Effect of heat treatments on the microbial load of 'nono'

Fresh nono samples were subjected to temperature treatments of 55, 60, 65 and 70°C at holding times of 5, 10, 20 and 30 min. Treatment at 65°C for 30 min was most effective in leaving the least number of viable bacteria (1·97 times 10³ pL 0·04) without affecting the organoleptic quality of the product. Some micro-organisms isolated after the pasteurization treatments were Lactobacillus bulgaricus, L. plantarum, L. helveticus and Streptococcus cremoris while coliform bacteria and fungi did not survive the pasteurization treatments.     

Effect of the ethanol content of beer on the heat resistance of a spoilage Lactobacillus

D -values of a heterofermentative beer spoilage lactobacillus were measured at 55°C, 60°C and 65°C in beers containing <0·05% to 4·4% v/v ethanol. Z -values for the different beers varied between 9·17 and 12·13°C. At each temperature an increase in ethanol reduced the measured D -value. The maximum, 5·01 min was observed in alcohol-free beer (<0·05%) at 55°C and the minimum, 0·31 min, at 60°C and 65°C in beer containing 4·4% ethanol. D -values could be increased by prior growth in the presence of ethanol. They could be reduced by adding ethanol to alcohol-free beer or by increasing its hop extract content. The implications for the pasteurization of low-alcohol beers are discussed.     

Mathematical modelling of the heat resistance of Listeria monocytogenes

The heat resistance of Listeria monocytogenes phagovar 2389/2425/3274/2671/47/108/340 (1992 French outbreak strain) in broth was studied at 55, 60 and 65 °C. Experiments were carried out on bacterial cultures in three different physiological states: cultures at the end of the log phase, cultures heat-shocked at 42 °C for 1 h, and subcultures of cells resistant to prolonged heating. Survivor curves were better fitted using a sigmoidal equation than the classical log-linear model. This approach was justified by the existence of heat resistance distributions within the bacterial populations. Peaks (log₁₀ of heating time) of heat resistance distributions of untreated, heat-shocked, and selected cultures at 55, 60 and 65 °C were 0·34, −0·90 and −1·84 min, 0·74, −0·51 and −1·24 min, and 0·17, −0·94 and−1·45 min, respectively. The widths of the distributions are proportional to 0·29, 0·36and 0·41 min^0·5, 0·26, 0·36 and 0·41 min^0·5, and 0·34, 0·44 and 0·41 min^0·5. An increase in thethermal tolerance could then be induced by sublethal heat shock or by selection of heatresistant cells.     

Survival of Listeria monocytogenes in sea water and effect of exposure on thermal resistance

Survival, recoverability and sublethal injury of two strains of Listeria monocytogenes , Scott A and an environmental strain KM, on exposure to sea water at 12·8 or 20·8 °C was determined using in situ diffusion chambers. Plate counts were used to assess recoverability and injury while 5-cyano-2,3-ditolyl tetrazolium chloride (CTC) reduction was used to determine respiratory activity. T₉₀ values (times for 10-fold decreases in numbers of recoverable cells) on non-selective medium (trypticase soya agar with 0·6% yeast extract) at 12·8 and 20·8 °C were 61·7 and 69·2 h for L. monocytogenes Scott A, and 103·0 and 67·0 h for L. monocytogenes KM, respectively. On selective medium (Oxford agar), T₉₀ values at 12·8 and 20·8 °C were 60·6 and 56·9 h for L. monocytogenes Scott A, and 83·0 and 65·9 h for L. monocytogenes KM, respectively. With Scott A, the percentage of sublethally injured cells at 12·8 and 20·8 °C was 1·7 and 17·7%, respectively, while for KM the values were 19·0 and 1·6%, respectively. The fraction of cells reducing CTC but which were not recoverable on plating progressively increased on exposure to sea water. Listeria monocytogenes KM challenged at 58 °C showed an apparent increase in heat resistance after exposure to sea water at 20·8 °C for 7 d ( D ₅₈= 2·64 min) compared with before exposure ( D ₅₈= 1·24). This increase in thermal resistance was not apparent at temperatures greater than 63 °C, and analysis of the best-fit regression lines fitted to the thermal data obtained from the two cell populations indicated that their thermal resistance was not significantly different ( P > 0·05) over the temperature range tested (58–62 °C).     

Heat-resistant Bacteria in Pasteurized Whole Egg

Samples of egg melange taken from an egg packing station contained an average of 7·3 x 10⁴ organisms/ml which survived laboratory pasteurization at 65°C for 3 min. Many of the organisms surviving pasteurization were found to be coryneform bacteria related to Microbacterium lacticum which could be differentiated into several groups. The remainder were a miscellaneous collection of unidentified cocci and coccobacilli and some Bacillus spp. The coryneform bacteria were shown to be the most heat-resistant isolates with negligible loss of viability after 60 min at 65°C, At least two of the representative strains were very heat-resistant, 0·01% surviving 20 and 38 min at 80°C in phosphate buffer at pH 7·1. Growth tests showed that none of the isolates grew at 5°C after 10 d incubation but those capable of growing most rapidly at 10° and 15°C were also the most heat-resistant. Such strains had a doubling time at 15°C of between 6 and 8 h in whole egg. Freezing the coryneform bacteria in liquid whole egg at –18°C had negligible effect on viability or heat-resistance at 65°C.     

Partial purification, characterization and regulation of cellulolytic enzymes from Trichoderma longibrachiatum

A net purification of 9·46-, 18·6- and 16·7-fold for filter paper (FP) hydrolytic activity, carboxymethyl (CM) cellulase and β-glucosidase, respectively was achieved through ion exchange and gel chromatographies. The purified enzyme preparation showed an optimal pH of 5·0 for CM cellulase and 5·5 for the other two components. The enzyme activities increased up to 60°–65°C for the three enzyme components and they were stable at 30° or 40°C and pH 4·5 to 5·0 after 20–30 min treatment. The four enzyme components, that is, two FP activities (unadsorbed and adsorbed), a CM cellulase and a β-glucosidase, had K_m values of 47·6 mg, 33·3 mg, 4·0 mg and 0·18 mmol/l with V _max of 4, 1·28, 66·5 and 1·28 units per mg protein. The molecular weights as determined with SDS-PAGE were found to be 44000, 38000, 55000 and 63000 for the above four enzyme components in the same sequence. A distinct type of synergistic action was observed between these components by their action on dewaxed cotton. Glycerol at 1% strongly repressed the formation of all the cellulolytic enzymes. The role of proteolytic enzymes in in vitro inactivation of cellulases was not apparent.     

Factors affecting the heat resistance of Escherichia coli O157 : H7

Escherichia coli O157 : H7 has been reported as being not particularly heat resistant. However, several factors which might increase its heat resistance have been investigated in this study using five strains. Increase in growth temperature to 40 °C, as found in the cow gut, heat-shock at sub-lethal temperatures of 42, 45, 48 and 50 °C, and variable heating rate (1 °C min⁻¹ to 23 °C min⁻¹) had no dramatic effect on heat resistance. Growth phase had a marked impact on heat resistance ; late stationary phase cells were more heat-resistant than were log phase cells. The difference in heat resistance between the two phases of growth became more pronounced when cells were resuspended in fresh nutrient broth ; heat resistance of late stationary phase cells increased dramatically whereas no such effect was observed with log phase cells. The addition of polyphosphates to the heating medium did not increase heat resistance. A reduction in water activity of the heating medium from 0·995 to levels between 0·980 and 0·960 also resulted in a marked increase in heat resistance. This effect was more pronounced under conditions of extremely low water activity created by resuspending late stationary phase cells in sunflower oil. Survivors were detected even after a heat treatment at 60 °C for 1 h or 70 °C for 5 min. It can be confirmed that this serotype has no unusual heat resistance and that the heating environment markedly affects resistance.     

Effect of bacterial suspensions on vascular occlusion in stems of cut rose flowers

A suspension of Pseudomans aeruginosa at 5 × 10⁹ cfu/ml was either left untreated, pasteurized (15 min, 70°C) or autoclaved (15 min, 121°C). Stems of cut rose flowers ( Rosa hybrida L. cv. Sonia) placed in these solutions for 0·5–4·0 h showed decreased water uptake and a reduction of hydraulic conductance of the basal 5·0 cm stem segment. No difference was found between the treatments. When the pasteurized or autoclaved solutions were left at 4°C for 7 days, bacterial cells had autolyzed, and stems placed in these suspensions showed lower water uptake and hydraulic conductance than stems in freshly prepared solutions. The results show that living and non-living bacteria have the same effect on vascular occlusion, and indicate that hydraulic conductance was more reduced when the average size of the particles was smaller than that of bacterial cells. Vascular blockage occurred within 30 min after the start of treatment, apparently due to a physical effect rather than a physiological response of the stem tissue.     

Evaluation of thermal disinfection procedures for hydrophilic contact lenses.

The kinetics and efficacy of moist heat disinfection for hydrophilic contact lenses were investigated by using representative microorganisms of ophthalmic concern and several heat-resistant species. In replicate challenges, 80 degrees C for 10 min and 75 degrees C for 5 min were proven efficacious for moist-heat disinfection.     

Effect of oscillatory high hydrostatic pressure treatments on Byssochlamys nivea ascospores suspended in fruit juice concentrates

The effect of continuous (689 MPa with holding times of 5, 15 or 25 min) and oscillatory (one, three or five cycles at 689 MPa with holding times of 1 s) high hydrostatic pressure treatments on the viability of Byssochlamys nivea ascospores suspended in apple and cranberry juice concentrates adjusted by dilution to water activities (a_w) of 0·98 and 0·94 was evaluated at 21 and 60 °C. Inactivation of the initial spore inocula was achieved after three or five cycles of oscillatory pressurization at 60 °C when the a_w was 0·98 in both fruit juices. With a_w 0·94, the initial inocula were reduced by less than 1 log-cycle after five pressure cycles. Inactivation was not observed within 25 min with continuous pressurization at 60 °C. In treatments at 21 °C, no effect on spore viability was observed with continuous or oscillatory treatments.     

Immersion heat treatments for inactivation of Salmonella enteritidis with intact eggs

The effects of water-bath immersion heat treatments on the inactivation of Salmonellaenteritidis within intact shell eggs were evaluated. Six pooled strains of Salm. enteritidis ( ca 3×10⁸ cfu, inoculated near the centre of the yolk) were completelyinactivated within 50–57·5 min at a bath temperature of 58°C and within 65–75min at 57°C (an 8·4 to 8·5- D process per egg). Following the initial 24 to35-min come-up period, semilogarithmic survivor curves obtained at 58 and 57°C yieldedapparent decimal reduction times ( D -values) of 4·5 and 6·0 min, respectively.Haugh unit values increased during heating, while yolk index and albumen pH values wereunaffected. Albumen clarity and functionality were affected by the thermal treatments; therefore,extended whip times would be required for meringue preparation using immersion-heated eggwhites. Immersion-heated shell eggs could provide Salmonella -free ingredients for thepreparation of a variety of minimally-cooked foods of interest to consumers and foodserviceoperators.     

Heat resistance of Cronobacter species (Enterobacter sakazakii) in milk and special feeding formula

Aim:  To determine D - and z -values of Cronobacter species ( Enterobacter sakazakii ) in different reconstituted milk and special feeding formula and the effect of reconstitution of powdered milk and special feeding formula with hot water on the survival of the micro-organism.
Methods and Results:  Five Cronobacter species (four C. sakazakii isolates and C. muytjensii ) were heated in reconstituted milk or feeding formula pre-equilibrated at 52–58°C for various times or mixed with powdered milk or feeding formula prior to reconstitution with water at 60–100°C. The D -values of Cronobacter at 52–58°C were significantly higher in whole milk (22·10–0·68 min) than in low fat (15·87–0·62 min) or skim milk (15·30–0·51 min) and significantly higher in lactose-free formula (19·57–0·66 min) than in soy protein formula (17·22–0·63 min). The z -values of Cronobacter in reconstituted milk or feeding formula ranged from 4·01°C to 4·39°C. Water heated to ≥70°C and added to powdered milk and formula resulted in a > 4 log₁₀ reduction of Cronobacter .
Conclusions:  The heat resistance of Cronobacter should not allow the survival of the pathogen during normal pasteurization treatment. The use of hot water (≥70°C) during reconstitution appears to be an effective means to reduce the risk of Cronobacter in these products.
Significance and Impact of the Study:  This study supports existing data available to regulatory agencies and milk producers that recommended heat treatments are sufficient to substantially reduce risk from Cronobacter which may be present in these products.     

Evaluation of thermal disinfection procedures for hydrophilic contact lenses

The kinetics and efficacy of moist heat disinfection for hydrophilic contact lenses were investigated by using representative microorganisms of ophthalmic concern and several heat-resistant species. In replicate challenges, 80 degrees C for 10 min and 75 degrees C for 5 min were proven efficacious for moist-heat disinfection.     

Detection and characterization of a bacteriocin produced by Lactococcus lactis subsp. cremoris R isolated from radish

Bacteria isolated from radish were identified as Lactococcus lactis subsp. cremoris R and their bacteriocin was designated lactococcin R. Lactococcin R was sensitive to some proteolytic enzymes (proteinase-K, pronase-E, proteases, pepsin, α-chymotrypsin) but was resistant to trypsin, papain, catalase, lysozyme and lipase, organic solvents, or heating at 90 °C for 15, 30 and 60 min, or 121 °C for 15 min. Lactococcin R remained active after storage at −20 and −70 °C for 3 months and after exposure to a pH of 2–9. The molecular weight of lactococcin R was about 2·5 kDa. Lactococcin R was active against many food-borne pathogenic and food spoilage bacteria such as Clostridium, Staphylococcus, Listeria, Bacillus, Micrococcus, Enterococcus, Lactobacillus, Leuconostoc, Streptococcus and Pediococcus spp., but was not active against any Gram-negative bacteria. Lactococcin R was produced during log phase and reached a maximum activity (1600 AU ml⁻¹) at early stationary phase. The highest lactococcin R production was obtained in MRS broth with 0·5% glucose, at 6·5–7·0 initial pH values, 30 °C temperature and 18–24-h incubation times. Lactococcin R adsorbed maximally to its heat-killed producing cells at pH 6–7 (95%). Crude lactococcin R at 1280 AU ml⁻¹ was bactericidal, reducing colony counts of Listeria monocytogenes by 99·98% in 3 h. Lactococcin R should be useful as a biopreservative to prevent growth of food-borne pathogenic and food spoilage bacteria in ready-to-eat, dairy, meat, poultry and other food products. Lactococcin R differs from nisin in having a lower molecular weight, 2·5 kDa vs 3·4 kDa, and in being sensitive to pepsin and α-chymotrypsin to which nisin is resistant.     

Production of alkaline xylanase by an alkaliphilic Bacillus sp. isolated from an alkalinesoda lake

An alkaline xylanase-producing alkaliphilic Bacillus sp. AR-009 was isolated from analkaline soda lake in Ethiopia. The enzyme was optimally active at pH 9 and was stable over abroad pH range. The optimum temperature for xylanase activity, assayed at pH 9, was60°–65°C. Measured at pH 8 and 9, the enzyme had good stability at 55° and60°C. At both pH values, over 80% of its original activity was retained after heating for2·5 h at 55°C. At 60°C, the enzyme maintained 63% of its original activity after2·5 h incubation while at pH 9 it retained 54% of its original activity after 1 h heating. Theseproperties qualify the enzyme to be novel and potentially important for application in someindustrial processes.     

The combined effect of sub-optimal temperature and sub-optimal pH on growth and toxin formation from spores of Clostridium botulinum

Low-acid foods (pH ≥ 4.5) are not sufficiently acidic to prevent growth of Clostridium botulinum in otherwise optimal conditions. The combination of sub-optimal pH and sub-optimal temperature may, however, result in a very significant reduction in the risk of growth of this bacterium compared with the risk in optimal conditions. The combined effect of incubation temperatures of 12° and 16°C and pH values between 5·2 and 5·5 on growth and toxin production from spores of Cl. botulinum during incubation for 28 d has been investigated. Growth and formation of toxin (type B) were detected only in medium at pH 5·5 and incubated at 16°C, corresponding to a probability of growth from a single spore within 14 d of 1·6 × 10^-5. The probability of growth in 28 d in the remaining conditions was <9 × 10^-6. After transfer of inoculated media from 12° to 30°C growth occurred at pH 5·2–5·5 within 19 d. After transfer of inoculated media from 12° to 20°C growth occurred at pH 5·5 and 5·4 but not at pH 5·3 or 5·2 in 40 d. Growth at pH 5·2–5·5 was accompanied by formation of toxin, in most cases of types A or B. In addition to the effect of sub-optimal temperature and pH, chelation of divalent metal ions by citrate may have contributed to inhibition.     

Note: Influence of different heating media on thermal resistance of Neosartorya fischeri isolated from papaya fruit

E. RAJASHEKHARA, E.R. SURESH AND S. ETHIRAJ. 1996. A heat-resistant mold identified as a strain of Neosartorya fischeri was isolated from microbiologically spoiled papaya fruits. The optimum heat activation temperature and time for the ascospores of the test mold was found to be 80°C for 15–30 min. The decimal reduction times ( D -values) at 85°, 87° and 89°C in phosphate buffer (pH 7·0) as heating medium were 35·25, 11·1 and 3·90 min respectively and hence the calculated z -value was 4·0°C. In grape and mango juices as heating media, the D _80°C and the D _85°C values were increased as the °Brix level raised from 10 to 45. In commercial fruit juices of mango, orange, pineapple and mango-pineapple blend as heating media D _85°C values were greater than those observed for phosphate buffer.     

Production and stability of pediocin N5p in grape juice medium

The production and stability of pediocin N5p from Pediococcus pentosaceus , isolated from wine, were examined in grape juice medium. Maximum growth and higher titre (4000 U ml^-1) were observed at a initial pH of 7·5 and 30°C. The activity of the inhibitory substance was stable between pH values from 2·0 to 5·0 at 4° and 30°C. At pH 10·0 it was completely inactivated. When submitted to 30 min at 80°, 100° and 115°C, maximal stability was observed at pH 2·0. Ethanol up to 10% did not affect pediocin activity at acid pH, nor did 40–80 mg 1^-1 SO₂, independently or combined with different ethanol concentrations, affect inhibitory activity.     

Toxicity of crude extracellular products of Aeromonas hydrophila in tilapia, Tilapianilotica

Extracellular products (ECP) secreted from Aeromonas hydrophila with haemolytic andproteolytic activity were studied with respect to temperature and time of incubation as well as thelethal toxicity on tilapia, Tilapia nilotica . The highest production of the haemolysin productwas achieved when Aer. hydrophila was grown at 35°C for 30 h. Tilapia erythrocytewas found to be more susceptible than sheep erythrocyte for determining the haemolytic activity.The haemolytic activity against tilapia erythrocyte was completely inactivated after heating theECP at 60°C for 10 min or 55°C for 15 min. The proteolytic activity was maximized whenthe bacterium was grown at 30°C for 36 h. Complete inactivation of the protease enzyme wasperformed after heating the ECP at 80°C for 10 min or 70°C for 15 min. Aeromonashydrophila was found to produce haemolytic and proteolytic exotoxin lethal to tilapia (LD₅₀ 2·1 × 10⁴ cell/fish), as well as heat stable unknown virulent factors thatwere responsible for 20% mortality. The lethality of ECP was decreased by heating andcompletely inactivated by boiling at 100°C for 10 min.     

Growth, diet and metabolism of common wolf–fish in the North Sea, a fast–growing population

The von Bertalanffy growth parameters for common wolf–fish Anarhichas lupus in the North Sea were: male: L ∞=111·2 cm, t ₀=–0·43 and K =0·12; and female: L ∞=115·1 cm, t ₀=–0·39 and K =0·11, making this the fastest growing stock reported. Resting metabolic rates (RMR±S.E.) and maximum metabolic rates (MMR±S.E.) for six adult common wolf–fish (mean weight, 1·39 kg) at 5° C were 12·18±1·6 mg O₂ kg^–1 h^–1 and 70·65±7·63 mg O₂ kg^–1 h^–1 respectively, and at 10° C were 25·43±1·31 mg O₂ kg^–1 h^–1 and 113·84±16·26 mg O₂ kg^–1 h^–1. Absolute metabolic scope was 53% greater at 10° C than at 5° C. The diet was dominated by Decapoda (39% overall by relative occurrence), Bivalvia (20%) and Gastropoda (12%). Sea urchins, typically of low energy value, occupied only 7% of the diet. The fast growth probably resulted from summer temperatures approximating to the optimum for food processing and growth, but may have been influenced by diet, and reduced competition following high fishing intensity.