Critical evaluation of sampling techniques for residual glucose determination in carbon-limited chemostat culture of Saccharomyces cerevisiae

In this paper, three sampling techniques for rapid quenching of cellular metabolism and subsequent separation of cells from fermentation broth are compared: (i) quick freezing of fermentation broth directly in liquid nitrogen; (ii) quenching metabolism by exposing the fermentation broth to stainless steel beads (4-mm diameter) in a filter syringe precooled to -18 degrees C; and (iii) withdrawal of the filtrate through a 0.45 microm filter attached to a syringe and a needle inserted directly into the fermentor. It was concluded that use of liquid nitrogen as a quenching method to rapidly arrest cellular metabolism, for quantitative analysis of extracellular glucose, is not a very reliable method and that the filter syringe steel beads work very well.     

cAMP-dependent phosphoprotein changes in the yeast Saccharomyces cerevisiae

Abstract cAMP-dependent phosphoprotein changes were determined using 1-dimensional SDS-gel electrophoresis in a cAMP-requiring yeast mutant ( Saccharomyces cerevisiae AM18). During cAMP starvation, the yeast cells accumulated 3 ³²P-labeled bands with M _r/ 72000, 54000, and 37000. The M _r/ 72000 protein was the most prominent phosphorylated protein. After the readdition of cAMP, these phosphoproteins lost their ³²P-label while phosphoproteins with M _r/ 76000, 65000, 56000 and 30000 were accumulated. Similar phosphoprotein changes were also detected in cdc35 at the nonpermissive temperature, but not in wildtype (A363A) or cdc7 strains of S. cerevisiae .     

Anomalies in the growth kinetics of Saccharomyces cerevisiae strains in aerobic chemostat cultures

Aerobic glucose-limited chemostat cultivations were conducted with Saccharomyces cerevisiae strains NRRL Y132, ATCC 4126 and CBS 8066, using a complex medium. At low dilution rates all three strains utilised glucose oxidatively with high biomass yield coefficients, no ethanol production and very low steady-state residual glucose concentrations in the culture. Above a threshold dilution rate, respiro-fermentative (oxido-reductive) metabolism commenced, with simultaneous respiration and fermentation occurring, which is typical of Crabtree-positive yeasts. However, at high dilution rates the three strains responded differently. At high dilution rates S. cerevisiae CBS 8066 produced 7–8 g ethanol L⁻¹ from 20 g glucose L⁻¹ with concomitant low levels of residual glucose, which increased markedly only close to the wash-out dilution rate. By contrast, in the respiro-fermentative region both S. cerevisiae ATCC 4126 and NRRL Y132 produced much lower levels of ethanol (3–4 g L⁻¹) than S. cerevisiae CBS 8066, concomitant with very high residual sugar concentrations, which was a significant deviation from Monod kinetics and appeared to be associated either with high growth rates or with a fermentative (or respiro-fermentative) metabolism. Supplementation of the cultures with inorganic or organic nutrients failed to improve ethanol production or glucose assimilation. Journal of Industrial Microbiology & Biotechnology (2000) 24, 231–236. Received 09 August 1999/ Accepted in revised form 18 December 1999     

Sequential inactivation of ammonium and glucose transport in Saccharomyces cerevisiae during fermentation

Abstract Ethanol at concentrations above 12% (v/v) in mineral medium with glucose and with ammonium as the only nitrogen source induced rapid inactivation of the ammonium transport system in the strain IGC 3507 of Saccharomyces cerevisiae terminating protein synthesis. Subsequently, when glucose was present, the glucose transport system was irreversibly inactivated. This two-step mechanism may play a decisive role when ethanol stops fermentation by S. cerevisiae , before all the fermentable sugar has been consumed.     

酿酒酵母在传代过程中生理变化研究进展

酿酒酵母在进行连续传代的过程中,细胞的形态结构以及细胞内的各项生理指标因受胁迫条件的影响而发生改变,细胞出现逐渐衰老现象。深入了解酿酒酵母在传代中的生理变化对酿酒酵母抗衰老研究具有重要意义。文中综述了酿酒酵母在传代过程中各项生理指标的变化,并提出了进一步研究的方向,以期为酵母在工业生产中的抗衰老研究提供理论依据和参考。     

Production of wild-type and peptide fusion cutinases by recombinant Saccharomyces cerevisiae MM01 strains

This study focused on the growth of Saccha-romyces cerevisiae MM01 recombinant strains and the respective production of three extracellular heterologous cutinases: a wild-type cutinase and two cutinases in which the primary structure was fused with the peptides (WP)(2) and (WP)(4), respectively. Different cultivation and strategies were tested in a 2-L shake flask and a 5-L bioreactor, and the respective cell growth and cutinase production were analyzed and compared for the three yeast strains. The highest cutinase productions and productivities were obtained in the fed-batch culture, where wild-type cutinase was secreted up to a level of cutinase activity per dry cell weight (specific cell activity) of 4.1 Umg(-1) with activity per protein broth (specific activity) of 266 Umg(-1), whereas cutinase-(WP)(2) was secreted with a specific cell activity of 2.1 Umg(-1) with a specific activity of 200 Umg(-1), and cutinase-(WP)(4) with a specific cell activity of 0.7 Umg(-1) with a specific activity of 15 Umg(-1). The results indicate that the fusion of hydrophobic peptides to cutinase that changes the physical properties of the fused protein limits cutinase secretion and subsequently leads to a lower plasmid stability and lower yeast cell growth. These effects were observed under different cultivation conditions (shake flask and bioreactor) and cultivation strategies (batch culture versus fed-batch culture).     

Heterologous expression of a Clostridium minicellulosome in Saccharomyces cerevisiae

The yeast Saccharomyces cerevisiae was genetically modified to assemble a minicellulosome on its cell surface by heterologous expression of a chimeric scaffoldin protein from Clostridium cellulolyticum under the regulation of the phosphoglycerate kinase 1 ( PGK1 ) promoter and terminator regulatory elements, together with the β-xylanase 2 secretion signal of Trichoderma reesei and cell wall protein 2 (Cwp2) of S. cerevisiae . Fluorescent microscopy and Far Western blot analysis confirmed that the Scaf3p is targeted to the yeast cell surface and that the Clostridium thermocellum cohesin domain is functional in yeast. Similarly, functionality of the C. thermocellum dockerin domain in yeast is shown by binding to the Scaf3 protein in Far Western blot analysis. Phenotypic evidence for cohesin–dockerin interaction was also established with the detection of a twofold increase in tethered endoglucanase enzyme activity in S. cerevisiae cells expressing the Scaf3 protein compared with the parent strain. This study highlights the feasibility to future design of enhanced cellulolytic strains of S. cerevisiae through emulation of the cellulosome concept. Potentially, Scaf3p-armed yeast could also be developed into an alternative cell surface display strategy with various tailor-made applications.     

Kinetic analysis of a trehalase-overexpressing strain grown on trehalose: a new tool for respiro-fermentative transition studies in Saccharomyces cerevisiae

AIMS: The aim was to demonstrate the use of a trehalase-overexpressing Saccharomyces cerevisiae strain grown on trehalose as a valuable tool in the studies of respiro-fermentative transition at a reduced scale. METHODS AND RESULTS: A trehalase-overexpressing strain was cultivated in synthetic medium on trehalose under aerobic conditions. This strain grew at a maximum specific growth rate of 0.16 h(-1) and showed a pure oxidative metabolism. Glucose pulse experiments were carried out in this system in order to quantify the short-term Crabtree effect. These data were then compared with glucose pulse experiments carried out in the conventional way with the wild-type strain in glucose-limited chemostats. Glucose-pulse experiments in aerobic batch cultures grown on trehalose led to a metabolic respiro-fermentative transition similar to the one observed in glucose-limited chemostats. CONCLUSIONS: This cultivation system allowed us to quantitatively mimic at the flask scale the Crabtree effect observed in conventional chemostat studies. SIGNIFICANCE AND IMPACT OF THE STUDY: This study is of primary interest in S. cerevisiae studies in which: (i) the implementation of oxidative growth is required (as with studies of the Crabtree effect and heterologous protein production); (ii) small-scale culture systems are required (e.g. high-throughput mutant screening and isotopic labelling experiments).     

Physiological characterisation of a pyruvate-carboxylase-negative Saccharomyces cerevisiae mutant in batch and chemostat cultures

A prototrophic pyruvate-carboxylase-negative (Pyc-) mutant was constructed by deleting the PYC1 and PYC2 genes in a CEN.PK strain of Saccharomyces cerevisiae. Its maximum specific growth rate on ethanol was identical to that of the isogenic wild type but it was unable to grow in batch cultures in glucose-ammonia media. Consistent with earlier reports, growth on glucose could be restored by supplying aspartate as a sole nitrogen source. Ethanol could not replace aspartate as a source of oxaloacetate in batch cultures. To investigate whether alleviation of glucose repression allowed expression of alternative pathways for oxaloacetate synthesis, the Pyc- strain and an isogenic wild-type strain were grown in aerobic carbon-limited chemostat cultures at a dilution rate of 0.10 h-1 on mixtures of glucose and ethanol. In such mixed-substrate chemostat cultures of the Pyc- strain, steady-state growth could only be obtained when ethanol contributed 30% or more of the substrate carbon in the feed. Attempts to further decrease the ethanol content of the feed invariably resulted in washout. In Pyc- as well as in wild-type cultures, levels of isocitrate lyase, malate synthase and phospho-enol-pyruvate carboxykinase in cell extracts decreased with a decreasing ethanol content in the feed. Nevertheless, at the lowest ethanol fraction that supported growth of the Pyc- mutant, activities of the glyoxylate cycle enzymes in cell extracts were still sufficient to meet the requirement for C4-compounds in biomass synthesis. This suggests that factors other than glucose repression of alternative routes for oxaloacetate synthesis prevent growth of Pyc-mutants on glucose.     

Directed evolution of a secretory leader for the improved expression of heterologous proteins and full‐length antibodies in Saccharomyces cerevisiae

Because of its eukaryotic nature, simple fermentation requirements, and pliable genetics, there have been many attempts at improving recombinant protein production in Saccharomyces cerevisiae. These strategies typically involve altering the expression of a native protein thought to be involved in heterologous protein trafficking. Usually, these approaches yield three‐ to tenfold improvements over wild‐type strains and are almost always specific to one type of protein. In this study, a library of mutant alpha mating factor 1 leader peptides (MFα1pp) is screened for the enhanced secretion of a single‐chain antibody. One of the isolated mutants is shown to enhance the secretion of the scFv up to 16‐fold over wild type. These leaders also confer a secretory improvement to two other scFvs as well as two additional, structurally unrelated proteins. Moreover, the improved leader sequences, combined with strain engineering, allow for a 180‐fold improvement over previous reports in the secretion of full‐length, functional, glycosylated human IgG₁. The production of full‐length IgG₁ at milligram per liter titers in a simple, laboratory‐scale system will significantly expedite drug discovery and reagent synthesis while reducing antibody cloning, production, and characterization costs. Biotechnol. Bioeng. 2009;103: 1192–1201. © 2009 Wiley Periodicals, Inc.     

酿酒酵母基因组位置效应对外源基因表达的影响

外源基因元件和模块在底盘细胞中发挥特定功能是合成生物学研究的基本过程,而外源元件和模块在基因组中的位置对其功能的实现具有显著影响。为了系统、全面地表征酿酒酵母基因组位置效应对外源基因的表达影响,以绿色荧光蛋白为报告基因,通过双交换同源重组方法,对酿酒酵母单基因敲除库进行高通量转化,构建酿酒酵母基因组单位点荧光标记菌株库。结合流式细胞术和高通量测序技术对单位点荧光标记库菌株进行分析,构建高表达位点库和低表达位点库,共发现促进绿色荧光蛋白表达的位点428个,抑制绿色荧光蛋白表达的位点444个。通过分析高、低表达位点在酵母染色体上的分布,从全基因组尺度上对酿酒酵母基因组整合位置对基因表达的影响进行表征。本研究可为酿酒酵母基因组位置效应的分布规律和产生机理研究提供重要参考,对外源蛋白工业生产和合成生物学中的基因表达精细调控也具有重要的指导意义。     

中国酱香型白酒酿造酿酒酵母的独特生理代谢特征

【目的】酿酒酵母是白酒发酵的主要微生物,对白酒的产量及质量都有重要影响。而酱香酒酿造环境具有高温、酸性、高乙醇等胁迫因素,研究其中酿酒酵母的生理代谢特征并有目的地应用于白酒实际生产中的意义。【方法】从酱香酒酿造环境中筛选一株性能优良的酿酒酵母菌株,比较其与酿酒酵母模式菌株S288c和商业酵母的生理代谢特征。【结果】从酱香型酒醅中筛选得到性能优良的Saccharomyces cerevisiae MT1,该菌株可耐受高温42 °C,高浓度乙醇(16%,体积比),低pH (2.0),其最大比生长速率和最大比产乙醇速率分别达到了S288c的125%和114%,其乙醇转化率也要高于其他菌株。一些挥发性物质只有在MT1的发酵液中可检测到,包括苯并噻唑、2,3-二氢苯并呋喃、4-乙烯基愈创木酚以及丁羟甲苯等,MT1的苯乙醇、法呢醇、橙花叔醇、乙偶姻和大马酮量也要高于S288c。另外,MT1可以利用多种碳源发酵产乙醇,如半乳糖、麦芽糖、蜜二糖、松二糖、海藻糖和棉子糖等。【结论】来源于酱香酒酿造的S. cerevisiae MT1具有高耐受力、高效的发酵性能及更广泛的碳源利用图谱,并能生成多种挥发性物质。     

Growth of Saccharomyces cerevisiae in a chemostat under high glucose conditions

Saccharomyces cerevisiae was grown in a chemostat under high glucose conditions (up to 300 g l^–1). The results support the view that higher glucose feed favors higher ethanol production regardless of the existence of osmotic stress. A low glucose utilization and yield coefficient provides an opportunity to improve continuous fermentation performance in the fuel alcohol industry. The possibility exists of reusing yeast cells and subsequently lower operating costs, and by using an optimal glucose feeding concentration between 100 and 200 g l^–1.     

The plasma membrane proteome of Saccharomyces cerevisiae and its response to the antifungal calcofluor

Calcofluor is an antifungal compound known to induce structural perturbations of the cell wall by interfering with the synthesis of chitin microfibril. Proteins from a stripped plasma membrane fraction were solubilized with the neutral and non-denaturing detergent, the n-dodecyl beta-D-maltoside. Proteins were then resolved using a recently described ion-exchange chromatography (IEC)/lithium dodecyl sulfate (LDS)-PAGE procedure. Nearly 90 proteins were identified and clustered, based on their pI, molecular weight, abundance and/or hydrophobicity. This method was then applied to profile the plasma membrane response to calcofluor. The LDS-PAGE patterns obtained from whole plasma membrane proteins were similar for the non-treated and calcofluor-treated samples. However, IEC/LDS-PAGE analysis revealed subtle changes in the expression of several proteins of low abundance, in response to calcofluor. These proteins include Pil1p and Lsp1p, two sphingolipid long-chain base-responsive inhibitors of protein kinases involved in signaling pathways for cell wall integrity and Rho1p, a small GTPase. It was recently hypothesized that Pil1p and Lsp1p could associate with, and regulate, the plasma membrane beta-1-3-glucan synthase, responsible for the synthesis of another major microfibril for yeast cell wall. Results are discussed with respect to both calcofluor effects on the plasma membrane proteins and the power of the IEC/LDS-PAGE procedure in the search for new potential therapeutics targets.     

Discrepancy in glucose and fructose utilisation during fermentation by Saccharomyces cerevisiae wine yeast strains

While unfermented grape must contains approximately equal amounts of the two hexoses glucose and fructose, wine producers worldwide often have to contend with high residual fructose levels (>2 gl(-1)) that may account for undesirable sweetness in finished dry wine. Here, we investigate the fermentation kinetics of glucose and fructose and the influence of certain environmental parameters on hexose utilisation by wine yeast. Seventeen Saccharomyces cerevisiae strains, including commercial wine yeast strains, were evaluated in laboratory-scale wine fermentations using natural Colombard grape must that contained similar amounts of glucose and fructose (approximately 110 gl(-1) each). All strains showed preference for glucose, but to varying degrees. The discrepancy between glucose and fructose utilisation increased during the course of fermentation in a strain-dependent manner. We ranked the S. cerevisiae strains according to their rate of increase in GF discrepancy and we showed that this rate of increase is not correlated with the fermentation capacity of the strains. We also investigated the effect of ethanol and nitrogen addition on hexose utilisation during wine fermentation in both natural and synthetic grape must. Addition of ethanol had a stronger inhibitory effect on fructose than on glucose utilisation. Supplementation of must with assimilable nitrogen stimulated fructose utilisation more than glucose utilisation. These results show that the discrepancy between glucose and fructose utilisation during fermentation is not a fixed parameter but is dependent on the inherent properties of the yeast strain and on the external conditions.     

Soy Peptides Enhance Heterologous Membrane Protein Productivity during the Exponential Growth Phase of Saccharomyces cerevisiae

In this study, the production of eight G protein-coupled receptors by Saccharomyces cerevisiae was compared using two types of media, one of which contained soy peptides and the other free amino acids. Yeast cell growth improved in the medium with soy peptides, and the expression levels of six of the receptors increased during the exponential phase by an average of 2.3-fold as against the free amino acid-based medium. The enhancement of protein expression by soy peptides can be explained by alleviation of metabolite stress due to amino acid source depletion caused by heterologous protein expression.