The influences of fungitoxicants on growth and aflatoxin production by Aspergillus flavus

The influence of six fungitoxicants on growth and aflatoxin production by Aspergillus flavus was tested in liquid SMKY medium at two concentrations, viz . 0.1 and 0.5%. Thiram completely inhibited the aflatoxin production at 0.5% concentration. Other fungitoxicants showing more than 60% inhibition were bavistin and daconil. Vitavax (0.1%) and agrosan GN (0.1 and 0.5%) stimulated the growth of fungus and aflatoxin elaboration after 7 d of incubation. Dithane M-45 moderately inhibited aflatoxin synthesis. Treatment with fungitoxicants also alters the ratio of B₁ and G₁.     

Efficacy of medicinal plant (Andrographis peniculata) extract on aflatoxin production and growth of Aspergillus flavus

The efficacies of four different concentrations (3, 5, 8 and 10 mg/ml) of an aqueous extract of the Andrographis peniculata were tested on growth and aflatoxin production by Aspergillus flavus in liquid SMKY medium. The maximum inhibition of aflatoxin production and growth of A. flavus were marked at 10 mg/ml (i.e. 78.6% aft. B₁ and 75.1% growth). Growth and aflatoxin production were co-related processes.     

Interaction of aflatoxin with L-ascorbic acid: a kinetic and mechanistic approach.

Aflatoxins containing B(1), B(2), G(1) and G(2) obtained by growing Aspergillus parasiticus on SMKY liquid medium were tested for cytotoxicity (hemolysis) on RBC suspension in the presence and absence of L-ascorbic acid (AA). The results revealed that hemolysis was significantly increased on increasing the concentration of aflatoxin (0.5-3 microg ml(-1)). It was also found that pretreatment with AA (5-100 microg ml(-1)) significantly decreased aflatoxin-induced hemolysis. The solution chemistry of the interaction of aflatoxin with AA in aqueous solutions showed enhanced conversion of AFB(1) and AFG(1) to AFB(2) and AFG(2), respectively. Hemolytic, kinetic and mechanistic aspects of the interactions of aflatoxins and AA are discussed.     

Morphological alterations in toxigenic <Emphasis Type="Italic">Aspergillus parasiticus</Emphasis> exposed to neem (<Emphasis Type="Italic">Azadirachta indica</Emphasis>) leaf and seed aqueous extracts

The mode of action of the extracts prepared from neem plant i.e., Azadirachta indica on aflatoxin formation in toxigenic Aspergillus species is not well understood. Aflatoxin production by A. parasiticus was suppressed depending on the concentration of the plant aqueous extract (0, 1.56, 3.12, 6.25, 12.5, and 50% v/v) added to the culture media at the time of spore inoculation. Aflatoxin production in fungal mycelia grown for 96 h in culture media containing 50% neem leaf and seed extracts was inhibited by approximately 90 and approximately 65% respectively. Under similar conditions, culture media amended with 1.56% of leaf or seed extract caused approximately 23 and approximately 7% inhibition respectively. Mycelial samples exposed to selected concentrations of the plant extract (1.56 or 50% v/v) collected and processed for morphological studies. Semi-thin longitudinal and cross sections prepared from control (untreated) and treated mycelia (1.56% v/v) revealed that alterations are limited to the vacuolation of the mycelial cytoplasm. Nevertheless, exposure to high concentration i.e., 50% v/v of the extract resulted in vacuolation of the mycelial cytoplasm and vesicle deformation causing attenuation of cell wall at variable intervals. Herniation of the cytoplasmic contents that was protruding from the mycelium was associated with deformation of the mycelium. Some mycelia showed a cleft between the cell wall and cytoplasm. Association of aflatoxin production with morphological changes suggest that probably integrity of the cell barriers particularly cell wall is critical in regulation of aflatoxin production and excretion.     

Genetic diversity in Aspergillus parasiticus population from the peanut agroecosystem in Argentina

AIMS: The aims of this work were to identify potential sources of Aspergillus parasiticus inoculum and to evaluate the sclerotial and toxigenic profiles of this species from the peanut agroecosystem in Argentina. Likewise, the genetic diversity of A. parasiticus population was analysed using vegetative compatibility group (VCG) analysis. METHODS AND RESULTS: The A. parasiticus strains were isolated from soil, debris and peanut seeds in Córdoba Province, Argentina. A. parasiticus was recovered from the three sources analysed. Only 11 of 185 A. parasiticus isolates (5.9%) did not produce aflatoxins, while 57% produced sclerotia. Twenty-four VCG were identified from 63 isolates. The VCG diversity index for A. parasiticus, expressed as the number of groups divided by the total number of isolates, was 0.31. In general, there were significant differences among VCG in aflatoxin production. CONCLUSIONS: The presence of aflatoxigenic strains of A. parasiticus in the three substrates suggests that they may be an important source of aflatoxin in Argentina's peanut agroecosystem. The A. parasiticus population shows a low genetic diversity. SIGNIFICANCE AND IMPACT OF THE STUDY: The present study showed data on inoculum distribution, aflatoxin and sclerotia production and genetic diversity in an A. parasiticus population isolated from the peanut agroecosystem in Argentina.     

The effect of clove and cinnamon oils on growth of and aflatoxin production by Aspergillus flavus

The effect of different concentrations of clove and cinnamon oils was studied on the growth of and aflatoxin production by Aspergillus flavus in SMKY liquid medium. The effect of these compounds was also verified against aflatoxin production in maize. Significant reduction (P < 0.05) in the elaboration of aflatoxin in liquid culture after treatment with more than 100 μg ml^-1 of these compounds was recorded. Cinnamon oil exhibited maximum inhibitory action and reduced 78% aflatoxin formation on maize at 1000 mg kg^-1.     

Intrafungal distribution of aflatoxins among conidia and sclerotia of Aspergillus flavus and Aspergillus parasiticus

This research examines the distribution of aflatoxins among conidia and sclerotia of toxigenic strains of Aspergillus flavus Link and Aspergillus parasiticus Speare cultured on Czapek agar (21 days, 28 degrees C). Total aflatoxin levels in conidia and sclerotia varied considerably both within (intrafungal) and among strains. Aspergillus flavus NRRL 6554 accumulated the highest levels of aflatoxin (conidia: B1, 84000 ppb; G1, 566000 ppb; sclerotia: B1, 135000 ppb; G1, 968000 ppb). Substantial aflatoxin levels in conidia could place at risk those agricultural workers exposed to dust containing large numbers of A. flavus conidia. Cellular ratios of aflatoxin B1 to aflatoxin G1 were nearly identical in conidia and sclerotia even though levels of total aflatoxins in these propagule types may have differed greatly. Aflatoxin G1 was detected in sclerotia of all A. flavus strains but in the conidia of only one strain. Each of the A. parasiticus strains examined accumulated aflatoxin G1 in both sclerotia and conidia. These results are examined in the context of current evolutionary theory predicting an increase in the chemical defense systems of fungal sclerotia, propagules critical to the survival of these organisms.     

veA is required for toxin and sclerotial production in Aspergillus parasiticus

It was long been noted that secondary metabolism is associated with fungal development. In Aspergillus nidulans, conidiation and mycotoxin production are linked by a G protein signaling pathway. Also in A. nidulans, cleistothecial development and mycotoxin production are controlled by a gene called veA. Here we report the characterization of a veA ortholog in the aflatoxin-producing fungus A. parasiticus. Cleistothecia are not produced by Aspergillus parasiticus; instead, this fungus produces spherical structures called sclerotia that allow for survival under adverse conditions. Deletion of veA from A. parasiticus resulted in the blockage of sclerotial formation as well as a blockage in the production of aflatoxin intermediates. Our results indicate that A. parasiticus veA is required for the expression of aflR and aflJ, which regulate the activation of the aflatoxin gene cluster. In addition to these findings, we observed that deletion of veA reduced conidiation both on the culture medium and on peanut seed. The fact that veA is necessary for conidiation, production of resistant structures, and aflatoxin biosynthesis makes veA a good candidate gene to control aflatoxin biosynthesis or fungal development and in this way to greatly decrease its devastating impact on health and the economy.     

Growth of, and aflatoxin production by Aspergillus parasiticus when in the presence of either Lactococcus lactis or lactic acid and at different initial pH values

L uchese , R.H. & H arrigan , W.F. 1990. Growth of, and aflatoxin production by Aspergillus parasiticus when in the presence of either Lactococcus lactis or lactic acid and at different initial pH values. Journal of Applied Bacteriology 69 , 512–519.
Aspergillus parasiticus was grown in a modified Lab-Lemco tryptone broth both as a single culture and in association with Lactococcus lactis . Total aflatoxin (B1 + G1) production was higher in the mixed cultures. This stimulation persisted when different batches of media, inoculation procedures and makes of ingredients were used. Aflatoxin yields increased in media with an initial pH of 4.2 compared with a pH close to neutrality. Hydrochloric and/or lactic acid had little effect. The substitution of half the carbon content of the medium by lactate resulted in stimulation or reduction on aflatoxin production when the initial pH was 4.2 or 6.8, respectively.     

The influence of colouring and pungent agents of red Chilli (Capsicum annum) on growth and aflatoxin production by Aspergillus flavus

Capsanthin and capsaicin, the colouring and pungent principles of red chilli Capsicum annum , respectively, were tested against the growth and aflatoxin producing potentials of Aspergillus flavus in SMKY liquid medium. Capsanthin completely checked both the growth and toxin production at all the concentrations viz. 0.2, 0.6 and 1.0 mg ml^-1, till the fourth day of incubation. On the 10th day growth of the fungus and toxin biosynthesis were 39 and 22% of the control, respectively, at 1.0 mg ml^-1. Capsaicin showed some inhibitory efficacy only up to the fourth day of incubation. The fungus grew thereafter with a marginal inhibition in growth at the highest concentration. The amount of the toxin in the medium was also higher.     

Stimulation of aflatoxin biosynthesis by lipophilic epoxides

Epoxy fatty acids added to the culture media either with the inoculum or at the end of exponential growth phase stimulated aflatoxin production by toxigenic strains of Aspergillus flavus and Aspergillus parasiticus. This effect did not appear when the unsaturated fatty acids used for the synthesis of the epoxides and the polyhydroxyacids (which can be considered to be derived from the opening of the oxirane ring) replaced the epoxides in the culture media. No significant differences were detected in the lipid fractions (diglycerides, sterols, triglycerides, free fatty acids, sterol esters) extracted from the mycelia grown in the presence of any of the fatty acid derivates.     

Isolation of DNA from fungal mycelia and sclerotia without use of density gradient ultracentrifugation

A rapid method for extracting total DNA from Aspergillus flavus and Aspergillus parasiticus has been developed. The procedure can be completed in 2 h and yields 200 to 350 micrograms of DNA from 0.5 to 1.0 g wet wt of mycelia and 150 micrograms from 0.5 g of sclerotia. DNA samples had an OD260/OD280 of 1.6 to 1.8. Most of the DNA was at least 50 kb pairs in size and showed little degradation. DNA prepared by this method was used for restriction endonuclease digestion and Southern blotting. A DNA fragment containing the repeat unit of the ribosomal RNA genes of A. flavus has been identified.     

The effect of eucalyptus oil on growth and aflatoxin production by Aspergillus flavus

The effect of eucalyptus oil on growth and aflatoxin production by Aspergillus flavus was tested at three levels, viz . 0·05, 0·1 and 0·2 ml/50 ml SMKY medium. After 6 days of incubation on 0·05 and 0·1 ml supplemented SMKY medium, growth and toxin production were inhibited while at 0·2 ml concentration there was no growth. However, after 12 days of incubation toxin production was greater than the controls.     

Molasses supplementation promotes conidiation but suppresses aflatoxin production by small sclerotial Aspergillus flavus

AIMS: To find a supplemental ingredient that can be added to routinely used growth media to increase conidial production and decrease aflatoxin biosynthesis in small sclerotial (S strain) isolates of Aspergillus flavus. METHODS AND RESULTS: Molasses was added to three commonly used culture media: coconut agar (CAM), potato dextrose agar (PDA), and vegetable juice agar (V8) and production of conidia, sclerotia, and aflatoxins by A. flavus isolate CA43 was determined. The effect of nitrogen sources in molasses medium (MM) on production of conidia, sclerotia and aflatoxins was examined. Water activity and medium pH were also measured. Conidia harvested from agar plates were counted using a haemocytometer. Sclerotia were weighed after drying at 45 degrees C for 5 days. Aflatoxins B(1) and B(2) were quantified by high-performance liquid chromatography. Addition of molasses to the media did not change water activity or the pH significantly. Supplementing CAM and PDA with molasses increased conidial production and decreased aflatoxins. Two-fold increased yield of conidia was found on MM, which, like V8, did not support aflatoxin production. Adding ammonium to MM significantly increased the production of sclerotia and aflatoxins, but slightly decreased conidial production. Adding urea to MM significantly increased the production of conidia, sclerotia and aflatoxins. CONCLUSIONS: Molasses stimulated conidial production and inhibited aflatoxin production. Its effect on sclerotial production was medium-dependent. Water activity and medium pH were not related to changes in conidial, sclerotial or aflatoxin production. Medium containing molasses alone or molasses plus V8 juice were ideal for conidial production by S strain A. flavus. SIGNIFICANCE AND IMPACT OF THE STUDY: Insight into molecular events associated with the utilization of molasses may help to elucidate the mechanism(s) that decreases aflatoxin biosynthesis. Targeting genetic parameters in S strain A. flavus isolates may reduce aflatoxin contamination of crops by reducing the survival and toxigenicity of these strains.     

Substrate-induced lipase gene expression and aflatoxin production in Aspergillus parasiticus and Aspergillus flavus

AIMS: To establish a relationship between lipase gene expression and aflatoxin production by cloning the lipA gene and studying its expression pattern in several aflatoxigenic and nontoxigenic isolates of Aspergillus flavus and A. parasiticus. METHODS AND RESULTS: We have cloned a gene, lipA, that encodes a lipase involved in the breakdown of lipids from aflatoxin-producing A. flavus, A. parasiticus and two nonaflatoxigenic A. flavus isolates, wool-1 and wool-2. The lipA gene was transcribed under diverse media conditions, however, no mature mRNA was detected unless the growth medium was supplemented with 0.5% soya bean or peanut oil or the fungus was grown in lipid-rich medium such as coconut medium. The expression of the lipase gene (mature mRNA) under substrate-induced conditions correlated well with aflatoxin production in aflatoxigenic species A. flavus (SRRC 1007) and A. parasiticus (SRRC 143). CONCLUSIONS: Substrate-induced lipase gene expression might be indirectly related to aflatoxin formation by providing the basic building block 'acetate' for aflatoxin synthesis. No direct relationship between lipid metabolism and aflatoxin production can be ascertained, however, lipase gene expression correlates well with aflatoxin formation. SIGNIFICANCE AND IMPACT OF THE STUDY: Lipid substrate induces and promotes aflatoxin formation. It gives insight into genetic and biochemical aspects of aflatoxin formation.     

Effect of Corn Steep Liquor on Mycelial Growth and Aflatoxin Production in Aspergillus parasiticus

Total aflatoxin concentrations produced by Aspergillus parasiticus, isolate 64-R8, in Czapek's broth fortified with corn steep liquor increased proportionately as the concentration of corn steep was increased from 0.5 to 8.0% (v/v) until maximal growth, as measured by dry mycelial weight, was reached. Thereafter, aflatoxin concentrations declined more rapidly than the rate of autolysis of mycelial material. Data are presented which indicate that the concentration of corn steep liquor also affects the ratio of production of aflatoxin B(1) and B(2) to that of aflatoxin G(1) and G(2). Further, this ratio also varies with time of incubation. Although both growth of the fungus and aflatoxin production are stimulated by the addition of corn steep to the basic medium, the stimulation of toxin production is much greater than fungus growth.     

Effect of pyridazinone herbicides on growth and aflatoxin release by Aspergillus flavus and Aspergillus parasiticus.

The influence of pyridazinone herbicides on aflatoxin production by Aspergillus flavus and A. parasiticus was studied in liquid media. Mycelia production was not affected by 20, 40, or 60 micrograms of herbicide per ml; however, aflatoxin production by A. parasiticus was higher in media with herbicide, whereas A. flavus produced lower aflatoxin levels.     

Effect of pyridazinone herbicides on growth and aflatoxin release by Aspergillus flavus and Aspergillus parasiticus

The influence of pyridazinone herbicides on aflatoxin production by Aspergillus flavus and A. parasiticus was studied in liquid media. Mycelia production was not affected by 20, 40, or 60 micrograms of herbicide per ml; however, aflatoxin production by A. parasiticus was higher in media with herbicide, whereas A. flavus produced lower aflatoxin levels.     

Growth of, and aflatoxin production by Aspergillus parasiticus when in the presence of either Lactococcus lactis or lactic acid and at different initial pH values

Aspergillus parasiticus was grown in a modified Lab-Lemco tryptone broth both as a single culture and in association with Lactococcus lactis. Total aflatoxin (B1 + G1) production was higher in the mixed cultures. This stimulation persisted when different batches of media, inoculation procedures and makes of ingredients were used. Aflatoxin yields increased in media with an initial pH of 4.2 compared with a pH close to neutrality. Hydrochloric and/or lactic acid had little effect. The substitution of half the carbon content of the medium by lactate resulted in stimulation or reduction on aflatoxin production when the initial pH was 4.2 or 6.8, respectively.     

Identification of O-methylsterigmatocystin as an aflatoxin B1 and G1 precursor in Aspergillus parasiticus.

An isolate of Aspergillus parasiticus CP461 (SRRC 2043) produced no detectable aflatoxins, but accumulated O-methylsterigmatocystin (OMST). When sterigmatocystin (ST) was fed to this isolate in a low-sugar medium, there was an increase in the accumulation of OMST, without aflatoxin synthesis. When radiolabeled [14C]OMST was fed to resting mycelia of a non-aflatoxin-, non-ST-, and non-OMST-producing mutant of A. parasiticus AVN-1 (SRRC 163), 14C-labeled aflatoxins B1 and G1 were produced; 10 nmol of OMST produced 7.8 nmol of B1 and 1.0 nmol of G1, while 10 nmol of ST produced 6.4 nmol of B1 and 0.6 nmol of G1. A time course study of aflatoxin synthesis in ST feeding experiments with AVN-1 revealed that OMST is synthesized by the mold during the onset of aflatoxin synthesis. The total amount of aflatoxins recovered from OMST feeding experiments was higher than from experiments in which ST was fed to the resting mycelia. These results suggest that OMST is a true metabolite in the aflatoxin biosynthetic pathway between sterigmatocystin and aflatoxins B1 and G1 and is not a shunt metabolite, as thought previously.