-substituted L-homoserines (i.e., ROCH₂CH₂CH(NH₂)COOH; R = acetyl, succinyl, or ethyl) to produce α-ketobutyrate, ammonia, and the corresponding carboxylate or alcohol, and also their γ-replacement reactions with various thiols to produce the corresponding S-substituted L-homocysteines. The reactivities of O-substituted L-homoserines in α,γ-elimination relative to that of L-methionine were as follows: O-acetyl, 140%; O-succinyl, 17%; and O-ethyl-L-homoserine, 99%. However, the enzyme does not catalyze the synthesis of O-substituted L-homoserines from alcohol or carboxylic acids in a γ-replacement reaction. We have analyzed the α,γ-elimination of O-acetyl-L-homoserine in deuterium oxide by ¹H-NMR. The [β-²H, γ-²H]-species of α-ketobutyrate was exclusively formed from O-acetyl-L-homoserine. The enzyme catalyzes deamination of L-vinylglycine to give the identically labeled α-ketobutyrate species. Incubation of the enzyme with O-acetyl-L-homoserine resulted in the appearance of a new absorption band at 480 nm, which was observed also with L-vinylglycine. These results strongly suggest that the α,γ-elimination and γ-replacement reactions of O-acetyl-L-homoserine proceed through the stabilized α-carbanion of a Schiff base between pyridoxal 5'-phosphate and vinylglycine, which has been suggested as the key intermediate of L-methionine γ-lyase-caralyzed reactions of S-substituted L-homocysteines [N. Esaki, T. Suzuki, H. Tanaka, K. Soda and R. R. Rando, FEBS Lett., 84, 309 (1977).     

NADP-Specific Glutamate Dehydrogenase from Alkaliphilic Bacillus sp. KSM-635: Purification and Enzymatic Properties

An NADP-specific glutamate dehydrogenase [L-glutamate: NADP⁺ oxidoreductase (deaminating), EC 1.4.1.4] from alkaliphilic Bacillus sp. KSM-635 was purified 5840-fold to homogeneity by a several-step procedure involving Red-Toyopearl affinity chromatography. The native protein, with an isoelectric point of pH 4.87, had a molecular mass of approximately 315 kDa consisting of six identical summits each with a molecular mass of 52 kDa. The pH optima for the aminating and deaminating reactions were 7.5 and 8.5, respectively. The optimum temperature was around 60°C for both. The purified enzyme had a specific activity of 416units/mg protein for the aminating reaction, being over 20-fold greater than that for deaminating reaction, at the respective pH optima and at 30°C. The enzyme was specific for NADPH (K_m 44 μM), 2-oxoglutarate (K_m 3.13 mM), NADP⁺ (K_m 29 μM), and L-glutamate (K_m 6.06 mM). The K_m for NH₄Cl was 5.96 mM. The enzyme could be stored without appreciable loss of enzyme activity at 5°C for half a year in phosphate buffer (pH 7.0) containing 2 mM 2-mercaptoethanol, although the enzyme activity was abolished within 20 h by freezing at ?20°C.     

Biosynthetic Threonine Deaminase from Proteus morganii

Biosynthetic threonine deaminase was purified to an apparent homogeneous state from the cell extract of Proteus morganii, with an overall yield of 7.5%. The enzyme had a s⁰_20,w of 10.0 S, and the molecular weight was calculated to be approximately, 228,000. The molecular weight of a subunit of the enzyme was estimated to be 58,000 by sodium dodecyl sulfate gel electrophoresis. The enzyme seemed to have a tetrameric structure consisting of identical subunits. The enzyme had a marked yellow color with an absorption maximum at 415 nm and contained 2 mol of pyridoxal 5′-phosphate per mol. The threonine deaminase catalyzed the deamination of l-threonine, l-serine, l-cysteine and β-chloro-l-alanine. Km values for l-threonine and l-serine were 3.2 and 7.1 mm, respectively. The enzyme was not activated by AMP, ADP and ATP, but was inhibited by l-isoleucine. The Ki for l-isoleucine was 1.17 mm, and the inhibition was not recovered by l-valine. Treatment with mercuric chloride effectively protected the enzyme from inhibition by l-isoleucine.     

Enzymatic activity of L-amino acid oxidase from snake venom Crotalus adamanteus in supercritical CO2

L-amino acid oxidase (L-AAO) from snake venom Crotalus adamanteus was successfully tested as a catalyst in supercritical CO₂ (SC-CO₂). The enzyme activity was measured before and after exposure to supercritical conditions (40°C, 110 bar). It was found that L-AAO activity slightly increased after SC-CO₂ exposure by up to 15%. L-AAO was more stable in supercritical CO₂ than in phosphate buffer under atmospheric pressure, as well as in the enzyme membrane reactor (EMR) experiment. 3,4-Dihydroxyphenyl-L-alanine (L-DOPA) oxidation was performed in a batch reactor made of stainless steel that could withstand the pressures of SC-CO₂, in which L-amino acid oxidase from C. adamanteus was able to catalyze the reaction of oxidative deamination of L-DOPA in SC-CO₂. For the comparison L-DOPA oxidation was performed in the EMR at 40°C and pressure of 2.5 bar. Productivity expressed as mmol-s of converted L-DOPA after 3?h per change of enzyme activity after 3?h was the highest in SC-CO₂ (1.474?mmol?U^?1), where catalase was present, and the lowest in the EMR (0.457?mmol?U^?1).     

Two novel pyrrolooxazole pigments formed by the Maillard reaction between glucose and threonine or serine

Pyrrolothiazolate formed by the Maillard reaction between l-cysteine and d-glucose has a pyrrolothiazole skeleton as a chromophore. We searched for a Maillard pigment having a pyrrolooxazole skeleton formed from l-threonine or l-serine instead of l-cysteine in the presence of d-glucose. As a result, two novel yellow pigments, named pyrrolooxazolates A and B, were isolated from model solutions of the Maillard reaction containing l-threonine and d-glucose, and l-serine and d-glucose, respectively, and identified as (2R,3S,7aS)-2,3,7,7a-tetrahydro-6-hydroxy-2,5,7a-trimethyl-7-oxo-pyrrolo[2,1-b]oxazole-3-calboxylic acid and (3S,7aS)-2,3,7,7a-tetrahydro-6-hydroxy-5,7a-dimethyl-7-oxo-pyrrolo[2,1-b]oxazole-3-calboxylic acid by instrumental analyses. These compounds were pyrrolooxazole derivatives carrying a carboxy group, and showed the absorption maxima at 300–360 nm under acidic and neutral conditions and at 320–390 nm under alkaline conditions.     

Isolation of 6-hydroxy-L-tryptophan from the fruiting body of Lyophyllum decastes for use as a tyrosinase inhibitor

ABSTRACT

Tyrosinase is the key enzyme that controls melanin formation. We found that a hot water extract of the lyophilized fruiting body of the fungus Lyophyllum decastes inhibited tyrosinase from Agaricus bisporus. The extract was fractionated by ODS column chromatography, and an active compound was obtained by purification through successive preparative HPLC using an ODS and a HILIC column. Using spectroscopic data, the compound was identified to be an uncommon amino acid, 6-hydroxytryptophan. 6-Hydroxy-L-tryptophan and 6-hydroxy-D-tryptophan were prepared through a Fenton reaction from L-tryptophan and D-tryptophan, respectively. The active compound was determined to be 6-hydroxy-L-tryptophan by comparison of their circular dichroism spectra and retention time on HPLC analysis of the N^α-(5-fluoro-2,4-dinitrophenyl)-L-leuciamide derivative with those of 6-hydroxy-L-tryptophan and 6-hydroxy-D-tryptophan. A Lineweaver–Burk plot of the enzyme reaction in the presence of 6-hydroxy-L-tryptophan indicated that this compound was a competitive inhibitor. The IC₅₀ values of 6-hydroxy-L-tryptophan was 0.23 mM.     

Structure of Rugulovasine A,B and their Derivatives

Culture conditions for the preparation of cells containing high tyrosine phenol lyase activity were studied with Erwinia herbicola ATCC 21434. Adding pyridoxine to the medium enhanced enzyme formation, suggesting that it was utilized as a precursor of the coenzyme, pyridoxal phosphate. Glycerol plus succinic acid; amino acids, such as, DL-methionine, DL-alanine and glycine; and metallic ion, ferrous ion promoted enzyme formation as well as cell growth. Adding L-tyrosine, as inducer, to the culture medium was essential for enzyme formation. However, when large amounts of L-tyrosine were added, the enzyme formation was repressed by the phenol liberated from L-tyrosine. In fact, formation of the enzyme was enhanced by removing phenol during cultivation. L(D)-Phenylalanine or phenylpyruvic acid had a synergistic effect on the induction of enzyme by L-tyrosine.

Cells with high enzyme activity were prepared by growing cells at 28°C for 28 hr in a medium containing 0.2% L-tyrosine, 0.2% KH₂PO₄, 0.1% MgSO₄7H₂O, 0.001% FeSO_4·7H₂O, 0.01% pyridoxine-HC1, 0.6% glycerol, 0.5% succinic acid, 0.1% DL-methionine, 0.2% DL-alanine, 0.05% glycine, 0.1% L-phenylalanine and 120 ml/liter hydrolyzed soybean protein in tap water with the pH controlled at 7.5 throughout cultivation.     

Purification and Characterization of Novel N-Acyl-D-aspartate Amidohydrolase from Alcaligenes xylosoxydans subsp. xylosoxydans A-6

Alcaligenes xylosoxydans subsp. xylosoxydans A-6 (Alcaligenes A-6) produced N-acyl-D-aspartate amidohydrolase (D-AAase) in the presence of N-acetyl-D-aspartate as an inducer. The enzyme was purified to homogeneity. The enzyme had a molecular mass of 56 kDa and was shown by sodium dodecyl sulfate (SDS)–polyacrylamide gel electrophoresis (PAGE) to be a monomer. The isoelectric point was 4.8. The enzyme had maximal activity at pH 7.5 to 8.0 and 50°C, and was stable at pH 8.0 and up to 45°C. N-Formyl (K_m=12.5 mM), N-acetyl (K_m=2.52 mM), N-propionyl (K_m=0.194 mM), N-butyryl (K_m=0.033 mM), and N-glycyl (K_m =1.11 mM) derivatives of D-aspartate were hydrolyzed, but N-carbobenzoyl-D-aspartate, N-acetyl-L-aspartate, and N-acetyl-D-glutamate were not substrates. The enzyme was inhibited by both divalent cations (Hg²⁺, Ni²⁺, Cu²⁺) and thiol reagents (N-ethylmaleimide, iodoacetic acid, dithiothreitol, and p-chloromercuribenzoic acid). The N-terminal amino acid sequence and amino acid composition were analyzed.     

Mutant of Escherichia coli Tolerant to the Lysis Induced by Cephalexin

2,3-Diaminopropionate ammonia-lyase (DAPAL), which catalyzes α,β-elimination of 2,3-diaminopropionate regardless of its stereochemistry, was purified from Salmonella typhimurium. We cloned the Escherichia coli ygeX gene encoding a putative DAPAL and purified the gene product to homogeneity. The protein obtained contained pyridoxal 5′-phosphate and was composed of two identical subunits with a calculated molecular weight of 43,327. It catalyzed the α,β-elimination of both D- and L-2,3-diaminopropionate. The results confirmed that ygeX encoded DAPAL. The enzyme acted on D-serine, but its catalytic efficiency was only 0.5% that with D-2,3-diaminopropionate. The enzymologic properties of E. coli DAPAL resembled those of Salmonella DAPAL, except that L-serine, D- and L-β-Cl-alanine were inert as substrates of the enzyme from E. coli. DAPAL had significant sequence similarity with the catalytic domain of L-threonine dehydratase, which is a member of the fold-type II group of pyridoxal phosphate enzymes, together with D-serine dehydratase and mammalian serine racemase.