Intracellular ethanol accumulation in Saccharomyces cerevisiae during fermentation

An intracellular accumulation of ethanol in Saccharomyces cerevisiae was observed during the early stages of fermentation (3 h). However, after 12 h of fermentation, the intracellular and extracellular ethanol concentrations were similar. Increasing the osmotic pressure of the medium caused an increase in the ratio of intracellular to extracellular ethanol concentrations at 3 h of fermentation. As in the previous case, the intracellular and extracellular ethanol concentrations were similar after 12 h of fermentation. Increasing the osmotic pressure also caused a decrease in yeast cell growth and fermentation activities. However, nutrient supplementation of the medium increased the extent of growth and fermentation, resulting in complete glucose utilization, even though intracellular ethanol concentrations were unaltered. These results suggest that nutrient limitation is a major factor responsible for the decreased growth and fermentation activities observed in yeast cells at higher osmotic pressures.     

Osmotic pressure effects and intracellular accumulation of ethanol in yeast during fermentation

Summary The intracellular accumulation of ethanol in yeast and its potential effects on growth and fermentation have been topics of controversy for the past several years. The determination of intracellular ethanol based on the exclusion of [¹⁴C]sorbitol to estimate aqueous cell volume was used to examine the question of intracellular ethanol accumulation. An intracellular accumulation of ethanol inSaccharomyces cerevisiae was observed during the early stages of fermentation. However, as fermentation continued, the intracellular and extracellular concentrations of ethanol became similar. Increasing the osmotic pressure of the medium with glucose or sorbitol was observed to cause an increase in the intracellular ethanol concentration. Associated with this was a decrease in yeast growth and fermentation rates. In addition, increasing the osmotic pressure of the medium was observed to cause an increase in glycerol production. Supplementation of the media with excess peptone, yeast extract, magnesium sulfate and potassium phosphate was found to relieve the detrimental effects of high osmotic pressure. Under these conditions, though, no effect on the intracellular and extracellular ethanol distribution was observed. These results indicate that nutrient limitation, and not necessarily intracellular ethanol accumulation, plays a key role during yeast fermentations in media of high osmolarity.     

A study of ethanol tolerance in yeast

The ethanol tolerance of yeast and other microorganisms has remained a controversial area despite the many years of study. The complex inhibition mechanism of ethanol and the lack of a universally accepted definition and method to measure ethanol tolerance have been prime reasons for the controversy. A number of factors such as plasma membrane composition, media composition, mode of substrate feeding, osmotic pressure, temperature, intracellular ethanol accumulation, and byproduct formation have been shown to influence the ethanol tolerance of yeast. Media composition was found to have a profound effect upon the ability of a yeast strain to ferment concentrated substrates (high osmotic pressure) and to ferment at higher temperatures. Supplementation with peptone-yeast extract, magnesium, or potassium salts has a significant and positive effect upon overall fermentation rates. An intracellular accumulation of ethanol was observed during the early stages of fermentation. As fermentation proceeds, the intracellular and extracellular ethanol concentrations become similar. In addition, increases in osmotic pressure are associated with increased intracellular accumulation of ethanol. However, it was observed that nutrient limitation, not increased intracellular accumulation of ethanol, is responsible to some extent for the decreases in growth and fermentation activity of yeast cells at higher osmotic pressure and temperature.     

废糟液全循环对自絮凝酵母糖酵解途径关键酶、胁迫相关代谢物及胞内组分的影响

旨在研究废糟液直接全循环对絮凝酵母乙醇发酵、糖酵解关键酶以及细胞组成的影响。在一有效容积1.5 L的搅拌式生物反应器中,使用葡萄糖为220 g/L,添加8 g/L酵母粉和6 g/L蛋白胨的培养基,以0.04 h?1的稀释率进行自絮凝颗粒酵母乙醇连续发酵。每隔3天将收集到的发酵液集中精馏处理,得到的废糟液用于配制发酵培养基。装置运行近20 d,实验结果表明,随着废液循环批次的增加,系统乙醇和生物量浓度明显降低,糖酵解途径3个关键限速酶:己糖激酶、6-磷酸果糖激酶和丙酮酸激酶不同程度受到抑制。为了应对废糟液中高沸点副产物积累导致的环境胁迫,维持细胞正常代谢,甘油和菌体胞内蛋白生物合成加强,碳水化合物积累减弱。这些研究结果对进一步研究高沸点副产物积累对酵母细胞乙醇发酵影响的机理和菌种的代谢工程改造,具有重要意义。     

Influence of invertase activity and glycerol synthesis and retention on fermentation of media with a high sugar concentration by Saccharomyces cerevisiae.

In the past, the fermentation activity of Saccharomyces cerevisiae in substrates with a high concentration of sucrose (HSuc), such as sweet bread doughs, has been linked inversely to invertase activity of yeast strains. The present work defines the limits of the relationship between invertase activity and fermentation in hyperosmotic HSuc medium. Fourteen polyploid, wild-type strains of S. cerevisiae with different invertase levels gave a similar ranking of fermentation activity in HSuc and in medium in which glucose and fructose replaced sucrose (HGF medium). Thus, invertase is unlikely to be the most important determinant of fermentation in sweet doughs. Yeasts produce the compatible solute-osmoprotective compound glycerol when exposed to hyperosmotic environments. Under low sugar concentrations (and nonstressing osmotic pressure), there was no correlation between glycerol and fermentation activities. However, there was a strong correlation between the ability of yeasts to ferment in HSuc or HGF medium and their capacity to produce and retain glycerol intracellularly. There was also a strong correlation between intracellular glycerol and fermentation activity of yeasts in a medium in which the nonfermentable sugar alcohol sorbitol replaced most of the sugars (HSor), but the ability to produce and retain glycerol was greater when yeasts were incubated in HGF medium under the same osmotic pressure. The difference between the amounts of glycerol produced and retained in HSor and in HGF media varied with strains. This implies that high fermentable sugar concentrations cause physiological conditions that allow for enhanced glycerol production and retention, the degree of which is strain dependent. In conclusion, one important prerequisite for yeast strains to ferment media with high concentrations of sugar is the ability to synthesize glycerol and especially to retain it.     

Intracellular ethanol accumulation in yeast cells during aerobic fermentation: a Raman spectroscopic exploration

Aims: To investigate the intracellular ethanol accumulation in yeast cells by using laser tweezers Raman spectroscopy (LTRS). Methods and Results: Ethanol accumulation in individual yeast cells during aerobic fermentation triggered by excess glucose was studied using LTRS. Its amount was obtained by comparing intracellular and extracellular ethanol concentrations during initial process of ethanol production. We found that (i) yeasts start to produce ethanol within 3 min after triggering aerobic fermentation, (ii) average ratio of intracellular to extracellular ethanol is 1·54 ± 0·17 during the initial 3 h after addition of 10% (w/v) excess glucose and (iii) the accumulated intracellular ethanol is released when aerobic fermentation is stimulated with decreasing glucose concentration. Conclusions: Intracellular ethanol accumulation occurs in initial stage of a rapid aerobic fermentation and high glucose concentration may attribute to this accumulation process. Significance and Impact of the Study: This work demonstrates LTRS is a real‐time, reagent‐free, in situ technique and a powerful tool to study kinetic process of ethanol fermentation. This work also provides further information on the intracellular ethanol accumulation in yeast cells.     

Very high gravity ethanol fermentation by flocculating yeast under redox potential-controlled conditions

ABSTRACT: BACKGROUND: Very high gravity (VHG) fermentation using medium in excess of 250 g/L sugars for more than 15 % (v) ethanol can save energy consumption, not only for ethanol distillation, but also for distillage treatment; however, stuck fermentation with prolonged fermentation time and more sugars unfermented is the biggest challenge. Controlling redox potential (ORP) during VHG fermentation benefits biomass accumulation and improvement of yeast cell viability that is affected by osmotic pressure and ethanol inhibition, enhancing ethanol productivity and yield, the most important techno-economic aspect of fuel ethanol production. RESULTS: Batch fermentation was performed under different ORP conditions using the flocculating yeast and media containing glucose of 201 [PLUS-MINUS SIGN] 3.1, 252 [PLUS-MINUS SIGN] 2.9 and 298 [PLUS-MINUS SIGN] 3.8 g/L. Compared with ethanol fermentation by non-flocculating yeast, different ORP profiles were observed with the flocculating yeast due to the morphological change associated with the flocculation of yeast cells. When ORP was controlled at [MINUS SIGN]100 mV, ethanol fermentation with the high gravity (HG) media containing glucose of 201 [PLUS-MINUS SIGN] 3.1 and 252 [PLUS-MINUS SIGN] 2.9 g/L was completed at 32 and 56 h, respectively, producing 93.0 [PLUS-MINUS SIGN] 1.3 and 120.0 [PLUS-MINUS SIGN] 1.8 g/L ethanol, correspondingly. In contrast, there were 24.0 [PLUS-MINUS SIGN] 0.4 and 17.0 [PLUS-MINUS SIGN] 0.3 g/L glucose remained unfermented without ORP control. As high as 131.0 [PLUS-MINUS SIGN] 1.8 g/L ethanol was produced at 72 h when ORP was controlled at [MINUS SIGN]150 mV for the VHG fermentation with medium containing 298 [PLUS-MINUS SIGN] 3.8 g/L glucose, since yeast cell viability was improved more significantly. CONCLUSIONS: No lag phase was observed during ethanol fermentation with the flocculating yeast, and the implementation of ORP control improved ethanol productivity and yield. When ORP was controlled at [MINUS SIGN]150 mV, more reducing power was available for yeast cells to survive, which in turn improved their viability and VHG ethanol fermentation performance. On the other hand, controlling ORP at [MINUS SIGN]100 mV stimulated yeast growth and enhanced ethanol production under the HG conditions. Moreover, the ORP profile detected during ethanol fermentation with the flocculating yeast was less fluctuated, indicating that yeast flocculation could attenuate the ORP fluctuation observed during ethanol fermentation with non-flocculating yeast.     

Osmotic mass transfer in the yeast Saccharomyces cerevisiae.

This paper reviews the passive mechanisms involved in the response of a yeast to changes in medium concentration and osmotic pressure. The results presented here were collected in our laboratory during the last decade and are experimentally based on the measurement of cell volume variations in response to changes in the medium composition. In the presence of isoosmotic concentration gradients of solutes between intracellular and extracellular media, mass transfers were found to be governed by the diffusion rate of the solutes through the cell membrane and were achieved within a few seconds. In the presence of osmotic gradients, mass transfers mainly consisting in a water flow were found to be rate limited by the mixing systems used to generate a change in the medium osmotic pressure. The use of ultra-rapid mixing systems allowed us to show that yeast cells respond to osmotic upshifts within a few milliseconds and to determine a very high hydraulic permeability for yeast membrane (Lp>6.10(-11) m x sec)-1) x Pa(-1)). This value suggested that yeast membrane may contain facilitators for water transfers between intra and extracellular media, i.e. aquaporins. Cell volume variation in response to osmotic gradients was only observed for osmotic gradients that exceeded the cell turgor pressure and the maximum cell volume decrease, observed during an hyperosmotic stress, corresponded to 60% of the initial yeast volume. These results showed that yeast membrane is highly permeable to water and that an important fraction of the intracellular content was rapidly transferred between intracellular and extracellular media in order to restore water balance after hyperosmotic stresses. Mechanisms implied in cell death resulting from these stresses are then discussed.     

Physiological, biochemical, and mathematical studies of micro-aerobic continuous ethanol fermentation by Saccharomyces cerevisiae. II: intracellular metabolite and enzyme assays at steady state chemostat cultures

Intracellular metabolite concentration and enzyme activity measurements were made to explain the new metabolic and growth phenomena seen in the micro-aerobic, continuous yeast cultures described in Part I. The results of these assays suggested mechanisms for the observed maximum in the specific ethanol productivity as a function of the oxygen feed rate, changing ATP yields, the effects of antifoam, and the sharp changes in the biomass concentration with small changes in the oxygenation. Measured were the intracellular concentrations of ATP, NADH, glucose 6-phosphate, pyruvate, glycerol, and ethanol, and the activities of hexokinase and alcohol dehydrogenase. Rate-limiting steps were identified by the accumulation of metabolites upstream and the depletion of metabolites downstream of the step.A potential mechanism for the stimulation of fermentation with decreasing oxygenation was an activation of glucose transport by an accumulating intracellular ATP concentration. The inhibition of fermentation at yet lower oxygenation rates may have been caused by the continued accumulation of ATP to the point that the glycolytic kineses were inhibited. A mechanism for the changing ATP yields and intracellular ATP concentration proposed the existence of ATPases or ATP waste reactions stimulated by both oxygen and ATP. Antifoam had the effect of decreasing the resistance for glycerol transport out of the cell. The resulting stimulation of glycerol production and inhibition of ethanol production decreased the intracellular ATP content. Finally, intracellular ethanol was found not to accumulate to levels of higher than the extracellular concentration.     

Batch fermentation kinetics of sugar beet molasses by Zymomonas mobilis

A new osmotolerant mutant strain of Zymomonas mobilis was successfully used for ethanol production from beet molasses. Addition of magnesium sulfate to hydrolyzed molasses allowed repeated growth without the need of yeast extract addition. The kinetics and yields parameters of fermentation on media with different molasses concentrations were calculated. The anabolic parameters (specific growth rate, mu, and biomass yield, Y(X/S)) were inhibited at elevated molasses concentrations while the catabolic parameters (specific ethanol productivity, q(p), and ethanol yield, Y(p/s)) were not significantly affected. In addition to ethanol and substrate inhibition, osmotic pressure effects can explain the observed results.     

Intracellular acidification does not account for inhibition of Saccharomyces cerevisiae growth in the presence of ethanol

Abstract Intracellular acidification has been considered one of a number of mechanisms underlying the inhibition of growth and fermentation by ethanol in yeast. However, most of the studies on the effect of ethanol on yeast intracellular pH (pH_i) were carried out by using unadapted cells to which ethanol was added. In this paper we show that the pH_i of exponential cells of Saccharomyces cerevisiae IGC 3507 III grown in a medium with glucose and inhibitory concentrations of ethanol only decreased to values below those in unstressed cells (6.9) for concentrations equal to or above 7% (v/v). Only at these supracritical levels (7–10% (v/v)) was pH homeostasis in ethanol-adapted yeast affected. This is consistent with the significant increase of plasma membrane permeability and decrease of plasma membrane H⁺-ATPase in comparison with the corresponding values in unstressed cells. These deleterious effects were only observed with those high concentrations of toxin. These results indicate that intracellular acidification does not account for inhibition of yeast growth in the presence of ethanol. In fact, growth was inhibited by ethanol concentrations (3–6% (v/v)) that did not lead to the decrease of pH_i. Furthermore, even for supracritical concentrations, close to the maximal that allowed growth (10% (v/v)), the dedrease of pH_i was not important reaching, at the most, values of 6.5–6.6.     

The involvement of trehalose in yeast stress tolerance

Summary A total of 12 yeast strains from various genera were examined for their ability to produce ethanol in the presence of high concentrations of glucose. From these studies, the yeastsTorulaspora delbrueckii andZygosaccharomyces rouxii were observed to the most osmotolerant. These osmotolerant yeast strains were also observed to possess high concentrations of intracellular trehalose. Futhermore, these strains were found to be tolerant to long-term storage at –20°C and to storage at 4°C in beer containing 5% (v/v) ethanol. Cells containing high trehalose levels at the time of freezing or cold storage exhibited the highest cell viabilities. Trehalose concentration was observed to increase during growth on glucose, reaching a maximum after 24–48 h. Increasing the incubation temperature from 21 to 40°C also resulted in an increase in intracellular trehalose content. These results suggest that trehalose plays a role in enhancing yeast survival under environmentally stressful conditions.     

Overexpression of the OLE1 gene enhances ethanol fermentation by Saccharomyces cerevisiae

 The fermentation characteristics of Saccharomyces cerevisiae strains which overexpress a constitutive OLE1 gene were studied to clarify the relationship between the fatty acid composition of this yeast and its ethanol productivity. The growth yield and ethanol productivity of these strains in the medium containing 15% dextrose at 10 °C were greater than those of the control strains under both aerobic and anaerobic conditions but this difference was not observed under other culture conditions. During repeated-batch fermentation, moreover, the growth yield and ethanol productivity of the wild-type S. cerevisiae increased gradually and then were similar to those of the OLE1-overexpressing transformant in the last batch fermentation. However, the unsaturated fatty acid content (77.6%) of the wild-type cells was lower than that (86.2%) of the OLE1-recombinant cells. These results suggested that other phenomena caused by the overexpression of the OLE1 gene, rather than high unsaturated fatty acid content, are essential to ethanol fermentation by this yeast. Received: 11 June 1999 / Received last revision: 12 November 1999 / Accepted: 28 November 1999     

Extracellular trehalose utilization by Saccharomyces cerevisiae

Two haploid strains of Saccharomyces cerevisiae viz. MATalpha and MATa were grown in glucose and trehalose medium and growth patterns were compared. Both strains show similar growth, except for an extended lag phase in trehalose grown cells. In both trehalose grown strains increase in activities of both extracellular trehalase activities and simultaneous decrease in extracellular trehalose level was seen. This coincided with a sharp increase in extracellular glucose level and beginning of log phase of growth. Alcohol production was also observed. Secreted trehalase activity was detected, in addition to periplasmic activity. It appeared that extracellular trehalose was hydrolyzed into glucose by extracellular trehalase activity. This glucose was utilized by the cells for growth. The alcohol formation was due to the fermentation of glucose. Addition of extracellular trehalase caused reduction in the lag phase when grown in trehalose medium, supporting our hypothesis of extracellular utilization of trehalose.     

Optimization of batch alcoholic fermentation of glucose syrup substrate

The quantitative effects of substrate concentration, yeast concentration, and nutrient supplementation on ethanol content, fermentation time, and ethanol productivity were investigated in a Box–Wilson central composite design experiment, consisting of five levels of each variable, High substrate concentration, up to 30° Brix, resulted in higher ethanol content (i.e., up to 15.7% w/v or 19.6% v/v) but longer fermentation time and hence lower ethanol productivity. Increasing yeast concentration, on the other hand, resulted in shorter fermentation time and higher productivity. The highest ethanol productivity of about 21 g EiOH/L h was obtained at low substrate concentration (i.e., 12° Brix), low alcohol content (i.e., 6% by weight), high yeast concentration (i.e., 4.4%), and high supplementation of yeast extract (i.e., 2.8). Productivity of this magnitude is substantially higher that that of the traditional batch fermentation of fed-batch fermentation. It is comparable to the results of continuous fermentation but lower than those of vacuum fermentation but lower than those of vacuum fermentation. Optimal conditions for maximal ethanol productivity can be established by a multiple regression analysis technique and by plotting the contours of constant response to conform to the constraints of individual operations.     

Metabolite profiling for analysis of yeast stress response during very high gravity ethanol fermentations

A laboratory strain and an industrial strain of Saccharomyces cerevisiae were grown at high substrate concentration, so-called very high gravity (VHG) fermentation. Simultaneous saccharification and fermentation (SSF) was applied in a batch process using 280 g/L maltodextrin as carbon source. It was shown that known ethanol and osmotic stress responses such as decreased growth rate, lower viability, higher energy consumption, and intracellular trehalose accumulation occur in VHG SSF for both strains when compared with standard laboratory medium (20 g/L glucose). The laboratory strain was the most affected. GC-MS metabolite profiling was applied for assessing the yeast stress response influence on cellular metabolism. It was found that metabolite profiles originating from different strains and/or fermentation conditions were unique and could be distinguished with the help of multivariate data analysis. Several differences in the metabolic responses to stressing conditions were revealed, particularly the increased energy consumption of stressed cells was also reflected in increased intracellular concentrations of pyruvate and related metabolites.     

代谢工程与全基因组重组构建酿酒酵母抗逆高产乙醇菌株

将酿酒酵母海藻糖代谢工程与全基因组重组技术相结合,改良工业酿酒酵母菌株的抗逆性和乙醇发酵性能。对来源于二倍体出发菌株Zd4的两株优良单倍体Z1和Z2菌株进行杂交获得基因组重组菌株Z12,并对Z1和Z2先进行(1)过表达海藻糖-6-磷酸合成酶基因 (TPS1) ,(2)敲除海藻糖水解酶基因 (ATH1), (3)同时过表达 TPS1和敲除ATH1, 经此三种基因工程操作后再进行杂交获得代谢工程菌株的全基因组重组菌株Z12ptps1、Z12 Δath1和Z12pTΔA。与亲株Zd4相比,Z12及结合代谢工程获得的菌株在高糖、高乙醇浓度与高温条件下生长与乙醇发酵性能都有不同程度的改进。对比研究结果表明:在高糖发酵条件下,同时过表达 TPS1和敲除ATH1 的双基因操作工程菌株胞内海藻糖积累、乙醇主发酵速率和乙醇产量相对于亲株的提高幅度要大于只过表达 TPS1,或敲除ATH1 的工程菌。结合了全基因组重组后获得的二倍体工程菌株Z12pTΔA,与原始出发菌株Zd4及重组子Z12相比,主发酵速率分别提高11.4%和6.3%,乙醇产量提高7.0%和4.1%,与其胞内海藻糖含量高于其它菌株、在胁迫条件下具有更强耐逆境能力相一致。结果证明,海藻糖代谢工程与杂交介导的全基因组重组相结合,是提高酿酒酵母抗逆生长与乙醇发酵性能的有效策略与技术途径。     

Alterations in fatty acid composition and trehalose concentration ofSaccharomyces brewing strains in response to heat and ethanol shock

Summary The effects of heat and ethanol shock on fatty acid composition and intracellular trehalose concentration of lager and ale brewing yeasts were examined. Exposure of cells to heat shock at 37°C or 10% (v/v) ethanol for 60 min resulted in a significant increase in the ratio of the total unsaturated to saturated fatty acyl residues and the intracellular trehalose concentration of cells. A similar increase in the amount of unsaturated fatty acids was observed in cells after 24 h of fermentation of 16°P (degree Plato) or 25°P wort, at which time more than 2% (v/v) ethanol was present in the growth medium. These results suggest that unsaturated fatty acids and high concentrations of intracellular trehalose may protect the cells from the inhibitory effects of heat and ethanol shock.     

Role of phosphatidylinositol (PI) in ethanol production and ethanol tolerance by a high ethanol producing yeast

The effect of inositol addition on phospholipids, cell growth, ethanol production and ethanol tolerance in a high ethanol producing Saccharomyces sp were studied. Addition of inositol greatly influenced major phospholipid synthesis. With inositol in the fermentation medium, phosphatidylinositol (PI) content was increased, while phosphatidylcholine (PC) and phosphatidylethanolamine (PE) were decreased. However, without inositol in the fermentation medium, PI content dropped down within 24 h, then increased, but was lower than in the presence of inositol. When yeast cells had a higher content of PI, they produced ethanol much more rapidly and tolerated higher concentrations of ethanol. During ethanol shock treatment at 18% (v/v) ethanol, yeast cells with a higher concentration of PI lost their viability much more slowly than those with a lower concentration of PI, indicating that the PI content in these yeast cells can play an important role in ethanol production and ethanol tolerance. Fatty acids and ergosterol were not responsible for high ethanol tolerance and high ethanol production in this yeast strain. Received 22 September 1998/ Accepted in revised form 20 December 1998