诱变选育高产海藻糖的酵母菌株

以酿酒酵母Saccharomyces cerevisiae HY01为出发菌株,分别对其进行化学诱变和紫外诱变。选用5-溴尿嘧啶和盐酸平阳霉素两种低毒性诱变剂联合使用,通过均匀设计确定了两种诱变剂的最佳配比即5-Bu浓度为300umol/L、平阳霉素浓度为5umol/L时,获得一定数量的正突变株,最高海藻糖含量是15．98％。在紫外诱变过程中经摇瓶初筛、复筛获得了高产海藻糖菌株,其海藻糖含量为19．52％,比出发菌株提高了35％。     

花生四烯酸高产菌株的选育

本研究以一株能产生花生四烯酸的被孢霉菌为出发菌株,通过紫外线诱变筛选出一株高产花生四烯酸的突变株Ｍ１０,发酵试验结果表明：突变株Ｍ１０的每升培养液中干菌体得率为３１ｇ,油脂含量为８．３ｇ,而原菌株仅为２０．３ｇ和５．４ｇ,气相色谱分析结果Ｍ１０所产花生四烯酸的量占总脂的１０．０６％（０．８３ｇ／Ｌ培养液）。同时对Ｍ１０菌株的生长和发酵特性及发酵过程中菌丝体形态变化作了一定的探讨。     

赖氨酸高产菌株选育的基础研究

以本实验室提供的谷氨酸棒状杆菌为出发菌株,经紫外线或硫酸二乙酯(DES)诱变处理,共检出营养缺陷型12株,并进行鉴定,从中筛选出赖氨酸的高产菌株,且对其进行发酵产酸试验。本文研究旨在选育赖氨酸的高产菌株,并研究适宜的发酵工艺,以提高产酸率,降低生产成本。     

植酸酶高产菌株的诱变选育

无花果曲霉是一种可以产植酸酶的菌株,其代谢产物植酸酶可以将有机植酸磷降解为无机磷。以此菌株为出发菌株,确定了它的最适pH值为1.3~1.4,最适温度为55~60℃。同时,为获得高酶活的突变株,进行亚硝基胍和紫外线处理,经初筛得到99株高效突变株,再经复筛和传代试验,得到1株植酸酶活性是出发菌株2.47倍的突变株NTG-23。     

曲酸高产菌株的诱变选育

以紫外线和氮离子注入作为诱变手段对曲酸产生菌黄曲霉CICC2242进行诱变处理,筛选出一株高产菌株N83。曲酸产量由初始的12．4g／L提高到19．4g／L,提高了56．5％;遗传稳定性实验结果表明,N83遗传性状稳定良好。该结果表明氮离子注入诱变是获得高产曲酸的有效途径。     

高产生物表面活性剂菌株的紫外诱变选育

从新疆塔里木河边的土壤中筛选出1株产表面活性剂的菌株BIT-TLM1,该菌在以葡萄糖为碳源的无机盐培养基中,在150 r/min、40℃的条件下培养20 h,发酵液的表、界面张力分别降至29.29和0.61 mN/m。以菌株BIT-TLM1为原始菌株,对该菌进行紫外线诱变,选育出1株高产表面活性剂的诱变菌株UV-10,其产生表面活性剂的量达到0.309 7 g/g菌体,比原始菌株提高了9.22%,UV-10有较好的遗传稳定性,UV-10产表面活性剂的最佳培养条件:碳源为葡萄糖、氮源为NH4Cl、pH8.0和2%的盐度。     

复合诱变选育高产GSH的菌株

目的:选育出GSH的高产菌株.方法:以产GSH的产朊假丝酵母(Candida utilis)为出发菌株,利用紫外-超声波复合诱变.结果:筛选得到ZnCl2抗性突变株UU3,GSH菌体含量为53.50mg·g-1,比出发菌株提高137.03%.结论:突变株UU3遗传性能稳定,可做进一步研究.     

耐酸性α-淀粉酶高产菌株的选育

从酒曲中筛选得到1株高产耐酸性α-淀粉酶的野生菌株Tx-78,经鉴定为曲霉属的黑曲霉(Aspergil-lus niger)。以Tx-78作为出发菌株,通过紫外线(UV)诱变和亚硝基胍(NG)诱变,获得了遗传稳定的高产菌株UN78358,其产酶量可达到1 120 U/mL。     

紫外线诱变选育高产PHB解聚酶的菌株

以降解聚-β羟基丁酸酯(PHB)的青霉(Penieillium sp．)DS9713a为出发菌株,通过紫外线(UV)诱变分生孢子,采用透明圈初筛和摇瓶复筛,获得酶活高于原始菌株的突变株5株,其中DS9713a-CS01突变株的PHB解聚酶活力高于对照97．42％,并对其酶学性质进行了初步研究。     

UV与DES复合诱变选育高产脂肪酶菌株

以产脂肪酶菌株BaciUus sp CS-4为出发菌株,进行了UV与硫酸二乙酯(DES)复合诱变处理.筛选出一株高酶活的目的菌株,命名为Bacillus spDE-8.其酶活为每毫升14.85U,比出发菌株提高48.2%.传代实验证明,其遗传性能稳定.     

Strain Improvement of Streptomyces xanthochromogenes RIA 1098 for Enhanced Pravastatin Production at High Compactin Concentrations

Pravastatin is one of the most popular cholesterol-lowering drugs. Its industrial production represents a two-stage process including the microbial production of compactin and its further biocatalytic conversion to pravastatin. To increase a conversion rate, a higher compactin content in fermentation medium should be used; however, high compactin concentrations inhibit microbial growth. Therefore, the improvement of the compactin resistance of a producer still remains a relevant problem. A multi-step random UV mutagenesis of a Streptomyces xanthochromogenes strain RIA 1098 and the further selection of high-yield compactin-resistant mutants have resulted in a highly productive compactin-resistant strain S 33-1. After the fermentation medium improvement, the maximum bioconversion rate of this strain has reached 91 % at the daily compactin dose equal to 1 g/L and still remained high (83 %) even at the doubled dose (2 g/L). A 1-year study of the mutant strain stability has proved a stable inheritance of its characteristics that provides this strain to be very promising for the pravastatin-producing industry.

Electronic supplementary material

The online version of this article (doi:10.1007/s12088-015-0537-5) contains supplementary material, which is available to authorized users.     

豆豉纤溶酶产生菌的筛选及诱变

从广泛收集的豆豉成品及半成品中筛选到数株菌落形态各异且具有纤溶酶活性的菌株.分别采用亚硝酸和紫外线对豆豉纤溶酶产生菌DC-12进行诱变育种,成功筛选到了3株突变株,其纤溶酶产量较出发菌株分别提高了3.6、3.7和4.75倍.     

吸水链霉菌发酵生产谷氨酰胺转胺酶的补料研究

在吸水链霉菌(Streptomyces hygroscopicus)分批发酵研究的基础上,通过在菌体生长阶段指数流加葡萄糖,进行高细胞密度培养,获得了较高的菌体量;待菌体生长进入产酶期后,通过补加氮源,为产酶提供充足的氮源,其中通过流加蛋白质氮源,可以减少蛋白酶对成熟MTG的分解,促进产酶。结果表明,8~16 h采用较高的的比生长速率(0.15 h-1),后期降低比生长速率(0.10 h-1),此时得到的菌体量较高,可达到36 g/L,比分批发酵下的菌体量提高了80%。同时在培养基中添加50g/L的豆饼粉,最终酶活可达到5.79U/ml,提高了83%。     

Improvement of biological and pharmacokinetic features of human interleukin-11 by site-directed mutagenesis

Recombinant human interleukin-11 (rhIL-11) has been shown to increase platelet counts in animals and humans and is the only drug approved for its use in chemotherapy-induced thrombocytopenia (CIT). However, due to its serious side effects, its clinical use has been limited. The current work presents significantly improved efficacy of rhIL-11 via knowledge based re-designing process. The interleukin-11 mutein (mIL-11) was found to endure chemical and proteolytic stresses, while retaining the biological activity of rhIL-11. The improved efficacy of mIL-11 was evident after subcutaneous administration of mIL-11 and rhIL-11 in the rodent and primate models. More than three-fold increase in maximum plasma concentration (C_max) and area-under-the curve (AUC) was observed. Furthermore, three-fold higher increase in the platelet counts was obtained after seven consecutive daily subcutaneous mIL-11 injections than that with rhIL-11. The mIL-11 demonstrated not only improved stability but also enhanced efficacy over the currently used rhIL-11 regimen, thereby suggesting less toxicity.     

高产透明质酸菌种FJ-23的诱变选育

目的:高产透明质酸菌种的选育是提高透明质酸产量和质量的关键。方法:以马疫链球菌SH-0为出发菌,对其进行紫外诱变和NTG诱变选育。结果:筛选出溶血素和透明质酸酶双缺陷型突变菌株FJ-23,其透明质酸产量提高了7倍;突变株经6次传代,其产酸量及HA的相对分子量保持稳定,为今后进一步研究发酵法生产透明质酸打下基础。     

Production of Acidic Actinomycin Congeners by a Mutant Strain of Streptomyces antibioticus,No. B-1625

Streptomyces sp. No. B-1625, which was identified as a strain of Streptomyces antibioticus, is a typical producer of actinomycin, but also produces minor acidic antibiotic components (FA), besides actinomycins X₂, D and X_0β. The FA-components, which were obtained with a high-producing mutant, 11M-21, showed antibacterial and antitumor activities, and also similar visible and UV absorption spectra to those characteristic of actinomycin. The FA-components were separated into five components, FA₁ FA_2α, FA_2β, FA_3α and FA_3β, on TLC. Among them, one component, FA_3β, isolated in a purified state as an orange powder, has a composition of C, 52.97: H, 6.34: N, 10.48%, and is active against B. subtilis at a MIC of 5mcg/ml. The FA_3β component showed pK_a′ of 5.4 and 12.0 and λ_max at 443, 427 and 233 nm. From these properties, FA_3β is considered to be an acidic actinomycin congener.     

Production of tylosin in solid-state fermentation by Streptomyces fradiae NRRL-2702 and its gamma-irradiated mutant (γ-1)

Aims:  To develop solid-state fermentation system (SSF) for hyper production of tylosin from a mutant γ-1 of Streptomyces fradiae NRRL-2702 and its parent strain.
Methods and Results:  Various agro-industrial wastes were screened to study their effect on tylosin production in SSF. Wheat bran as solid substrate gave the highest production of 2500 μg of tylosin g⁻¹ substrate by mutant γ-1 against parent strain (300 μg tylosin g⁻¹ substrate). The tylosin yield was further improved to 4500 μg g⁻¹ substrate [70% moisture, 10% inoculum (v/w), pH 9·2, 30°C, supplemental lactose and sodium glutamate on day 9]. Wild-type strain displayed less production of tylosin (655 μg of tylosin g⁻¹ substrate) in SSF even after optimization of process parameters.
Conclusion:  The study has shown that solid-state fermentation system significantly enhanced the tylosin yield by mutant γ-1.
Significance and Impact of the Study:  This study proved to be very useful and resulted in 6·87 ± 0·30-fold increase in tylosin yield by this mutant when compared to that of wild-type strain.     

转座子挽救法对转座子突变菌株中插入位点的定位分析

为寻找谷氨酸棒杆菌转座子插入突变菌株中的转座子插入位点,采用了转座子挽救法对转座子及其插入位点附近的序列进行分离,并测定插入位点相邻DNA序列,获得了三个转座子插入位点DNA序列,其中一个是柠檬酸合成酶基因,另两个为目前未知基因,暂命名为orfA和orfB。该方法简便易行,是分析转座子插入位点的理想方法。