HPLC and SFC enantioseparation of (±)‐Corey lactone diol: Impact of the amylose tris‐(3,5‐dimethylphenylcarbamate) coating amount on chiral preparation

As an important intermediate of prostaglandins and entecavir, optically pure Corey lactone diol (CLD) has great value in the pharmaceutical industry. In this work, the enantioseparation of (±)‐CLD was evaluated using high‐performance liquid (HPLC) and supercritical fluid chromatography (SFC). In HPLC, the separations of CLD enantiomers on polysaccharide‐based chiral stationary phases with both normal phase and polar organic phase were screened. And the conditions for the enantioseparation were optimized in HPLC and SFC, including the selection of mobile phase, temperature, back‐pressure, and other conditions. More important, it was found that the chiral resolutions were greatly enhanced by the increase of the coating amount of ADMPC (amylose tris‐(3,5‐dimethylphenylcarbamate)) under both HPLC and SFC conditions, which can lead to the increase of the productivity and the decrease of the solvent consumption. The preparations of optically pure CLD were evaluated on a semi‐preparative (2 × 25 cm) column packed with 30% ADMPC‐coated CSP under HPLC and SFC conditions. Preparative performances in terms of kkd are 1.536 kg racemate/kg CSP/day and 1.248 kg racemate/kg CSP/day in HPLC and SFC, respectively.     

Use of a naphthylethylcarbamoylated-β-cyclodextrin chiral stationary phase for the separation of drug enantiomers and related compounds by sub- and supercritical fluid chromatography

Enantiomeric separation of a variety of drugs and related compounds was achieved on an (S)-naphthylethylcarbamoylated-β-cyclodextrin (S-NEC-CD) chiral stationary phase (CSP) using sub- and supercritical fluid chromatography (SFC). Compounds previously resolved on native or derivatized cyclodextrin CSPs in liquid chromatography (LC) using reversed phase or polar organic mobile phase modes could be resolved in SFC using a simple carbon dioxide/methanol eluent. Resolution of cromakalim, which is not possible on the S-NEC-CD column in LC, was readily accomplished in SFC. The importance of modifier, temperature, and pressure was assessed in relation to retention, selectivity, and resolution. The nature of the modifier and the modifier concentration were found to be crucial parameters. © 1996 Wiley-Liss, Inc. Contribution of the National Institute of Standards and Technology. Not subject to copyright.     

Evaluation of a ristocetin bonded stationary phase for subcritical fluid chromatography of enantiomers

A stationary phase derived from ristocetin was evaluated for chiral separation in subcritical fluid chromatography. Separation of various enantiomers having different structures and pK(a) values were investigated using carbon dioxide and polar modifiers. The influence of modifiers, additives, temperature, and mobile phase flow rate on separations is presented. It is concluded that this stationary phase can be used for SFC despite its structural similarity with protein-derived stationary phases that can only be used in HPLC. The separation mechanisms could not be elucidated or predicted using these initial experiments. The separations of warfarin and, especially, efavirenz demonstrate the potential of this type of stationary phase for rapid SFC chiral separations.     

Simulated moving bed chromatography with supercritical fluids for the resolution of bi-naphthol enantiomers and phytol isomers

The combination of the simulated moving bed (SMB) technique with supercritical fluid chromatography (SFC) leads to a process with unique features. Besides the known advantages of the SMB process, the use of supercritical carbon dioxide as the mobile phase offers the advantages of reduction in organic solvents and an easy eluent/solute separation. Because of the low viscosity and high diffusion coefficients of supercritical fluids, a high efficiency is possible. The steps of process development for SMB SFC are presented using the separations of the bi-naphthol enantiomers and phytol isomers as examples. The development of a packed column SFC method at an analytical scale is shown for the separation of the bi-naphthol enantiomers on a chiral stationary phase and CO(2) with a modifier as the mobile phase. The influence of the modifier, modifier content, and column configuration on productivity of the SMB SFC process was investigated by simulation. The first set of experiments was performed in the SMB separation of phytol isomers at low concentration to test the feasibility of the SMB SFC high purity separation of the binary mixtures. In the second set of experiments, the productivity of the process was increased by increasing the feed concentration up to 54 grams feed per liter stationary phase (SP) and hour (g(feed)/l(SP) h).     

Analysis and purification of alcohol-sensitive chiral compounds using 2,2,2-trifluoroethanol as a modifier in supercritical fluid chromatography

2,2,2-Trifluoroethanol (TFE) is evaluated as an alternative modifier for the analysis and purification of alcohol-sensitive chiral compounds using supercritical fluid chromatography (SFC). Four chiral compounds, selected for their sensitivity to alcohols, in addition to a variety of standard chiral compounds were analyzed by SFC using TFE with polysaccharide and Pirkle-type chiral stationary phases (CSPs) to produce selectivities (alpha) and resolutions (Rs) as high as 1.4 and 7.2. A preparative isolation of 2-phenylglutaric anhydride was achieved using TFE as the mobile phase modifier to produce clean enantiomers.     

Use of cellulose-based stationary phases for chiral separation in open tubular column chromatography

Application of cellulose-based chiral stationary phases was extended to open tubular columns. These chiral materials were mixed with achiral matrix stationary phases. Compromises were found among the polarity and the ratio of achiral matrix polymers against the content of the chiral cellulose derivative in order to optimize the resolution of the investigated racemates. In GC, the high efficiency feature of open tubular columns allows fast analysis, however, compounds which express strong H-bond interaction with cellulose derivatives elute with a bad peak shape. The application of these stationary phases for open tubular SFC was more successful, because the solvation power of the mobile phase can compensate the strong interaction between the solute and the cellulose derivative. Immobilization of the stationary phases were achieved for SFC purposes. © 1992 Wiley-Liss, Inc.     

Polar organic phase liquid chromatography with packed capillary columns using a vancomycin chiral stationary phase

Vancomycin immobilized on silica served as the chiral stationary phase (CSP) in this investigation with polar organic solvents as the mobile phase in liquid chromatography (LC). It was shown that trace amounts of water were beneficial for improving peak shape and efficiency. To regulate the retention and selectivity an acid and/or base were added to the mobile phase where an excess of acid was shown to be preferential for enantioseparation. An unusual increase in selectivity with increasing temperature was shown for the acidic drug, thalidomide. Additionally, nonlinear van't Hoff plots were obtained for metoprolol enantiomers that showed increased retention with increasing temperature. Metoprolol also showed unusual behavior in the polar organic phase when water was added to resemble reversed-phase chromatography, with minimum retention observed at high water or high methanol concentrations. In both instances a high degree of electrostatic interaction between metoprolol and vancomycin was concluded. Metoprolol and ten of its analogs were examined on this CSP to evaluate the enantiorecognition process. A comparison in enantioselectivity for a number of acidic and basic drugs using this CSP was also carried out using the polar organic phase, reversed phase, and normal phase LC which were all compared to the results obtained in supercritical fluid chromatography (SFC). Polar organic phase LC offered a better separation of basic molecules while reversed phase LC was preferred for the resolution of acids. SFC showed the broadest enantioselectivity overall and normal phase LC indicated similar properties, as expected, to SFC but with lower column efficiency. Copyright 2000 Wiley-Liss, Inc.     

Use of a new pirkle-type chiral stationary phase in analytical and preparative subcritical fluid chromatography of pharmaceutical compounds

Good results have been obtained with use of the new bonded chiral stationary phase Whelk-O 1 in analytical and preparative subcritical fluid chromatography. A wide variety of enantiomeric pairs of compounds with different functional groups that are of pharmaceutical and biological interest have been resolved. This Pirkle-concept CSP appears to be more rugged than cellulosic phases (e.g., Chiralcel) with regards to solvents and pressure. In comparing the usefulness of the column for SFC versus HPLC chiral analysis, we have observed a clear superiority of SFC in terms of higher speed and efficiency of analysis, and faster method development. This is consistent with our experience with Chiralcel CSPs. With the Whelk-O 1 we have shown that the effects of temperature and modifier on SFC separations are similar to what has been reported for most other CSPs. We also observed a unique selectivity advantage of SFC for verapamil. We had good success with using a 1-in. diameter column packed with Whelk-O 1 to perform preparative SFC separations of a number of enantiomeric mixtures. The advantages of preparative SFC over preparative HPLC will be discussed. The feasibility of preparative SFC is dependent on how well we meet the practical challenges such as sample introduction issues, special hardware requirements due to the high pressure, and fraction collection issues. © 1994 Wiley-Liss, Inc.     

Mobile phase effects on enantiomer resolution using molecularly imprinted polymers

The aim of this study was to rationalise retention behaviour of a chiral solute on molecularly imprinted polymer (MIP) HPLC stationary phases in terms of variation of the mobile phase. It is generally held that the most important interaction governing the separation of enantiomers on such materials is H-bonding, and that retention times increase with decreasing H-bonding potential of the mobile phase. Previous studies have largely concerned mobile phases containing chloroform with acetic acid as a polar modifier. Boc-L-Phenylalanine (Boc-L-Phe-OH) MIPs were prepared, processed, and packed into HPLC columns, which were then used to investigate the retention characteristics of Boc-L-Phe-OH and Boc-D-Phe-OH with a range of mobile phases. The main observations were as follows: (1) in chloroform-based mobile phases there was generally a linear relationship between the H-bond donator factor of the polar modifier and capacity (K′). Results also indicated a hydrogen bond donor parameter value for a polar modifier at which retention became concentration independent; (2) For given values of K′_L, K′_D varied depending on the polar modifier, indicating that enantiomer resolution was solvent dependent; (3) Using mobile phases based on solvents of lower polarity/H-bonding potential than chloroform, substantial increases in K′ were observed, although enantioselectivity was greatly reduced. Chirality 9:238–242, 1997. © 1997 Wiley-Liss, Inc.     

Separation of vitamins by supercritical fluid chromatography with water-modified carbon dioxide as the mobile phase

Supercritical fluid chromatography (SFC) has become a technique for solving problems that are difficult to be monitored by other chromatographic methods. However, the most widely used fluid, is no more polar than hexane. Polar samples which are difficult to be analyzed with pure supercritical CO(2) because of their high polarity can be separated by adding polar modifiers to supercritical CO(2). In this paper various vitamins were well separated using water-modified supercritical CO(2) fluid. The amount of water dissolved in supercritical CO(2) was measured using an amperometric microsensor made of a thin film of perfluorosulfonate ionomer (PFSI).     

Chiral separations in polar organic solvent chromatography: updating a screening strategy with new chlorine-containing polysaccharide-based selectors

The screening conditions of an existing column and mobile phase selection strategy for chiral drug substances in polar organic solvent liquid chromatography (POSC) were tested for their applicability on two new chlorine-containing polysaccharide-based stationary phases. The selectors of these phases are cellulose tris(3-chloro-4-methylphenylcarbamate) and amylose tris(5-chloro-2-methylphenylcarbamate). The enantioselectivity of these phases is compared to that of the four phases (Chiralpak AD-RH, Chiralcel OD-RH, Chiralpak AS-RH and Chiralcel OJ-RH) used in the earlier defined strategy. A test set of 62 structurally diverse chiral drug substances is analyzed using the screening conditions of the strategy on the six phases. The results confirm that the acetonitrile-based mobile phase provides a higher success rate and better resolutions than the methanol-based also on the new phases. However, the importance of the methanol-based mobile phase cannot be neglected for complementarity reasons; the two mobile phases insure enantioselectivity for different compounds. A third (ethanol-based) mobile phase, not part of the strategy, was also used to screen the two new phases. The joint results led to different possibilities to upgrade the current screening strategy so that improved success rates are obtained. The chlorine-containing chiral stationary phases demonstrated to have an added value to the screening process since they provided enantioresolution for compounds not resolved by non-chlorine-containing ones.     

Enantiomeric separation of mineralocorticoid receptor (hMR) antagonists using the Chiralcel OJ-H HPLC column with novel polar cosolvent eluent systems

This study demonstrates the increased versatility of the Chiralcel OJ-H stationary phase when using various alcohol/acetonitrile mobile phases. This chiral stationary phase has traditionally been employed in the normal phase mode and more recently with neat alcohols as eluents. Selected isomeric human mineralocorticoid receptor (hMR) antagonist pharmaceutical candidates and synthetic intermediates were separated using the Chiralcel OJ-H HPLC column with novel polar cosolvent eluent systems. The capacity factors, resolution, and selectivity of the chiral separations were assessed while varying the alcohol/acetonitrile composition and alcohol identity. The mixed polar eluents provide separations that are nearly always superior to both the traditional hexane-rich and single-alcohol "polar organic" eluents for the compounds tested in this article.     

基于高速逆流色谱的大极性海参多肽分离方法研究

本文通过对HEMWat溶剂体系中28种常用溶剂系统单相以及整体极性进行系统分析,探讨了无法用常规J型逆流色谱实现对大极性化合物实现有效分离的原因。根据分析结果建立了一种以分离物质理化性质为基础选择潜在改性剂,样品在溶剂系统上相中的溶解程度为判断指标进行筛选逆流色谱溶剂系统改性剂,进而得到适宜的溶剂系统对大极性海参多肽样品进行系统分段方法。经过两步分离,共得到8个随极性分布的海参多肽片段,为海参多肽最佳活性物质的追踪和筛选提供了技术支持。     

Enantioseparation of chiral perfluorooctane sulfonate (PFOS) by supercritical fluid chromatography (SFC): Effects of the chromatographic conditions and separation mechanism

Perfluorooctane sulfonate (PFOS) is one of the most frequently detected perfluoroalkyl substances in environmental and human samples. Previous studies have shown that nonracemic PFOS in biological samples can be used as a marker of PFOS exposure sources. In recent years, supercritical fluid chromatography (SFC) has emerged as a powerful method to separate chiral compounds. In this study, a method of perfluoro‐1‐methylheptane sulfonate (1 m‐PFOS) enantioseparation by SFC was established. The optimal separation was obtained using a Chiralpak QN‐AX column with CO₂/2‐propanol (70/30, v/v) as the mobile phase with a flow rate of 1 mL/min, column temperature was 32°C, and BPR pressure was 1800 psi. The resolution (Rs) and retention time were 0.88 and 130 minutes, respectively. This method is more economic and greener than HPLC. Modifier pH and column temperature were determined to be significant factors of SFC chiral separation. Modifier pH is negatively correlated with the retention factors and Rs. Adsorption thermodynamics were used to explain the influence of temperature change, and it was concluded that the transfer of two enantiomers from the mobile phase to the stationary phase is enthalpy‐driven. Enantioseparation of 1 m‐PFOS by SFC follows the same rules of ion exchange as those for the chiral separation by HPLC.     

Automated extraction and HPLC resolution of lipoxygenase and cyclooxygenase products utilizing high pressure column switching

An automatable column switching technique for extraction of cyclooxygenase and lipoxygenase products has been developed. The extraction column is a 0.4 cm X 3 cm stainless steel column slurry packed with Polygosil (C18, 25-40 mu particle diameter). Supernatants of incubations terminated by the addition of 1 volume MeOH, bath sonicated and centrifuged were pumped onto the extraction column. The non-adherent polar material was eluted to waste with up to five times the sample volume with a high polarity mobile phase. Following this, the extraction column was then eluted to an analytical column with a mobile phase of decreased polarity.     

A comparison of LC and SFC for cellulose- and amylose-derived chiral stationary phases

This paper presents a systematic comparison of liquid chromatography (LC) and supercritical fluid chromatography (SFC) for Chiralcel OD and Chiralpak AD chiral stationary phases (CSPs), performed using various chiral compounds having a known or potential pharmaceutical activity. The chiral recognition mechanisms involved in LC and SFC for the enantiomeric separation of β-blockers have been studied more particularly. As a general rule, it appears that the presence of polar functions, like primary or secondary hydroxyl or amine functions, may result in marked discrepancies in selectivity between LC and SFC. This result is peculiar to cellulose- and amylose-derived CSPs, for which the interactions involved in chiral recognition mechanism are not always well balanced, contrary to what happens for independent CSPs. In the case of chiral resolution of polar solutes or polymer-type CSPs, the analyst should try both the LC and SFC techniques to be able to choose the more stereoselective one. © 1995 Wiley-Liss, Inc.     

Supercritical fluid chromatography comparison of the poly(trans-1,2-cyclohexanediyl-bis acrylamide) (P-CAP) column with several derivatized polysaccharide-based stationary phases

The poly(trans-1,2-cyclohexanediyl-bis acrylamide) (P-CAP) column has so far been primarily used with normal phase and polar organic mobile phase chromatography. Its use in supercritical fluid chromatography (SFC) was investigated via the analysis of 40 commercial and 100 proprietary compounds using a 12-min gradient with methanol as a modifier. Results were then compared against those obtained from the popular derivatized polysaccharide-based chiral stationary phases (CSPs) such as Chiralpak AD-H and Chiralpak AS-H as well as Chiralcel OD-H and Chiralcel OJ-H columns. P-CAP demonstrated separation of 25% of the 140 total compounds, while each of the derivatized polysaccharide-based CSPs separated at least 46%. A study that compared the loading of 1,1'-bi-2-naphthol with P-CAP and Chiralpak AS columns indicated a similar trend in resolution vs. amount injected, though AS appeared capable of allowing a greater loading of material. The P-CAP column was found to be beneficial in the separation of a complex mixture of enantiomers and achiral impurities, where the derivatized polysaccharide-based columns did not show as desirable of a separation. A key advantage of this type of chiral stationary phase is the fact that it is available in both enantiomeric forms, allowing manipulation of elution order of enantiomers, which is especially helpful for preparative applications. P-CAP also demonstrated that it could resolve an achiral impurity from the desired compound in a different mixture, while the same impurity co-eluted on the Chiralpak AD-H column. Overall, the synthetic polymer-based P-CAP showed less chiral discrimination power compared to the derivatized polysaccharide-based CSPs under the conditions explored in this study.     

Effects of Hexane in Supercritical Fluid Chromatography for the Separation of Enantiomers

Supercritical fluid chromatography (SFC), operated in conventional mode, is normally recognized as normal phase chromatography, and uses a solvent combination of supercritical CO₂ and alcohols to separate compounds. Hexane, a commonly used solvent in normal phase liquid chromatography (NP‐LC), is rarely used in SFC and, in some cases, is added to the organic modifiers to increase liquid content in order to achieve better efficiency in preparative SFC for poorly retained compounds. Although hexane is believed to have similar solvent strength to that of supercritical CO₂, its effects on the enantioseparation in SFC is largely unknown. To understand the chromatographic effects of an apolar solvent, such as hexane in SFC, we compared the chromatographic behaviors of 35 chiral compounds using a parallel SFC method under traditional SFC mode of only “pure” alcohol‐CO₂ to that of hexane‐assisted SFC (HA‐SFC), which uses mixtures of alcohol and hexane (as cosolvents) and CO₂. We observed that, in some cases, hexane behaves just like supercritical CO₂, where replacement of a portion of CO₂ with hexane does not significantly change retention times or resolution of the peaks. In many cases, however, addition of hexane in mobile phases does affect chromatographic behavior of one or both enantiomers. Such effects might provide opportunities for separation of some enantiomers. Chirality 28:192–198, 2016. © 2016 Wiley Periodicals, Inc.     

Enantiomeric separation of mirtazapine and its metabolite in rat plasma by reverse polar ionic liquid chromatography using fluorescence and polarimetric detectors connected in series

A simple and rapid reverse polar ionic LC method was developed and validated for simultaneous separation and determination of mirtazapine, an antidepressant drug, and its main metabolite N-desmethyl mirtazapine using fluorescence and polarimetric detectors connected in series. The chromatographic separation was achieved on Chirobiotic V column packed with vancomycin as a stationary phase in an isocratic mode of elution of methanol:glacial acetic acid:anhydrous triethyl amine (100:0.2:0.1, v/v/v) as a mobile phase. The compounds were detected by their excitation at 290nm and emission at 370nm using fluorescence detector while the optical rotation (+/-) of the enantiomers was identified by polarimetric detector. The analytes were extracted from rat plasma by precipitation of proteins and the average yield was 88-111% for mirtazapine and 85-123% for N-desmethyl mirtazapine. The method was linear over the concentration range of 20-5000ng/mL. The method was successfully applied on rat plasma spiked with the enantiomers of mirtazapine and N-desmethyl mirtazapine.     

Use of chiral β-lactones for the synthesis of chiral LC phases

Chiral β-lactones offer an easy and economic approach to novel chiral R- or S-configurated LC phases. The preferred method for their preparation is based on conventional ready-to-use aminopropyl-functionalized silicas, e.g., aminopropyl HPLC columns. The new stationary phases can be used for analytical and preparative separations and are particularly suitable for the resolution of rotatory and heterocyclic stereoisomers. Applications in the LC, SFC, and TLC mode are possible, including the use of β-lactone-based mobile phase additives in a “push–pull” combination. A large variety of organic solvents can be used as eluents. © 1993 Wiley-Liss, Inc.