A note on the effect of sporulation conditions on the resistance of Bacillus spores to heat and chemicals

Spores of Bacillus subtilis SA22 harvested after 22 d incubation on nutrient agar at 30°C were more resistant to 0–04% peracetic acid at 20°C than spores harvested following 2 d incubation. Similarly, spores of B. subtilis globigii B17, harvested after 7 d incubation on a sporulation agar were up to 10 times less resistant to 0.04% peracetic acid at 20°C than spores harvested after 35 d incubation. An increase in resistance to heating at 100°C and to exposure to 17.7% hydrogen peroxide at 20°C occurred as the age of B. subtilis SA22 spores prior to harvesting increased, whereas differences in resistance were not observed with spores of B. subtilis globigii B17.     

Comparative sporicidal effects of liquid chemical agents.

We compared the effectiveness of glutaraldehyde, formaldehyde, hydrogen peroxide, peracetic acid, cupric ascorbate (plus a sublethal amount of hydrogen peroxide), sodium hypochlorite, and phenol to inactivate Bacillus subtilis spores under various conditions. Each chemical agent was distinctly affected by pH, storage time after activation, dilution, and temperature. Only three of the preparations (hypochlorite, peracetic acid, and cupric ascorbate) studied here inactivated more than 99.9% of the spore load after a 30-min incubation at 20 degrees C at concentrations generally used to decontaminate medical devices. Under similar conditions, glutaraldehyde inactivated approximately 90%, and hydrogen peroxide, formaldehyde, and phenol produced little killing of spores in suspension. By kinetic analysis at different temperatures, we calculated the rate of spore inactivation (k) and the activation energy of spore killing (delta E) for each chemical agent. Rates of spore inactivation had a similar delta E value of approximately 20 kcal/mol (ca.83.68 kJ/mol) for every substance tested. The variation among k values allowed a quantitative comparison of liquid germicidal agents.     

Influence of the sporulation temperature upon the heat resistance of Bacillus subtilis

The influence of different sporulation temperatures (30, 37, 44 and 52°C) upon heat resistance of Bacillus subtilis was investigated.
Heat resistance was greater after higher sporulation temperatures. Relation of heat resistance and temperature of sporulation was not linear over all the range of temperatures tested. Heat resistance increased about tenfold in the range of 30–44°C. Sporulation at 52°C did not show any further increase in heat resistance.
This effect was constant over all the range of heating temperatures tested (100–120°C). z value remained constant ( z = 9°C).
Greater heat resistances at higher temperatures of sporulation were not due to selection of more heat resistant cells by a higher sporulation temperature. Spores obtained from cells incubated at 32 or 52°C always possessed heat resistances that corresponded to the sporulation temperature regardless of the incubation temperature of their vegetative cells.     

The oxidative stress response in Bacillus subtilis

Abstract Bacillus subtilis undergoes a typical bacterial stress response when exposed to low concentrations (0.1 mM) of hydrogen peroxide. Protection is thereby induced against otherwise lethal, challenge concentrations (10 mM) of this oxidant and a number of proteins are induced including the scavenging enzymes, catalase and alkyl hydroperoxide reductase, and a putative DNA binding and protecting protein. Induced protection against higher concentrations (10–30 mM) of hydrogen peroxide is eliminated in a catalase-deficient mutant. Both RecA and Spo0A influence the basal but not the induced resistance to hydrogen peroxide. A regulatory mutation has been characterized that affects the inducible phenotype and is constitutively resistant to high concentrations of hydrogen peroxide. This mutant constitutively overexpresses the proteins induced by hydrogen peroxide in the wild-type. The resistance of spores to hydrogen peroxide is partly attributable to binding of small acid soluble proteins by the spore DNA and partly to a second step which coincides with the depletion of the NADH pool, which may inhibit the generation of hydroxyl radicals from hydrogen peroxide.     

Cloning in Bacillus subtilis of temperature-dependent promoter fragments from Bacillus stearothermophilus and Bacillus subtilis

Abstract Using promoter-probe plasmids, more than 200 promoter-containing fragments from Bacillus stearothermophilus and Bacillus subtilis were cloned in B. subtilis . Among these, 15 promoter fragments were highly temperature-dependent in activity compared to the promoter sequence (TTGAAA for the −35 region, TATAAT for the −10 region) of the amylase gene, amyT , from B. stearothermophilus . Some fragments exhibited higher promoter activities at elevated temperature (48°C), others showed higher activities at lower temperature (30°C). Active promoter fragments at higher and lower temperatures were obtained mainly from the thermophile ( B. stearothermophilus ) and the mesophile ( B. subtilis ), respectively. A promoter fragment active at high temperature was sequenced, and the feature of the putative promoter region was discussed.     

Studies on the mechanism of killing of Bacillus subtilis spores by hydrogen peroxide

AIMS: To determine the mechanism of killing of Bacillus subtilis spores by hydrogen peroxide. METHODS AND RESULTS: Killing of spores of B. subtilis with hydrogen peroxide caused no release of dipicolinic acid (DPA) and hydrogen peroxide-killed spores were not appreciably sensitized for DPA release upon a subsequent heat treatment. Hydrogen peroxide-killed spores appeared to initiate germination normally, released DPA and hydrolysed significant amounts of their cortex. However, the germinated killed spores did not swell, did not accumulate ATP or reduced flavin mononucleotide and the cores of these germinated spores were not accessible to nucleic acid stains. CONCLUSIONS: These data indicate that treatment with hydrogen peroxide results in spores in which the core cannot swell properly during spore germination. SIGNIFICANCE AND IMPACT OF THE STUDY: The results provide further information on the mechanism of killing of spores of Bacillus species by hydrogen peroxide.     

Thermal Activation and Dry-heat Inactivation of Spores of Bacillus subtilis MD2 and Bacillus subtilis var. niger

Spores of Bacillus subtilis MD2 and Bacillus subtilis var. niger were heat activated for different times at 60° and 80°C. Strain MD2 required considerable heat activation while B. subtilis var. niger did not. Maximum germination rates increased with heat activation dose and declined subsequently without loss of germinability. Germination rates and percentages were considerably greater in tryptone glucose extract (TGE) than in nutrient broth. The addition of 2°° dimethyl sulphoxide did not increase germination in nutrient broth. The spores of var. niger are more resistant to dry-heat than MD2 although they are less resistant to moist heat. Survivor curves in the dry-heat range 140°-170°C gave D-values from 4–123 to 0.106 min for MD2 and 5.679 to 0.233 min for var. niger recovered on TGE agar. D-values were lower on poorer media. The z-values for MD2 and var. niger on TGE were 18.7°C and 21.25C respectively.     

Sporicidal activity of hydrogen peroxide and peracetic acid against Bacillus anthracis spores

The aim of the presented study was determined the effectiveness of sporicidal activity the peracetic acid and the hydrogen peroxide against B. anthracis spores. In the investigations was used B. anthracis stain "Sterne" 34F2. As inactivators were applied 0,5 % natriumthiosulphate and catalase. The obtained results show that the sporicidal effect of studied substances depends from their concentration and operates time. 5% water solution of peracetic acid shows the full sporicidal activity after outflow 120 minutes and the hydrogen peroxide about concentration 30% after outflow 180 minutes. However the hydrogen peroxide.     

The bactericidal, fungicidal and sporicidal properties of hydrogen peroxide and peracetic acid

The antimicrobial properties of aqueous solutions of peracetic acid and hydrogen peroxide have been compared. Peracetic acid exhibited excellent antimicrobial properties, especially under acidic conditions. Reductions by a factor of 10⁶ in the numbers of vegetative bacteria are obtained within 1 min at 25°C using a solution containing 1.3 mmol/l of peracetic acid. Rapid activity against bacterial spores and yeasts also occurs. Hydrogen peroxide is more effective as a sporicide than as a bactericide, with sporicidal action being obtained using a solution containing 0.88 mol/l. Bactericidal action is poor but hydrogen peroxide was bacteriostatic at concentrations above 0.15 mmol/l.     

Analysis of the properties of spores of Bacillus subtilis prepared at different temperatures

AIMS: To determine the effect of sporulation temperature on Bacillus subtilis spore resistance and spore composition. METHODS AND RESULTS: Bacillus subtilis spores prepared at temperatures from 22 to 48 degrees C had identical amounts of dipicolinic acid and small, acid-soluble proteins but the core water content was lower in spores prepared at higher temperatures. As expected from this latter finding, spores prepared at higher temperatures were more resistant to wet heat than were spores prepared at lower temperatures. Spores prepared at higher temperatures were also more resistant to hydrogen peroxide, Betadine, formaldehyde, glutaraldehyde and a superoxidized water, Sterilox. However, spores prepared at high and low temperatures exhibited nearly identical resistance to u.v. radiation and dry heat. The cortex peptidoglycan in spores prepared at different temperatures showed very little difference in structure with only a small, albeit significant, increase in the percentage of muramic acid with a crosslink in spores prepared at higher temperatures. In contrast, there were readily detectable differences in the levels of coat proteins in spores prepared at different temperatures and the levels of at least one coat protein, CotA, fell significantly as the sporulation temperature increased. However, this latter change was not due to a reduction in cotA gene expression at higher temperatures. CONCLUSIONS: The temperature of sporulation affects a number of spore properties, including resistance to many different stress factors, and also results in significant alterations in the spore coat and cortex composition. SIGNIFICANCE AND IMPACT OF THE STUDY: The precise conditions for the formation of B. subtilis spores have a large effect on many spore properties.     

Injury and repair in biocide-treated spores of Bacillus subtilis

Abstract Bacillus subtilis NCTC 8236 spores exposed to appropriate concentrations of test biocides (glutaraldehyde, two iodine and two chlorine preparations) were able to repair injury if subsequently held in nutrient broth at 37°C but not in broth at 22°C, sterile filtered water at 4, 22 or 37°C or germination medium at 37°C. Repair appeared to occur primarily during outgrowth and was initiated soonest for iodine-treated spores and latest for glutaraldehyde-treated ones.     

The effect of acid shock on sporulating Bacillus subtilis cells

AIMS: To study the effect of acid shock in sporulation on the production of acid-shock proteins, and on the heat resistance and germination characteristics of the spores formed subsequently. METHODS AND RESULTS: Bacillus subtilis wild-type (SASP-alpha+beta+) and mutant (SASP-alpha-beta-) cells in 2 x SG medium at 30 degrees C were acid-shocked with HCl (pH 4, 4.3, 5 and 6 against a control pH of 6.2) for 30 min, 1 h into sporulation. The D85-value of B. subtilis wild-type (but not mutant) spores formed from sporulating cells acid-shocked at pH 5 increased from 46.5 min to 78.8 min, and there was also an increase in the resistance of wild-type acid-shocked spores at both 90 degrees C and 95 degrees C. ALA- or AGFK-initiated germination of pH 5-shocked spores was the same as that of non-acid-shocked spores. Two-dimensional gel electrophoresis showed only one novel acid-shock protein, identified as a vegetative catalase 1 (KatA), which appeared 30 min after acid shock but was lost later in sporulation. CONCLUSIONS: Acid shock at pH 5 increased the heat resistance of spores subsequently formed in B. subtilis wild type. The catalase, KatA, was induced by acid shock early in sporulation, but since it was degraded later in sporulation, it appears to act to increase heat resistance by altering spore structure. SIGNIFICANCE AND IMPACT OF THE STUDY: This is the first proteomic study of acid shock in sporulating B. subtilis cells. The increasing spore heat resistance produced by acid shock may have significance for the heat resistance of spores formed in the food industry.     

Studies on the Mechanism of the Sporicidal Action of Glutaraldehyde

S ummary . Low concentrations (0.025–0.125%) of glutaraldehyde inhibited or prevented colony formation by Escherichia coli, Bacillus subtilis and B. pumilis in agar, and inhibited germination of spores of the Bacillus spp. in L-alanine plus D-glucose. Higher concentrations (2%) of glutaraldehyde at pH 8.5 were sporicidal. Pre-treatment of spores with glutaraldehyde lessened release of dipicolinic acid when the spores were subsequently heated at 100°, but not at 121°. Spores treated with glutaraldehyde and then with 0.5 M thioglycollic acid in 6 M urea at 70° were less sensitive to lysis by hydrogen peroxide than spores which had not been exposed to glutaraldehyde. Glutaraldehyde was less effective in preventing peroxide induced lysis if added to spores which had been previously exposed to thioglycollic acid plus urea at 70°. The mechanism of the sporicidal activity of glutaraldehyde is discussed in relation to these findings.     

Effects of temperature and heat activation on germination of individual spores of Bacillus subtilis

Phase intensity changes of individual germinating spores of Bacillus subtilis were determined by phase-contrast light microscopy and image analysis. Two germination phases were investigated. The length of the time period before a change in phase brightness was evident and the duration of the phase intensity change until a constant greylevel was maintained. The incubation temperature (37 and 20 °C) and heat activation (10 min at 65 °C) had a distinct effect on both phases. At 37 °C, spores of B. subtilis 604 started to show a decrease in brightness in l -alanine buffer after 3–39 min and needed 10–39 min to complete the phase change. At 20 °C, lag times of 10–100 min were observed and the spores needed 30–100 min to reach a constant greylevel. Heat activation and subsequently exposure to l -alanine buffer at 20 °C reduced the lag phase to 6–90 min and the phase change was finished after 30–60 min. Our results indicate enzymatic involvement before and during the phase intensity change of germinating spores.     

Binding of small, acid-soluble spore proteins to DNA plays a significant role in the resistance of Bacillus subtilis spores to hydrogen peroxide.

Dormant spores of Bacillus subtilis which lack the majority of the alpha/beta-type small, acid-soluble proteins (SASP) (termed alpha- beta- spores) that coat the DNA in wild-type spores are significantly more sensitive to hydrogen peroxide than are wild-type spores. Hydrogen peroxide treatment of alpha- beta- spores causes DNA strand breaks more readily than does comparable treatment of wild-type spores, and alpha- beta- spores, but not wild-type spores, which survive hydrogen peroxide treatment have acquired a significant number of mutations. The hydrogen peroxide resistance of wild-type spores appears to be acquired in at least two incremental steps during sporulation. The first increment is acquired at about the time of alpha/beta-type SASP synthesis, and the second increment is acquired approximately 2 h later, at about the time of dipicolinic acid accumulation. During sporulation of the alpha- beta- strain, only the second increment of hydrogen peroxide resistance is acquired. In contrast, sporulation mutants which accumulate alpha/beta-type SASP but progress no further in sporulation acquire only the first increment of hydrogen peroxide resistance. These findings strongly suggest that binding of alpha/beta-type SASP to DNA provides one increment of spore hydrogen peroxide resistance. Indeed, binding of alpha/beta-type SASP to DNA in vitro provides strong protection against cleavage of DNA by hydrogen peroxide.     

枯草芽胞杆菌微生态制剂的研制

采用液体发酵工艺,确定枯草芽胞杆菌的最适发酵条件为:发酵温度30℃,初始pH值7.2,并以1%海藻酸钠和3%明胶组成的混合胶体溶液为囊壁材料,以4%氯化钙作固化剂将枯草芽胞杆菌制成微胶囊剂,稳定性试验结果显示经微胶囊包埋的枯草芽胞杆菌制剂,室温下保存1个月,活菌存活率为98.8%,保存3个月,活菌存活率为50.6%,保存6个月,活菌存活率为15.7%,均高于未经微胶囊化的样品;在4℃冷藏下保存3个月,未经微胶囊化的样品活菌存活率仅为经微胶囊包埋制剂的66.2%。该微胶囊制剂提高了活菌存活率,延长了活菌常温保存期。     

Biofilms of a Bacillus subtilis Hospital Isolate Protect Staphylococcus aureus from Biocide Action

The development of a biofilm constitutes a survival strategy by providing bacteria a protective environment safe from stresses such as microbicide action and can thus lead to important health-care problems. In this study, biofilm resistance of a Bacillus subtilis strain (called hereafter ND(medical)) recently isolated from endoscope washer-disinfectors to peracetic acid was investigated and its ability to protect the pathogen Staphylococcus aureus in mixed biofilms was evaluated. Biocide action within Bacillus subtilis biofilms was visualised in real time using a non-invasive 4D confocal imaging method. The resistance of single species and mixed biofilms to peracetic acid was quantified using standard plate counting methods and their architecture was explored using confocal imaging and electronic microscopy. The results showed that the ND(medical) strain demonstrates the ability to make very large amount of biofilm together with hyper-resistance to the concentration of PAA used in many formulations (3500 ppm). Evidences strongly suggest that the enhanced resistance of the ND(medical) strain was related to the specific three-dimensional structure of the biofilm and the large amount of the extracellular matrix produced which can hinder the penetration of peracetic acid. When grown in mixed biofilm with Staphylococcus aureus, the ND(medical) strain demonstrated the ability to protect the pathogen from PAA action, thus enabling its persistence in the environment. This work points out the ability of bacteria to adapt to an extremely hostile environment, and the necessity of considering multi-organism ecosystems instead of single species model to decipher the mechanisms of biofilm resistance to antimicrobials agents.     

Induction and cultivation of a stable L-form of Bacillus subtilis

The induction of L-forms of Bacillus subtilis from protoplasts is described. The method involved the frequent subculture of the unstable L-form on a growth medium supplemented with lysozyme and horse serum. A stable culture, which did not revert when lysozyme and horse serum were omitted from the medium, was obtained after 13 subcultures. This culture could be grown on solid and in liquid medium by routine microbiological methods. Long-term storage of these cells was achieved by freeze drying and maintenance in glycerol at −70°C. The cultural adaptability of the L-form is described and discussed with respect to methods of cultivation and growth.     

The Effect of Sporulation Temperature on the Resistance of Bacillus subtilis to a Chemical Inhibitor

The ability of spores of Bacillus subtilis to germinate at 50° in sublethal concentrations of chlorocresol is related to sporulation temperature as is the resistance of the subsequent outgrowth at 50° to this substance. The degree of germination, age of spores and amount of outgrowth produced are of minor importance in determining resistance of the outgrowth.     

Decontamination assessment of Bacillus anthracis, Bacillus subtilis, and Geobacillus stearothermophilus spores on indoor surfaces using a hydrogen peroxide gas generator

AIMS: To evaluate the decontamination of Bacillus anthracis, Bacillus subtilis, and Geobacillus stearothermophilus spores on indoor surface materials using hydrogen peroxide gas. METHODS AND RESULTS: Bacillus anthracis, B. subtilis, and G. stearothermophilus spores were dried on seven types of indoor surfaces and exposed to > or =1000 ppm hydrogen peroxide gas for 20 min. Hydrogen peroxide exposure significantly decreased viable B. anthracis, B. subtilis, and G. stearothermophilus spores on all test materials except G. stearothermophilus on industrial carpet. Significant differences were observed when comparing the reduction in viable spores of B. anthracis with both surrogates. The effectiveness of gaseous hydrogen peroxide on the growth of biological indicators and spore strips was evaluated in parallel as a qualitative assessment of decontamination. At 1 and 7 days postexposure, decontaminated biological indicators and spore strips exhibited no growth, while the nondecontaminated samples displayed growth. CONCLUSIONS: Significant differences in decontamination efficacy of hydrogen peroxide gas on porous and nonporous surfaces were observed when comparing the mean log reduction in B. anthracis spores with B. subtilis and G. stearothermophilus spores. SIGNIFICANCE AND IMPACT OF THE STUDY: These results provide comparative information for the decontamination of B. anthracis spores with surrogates on indoor surfaces using hydrogen peroxide gas.