Effect of pH on Adenine and Amino Acid Uptake During Sporulation in Saccharomyces cerevisiae

During the early stages of sporulation in Saccharomyces cerevisiae, the pH of the acetate sporulation medium rises to values of 8.0 or higher. Associated with this rise in pH is a reduced cell permeability to certain precursors of ribonucleic acid (RNA), deoxyribonucleic acid or protein. Uptake of adenine, alanine, and leucine was optimal at pH 5.6 to 6.0, but sporulation was inhibited when the sporulation medium was buffered below pH 7.0. Cellular impermeability can be largely overcome by adjusting the acetate sporulation medium to pH 6.0 for optimal uptake of ¹⁴ C-adenine during short pulses without any apparent effect on sporulation. Sporulating cells pulse-labeled 20 min at pH 6.0 incorporated 40 times more ¹⁴C-adenine into RNA than sporulating cells pulse-labeled at pH 8.0. This increased incorporation can be attributed to a 100-fold increase in labeled adenosine triphosphate in cells pulse-labeled at pH 6.0 where maximum uptake occurs.     

Production of gluconic acid from glucose by Aspergillus niger: growth and non-growth conditions

Batch fermentation of glucose to gluconic acid was conducted using Aspergillus niger under growth and non-growth conditions using pure oxygen and air as a source of oxygen for the fermentation in 2 and 5 l stirred tank reactors (batch reactor). Production of gluconic acid under growth conditions was conducted in a 5 l batch reactor. Production and growth rates were higher during the period of supplying pure oxygen than that during supplying air, and the substrate consumption rate was almost constant. For the production of gluconic acid under non-growth conditions, conducted in the 2 l batch reactor, the effect of the pure oxygen flow rate and the biomass concentration on the gluconic acid production was investigated and an empirical equation suggested to show the dependence of the production rate r_p on the biomass concentration C_x and oxygen flow rate Q, at constant operating conditions (30 °C, 300 rpm and pH 5.5). Biomass concentration had a positive effect on the production rate r_p, and the effect of Q on r_p was positive at high biomass concentrations.     

Production of caproic acid by cocultures of ruminal cellulolytic bacteria and Clostridium kluyveri grown on cellulose and ethanol

Ruminal cellulolytic bacteria (Fibrobacter succinogenes S85 or Ruminococcus flavefaciens FD-1) were combined with the non-ruminal bacterium Clostridium kluyveri and grown together on cellulose and ethanol. Succinate and acetate produced by the cellulolytic organisms were converted to butyrate and caproate only when the culture medium was supplemented with ethanol. Ethanol (244 mM) and butyrate (30 mM at pH 6.8) did not inhibit cellulose digestion or product formation by S85 or FD-1; however caproate (30 mM at pH 6.8) was moderately inhibitory to FD-1. Succinate consumption and caproate production were sensitive to culture pH, with more caproic acid being produced when the culture was controlled at a pH near neutrality. In a representative experiment under conditions of controlled pH (at 6.8) 6.0 g cellulose 1^–1 and 4.4 g ethanol 1^–1 were converted to 2.6 g butyrate 1^–1 and 4.6 g caproate 1^–1. The results suggest that bacteria that efficiently produce low levels of ethanol and acetate or succinate from cellulose should be useful in cocultures for the production of caproic acid, a potentially useful industrial chemical and bio-fuel precursor.Mention of specific products is intended only to provide information and does not contitute an endorsement by the U.S. Department of Agriculture over other products not mentioned.     

Relation Between Iron Uptake, pH of Growth Medium, and Penicillinase Formation in Staphylococcus aureus

The uptake of iron and the formation of penicillinase was examined in cultures of wild-type Staphylococcus aureus. Uptake of iron was about twice as great at pH 4.7 as at pH 7.4 At pH 4.7, increase in iron uptake in the range of 1.0 to 4.0 μg per mg of bacterial protein was associated with a progressive increase in the rate of penicillinase formation, but a direct correlation between cellular iron content and rate of enzyme formation was not demonstrated. Addition of iron to deferrated medium enhanced penicillinase formation at pH 6.5 to 7.4 two- to fourfold in cultures induced with benzylpenicillin and in uninduced cultures. To demonstrate an effect on the uninduced cells, it was necessary to increase iron uptake by preliminary incubation of cells with iron in buffer. Calcium and certain other ions depressed iron uptake at acidic and at neutral pH, and, presumably as a result of this action, depressed the formation of penicillinase. Iron did not enhance penicillinase formation at pH 4.7 by two penicillinase constitutive mutants nor by wild-type cells undergoing induction at pH 6.5 by cephalosporin C or methicillin. After removal of cephalosporin C or methicillin during an early phase of induction, residual synthesis of enzyme was increased by prior uptake of iron. The results are considered compatible with the concept that uptake of iron, especially at acidic pH, interferes with the formation or function of penicillinase repressor.     

Vacuolar Acid hydrolysis as a physiological mechanism for sucrose breakdown

Sucrose breakdown in mature acidic `Persian' limes (Citrus aurantifolia [Christm.] Swing.) occurred at a rate of 30.6 picomoles per milliliter per day during 9 weeks storage at 15°C. Neither enzyme of sucrose catabolism (sucrose synthase or acid/alkaline invertase) was present in extracts of mature storage tissue. The average vacuolar pH, estimated by direct measurement of sap from isolated vacuoles and by the methylamine method, was about 2.0 to 2.2. In vitro acid hydrolysis of sucrose at physiological concentrations in a buffered solution (pH 2.2) occurred at identical rates as in matured limes. The results indicate that sucrose breakdown in stored mature acidic limes occurs by acid hydrolysis.     

Detection of endogenous β-glucuronidase activity in Aspergillus niger

 An endogenous β-glucuronidase that hydrolyses the chromogenic substrate 5-bromo-4-chloro-3-indolyl-β-D-glucuronide (X-gluc) in Aspergillus niger is reported. The activity was induced when the fungus was grown in media containing xylan, but was either very low, or absent, when grown on glucose. Endogenous β-glucuronidase was primarily located in newly formed hyphae, and was apparent at pH values between 3 and 6. Hydrolysis of X-gluc was sensitive to the inhibitor D-saccharic acid 1,4-lactone and was irreversibly inactivated by heating. The bacterial uidAβ-glucuronidase reporter gene was strongly expressed in the hyphae of transformed A. niger but, in contrast to the endogenous activity, the enzyme was also active at pH 7–8.5. Histochemical localization of uidA expression in A. niger, without interference from the endogenous β-glucuronidase activity, was achieved by staining at this pH. Received : 22 March 1995/Received last revision : 17 August 1995/Accepted : 22 August 1995     

Stimulation of fermentation and yeast-like morphogenesis in Mucor rouxii by phenethyl alcohol

The germination of fungal spores into hyphae was inhibited by concentrations of phenethyl alcohol (PEA) from 0.05 to 0.3%. Spores of Mucor formed budding spherical cells instead of filaments. These cells were abundant in cultures of Mucor rouxii at 0.22% PEA, provided that the carbon source was a hexose at 2 to 5%. Morphology was filamentous with xylose, maltose, sucrose, or a mixture of amino acids. Removal of PEA resulted in the conversion of yeast-like cells into hyphae. PEA did not inhibit biosynthesis of cytochromes or oxygen uptake, but it stimulated CO₂ and ethyl alcohol production. PEA had no effect on the rate of oxygen uptake, but it inhibited the oxidative-phosphorylation activity of mitochondria. These results suggested that growth inhibition by PEA could result from uncoupling of oxidative phosphorylation and that, in Mucor, yeast-like morphology and fermentation were linked.     

Extraction of Zinc from Industrial Waste by a Penicillium sp

Zinc was extracted from a filter residue of a copper works (58.6% zinc) by a Penicillium sp. isolated from a metal-containing location. By isotachophoresis citric acid was identified as the leaching agent. Citrate was only formed when the leaching substrate was present. This production of citrate was different in several ways from that achieved by Aspergillus niger: glucose was utilized before fructose; the initial concentration of zinc was 50 to 500 times higher than usual in citrate fermentations with A. niger; citrate production stopped when 80 to 90% of the zinc was leached, although sufficient sugar for further synthesis was still present; and in synthetic media citrate production by A. niger needs an acidic environment (pH 2), while the formation of citric acid by Penicillium sp. occurred in a pH range of 7 to 4. Tests with different concentrations of waste material (0.5, 2.5, and 5%) showed that the highest yield of solubilized zinc occurred with a 2.5% substrate (93% zinc extracted after 13 days).     

Iron and phosphate uptake in epiphytic and saxicolous lichens differing in their pH requirements

The hypothesis is tested that pH-dependent Fe and P uptake influence the preference of epiphytic and saxicolous lichens for certain ranges of ambient pH. Five species from acidic substrata (Hypogymnia physodes, Parmeliopsis ambigua, and Platismatia glauca) or covering the range from weakly acidic to alkaline substrata (Lecanora muralis and Phaeophyscia orbicularis) were exposed to solutions of FeCl₂, FeCl₃, or KH₂PO₄ at pH 3 and 8 in the laboratory. Avoidance of alkaline substrata is explainable by low Fe³⁺ uptake at pH 8 in the case of H. physodes and the inability for net P uptake and membrane damage in P. ambigua at this pH. Preference for acidic substrata in Pl. glauca, however, is neither related to Fe nor P uptake. Efficient Fe³⁺ and P uptake at pH 8 explains the tolerance of L. muralis and Ph. orbicularis to alkaline conditions. Intracellular accumulation of Fe²⁺ in probably toxic amounts at pH 3 in Ph. orbicularis is correlated with the absence of this lichen from strongly acidic substrata. Avoidance of acidic sites by L. muralis is not attributable to Fe or P uptake. In summary, the results suggest that pH-dependent Fe and P uptake characteristics are involved in the determination of pH preferences of epiphytic and saxicolous lichens, but are not the only relevant factor.     

Characterization of metabolically active developmental stage of Aspergillus niger cells immobilized in polyacrylamide gel

Summary The in-situ development of Aspergillus niger entrapped in polyacrylamide gel from spores and the gel surface characteristics were studied during the repeated shake flask batch citric acid fermentation. A marked increase in the rate of citric acid production was observed with the periodic replacement of culture with fresh media at an interval of 6 days reducing the fermentation time nearly to half. The metabolically active A. niger cells for citric acid production were characterized by the appearance of thick and bulbous hyphae scattered in and on the gel surface.     

Author index for volume 171

Kinetic analyses of the irreversible inhibition of l-tyrosine and l-phenylalanine transport in Bacillus subtilis by phenylalanine chloromethyl ketone revealed that the inhibition was due to an affinity labeling process. Phenylalanine chloromethyl ketone is a competetive inhibitor of l-tyrosine and l-phenylalanine transport. The K_i values for irreversible inhibition of l-tyrosine and l-phenylalanine transport were 194 and 177 μm, respectively, and the first order rate constants for the alkylation reaction leading to inactivation of transport of l-tyrosine and l-phenylalanine were 0.016 and 0.012 min^?1, respectively. The similarity of these constants are consistent with the involvement of the same functional site for l-phenylalanine and l-tyrosine transport. A second effect of phenylalanine chloromethyl ketone was inhibition of the uptake of neutral, aliphatic amino acids; transport of basic and acidic amino acids was unaffected by it. Since high concentrations of any amino acid did not reduce the inhibitory effects of phenylalanine chloromethyl ketone on transport of neutral, aliphatic amino acids, an independent effect, not due to an affinity labeling process was inferred. A procedure for selective labeling of the l-tyrosine/l-phenylalanine transport system was demonstrated that should be applicable to the introduction of a radioactive label into the transport protein(s).     

Accumulation and partial re-consumption of polyols during citric acid fermentation by Aspergillus niger

Summary Quantitative balances have been made for sugar and oxygen uptake rates during citric acid accumulation by Aspergillus niger: during the first phase of citric acid accumulation (up to 130 h) more sugar is taken up than the production of biomass, CO₂ and citric acid account for. In contrast, during later phases of fermentation more citric acid, CO₂ and biomass are formed than sugar uptake would theoretically allow. A similar pattern is obtained for oxygen uptake, where less uptake occurs during the early phase of fermentation than needed for complete balance, and the reverse is observed during the late stage of fermentation. It could subsequently be shown that this is caused by the intermediate accumulation and partial re-consumption of a number of polyhydric alcohols (glycerol, arabitol, erythritol and mannitol) during citric acid fermentation.Dedicated to Professor H. J. Rehm on the occasion of his 60th birthday with kind regards     

Profiling of urinary testosterone and luteinizing hormone in exercise-stressed male athletes,using gas chromatography-mass spectrometry and enzyme immunoassay techniques

Knowledge of the effects of episodic or short-term exercise-stress on endogenous testosterone and luteinizing hormone levels still remains fragmentary and inconclusive. In this study, an approach based on the absolute concentrations of urinary total testosterone (T), luteinizing hormone (LH) and the T/LH concentration ratios, was used to profile short-term exercise-stress responses in healthy drug-free male athletes. Testosterone and luteinizing hormone concentrations were measured using gas chromatography-mass spectrometry (GC-MS) and microparticle enzyme immunoassay (MEIA) techniques, respectively. Stress profiles derived from exercise-stress at VO₂max, 68.1% VO₂max and 51.6% VO₂max were plotted using the concentrations of T, LH and the ratios of T/LH found under non-stressed and stressed conditions. Significant changes in LH concentrations (p<0.005) and T/LH ratios (p<0.005) levels were observed between the pre-stress and post-exercise conditions during acute exercise-stress at VO₂max but the T concentration did not show any marked change relative to the non-stressed condition. Whilst exercise-stress appeared to reduce the change in T concentrations between the pre- and post-exercise states compared to that in the non-stressed control condition, the change in LH concentrations showed a moderate increase at submaximal oxygen uptake values. The stress profiles derived from this study facilitated an assessment of the relationship between the endogenous T, LH and T/LH ratio stress-responses over a short period of applied exercise-stress.     

Prokaryotic Communities in Pit Mud from Different-Aged Cellars Used for the Production of Chinese Strong-Flavored Liquor

Chinese strong-flavored liquor (CSFL) accounts for more than 70% of all Chinese liquor production. Microbes in pit mud play key roles in the fermentation cellar for the CSFL production. However, microbial diversity, community structure, and cellar-age-related changes in pit mud are poorly understood. Here, we investigated the prokaryotic community structure and diversity in pit-mud samples with different cellar ages (1, 10, 25, and 50 years) using the pyrosequencing technique. Results indicated that prokaryotic diversity increased with cellar age until the age reached 25 years and that prokaryotic community structure changed significantly between three cellar ages (1, 10, and 25 years). Significant correlations between prokaryotic communities and environmental variables (pH, NH₄⁺, lactic acid, butyric acid, and caproic acid) were observed. Overall, our study results suggested that the long-term brewing operation shapes unique prokaryotic community structure and diversity as well as pit-mud chemistry. We have proposed a three-phase model to characterize the changes of pit-mud prokaryotic communities. (i) Phase I is an initial domestication period. Pit mud is characterized by abundant Lactobacillus and high lactic acid and low pH levels. (ii) Phase II is a transition period. While Lactobacillus abundance decreases dramatically, that of Bacteroidetes and methanogens increases. (iii) Phase III is a relative mature period. The prokaryotic community shows the highest diversity and capability to produce more caproic acid as a precursor for synthesis of ethyl caproate, the main flavor component in CSFL. This research provides scientific evidence to support the practical experience that old fermentation cellars produce high-quality liquor.     

Expression of Lactate Dehydrogenase in Aspergillus niger for L-Lactic Acid Production

Different engineered organisms have been used to produce L-lactate. Poor yields of lactate at low pH and expensive downstream processing remain as bottlenecks. Aspergillus niger is a prolific citrate producer and a remarkably acid tolerant fungus. Neither a functional lactate dehydrogenase (LDH) from nor lactate production by A. niger is reported. Its genome was also investigated for the presence of a functional ldh. The endogenous A. niger citrate synthase promoter relevant to A. niger acidogenic metabolism was employed to drive constitutive expression of mouse lactate dehydrogenase (mldhA). An appraisal of different branches of the A. niger pyruvate node guided the choice of mldhA for heterologous expression. A high copy number transformant C12 strain, displaying highest LDH specific activity, was analyzed under different growth conditions. The C12 strain produced 7.7 g/l of extracellular L-lactate from 60 g/l of glucose, in non-neutralizing minimal media. Significantly, lactate and citrate accumulated under two different growth conditions. Already an established acidogenic platform, A. niger now promises to be a valuable host for lactate production.     

Synthesis of methyl ketones by metabolically engineered Escherichia coli

Methyl ketones are a group of highly reduced platform chemicals with widespread applications in the fragrance, flavor and pharmacological industries. Current methods for the industrial production of methyl ketones include oxidation of hydrocarbons, but recent advances in the characterization of methyl ketone synthases from wild tomato have sparked interest towards the development of microbial platforms for the industrial production of methyl ketones. A functional methyl ketone biosynthetic pathway was constructed in Escherichia coli by over-expressing two genes from Solanum habrochaites: shmks2, encoding a 3-ketoacyl-ACP thioesterase, and shmks1, encoding a beta-decarboxylase. These enzymes enabled methyl ketone synthesis from 3-ketoacyl-ACP, an intermediate in the fatty acid biosynthetic cycle. The production of 2-nonanone, 2-undecanone, and 2-tridecanone by MG1655 pTH-shmks2-shmks1 was initially detected by nuclear magnetic resonance and gas chromatography–mass spectrometry analyses at levels close to 6?mg/L. The deletion of major fermentative pathways leading to ethanol (adhE), lactate (ldhA), and acetate (pta, poxB) production allowed for the carbon flux to be redirected towards methyl ketone production, doubling total methyl ketone concentration. Variations in methyl ketone production observed under different working volumes in flask experiments led to a more detailed analysis of the effects of oxygen availability on methyl ketone concentration in order to determine optimal levels of oxygen. The methyl ketone concentration achieved with MG1655 ?adhE ?ldhA ?poxB ?pta pTrcHis2A-shmks2-shmks1, the best performer strain in this study, was approximately 500?mg/L, the highest reported for an engineered microorganism. Through the establishment of optimal operating conditions and by executing rational metabolic engineering strategies, we were able to increase methyl ketone concentrations by almost 75-fold from the initial confirmatory levels.     

Role of glutamine synthetase in citric acid fermentation byAspergillus niger

The activity of glutamine synthetase fromAspergillus niger was significantly lowered under conditions of citric acid fermentation. The intracellular pH of the organism as determined by bromophenol blue dye distribution and fluorescein diacetate uptake methods was relatively constant between 6·0–6·5, when the pH of the external medium was varied between 2·3–7·0.Aspergillus niger glutamine synthetase was rapidly inactivated under acidic pH conditions and Mn²⁺ ions partially protected the enzyme against this inactivation. Mn²⁺-dependent glutamine synthetase activity was higher at acidic pH (6·0) compared to Mg²⁺-supported activity. While the concentration of Mg²⁺ required to optimally activate glutamine synthetase at pH 6·0 was very high (≥ 50 mM), Mn²⁺ was effective at 4 mM. Higher concentrations of Mn²⁺ were inhibitory. The inhibition of both Mn²⁺ and Mg²⁺-dependent reactions by citrate, 2-oxoglutarate and ATP were probably due to their ability to chelate divalent ions rather than as regulatory molecules. This suggestion was supported by the observation that a metal ion chelator, EDTA also produced similar effects. Of the end-products of the pathway, only histidine, carbamyl phosphate, AMP and ADP inhibitedAspergillus niger glutamine synthetase. The inhibitions were more pronounced when Mn²⁺ was the metal ion activator and greater inhibition was observed at lower pH values. These results permit us to postulate that glutamine synthesis may be markedly inhibited when the fungus is grown under conditions suitable for citric acid production and this block may result in delinking carbon and nitrogen metabolism leading to acidogenesis     

The role of coproporphyrinogen III oxidase and ferrochelatase genes in heme biosynthesis and regulation in Aspergillus niger

Heme is a suggested limiting factor in peroxidase production by Aspergillus spp., which are well-known suitable hosts for heterologous protein production. In this study, the role of genes coding for coproporphyrinogen III oxidase (hemF) and ferrochelatase (hemH) was analyzed by means of deletion and overexpression to obtain more insight in fungal heme biosynthesis and regulation. These enzymes represent steps in the heme biosynthetic pathway downstream of the siroheme branch and are suggested to play a role in regulation of the pathway. Based on genome mining, both enzymes deviate in cellular localization and protein domain structure from their Saccharomyces cerevisiae counterparts. The lethal phenotype of deletion of hemF or hemH could be remediated by heme supplementation confirming that Aspergillus niger is capable of hemin uptake. Nevertheless, both gene deletion mutants showed an extremely impaired growth even with hemin supplementation which could be slightly improved by media modifications and the use of hemoglobin as heme source. The hyphae of the mutant strains displayed pinkish coloration and red autofluorescence under UV indicative of cellular porphyrin accumulation. HPLC analysis confirmed accumulation of specific porphyrins, thereby confirming the function of the two proteins in heme biosynthesis. Overexpression of hemH, but not hemF or the aminolevulinic acid synthase encoding hemA, modestly increased the cellular heme content, which was apparently insufficient to increase activity of endogenous peroxidase and cytochrome P450 enzyme activities. Overexpression of all three genes increased the cellular accumulation of porphyrin intermediates suggesting regulatory mechanisms operating in the final steps of the fungal heme biosynthesis pathway.     

Reduced by-product formation and modified oxygen availability improve itaconic acid production in Aspergillus niger

Aspergillus niger has an extraordinary potential to produce organic acids as proven by its application in industrial citric acid production. Previously, it was shown that expression of the cis-aconitate decarboxylase gene (cadA) from Aspergillus terreus converted A. niger into an itaconic acid producer (Li et al., Fungal Genet Bio 48: 602–611, 2011). After some initial steps in production optimization in the previous research (Li et al., BMC biotechnol 12: 57, 2012), this research aims at modifying host strains and fermentation conditions to further improve itaconic acid production. Expression of two previously identified A. terreus genes encoding putative organic acid transporters (mttA, mfsA) increased itaconic acid production in an A. niger cis-aconitate decarboxylase expressing strain. Surprisingly, the production did not increase further when both transporters were expressed together. Meanwhile, oxalic acid was accumulated as a by-product in the culture of mfsA transformants. In order to further increase itaconic acid production and eliminate by-product formation, the non-acidifying strain D15#26 and the oxaloacetate acetylhydrolase (oahA) deletion strain AB 1.13 ?oahA #76 have been analyzed for itaconic acid production. Whereas cadA expression in AB 1.13 ?oahA #76 resulted in higher itaconic acid production than strain CAD 10.1, this was not the case in strain D15#26. As expected, oxalic acid production was eliminated in both strains. In a further attempt to increase itaconic acid levels, an improved basal citric acid-producing strain, N201, was used for cadA expression. A selected transformant (N201CAD) produced more itaconic acid than strain CAD 10.1, derived from A. niger strain AB1.13. Subsequently, we have focused on the influence of dissolved oxygen (D.O.) on itaconic acid production. Interestingly, reduced D.O. levels (10–25 %) increased itaconic acid production using strain N201 CAD. Similar results were obtained in strain AB 1.13 CAD + HBD2.5 (HBD 2.5) which overexpressed a fungal hemoglobin domain. Our results showed that overexpression of the hemoglobin domain increased itaconic acid production in A. niger at lower D.O. levels. Evidently, the lower levels of D.O. have a positive influence on itaconic acid production in A. niger strains.     

Primary Action of Indole-3-acetic Acid in Crown Gall Tumors: Increase of Solute Uptake

Exogenously added indole-3-acetic acid at a concentration of 100 micromolars stimulates d-glucose uptake (or 3-O-methyl-d-glucose uptake) by 25% in crown gall tumors induced on potato tuber tissue by Agrobacterium tumefaciens strain C 58. The titration of the endogenous IAA with the auxin antagonist 2-naphthaleneacetic acid at 100 micromolars reduces d-glucose uptake by about 80%. The apparent inhibition constant K_i is 21 micromolars. Other auxin antagonists like 1-naphthoxyacetic acid and 2-(p-chlorophenoxy)-2-methylpropionic acid show similar effects. The uptake of the amino acids leucine, methionine, tryptophan, lysine, and aspartic acid is also inhibited by 2-naphthaleneacetic acid to similar degrees. The auxins 1-naphthaleneacetic acid and 2-naphthoxyacetic acid at concentrations between 10 and 100 micromolars inhibit solute uptake only slightly (inhibition less than 20%). The impact of the results on the postulated role of indole-3-acetic acid as a modifier of the electrochemical proton gradient across the plasmalemma in crown gall tumor tissue is discussed.