2,3-丁二醇代谢途径关键酶基因敲除对克雷伯氏菌发酵产1,3-丙二醇的影响

2,3-丁二醇是克雷伯氏菌发酵产1,3-丙二醇的主要副产物,为减少2,3-丁二醇的产生,利用Red重组技术对克雷伯氏菌2,3-丁二醇合成途径关键酶基因budC和budA进行了敲除。突变株发酵性能实验结果表明,所获得的两株突变株生长性能受到不同程度的影响;budC基因的缺失使菌株1,3-丙二醇产量提高了10%,2,3-丁二醇降低为原来的70%,而budA基因缺失则使菌株无2,3-丁二醇和1,3-丙二醇的产生,但乳酸、琥珀酸、乙醇和乙酸的产量较出发菌株都有明显增长。通过进一步对budC基因缺失菌株主要产物分析,推测在该菌中存在2,3-丁二醇回补途径,这一结果为低副产物克雷伯氏菌的改造提供了新依据。     

一种简单的高产2,3-丁二醇发酵生产方法

利用一株克雷伯氏菌(Klebsiellasp.LN145)在以葡萄糖和磷酸氢二铵为主要成分的培养基中发酵生产2,3-丁二醇。在补料发酵培养过程中,通过补糖,2,3-丁二醇和3-羟基丁酮的最大产量分别达到了84.0 g/L和10.5 g/L,二醇的摩尔转化率达到理论水平的91%,转化速率达到1.8 g/(L.h)。     

耐高糖高产2,3-丁二醇产酸克雷伯氏杆菌的选育

以产酸克雷伯氏杆菌(Klebsiella oxytoca) ME-UD-3为出发菌株,经紫外线及硫酸二乙酯复合诱变后分别在葡萄糖浓度逐渐提高的液体培养基中进行富集培养,筛选获得了一株耐高糖的2,3-丁二醇高产突变菌株K. oxytoca ME-UD-3-4;该菌株的初始葡萄糖耐受浓度从出发菌株的120g/L提高到300g/L以上,在初始葡萄糖浓度为95 g/L的条件下发酵培养,与出发菌株相比发酵时间缩短了8h,2,3-丁二醇的产量由原来的38.5g/L提高到43.0g/L,生产强度从0.80 g/L·h提高到1.08 g/L·h,转化率达到了理论值的91%。     

一株产酸克雷伯氏菌发酵培养基优化

为提高产酸克雷伯氏菌(Klebsiella oxytoca)的发酵水平,通过单因素优化,研究培养条件、碳源、氮源、无机盐对产酸克雷伯氏菌活菌量的影响,利用响应面分析法对影响产酸克雷伯氏菌活菌量的关键因子进行优化,30 L发酵罐进行扩大培养。得出最佳配方（质量分数）：黄豆饼粉2.19%,玉米粉1.0%,蔗糖1.10%,硫酸铵0.06%,玉米浆干粉0.5%,蛋白胨0.05%,硫酸镁0.04%,磷酸二氢钾0.02%,氯化钠0.080%,硫酸锰0.03%,pH 7.0~7.4。活菌量稳定在2.0×10¹⁰  cfu/mL以上,能够满足生产要求,为产酸克雷伯氏菌作为微生物菌肥的应用提供参考。     

产酸克雷伯氏杆菌发酵产2，3-丁二醇的培养基优化

采用不同设计方法相结合的策略对耐高糖产酸克雷伯氏杆菌（Klebsiella oxytoca）ME—UD-3-4发酵产2,3-丁二醇的培养基进行优化。首先在单因素实验的基础上采用Plackett—Burrnan设计法对影响ME—UD-3-4发酵产2,3-丁二醇的相关因素进行研究,筛选到3种有显著效应的因素（P〈0．05）：葡萄糖、玉米浆和MgSO4·7H2O。然后利用响应曲面法（Response Surface Methodology,RSM）对这3种因素的最佳水平范围进一步探讨;对得到的回归模型进行分析,得最佳条件（g／L）：葡萄糖220、玉米浆19和MgSO4·7H2O 0．4;在最佳条件下,发酵80h,2,3-丁二醇产量从原来的57．3 g／L提高到86．1 g／L,生产强度由0．72g／（L·h）提高到1．08g/（L·h）。     

糠醛和5-羟甲基糠醛对大肠杆菌产丁二酸的影响

利用可再生生物质特别是木质纤维素水解液来生产平台化合物丁二酸,是目前研究的热点。虽然许多研究者相继报道了木质纤维素水解液对菌株生长和丁二酸生产存在一定抑制作用,但并没有水解液中各种抑制物对菌株影响的相关动力学研究及机理研究。我们选择了两种代表性木质纤维素水解液抑制物,即糠醛和5-羟甲基糠醛,系统研究了它们对大肠杆菌的生长和丁二酸生产的影响。结果表明：糠醛和5-羟甲基糠醛的初始抑制浓度均为0.8 g/L。当糠醛浓度大于6.4 g/L,5-羟甲基糠醛浓度大于12.8 g/L时,菌株生长完全受到抑制。在最高耐受浓度下,糠醛的存在使菌株生物量比对照菌株下降77.8%,丁二酸产量下降36.1%。5-羟甲基糠醛的存在使菌株生物量比对照菌株降低13.6%,丁二酸产量降低18.3%。糠醛和5-羟甲基糠醛具有明显的协同作用。体外酶活测定表明丁二酸生产途径中关键酶磷酸烯醇式丙酮酸羧化酶、苹果酸脱氢酶、富马酸还原酶均受糠醛和5-羟甲基糠醛抑制。研究结果对丁二酸生产用纤维素水解液的预处理和脱毒工艺开发具有指导作用,有利于实现丁二酸发酵生产的工业化。     

成果期女贞子炮制后5-羟甲基糠醛的含量变化

目的:测定不同生长期女贞子酒炖前后5-羟甲基糠醛的含量.方法:采收8～l2月产女贞子,依据《中华人民共和国药典》(2010年版)中的方法进行炮制.采用Inertsil ODS-3 C18色谱柱(4.6 mm x 250mm,5 μm),色谱条件为流动相乙腈-水(10∶90),检测波长285 nm,流速为1mL?min-1,柱温为室温.结果:生女贞子中5-羟甲基糠醛的含量在幼果中(8月)最高,而酒炖后5-羟甲基糠醛的含量增加12.50～45.95倍.结论:为更有效利用女贞子中的5-羟甲基糠醛,可根据实际需要适时采收并加以炮制.     

成果期女贞子炮制后5-羟甲基糠醛的含量变化

目的:测定不同生长期女贞子酒炖前后5-羟甲基糠醛的含量。方法:采收8～12月产女贞子,依据《中华人民共和国药典》(2010年版)中的方法进行炮制。采用Inertsil ODS-3 C18色谱柱(4.6 mm×250 mm,5μm),色谱条件为流动相乙腈-水(10:90),检测波长285 nm,流速为1 mL.min-1,柱温为室温。结果:生女贞子中5-羟甲基糠醛的含量在幼果中(8月)最高,而酒炖后5-羟甲基糠醛的含量增加12.50～45.95倍。结论:为更有效利用女贞子中的5-羟甲基糠醛,可根据实际需要适时采收并加以炮制。     

产酸克雷伯氏菌耐氧产氢及其可溶性氢酶耐氧特性研究

目的：考察产酸克雷伯氏菌（KZebsielaloxytocaHPl）耐氧产氢特性及其可溶性氢酶的氧耐受特性。方法：研究K．oxytocctHPl在不同气相氧浓度条件下利用葡萄糖（1％,m/v）、丙酮酸钠（0．5％,m／v）及甲酸（0．1％,v／v）等底物产氢活性的以及K．oxyto-07,HPl可溶性氢酶在空气及氧饱和溶液中催化产氢活性。结果：K．oxytocaHP1在葡萄糖（1％,m/v）底物中具有较高耐氧产氢活性,6h内在气相氧浓度为5％、10％和21％条件下的氢产量分别为厌氧条件下的20．9％、13．7％、8．3％;K．oxytoca HP1可溶性氢酶在空气中孵育12h后,其活性残余85．4％,在氧饱和溶液中活性损失一半约3h。结论：试验结果提示K．oxytoca HP1具有耐氧产氢特性,其可溶性氢酶具有较高氧耐受性,在氢能源的开发中具有潜在的应用前景。     

Effect of succinic acid on 2,3-butanediol production by Klebsiella oxytoca

Summary The effect of succinic acid on the growth of Klebsiella oxytoca and its production of 2,3-butanediol was studied. Increasing succinic acid from 0 g/L to 30 g/L increased the final butanediol concentration. The maximum butanediol productivity occurred at an initial succinic acid concentration of approximately 10 g/L.     

Mixed inhibitions by methanol, furfural and acetic acid on xylitol production by Candida guilliermondii

Xylose production by Candida guilliermondii FTI 20037 was carried out in a synthetic medium in the presence of 0–100 g methanol l^–1, 0–0.7 g furfural l^–1 or 0–1.3 g acetic acid l^–1. Kinetic results show a mixed inhibition mechanism in all three cases. Maximum specific productivity and saturation constant for product formation were, in the absence of inhibition, 3.6 g_P g_X ^–1 h^–1 and 232 g_S l^–1, respectively, while the inhibition constants, K _i and K _i, were 17 and 50 g methanol l^–1, 0.62 and 7.0 g furfural l^–1, 0.69 and 3.5 g acetic acid l^–1, which suggests the following order of inhibition: furfural > acetic acid > methanol.     

Optimization of 2,3-butanediol production by Klebsiella oxytoca through oxygen transfer rate control

Production of 2,3-butanediol by Klebsiella oxytoca is influenced by the degree of oxygen limitation. During batch culture studies, two phases of growth are observed: energy-coupled growth, during which cell growth and oxygen supply are coupled; and, energy-uncoupled growth, which arises when the degree of oxygen limitation reaches a critical value. Optimal 2,3-butanediol productivity occurs during the energy-coupled growth phase. In this article, a control system which maintains the batch culture at a constant level of oxygen limitation in the energy-coupled growth regime has been designed. Control, which involves feedback control on the oxygen transfer coefficient, is achieved by continually increasing the partial pressure of oxygen in the feed gas, which in turn continually increases the oxygen transfer rate. Control has resulted in a balanced state of growth, a repression of ethanol formation, and an increase in 2,3-butanediol productivity of 18%. (c) 1993 John Wiley & Sons, Inc.     

Involvement of a plasmid in exopolysaccharide production by Klebsiella oxytoca

A Klebsiella oxytoca isolate which can produce significant levels of an exopolysaccharide using whey as a growth substrate has been reported. The plasmid profile of this isolate was shown to be different from that of the non-exopolysaccharide-producing K. oxytoca ATCC 43863. Irreversible curing of the single plasmid in the K. oxytoca isolate was achieved using 30 g acriflavin/ml. The ability to produce the exopolysaccharide was lost with the curing of the plasmid (parent strain produced a medium viscosity of 1260 cP at 1 s^–1 compared to 1.6 cP at 200 s^–1 produced by the cured strain). However, the ability to metabolize lactose was not significantly affected by curing, and both the parent and the cured strain produced similar levels of viable cells (~10⁹ cfu/ml) after 62 h growth on lactose-rich medium. The exopolysaccharide-producing ability of the isolate was stable for at least 139 generations.     

Fermentation of maltose and starch by Klebsiella oxytoca P2

Klebsiella oxytoca P2, which has genes from Zymomonas mobilis encoding the alcohol dehydrogenase and pyruvate decarboxylase integrated in its chromosome, fermented 50 g maltose/l to 25.4 g of ethanol/l. It also fermented 10, 20 and 40 g starch/l yielding 4, 8.4, and 17.7 g ethanol/l, respectively, representing 72, 75 and 78% of the theoretical yield. © Rapid Science Ltd. 1998