Chemolithotrophic Bacteria in Copper Ores Leached at High Sulfuric Acid Concentration

Extensive bacterial growth was observed when copper sulfide ores were leached with 0.6 N sulfuric acid. The bacterial population developed in this condition was examined by characterization of the spacer regions between the 16S and 23S rRNA genetic loci obtained after PCR amplification of the DNA extracted from the leached ore. The spacers observed had the sizes found in strains of "Leptospirillum ferrooxidans" and Thiobacillus thiooxidans, except for a larger one, approximately 560 bp long, that was not observed in any of the strains examined, including those of Thiobacillus ferrooxidans. The bacteria with this last spacer were selected after culturing in mineral and elemental sulfur media containing 0.7 N sulfuric acid. The spacer and the 16S ribosomal DNA of this isolate were sequenced and compared with those in species commonly found in bioleaching processes. Though the nucleotide sequence of the spacer showed an extensive heterologous region with T. thiooxidans, the sequence of its 16S rDNA gene indicated a close relationship (99.85%) with this species. These results indicate that a population comprised of bacterial strains closely related to T. thiooxidans and of another strain, possibly related to "L. ferrooxidans," can develop during leaching at high sulfuric acid concentration. Iron oxidation in this condition is attributable to "L. ferrooxidans" and not T. ferrooxidans, based on the presence of spacers with the "L. ferrooxidans" size range and the absence of spacers characteristic of T. ferrooxidans.     

嗜酸异养菌对自养菌Acidithiobacillus ferrooxidans金属离子抗性和生物浸出的影响

【目的】了解嗜酸异养菌在诸如酸性矿坑水(AMD)和生物浸出体系等极端酸性环境中对浸矿微生物产生的影响。【方法】研究由嗜酸异养菌Acidiphilium acidophilum和自养菌Acidithiobacillus ferrooxidans经长期驯化后形成的共培养体系分别在Cd2+、Cu2+、Ni2+和Mg2+胁迫下的稳定性;并将此共培养体系应用于黄铁矿和低品位黄铜矿的生物浸出实验。【结果】在上述4种金属离子分别存在的条件下,异养菌Aph.acidophilum均能促进At.ferrooxidans对亚铁的氧化,提高其对能源利用的效率。共培养体系中的异养菌Aph.acidophilum使At.ferrooxidans对Cu2+的最大耐受浓度(MTC)由2.0 g/L提高到5.0 g/L,而且共培养的细胞数量与2.0 g/L Cu2+条件下生长的At.ferrooxidans纯培养相似。另外,共培养中的At.ferrooxidans对Mg2+的MTC也由12.0 g/L提高到17.0 g/L。生物浸出实验中嗜酸异养菌Aph.acidophilum促进了At.ferrooxidans对黄铁矿样品的浸出,浸出率较其纯培养提高了22.7%;但在含铁量较低的低品位黄铜矿浸出体系中共培养和At.ferrooxidans纯培养的浸出率均低于33%。在加入2.0 g/L Fe2+的低品位黄铜矿浸出体系中,共培养和At.ferrooxidans纯培养的浸出率均得到提高,分别达到52.22%和41.27%。【结论】以上结果表明,Aph.acidophilum与At.ferrooxidans共培养在一定的环境胁迫下仍能保持其稳定性并完成各自的生态功能,并且嗜酸异养菌Aph.acidophilum适合在含铁量较高的浸出体系中与铁氧化细菌共同作用来提高生物浸出的效率。     

Biological oxidation of metallic copper by Acidithiobacillus ferrooxidans

This is a report on the kinetic aspects and the analytical study of the bioproducts of the oxidation of zero-valence copper by immobilized Acidithiobacillus ferrooxidans. Two different mechanisms of oxidation were considered: direct and indirect. A custom-built bioreactor was used to grow A. ferrooxidans in an iron-free media, which was required for the study of the direct mechanism. X-ray microdiffraction analysis of the copper after biooxidation in the sulfate-free medium revealed the presence of the copper sulfate, piypite, K(2)Cu(2)O(SO(4))(2), which indicates biooxidation of Cu metal has occurred. It was shown that the direct oxidation exists, but it is relatively slow, as compared to the indirect mechanism.     

Toxicity evaluation of complex metal mixtures using reduced metal concentrations: application to iron oxidation by Acidithiobacillus ferrooxidans

In this study, we investigated the inhibition effects of single and mixed heavy metal ions (Zn2+, Ni2+, Cu2+, and Cd2+) on iron oxidation by Acidithiobacillus ferrooxidans. Effects of metals on the iron oxidation activity of A. ferrooxidans are categorized into four types of patterns according to its oxidation behavior. The results indicated that the inhibition effects of the metals on the iron oxidation activity were noncompetitive inhibitions. We proposed a reduced inhibition model, along with the reduced inhibition constant (alphai), which was derived from the inhibition constant (KI) of individual metals and represented the tolerance of a given inhibitor relative to that of a reference inhibitor. This model was used to evaluate the toxicity effect (inhibition effect) of metals on the iron oxidation activity of A. ferrooxidans. The model revealed that the iron oxidation behavior of the metals, regardless of metal systems (single, binary, ternary, or quaternary), is closely matched to that of any reference inhibitor at the same reduced inhibition concentration, [I]reduced, which defines the ratio of the inhibitor concentration to the reduced inhibition constant. The model demonstrated that single metal systems and mixed metal systems with the same reduced inhibitor concentrations have similar toxic effects on microbial activity.     

Mechanism of Bacterial Pyrite Oxidation

The oxidation by Ferrobacillus ferrooxidans of untreated pyrite (FeS(2)) as well as HCl-pretreated pyrite (from which most of the acid-soluble iron species were removed) was studied manometrically. Oxygen uptake was linear during bacterial oxidation of untreated pyrite, whereas with HCl-pretreated pyrite both a decrease in oxygen uptake at 2 hr and nonlinear oxygen consumption were observed. Ferric sulfate added to HCl-pretreated pyrite restored approximately two-thirds of the decrease in total bacterial oxygen uptake and caused oxygen uptake to revert to nearly linear kinetics. Ferric sulfate also oxidized pyrite in the absence of bacteria and O(2); recovery of ferric and ferrous ions was in excellent agreement with the reaction Fe(2)(SO(4))(3) + FeS(2) = 3FeSO(4) + 2S, but the elemental sulfur produced was negligible. Neither H(2)S nor S(2)O(3) (2-) was a product of the reaction. It is probable that two mechanisms of bacterial pyrite oxidation operate concurrently: the direct contact mechanism which requires physical contact between bacteria and pyrite particles for biological pyrite oxidation, and the indirect contact mechanism according to which the bacteria oxidize ferrous ions to the ferric state, thereby regenerating the ferric ions required for chemical oxidation of pyrite.     

Tolerance ofThiobacillus ferrooxidans to some metals

During iron oxidation,Thiobacillus ferrooxidans (Ferrobacillus ferrooxidans) was able to tolerate high concentrations of Zn, Ni, Cu, Co, Mn and Al (more than 10 g/litre). Silver and anions of tellurium, arsenic and selenium were toxic in concentrations of 50–100 mg/litre. Molybdenum (as molybdate), at concentrations above 5 mg/litre, was lethal toT. ferrooxidans. During thiosulphate oxidation, the tolerance to Zn, Ni and Co was greatly reduced, cobalt now being at least 2000 times more toxic, and the inhibitory levels of Zn and Ni being 600 mg Zn/litre and 150 mg Ni/litre. During sulphur oxidation, the tolerance to heavy metals extended to concentrations above 5 g/litre. Adaptation to Zn, Ni or Cu during iron oxidation was found to result in increased tolerance to some of the other metals also.     

Isolation and characterization of an acidophilic, heterotrophic bacterium capable of oxidizing ferrous iron.

A heterotrophic bacterium, isolated from an acidic stream in a disused pyrite mine which contained copious growths of "acid streamers," displayed characteristics which differentiated it from previously described mesophilic acidophiles. The isolate was obligately acidophilic, with a pH range of 2.0 to 4.4 and an optimum pH of 3.0. The bacterium was unable to fix carbon dioxide but oxidized ferrous iron, although at a slower rate than either Thiobacillus ferrooxidans or Leptospirillum ferrooxidans. Elemental sulfur and manganese(II) were not oxidized. In liquid media, the isolate produced macroscopic streamerlike growths. Microscopic examination revealed that the bacterium formed long (greater than 100 microns) filaments which tended to disintegrate during later growth stages, producing single, motile cells and small filaments. The isolate did not appear to utilize the energy from ferrous iron oxidation. Both iron (ferrous or ferric) and an organic substrate were necessary to promote growth. The isolate displayed a lower tolerance to heavy metals than other iron-oxidizing acidophiles, and growth was inhibited by exposure to light. There was evidence of extracellular sheath production by the isolate. In this and some other respects, the isolate resembles members of the Sphaerotilus-Leptothrix group of filamentous bacteria. The guanine-plus-cytosine content of the isolate was 62 mol%, which is less than that recorded for Sphaerotilus-Leptothrix spp. and greater than those of L. ferrooxidans and most T. ferrooxidans isolates.     

Isolation and characterization of an acidophilic, heterotrophic bacterium capable of oxidizing ferrous iron.

A heterotrophic bacterium, isolated from an acidic stream in a disused pyrite mine which contained copious growths of "acid streamers," displayed characteristics which differentiated it from previously described mesophilic acidophiles. The isolate was obligately acidophilic, with a pH range of 2.0 to 4.4 and an optimum pH of 3.0. The bacterium was unable to fix carbon dioxide but oxidized ferrous iron, although at a slower rate than either Thiobacillus ferrooxidans or Leptospirillum ferrooxidans. Elemental sulfur and manganese(II) were not oxidized. In liquid media, the isolate produced macroscopic streamerlike growths. Microscopic examination revealed that the bacterium formed long (greater than 100 microns) filaments which tended to disintegrate during later growth stages, producing single, motile cells and small filaments. The isolate did not appear to utilize the energy from ferrous iron oxidation. Both iron (ferrous or ferric) and an organic substrate were necessary to promote growth. The isolate displayed a lower tolerance to heavy metals than other iron-oxidizing acidophiles, and growth was inhibited by exposure to light. There was evidence of extracellular sheath production by the isolate. In this and some other respects, the isolate resembles members of the Sphaerotilus-Leptothrix group of filamentous bacteria. The guanine-plus-cytosine content of the isolate was 62 mol%, which is less than that recorded for Sphaerotilus-Leptothrix spp. and greater than those of L. ferrooxidans and most T. ferrooxidans isolates.     

铜蓝精矿的生物浸出

采用两种嗜酸硫杆菌(嗜酸氧化亚铁硫杆菌和喜温硫杆菌)对铜蓝进行生物浸出,实验在有或没有4 g/L硫酸亚铁pH 2．0、150转/分、35℃的三角瓶中进行。实验结果表明:用两种菌混合浸出的铜几乎等于嗜酸氧化亚铁硫杆菌单独浸出的铜;另外,亚铁的加入能提高铜的浸出。     

Mineral and iron oxidation at low temperatures by pure and mixed cultures of acidophilic microorganisms

An enrichment culture from a boreal sulfide mine environment containing a low-grade polymetallic ore was tested in column bioreactors for simulation of low temperature heap leaching. PCR-denaturing gradient gel electrophoresis and 16S rRNA gene sequencing revealed the enrichment culture contained an Acidithiobacillus ferrooxidans strain with high 16S rRNA gene similarity to the psychrotolerant strain SS3 and a mesophilic Leptospirillum ferrooxidans strain. As the mixed culture contained a strain that was within a clade with SS3, we used the SS3 pure culture to compare leaching rates with the At. ferrooxidans type strain in stirred tank reactors for mineral sulfide dissolution at various temperatures. The psychrotolerant strain SS3 catalyzed pyrite, pyrite/arsenopyrite, and chalcopyrite concentrate leaching. The rates were lower at 5 degrees C than at 30 degrees C, despite that all the available iron was in the oxidized form in the presence of At. ferrooxidans SS3. This suggests that although efficient At. ferrooxidans SS3 mediated biological oxidation of ferrous iron occurred, chemical oxidation of the sulfide minerals by ferric iron was rate limiting. In the column reactors, the leaching rates were much less affected by low temperatures than in the stirred tank reactors. A factor for the relatively high rates of mineral oxidation at 7 degrees C is that ferric iron remained in the soluble phase whereas, at 21 degrees C the ferric iron precipitated. Temperature gradient analysis of ferrous iron oxidation by this enrichment culture demonstrated two temperature optima for ferrous iron oxidation and that the mixed culture was capable of ferrous iron oxidation at 5 degrees C.     

Strain polymorphism of the plasmid profiles in Acidithiobacillus ferrooxidans

Plasmid profiles were studied in 27 Acidithiobacillus ferrooxidans strains isolated from different geographic zones and substrates differing in the composition of the main sulfide minerals, and also in experimentally obtained strains with acquired enhanced resistance to the ions of heavy metals (Fe, Ni, Cu, Zn, As). In 16 out of 20 strains isolated from different substrates, one to four 2- to 20-kb and larger plasmids were revealed. Plasmids were found in all five strains isolated from gold-containing pyrite-arsenopyrite ores and concentrates, in nine of 11 strains isolated from the ores and concentrates containing nonferrous metals, and in two of four strains isolated from the oxidation substrates of simple composition (mine waters, pyritized coals, active sludge). Changes in the plasmid profiles in some A. ferrooxidans strains (TFZ, TFI-Fe, TFV-1-Cu) with experimentally enhanced resistance to Zn2+, Fe3+, and Cu2+, respectively, were noted as compared with the initial strains. After 30 passages on S0-containing medium, strain TFBk showed changes in the copy number of plasmids. The role of plasmids in the processes of oxidation of energy substrates and in the acquired enhanced resistance to the heavy metal ions is discussed.     

Bio-oxidation of iron using Thiobacillus ferrooxidans

The effects of pH, ferrous and ferric ion concentrations on iron oxidation by Thiobacillus ferrooxidans were examined. The initial temperature and bacterial concentration were maintained at 37°C and 2±1×104cells/ml, respectively. The iron oxidation rate increased with increased initial ferrous iron concentration to 4g/l and thereafter decreased. The presence of iron(III) showed a negative effect on the bacterial iron oxidation rate. The increase of pH also showed an increase in the oxidation rate up to pH 1.75. The oxidation rate followed first order kinetics for the parameters studied. A rate equation has been developed.     

Bio-oxidation of iron using Thiobacillus ferrooxidans

The effects of pH, ferrous and ferric ion concentrations on iron oxidation by Thiobacillus ferrooxidans were examined. The initial temperature and bacterial concentration were maintained at 37°C and 2±1×104cells/ml, respectively. The iron oxidation rate increased with increased initial ferrous iron concentration to 4g/l and thereafter decreased. The presence of iron(III) showed a negative effect on the bacterial iron oxidation rate. The increase of pH also showed an increase in the oxidation rate up to pH 1.75. The oxidation rate followed first order kinetics for the parameters studied. A rate equation has been developed.     

Microbiological Leaching of Metallic Sulfides

The percentage of chalcopyrite leached in percolators by Thiobacillus ferrooxidans was dependent on the surface area of the ore but not on the amount. Typical examples of ore leaching, which demonstrate the role of the bacteria, are presented. In stationary fermentations, changes in KH(2)PO(4) concentration above or below 0.1% decreased copper leaching as did reduction in the MgSO(4).7H(2)O and increase in the (NH(4))(2)SO(4) concentration. Bacterial leaching of chalcopyrite was more effective than nonbiological leaching with ferric sulfate; ferric sulfate appeared to retard biological leaching, but this effect was likely caused by formation of an insoluble copper-iron complex. Ferrous sulfate and sodium chloride singly accentuated both bacterial and nonbiological leaching of chalcocite but jointly depressed bacterial action. Sodium chloride appeared to block bacterial iron oxidation without interfering with sulfide oxidation. Bacterial leaching of millerite, bornite, and chalcocite was greatest at pH 2.5. The economics of leaching a number of British Columbia ore bodies was discussed.     

Selective inhibition of the oxidation of ferrous iron or sulfur in Thiobacillus ferrooxidans

The oxidation of either ferrous iron or sulfur by Thiobacillus ferrooxidans was selectively inhibited or controlled by various anions, inhibitors, and osmotic pressure. Iron oxidation was more sensitive than sulfur oxidation to inhibition by chloride, phosphate, and nitrate at low concentrations (below 0.1 M) and also to inhibition by azide and cyanide. Sulfur oxidation was more sensitive than iron oxidation to the inhibitory effect of high osmotic pressure. These differences were evident not only between iron oxidation by iron-grown cells and sulfur oxidation by sulfur-grown cells but also between the iron and sulfur oxidation activities of the same iron-grown cells. Growth experiments with ferrous iron or sulfur as an oxidizable substrate confirmed the higher sensitivity of iron oxidation to inhibition by phosphate, chloride, azide, and cyanide. Sulfur oxidation was actually stimulated by 50 mM phosphate or chloride. Leaching of Fe and Zn from pyrite (FeS(2)) and sphalerite (ZnS) by T. ferrooxidans was differentially affected by phosphate and chloride, which inhibited the solubilization of Fe without significantly affecting the solubilization of Zn.     

Bacterial populations in samples of bioleached copper ore as revealed by analysis of DNA obtained before and after cultivation.

The composition of bacterial populations in copper bioleaching systems was investigated by analysis of DNA obtained either directly from ores or leaching solutions or after laboratory cultures. This analysis consisted of the characterization of the spacer regions between the 16 and 23S genes in the bacterial rRNA genetic loci after PCR amplification. The sizes of the spacer regions, amplified from DNAs obtained from samples, were compared with the sizes of those obtained from cultures of the main bacterial species isolated from bioleaching systems. This allowed a preliminary assessment of the bacterial species present in the samples. Identification of the bacteria was achieved by partial sequencing of the 16S rRNA genes adjacent to the spacer regions. The spacer regions observed in DNA from columns leached at different iron concentrations indicated the presence of a mixture of different bacteria. The spacer region corresponding to Thiobacillus ferrooxidans was the main product observed at high ferrous iron concentration. At low ferrous iron concentration, spacer regions of different lengths, corresponding to Thiobacillus thiooxidans and "Leptospirillum ferrooxidans" were observed. However, T. ferrooxidans appeared to predominate after culture of these samples in medium containing ferrous iron as energy source. Although some of these strains contained singular spacer regions, they belonged within previously described groups of T. ferrooxidans according to the nucleotide sequence of the neighbor 16S rRNA. These results illustrate the bacterial diversity in bioleaching systems and the selective pressure generated by different growth conditions.     

Development of an automated water toxicity biosensor using Thiobacillus ferrooxidans for monitoring cyanides in natural water for a water filtering plant

An on-line biosensor consisting of immobilized Thiobacillus ferrooxidans and an oxygen electrode was developed for automated monitoring of acute toxicity in water samples. T. ferrooxidans is an obligatory acidophilic, autotrophic bacterium and derives its energy by the oxidation of ferrous ion, elemental sulfur, and reduced sulfur compounds including metal sulfides. The assay is based on the monitoring of a current increase by addition of toxicoids, which is caused by the inhibition of bacterial respiration and decrease in oxygen consumption. Optimum cell number on the membrane was 5.0 x 10(8) cells. The steady-state current was obtained when concentration of FeSO4 was above 3.6 mM at pH 3. The sensor response of T. ferrooxidans immobilized membrane for 5.0 microM KCN was within an error of 10% for 30 membranes. A linear relationship was obtained at KCN concentration in the range of 0.5-3.0 microM in a flow-type monitoring system. Minimum detectable concentrations of KCN, Na2S, and NaN3 were 0.5, 1.2, and 0.07 microM, respectively. The monitoring system contained two biosensors and these sensors were cleaned with sulfuric acid (pH 1.5) twice a day. This treatment could remove fouling on microbial immobilized membrane by natural water and ferrous precipitation in the flow cell. This flow-type monitoring sensor was operated continuously for 5 months. Also, T. ferrooxidans immobilized membrane can be stored for one month at 4 degrees C when preserved with wet absorbent cotton under argon gas.     

Molecular genetics of Thiobacillus ferrooxidans.

Thiobacillus ferrooxidans is a gram-negative, highly acidophilic (pH 1.5 to 2.0), autotrophic bacterium that obtains its energy through the oxidation of ferrous iron or reduced inorganic sulfur compounds. It is usually dominant in the mixed bacterial populations that are used industrially for the extraction of metals such as copper and uranium from their ores. More recently, these bacterial consortia have been used for the biooxidation of refractory gold-bearing arsenopyrite ores prior to the recovery of gold by cyanidation. The commercial use of T. ferrooxidans has led to an increasing interest in the genetics and molecular biology of the bacterium. Initial investigations were aimed at determining whether the unique physiology and specialized habitat of T. ferrooxidans had been accompanied by a high degree of genetic drift from other gram-negative bacteria. Early genetic studies were comparative in nature and concerned the isolation of genes such as nifHDK, glnA, and recA, which are widespread among bacteria. From a molecular biology viewpoint, T. ferrooxidans appears to be a typical member of the proteobacteria. In most instances, cloned gene promoters and protein products have been functional in Escherichia coli. Although T. ferrooxidans has proved difficult to transform with DNA, research on indigenous plasmids and the isolation of the T. ferrooxidans merA gene have resulted in the development of a low-efficiency electroporation system for one strain of T. ferrooxidans. The most recent studies have focused on the molecular genetics of the pathways associated with nitrogen metabolism, carbon dioxide fixation, and components of the energy-producing mechanisms.     

Sulfite oxidation catalyzed by aa(3)-type cytochrome c oxidase in Acidithiobacillus ferrooxidans

Sulfite is produced as a toxic intermediate during Acidithiobacillus ferrooxidans sulfur oxidation. A. ferrooxidans D3-2, which posseses the highest copper bioleaching activity, is more resistant to sulfite than other A. ferrooxidans strains, including ATCC 23270. When sulfite oxidase was purified homogeneously from strain D3-2, the oxidized and reduced forms of the purified sulfite oxidase absorption spectra corresponded to those of A. ferrooxidans aa(3)-type cytochrome c oxidase. The confirmed molecular weights of the α-subunit (52.5 kDa), the β-subunit (25 kDa), and the γ-subunit (20 kDa) of the purified sulfite oxidase and the N-terminal amino acid sequences of the γ-subunit of sulfite oxidase (AAKKG) corresponded to those of A. ferrooxidans ATCC 23270 cytochrome c oxidase. The sulfite oxidase activities of the iron- and sulfur-grown A. ferrooxidans D3-2 were much higher than those cytochrome c oxidases purified from A. ferrooxidans strains ATCC 23270, MON-1 and AP19-3. The activities of sulfite oxidase purified from iron- and sulfur-grown strain D3-2 were completely inhibited by an antibody raised against a purified A. ferrooxidans MON-1 aa(3)-type cytochrome c oxidase. This is the first report to indicate that aa(3)-type cytochrome c oxidase catalyzed sulfite oxidation in A. ferrooxidans.     

Plasmid profiles of Acidithiobacillus ferrooxidans strains adapted to different oxidation substrates

Plasmid profiles were studied in five Acidithiobacillus ferrooxidans strains of various origin cultivated on medium with Fe2+, as well as adapted to such oxidation substrates as S0, FeS2, and sulfide concentrate. The method used revealed plasmids in all A. ferrooxidans strains grown on medium with Fe2+. One plasmid was found in strain TFL-2, two plasmids, in strains TFO, TFBk, and TFV-1, and three plasmids were detected in strain TFN-d. The adaptation of strain TFN-d to sulfide concentrate and the adaptation of strain TFV-1 to S0, FeS2, or sulfide concentrate resulted in a change in the number of plasmids occurring in cells. In cells of strain TFN-d adapted to sulfide concentrate, the number of plasmids decreased from three to two. The number of plasmids in cells of strain TFV-1 adapted to different substrates varied from three to six depending on the energy source present in the medium: three plasmids were found after growth on FeS2, four after growth on S0, and six after growth on sulfide concentrate. The possible role of plasmids in the adaptation of A. ferrooxidans to new energy substrates and in the regulation of the intensity of their oxidation is discussed.