Engineering <Emphasis Type="Italic">Yarrowia lipolytica</Emphasis> for poly-3-hydroxybutyrate production

Strains of Yarrowia lipolytica were engineered to express the poly-3-hydroxybutyrate (PHB) biosynthetic pathway. The genes for β-ketothiolase, NADPH-dependent acetoacetyl-CoA reductase, and PHB synthase were cloned and inserted into the chromosome of Y. lipolytica. In shake flasks, the engineered strain accumulated PHB to 1.50 and 3.84% of cell dry weight in complex medium supplemented with glucose and acetate as carbon source, respectively. In fed-batch fermentation using acetate as sole carbon source, 7.35 g/l PHB (10.2% of cell dry weight) was produced. Selection of Y. lipolytica as host for PHB synthesis was motivated by the fact that this organism is a good lipids producer, which suggests robust acetyl-CoA supply also the precursor of the PHB pathway. Acetic acid could be supplied by gas fermentation, anaerobic digestion, and other low-cost supply route.     

Dynamics of Activity of the Key Enzymes of Polyhydroxyalkanoate Metabolism in Ralstonia eutropha B5786

The dynamics of accumulation of polyhydroxybutyrate (PHB) and the activities of key enzymes of PHB metabolism (-ketothiolase, acetoacetyl-CoA reductase, PHB synthase, D-hydroxybutyrate dehydrogenase, and PHB depolymerase) in the hydrogen bacterium Ralstonia eutropha B5786 were studied under various conditions of carbon nutrition and substrate availability. The highest activities of -ketothiolase, acetoacetyl-CoA reductase, and PHB synthase were recorded during acceleration of PHB synthesis. The activities of enzymes catalyzing PHB depolymerization (PHB depolymerase and D-hydroxybutyrate dehydrogenase) were low, being expressed only upon stimulated endogenous PHB degradation. The change of carbon source (CO₂ or fructose) did not affect the time course of the enzyme activity significantly.     

Poly(β-hydroxybutyrate) production in oilseed leukoplasts of Brassica napus

Polyhydroxyalkanoates (PHAs) comprise a class of biodegradable polymers which offer an environmentally sustainable alternative to petroleum-based plastics. Production of PHAs in plants is attractive since current fermentation technology is prohibitively expensive. The PHA homopolymer poly(β-hydroxybutyrate) (PHB) has previously been produced in leaves of Arabidopsis thaliana (Nawrath et al., 1994, Proc Natl Acad Sci USA 91: 12760–12764). However, Brassica napus oilseed may provide a better system for PHB production because acetyl-CoA, the substrate required in the first step of PHB biosynthesis, is prevalent during fatty acid biosynthesis. Three enzymatic activities are needed to synthesize PHB: a β-ketothiolase, an acetoacetyl-CoA reductase and a PHB synthase. Genes from the bacterium Ralstonia eutropha encoding these enzymes were independently engineered behind the seed-specific Lesquerella fendleri oleate 12-hydroxylase promoter in a modular fashion. The gene cassettes were sequentially transferred into a single, multi-gene vector which was used to transform B. napus. Poly(β-hydroxybutyrate) accumulated in leukoplasts to levels as high as 7.7% fresh seed weight of mature seeds. Electron-microscopy analyses indicated that leukoplasts from these plants were distorted, yet intact, and appeared to expand in response to polymer accumulation. Received: 26 May 1999 / Accepted: 16 June 1999     

Poly-β-hydroxybutyrate metabolism in Azospirillum brasilense and the ecological role of PHB in the rhizosphere

Abstract Azospirillum brasilense is a rhizosphere microorganism which has potential use for promoting plant growth in economically important crops. Its ability to survive the adverse conditions imposed by nutrient starvation and competition in the rhizosphere is of great importance. A. brasilense accumulates up to 70% of its cell dry weight with poly-β-hydroxybutyrate (PHB). In the presence of stress factors such as ultraviolet radiation, desiccation and osmotic stress, PHB-rich cells survived better than PHB-poor cells. Polymer-rich cells of Azospirillum fixed N₂ in the absence of exogenous carbon and combined nitrogen. The enzymes of the PHB cycle in both the synthesis and degradation processes as well as during starvation were more active in PHB-rich cells. After 24 h of starvation there was a peak of activity of d (−)β-hydroxybutyrate dehydrogenase, β-ketothiolase and thiophorase due to PHB degradation. Additionally, acetoacetyl-CoA reductase dropped to a minimum level because PHB could not be synthesized. The possible utilization of PHB as a sole carbon and energy source by A. brasilense and other bacteria during establishment, proliferation and survival in the rhizosphere will be discussed.     

Poly-β-hydroxybutyrate (PHB) biosynthesis,tricarboxylic acid activity and PHB content in chickpea (<Emphasis Type="Italic">Cicer arietinum</Emphasis> L.) root nodule

An experiment was conducted to assess the relationship between poly-β-hydroxybutyrate (PHB) biosynthesis and tricarboxylic acid (TCA) activity in desi and kabuli chickpea (Cicer arietinum L.) genotypes. The specific activities of enzymes of PHB metabolism viz., β-ketothiolase (PHB-A), acetoacetyl coenzyme A reductase (PHB-B) and PHB synthase (PHB-C), and those of tricarboxylic acid cycle (citrate synthase (CS) and malate dehydrogenase (MDH) under symbiosis were measured in bacteroids and compared with the PHB accumulation in the nodule and the root. The significant positive correlation was observed between shoot and nodule mass and PHB-A, PHB-B, and PHB-C activities. However, nodule and shoot weights were not significantly correlated with PHB content either in the roots or nodules. The same was true for PHB levels and citrate synthase activity. MDH activity showed a significant negative correlation with nodule PHB. A marked variation and an age dependant increase in malate dehydrogenase activity were measured. A higher capacity for malate oxidation by an increased MDH is likely alter the balance between malate decarboxylation and oxidation, resulting in a higher steady-state concentration of oxaloacetate and that may favor the utilization of acetyl-CoA in the TCA cycle rather than for the synthesis of PHB.     

Metabolic and kinetic analysis of poly(3-hydroxybutyrate) production by recombinant Escherichia coli

A quantitatively repeatable protocol was developed for poly(3-hydroxybutyrate) (PHB) production by Escherichia coli XL1-Blue (pSYL107). Two constant-glucose fed-batch fermentations of duration 25 h were carried out in a 5-L bioreactor, with the measured oxygen volumetric mass-transfer coefficient (k(L)a) held constant at 1.1 min(-1). All major consumption and production rates were quantified. The intracellular concentration profiles of acetyl-CoA (300 to 600 microg x g RCM(-1)) and 3-hydroxybutyryl-CoA (20 to 40 microg x g RCM(-1)) were measured, which is the first time this has been performed for E. coli during PHB production. The kinetics of PHB production were examined and likely ranges were established for polyhydroxyalkanoate (PHA) enzyme activity and the concentration of pathway metabolites. These measured and estimated values are quite similar to the available literature estimates for the native PHB producer Ralstonia eutropha. Metabolic control analysis performed on the PHB metabolic pathway showed that the PHB flux was highly sensitive to acetyl-CoA/CoA ratio (response coefficient 0.8), total acetyl-CoA + CoA concentration (response coefficient 0.7), and pH (response coefficient -1.25). It was less sensitive (response coefficient 0.25) to NADPH/NADP ratio. NADP(H) concentration (NADPH + NADP) had a negligible effect. No single enzyme had a dominant flux control coefficient under the experimental conditions examined (0.6, 0.25, and 0.15 for 3-ketoacyl-CoA reductase, PHA synthase, and 3-ketothiolase, respectively). In conjunction with metabolic flux analysis, kinetic analysis was used to provide a metabolic explanation for the observed fermentation profile. In particular, the rapid onset of PHB production was shown to be caused by oxygen limitation, which initiated a cascade of secondary metabolic events, including cessation of TCA cycle flux and an increase in acetyl-CoA/CoA ratio.     

Non-conventional yeasts as producers of polyhydroxyalkanoates—genetic engineering of<Emphasis Type="Italic"> Arxula adeninivorans</Emphasis>

The non-conventional yeast Arxula adeninivorans was equipped with the genes phbA, phbB and phbC of the polyhydroxyalkanoate (PHA) biosynthetic pathway of Ralstonia eutropha, which encode -ketothiolase, NADPH-linked acetoacetyl-CoA reductase and PHA synthase, respectively. Arxula strains transformed solely with the PHA synthase gene (phbC) were able to produce PHA. However, the maximum content of the polymer detected in these strains was just 0.003% poly-3-hydroxybutyrate (PHB) and 0.112% poly-3-hydroxyvalerate (PHV). The expression of all three genes (phbA, phbB, phbC) resulted in small increases in the PHA content of the transgenic Arxula cells. However, under controlled cultivation conditions with minimal medium and ethanol as the carbon source, the recombinant yeast was able to accumulate up to 2.2% PHV and 0.019% PHB. Possible reasons for these differences are discussed.     

Competition between β-ketothiolase and citrate synthase during poly(β-hydroxybutyrate) synthesis inMethylobacterium rhodesianum

The enzymes -ketothiolase and citrate synthase from the facultatively methylotrophicMethylobacterium rhodesianum MB 126, which uses the serine pathway, were purified and characterized. The -ketothiolase had a relatively highK _m for acetyl-CoA (0.5 mM) and was strongly inhibited by CoA (K _i 0.02 mM). The citrate synthase had a much higher affinity for acetyl-CoA (K _m 0.07 mM) and was significantly inhibited by NADH (K _i 0.15 mM). The intracellular concentration of CoA metabolites and nucleotides was determined inM. rhodesianum MB 126 during growth on methanol. The level of CoA decreased from about 0.6 nmol (mg dry mass)^-1 during growth to the detection limit when poly(-hydroxybutyrate) (PHB) accumulated. Nearly unchanged intracellular concentrations of NADH, NADPH, and acetyl-CoA of about 0.5, 0.6–0.7, and 1.0 nmol (mg dry mass)^-1, respectively, were determined during growth and PHB synthesis. During growth, the -ketothiolase was almost completely inhibited by CoA, and acetyl-CoA was principally consumed by the citrate synthase. During PHB accumulation, the -ketothiolase had about 75% of its maximum activity and showed much higher activity than citrate synthase, which at the actual NADH concentration was about 75% inhibited. NADPH concentration was sufficiently high to allow the unlimited activity of acetoacetyl-CoA reductase (K _mNADPH 18 M). PHB synthesis is probably mainly controlled by the CoA concentration inM. rhodesianum MB 126.Abbreviation PHB Poly(-hydroxybutyrate)     

Poly-β-Hydroxybutyrate Metabolism Is Affected by Changes in Respiratory Enzymatic Activities Due to Cold Stress in Two Psychrotrophic Strains of Rhizobium

Cold stress resulted in a decrease in the poly-β-hydroxybutyrate (PHB) content of non-cold-acclimated Rhizobium DDSS69 cultures. Analysis of the specific activity of β-ketothiolase and β-hydroxybutyrate dehydrogenase revealed that decrease in PHB levels was a result of the inhibition of synthesis of PHB rather than an increase in its breakdown. Rhizobium ATR1, a cold-acclimated strain, revealed the presence of a stable PHB metabolism that did not show any significant differences either in PHB levels or in the activity of enzymes of the PHB metabolism under cold stress, suggesting that PHB is not involved in cold tolerance. Analysis of specific activities of glucose-6-phosphate dehydrogenase and 6-phosphogluconate dehydrogenase of the pentose phosphate pathway showed the upward regulation of alternate pathways of carbohydrate metabolism under cold stress to rapidly generate energy to overcome the stress. There is diversity in the switching mechanisms of carbon metabolism among cold-acclimated and non-cold-acclimated Rhizobium isolates. Upward regulation of malate dehydrogenase in both isolates suggests that it is a critical input for cold tolerance. Received: 26 June 2000 / Accepted: 31 July 2000     

Effects of indole-3-acetic acid on <Emphasis Type="Italic">Sinorhizobium meliloti</Emphasis> survival and on symbiotic nitrogen fixation and stem dry weight production

We evaluated the effects of the main auxin phytohormone, indole-3-acetic acid (IAA), on the central metabolism of Sinorhizobium meliloti 1021. We either treated S. meliloti 1021 wild-type cells with 0.5 mM IAA, 1021+, or use a derivative, RD64, of the same strain harboring an additional pathway for IAA biosynthesis (converting tryptophan into IAA via indoleacetamide). We assayed the activity of tricarboxylic acid cycle (TCA) key enzymes and found that activity of citrate synthase and α-ketoglutarate dehydrogenase were increased in both 1021+ and RD64 as compared to the wild-type strain. We also showed that the intracellular acetyl-CoA content was enhanced in both RD64 and 1021+ strains when compared to the control strain. The activity of key enzymes, utilizing acetyl-CoA for poly-β-hydroxybutyrate (PHB) biosynthesis, was also induced. The PHB level measured in these cells were significantly higher than that found in control cells. Moreover, 4-week-long survival experiments showed that 80% of 1021 cells died, whereas 50% of RD64 cells were viable. Medicago truncatula plants nodulated by RD64 (Mt-RD64) showed an induction of both acetylene reduction activity and stem dry weight production.     

Regulatory effects of cellular nicotinamide nucleotides and enzyme activities on poly(3-hydroxybutyrate) synthesis in recombinant Escherichia coli

Regulatory roles of nicotinamide nucleotides and three key enzymes, beta-ketothiolase (KT), NADPH-dependent acetoacetyl-CoA reductase (AAR), and citrate synthase (CS), on poly(3-hydroxybutyrate) (PHB) synthesis in recombinant Escherichia coli harboring a plasmid containing the Alcaligenes eutrophus polyhydroxyalkanoate (PHA) biosynthesis genes were examined. Cells were grown in various media and were subsequently compared for PHB concentration, PHB content, the activities of the key enzymes, and the levels of nicotinamide nucleotides. Cells of recombinant E. coli accumulated the largest amount of PHB in LB+glucose medium among those tested. PHB synthesis was not enhanced by limiting inorganic ions. The activity of CS, which competes with KT for acetyl-CoA, was lower when cells were grown in LB+glucose compared with other media. The NADPH level and the NADPH/NADP ratio were high in LB+glucose. Examination of the time profiles of the specific PHB synthesis rate, key enzyme activities, and the levels of nicotinamide nucleotides showed that PHB synthesis is most significantly affected by the NADPH level. Even though the NADH level and the NADH/NAD ratio were also high during the synthesis of PHB, no direct evidence of their positive effect on PHB synthesis was found. Low activity of CS was beneficial for PHB synthesis due to the availability of more acetyl-CoA to PHB biosynthetic pathway. In recombinant E. coli, the level of NADPH and/or the NADPH/NADP ratio seem to be the most critical factor regulating the activity of AAR and, subsequently, PHB synthesis. (c) 1996 John Wiley & Sons, Inc.     

Metabolic engineering of Alcaligenes eutrophus through the transformation of cloned phbCAB genes for the investigation of the regulatory mechanism of polyhydroxyalkanoate biosynthesis

The regulatory mechanisms of the biosynthesis of in vivo poly-beta-hydroxybutyrate [PHB] and poly(3-hydroxybutyrate-3-hydroxyvalerate) [P(3HB-3HV)] of Alcaligenes eutrophus were investigated by using various transformants with enzyme activities that were modified through the transformation of cloned phbCAB genes. The biosynthesis rates of PHB and P(3HB-3HV) were controlled by beta-ketothiolase and acetoacetyl-CoA reductase, and especially by beta-ketothiolase condensing acetyl-CoA or propionyl-CoA. The contents of PHB and P(3HB-3HV) were controlled by PHB synthase, polymerizing 3-hydroxybutyrate to PHB or 3-hydroxybutyrate and 3-hydroxyvalerate to P(3HB-3HV). The molar fraction of 3-hydroxyvalerate in P(3HB-3HV) was also closely connected with PHB synthase. This may be due to the accelerated polymerization between 3-HB from glycolysis pathway and 3-HV converted from propionate supplied as precursor. Enforced beta-ketothiolase and acetoacetyl-CoA reductase to PHB synthase tended to enlarge the size of the PHB and P(3HB-3HV) granules, however, higher activity ratio of PHB synthase to beta-ketothiolase and acetoacetyl-CoA reductase than parent strain tended to induce the number of granules.     

Isolated poly(3-hydroxybutyrate) (PHB) granules are complex bacterial organelles catalyzing formation of PHB from acetyl coenzyme A (CoA) and degradation of PHB to acetyl-CoA

Poly(3-hydroxybutyrate) (PHB) granules isolated in native form (nPHB granules) from Ralstonia eutropha catalyzed formation of PHB from ¹⁴C-labeled acetyl coenzyme A (CoA) in the presence of NADPH and concomitantly released CoA, revealing that PHB biosynthetic proteins (acetoacetyl-CoA thiolase, acetoacetyl-CoA reductase, and PHB synthase) are present and active in isolated nPHB granules in vitro. nPHB granules also catalyzed thiolytic cleavage of PHB in the presence of added CoA, resulting in synthesis of 3-hydroxybutyryl-CoA (3HB-CoA) from PHB. Synthesis of 3HB-CoA was also shown by incubation of artificial (protein-free) PHB with CoA and PhaZa1, confirming that PhaZa1 is a PHB depolymerase catalyzing the thiolysis reaction. Acetyl-CoA was the major product detectable after incubation of nPHB granules in the presence of NAD⁺, indicating that downstream mobilizing enzyme activities were also present and active in isolated nPHB granules. We propose that intracellular concentrations of key metabolites (CoA, acetyl-CoA, 3HB-CoA, NAD⁺/NADH) determine whether a cell accumulates or degrades PHB. Since the degradation product of PHB is 3HB-CoA, the cells do not waste energy by synthesis and degradation of PHB. Thus, our results explain the frequent finding of simultaneous synthesis and breakdown of PHB.     

Multiple β-Ketothiolases Mediate Poly(β-Hydroxyalkanoate) Copolymer Synthesis in Ralstonia eutropha

Polyhydroxyalkanoates (PHAs) are a class of carbon and energy storage polymers produced by numerous bacteria in response to environmental limitation. The type of polymer produced depends on the carbon sources available, the flexibility of the organism’s intermediary metabolism, and the substrate specificity of the PHA biosynthetic enzymes. Ralstonia eutropha produces both the homopolymer poly-β-hydroxybutyrate (PHB) and, when provided with the appropriate substrate, the copolymer poly(β-hydroxybutyrate-co-β-hydroxyvalerate) (PHBV). A required step in production of the hydroxyvalerate moiety of PHBV is the condensation of acetyl coenzyme A (acetyl-CoA) and propionyl-CoA to form β-ketovaleryl-CoA. This activity has generally been attributed to the β-ketothiolase encoded by R. eutropha phbA. However, we have determined that PhbA does not significantly contribute to catalyzing this condensation reaction. Here we report the cloning and genetic analysis of bktB, which encodes a β-ketothiolase from R. eutropha that is capable of forming β-ketovaleryl-CoA. Genetic analyses determined that BktB is the primary condensation enzyme leading to production of β-hydroxyvalerate derived from propionyl-CoA. We also report an additional β-ketothiolase, designated BktC, that probably serves as a secondary route toward β-hydroxyvalerate production.Polyhydroxyalkanoates (PHAs) are a class of naturally occurring polymers which serve as a carbon and energy reserve in numerous bacterial species. Ralstonia eutropha (formerly designated Alcaligenes eutrophus [41]) produces the homopolymer poly(β-hydroxybutyrate) (PHB) and, when provided with propionate in the feedstock, the copolymer poly(β-hydroxybutyrate-co-β-hydroxyvalerate) (PHBV). R. eutropha is used commercially to produce PHBV, which is a biodegradable thermoplastic.The PHB biosynthetic pathway requires three enzymatic activities: a β-ketothiolase (PhbA), an NADPH-dependent acetoacetyl coenzyme A (acetoacetyl-CoA) reductase (PhbB) and a PHB synthase (PhbC). The first step in production of the homopolymer PHB is catalyzed by β-ketothiolase which condenses two acetyl-CoA molecules to form acetoacetyl-CoA. Formation of the copolymer PHBV requires the additional condensation of acetyl-CoA with propionyl-CoA to form β-ketovaleryl-CoA (Fig. ​(Fig.1).1). Subsequently, the acetoacetyl-CoA and β-ketovaleryl-CoA are converted into a polymer by the activities of the reductase and synthase. The genes encoding these proteins in R. eutropha reside in an operon which has been well characterized (10, 21, 22, 31, 37). Open in a separate windowFIG. 1Pathway for production of PHBV from acetyl-CoA and propionyl-CoA. β-Ketothiolase performs the condensation reactions to generate either acetoacetyl-CoA or β-ketovaleryl-CoA. These are reduced by acetoacetyl-CoA reductase (PhbB) and polymerized by PHB synthase (PhbC).The substrate specificities of these three enzymes are reportedly adequate for production of PHBV copolymer (7–9), but propionate-fed Escherichia coli harboring the R. eutropha phb operon produces essentially PHB homopolymer (35). Moreover, PHBV copolymer can be produced in E. coli after induction of the fatty acid β-oxidation complex, which contains a β-ketothiolase with broad substrate specificity (26, 27, 35). These data suggest that the R. eutropha PHB pathway is capable of producing copolymer, but only in the context of a second β-ketothiolase with broad substrate specificity.R. eutropha is known to produce at least two β-ketothiolases (7), and at least two distinct plasmid clones which express β-ketothiolase have been isolated from R. eutropha (37). In this work, we analyzed the substrate specificity of the PhbA β-ketothiolase and demonstrated that this enzyme catalyzes thiolysis of β-ketovaleryl-CoA very poorly. We determined that R. eutropha expresses at least two β-ketothiolases in addition to PhbA and that these additional enzymes, which we designate BktB and BktC, efficiently utilize β-ketovaleryl-CoA. We also report the isolation and characterization of bktB (β-ketothiolase B), which encodes the BktB β-ketothiolase required for efficient production of PHBV in R. eutropha.     

Growth of <Emphasis Type="Italic">Methylosinus trichosporium</Emphasis> OB3b on methane and poly-β-hydroxybutyrate biosynthesis

Optimal conditions for batch cultivation of the obligate methanotroph Methylosinus trichosporium OB3b on methane without superatmospheric pressure were chosen. The yield of absolutely dry biomass after 120 h of growth reached 20 g/l. This biomass contained 30% poly-β-hydroxybutyrate (PHB) with molecular weight 300 kDa. The growth process included the stages of biomass growth and PHB biosynthesis. The latter stage occurred under nitrogen-deficiency conditions. It was accompanied by an increase in the activity of PHB biosynthesis enzymes (β-ketothiolase, acetoacetyl-CoA reductase, and PHB synthase) and the main NAD(P)H producer, methylenetetrahydromethanopterin dehydrogenase. The activity of PHB depolymerase increased insignificantly.     

Engineered <Emphasis Type="Italic">Corynebacterium glutamicum</Emphasis> as an endotoxin-free platform strain for lactate-based polyester production

The first biosynthetic system for lactate (LA)-based polyesters was previously created in recombinant Escherichia coli (Taguchi et al. 2008). Here, we have begun efforts to upgrade the prototype polymer production system to a practical stage by using metabolically engineered Gram-positive bacterium Corynebacterium glutamicum as an endotoxin-free platform. We designed metabolic pathways in C. glutamicum to generate monomer substrates, lactyl-CoA (LA-CoA), and 3-hydroxybutyryl-CoA (3HB-CoA), for the copolymerization catalyzed by the LA-polymerizing enzyme (LPE). LA-CoA was synthesized by D-lactate dehydrogenase and propionyl-CoA transferase, while 3HB-CoA was supplied by β-ketothiolase (PhaA) and NADPH-dependent acetoacetyl-CoA reductase (PhaB). The functional expression of these enzymes led to a production of P(LA-co-3HB) with high LA fractions (96.8 mol%). The omission of PhaA and PhaB from this pathway led to a further increase in LA fraction up to 99.3 mol%. The newly engineered C. glutamicum potentially serves as a food-grade and biomedically applicable platform for the production of poly(lactic acid)-like polyester.     

Dynamics of activity of the key enzymes of polyhydroxyalkanoate metabolism in Ralstonia eutropha

The dynamics of accumulation of polyhydroxybutyrate (PHB) and the activities of the key enzymes of PHB metabolism (beta-ketothiolase, acetoacetyl-CoA reductase, PHA synthase, D-hydroxybutyrate dehydrogenase, and PHA depolymerase) in the hydrogen bacterium Ralstonia eutropha B5786 were studied under various conditions of carbon nutrition and substrate availability. The highest activities of beta-ketothiolase, acetoacetyl-CoA reductase, and PHA synthase were recorded at the stage of acceleration of PHB synthesis. The activities of enzymes catalyzing PHB depolymerization (PHB depolymerase and D-hydroxybutyrate dehydrogenase) were low, being expressed only at stimulated endogenous PHB degradation. The change of carbon source (CO2 or fructose) did not cause any marked changes in the time course of enzyme activity.     

Physiology and molecular genetics of poly(β-hydroxyalkanoic acid) synthesis in Alcaligenes eutrophus

The Alcaligenes eutrophus genes for beta-ketothiolase, NADPH-dependent acetoacetyl-CoA reductase and poly(beta-hydroxybutyric acid) synthase (PHB synthase) which comprise the three-step PHB-biosynthetic pathway, were cloned. Molecular studies revealed that these genes are organized in a single operon. The A. eutrophus PHB-biosynthetic genes are readily expressed in other bacteria, and DNA fragments harbouring the operon can be used as a cartridge to confer to other bacteria the ability to synthesize PHB from acetyl-CoA. The biochemical and physiological capabilities of A. eutrophus for the synthesis of a wide variety of polyhydroxyalkanoates are discussed.     

Acetoacetyl Coenzyme A Reductase and Polyhydroxybutyrate Synthesis in Rhizobium (Cicer) sp. Strain CC 1192

Biochemical controls that regulate the biosynthesis of poly-3-hydroxybutyrate (PHB) were investigated in Rhizobium (Cicer) sp. strain CC 1192. This species is of interest for studying PHB synthesis because the polymer accumulates to a large extent in free-living cells but not in bacteroids during nitrogen-fixing symbiosis with chickpea (Cicer arietinum L.) plants. Evidence is presented that indicates that CC 1192 cells retain the enzymic capacity to synthesize PHB when they differentiate from the free-living state to the bacteroid state. This evidence includes the incorporation by CC 1192 bacteroids of radiolabel from [¹⁴C]malate into 3-hydroxybutyrate which was derived by chemically degrading insoluble material from bacteroid pellets. Furthermore, the presence of an NADPH-dependent acetoacetyl coenzyme A (CoA) reductase, which was specific for R-(−)-3-hydroxybutyryl-CoA and NADP⁺ in the oxidative direction, was demonstrated in extracts from free-living and bacteroid cells of CC 1192. Activity of this enzyme in the reductive direction appeared to be regulated at the biochemical level mainly by the availability of substrates. The CC 1192 cells also contained an NADH-specific acetoacetyl-CoA reductase which oxidized S-(+)-3-hydroxybutyryl-CoA. A membrane preparation from CC 1192 bacteroids readily oxidized NADH but not NADPH, which is suggested to be a major source of reductant for nitrogenase. Thus, a high ratio of NADPH to NADP⁺, which could enhance delivery of reductant to nitrogenase, could also favor the reduction of acetoacetyl-CoA for PHB synthesis. This would mean that fine controls that regulate the partitioning of acetyl-CoA between citrate synthase and 3-ketothiolase are important in determining whether PHB accumulates.