Mineralization of 14C-Ring-Labeled Synthetic Lignin Correlates with the Production of Lignin Peroxidase, not of Manganese Peroxidase or Laccase

Recently, Mn(II) has been shown to induce manganese peroxidases (MnPs) and repress lignin peroxidases (LiPs) in defined liquid cultures of several white rot organisms. The present work shows that laccase is also regulated by Mn(II). We therefore used Mn(II) to regulate production of LiP, MnP, and laccase activities while determining the effects of Mn(II) on mineralization of ring-labeled synthetic lignin. At a low Mn(II) level, Phanerochaete chrysosporium and Phlebia brevispora produced relatively high titers of LiPs but only low titers of MnPs. At a high Mn(II) level, MnP titers increased 12- to 20-fold, but LiPs were not detected in crude broths. P. brevispora formed much less LiP than P. chrysosporium, but it also produced laccase activity that increased more than sevenfold at the high Mn(II) level. The rates of synthetic lignin mineralization by these organisms were similar and were almost seven times higher at low than at high Mn(II). Increased synthetic lignin mineralization therefore correlated with increased LiP, not with increased MnP or laccase activities.     

Extracellular Enzyme Production and Synthetic Lignin Mineralization by Ceriporiopsis subvermispora

The ability of the white rot fungus Ceriporiopsis subvermispora to mineralize ¹⁴C-synthetic lignin was studied under different culture conditions, and the levels of two extracellular enzymes were monitored. The highest mineralization rates (28% after 28 days) were obtained in cultures containing a growth-limiting amount of nitrogen source (1.0 mM ammonium tartrate); under this condition, the levels of manganese peroxidase (MnP) and laccase present in the culture supernatant solutions were very low compared with cultures containing 10 mM of the nitrogen source. In contrast, cultures containing a limiting concentration of the carbon source (0.1% glucose) showed low levels of both enzymes and also very low mineralization rates compared with cultures containing 1% glucose. Cultures containing 11 ppm of Mn(II) showed a higher rate of mineralization than those containing 0.3 or 40 ppm of this cation. Levels of MnP and laccase were higher when 40 ppm of Mn(II) was used. Mineralization rates were slightly higher in cultures flushed daily with oxygen, whereas laccase levels were lower and MnP levels were approximately the same as in cultures maintained under an air atmosphere. The presence of 0.4 mM veratryl alcohol reduced both mineralization rates and MnP levels, without affecting laccase levels. Lignin peroxidase activity was not detected under any condition. Addition of purified lignin peroxidase to the cultures in the presence or absence of veratryl alcohol did not enhance mineralization rates significantly.     

Production of Manganese Peroxidase and Organic Acids and Mineralization of 14C-Labelled Lignin (14C-DHP) during Solid-State Fermentation of Wheat Straw with the White Rot Fungus Nematoloma frowardii

The basidiomycetous fungus Nematoloma frowardii produced manganese peroxidase (MnP) as the predominant ligninolytic enzyme during solid-state fermentation (SSF) of wheat straw. The purified enzyme had a molecular mass of 50 kDa and an isoelectric point of 3.2. In addition to MnP, low levels of laccase and lignin peroxidase were detected. Synthetic ¹⁴C-ring-labelled lignin (¹⁴C-DHP) was efficiently degraded during SSF. Approximately 75% of the initial radioactivity was released as ¹⁴CO₂, while only 6% was associated with the residual straw material, including the well-developed fungal biomass. On the basis of this finding we concluded that at least partial extracellular mineralization of lignin may have occurred. This conclusion was supported by the fact that we detected high levels of organic acids in the fermented straw (the maximum concentrations in the water phases of the straw cultures were 45 mM malate, 3.5 mM fumarate, and 10 mM oxalate), which rendered MnP effective and therefore made partial direct mineralization of lignin possible. Experiments performed in a cell-free system, which simulated the conditions in the straw cultures, revealed that MnP in fact converted part of the ¹⁴C-DHP to ¹⁴CO₂ (which accounted for up to 8% of the initial radioactivity added) and ¹⁴C-labelled water-soluble products (which accounted for 43% of the initial radioactivity) in the presence of natural levels of organic acids (30 mM malate, 5 mM fumarate).     

Effects of Manganese Peroxidase on Residual Lignin of Softwood Kraft Pulp

Manganese peroxidase treatment lowered the kappa number of kraft pulp and increased the alkali extractability of the residual lignin but did not directly solubilize it. This indicates that MnP partially oxidizes the lignin in the pulp but does not degrade it to soluble fragments.     

Roles of Lignin Peroxidase and Manganese Peroxidase from Phanerochaete chrysosporium in the Decolorization of Olive Mill Wastewaters

The relative contributions of lignin peroxidase (LiP) and manganese peroxidase (MnP) to the decolorization of olive mill wastewaters (OMW) by Phanerochaete chrysosporium were investigated. A relatively low level (25%) of OMW decolorization was found with P. chrysosporium which was grown in a medium with a high Mn(II) concentration and in which a high level of MnP (0.65 (mu)M) was produced. In contrast, a high degree of OMW decolorization (more than 70%) was observed with P. chrysosporium which was grown in a medium with a low Mn(II) concentration but which resulted in a high level of LiP activity (0.3 (mu)M). In this culture medium, increasing the Mn(II) concentration resulted in decreased levels of OMW decolorization and LiP activity. Decolorization by reconstituted cultures of P. chrysosporium was found to be more enhanced by the addition of isolated LiP than by the addition of isolated MnP. The highest OMW decolorization levels were obtained at low initial chemical oxygen demands combined with high levels of extracellular LiP. These data, plus the positive effect of veratryl alcohol on OMW decolorization and LiP activity, indicate that culture conditions which yield high levels of LiP activity lead to high levels of OMW decolorization.     

变色栓菌产锰过氧化物酶的条件优化

研究了多种培养基组分及培养条件对变色栓菌产锰过氧化物酶(MnP)的影响.当培养基中果糖浓度为20g/L,酒石酸铵浓度为10mmoL/L,吐温80浓度为1.0g/L,MgSO4·7H2O为0.43g/L,最终pH为4.5,500mL三角瓶装液量为100mL,接种量为10片(φ8mm)菌苔,培养温度为30℃,转速为280r/min时,MnP的活力有了很大程度的提高,最高酶活力可达2,270U/L.     

Phanerochaete flavido-alba Laccase Induction and Modification of Manganese Peroxidase Isoenzyme Pattern in Decolorized Olive Oil Mill Wastewaters

Lignin-degrading enzymes were partially purified from supernatant solutions obtained from Phanerochaete flavido-alba-decolorized olive oil mill wastewaters (OMW). The dominant enzymes, manganese peroxidases, exhibited different isoform patterns in decolorized OMW-containing cultures than in residue-free samples. Laccase induction was also detected in OMW-containing cultures but not in control cultures.     

Manganese Regulation of Veratryl Alcohol in White Rot Fungi and Its Indirect Effect on Lignin Peroxidase

Many white rot fungi are able to produce de novo veratryl alcohol, which is known to be a cofactor involved in the degradation of lignin, lignin model compounds, and xenobiotic pollutants by lignin peroxidase (LiP). In this study, Mn nutrition was shown to strongly influence the endogenous veratryl alcohol levels in the culture fluids of N-deregulated and N-regulated white rot fungi Bjerkandera sp. strain BOS55 and Phanerochaete chrysosporium BKM-F-1767, respectively. Endogenous veratryl alcohol levels as high as 0.75 mM in Bjerkandera sp. strain BOS55 and 2.5 mM in P. chrysosporium were observed under Mn-deficient conditions. In contrast, veratryl alcohol production was dramatically decreased in cultures supplemented with 33 or 264 (mu)M Mn. The LiP titers, which were highest in Mn-deficient media, were shown to parallel the endogenous veratryl alcohol levels, indicating that these two parameters are related. When exogenous veratryl alcohol was added to Mn-sufficient media, high LiP titers were obtained. Consequently, we concluded that Mn does not regulate LiP expression directly. Instead, LiP titers are enhanced by the increased production of veratryl alcohol. The well-known role of veratryl alcohol in protecting LiP from inactivation by physiological levels of H(inf2)O(inf2) is postulated to be the major reason why LiP is apparently regulated by Mn. Provided that Mn was absent, LiP titers in Bjerkandera sp. strain BOS55 increased with enhanced fungal growth obtained by increasing the nutrient N concentration while veratryl alcohol levels were similar in both N-limited and N-sufficient conditions.     

Control of Lignin Peroxidase Production by Phanerochaete chrysosporium INA-12 by Temperature Shifting

There are two temperature optima connected with lignin peroxidase synthesis by Phanerochaete chrysosporium INA-12. One, at 37°C, is for the mycelium-growing phase; the other, at 30°C, is for the lignin peroxidase-producing phase. One of six extracellular proteins with ligninase activity increased when cultures were grown at 30°C for the entire fermentation period or when cultures were grown at 37°C for the first 2 days of incubation and then shifted to 30°C, compared with the activity of control cultures grown at 37°C for the entire fermentation period. The unsaturation of fatty acid (Δ/mole) of P. chrysosporium INA-12 mycelium decreased from 1.25 to 1.03 when the growth temperature was shifted from 20 to 40°C.     

Secretion of Ligninolytic Enzymes and Mineralization of C-Ring-Labelled Synthetic Lignin by Three Phlebia tremellosa Strains

Production of ligninolytic enzymes by three strains of the white rot fungus Phlebia tremellosa (syn. Merulius tremellosus) was studied in bioreactor cultivation under nitrogen-limiting conditions. The Mn(II) concentration of the growth medium strongly affected the secretion patterns of lignin peroxidase and laccase. Two major lignin peroxidase isoenzymes were expressed in all strains. In addition, laccase and glyoxal oxidase were purified and characterized in one strain of P. tremellosa. In contrast, manganese peroxidase was not found in fast protein liquid chromatography profiles of extracellular proteins under either low (2.4 muM) or elevated (24 and 120 muM) Mn(II) concentrations. However, H(2)O(2)- and Mn-dependent phenol red-oxidizing activity was detected in cultures supplemented with higher Mn(II) levels. Mineralization rates of C-ring-labelled synthetic lignin (i.e., dehydrogenation polymerizate) by all strains under a low basal Mn(II) level were similar to those obtained for Phanerochaete chrysosporium and Phlebia radiata. A high manganese concentration repressed the evolution of CO(2) even when a chelating agent, sodium malonate, was included in the medium.     

Improving the pH-stability of Versatile Peroxidase by Comparative Structural Analysis with a Naturally-Stable Manganese Peroxidase

Versatile peroxidase (VP) from the white-rot fungus Pleurotus eryngii is a high redox potential peroxidase of biotechnological interest able to oxidize a wide range of recalcitrant substrates including lignin, phenolic and non-phenolic aromatic compounds and dyes. However, the relatively low stability towards pH of this and other fungal peroxidases is a drawback for their industrial application. A strategy based on the comparative analysis of the crystal structures of VP and the highly pH-stable manganese peroxidase (MnP4) from Pleurotus ostreatus was followed to improve the VP pH stability. Several interactions, including hydrogen bonds and salt bridges, and charged residues exposed to the solvent were identified as putatively contributing to the pH stability of MnP4. The eight amino acid residues responsible for these interactions and seven surface basic residues were introduced into VP by directed mutagenesis. Furthermore, two cysteines were also included to explore the effect of an extra disulfide bond stabilizing the distal Ca²⁺ region. Three of the four designed variants were crystallized and new interactions were confirmed, being correlated with the observed improvement in pH stability. The extra hydrogen bonds and salt bridges stabilized the heme pocket at acidic and neutral pH as revealed by UV-visible spectroscopy. They led to a VP variant that retained a significant percentage of the initial activity at both pH 3.5 (61% after 24 h) and pH 7 (55% after 120 h) compared with the native enzyme, which was almost completely inactivated. The introduction of extra solvent-exposed basic residues and an additional disulfide bond into the above variant further improved the stability at acidic pH (85% residual activity at pH 3.5 after 24 h when introduced separately, and 64% at pH 3 when introduced together). The analysis of the results provides a rational explanation to the pH stability improvement achieved.     

Secretion of Ligninolytic Enzymes and Mineralization of 14C-Ring-Labelled Synthetic Lignin by Three Phlebia tremellosa Strains

Production of ligninolytic enzymes by three strains of the white rot fungus Phlebia tremellosa (syn. Merulius tremellosus) was studied in bioreactor cultivation under nitrogen-limiting conditions. The Mn(II) concentration of the growth medium strongly affected the secretion patterns of lignin peroxidase and laccase. Two major lignin peroxidase isoenzymes were expressed in all strains. In addition, laccase and glyoxal oxidase were purified and characterized in one strain of P. tremellosa. In contrast, manganese peroxidase was not found in fast protein liquid chromatography profiles of extracellular proteins under either low (2.4 μM) or elevated (24 and 120 μM) Mn(II) concentrations. However, H₂O₂- and Mn-dependent phenol red-oxidizing activity was detected in cultures supplemented with higher Mn(II) levels. Mineralization rates of ¹⁴C-ring-labelled synthetic lignin (i.e., dehydrogenation polymerizate) by all strains under a low basal Mn(II) level were similar to those obtained for Phanerochaete chrysosporium and Phlebia radiata. A high manganese concentration repressed the evolution of ¹⁴CO₂ even when a chelating agent, sodium malonate, was included in the medium.     

Laccase and Manganese Peroxidase Activities of Phellinus Robustus and Ganoderma Adspersum Grown on Food Industry Wastes in Submerged Fermentation

Phellinus robustus produced both laccase (700–4,000 U l⁻¹) and manganese peroxidase (MnP) (1,000–11,300 U l⁻¹) in fermentation of nine food wastes, whereas Ganoderma adspersum produced only laccase (600–34,000 U l⁻¹). Glucose provided high laccase and MnP activity of P. robustus but repressed enzyme production by G. adspersum. Ammonium sulphate and ammonium tartrate increased the P. robustus laccase yield (3-fold), whereas the accumulation of MnP was not enhanced by additional nitrogen.     

Production of Manganese Peroxidase by free pellets ofPhanerochaete chrysosporium in an Expanded-Bed Bioreactor

Summary Continuous production of Manganese Peroxidase by free pellets ofPhanerochaete chrysosporium in an Expanded-Bed Bioreactor was successfully achieved for more than 30 days of operation. The stability in continuous production was attained because of two modifications in the operational policy: an adequate feed control and the supply of oxygen in a pulsing mode. Feed control allowed to stablish an equilibrium between primary and secondary metabolism, thus avoiding metabolic stress. The use of pulsation had two beneficial effects: 1) Increase of stability by avoiding bed compactation during operation performance; 2) Control of mycelial pellet size. The bioreactor operated without oxygen pulsation did not maintain enzyme production longer than 14 days.     

Use of Phanerochaete chrysosporium Immobilized on Kissiris for Synthetic Dye Decolourization: Involvement of Manganese Peroxidase

The mineral Kissiris, which is formed from the thickened foam of volcanic lava, was tested to approximate its mineral composition using energy-dispersive X-ray (EDX) analysis. The solid mineral contains silicon dioxide at about 16 (w/w). The considerable surface roughness of Kissiris along with its extensive porosity made this natural solid cell support an attractive candidate for manganese peroxidase (MnP) production for synthetic dye decolourization, at low cost. The white rot fungus Phanerochaete chrysosporium immobilized on the mineral Kissiris was grown in both stationary and agitated cultures (rotary shaker, 100 rev/min) using either carbon- or nitrogen-limited growth medium to study the ability of the fungus to degrade the synthetic dye methylene blue (MB). The value of residual dye for MB used at 60 ppm was 6% within 8 days of the incubation of the nitrogen-limited culture under the shaken conditions. Production of (MnP) occurred simultaneously in nitrogen-limited culture medium with the added MnSO₄ at 100 ppm. The MnP activity was at relatively high level (170 U/l).     

Manganese-Dependent Cleavage of Nonphenolic Lignin Structures by Ceriporiopsis subvermispora in the Absence of Lignin Peroxidase

Vol. 62, no. 10, p. 3684, column 2, line 16: "Tri(methylsilyl)" should read "Tri(trimethylsilyl)." Line 17: "Di(methylsilyl)" should read "Di(trimethylsilyl)." Line 20: "Tri(methylsilyl)" should read "Trimethylsilyl." Page 3686, column 1, reference 12: The journal should be Dokl. Akad. Nauk Belarusi. [This corrects the article on p. 3679 in vol. 62.].     

Manganese-Dependent Cleavage of Nonphenolic Lignin Structures by Ceriporiopsis subvermispora in the Absence of Lignin Peroxidase

Many ligninolytic fungi appear to lack lignin peroxidase (LiP), the enzyme generally thought to cleave the major, recalcitrant, nonphenolic structures in lignin. At least one such fungus, Ceriporiopsis subvermispora, is nevertheless able to degrade these nonphenolic structures. Experiments showed that wood block cultures and defined liquid medium cultures of C. subvermispora rapidly depolymerized and mineralized a (sup14)C-labeled, polyethylene glycol-linked, high-molecular-weight (beta)-O-4 lignin model compound (model I) that represents the major nonphenolic structure of lignin. The fungus cleaved model I between C(inf(alpha)) and C(inf(beta)) to release benzylic fragments, which were shown in isotope trapping experiments to be major products of model I metabolism. The C(inf(alpha))-C(inf(beta)) cleavage of (beta)-O-4 lignin structures to release benzylic fragments is characteristic of LiP catalysis, but assays of C. subvermispora liquid cultures that were metabolizing model I confirmed that the fungus produced no detectable LiP activity. Three results pointed, instead, to the participation of a different enzyme, manganese peroxidase (MnP), in the degradation of nonphenolic lignin structures by C. subvermispora. (i) The degradation of model I and of exhaustively methylated (nonphenolic), (sup14)C-labeled, synthetic lignin by the fungus in liquid cultures was almost completely inhibited when the Mn concentration of the medium was decreased from 35 (mu)M to approximately 5 (mu)M. (ii) The fungus degraded model I and methylated lignin significantly faster in the presence of Tween 80, a source of unsaturated fatty acids, than it did in the presence of Tween 20, which contains only saturated fatty acids. Previous work has shown that nonphenolic lignin structures are degraded during the MnP-mediated peroxidation of unsaturated lipids. (iii) In experiments with MnP, Mn(II), and unsaturated lipid in vitro, this system mimicked intact C. subvermispora cultures in that it cleaved nonphenolic (beta)-O-4 lignin model compounds between C(inf(alpha)) and C(inf(beta)) to release a benzylic fragment.     

锰过氧化物酶的耦合固定化及其性质研究

分别采用海藻酸钠、明胶和壳聚糖为载体,并以戊二醛为交联剂,通过包埋-交联和吸附-交联两种耦合固定化方法制备固定化锰过氧化物酶。探讨了酶的不同固定化条件和固定化酶的部分性能。与游离酶相比,制备的3种固定化酶最适反应pH分别由7.0降低到5.0、5.0和3.0,最适反应温度分别由35℃升高到75℃、55℃和75℃。3种固定化酶的耐热性都显著提高,其中用壳聚糖制成的固定化酶在pH 2.2～11的宽范围内表现出很好的酸碱耐受性。30℃连续测定6～9次酶活力,重复使用的3种固定化酶显示出良好的稳定性。将固定化酶应用在偶氮染料的脱色中,用明胶制成的固定化酶在静置和摇床条件下,以及用海藻酸钠制成的固定化酶在摇床条件下,均表现出与游离酶相近的脱色能力,并且在重复进行的摇床实验中,脱色能力未降低,反应前后的酶活力均没有损失。