Production and storage of Rhizobium leguminosarum cell concentrates for use as inoculants

Recovery of Rhizobium leguminosarum cells by centrifugation after growth in an industrial fermenter was 100-fold higher when cells were grown on yeast extract (5 g/1) as sole source of carbon and nitrogen when compared with the yields recovered when cells were grown in standard mannitol-yeast extract medium. Methods of storing concentrated suspensions of R. leguminosarum were investigated. Freeze-drying caused a marked decrease in viable cell numbers. Viable cell numbers of bacterial concentrates stored in peat decreased steadily from 10₁₁-10₁₂ cfu/g to 10₉ cfu/g or less during 26 weeks storage at room temperature or at 4°C. Cell concentrates stored in 40% glycerol at — 20°C maintained viable numbers higher than 10₁₁ cfu/ml during a 76 week storage period.     

The Survival of Starter Organisms in Concentrated Suspensions

S ummary : Two representative lactic acid bacteria were grown in a rich organic medium, the cells were harvested by centrifugation, and the organisms were suspended in skimmilk at concentrations of 25–55 × 10⁹/ml. The pH was adjusted to different values and the suspensions were stored, with and without the addition of 20% (v/v) glycerol, at 4° and - 20°.
Both organisms survived better at pH 7°0 than at pH 5°0. Glycerol protected the cells at the lower pH value but offered no benefit at neutrality. At 4° about half the cells died within 5 or 6 weeks. At - 20°, however, there was no appreciable loss of viability or acid producing ability up to 9 months at pH 7°0. Suspensions stored for 9 months at - 20° produced excellent cultured buttermilk within the normal incubation period from an inoculum comparable to that used for a fresh culture. Cells harvested early in the maximum stationary phase of the growth cycle were more active than older cells, and they survived better than older cells during storage in the frozen state.     

ESTABLISHMENT AND SOME CHARACTERISTICS OF A CONTINUOUS CELL LINE DERIVED FROM FAT BODYS OF THE CABBAGE ARMYWORM (LEPIDOPTERA, NOCTUIDAE)

Fat bodies from fully grown larvae of the cabbage armyworm, Mamestra brassicae , were cultivated in a synthetic medium, MGM–431. Small free cells migrated out and multiplied rapidly. The first cell passage was done after culture for 26 days, and 100 passages were performed in the following 9 months. The established cell line was designated as NIAS–MaBr–85. The cell population is morphologically heterogeneous, but most of the cells are hexaploid with 180 microchromosomes. The cells could be stored for 3 months at 5°C, or for longer when frozen at -80°C in medium containing 10% glycerol. Qualitatively the cell line requires few amino acids: only cystine, histidine, isoleucine, methionine and threonine are essential as determined by omission of individual amino acids. The cells are susceptible to Chilo iridescent virus and Autographa californica nuclear polyhedrosis virus. This cell line can grow in serum-free M-M medium.     

Progression throughout All Stages of Meiosis from the Early Prophase of Newt Primary Spermatocytes in vitro

Stages of prophase of living primary spermatocytes were determined by use of Rose culture chambers (1). Dissociated primary spermatocytes were cultured at low cell-density in a collagen matrix at 22°C or 27°C and the percentages of cells which had progressed from various stages in prophase through meiosis to various advanced stages were measured. In a standard medium (Leibovitz-15 + 10% fetal bovine serum), more than 70% of the primary spermatocytes at stages beyond the pachytene stage could advance to round spermatids with flagella within a few days at 22°C. The percentages of cells that progressed from stages before the late zygotene stage were less, but at least 13 % of leptotene cells reached metaphase I within a week at 22°C. The percentage of cells that progressed was slightly lower at 27°C than at 22°C: 6.3 and 4.3 days were required for progress from leptotene to metaphase I at 22°C and 27C, respectively. Fetal bovine serum was not indispensable for progression through meiosis. Moreover, 0.5–5.0 μg/ml ovine follicle stimulating hormone (NIAMDD-o-FSH-13), 0.01–1.0 μg/ml 5α-dihydrotestosterone and 1.0 μg/ml testosterone propionate had no significant effect in increasing the percentage of cell progression at 22°C.     

Cellulase production and activity by Trichoderma sp. A-001

Trichoderma species A-001 was grown on various carbon and nitrogen sources supplemented with surfactants on shake cultures. Although the degree of growth was variable, the organism grew on all carbon substrates. Large amounts of the cellulase enzyme components were released into the growth medium during growth on filter paper. In the filter paper containing medium, the organism produced 167 U/ml of carboxymethylcellulase (CMCase), 18 U/ml of filter paper activity (FPase) and 49 U/ml of beta-glucosidase activity (BGDase). Wheat straw and grass were better carbon sources than cotton or barley husks. Nitrogen in the form of KNO₃ was better than NH₄Cl or urea in facilitating the production of cellulase. Of the surfactants used, Tween-80 at 0.2% concentration in the medium increased the production of cellulase several-fold. All the cellulase components were optimally active in the assay at pH 5.5 and 60°C. CMCase and FPase lost 20–33% of their activities when kept at 60°C for 4 h before assaying. On the other hand, BGDase was moderately stable; it lost only 37% of its activity when maintained at 70°C for 4 h.     

Interactive effects of solutes, potassium sorbate and incubation temperature on growth, heat resistance and tolerance to freezing of Zygosaccharomyces rouxii

The interactive effects of solutes, potassium sorbate and incubation temperature on growth, heat resistance and tolerance to freezing of Zygosaccharomyces rouxii were investigated. Growth rates in media supplemented with glucose, sucrose or NaCl to a _w 0.93 were more rapid than in unsupplemented media ( a _w 0.99). Although growth in unsupplemented medium was lower at 35°C, incubation at 21°C or 35°C had little effect on growth in media supplemented with glucose and sucrose. The addition of 300 μg potassium sorbate/ml to media resulted in reduced growth rates, particularly at 35°C. Heat resistance of Z. rouxii was substantially greater in cultures previously incubated at 35°C than in cultures incubated at 21° in media both with and without 300 μg potassium sorbate/ml. Zygosaccharomyces rouxii was tolerant to freezing at - 18°C for up to 120 d in all test media supplemented with glucose, sucrose or NaCl. The addition of 300 μg potassium sorbate/ml to sucrose-supplemented media resulted in increased resistance to freezing in cultures previously incubated at 21°C. Sensitivity to freezing increased when cultures were incubated at 21°C in media not supplemented with solutes. Glucose and sucrose provided the best protection against inactivation by heating and freezing, regardless of the presence of potassium sorbate in growth media.     

High temperature causes arrest of cell cycle in G2 phase in BmN cells derived from the silkworm, Bombyx mori

Abstract.  The influence of temperature on the insect cell line, BmN, derived from the silkworm, Bombyx mori is investigated. These cells proliferate at an accelerated pace as the temperature increases from 22 to 30 °C, but the growth rate slows at 34 °C, and proliferation stops at 38 °C. At high temperatures, abnormal cellular morphology is observed. Cells treated at 38 °C have cytoplasmic bilateral protrusions and they gradually aggregate and float in the medium. BmN cells without proliferation at 38 °C are viable but have reduced DNA synthesis. At high temperatures, the cell cycle of BmN cells halts at the G₂ phase. After heat treatment of the larvae, an accumulation of larval haemocytes with high DNA content is found, which suggests that the cell cycle arrest at G₂ also occurs in the silkworm at high temperatures.     

Effect of temperature in the regulation of DNA synthesis in synchronous cultures of Chlorella

The influence of temperature on DNA replication of Chlorella pyrenoidosa grown at 30 °C was studied in synchronous cultures. Final DNA content and cell counts/ml were 30 to 40% less than controls after a 4 h exposure to 15 °C, but reached normal levels after being kept temporarily at 10 °C. The rates of DNA synthesis at these two temperatures were, respectively, one-sixth and one-tenth of the rate at 30 °C, but during the 15 °C treatment the cells lost the ability to enter a further replication cycle more rapidly than at 10 °C. This loss of capacity to initiate further replication cycles was prevented by inhibiting protein synthesis with cycloheximide.     

Characterization of a reptilian epithelioid skin cell line derived from the green sea turtle,Chelonia mydas

Summary A continuous line of epithelioid cells was established from explant skin tissues of the green sea turtle,Chelonia mydas. These cells, designated GTS, have been subcultured more than 60 times in commercially available mammalian cell culture medium supplemented with 5% bovine calf serum. Of those temperatures tested, optimal growth was achieved at 30°C although replication occurred between 16 and 37°C. These cells may be held as monolayers at 8°C or stored frozen in growth medium containing 10% dimethylsulfoxide at −70 or −196°C. The modal number of 55 chromosomes per cell is in agreement with the heterogametic female diploid number of this species. The GTS line represents the first established culture of normal epithelioid skin cells to be reported for a poikilothermic species.     

Thermophilic bacterial isolates producing lipase

Abstract A number of lipase-producing thermophilic bacteria were isolated from natural habitats. One isolate, obtained from a coal tip sample, was examined in some detail: it was a highly thermophilic Bacillus sp. (optimum growth temperature approx. 65°C) and at 55°C it produced the maximum level of lipase (about 4 U/ml) in a medium containing Tween-80 (polyoxyethylene sorbitan monooleate) as the principal carbon source when growth had virtually ceased. Lipase synthesis thus appears to be inducible, and since a very low level of lipase was observed when the isolate was grown in a medium containing a carbon source like glucose as well as Tween-80, lipase synthesis is apparently also subject to catabolite repression.     

Basic studies on gene therapy of human malignant melanoma by use of the human interferon beta gene entrapped in cationic multilamellar liposomes. 1. Morphology and growth rate of six melanoma cell lines used in transfection experiments with the human interferon beta gene

Six cell lines of human malignant melanoma: A375, A375.2, G361, HMV-1, MM8.1 and WM115 were seeded at densities of 1 × 10⁴ cells/ml, 2 × 10⁴ cells/ml or 3 × 10⁴ cells/ml of RPMI medium supplemented with 10% fetal calf serum and antibiotics in a humidified atmosfere of 5% CO₂ at 37°C. A375 cells were also grown in Dulbecco's minimum Eagle's medium (DMEM medium). The morphology was studied by phase contrast light microscopy. At 4 days after seeding the colonies of A375 cells and HMV-1 cells were oval-shaped, the cells were polyhedrical and were making contact with each other regularly. The remaining cells were scattered, more elongated, and made contact randomly. G361 cells and MM8.1 cells tended to form superposed layers before 100% confluency was achieved. There were great differences in the growth rate and doubling time of melanoma cells. The doubling time in day 1 was short (around 6-12 h) in the case of A375, G361 and HMV-1 cells, longer (around 18h) in the case of MM8.1 cells and very long (ranging between 26 and 89 h) for A375.2 and WM115 cells. There were also differences in the doubling time of cells as a function of the cell density at seeding. On the other hand, except for MM8.1 cells, there were differences between the doubling time in day 2 compared to day 1.     

A comparative study of the formation of extracellular proteins by Aeromonas salmonicida at two different temperatures

Aeromonas salmonicida was grown in a supplemented 3% (w/v) tryptone soya broth medium at 10°C, a temperature at the lower end of the range over which furunculosis has been observed to occur in the field, and 25°C, the optimum temperature for growth. Similar bacterial densities in the range 2.35 × 0.05 mg dry wt/ml were achieved in the two cultures at the beginning of the stationary phase of the growth cycle, after 125 h at 10°C and 18 h at 25°C. At this point, at the higher temperature 1.5 times more exoprotein was formed, 80 × 2.8 μg/ml compared with 54 × 1.7 μg/ml. Exoprotein contained the same proportion of haemolysin at both temperatures and twice as much protease at the higher temperature. The most marked difference was in an unidentified 100 kD protein which was formed in a 10-fold greater amount at 10°C.     

Observations consistent with autocrine stimulation of hybridoma cell growth and implications for large-scale antibody production

Existence of autocrine growth factors (aGFs) may influence the serum requirement for growth of hybridoma cells and thus significantly influence process economics. For the murine hybridoma cell line S3H5/2bA2, critical inoculum density (cID) and serum requirement for growth were inversely related for cultivation in both T flasks and spinner flasks. In spinner flasks, an inoculum density of 10⁶ cells/ml was necessary for the cells to grow in RPMI 1640 medium without serum supplement, and an inoculum density of 10³ cell/ml was necessary in RPMI 1640 medium with 10% serum. In T flasks, where the local cell density is higher than in spinner flasks, an inoculum density of 10⁶ cells/ml was necessary for the cells to grow in RPMI 1640 medium without serum supplement, and an inoculum density of 1 cell/ml was also necessary in RPMI 1640 medium with 10% serum. Further, immobilized cells at high local cell density could grow under conditions where cells in T flasks at corresponding overall cell density could not grow. The cells at high inoculum density were less sensitive to shear induced by mechanical agitation than the cells at low inoculum density. Taken together these observations support the existence of secreted aGF(s) by the hybridoma cell line used. Since the specific MAb production rate was independent of cultivation method and inoculum density, the existence of autocrine growth factors would suggest that the use of immobilized cells should improve the economics of MAb production.     

Development and characterization of cell lines from heart, liver, spleen and head kidney of sea perch Lateolabrax japonicus

Five cell lines (LJHK, LJS, LJL, LJH-1 and LJH-2) were established from the head kidney, spleen, liver and heart of sea perch Lateolabrax japonicus . The cell lines LJHK, LJS, LJL, LJH-1 and LJH-2 were subcultured 46, 32, 32, 36 and 34 times in minimum essential medium (MEM) supplemented with foetal bovine serum (FBS), sea perch serum and 10 ng ml⁻¹ basic fibroblast growth factor (bFGF). Morphology of primary cultures and subcultures of the five cell lines were observed continuously by microscopy. The suitable temperature for growth was 18 to 30° C for all of these cell lines with the optimum growth at 24° C and a reduced growth rate <18° C. The optimum concentration of FBS was found to be 10% and addition of bFGF to the medium significantly increased the growth rate of the cells. The doubling time of LJS, LJH-1, LJL, LJH-2 and LJHK cells was determined to be 52·7, 54·9, 57, 58·7 and 66 h at a plating density of 1 × 10⁵ cells ml⁻¹ at 24° C, respectively. Chromosome analysis revealed that 42, 48, 38, 43 and 45% cells maintained normal diploid chromosome number (48) in the LJH-1, LJH-2, LJHK, LJL and LJS cell lines, respectively. The LJHK cells were successfully transfected with green fluorescent protein (GFP) reporter plasmids and the expression of GFP gene in the cells indicated the possible utility of the cells in gene expression studies. Furthermore, treatment of the LJHK cells with lipopolysaccharide led to increased expression of IL-1β, demonstrating that LJHK cells might be a valuable tool for studying the expression and function of immunomodulatory gene in fishes.     

Effect of Hyperbaric Carbon Dioxide Pressure on the Microbial Flora of Pork Stored at 4 or 14°C

Changes in the microbial flora of pork stored at 4 or 14°C were studied in 5 atm CO₂, 1 atm CO₂ or 1 atm air. The time needed for the total aerobic count at 4°C to reach 5 × 10⁶ organisms/cm² was about three times longer in 5 atm CO₂ than in 1 atm CO₂, and about 15 times longer in 5 atm CO₂ than in air. At 14°C there was no difference in growth rate between 5 atm CO₂ and 1 atm CO₂. No off-odour was detected after storage in 5 atm CO₂ for 14 d, but the pork in 1 atm CO₂ (6 d) was organoleptically unacceptable.
The predominant organisms on the pork from the processing line were: Flavobacterium spp., Acinetobacter calcoaceticus, Pseudomonas spp., Micrococcus spp. and Moraxella spp. After aerobic storage at 4°C (8 d) or 14°C (3 d) more than 90% of the flora consisted of Pseudomonas spp. At 4°C all Pseudomonas spp. were of the non-fluorescent type, whilst at 14°C 32% were Ps. putida and Ps. fluorescens. After storage in 1 atm CO₂ Lactobacillus spp. represented 66% of the flora at 14°C (6 d) and 100% at 4°C (40 d), with L. xylosus dominating. After storage in 5 atm CO₂ Lactobacillus spp. constituted the total flora at both temperatures with L. lactis (14°C) and L. xylosus (4°C) dominating.
It was concluded that high partial pressures of CO₂ have a considerable shelf-life prolonging effect by (i) selecting the microflora towards Lactobacillus spp. and (ii) reducing the growth rate of these Lactobacillus spp. The controlling and growth inhibitory effect of CO₂ was promoted by reduced temperatures.     

Fish cell line (ULF-23HU) derived from the fin of the central mudminnow (Umbra limi): Suitable characteristics for clastogenicity assay

Summary A cell line (ULF-23HU) from the fin of the central mudminnow (Umbra limi) was characterized and tested for its suitability to assess cytogenetic damages induced by chemicals in fish. Cells of this line exhibit a fibroblastlike appearance and grew optimal at 25°C in, TC-199 medium containing 10% fetal bovine serum, but slower growth continued down to 4°C, where they could be stored for prolonged periods. Seeding efficiency of ULF-23HU cells on the plastic substratum was approximately 85% in the above culture medium at 25°C. They had a 32-h cell cycle time taken up by a 20-h S period as determined by the autoradiographic analysis of the fraction of labeled mitosis. Cultures showed relatively high mitotic index (0.84 to 2.35%) during exponential growth phase lasting about 7 d. Karyological analysis of the cells at the different subculture passages revealed constant chromosome modal number of 23 consisting of metacentric or submetacentric chromosomes, which were primarily similar to those of in vivo cells, with one additional chromosome. The spontaneous sister chromatid exchange rate was 5.3 per metaphse. When ULF-23HU cells were exposed toN-nitroso-N-methylurea, a clastogen in the mammalian cells, dose-dependent increases both in sister chromatid exchanges and chromosome aberrations were clearly detected. These results on the growth kinetics and cytogenetic characteristics offered the high possibility of the use of this cell line as a suitable in vitro model for clastogenicity studies in fish. This work was supported by grants from Korea Sciences and Engineering Foundation and Japanese Government Research Awards for Foreign Specialists to E.-H. Park.     

Temperature effects on the viable but non-culturable state of Vibrio vulnificus

Abstract The non-culturable state of Vibrio vulnificus , strain C7184, was studied in artificial seawater microcosms held at 5, 10, 15, 20, and 30°C. Plate counts were made on a non-selective medium, total cell counts were monitored by acridine orange epifluorescence, and direct viable counts (DVSs) by the method of Kogure et al. (Can J. Microbiol. 25, 415–420; 1986) and by the INT method. From an initial inoculum of 10⁷ cells/ml, V. vulnificus became non-culturable within 40 days at 5°C, although both indicators of viability revealed a viable population exceeding 10⁶ cells/ml. Cells at all higher temperatures remained culturable (at least 10⁴/ml) throughout the study. The non-culturable states of the opaque and translucent colony variants of V. vulnificus , as well as those of six other clinical and environmental strains of V. vulnificus , were examined at 5°C; all but one strain and both colony variants also became non-culturable within 40 days. In contrast, six other Vibrio spp. ( V. cholerae, V. mimicus, V. parahaemolyticus, V. natriegens, V. proteolyticus , and V. campbelli ) remained culturable at 5°C. Thus, entrance of V. vulnificus into the non-culturable state appears to be highly temperature dependent and, among the vibrios, this species may be especially sensitive to low temperature. The public health aspects of these findings are discussed.     

Studies on the control of cell division in a green alga, Ankistrodesmus gracilis (Chlorococcales) III. Induction synchrony with controlled division patterns

When stagnant cells of Ankistrodesmus gracilis obtained froma standard culture were inoculated into the basal medium atcell densities lower than 1.0 ? 10⁷ cells/ml, cell proliferationoccurred stepwise at time intervals of about 30 hr. At a densityof 5.5 ? 10⁴cells/ml, the increase in cell number per step wasabout 2.7-fold. When inoculated into a glutamine medium thetime interval was 24 hr, and the average increase of cell numberwas about 4-fold. When cells were preincubated at about 5.0? 10⁵ cells per ml in the basal medium for 30 hr, then transferredinto a glutamine or arginine medium at about 7.0 ? 10⁶ cells/ml,synchronous division occurred about 18 hr later with binaryfission or about 33 hr later with multiple fission, respectively. (Received May 16, 1979; )     

Population-dependent requirements of vitamin B12 and metabolically related substances of several mouse cell types in serum-free, albumin-fortified medium

Mouse FM3A cells propagated well in serum-free medium containing 0.5% serum albumin and 1 microgram of insulin/ml. The vitamin B12 (B12) requirement of the cells depended on the population density. This requirement disappeared when a sufficiently large cell population was present. A combination of 1-100 ng of B12/ml and 4 micrograms of hypoxanthine/ml resulted in a synergistic increase in cell growth at low cell densities. A similar growth response was obtained when the B12 plus hypoxanthine was replaced by 4 micrograms of hypoxanthine/ml in combination with 100 ng of thymidine/ml, 1 microgram of folic acid/ml or 1 microgram of folinic acid/ml, even though 1 microgram of folic acid/ml already was present in the medium. Experiments on single cell inoculation showed that colony size and the yield of cells grown in B12-supplemented medium were much larger than those for cells grown in B12-free medium. A more critical population-dependent B12 requirement was demonstrated in mouse Ehrlich and L cells and their hybrids. At less than 100 cells there was no propagation in serum-free medium lacking B12, folinic acid and thymidine; whereas, a satisfactory growth response was obtained in medium supplemented with these substances.     

Production of Choristoneura fumiferana Nucleopolyhedrovirus in C. fumiferana (CF-2C1 Cells) in a 3 Litre Bioreactor Using Serum-free Medium

The purpose of this study was to develop a cell culture process in a bioreactor for the production of a viral insecticide for the spruce budworm, Choristoneura fumiferana . Several cell lines were tested for their growth in serum-free medium suspension cultures. One cell line, CF-124T-2C1 (CF-2C1), was successfully adapted to grow in suspension cultures in SFM. Serum-free Ex-Cell 405 medium produced a much higher cell density (6.3 x 10 6 cells ml -1 ) than the Grace's medium supplemented with 10% fetal bovine serum (2.5 x 10 6 cells ml -1 ). Also, a higher yield of virus was obtained in the former medium. Ex-Cell 405, was used to study the growth of CF-2C1 cells and the production of C. fumiferana nucleopolyhedrovirus (CfMNPV) in a 3 l bioreactor. Under these conditions, a specific growth rate ( μ) of 0.027 h -1 was obtained during the exponential growth phase, and the specific carbon dioxide evolution rate, as determined by on-line measurement, was 0.9 x 10 -16 mol cell -1 s -1 and 1.78 x 10 -16 mol cell -1 s -1 during growth and infection phases, respectively. Virus production in bioreactor cultures infected at 1.3 x 10 6 cells ml -1 was consistently lower than that obtained in Erlenmeyer shake flasks. Only 26% of the cells were infected in the bioreactor compared to 44% in the shake flasks. However, a higher yield of occluded virus was obtained in the bioreactor cultures than in shake flasks. The production of occlusion bodies (OB) achieved in bioreactor cultures was 2 x 10 6 OB ml -1 .