Fermentation performance of an exopolysaccharide-producing strain of<Emphasis Type="Italic"> Lactobacillus delbrueckii</Emphasis> subsp.<Emphasis Type="Italic"> bulgaricus</Emphasis>

The formation of exopolysaccharide (EPS) and extracellular metabolites was studied in a strain of Lactobacillus delbrueckii subsp. bulgaricus (NCFB 2483), grown under batch culture conditions in a semi-defined medium incorporating lactose and casein hydrolysate. Performance parameters were derived from the fermentation data, and kinetic models were applied in order to describe the production of EPS, extracellular metabolites, and biomass produced. Lactose was split intracellularly, with the resultant galactose being exported from the cell, and the glucose being metabolised further to EPS and lactic acid. Production of EPS, lactate, and galactose was closely growth-associated and followed a pattern of primary kinetics. A marginally lower galactose level relative to the modelled levels throughout most of the time course of the fermentation suggests that not all galactose is exported from the cell, and that a low level of flux to other metabolites, such as EPS, might exist.     

Partial characterization and dynamics of synthesis of high molecular mass exopolysaccharides from Lactobacillus delbrueckii ssp. bulgaricus and Streptococcus thermophilus

Exopolysaccharide (EPS) preparations from Lactobacillus delbrueckii ssp. bulgaricus (L. bulgaricus) strains LBB.B26 and LBB.B332 and Streptococcus thermophilus strains LBB.T54 and LBB.T6V were characterized using ion-exchange chromatography and gel filtration. All four preparations contained a neutral EPS with molecular mass in the range of 1.3−1.6 × 10⁶ Da (HMM-EPS). The EPS preparations from the two L. bulgaricus strains also contained an acidic low molecular mass EPS fraction (LMM-EPS) comprising from 10% to 34% of the total EPS yield. HMM-EPS preparations were subjected to High Pressure Liquid Chromatography (HPLC) analysis of monomer sugars after complete hydrolysis. Glucose, galactose and/or rhamnose in different ratios proved to be the principal sugars building the HMM-EPS from all four strains. The chemical composition of HMM-EPS was strictly strain-specific. The LMM-EPS contained galactose. The viscosifying properties of the four different HMM-EPS varied greatly with intrinsic viscosity in the range from 0.26 (strain B26) to 2.38 (strain T6V). For 24 h the two L. bulgaricus strains accumulated more HMM-EPS in milk (>70 mg l⁻¹) than S. thermophilus strains T54 and T6V (<30 mg l⁻¹), but maximal yields were reached earlier with cocci (8 h) than with rods (16–24 h). The contribution of HMM-EPS production to increased viscosity of fermented milk was demonstrated for all of the tested strains grown as monocultures or as mixed yogurt starters compared to non-EPS producing S. thermophilus LBB.A and poor EPS-producer L. bulgaricus LBB.B5. The extent of increased viscosity was strongly dependent on the nature of the produced HMM-EPS, rather than simply on polymer yield.     

Exopolysaccharide and extracellular metabolite production by Lactobacillus delbrueckii subsp. bulgaricus, grown on lactose in continuous culture

Lactobacillus delbrueckii subsp. bulgaricus NCFB 2483, when grown on lactose in continuous culture, showed increasing specific yields and volumetric productivities of exopolysaccharide (EPS) with increasing dilution rate. Specific and volumetric productivities of lactate and galactose, as extracellular metabolites, increased in response to the incremental changes in the dilution rate up to 0.4 h^–1. Elevated Y_p/s values determined for EPS (0.025 g EPSg lactose^–1) at the dilution rates of 0.3 h^–1–0.4 h^–1, relative to those determined at lower dilution rates, suggest a diversion of carbon flux towards EPS being associated with the higher rates of growth.     

Effect of oxygen on batch yogurt cultures

A yogurt culture (Streptococcus thermophilus 15HA + Lactobacillus delbrueckii subsp. bulgaricus 2-11) was studied in conditions of aerobic batch fermentation (10–40% dissolved oxygen in milk). The growth and acidification of S. thermophilus 15HA were stimulated at 20% oxygen concentration and the lactic acid process in a mixed culture was shortened by 1 h (2.5 h for the aerobic culture and 3.5 h for the anaerobic mixed culture). Streptococcus thermophilus 15HA oxygen tolerance was significantly impaired at oxygen concentrations in the milk above 30%. Though S. thermophilus 15HA was able to overcome to some extent the impact of high oxygen concentration (40%), the lactic acid produced was insufficient to coagulate the milk casein (4.0 g lactic acid l⁻¹ in the mixed culture and 3.8 g lactic acid l⁻¹ in the pure culture). A dramatic decrease in the viable cell count of L. delbrueckii subsp. bulgaricus 2-11 in the pure and mixed cultures was recorded at 30% dissolved oxygen. This revised version was published online in July 2006 with corrections to the Cover Date.     

Exopolysaccharides production in Lactobacillus bulgaricus and Lactobacillus casei exploiting microfiltration

The physiology of Lactobacillus delbrueckii ssp. bulgaricus and Lactobacillus casei, extensively used in the dairy industry, was studied in order to evaluate key parameters in the synthesis of exopolysaccharides and to improve their production through novel fermentation processes. Selected strains were studied in shake flasks and in fermentor experiments using glucose and lactose as main carbon sources and bacto casitone as the only complex component, in a temperature range between 35 and 42°C. The production of exopolysaccharides was monitored and correlated to the growth conditions using both a colorimetric assay and chromatographic methods. Fermentor experiments in batch mode yielded 100 mg l⁻¹ of EPS from L. bulgaricus and 350 mg l⁻¹ from L. casei. Moreover, the use of a microfiltration (MF) bioreactor resulted in exopolysaccharides (EPS) concentrations threefold and sixfold those of batch experiments, respectively. The monosaccharidic composition of the two analyzed polymers differed from those previously reported. The optimization of the production of EPSs using the MF fermentation strategy could permit the use of these molecules produced by generally recognised as safe (GRAS) microorganisms in the place of other polysaccharides in the food industry.     

Factors Affecting Exocellular Polysaccharide Production by Lactobacillus delbrueckii subsp. bulgaricus Grown in a Chemically Defined Medium

We developed a chemically defined medium (CDM) containing lactose or glucose as the carbon source that supports growth and exopolysaccharide (EPS) production of two strains of Lactobacillus delbrueckii subsp. bulgaricus. The factors found to affect EPS production in this medium were oxygen, pH, temperature, and medium constituents, such as orotic acid and the carbon source. EPS production was greatest during the stationary phase. Composition analysis of EPS isolated at different growth phases and produced under different fermentation conditions (varying carbon source or pH) revealed that the component sugars were the same. The EPS from strain L. delbrueckii subsp. bulgaricus CNRZ 1187 contained galactose and glucose, and that of strain L. delbrueckii subsp. bulgaricus CNRZ 416 contained galactose, glucose, and rhamnose. However, the relative proportions of the individual monosaccharides differed, suggesting that repeating unit structures can vary according to specific medium alterations. Under pH-controlled fermentation conditions, L. delbrueckii subsp. bulgaricus strains produced as much EPS in the CDM as in milk. Furthermore, the relative proportions of individual monosaccharides of EPS produced in pH-controlled CDM or in milk were very similar. The CDM we developed may be a useful model and an alternative to milk in studies of EPS production.     

Effective plasmid pX3 transduction in Lactobacillus delbrueckii by bacteriophage LL-H

High-frequency plasmid transductions in Lactobacillus delbrueckii subsp. lactis and subsp. bulgaricus strains mediated by pac-type bacteriophages were observed and further investigated. The frequency of plasmid transduction by phages LL-H and LL-S attained levels of from 0.10 to about 1 with plasmid pX3, but only about 2 × 10⁻² with plasmid pJK650. Infection of L. delbrueckii subsp. lactis strain LKT(pX3) or ATCC 15808(pX3) with phage LL-H resulted in intensive concatemerization of plasmid pX3, and most progeny phage particles contained concatemers of plasmid DNA instead of phage LL-H DNA. The synthesis of phage LL-H DNA was depressed. No evident homology or recombination was observed between phage LL-H DNA and plasmid pX3. The unusually high frequency of plasmid pX3 transduction by phage LL-H could be considered to result from specific interaction(s) between a particular phage and plasmid. These interactions may include pX3-mediated blockage of phage LL-H DNA replication and effective use of a particular pac-like site located about 1 kb from BglII in the smaller NdeI-BglII fragment of plasmid pX3. Phage LL-H together with plasmid vector pX3 could be used as effective plasmid transduction tools for genetic engineering of L. delbrueckii subsp. lactis and subsp. bulgaricus strains.     

Cholesterol removal by some lactic acid bacteria that can be used as probiotic

In the present study, the relationship between exopolysaccharide production and cholesterol removal rates of five strains of Lactobacillus delbrueckii subsp. bulgaricus isolated from home‐made yoghurt was studied. Test strains were selected according to their exopolysaccharide production capacity. Influence of different bile concentrations on cholesterol removal was investigated. It was confirmed that B3, ATCC 11842 and G11 strains which produce high amounts of exopolysaccharide (211, 200 and 159 mg/l, respectively) were able to remove more cholesterol from the medium compared to those that produce low amounts of exopolysaccharide (B2, A13). The highest cholesterol removal (31%) was observed by strain L. delbrueckii subsp. bulgaricus B3, producing a high amount of exopolysaccharide, in 3 mg/ml bile concentration. Cholesterol removal by resting and dead cells was investigated and it was found to be 4%–14% and 3%–10%, respectively. Cholesterol removal by immobilized and free cells of the B3 strain was studied and it was determined that immobilized cells are more effective. Influence of cholesterol on exopolysaccharide production has also been tested and it was found that cholesterol increased the production of EPS. The results indicated that: (i) there is a correlation between cholesterol removal and EPS production; and (ii) L. delbrueckii subsp. bulgaricus B3 is regarded as a suitable candidate probiotic and adjunct culture.     

Hydrolysis of organic phosphates by corn and soybean roots

Because of the importance of organic phosphates as sources of P for plants, this work was performed to study the hydrolysis of nine organic phosphates by sterile, intact corn (Zea mays L.) and soybean (Glycine max L.) roots. Results showed that the rates of hydrolysis ofp-nitrophenyl phosphate (PNP) in buffered solutions by roots of three varieties of corn and three varieties of soybean ranged from 13 to 22 μmol PO₄−P g⁻¹ root h⁻¹ and from 2.1 to 2.2 μmol PO₄−P 0.1 g⁻¹ root h⁻¹, respectively. The average rate of hydrolysis of PNP in nonbuffered solutions was 2- to 3-fold lower for corn roots and 6- to 10-fold lower for soybean roots as compared with those obtained with buffered solutions. The orthophosphate released from hydrolysis of organic P compounds in buffered solutions during a 48-h incubation of corn roots showed that the maximum rate of hydrolysis of PNP was 4 to 6 times greater than the commonly used substrates: α- and β-glycerophosphates, phenolphthalein diphosphate, and glucose-6-phosphate. The rates of hydrolysis of glucose-6-phosphate and glucose-1-phosphate were similar and about 6- to 12-fold lower than that of PNP. Phosphoethanolamine and phosphocholine were hydrolyzed slightly, ando-carboxyphenyl phosphate was not hydrolyzed. The rates of hydrolysis of organic P compounds in nonbuffered solutions by corn and soybean roots were 1 to 3 and 1 to 10 times lower than those in buffered solutions, respectively. The trends in rates of hydrolysis by soybean roots of buffered organic P substrates were similar to those observed with corn roots, with the exception of glucose-1-phosphate and phosphoethanolamine.     

Growth and Proteolytic Activity of Lactobacillus delbrueckii ssp. bulgaricus and Streptococcus thermophilus in Reduced Sodium Kashkaval Cheese

Summary Reduced sodium Kashkaval cheese was produced from cow’s milk. Mixtures of NaCl, NaCl:KCl (1:1, 2:1) and NaCl:KH₂PO₄ (1:1, 2:1) were used for hot brining and salting of the cheddarized cheese curd. There were no significant differences (P < 0.05) in the count of Lb. delbrueckii ssp. bulgaricus after aging of Kashkaval samples. At the end of the ripening process the counts of Lb. delbrueckii ssp. bulgaricus reached 10⁶ c.f.u./g and the counts of Streptococcus thermophilus varied from 10⁴ to 10⁵ c.f.u./g. Proteolysis during ripening of reduced sodium Kashkaval cheese, initiated by the starter microorganisms Streptococcus thermophilus and Lactobacillus delbrueckii ssp. bulgaricus, was studied through the changes in the levels of non-casein and non-protein nitrogen. It was observed that non-casein and non-protein nitrogen increased significantly (P < 0.05) during ripening. The amounts of non-casein and non-protein nitrogen accumulated in the studied Kashkaval samples were similar. That indicates that the partial replacement of NaCl with KCl or KH₂PO₄ does not cause significant changes in the course of proteolysis of Kashkaval cheese by Streptococcus thermophilus and Lactobacillus delbrueckii ssp. bulgaricus.     

Double Mutants of Cellulomonas biazotea for Production of Cellulases and Hemicellulases following Growth on Straw of a Perennial Grass

Summary Deoxyglucose-resistant mutants of Cellulomonas biazotea secreted elevated levels of cellulases and xylanases. The production of β-glucosidase in the constitutive mutant was increased 5-fold over its parent strain. This mutant showed an approximately 1.6-fold enhanced productivity of extracellular endo-glucanase following growth on Leptochloa fusca over the mutant parent. Extracellular production of xylanase, filter-paper cellulase (FPase) and endo-glucanase (CMCase) were also altered in the mutant. Maximum volumetric productivities for xylanase, β-xylosidase, FPase, β-glucosidase and endo-glucosidase were 451, 98, 80, 95, and 143 IU l⁻¹ h⁻¹ which were significantly more than their respective values from the parental strains. The enzyme preparation of the mutants exhibited improved saccharification of kallar grass straw.     

Frontiers in mycoplasma pathogenicity

Four different strains ofLactobacillus delbrueckii subsp.bulgaricus (Ss₁ and Yop₁₂) andStreptococcus salivarius subsp.thermophilus (Ss₂ and Yop₉) were isolated from two different yogurt sources in Argentina. In medium containing different carbon sources: lactose, fructose, sucrose or glucose plus fructose, the growth of a mixed culture (Yop₁₂+Ss₂) shows stimulation ofS. thermophilus and inhibition ofL. bulgaricus with respect to pure cultures. Both microorganisms in mixed culture grew less well on glucose plus galactose. However, in medium with glucose or galactose, both microorganisms were stimulated.     

A new methodology for rapid detection of Lactobacillus delbrueckii subsp. bulgaricus based on multiplex PCR

In this study we present a novel multiplex PCR assay for rapid and efficient detection of Lactobacillus delbrueckii subsp. bulgaricus. The accuracy of our method was confirmed by the successful identification of L. delbrueckii subsp. bulgaricus in commercial yoghurts and food supplements and it may be readily applied to the food industry.     

Galacto-oligosaccharides as protective molecules in the preservation of Lactobacillus delbrueckii subsp. bulgaricus

In this work, the protective capacity of galacto-oligosaccharides in the preservation of Lactobacillus delbrueckii subsp. bulgaricus CIDCA 333 was evaluated.Lactobacillus bulgaricus was freeze-dried or dried over silica gel in the presence of three commercial products containing galacto-oligosaccharides. The freeze-dried samples were stored at 5 and 25 °C for different periods of time. After desiccation, freeze-drying or storage, samples were rehydrated and bacterial plate counts were determined.According to the results obtained, all galacto-oligosaccharides assays demonstrated to be highly efficient in the preservation of L. bulgaricus. The higher content of galacto-oligosaccharides in the commercial products was correlated with their higher protective capacity.Galacto-oligosaccharides are widely known by their prebiotic properties. However, their role as protective molecules have not been reported nor properly explored up to now. In this work the protective capacity of galacto-oligosaccharides in the preservation of L. bulgaricus, a strain particularly sensitive to any preservation process, was demonstrated.The novel role of galacto-oligosaccharides as protective molecules opens up several perspectives in regard to their applications. The supplementation of probiotics with galacto-oligosaccharides allows the production of self-protected synbiotic products, galacto-oligosaccharides exerting both a prebiotic and protecting effect.     

Optimization of a protective medium for enhancing the viability of freeze-dried Lactobacillus delbrueckii subsp. bulgaricus based on response surface methodology

Response surface methodology (RSM) was used to optimize a protective medium for enhancing the cell viability of Lactobacillus delbrueckii subsp. bulgaricus LB14 during freeze-drying. Using a previous Plackett–Burman design, it was found that sucrose, glycerol, sorbitol and skim milk were the most effective freeze-drying protective agents for L. bulgaricus LB14. A full factorial central composite design was applied to determine the optimum levels of these four protective agents. The experimental data allowed the development of an empirical model (P<0.0001) describing the inter-relationships between the independent and dependent variables. By solving the regression equation, and analyzing the response surface contour and surface plots, the optimal concentrations of the agents were determined as: sucrose 66.40 g/L, glycerol 101.20 g/L, sorbitol 113.00 g/L, and skim milk 130.00 g/L. L. bulgaricus LB14 freeze-dried in this medium obtained a cell viability of up to 86.53%.     

Development and characterization of a potent producer of penicillin G amidase by mutagenization

Summary The penicillin G amidase (PGA) activity of a parent strain of E. coli (PCSIR-102) was enhanced by chemical mutagenization with N-methyl-N′-nitro-N-nitrosoguanidine (MNNG). After screening and optimization, a penicillinase deficient mutant (MNNG-37) was isolated and found effective for the production of penicillin G amidase as compared to the parent strain of E. coli (PCSIR-102). Penicillin G amidase activity of MNNG-37 appeared during an early stage of growth, whereas PCSIR-102 did not exhibit PGA activity due to the presence of penicillinase enzyme which inhibits the activity of enzyme PGA. However, MNNG-37 gave a three-fold increase in enzyme activity (231 IU mg⁻¹) as compared to PCSIR-102 (77 IU mg⁻¹) in medium containing 0.15 and 0.1% concentrations of phenylacetic acid, respectively which was added after 6 h of cultivation. The difference in K _m values of the enzyme produced by parent strain PCSIR-102 (0.26 mM) and mutant strain MNNG-37 (0.20 mM) is significant (1.3-fold increase in K _m value) which may show the superiority of the latter in terms of better enzyme properties.     

The isolation and characterization of a mutant allele at a new X-linked locus,mex, affecting NADP+-dependent enzymes inDrosophila melanogaster

The isolation and characterization of mutant alleles in a regulatory gene affecting NADP⁺-dependent enzymes are described. The locus,mex, is at position 26.5 ± 0.74 on the X chromosome ofDrosophila melanogaster. The newly isolated mutant allele,mex ¹, is recessive to either themex allele found in Oregon-R wild-type individuals or that found in thecm v parental stock in which the new mutants were induced. Themex ¹ mutant allele is associated with statistically significant decreases in malic enzyme (ME) specific activity and ME specific immunologically cross-reacting material (ME-CRM) in newly emerged adult males. During this same developmental stage in males, the NADP⁺-dependent isocitrate dehydrogenase specific activity increases to statistically significant levels. Females of themex ¹ mutant strain show statistically significant elevated levels of the pentose phosphate shunt enzymes, glucose-6-phosphate dehydrogenase and 6-phosphogluconate dehydrogenase. Isoelectric focusing and thermolability comparisons of the active ME from mutant and control organisms indicate that the enzyme is the same. Developmental profiles ofmex ¹ and control strains indicate that this mutant allele differentially modulates the levels of ME enzymatic activity and ME-CRM during development. This work was supported by an Operating Grant from the Natural Sciences and Engineering Research Council of Canada to M.M.B.     

Effect of medium composition on the ultrastructure of Lactobacillus strains

The growth of some locally isolated Lactobacillus strains forming D(-) or L(+) lactic acid, Lactobacillus helveticus ATCC 15009 and Lactobacillus delbrueckii subsp. bulgaricus ATCC 11842 was examined in different media. L. helveticus and Lactobacillus LBL strains formed atypical protoplast-like cells in LAPT medium, sensitive to SDS and proteinase. Specific morphological changes in the cell wall structure of these variants were revealed by transmission and scanning electron microscopy. The effect of glucose and various salts on their appearance was investigated. The prevalent role of metal cations, especially of Mg²⁺, was established.     

Enhanced iturin A production by <Emphasis Type="Italic">Bacillus subtilis</Emphasis> and its effect on suppression of the plant pathogen <Emphasis Type="Italic">Rhizoctonia solani</Emphasis>

The behavior of Streptomyces peucetius var. caesius N47 was studied in a glucose limited chemostat with a complex cultivation medium. The steady-state study yielded the characteristic constants μ _max over 0.10 h⁻¹, Y _XS 0.536 g g⁻¹, and m_S 0.54 mg g⁻¹ h⁻¹. The product of secondary metabolism, ɛ-rhodomycinone, was produced with characteristics Y _PX 12.99 mg g⁻¹ and m _P 1.20 mg g⁻¹ h⁻¹. Significant correlations were found for phosphate and glucose consumption with biomass and ɛ-rhodomycinone production. Metabolic flux analysis was conducted to estimate intracellular fluxes at different dilution rates. TCA, PPP, and shikimate pathway fluxes exhibited bigger values with production than with growth. Environmental perturbation experiments with temperature, airflow, and pH changes on a steady-state chemostat implied that an elevation of pH could be the most effective way to shift the cells from growing to producing, as the pH change induced the biggest transient increase to the calculated ɛ-rhodomycinone flux.