Production of citric acid with immobilized Aspergillus niger

Summary The spores of Aspergillus niger were entrapped in calcium-alginate beads and precultivated in growth media with various amounts of nitrogen. During the following citric acid production in shaking cultures an optimum of acid formation and yield was observed after the precultivation with 100–200 mg/l NH₄NO₃. The productivity of the immobilized Aspergillus was found to be 1.5 times higher than in the case of free pellets. The outgrowth of free mycelia into the medium could be provided by increasing the ratio particle-volume: medium volume, using a 1-l air-lift fermenter, by which means the productivity was increased twice as much as obtained in shaking culture.     

Improved reproducibility of citric acid production in Aspergillus niger

Summary We report the derivation of Aspergillus niger strains having a lower standard deviation in citric acid production by the use of ⁶⁰Co gamma radiation and by the parasexual cycle. On the basis of the results obtained by isolating diploids and segregants, diploidization seems to be sufficient for reducing variability. The implications of these results in terms of improvement of industrial strains are discussed.     

Aconitase and citric acid fermentation by Aspergillus niger

In view of the often-cited theory that citric acid accumulation is caused by an inhibition of aconitase activity, the equilibrium of the reaction of aconitase was investigated by comparing in vivo steady-state concentrations of citrate and isocitrate in Aspergillus niger grown under various citric acid-producing conditions. With the equilibrium catalyzed by the A. niger enzyme in vitro, similar values were obtained. The validity of our in vivo measurements was verified by the addition of the aconitase inhibitor fluorocitrate, which appreciably elevated the citrate:isocitrate ratio. The results strongly argue against an inhibition of aconitase during citric acid fermentation.     

Production of citric acid from starch-hydrolysate by Aspergillus niger

The present investigation explored the possible use of a rarely used agro-industrial by-product, maize starch-hydrolysate, for economic production of citric acid. To achieve this, seventeen strains of Aspergillus niger were screened for their capacity to produce citric acid using starch-hydrolysate as a substrate. The most efficient strain, ITCC-605 was selected for further improvement in citric acid content by mutation. Mutants developed by treatment with EMS and UV, singly and in combination, produced citric acid in the range of 0.51-64.7 g kg(-1) of glucose consumed. The mutant UE-1 produced the maximum citric acid which was about 130 times more than that produced by the parent strain, ITCC-605. For further increase in citric acid production from this substrate, the cultural conditions were optimized: concentration of starch-hydrolysate, 15% (glucose equivalent); ammonium nitrate, 0.25%; KH2PO4, 0.15%; nicotinic acid, 0.0001% and initial pH of 2.0. Under these conditions, the mutant strain UE-1 yielded 490 g citric acid kg(-1) of glucose consumed in 8 days of incubation at 30 degrees C. The productivity of 341 mgl(-1)h(-1) corresponded to 49% substrate conversion to citric acid.     

Cyclic AMP and citric acid accumulation by Aspergillus niger

Aspergillus niger accumulated citric acid in the medium under certain conditions. Cyclic AMP concentrations of the order of 10^?6M and higher caused an increase in the rate of citrate synthesis. Adenosine, ATP, and cyclic GMP at 10^?3M also stimulated, but were ineffective at 10^?4M. 5′-AMP had no effect while 5′-GMP and guanosine inhibited slightly. ADP showed a 42% inhibition. Theophylline enhanced the cyclic AMP effect. It is proposed that citric acid accumulation by Aspergillus niger may result from abnormal cyclic AMP metabolism.     

Parasexual hybridisation and citric acid production by Aspergillus niger

Summary In this investigation hybridisation experiments were performed with two auxotrophic mutants of Aspergillus niger. A heterozygous diploid was derived from them and it produced segregants including parental haploids and a recombinant. Their yield characters were studied.     

Aconitase and citric acid fermentation by Aspergillus niger.

In view of the often-cited theory that citric acid accumulation is caused by an inhibition of aconitase activity, the equilibrium of the reaction of aconitase was investigated by comparing in vivo steady-state concentrations of citrate and isocitrate in Aspergillus niger grown under various citric acid-producing conditions. With the equilibrium catalyzed by the A. niger enzyme in vitro, similar values were obtained. The validity of our in vivo measurements was verified by the addition of the aconitase inhibitor fluorocitrate, which appreciably elevated the citrate:isocitrate ratio. The results strongly argue against an inhibition of aconitase during citric acid fermentation.     

The role of the tricarboxylic acid cycle in citric acid accumulation by Aspergillus niger

Summary Determinations of the momentary levels of various intermediates related to the activity of the tricarboxylic acid cycle have been made during citric acid production in high-accumulating (manganese deficient) and lowaccumulating (manganese supplemented) mycelia of Aspergillus niger. During the growth period the levels of almost all TCA cycle acids, with the exception of 2-oxo-acids, were unusually high; during the induction phase of citrate accumulation malate, fumarate, and isocitrate decreased, whereas pyruvate, oxalacetate, and citrate increased. The presence of succinate could not be demonstrated. The interrelations of the momentary concentrations of the intermediates mainly demonstrate a lack in activity of 2-oxoglutarate dehydrogenase, representing a block in the TCA cycle concomitant with a strongly operating glycolysis as a prerequisite for citrate accumulation. Inhibition studies with crude enzyme preparations suggest that an inhibition of malate dehydrogenase by citrate and also inhibition of isocitrate dehydrogenase by citrate and 2-oxoglutarate occur during the production phase as additional factors.     

The effect of methanol on citric acid production from galactose by Aspergillus niger

Summary The effect of methanol on the ability of several strains of Aspergillus to produce citric acid from galactose has been investigated. In the absence of methanol, very little production (less than 1 g/l) was observed. In the presence of methanol (final concentration 1% v/v), however, citric acid production and yeilds were increased considerably. Strong relationships were observed between citric acid production and the activities of the enzymes 2-oxoglutarate dehydrogenase and pyruvate carboxylase in cell-free extracts. During citric acid production, in the presence of methanol, the activity of 2-oxoglutarate dehydrogenase was low and that of pyruvate carboxylase high. In the absence of methanol, where little citric acid was produced, the reverse was true. It is suggested that the presence of methanol may increase the permeability of the cell to citrate, and the cell responds to the diminished intracellular level by increasing production via repression of 2-oxoglutarate dehydrogenase.     

The effect of the sugar source on citric acid production by Aspergillus niger

Summary Under otherwise identical fermentation conditions, the sugar source has been shown to have a marked effect on citric acid production by Aspergillus niger. Sucrose was the most favourable source, followed by glucose and fructose and then lactose. No citric acid was produced from galactose. Strong relationships were observed between citric acid production and the activities of certain enzymes in myccelial cell-free extracts prepared from fermentation samples. When sucrose, glucose, or fructose was the sugar source pyruvate carboxylase activity was high, but 2-oxoglutarate dehydrogenase activity was not detected. When galactose was the sugar source pyruvate carboxylase activity was low, but 2-oxoglutarate dehydrogenase activity was high. It is suggested that whereas glucose and fructose repress 2-oxoglutarate dehydrogenase, thereby causing accumulation of citric acid, galactose does not. The activity of aconitase showed a direct relationship to the citric acid production rate. Thus, the activity was highest when sucrose was the sugar source, and lowest when galactose was the source. It is suggested that when large amounts of citric acid are lost from the cell the activity of aconitase increases as a response to the diminished intracellular supply of its substrate.     

Morphology and citric acid production of Aspergillus niger PM 1

Summary Aspergillus niger PM 1 was grown in a tubular loop and a stirred tank bioreactor. Batch fermentations were performed under various agitation conditions and pH. Citric acid, oxalic acid, extracellular polysaccharides and proteins were assayed. The following morphological parameters were measured: mean perimeter of clumps, mean perimeter of the central core of clumps, mean length of filaments and mean diameter of filaments. Citric acid production and morphology in both reactors were dependent on agitation intensity and pH. The length of the filaments was shown to be the only parameter that could be related to citric acid production in both reactors: the shorter the filaments the more citric acid was produced. However, for the same amount of citric acid produced the morphology of the organism grown in the stirred tank differed considerably from that grown in the loop reactor.     

Production of citric acid by Aspergillus niger immobilized in polyacrylamide gels

Summary Living Aspergillus niger cells were entrapped in polyacrylamide gels and employed in both replacement batch and continuous column bioreactors to produce citric acid from sucrose. With the replacement batch bioreactor, increase of citric acid was observed under conditions of higher aeration and of wider surface of immobilized cells. With the continuous bioreactor, the maximum citric acid yield was 39.1 mg/h per 40 g gels. The biocatalyst activity or half-life was 105 days.