重组巴氏毕赤酵母恒化培养动力学及代谢迁移特性研究

通过对甲醇营养型毕赤酵母基因工程菌以碳源甘油为限制性基质进行恒化培养动力学试验 ,结果认为 :(1 )细胞光密度与其干、湿重呈线性关系 ,当细胞光密度 (OD60 0 )为 1 0 0时细胞湿重 (WCW)为 1 2 8 3g L ,细胞干重 (WDW)则为 2 2 9g L ;(2 )基因工程菌P .pastoris的生长与限制性基质甘油残留浓度的关系符合Monod关系式 ,通过 1 μ对 1 S进行线性回归得 μmax=0 .366h- 1,Ks=0 .1 82 3g L ,经参数推导甘油最大菌体得率系数YG =0 .54g g ,菌体维持生长消耗底物系数m =0 .0 0 69g (g·h) ;氧最大菌体系数YX O2 =30 .96g moL ,菌体维持生长时消耗氧系数mO2 =0 .0 0 0 8mol (g·h) ,最适理论稀释速率Dm =0 .341h- 1;(3)从氨水的消耗速率和呼吸商 (RQ)的变化认为随着比生长速率 (μ)的增大 ,甘油代谢流从糖原异生和磷酸戊糖途径线性地向糖酵解和三羧酸循环途径进行代谢迁移 ,即糖酵解和三羧酸循环途径的代谢流量在线性地增大     

Ethanol production from seaweed (Undaria pinnatifida) using yeast acclimated to specific sugars

Ethanol production from Undaria pinnatifida (Sea mustard, Miyuk) was performed using yeast acclimated to specific sugars. Pretreatment conditions were optimized by thermal acid hydrolysis and enzyme treatment to increase the monosaccharide yield. Pretreatment by thermal acid hydrolysis was carried out using seaweed powder at 8 ～ 17% (w/v) solid content with a treatment time of 30 ～ 60 min. Enzyme treatment was carried out with 1% (v/v) Viscozyme L (1.2 FGU/mL), 1% (v/v) Celluclast 1.5 L (8.5 EGU/mL), 1% (v/v) AMG 300 L (3.0 AGU/mL), and 1% (v/v) Termamyl 120 L (0.72 KNU/mL). All enzymes except Termamyl 120 L, which was applied during pretreatment, were treated at 45°C for 24 h following pretreatment. Optimal pretreatment and enzyme conditions were determined to be 75 mM H₂SO₄, 13% (w/v) slurry, and 2.88 KNU/mL Termamyl 120 L at 121°C for 60 min. A maximum monosaccharide concentration of 33.1 g/L with 50.1% theoretical yield was obtained. To increase the ethanol yield, Pichia angophorae KCTC 17574 was acclimated to a high concentration (120 g/L) of galactose and mannitol at 30oC for 24 h. Ethanol production of 12.98 g/L with 40.12% theoretical yield was obtained from U. pinnatifida through fermentation with 0.35 g dry cell weight/L P. angophorae KCTC 17574 acclimated to mannitol and galactose.     

Isolation of γ-aminobutyric acid-producing bacteria and optimization of fermentative medium

Ten γ-aminobutyric acid (GABA)-producing lactic acid bacteria (LAB) strains were isolated from kimchi and yoghurt. The strain B, isolated from kimchi showed the highest GABA-producing ability (3.68 g/L) in MRS broth with 1% monosodium glutamate (MSG). Strain B was identified as Lactococcus lactis subsp. lactis. The GABA-producing ability of L. lactis B was investigated using brown rice juice, germinated soybean juice and enzymolyzed skim milk as medium compositions. The D-optimal mixture design was applied to optimize the ratio of the three kinds of components in the media. The results showed that when the mixing ratio of brown rice juice, germinated soybean juice and enzymolyzed skim milk was 33:58:9 (v:v:v), the maximum GABA yield of L. lactis B was 6.41 g/L.     

通气量和菊粉浓度对克鲁维酵母乙醇发酵的影响

马克斯克鲁维酵母能够利用集成生物加工技术发酵菊芋生产乙醇,具有非粮燃料乙醇生产潜力.文中研究了该技术中的两个关键因素(通气量和底物浓度)对于K.marxinaus YX01乙醇发酵过程和菊粉酶活性的影响.研究结果表明,底物浓度对乙醇得率影响不大,底物浓度为250 g/L时,发酵终点乙醇浓度为84.74 g/L,但乙醇得率由低浓度50 g/L的86.4％(理论值),降为84.7％.通气能够加速K.marxinaus YX01的乙醇发酵过程,但降低了乙醇得率,当底物浓度为250 g/L时,乙醇得率由不通气的84.7％降为1.0 vvm时的73.3％.随底物浓度的升高及通气量的降低,K.marxinaus YX01分泌的菊粉酶活力表现出降低的趋势.在不通气及底物浓度为250 g/L时,菊粉酶的活性为6.59 U/mL,而底物浓度50 g/L,通气量1.0 vvm时的酶活力为21.54 U/mL.乙醇发酵过程中的副产物甘油随通气量的降低及底物浓度的升高而增大,而乙酸的浓度随通气量的增大及底物浓度的升高而升高.     

Extractive fermentation for butyric acid production from glucose by Clostridium tyrobutyricum

A novel extractive fermentation for butyric acid production from glucose, using immobilized cells of Clostridium tyrobutyricum in a fibrous bed bioreactor, was developed by using 10% (v/v) Alamine 336 in oleyl alcohol as the extractant contained in a hollow-fiber membrane extractor for selective removal of butyric acid from the fermentation broth. The extractant was simultaneously regenerated by stripping with NaOH in a second membrane extractor. The fermentation pH was self-regulated by a balance between acid production and removal by extraction, and was kept at approximately pH 5.5 throughout the study. Compared with conventional fermentation, extractive fermentation resulted in a much higher product concentration (>300 g/L) and product purity (91%). It also resulted in higher reactor productivity (7.37 g/L. h) and butyric acid yield (0.45 g/g). Without on-line extraction to remove the acid products, at the optimal pH of 6.0, the final butyric acid concentration was only approximately 43.4 g/L, butyric acid yield was 0.423 g/g, and reactor productivity was 6.77 g/L. h. These values were much lower at pH 5.5: 20.4 g/L, 0.38 g/g, and 5.11 g/L. h, respectively. The improved performance for extractive fermentation can be attributed to the reduced product inhibition by selective removal of butyric acid from the fermentation broth. The solvent was found to be toxic to free cells in suspension, but not harmful to cells immobilized in the fibrous bed. The process was stable and provided consistent long-term performance for the entire 2-week period of study.     

Separate hydrolysis and fermentation (SHF) of Prosopis juliflora, a woody substrate, for the production of cellulosic ethanol by Saccharomyces cerevisiae and Pichia stipitis-NCIM 3498

Prosopis juliflora (Mesquite) is a raw material for long-term sustainable production of cellulosics ethanol. In this study, we used acid pretreatment, delignification and enzymatic hydrolysis to evaluate the pretreatment to produce more sugar, to be fermented to ethanol. Dilute H(2)SO(4) (3.0%,v/v) treatment resulted in hydrolysis of hemicelluloses from lignocellulosic complex to pentose sugars along with other byproducts such as furfural, hydroxymethyl furfural (HMF), phenolics and acetic acid. The acid pretreated substrate was delignified to the extent of 93.2% by the combined action of sodium sulphite (5.0%,w/v) and sodium chlorite (3.0%,w/v). The remaining cellulosic residue was enzymatically hydrolyzed in 0.05 M citrate phosphate buffer (pH 5.0) using 3.0 U of filter paper cellulase (FPase) and 9.0 U of beta-glucosidase per mL of citrate phosphate buffer. The maximum enzymatic saccharification of cellulosic material (82.8%) was achieved after 28 h incubation at 50 degrees C. The fermentation of both acid and enzymatic hydrolysates, containing 18.24 g/L and 37.47 g/L sugars, with Pichia stipitis and Saccharomyces cerevisiae produced 7.13 g/L and 18.52 g/L of ethanol with corresponding yield of 0.39 g/g and 0.49 g/g, respectively.     

菊糖芽孢乳杆菌DS2-18中试规模的D-乳酸发酵研究

研究了菊糖芽孢乳杆茵DS2的突变株DS2-18在中试规模的D-乳酸发酵.在容积为300L自控发酵罐中,DS2-18茵在合适的发酵条件下,即培养基组成(g/L):葡萄糖120,玉米浆8,蛋白胨6,豆粕水解液100,接种量8%(v/v),发酵温度40℃,以轻质碳酸钙作为中和剂调pH 5～6,发酵期间交替不通气和通气,发酵6...     

Effect of pH on<Emphasis Type="Italic"> Lactobacillus fermentum</Emphasis> growth,raffinose removal, α-galactosidase activity and fermentation products

In this study, the behaviour of Lactobacillus fermentum CRL 722 and CRL 251 were evaluated under different pH conditions (pH 6.0, 5.5, 5.0, 4.5) and without pH control. Growth was similar under all conditions assayed except at pH 4.5. These microorganisms were able to eliminate raffinose, a nondigestible -oligosaccharide (NDO) found in soy products, showing a consumption rate of 0.25 g l^–1 h^–1 (pH 6.0–5.0). The removal of raffinose was due to the high -galactosidase (-gal) activities of these lactic acid bacteria, which was highest at pH 5.5 (5.0 U/ml). The yield of organic acids produced during raffinose consumption was also highest at this pH. The results of this study will allow selection of the optimum growth conditions of L. fermentum with elevated levels of -gal to be used in the reduction of NDO in soy products when used as starter cultures.     

（S）-（-）-β-羟基苯丙酸乙酯的微生物法合成

采用酿酒酵母CGMCC No．2266菌体,不对称还原β-羰基苯丙酸乙酯制备光学纯（S）-（-）-β-羟基苯丙酸乙酯。结果表明：采用初始pH为8．0的液体发酵培养基培养的CGMCCNo．2266菌体经过50℃预热处理30min后用于生物转化获得的（S）-（-）-G-羟基苯丙酸乙酯对映体过剩值可以达到100％ee。确定了合成（S）-（-）-β-羟基苯丙酸乙酯的较佳转化条件为pH7．0,温度30℃,转化时间24h,底物浓度为3．63mmol／L,菌体用量为86g/L（干重／反应体积）。以10％葡萄糖为辅助底物,产率比不加辅助底物时提高了75．4％。在最佳转化条件下反应转化率及（S）-（-）-β-羟基苯丙酸乙酯对映体过剩值可分别达到98．4％和100％ee。     

A simple method for the fluorescence analysis of nucleic acid-dye complexes in cytological preparations

Summary This communication describes a simple method for recording fluorescence emission spectra of cytological preparations using a conventional fluorescence spectrophotometer. The emission characteristics of in situ complexes between some basic fluorochromes (DAPI, 33258 Hoechst, acridine orange, pyronin Y, and ethidium bromide) and nucleic acid containing structures from smears of chicken blood and Ehrlich tumor cells (chromatin, basophilic cytoplasm) are briefly described.     

产琥珀酸重组大肠杆菌的发酵性能研究

研究了重组大肠杆菌JM001(△ppc)/pTrc99a-pck发酵产琥珀酸的性能,结果表明厌氧条件下其耗糖能力和产酸能力分别为对照菌株JM001的4.2倍和15.3倍。进一步优化发酵条件表明：采用接入菌泥的发酵方式比按照10%接种量转接厌氧发酵的效果要好,琥珀酸的对葡萄糖的质量收率提高了约10%,且副产物乙酸的量进一步降低。初始葡萄糖浓度高于60g/L时会对菌株的生长和产酸产生抑制,且浓度越高,抑制作用越明显。7L发酵罐放大实验中,整个厌氧发酵阶段葡萄糖的消耗速率为0.42g/(L.h),琥珀酸对葡萄糖的质量收率为67.75%,琥珀酸的生产强度为0.28g/(L.h)。     

高产吩嗪-1-羧酸（PCA）假单胞菌株M18G发酵优化模型的构建

吩嗪-1-羧酸（phenazine-1-carboxylic acid, PCA）是促进根际生长假单胞菌分泌的重要抗菌物质。采用Plackett-Burman（PB）设计和响应面法（response surface method, RSM）对假单胞菌株M18（Pseudomonas sp. M18）的gacA基因突变株M18G的次级代谢产物PCA发酵的营养条件进行建模。运用Plackett-Burman（PB）设计试验,从12个营养成分中筛选出4个关键的组分,进而采用RSM 法对这4个因素进行中心组合设计试验,建立回归方程并进行统计学分析,绘制各营养因子之间的关系图。实验结果表明：建立的模型能合理地模拟并优化发酵中各参数及其浓度,确定发酵培养基的成分和浓度为：黄豆粉33.4g/L,葡萄糖12.7g/L,大豆蛋白胨10.9g/L和乙醇13.8 g/L, M18G菌株经60 h发酵培养,最高PCA产率能达到1.89 g/L,比优化前提高了6倍左右。各营养因子的等值线图表明黄豆粉和乙醇在PCA高产发酵中起到更为关键的作用,因此提供了提高PCA发酵产量的有效方法,并为其未来商业化应用奠定了基础。     

Optimization of pretreatment and saccharification for the production of bioethanol from water hyacinth by Saccharomyces cerevisiae

Alkaline-oxidative (A/O) pretreatment and enzymatic saccharification were optimized for bioethanol fermentation from water hyacinth by Saccharomyces cerevisiae. Water hyacinth was subjected to A/O pretreatment at various NaOH and H(2)O(2) concentrations and reaction temperatures for the optimization of bioethanol fermentation by S. cerevisiae. The most effective condition for A/O pretreatment was 7% (w/v) NaOH at 100 °C and 2% (w/v) H(2)O(2). The carbohydrate content was analyzed after reaction at various enzyme concentrations and enzyme ratios using Celluclast 1.5 L and Viscozyme L to determine the effective conditions for enzymatic saccharification. After ethanol fermentation using S. cerevisiae KCTC 7928, the concentration of glucose, ethanol and glycerol was analyzed by HPLC using a RI detector. The yield of ethanol in batch fermentation was 0.35 g ethanol/g biomass. Continuous fermentation was carried out at a dilution rate of 0.11 (per h) and the ethanol productivity was 0.77 [g/(l h)].     

Growth and lactic acid production in batch culture of Lactobacillus rhamnosus in a defined medium

To facilitate metabolic analysis, batch fermentations of Lactobacillus rhamnosus were carried out in a new defined medium. Biomass at 10.5 g/l and lactic acid at 67 g/l with a YP/S of 0.84 were achieved. The maximum specific growth rate and the average productivity were 0.49/h and 2.48 g/l.h, respectively. These are comparable to those of this organism and related organisms in complex media. Preliminary amino acid studies were also conducted, highlighting the importance of serine, asparagine, glutamine and cysteine. Kinetic analysis revealed that lactic acid production was predominantly growth-associated with growth associated and non-growth associated lactic acid constants of 0.389 mol/g-cell and 0.0025 mol/g-cell.h, respectively. Finally a kinetic model has been included to describe the fermentation of L. rhamnosus.     

碳源和氮源对5-酮基-葡萄糖酸生成的影响

氧化葡萄糖杆菌Gluconobacter oxydans可以将葡萄糖氧化成葡萄糖酸,并进一步氧化成2-酮基-葡萄糖酸(2KGA)和5-酮基-葡萄糖酸(5KGA),其中5KGA在催化剂的作用下能够转化为L(+)-酒石酸。为了提高5-酮基-葡萄糖酸产量,以仅生成5KGA的氧化葡萄糖杆菌Gluconobacter oxydans HGI-1为出发菌株,研究不同碳源(蔗糖、乳糖、麦芽糖、淀粉、葡萄糖)和有机氮源(酵母浸粉、鱼粉、玉米浆、黄豆饼粉、棉籽饼粉)对5KGA产量的影响。500 mL摇瓶试验结果表明,当葡萄糖浓度为100 g/L时,5KGA产量最高为98.20 g/L;当有机氮源为酵母浸粉、鱼粉和玉米浆,其添加量的蛋白含量为1.60%时,5KGA产量分别为100.20 g/L、109.10 g/L和99.83 g/L,其中,使用鱼粉的5KGA产量最高,使用玉米浆的5KGA产量比酵母浸粉略低。出于经济考虑,文中选择玉米浆作有机氮源,并在5 L发酵罐中进行分批发酵放大试验,5KGA的产量为93.80 g/L,最大生成速率为3.48 g/(L·h),平均生成速率为1.56 g/(L·h)。结果表明,葡萄糖和玉米浆分别为Gluconobacter oxydans HGI-1规模化生产5KGA的最适碳源和氮源,可利用葡萄糖几乎全部(85.93%)转化为5KGA。     

L-lactic acid production by Lactobacillus casei fermentation with corn steep liquor-supplemented acid-hydrolysate of soybean meal

Batch and fed-batch fermentation studies were performed to evaluate the potential of corn steep liquor (CSL)-supplemented acid-hydrolysate of soybean meal (AHSM) as an alternative to yeast extract (YE) for the production of L-lactic acid by Lactobacillus casei LA-04-1. The CSL-supplemented AHSM gave an outstanding result in supporting L-lactic acid production from glucose. In the exponential fed-batch fermentation, the concentration, yield and productivity of L-lactic acid were 162.5 g/L, 89.7% and 1.69 g/L per h, respectively, which were lower than those with 20 g/L YE (180 g/L, 90.3%, 2.14 g/L per h) after 96 h of fermentation. However, the raw material cost of the nitrogen resource was estimated as only 25% of that using the YE.     

pH控制对热凝胶发酵的影响

热凝胶 (Ｃｕｒｄｌａｎ)是一种直链结构的 β 1,3 葡聚糖 ,由Ａｌｃａｌｉｇｅｎｅｓｆａｅｃａｌｉｓｖａｒ.ｍｙｘｏｇｅｎｅｓ发酵生产而来 ,是一种新型的微生物胞外多糖[1 ] ,其分子量在 5 0万左右。热凝胶在中性条件下不溶于水 ,但能溶于碱溶液中。加热含有热凝胶的水浊液可形成两种类型的凝胶 ,一种是弹性较低的类似琼脂的可逆胶 ;另外一种是凝胶强度大、弹性好的热不可逆胶。由于热凝胶具有独特的热成胶性能 ,在食品工业 ,特别是高温制作的食品领域具有广阔的应用前景。热凝胶的胶体可以包容和控制药物的扩散 ,所以可以用来作为药物…     

Continuous production of ammonium lactate by Streptococccus cremoris in a three-stage reactor

Batch and continuous fermentation studies were performed to optimize the production of ammonium lactate from whey to optimize the production of ammonium lactate from whey permeate. The product known as fermented ammoniated condensed whey permeate (FACWP) is a very promising animal feed. After an initial screening of four strains which produce predominantly L(+)- lactic acid, the desired isomer [D(-)-lactic acid is toxic], Streptococcus cremoris 2487 was chosen for further study. In batch mode, pH between 6.0 and 6.5 and 35 degrees C provided optimum incubation conditions. To stimulate a plug flow reactor, three CSTRs (continuous stirred tank reactors) were connected in tandem. For a 7.5-h retention time, 1.6-fold and 1.3-fold higher productivities were obtained for three-stage than for the single- and two-stage reactors, respectively. Various retentions times were examined (5, 7.5, and 10 h; 5g/L yeast extract). Although maximum lactate productivity occurred at a 5-h residence time (5.38 g/L H. 75% lactose utilization), lactose utilization was more complete at 7.5 h (4.38 g/L h productivity, 91% lactose utilization and a productivity, 91% lactose utilization). Retention time was increased to 15 h to obtain 95.9% lactose utilization and a productivity of 2.42g/L h for 2g/L yeast extract. Based on this lower yeast extract concentration, it was determined that ammonium lactate production and subsequent concentration by 11-fold would yield a product (FACWP) 17% more than soybean meal (crude protein contents are equivalent, 44%) at current market prices.     

Low-cost propionate salt as road deicer: evaluation of cheese whey and other media constituents

Propionate and acetate salts are environmentally friendly, effective road deicer substitutes for widely used sodium chloride. A low-cost medium, using raw cheese whey and hydrolyzed whey permeate/whey permeate powder as substrates, and corn-steep liquor as a nutrient supplement, was studied for lactic acid production, replacing synthetic lactose and other high-cost nutrients. A non-sterile stage-I fermentation process for improved lactate productivity using an inexpensive commercial medium was performed at a 20-L fermenter level. A lactate yield of 0.98 g/g lactose and a productivity of 1.1 g/L/h was obtained with complete lactose utilization. When synthetic lactate and glucose were used as substrates in propionate and acetate fermentation, a total acid yield of 0.55 g/g glucose and lactate consumed and a batch productivity of 0.22 g/L/h was obtained. A stage-II fermentation process to produce propionate and acetate salts from cheese whey-derived lactate (stage-I fermentation broth) resulted in 1.6%( w/v) propionate after a total of 161 h (stages I and II).     

丙烯酸对十六碳二元酸发酵的影响和16L罐扩试

本文报道丙烯酸对发酵生产十六碳二元酸(DC_(16))的影响,加入0.1%丙烯酸,DC_(16)产量提高20—30%.在16L自动控制罐上,在最佳条件下,加入20%(v/v)正十六烷(nC_(16)),发酵5天,DC_(16)高达120g/L,nC_(16)的转化率高达79%.