Characterization and large-scale production of recombinant <Emphasis Type="Italic">Streptoverticillium platensis</Emphasis> transglutaminase

Recombinant Streptomyces platensis transglutaminase (MtgA) produced by the Streptomyces lividans transformant 25-2 was purified by ammonium sulfate fractionation, followed by CM-Sepharose CL-6B fast flow, and blue-Sepharose fast flow chromatography. The purification factor was ~33.2-fold, and the yield was 65%. The molecular weight of the purified recombinant MtgA was 40.0 KDa as estimated by SDS-PAGE. The optimal pH and the temperature for the enzyme activity were 6.0 and 55 degrees C, respectively, and the enzyme was stable at pH 5.0-6.0 and at temperature 45-55 degrees C. Enzyme activity was not affected by Ca(2+), Li(+), Mn(2+), Na(+), Fe(3+), K(+), Mg(2+), Al(3+), Ba(2+), Co(2+), EDTA, or IAA but was inhibited by Fe(2+), Pb(2+), Zn(2+), Cu(2+), Hg(2+), PCMB, NEM, and PMSF. Optimization of the fermentation medium resulted in a twofold increase of recombinant MtgA activity in both flasks (5.78 U/ml) and 5-l fermenters (5.39 U/ml). Large-scale productions of the recombinant MtgA in a 30-l air-lift fermenter and a 250-l stirred-tank fermenter were fulfilled with maximal activities of 5.36 and 2.54 U/ml, respectively.     

Partial purification and characterization of almond seed lipase

A lipase was partially purified from the almond (Amygdalus communis L.) seed by ammonium sulfate fractionation and dialysis. Kinetics of the enzyme activity versus substrate concentration showed typical lipase behavior, with K(m) and V(max) values of 25 mM and 113.63 micromol min(-1) mg(-1) for tributyrin as substrate. All triglycerides were efficiently hydrolyzed by the enzyme. The partially purified almond seed lipase (ASL) was stable in the pH range of 6-9.5, with an optimum pH of 8.5. The enzyme was stable between 20 and 90 degrees C, beyond which it lost activity progressively, and exhibited an optimum temperature for the hydrolysis of soy bean oil at 65 degrees C. Based on the temperature activity data, the activation energy for the hydrolysis of soy bean oil was calculated as -5473.6 cal/mol. Soy bean oil served as good substrate for the enzyme and hydrolytic activity was enhanced by Ca(2+), Fe(2+), Mn(2+), Co(2+), and Ba(2+), but strongly inhibited by Mg(2+), Cu(2+), and Ni(2+). The detergents, sodiumdeoxicholate and Triton X-100 strongly stimulated enzyme activity while CTAB, DTAB, and SDS were inhibitors. Triton X-405 had no effect on lipase activity. The partially purified enzyme retained its activity for more than 6 months at -20 degrees C, beyond which it lost activity progressively.     

Presence of rhodanese in the cytosolic fraction of the fruit bat (Eidolon helvum) liver

Rhodanese was isolated and purified from the cytosolic fraction of liver tissue homogenate of the fruit bat, Eidolon helvum, by using ammonium sulphate precipitation and CM-Sephadex C-50 ion exchange chromatography. The specific activity was increased 130-fold with a 53% recovery. The K(m) values for KCN and Na(2)S(2)O(3) as substrates were 13.5 +/- 2.2mM and 19.5 +/- 0.7 mM, respectively. The apparent molecular weight was estimated by gel filtration on a Sephadex G-100 column to be 36,000 Da. The optimal activity was found at a high pH (pH 9.0) and the temperature optimum was 35 degrees C. An Arrhenius plot of the heat stability data consisted of two linear segments with a break occurring at 35 degrees C. The apparent activation energy values from these slopes were 11.5 kcal/mol and 76.6 kcal/mol. Inhibition studies on the enzyme with a number of cations showed that Mg(2+), Mn(2+), Ca(2+), and Co(2+) did not affect the activity of the enzyme, but Hg(2+) and Ba(2+) inhibited the enzyme.     

Cloning of the SAP6 gene of Metschnikowia reukaufii and its heterologous expression and characterization in Escherichia coli

The SAP6 gene (without signal sequence) encoding Metschnikowia reukaufii acid protease was amplified by PCR and fused to the expression vector pET-24a(+). The carboxy-terminal 6x His-tagged recombinant acid protease (rSAP6) was expressed from pET-24a(+)SAP6-6His in Escherichia coli BL21 (DE3) and purified with affinity chromatography using a Ni-NTA column. SDS-PAGE analysis and Western blotting revealed that the molecular mass of the purified rSAP6 was 54kDa. The optimal temperature and pH of the purified rSAP6 were 40 degrees C and 3.4, respectively. The enzyme was stable below 45 degrees C and between pH 2.6 and 5.0. The results show that Mn(2+) had an activating effect on the enzyme, while Cu(2+), Mg(2+), Zn(2+) and Ag(+) acted as inhibitors of the enzyme. However, Ca(2+) had no effect on the enzyme activity. The purified rSAP6 was characterized as an aspartic protease as it was inhibited by aspartic protease-specific inhibitors, such as pepstatin. It was also found that the purified rSAP6 had milk-clotting activity.     

Purification and characterization of agarases from a marine bacterium <Emphasis Type="Italic">Vibrio</Emphasis> sp<Emphasis Type="Italic">.</Emphasis> F-6

Marine bacterium Vibrio sp. F-6, utilizing agarose as a carbon source to produce agarases, was isolated from seawater samples taken from Qingdao, China. Two agarases (AG-a and AG-b) were purified to a homogeneity from the cultural supernatant of Vibrio sp. F-6 through ammonium sulfate precipitation, Q-Sepharose FF chromatography, and Sephacryl S-100 gel filtration. Molecular weights of agarases were estimated to be 54.0 kDa (AG-a) and 34.5 kDa (AG-b) by sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE). The optimum pH values for AG-a and AG-b were about 7.0 and 9.0, respectively. AG-a was stable in the pH range of 4.0-9.0 and AG-b was stable in the pH range of 4.0-10.0. The optimum temperatures of AG-a and AG-b were 40 and 55 degrees C, respectively. AG-a was stable at temperature below 50 degrees C. AG-b was stable at temperature below 60 degrees C. Zn(2+), Mg(2+) or Ca(2+) increased AG-a activity, while Mn(2+), Cu(2+) or Ca(2+) increased AG-b activity. However, Ag(+), Hg(2+), Fe(3+), EDTA and SDS inhibited AG-a and AG-b activities. The main hydrolysates of agarose by AG-a were neoagarotetraose and neoagarohexaose. The main hydrolysates of agarose by AG-b were neoagarooctaose and neoagarohexaose. When the mixture of AG-a and AG-b were used, agarose was mainly degraded into neoagarobiose.     

Expression and characterization of dextransucrase gene dsrX from Leuconostoc mesenteroides in Escherichia coli

The dextransucrase gene dsrX from Leuconostoc mesenteroides CGMCC 1.544 was cloned into the vector pET-28a(+) and expressed as a N-terminal His(6)-tag fusion protein of 167.57 kDa in Escherichia coli BL21(DE3). DsrX with the high volumetric activity of 8.8 U ml(-1) culture and the specific activity of 97.37 U mg(-1) crude enzyme extracts was measured in the optimized recombinant expression system. The resultant expression level of the fusion protein amounted to 24.5% of the total cell proteins. The results of affinity chromatography and western blotting indicated that the three sensitive sites of proteolysis existed in the N-terminal catalytic domain of DsrX. Both the recombinant and native enzyme activity were slightly activated by 1 mmol l(-1) Mn(2+) and strongly inhibited by 1 mmol l(-1) Cu(2+) or Al(3+), and their optimum pH values were 5.4. The optimum temperature of the recombinant enzyme for dextran synthesis was 30 degrees C, which was 10 degrees C less than that of the native one. The transglucosylation products of two enzymes were studied by using thin layer chromatography and high-performance anion exchange chromatography. It could be concluded that the better sample-pretreatment temperature in SDS-PAGE was 37 degrees C, which significantly improved the detection of thermal instable enzyme than that of 100 degrees C.     

Kinetic properties of a magnesium ion- and calcium ion-stimulated adenosine triphosphatase from the outer-membrane fraction of rat spleen mitochondria

1. Isolated outer membranes from rat spleen mitochondria can be stored in liquid N(2) for several weeks without significant loss of ATPase (adenosine triphosphatase) activity. 2. The ATPase reaction has a broad pH optimum centering on neutral pH, with little significant activity above pH9.0 or below pH5.5. 3. A sigmoidal response of the ATPase activity to temperature is observed between 0 and 55 degrees C, with complete inactivation at 60 degrees C. The Arrhenius plot shows that the activation energy above the transition temperature (22 degrees C) (E(a)=144kJ/mol) is one-third of that calculated for below the transition temperature (E'(a)=408kJ/mol). 4. The outer-membrane ATPase (K(m) for MgATP=50mum) is inactive unless Mg(2+) is added, whereas the inner-membrane ATPase (K(m) for ATP=11mum) is active without added Mg(2+) unless the mitochondria have been depleted of all endogenous Mg(2+) (by using ionophore A23187). 5. The substrate for the outer-membrane ATPase is a bivalent metal ion-nucleoside triphosphate complex in which Mg(2+) (K(m)=50mum) can be replaced effectively by Ca(2+) (K(m)=6.7mum) or Mn(2+), and ATP by ITP. Cu(2+), Co(2+), Sr(2+), Ba(2+), Ni(2+), Cd(2+) and Zn(2+) support very little ATP hydrolysis. 6. Univalent metal ions (Na(+), K(+), Rb(+), Cs(+) and NH(4) (+), but not Li(+)) stimulate the MgATPase activity (<10%) at low concentrations (50mm), but, except for K(+), are slightly inhibitory (20-30%) at higher concentrations (500mm). 7. The Mg(2+)-stimulated ATPase activity is significantly inhibited by Cu(2+) (K(i)=90mum), Ni(2+) (K(i)=510mum), Zn(2+) (K(i)=680mum) and Co(2+) (K(i)=1020mum), but not by Mg(2+), Ca(2+), Ba(2+) or Sr(2+). 8. The outer-membrane ATPase is insensitive to the inhibitors oligomycin, NN'-dicyclohexylcarbodiimide, NaN(3), ouabain and thiol-specific reagents. A significant inhibition is observed at high concentrations of AgNO(3) (0.5mm) and NaF (10mm). 9. The activity towards MgATP is competitively inhibited by the product MgADP (K(i)=0.7mm) but not by the second product P(i) or by 5'-AMP.     

Purification, properties, and partial amino acid sequence of chitinase from a marine Alteromonas sp. strain O-7.

Chitinase (EC 3.2.1.14) was isolated from the culture supernatant of a marine bacterium, Alteromonas sp. strain O-7. The enzyme (Chi-A) was purified by anion-exchange chromatography (DEAE-Toyopearl 650 M) and gel filtration (Sephadex G-100). The purified enzyme showed a single band on sodium dodecyl sulfate polyacrylamide gel electrophoresis. The molecular size and pI of Chi-A were 70 kDa and 3.9, respectively. The optimum pH and temperature of Chi-A were 8.0 and 50 degrees C, respectively. Chi-A was stable in the range of pH 5-10 up to 40 degrees C. Among the main cations, such as Na+, K+, Mg2+, and Ca2+, contained in seawater, Mg2+ stimulated Chi-A activity. N-Bromosuccinimide and 2-hydroxy-5-nitrobenzyl bromide inhibited Chi-A activity. The amino-terminal 27 amino acid residues of Chi-A were sequenced. This enzyme showed sequence homology with chitinases from terrestrial bacteria such as Serratia marcescens QMB1466 and Bacillus circulans WL-12.     

A beta-mannanase from Bacillus subtilis B36: purification, properties, sequencing, gene cloning and expression in Escherichia coli

MANB36, a secrete endo-beta-1,4-D-mannanase produced by Bacillus subtilis B36, was purified to homogeneity from a culture supernatant and characterized. The optimum pH value for the mannanase activity of MANB36 is 6.4 and the optimum temperature is 50 degrees C. The enzyme activity of MANB36 is remarkably thermostable at 60 degrees C and the specific activity of MANB36 is 927.84 U/mg. Metal cations (except Hg2+ and Ag+), EDTA and 2-mercaptoethanol (2-ME) have no effects on enzyme activity. This enzyme exhibits high specificity with the substituted galactomannan locust bean gum (LBG). The gene encoding for MANB36, manB36, was cloned by PCR and sequenced. manB36 contains a single open reading frame (ORF) consisting of 1104 bp that encodes a protein of 367 amino acids. The predicted molecular weight of 38.13 kDa, calculated by the deduced protein of the gene manB36 without signal peptide, coincides with the apparent molecular weight of 38.0 kDa of the purified MANB36 estimated by SDS-PAGE. The mature protein of MANB36 has been expressed in Escherichia coli BL21 and the expressed mannanase has normal bioactivity.     

Purification and characterization of a novel pectinase from Acrophialophora nainiana with emphasis on its physicochemical properties

An extracellular pectinase (PECI) was purified to apparent homogeneity from liquid state cultures of the thermophilic fungus Acrophialophora nainiana by ultrafiltration and a combination of gel filtration and ion-exchange chromatographic procedures. The molecular masses of PECI were 35,500 and 30,749 Da, as determined by SDS-PAGE and mass spectrometry, respectively. It was more active at 60 degrees C and pH 8.0 and showed high stability at 50 degrees C with half-life of 7 days. However at 60 and 70 degrees C, PECI was much less stable with half lives of approximately 20 and 3 min, respectively. The thermostability of purified PECI was also investigated by fluorescence and circular dichroism spectroscopy. Fluorescence revealed that the unfolding transition region was observed between 45 and 70 degrees C. A major decrease in the stability was found at 70 degrees C. Circular dichroism measurements at pH between 5.0 and 9.0 showed a transition temperature (T(m)) range of 50-55 degrees . The thermodynamic analysis of these results showed that EPGI is thermal stable protein exhibiting maximum stability (DeltaG(25)) of 22.65 and 19.19 kcal/mol at pH 8.0 and 9.0, respectively. The apparent K(m) value on pectin from citrus fruits was 4.22 mgml(-1). PECI exhibited no detectable activity of pectin methylesterase, endo-polygalacturonase, mannanase, xylanase and cellulase. However, it showed exo-polygalacturonase and pectin lyase activities. The presence of carbohydrate was detected in the pure PECI. It was activated by l-tryptophan, DEPC, DTT, DTNB, DTP, l-cystein and beta-mercaptoethanol and inhibited by NBS, Fe(2+), Cu(2+), Zn(2+), Mn(2+), Al(3+) and Ca(2+). The enzyme showed homology with a pectin lyases from Xanthomonas campestris and Bacillus licheniformis.     

Expression and characterization of fumarase (FUMR) from Rhizopus oryzae

Fumarase catalyzes the reversible hydration of fumarate to l-malate in Rhizopus oryzae. A recombinant pET22b-fumR harboring a fumarase gene (fumR) from R. oryzae was constructed for high level expression in E. coli BL21 (DE3). The FUMR activity was optimal at 30°C and pH 7.2. The enzyme was stable below 45°C and at pH 3.0-9.0. No effects of Zn(2+), Fe(2+), or EDTA were observed on enzyme activity. A slight inhibition of FUMR activity was seen with Mg(2+), while Ca(2+) had a small stimulatory effect. The K(m) for l-malic acid and fumaric acid were 0.46 mM and 3.07 mM, respectively. The activity of FUMR catalyzing hydration of fumarate to l-malate was completely inhibited by 2mM fumaric acid. The unique enzymatic properties suggested that overexpression of FUMR could enhance fumaric acid accumulation in R. oryzae.     

Conversion of squid pen by Serratia ureilytica for the production of enzymes and antioxidants

Two proteases (P1 and P2) and a chitinase (C1) were purified from the culture supernatant of Serratia ureilytica TKU013 with squid pen as the sole carbon/nitrogen source. The molecular masses of P1, P2 and C1 determined by SDS-PAGE were approximately 50 kDa, 50 kDa and 60 kDa, respectively. The optimum pH, optimum temperature, pH stability, and thermal stability of P1, P2 and C1 were (pH 10, 40 degrees C, pH 7-11, and <50 degrees C), (pH 10, 40 degrees C, pH 8-11, and <40 degrees C) and (pH 6, 50 degrees C, pH 5-8, and <50 degrees C), respectively. P1 and P2 were inhibited by Mg(2+), EDTA and C1 was inhibited completely by Cu(2+). The antioxidant activity of TKU013 culture supernatant was 72% per mL (DPPH scavenging ability). With this method, we have shown that squid pen wastes can be utilized and have revealed its hidden potential in the production of functional foods.     

Midgut proteases of the cardamom shoot and capsule borer Conogethes punctiferalis (Lepidoptera: Pyralidae) and their interaction with aprotinin

Protease inhibitors cause mortality in a range of insects, and transgenic plants expressing protease inhibitors have been protected against pest attack, particularly internal feeders that are not amenable to control by conventional means. A study of luminal proteases in Conogethes punctiferalis Guenée was performed to identify potential targets for proteinaceous biopesticides, such as protease inhibitors. The midgut protease profile of the gut lumen from C. punctiferalis was studied to determine the conditions for optimal protein hydrolysis. Optimum conditions for peptidase activity were found to be in 50 mm Tris-HCl, pH 10 containing 20 mm CaCl2; incubation for 30 min at 40 degrees C. Four synthetic substrates, i.e. benzoyl-arg-p-nitroanilide, benzoyl-tyr-p-nitroanilide, succinyl-ala-ala-pro-leu-p-nitroanilide (SAAPLpNA) and leu-p-nitroanilide were hydrolysed by C. punctiferalis gut proteases in Tris-HCl buffer pH 10. Trypsin and elastase-like chymotrypsin were the prominent digestive proteases, and age-related modulation of midgut proteases existed for trypsin, chymotrypsin, elastase-like chymotrypsin and leucine aminopeptidase. Serine protease inhibitors such as aprotinin, soybean trypsin inhibitor and phenylmethanesulfonyl fluoride inhibited peptidase activity. Some metal ions such as Ca(2+), Mg(2+), Pb(2+) and Co(2+) enhanced BApNA-ase activity whereas others like Mn(2+), Zn(2+), Cu(2+), Fe(2+) and Hg(2+) were inhibitory at 6 mm concentration. Trypsin and elastase-like chymotrypsin were significantly inhibited by 94% and 29%, respectively, by aprotinin (150 nm) under in vitro conditions. A possible incorporation of protease inhibitors into transgenic plants is discussed.     

Purification and characterization of a Bacillus cereus exochitinase

Five extracellular chitinases of Bacillus cereus 6E1 were detected by a novel in-gel chitinase assay using carboxymethyl-chitin-remazol brilliant violet 5R (CM-chitin-RBV) as a substrate. The major chitinase activity was associated with a 36-kDa (Chi36) gel band. Chi36 was purified by a one-step, native gel purification procedure derived from the new in-gel chitinase assay. The purified Chi36 has optimal activity at pH 5.8 and retains some enzymatic activity between pH 2.5-8. The temperature optimum for Chi36 was 35 degrees C, but the enzyme was active between 4-70 degrees C. Based on its ability to hydrolyze mainly p-nitrophenyl-(N-acetyl-beta-D-glucosaminide)(2), Chi36 is characterized as a chitobiosidase, a type of exochitinase. The N-terminal amino acid sequence of mature Chi36 was determined (25 amino acids). Alanine is the first N-terminal amino acid residue indicating the cleavage of a signal peptide from a Chi36 precursor to form the mature extracellular Chi36. The N-terminal sequence of Chi36 demonstrated highest similarity with Bacillus circulans WL-12 chitinase D and significant similarity with several other bacterial chitinases.     

Purification and characterization of cathepsin L-like proteinase from goat brain

Cathepsin L-like proteinase was purified approximately 1708-fold with 40% activity yield to an apparent electrophoretic homogeneity from goat brain by homogenization, acid-autolysis at pH 4.2, 30-80% (NH4)2SO4 fractionation, Sephadex G-100 column chromatography and ion-exchange chromatography on CM-Sephadex C-50 at pH 5.0 and 5.6. The molecular weight of proteinase was found to be approximately 65,000 Da, by gel-filtration chromatography. The pH optima were 5.9 and 4.5 for the hydrolysis of Z-Phe-Arg-4mbetaNA (benzyloxycarbonyl-L-phenylalanine-L-arginine-4-methoxy-beta-naphthylamide) and azocasein, respectively. Of the synthetic chromogenic substrates tested, Z-Phe-Arg-4mbetaNA was hydrolyzed maximally by the enzyme (Km value for hydrolysis was 0.06 mM), followed by Z-Val-Lys-Lys-Arg-4mbetaNA, Z-Phe-Val-Arg-4mbetaNA, Z-Arg-Arg-4mbetaNA and Z-Ala-Arg-Arg-4mbetaNA. The proteinase was activated maximally by glutathione in conjunction with EDTA, followed by cysteine, dithioerythritol, thioglycolic acid, dithiothreitol and beta-mercaptoethanol. It was strongly inhibited by p-hydroxymercuribenzenesulphonic acid, iodoacetic acid, iodoacetamide and microbial peptide inhibitors, leupeptin and antipain. Leupeptin inhibited the enzyme competitively with Ki value 44 x 10(-9) M. The enzyme was strongly inhibited by 4 M urea. Metal ions, Hg(2+), Ca(2+), Cu(2+), Li(2+), K(+), Cd(2+), Ni(2+), Ba(2+), Mn(2+), Co(2+) and Sn(2+) also inhibited the activity of the enzyme. The enzyme was stable between pH 4.0-6.0 and up to 40 degrees C. The optimum temperature for the hydrolysis of Z-Phe-Arg-4mbetaNA was approximately 50-55 degrees C with an activation energy Ea of approximately 6.34 KCal mole(-1).     

Phytase activity in Cryptococcus laurentii ABO 510

Ten Cryptococcus strains were screened for phytase activity, of which the Cryptococcus laurentii ABO 510 strain showed the highest level of activity. The cell wall-associated enzyme displayed temperature and pH optima of 62 degrees C and 5.0, respectively. The enzyme was thermostable at 70 degrees C, with a loss of 40% of its original activity after 3 h. The enzyme was active on a broad range of substrates, including ATP, D-glucose 6-phosphate, D-fructose 1,6-diphosphate and p-nitrophenyl phosphate (p-NPP), but its preferred substrate was phytic acid (K(m) of 21 microM). The enzyme activity was completely inhibited by 0.5 mM inorganic phosphate or 5 mM phytic acid, and moderately inhibited in the presence of Hg(2+), Zn(2+), Cd(2+) and Ca(2+). These characteristics suggest that the Cry. laurentii ABO 510 phytase may be considered for application as an animal feed additive to assist in the hydrolysis of phytate complexes to improve the bioavailability of phosphorus in plant feedstuff.     

Purification and some properties of beta-N-acetyl-D-glucosaminidase from the cabbage butterfly (Pieris rapae)

A beta-N-acetyl-D-glucosaminidase (NAGase) from the cabbage butterfly (Pieris rapae) was purified. The purified enzyme was a single band on polyacrylamide gel electrophoresis and the specific activity was determined to be 8715 U/mg. The molecular weight of whole enzyme was determined to be 106 kDa by gel filtration, and the result of SDS-PAGE showed that the enzyme was a heterodimer, which contained two subunits with different mass of 59.5 and 57.2 kDa. The optimum pH and optimum temperature of the enzyme for the hydrolysis of p-nitrophenyl-N-acetyl-beta-D-glucosaminide (pNP-NAG) were investigated to be at pH 6.2 and at 42 degrees C, respectively, and the Michaelis-Menten constant (K(m)) was determined to be 0.285 mM at pH 6.2 and 37 degrees C. The stability of the enzyme was investigated and the results showed that the enzyme was stable at the pH range from 4.0 to 9.0 and at the temperature below 45 degrees C. The activation energy was 83.86 kJ/mol. The reaction of this enzyme with pNP-NAG was judged to be Ordered Bi-Bi mechanism according to the inhibitory behaviors of the products. The ionization constant, pK(e), of ionizing group at the active site of the enzyme was found to be 5.20 at 39.0 degrees C, and the standard dissociation enthalpy (DeltaH(o)) was determined to be 2.18 kcal/mol. These results showed that the ionizing group of the enzyme active center was the carboxyl group. The results of chemical modification also suggested that carboxyl group was essential to the enzyme activity. Moreover, Zn(2+), Hg(2+), Cu(2+) had strongly inhibitory effects on the enzyme activity.     

Purification and kinetics of a raw starch-hydrolyzing,thermostable, and neutral glucoamylase of the thermophilic mold Thermomucor indicae-seudaticae

The purified glucoamylase of the thermophilic mold Thermomucor indicae-seudaticaehad a molecular mass of 42 kDa with a pI of 8.2. It is a glycoprotein with 9-10.5% carbohydrate content, which acted optimally at 60 degrees C and pH 7.0, with a t(1/2) of 12 h at 60 degrees C and 7 h at 80 degrees C. Its experimental activation energy was 43 KJ mol(-1) with temperature quotient (Q(10)) of 1.35, while the values predicted by response surface methodology (RSM) were 43 KJ mol(-1) and 1.28, respectively. The enzyme hydrolyzed soluble starch at 50 degrees C (K(m) 0.50 mg mL(-1) and V(max) 109 micromol mg(-1) protein min(-1)) and at 60 degrees C (K(m) 0.40 and V(max) 143 micromol mg(-1) protein min(-1)). The experimental K(m) and V(max) values are in agreement with the predicted values at 50 degrees C (K(m) 0.45 mg mL(-1) and V(max) 111.11 micromol mg(-1) protein min(-1)) and at 60 degrees C (K(m) 0.36 mg mL(-1)and V(max) 142.85 micromol mg(-1) protein min(-1)). An Arrhenius plot indicated thermal activation up to 60 degrees C, and thereafter, inactivation. The enzyme was strongly stimulated by Co(2+), Fe(2+), Ag(2+), and Ca(2+), slightly stimulated by Cu(2+) and Mg(2+), and inhibited by Hg(2+), Zn(2+), Ni(2+), and Mn(2+). Among additives, dextran and trehalose slightly enhanced the activity. Glucoamylase activity was inhibited by EDTA, beta-mercaptoethanol, dithiothreitol, and n-bromosuccinimide, and n-ethylmaleimide inhibited its activity completely. This suggested the involvement of tryptophan and cysteine in catalytic activity and the critical role of disulfide linkages in maintaining the conformation of the enzyme. The enzyme hydrolyzed around 82% of soluble starch and 65% of raw starch (K(m) 2.4 mg mL(-1), V(max) 50 micromol mg(-1) protein min(-1)), and it was remarkably insensitive to glucose, suggesting its applicability in starch saccharification.     

Characterization of the Bacillus subtilis WL-3 mannanase from a recombinant Escherichia coli

A mannanase was purified from a cell-free extract of the recombinant Escherichia coli carrying a Bacillus subtilis WL-3 mannanase gene. The molecular mass of the purified mannanase was 38 kDa as estimated by SDS-PAGE. Optimal conditions for the purified enzyme occurred at pH 6.0 and 60 degrees C. The specific activity of the purified mannanase was 5,900 U/mg on locust bean gum (LBG) galactomannan at pH 6.0 and 50 degrees C. The activity of the enzyme was slightly inhibited by Mg(2+), Ca(2+), EDTA and SDS, and noticeably enhanced by Fe(2+). When the enzyme was incubated at 4 degrees C for one day in the presence of 3 mM Fe(2+), no residual activity of the mannanase was observed. The enzyme showed higher activity on LBG and konjac glucomannan than on guar gum galactomannan. Furthermore, it could hydrolyze xylans such as arabinoxylan, birchwood xylan and oat spelt xylan, while it did not exhibit any activities towards carboxymethylcellulose and para-nitrophenyl-beta-mannopyranoside. The predominant products resulting from the mannanase hydrolysis were mannose, mannobiose and mannotriose for LBG or mannooligosaccharides including mannotriose, mannotetraose, mannopentaose and mannohexaose. The enzyme could hydrolyze mannooligosaccharides larger than mannobiose.