Purification and properties of a heat-stable exoinulinase isoform from Aspergillus fumigatus

An inducible extracellular exoinulinase (isoform II) was purified from the extracellular extract of Aspergillus fumigatus by ammonium sulphate precipitation, followed by successive chromatographies on DEAE-Sephacel, Octyl-Sepharose (HIC), Sephacryl S-200, affinity chromatography on ConA-CL Agarose and Sephacryl S-100 columns. The enzyme was purified 75-folds with 3.2% activity yield from the starting culture broth. The purified isoform II was a monomeric 62 kDa protein with a pI value of 4.5. The enzyme showed maximum activity at pH 6.0 and was stable over a pH range of 4.0-7.0, whereas the optimum temperature for enzyme activity was 60 degrees C. The inulinase isoform II showed exo-inulinolytic activity and retained 72% and 44% residual activity after 12 h at 60 degrees C and 70 degrees C, respectively. The inulin hydrolysis activity was completely abolished with 5 mM Hg2+ and Fe2+, whereas K+ and Cu2+ enhanced the inulinase activity. As compared to sucrose, stachyose and raffinose the purified enzyme had a lower Km (1.25 mM) and higher catalytic center activity (Kcat = 3.47 x 10(4) min(-1)) for inulin. As compared to exoinulinase isoform I of A. fumigatus, purified earlier, the isoform II is more thermostable and is a potential candidate for commercial production of fructose from inulin.     

Effect of media supplements and culture conditions on inulinase production by an actinomycete strain

Streptomyces sp. GNDU 1 produced high levels of extra-cellular inulinase (0.552 IU/ml) after 24 h at pH 7.5, temperature 46 degrees C in the presence of 1% inulin. The optimum temperature and pH for enzyme activity were 60 degrees C and 5.5 respectively. Yeast extract as a nitrogen source was found to be most suitable one for inulinase production whereas ammonium ion was inhibitory to the enzymatic production. All these conditions make Streptomyces sp. GNDU 1, a potential candidate for industrial enzymatic production of fructose from inulin.     

Production of novel alkalitolerant and thermostable inulinase from marine actinomycete Nocardiopsis sp. DN-K15 and inulin hydrolysis by the enzyme

An actinomycete strain Nocardiopsis sp. DN-K15 showing high inulinolytic activity was isolated from marine sediment of Jiaozhou Bay in China. Under optimal conditions, Nocardiopsis sp. DN-K15 produced 25.1 U/ml of inulinase within 60 h of fermentation at shake flask level, which was 2.7-fold higher than the level in the basal medium. The optimal pH and temperature of the inulinase from strain DN-K15 were determined to be 60 °C and pH 8.0, respectively. The inulinase was highly active over a wide pH range (5.0–11.0) and retained more than 81 % of residual activity after incubation at 60 °C for 1 h, indicating its alkali-tolerant and thermostable nature. Thin layer chromatography analysis revealed that fructose was the main product of inulin hydrolysis, indicating its exoinulinase activity. The high yield of extracellular inulinase combined with its novel enzymatic property made Nocardiopsis sp. DN-K15 a potential candidate in biotechnological and industrial applications.     

Continuous production of fructose-syrups from inulin by immobilized inulinase from recombinantSaccharomyces cerevisiae

Recombinant exoinulinase was partially purified from the culture supernatant ofS. cerevisiae by (NH₄)₂SO₄ precipitation and PEG treatment. The purified inulinase was immobilized onto Amino-cellulofine with glutaraldehyde as a cross-linking agent. Immobilization yield based on the enzyme activity was about 15%. Optimal pH and temperature of immobilized enzyme were found to be 5.0 and 60°C, respectively. The enzyme activity was stably maintained in the pH ranges of 4.5 to 6.0 at 60°C. 100% of enzyme activity was observed even after incubation for 24 hr at 60°C. In the operation of a packed-bed reactor containing 412 U inulinase, dahalia inulin of 7.5%(w/v) concentration was completely hydrolyzed at flow rate of 2.0 mL/min at 60°C, resulting in a volumetric productivity of 693 g-reducing sugars/L/h. Under the reaction conditions of 1.0 mL/min flow rate with 2.5% inulin at 60°C, the reactor was successfully operated over 30 days without loss of inulinase activity.     

Production and properties of a bacterial thermostable exo-inulinase

Inulinase and Invertase Activities, Thermophilic Bacilli, Enzyme Thermostability Enzyme production of newly isolated thermophilic inulin-degrading Bacillus sp. 11 strain was studied by batch cultivation in a fermentor. The achieved inulinase and invertase activities after a short growth time (4.25 h) were similar or higher compared to those reported for other mesophilic aerobic or anaerobic thermophilic bacterial producers and yeasts. The investigated enzyme belonged to the exo-type inulinases and splitted-off inulin, sucrose and raffinose. It could be used at temperatures above 65 degrees C and pH range 5.5-7.5. The obtained crude enzyme preparation possessed high thermostability. The residual inulinase and invertase activities were 92-98% after pretreatment at 65 degrees C for 60 min in the presence of substrate inulin.     

Inulinase production by a marine yeast <Emphasis Type="Italic">Pichia guilliermondii</Emphasis> and inulin hydrolysis by the crude inulinase

Marine yeast strain 1, isolated from the surface of a marine alga, was found to secrete a large amount of inulinase into the medium. This marine yeast was identified as a strain of Pichia guilliermondii according to the results of routine yeast identification and molecular methods. The crude inulinase produced by this marine yeast worked optimally at pH 6.0 and 60°C. The optimal medium for inulinase production was seawater containing 4.0% (w/v) inulin and 0.5% (w/v) yeast extract, while the optimal cultivation conditions for inulinase production were pH 8.0, 28°C and 170 rpm. Under the optimal conditions, over 60 U ml⁻¹ of inulinase activity was produced within 48 h of fermentation in shake flasks. A large amount of monosaccharides and a trace amount of oligosaccharides were detected after the hydrolysis, indicating that the crude inulinase had a high exoinulinase activity.     

Hydrolysis of inulin: a kinetic study of the reaction catalyzed by an inulinase from Aspergillus ficuum

A kinetic study of the hydrolysis of inulin was performed by using as catalyst a commercial inulinase from Aspergillus ficuum. The reaction was studied carrying out initial rate as well as time course measurements. Both inulinase and invertase activities of the enzyme were taken into account, and the corresponding kinetic parameters were determined in the temperature range 30-50 degrees C. The activation energies of the turnover constant for inulinase and invertase activities were found to be similar (56-57 kJ . mol(-1)). The ratio S/I of invertase to inulinase activity was 1.6 regardless of temperature. The thermal degradation of the enzyme was also investigated up to 70 degrees C, and an activation energy of 350-370 kJ . mol(-1) was evaluated.     

Optimization of medium and process parameters for the production of inulinase from a newly isolated Kluyveromyces marxianus YS-1

A newly isolated strain of Kluyveromyces marxianus YS-1 was used for the production of extra cellular inulinase in a medium containing inulin, meat extract, CaCl2 and sodium dodecyl sulphate (SDS). Fermentation medium pH 6.5, cultivation temperature 30 degrees C and 5% (v/v) inoculum of 12 h-old culture were optimal for enzyme production (30.8 IU/ml) with a fermentation time of 72 h at shake flask level. Raw inulin (2%, w/v) extracted from dahlia tubers by processing at 15 kg/cm2 for 10 min was optimum for bioreactor studies. Maximum enzyme production (55.4 IU/ml) was obtained at an agitation rate of 200 rpm and aeration of 0.75 vvm in a stirred tank reactor with a fermentation time of 60 h.     

Effect of inulin on yeast inulinase production in sauerkraut brine

Kluyveromyces marxianus NRRL Y-1196 produced the highest inulinase activity (38 U/mg protein) of six yeasts examined after 24 h growth in sauerkraut brine in shaking flasks at 30°C with 0.3% inulin as an enzyme inducer. The enzyme was recovered by acetone fractionation, with a yield of 81%. It had maximum activity at pH 4.4 and 55°C with K _m values for inulin and sucrose of 3.92 mm and 11.9 mm, respectively. The yeast raised the pH from 3.4 to above 7.0, using all the lactic acid in the brine. Growth of K. marxianus in sauerkraut brine with a small amount of inulin may usefully decrease the BOD and concomitantly produce inulinase.The authors are with the Department of Food Science and Technology, Cornell University, Geneva, New York 14456, USA     

一步法发酵菊芋产乙醇菌种的筛选及产酶条件、酶学性质的研究

从腐烂的菊芋及实验室保存的菌种中,选育到一株发酵菊芋产乙醇的菌株克鲁维酵母Kluyveromyces marxianus Y1。利用正交实验法对克鲁维酵母产菊粉酶的培养基组成及培养条件进行优化,确定培养基组成（g/L）为：菊粉40,酵母粉4,蛋白胨4,尿素1;初始pH5．0,温度30℃,150r／min条件下培养达到最佳产酶效果（57U／mL）。该菌株所产菊粉酶的性质测定结果表明：以菊粉为底物,该菊粉酶最适反应温度为55℃,在60℃以下稳定性很好,高于60℃时酶迅速失活;最适pH为5．0,pH4．6—5．2范围内酶稳定性很好;该酶属于外切型菊粉酶,体积分数为8％的乙醇对酶活力基本没有影响。     

Hydrolysis of inulin from Jerusalem artichoke by inulinase immobilized on aminoethylcellulose

Purified inulinase (inulase, 2,1-β-d-fructan fructanohydrolase, EC 3.2.1.7) of Kluyveromyces fragilis has been immobilized on 2-aminoethyl-cellulose by treatment with 2% glutaraldehyde in 0.05 m phosphate buffer, pH 7.0, for 2 h at room temperature. The immobilized enzyme preparation had 39.3 units inulinase activity per gram dried matrix, with 53.4% recovery yield of activity, and showed good operational stability in the presence of substrate, inulin or the tuber extract of Jerusalem artichoke. Optimum pH and temperature were 5.5 and 45°C, respectively. In a batch reactor, the conversion was 90% ($\text{d}\text{-fructose/}\text{d}\text{-glucose}\text{= 76/24}$) and 34 mg d-fructose per ml was produced from the artichoke tuber extract by the immobilized inulinase in 20 h. In column reactor packed with 28 ml immobilized enzyme, the following conditions were found to be optimal: height/diameter ratio of column, 10.3; space time, 3.8 h; temperature, 40°C. Operation under these conditions gave 90% conversion of a 7% inulin solution and the productivity was 102 mmol l^?1 h^?1.     

Production of extracellular exoinulinase from Kluyveromyces marxianus YS-1 using root tubers of Asparagus officinalis

Root tubers of Asparagus officinalis were used as a source of raw inulin for the production of exoinulinase (EC 3.2.1.7) from Kluyveromyces marxianus YS-1. Root extract prepared at 10kg/cm2 pressure for 10min showed maximum inulinase production. Medium components and process parameters were standardized to improve the enzyme production. Inulinase yield of 40.2IU/mL in a medium containing raw inulin (3.5%), beef extract (2%), SDS (0.001%), Mn2+ (2.0mM), Mg2+ (1.5mM), Co2+ (2mM) and pH 6.5 has been obtained under agitation (150rpm) after 60h of incubation at 30 degrees C at shake flask level. After optimization, the enzyme production was 4.8 times more than the basal medium. To test the feasibility of raw inulin from A. officinalis for the production of inulinase, trials were also made in a bioreactor (1.5L). Inulinase activity of 50.2IU/mL was obtained from raw inulin (4.0%) under agitation (200rpm) and aeration (0.75vvm) at 30 degrees C after 60h of fermentation. Inulinase yield in bioreactor was almost six times higher than the basal medium used initially in shake flask.     

Characterization of molecular-sieve-bound inulinase

The enzyme inulinase (2,1-β-d-fructan fructanohydrolase, EC 3.2.1.7), prepared from Kluyveromyces marxianus has been immobilized using an inorganic solid support, molecular sieve 4A via the metal link method. The immobilized enzyme had around 22 units of inulinase activity per g of the support with retention of 72% of the original activity. The optimum protein to molecular sieve ratio for the maximum retention of inulinase activity was 9 mg/g molecular sieve. The properties of soluble and immobilized enzyme differed in many respects. The optimum pH of the enzyme shifted from 6 to 5 and the optimum temperature of enzyme activity changed from 50 to 55°C. K_m values were 6.7 mM for soluble enzyme and 10 mM for immobilized enzyme. The heat stability of the enzyme was improved by immobilization. Immobilized enzyme retained about 76% of the original activity after 40 days of storage at room temperature (30±2°C).     

Bioconversion of inulin to 2,3-butanediol by a newly isolated Klebsiella pneumoniae producing inulinase

Inulin could be converted to bio-based chemicals by an inulinase producer without external inulinase, and the production of 2,3-butanediol was less than 50 g/L. In this work, a novel inulinase producer of Klebsiella pneumoniae H3 was isolated, and inulinase catalytic properties as well as 2,3-butanediol fermentation were investigated. The enzyme was an intracellular inulinase with an optimal pH of 6 ∼ 7 and a temperature of 30 °C. The use of inulin by H3 was dependent on the degree of polymerization (DP), and the average DP of inulin in fermentation broth increased from 2.82 to 8.08 in 24-h culture of batch fermentation. Acidic pretreatment was developed to increase inulin utilization by adjusting medium pH to 3.0 prior to sterilization. In batch fermentation with optimized medium and fermentation conditions, the concentration of target product (2,3-butanediol and acetoin) was 80.4 g/L with a productivity of 2.23 g/(L⋅h), and a yield of 0.426 g/g inulin.     

毛壳霉内切菊粉酶的纯化与性质

毛壳霉 (Chaetomiumsp .)C34发酵液经硫酸铵分级沉淀、DEAE 纤维素 11离子交换层析、Q SepharoseFastFlow离子交换层析、SephacrylS 2 0 0凝胶过滤、PhenolSepharoseTM HP疏水层析 ,得到电泳纯的内切菊粉酶组分 ,纯化倍数为 30 8倍 ,活力回收率为 7 7%。用SDS PAGE测得该酶亚基的分子量为 6 6kD。菊粉酶的最适pH为 6 0 ,最适温度为 5 0～ 5 5℃。菊粉酶在 5 0℃以下 ,pH5 0～ 8 0时较稳定。Cu2 完全抑制酶的活性 ,Mn2 、Zn2 、Fe2 、EDTA以及NBS(N bromosuccinimide ,N 溴代丁二酰亚胺 )对该酶有很强的抑制作用。该酶对菊粉有较强底物专一性 ,产物主要为低聚果糖 ,也可作用于蔗糖 ,I S值为 2 0。以菊粉为底物时 ,Km 为 0 199mmol L ,Vmax为 115 μmol (mg·min)。     

高产菊粉酶酵母筛选、发酵和酶学性质研究

筛选到1株菊粉酶高产克鲁维酵母菌株,采用酵母高密度细胞发酵方法,最高菊粉酶产量达到288.78u/mL,比80～90年代国际上报道的克鲁维酵母菊粉酶最高产量高6.8倍。该酶的菊粉酶/转化酶活性比为1/24.72;菊糖m=13.3mmol/L,蔗糖Km=62.6mmol/L;最适反应pH值为4.4,但在pH3.8～5.6的范围内均保持了较高的活性,相当于最适pH值下活性的90%;最适反应温度为55℃,在50～575℃范围内能够保持较高活性,50℃下酶的半衰期约为16h;外加Mg2+提高酶活性11.28%。     

Inulinase production by the marine yeast Cryptococcus aureus G7a and inulin hydrolysis by the crude inulinase

The marine yeast strain G7a isolated from sediment of China South Sea was found to secrete a large amount of inulinase into the medium. This marine yeast strain was identified to be a strain of Cryptococcus aureus according to the results of routine yeast identification and molecular methods. The crude inulinase produced by this marine yeast showed the highest activity at pH 5.0 and 50 °C. The optimal medium for inulinase production was artificial seawater containing inulin 4.0% (w/v), K₂HPO₄ 0.3% (w/v), yeast extract 0.5% (w/v), KCl 0.5% (w/v), CaCl₂ 0.12% (w/v), NaCl 4.0% (w/v) and MgCl₂·6H₂O 0.6% (w/v), while the optimal cultivation conditions for inulinase production were pH 5.0, a temperature of 28 °C and a shaking speed of 170 rpm. Under the optimal conditions, over 85.0 U/ml of inulinase activity was produced within 42 h of fermentation at shake flask level. This is very high level of inulinase activity produced by yeasts. A large amount of monosaccharides and oligosaccharides were detected after inulin hydrolysis by the crude inulinase.     

Purification and characterization of inulinase from Aspergillus niger AF10 expressed in Pichia pastoris

The inuA1 gene encoding an exoinulinase from Aspergillus niger AF10 was expressed in Pichia pastoris, and the recombinant enzyme activity was 316U/ml in a 5L fermentor, with the inulinase protein accounting for 35% of the total protein of fermentation broth. The hydrolysis rate of inulin can reach 92%, with a 25U/g inulin enzyme addition, and 90% of fructose content after 6h. Glucose can significantly inhibit the enzymatic hydrolysis of inulin. This is the first report of glucose inhibition of inulinase-catalyzed hydrolysis.     

Identification of catalytically active groups in inulinase from Bacillus polymyxa 722

Inulinase from Bacillus polymyxa 722 hydrolyzing a polyfructosan inulin was studied. The dependence of inulinase activity on pH, measurements of pK value, calculation of ionization heat, photoinactivation with methylene blue, and inhibition with p-chloromercuribenzoate suggest that the active center of this enzyme contains imidazole and sulfhydryl groups. A possible mechanism underlying cleavage of beta-2,1-fructoside bonds in the inulin molecule with inulinase is considered.