Effects of cell density and glucose and glutamine levels on the respiration rates of hybridoma cells

The effects of cell density as well as the concentration levels of glucose and glutamine on the specific respiration rate of a hybridoma cell line were investigated. The experimental oxygen consumption rate was found to be constant over a wide range of dissolved oxygen levels if the suspension medium contained glutamine. In glutamine-free medium, however, the rate of oxygen consumption decreased slowly with time.In a stationary flask batch culture, the specific respiration rate decreased from about 7 to 2.9 mumol/min per 10(9) cells as the cell density increased exponentially from 1 x 10(5) to 1.2 x 10(6)/mL. To isolate the effect of cell density, cells were re suspended in fresh culture medium so that nutrient concentrations were the same for all experiments. The specific respiration rate decreased with increasing cell density in the same manner as in the stationary flask culture, falling from 8 to 4 mumol/min per 10(9) cells as the cell density increased from 10(5) to 10(6) cells/mL, then declining to 2 mumol/min per 10(9) cells when the cell density reached 10(7) cells/mL.Cells suspended in Hanks balanced sale solution (HBSS) were used to elucidate the effect of glucose and glutamine levels on respiration. The addition of glucose in concentrations of 0.25, 0.50, and 0.75 g/L had no observable effect on the specific oxygen uptake rate; however, a glucose concentration of 1 g/L reduced the uptake rate by 22%. Glutamine in a concentration of 0.30 g/L increased the specific respiration rate in HBSS containing 0 and 1 g/L glucose by approximately 13%.     

Lactate-stimulated ethanol oxidation in isolated hepatocytes

1. Hepatocytes isolated from starved rats and incubated without other substrates oxidized ethanol at a rate of 0.8-0.9mumol/min per g wet wt. of cells. Addition of 10mm-lactate increased this rate 2-fold. 2. Quinolinate (5mm) or tryptophan (1mm) decreased the rate of gluconeogenesis with 10mm-lactate and 8mm-ethanol from 0.39 to 0.04-0.08mumol/min per g wet wt. of cells, but rates of ethanol oxidation were not decreased. From these results it appears that acceleration of ethanol oxidation by lactate is not dependent upon the stimulation of gluconeogenesis and the consequent increased demand for ATP. 3. As another test of the relationship between ethanol oxidation and gluconeogenesis, the initial lactate concentration was varied from 0.5mm to 10mm and pyruvate was added to give an initial [lactate]/[pyruvate] ratio of 10. This substrate combination gave a large stimulation of ethanol oxidation (from 0.8 to 2.6mumol/min per g wet wt. of cells) at low lactate concentrations (0.5-2.0mm), but rates remained nearly constant (2.6-3.0mumol/min per g wet wt. of cells) at higher lactate concentrations (2.0-10mm). 4. In contrast, owing to the presence of ethanol, the rate of glucose synthesis was only slightly increased (from 0.08 to 0.12mumol/min per g wet wt. of cells) between 0.5mm- and 2.0mm-lactate and continued to increase (from 0.12 to 0.65mumol/min per g wet wt. of cells) with lactate concentrations between 2 and 10mm. 5. In the presence of ethanol, O(2) uptake increased with increasing substrate concentration over the entire range. 6. Changes in concentrations of glutamate and 2-oxoglutarate closely paralleled changes in the rate of ethanol oxidation. 7. In isolated hepatocytes, rates of ethanol oxidation are lower than those in vivo apparently because of depletion of malate-aspartate shuttle intermediates during cell preparation. Rates are returned to those observed in vivo by substrates that increase the intracellular concentration of shuttle metabolites.     

Immobilization of phospholipid vesicles and protein-lipid vesicles containing red cell membrane proteins on octyl derivatives of large-pore gels

For improved immobilization of phospholipid vesicles and protein-lipid vesicles (cf. Sandberg, M., Lundahl, P., Greijer, E. and Belew, M. (1987) Biochim. Biophys. Acta 924, 185-192) and for chromatographic experiments with vesicles containing membrane protein, we have prepared octyl sulfide derivatives of the large-pore gels Sephacryl S-1000 and Sepharose 2B with ligand concentrations up to 14 and 5 mumol/ml gel, respectively. The Sephacryl derivatives allowed higher flow rates, gave higher rates of adsorption and showed equally high or higher capacities than the Sepharose adsorbents. 'Small', 'medium' and 'large' vesicles of radii approx. 20, 50 and 100 nm showed distribution coefficients on Sephacryl S-1000 of 0.7, 0.5 and 0.05, respectively and could be immobilized on octyl sulfide-Sephacryl S-1000 in amounts corresponding to 110, 40 and 20 mumol of phospholipids per ml gel, respectively. 'Small' vesicles became absorbed onto this gel at a rate of 1.5 mumol of phospholipids per min per ml gel until 60 mumol of phospholipids had become immobilized, whereas the initial adsorption rate was about 0.4 mumol.min-1.ml-1 on octyl sulfide-Sepharose 4B (see reference above) and on octyl sulfide-Sepharose 2B. Lower ligand concentrations gave lower capacities for 'small' vesicles. When vesicles entrapping calcein were immobilized on octyl sulfide-Sephacryl S-1000 some calcein was released during the adsorption process. For 'small' and 'medium' vesicles, respectively, the leakage was 75 and 25% at a ligand concentration of 14 mumol/ml but only 3 and 2% at 5 mumol/ml. The internal volumes of immobilized 'small' and 'medium' vesicles were estimated at 0.97 and 2.9 microliters per mumol of phospholipid by determination of entrapped calcein, which could indicate vesicle radii 20 and 50 nm, respectively. The total volumes of immobilized 'medium' lipid vesicles and 'medium' protein-lipid vesicles containing integral membrane proteins from human red cells, were estimated at 2.9 and 2.0 microliters/mumol, respectively, by chromatography of D- and L-[14C]glucose and calcein on the octyl sulfide-Sephacryl S-1000 column before and after immobilization. These volumes are roughly consistent with the internal volume of the vesicles. A zone of D-glucose eluted 90 microliters later than a zone of L-glucose on a 4- or 5-ml column of octyl sulfide-Sephacryl S-1000 with immobilized 'medium' protein-lipid vesicles containing the glucose transporter from human red cells, probably since part of the internal vesicle volume was accessible to the D-glucose but not to the L-glucose. This indicates that the glucose transporter was active in the immobilized vesicles.(ABSTRACT TRUNCATED AT 400 WORDS)     

Repeated batch production of L-phenylalanine from phenylpyruvate and NH(4)Cl by immobilized cells of Nocardia opaca under hydrogen high pressure

Among various microbial cells examined under screening conditions, Nocardia opaca showed the highest activity for production of phenylalanine from phenylpyruvate. Here NH(4)Cl as well as amino acids were used as an amino donor for phenylalanine production. The phenylalanine production rate increased with increasing hydrogen pressure. The specific activity of phenylalanine dehydrogenase was increased by culturing N. opaca cells in nutrient broth containing 0.3% phenylalanine. As a result, the phenylalanine production rate increased from 0.69 to 4.4 mumol/min g dry cells. Immobilized cells were activated in nutrient broth containing ZnCl(2) before phenylalanine production. Phenylalanine dehydrogenase activity and cell number in the gel increased with increasing incubation time, and the maximum phenylalanine dehydrogenase activity was obtained at 36 h incubation. Then, phenylalanine was produced from phenylpyruvate, NH(4)Cl, and 100 atm H(2) with the activated immobilized cells. The rate of phenylalanine production was 0.24 mumol/min cm(3) gel. The conversion of phenylpyruvate to phenylalanine was 82%. Immobilized cells retained 76% of the initial phenylalanine production rate after 10 h reactions were repeated 11 times with two intervening reactivations.     

Production of monoclonal antibody using free-suspended and immobilized hybridoma cells: Effect of serum

The effect of serum on cell growth and monoclonal antibody (MAb) productivity was studied in a repeated fedbatch mode using both free-suspended and immobilized S3H5/gamma2bA2 hybridoma cells. In the suspension culture, serum influenced the cell growth rate but not the specific MAb productivity. The average specific growth rate of the suspension culture in medium containing 10% serum was approximately 0.99 +/- 0.12 day(-1) (+/-standard deviation), while that in medium containing 1% serum was approximately 0.73 +/- 0.12 day(-1). The specific MAb productivity was almost constant at 3.69 +/- 0.57 mug/10(6) cells/day irrespective of serum concentration reached a maximum at ca. 1.8 x 10(6) cells/mL of medium in 10% serum medium, and the cell concentration was gradually reduced to 1%. The specific MAb productivity of the immobilized cells was more than three times higher than that of the free-suspended cells. The amount of serum in the medium did not influence the specific MAb production rate of the immobilized cells. The maintenance of high cell concentration and the enhanced specific MAb productivity of the immobilized cell culture resulted in a higher volumetric MAb productivity. In addition, MAb yield in the immobilized cell culture with medium containing 1% serum was 2.2 mg/mL of serum, which was approximately three times higher than that in the suspension culture.     

Artificial capillary perfusion cell culture: metabolic studies.

Glucose, lactic-acid, and oxygen metabolism of BHK and L929 cells on artificial capillary perfusion units have been studied using several different modes of perfusion. After 7 to 10 days, cells planted in the extracapillary compartment of culture units containing 80 to 150 fibers reached populations that used 0.073 +/- 0.025 mumol per min glucose and 0.76 +/- 0.26 microliter per min oxygen and excreted 0.078 +/- 0.038 mumol per min lactic acid. From these data it is estimated that these units contain approximately 2 x 10(7) cells. The metabolic rate of cultures perfused through the capillaries or through the extracapillary compartment was not affected significantly by change in flow rate except at perfusion flow rates less than or equal to 0.05 ml per min. The cell population, as measured by metabolic activity, did not increase significantly when the serum content of the medium was less than or equal to 1%. No major differences were found in glucose utilization rates of equal numbers of cells on artificial capillaries, on short-term suspension culture, or as monolayers in plastic flasks. Artificial capillary perfusion may provide a simple system for studying metabolism of mammalian cells in culture.     

Characterization of L-asparagine transport systems in Stemphylium botryosum.

L-Asparagine uptake by Stemphylium botryosum is mediated by two distinct energy- and temperature-dependent transport systems. One permease is relatively specific for L-asparagine and L-glutamine and is present in nutrient-sufficient mycelium. The specific permease shows an optimum pH at 5.2, saturation kinetics (Km = 4.4 x 10(-4) M, Vmax = 1.1 mumol/g per min), competitive gradient of L-asparagine, and higher affinity towards the L-isomer of asparagine. Amide derivatives of L-asparagine (5-diazo-4-oxo-L-norvaline or L-aspartyl hydroxamate) are the most effective competitors, alpha-amino derivative (N-acetyl asparagine) is a moderate competitor, and alpha-carboxyl derivative (L-asparagine-t-butylester) shows only slight inhibition of the specific permease. Derivatives of L-glutamine are significantly less effective competitors than those of L-asparatine. The level of the specific permease is affected by nitrogen sources and increases approximately threefold upon starvation. The nonspecific permease possesses an optimum pH at 6.8, saturation kinetics (Km = 7 x 10(-5) M, Vmax = 5 mumol/g per min, Kt = 7.4 x 10(-5) M for L-leucine), and high affinity towards various types of amino acids.     

Culture of insect cells in helical ribbon impeller bioreactor

An 11-L helical ribbon impeller (HRI) bioreactor was tested for the culture of Spodoptera frugiperda (Sf-9) cells. This impeller and surface baffling ensured homogeneous mixing and high oxygen transfer through surface aeration and surface-induced babble generation. Serum-supplemented and serum-free cultures, using TNMFH and IPL/41 media, respectively, grew a similar specific growth rates(0.031 and 0.028 h(-1)) to maximum cell densities of 5.5 x 10(6)-6.0 x 10(6) cells. mL(-1) with viability exceeding 98% during exponential growth phase. Growth limitation coincided with glucose and glutamine depletion and production of significant amounts of alanine. The bioreactor was further tested under more stringent conditions by infecting a serum-free medium culture with a recombinant baculovirus. Heterologous protein production of approximately 35 mug per 10(6) cells was comparable to yields obtained in serum-free cultures grown in spinner flasks and petri dishes. Average specific oxygen up-take and carbon dioxide production rates of the serum-free culture prior to infection as measured by on-line mass spectroscopy were 0.20 mumol O(2)mu.(10(6) cells)(-1) h(-1) and 0.22 mumol CO(2) . (10(6) cells)(-1)h(-1) and increased by 30-40% during infection. Therefore, the mixing and oxygenation conditions of this bioreactor were suitable for insect cell culture and recombinant protein production, with limitation being mainly attributed to nutrient depletion and toxic by-product generation.     

31P-NMR studies of phosphate transfer rates in T47D human breast cancer cells

The concentration of phosphates and the kinetics of phosphate transfer reactions were measured in the human breast cancer cell line, T47D, using 31P-NMR spectroscopy. The cells were embedded in agarose filaments and perifused with oxygenated medium during the NMR measurements. The following phosphates were identified in spectra of perifused cells and of cell extracts: phosphorylcholine (PC), phosphorylethanolamine (PE), the glycerol derivatives of PC and PE, inorganic phosphate (Pi), phosphocreatine (PCr), nucleoside triphosphate (primarily ATP) and uridine diphosphate glucose. The rates of the transfers: PC----gamma ATP (0.2 mM/s), Pi----gamma ATP (0.2 mM/s) and the conversion beta ATP----beta ADP (1.3 mM/s) were determined from analysis of data obtained in steady-state saturation transfer and inversion recovery experiments. Data from spectrophotometric assays of the specific activity of creatine kinase (approx. 0.1 mumol/min per mg protein) and adenylate kinase (approx. 0.4 mumol/min per mg protein) suggest that the beta ATP----beta ADP rate is dominated by the latter reaction. The ratio between the rate of ATP synthesis from Pi and the rate of consumption of oxygen atoms (4 X 10(-3) mM/s) was approx. 50. This high value and preliminary measurements of the rate of lactate production from glucose, indicated that aerobic glycolysis is the main pathway of ATP synthesis.     

Estimation of heat production by cultured cells in suspension using semi-automated flow microcalorimetry

Modifications to a heat conduction flow microcalorimeter are described which allow registration of heat production by cells cultured in suspension. LS cells produced 34 +/- 3 pW per cell. Over an 8.5 h period, cell numbers increased by 9% and heat production per cell by 18%. Oxygen consumption per cell was 0.244 +/- 0.02 mumol min-1 per 10(8) cells and the enthalpy change was -836 kJ/mol O2. An automated pumping system allowed sequential registration of heat production by untreated cells and those exposed to a metabolic inhibitor. The results showed that 0.1 mM 2,4-dinitrophenol caused a greater increase in power (+65% at 1.5 h) than in oxygen consumption (+36%). The opposite occurred in the case of cells treated with 1 mM potassium cyanide, heat dissipation being depressed (-48%) slightly less than oxygen uptake (-52%). The results illustrate the potential of careful calorimetric determinations in studying metabolic events in the growth and division of cells in culture.     

Insulin regulation of glucose metabolism in HT29 colonic adenocarcinoma cells: activation of glycolysis without augmentation of glucose transport

The effects of insulin on glucose transport and metabolism were examined in cultured HT29 human colonic adenocarcinoma cells. The presence of glucose transporters was verified by D-glucose displaceable [3H]cytochalasin B binding. The Kd and Bmax values from cytochalasin B binding studies were 190 +/- 30 nM and 8.4 +/- 1.4 pmol/mg protein, respectively. Glucose transport determined with 3-O-methylglucose showed saturable kinetics with a Km of 5.8 +/- 0.4 mM and a Vmax of 0.047 +/- 0.003 mumol/mg protein per min at 25 degrees C. Moreover, in HT29 cells, two classes of insulin binding sites were detected in radioligand binding experiments. Although insulin failed to stimulate glucose transport, it was found to activate glycolysis in HT29 cells. Glucose consumption increased from 0.33 +/- 0.03 mumol/mg protein per h to 0.49 +/- 0.05 mumol/mg protein per h and lactate production was augmented from 0.67 +/- 0.04 mumol/mg protein per h to 0.87 +/- 0.06 mumol/mg protein per h in response to 10(-7) to 10(-5) M insulin. Insulin also enhanced mannose metabolism. Apart from these two hexoses, HT29 cells exhibited a surprisingly narrow substrate specificity. With the possible exception of glyceraldehyde, little lactate was produced from alternative substrates, including adenosine, inosine, ribose, deoxyribose, dihydroxyacetone, galactose and fructose either with or without insulin. Despite its limited utilization by the glycolytic pathway, adenosine was readily salvaged for de novo synthesis of adenine nucleotides. These findings suggest that insulin directly influences substrate utilization through the glycolytic pathway in HT29 cells without activating the glucose transport pathway.     

Microcalorimetric methods for substrate determination in flow systems with immobilized enzymes.

The enthalpy of processes catalyzed by immobilized enzymes in the reaction cell of a LKB-flow calorimeter is used for determination of urea (0.5-5 mumol) and glucose (0.03-0.5 mumol). Accuracy is 2-5% and the time needed for one analysis is 20 min. A sensitive "enzyme thermistor" consisting of a flow through cell with an immobilized enzyme and two thermistors is described, which permits glucose determinations (0.05-1 mumol +/- 0.03 mumol) by means of temperature difference caused by reaction heat. Coupling of enzyme reactions for increasing reaction heat and consequently sensitivity in calorimetric determinations is demonstrated.     

Gluconeogenesis in periportal and perivenous hepatocytes of rat liver, isolated by a new high-yield digitonin/collagenase perfusion technique.

A technique is described which allows preparations of hepatocytes, enriched in either periportal or perivenous hepatocytes ('PP-cells' and 'PV-cells' respectively), in a yield of about 30-50% compared with control cell preparations. The liver is first perfused for 40-60s with digitonin (4 mg/ml) to destroy selectively either the periportal or the perivenous part of the microcirculatory unit, and then the remaining hepatocytes are isolated by the ordinary collagenase perfusion technique. In periportal cells the activities of alanine aminotransferase and pyruvate kinase were 29.4 and 18.7 mumol/min per mg of DNA respectively. The rate of gluconeogenesis was 0.402 mumol/min per mg of DNA. In perivenous cells the corresponding values were 9.55, 22.1 and 0.244 mumol/min per mg of DNA respectively. These data support the concept of a zonation of glucose metabolism within the microcirculatory unit of the liver, with the afferent part (periportal zone) having a 2-fold, more active gluconeogenesis than the efferent part (perivenous zone).     

Regeneration of NAD(P)H by immobilized whole cells of Clostridium butyricum under hydrogen high pressure

Immobilized whole cells of Clostridium butyricum reduced both NAD(+) and NADP(+) in the presence of hydrogen at a pressure of 100 atm. The NAD(+) and NADP(+) reduction activities were 4.45 and 4.30 U/g dry cells, respectively [U = NAD(P)H regenerated, mu mol/min]. The amount of NADH regenerated by immobilized cells increased with increasing hydrogen pressure above 10 atm. Immobilized cells (6 mg dry cells) of Cl. butyricum completely converted NAD(+) (6.4 mumole) to NADH for 5 h, whereas only 60% of NAD(+) were reduced by free cells. Immobilized cells retained 89% activity after the 5-h reactions were repeated 4 times. L-Alanine was continuously produced at the rate of 12.8 mumol/min g dry cells from hydrogen, ammonium, and pyruvate with immobilized Cl. butyricum-alanine dehydrogenase.     

Initial steps in Haemophilus influenzae transformation. Donor DNA binding in the com10 mutant

The com10 mutant of Haemophilus influenzae binds donor DNA reversibly, but is deficient in uptake. The DNA binding has all the characteristics of interaction with a protein receptor; it is saturable, reversible, and specific. However, binding specificity is 6-fold weaker in com10 than is uptake specificity in wild-type. The binding of small (120 base pairs) and large (14,400 base pairs) DNA molecules were compared. For small molecules, binding data fitted a straight line by Scatchard analysis (Bmax = 4.8 DNA molecules/cell, Kd = 0.5 X 10(-9) M). In contrast, for large DNA molecules, the Scatchard plot was not linear. A high affinity binding (Kd = 0.4 X 10(-12) M) and a lower affinity binding (Kd = 1.2 X 10(-11) M) were found with a total number of 3 molecules bound per cell. In wild-type cells, 3.2 large molecules were taken up per cell, whereas up to 40 small 120-base pair DNA fragments were taken up per cell. Uptake of small DNA molecules followed a Michaelis-Menten function with a Km of 0.5 X 10(-9) M and a maximal initial velocity of 1.5 molecules/cell/min at room temperature. For large DNA molecules, maximal initial velocity was approximately 2 molecules/cell/min at room temperature. The analysis of the binding and uptake data suggest to us that a receptor or a receptor complex is responsible for the uptake of either a single large DNA molecule or, successively, a number of small DNA molecules.     

Monooxygenase activity of rat liver microsomes immobilized by entrapment in a crosslinked prepolymerized polyacrylamide hydrazide

Rat liver microsomes were immobilized by entrapment in a chemically crosslinked synthetic gel obtained by crosslinking prepolymerized polyacrylamide-hydrazide with glyoxal. Approximately 88% of the microsomal fraction was entrapped in the gel. The specific rate of O-demethylation of p-nitroanisole was used to assay the microsomal cytochrome P-450 activity of the immobilized microsomal preparations. The gel entrapped microsomes showed monooxygenase activity at 37 degrees C of Vmax = 2.3 nmol p-nitrophenol/min per nmol cytochrome P-450, similar to that of microsomes in suspension. The Km value for the p-nitroanisole-immobilized microsomal cytochrome P-450 system (1.2 X 10(-5) M) was rather close to that of microsomes in suspension (0.8 X 10(-5) M). Under the experimental conditions used the pH activity curve of the immobilized preparation was shifted towards more alkaline values by approx. 0.5 pH unit in comparison with microsomes in suspension. The rate of cytochrome c reduction by the immobilized microsomal system (11.7 nmol/min per mg protein) at 25 degrees C was considerably lower than that of the control (microsomes in suspension, 78 nmol/min per mg protein). Enzyme activity in both preparations showed the same temperature dependence at the temperature range of 10 to 37 degrees C. The immobilized microsomal monooxygenase system could be operated continuously for several hours at 37 degrees C provided that adequate amounts of an NADPH-generating system were added periodically. Under similar conditions a control microsomal suspension lost its enzymic activity within 90 min.     

ATP Sulfurylase from Penicillium chrysogenum: Is the Internal Level of the Enzyme Sufficient to Account for the Rate of Sulfate Utilization?

The in vivo rate of sulfate activation in Penicillium chrysogenum (wild-type strain ATCC 24791) was determined to be 0.19 +/- 0.09 mumol g(-1) (dry weight) min(-1) by the following methods. (i) The maximum growth of the organism in synthetic medium was a linear function of the initial Na(2)SO(4) concentration between 0 and 8 x 10(-4) Na(2)SO(4). The growth yield was 1.64 x 10(-2) g (dry weight) of mycelium per mumol of added sulfate, corresponding to a minimum sulfur requirement of 61 mumol/g (dry weight). Under these conditions (limiting sulfate) the minimum doubling time of P. chrysogenum in submerged culture was about 3.8 h, corresponding to a maximum exponential growth rate constant of 3.0 x 10(-3) min(-1). If all the sulfur in this mycelium passed through adenosine-5'-phosphosulfate, the rate of sulfate activation in vivo must have been 0.183 mumol min(-1) g(-1) (dry weight). (ii) In the presence of excess (35)SO(4) (2-), the total organic (35)S produced varied with the mycelial growth rate. However, until the culture approached maximum density, the product of [(growth rate constant) x (organic (35)S content)] was nearly constant at 0.24 to 0.28 mumol min(-1) g(-1) (dry weight). (iii) A sulfur-starved mycelium pulsed with 10(-4) M (35)SO(4) (2-) produced organic (35)S at a rate of about 0.10 mumol min(-1) g(-1) (dry weight) under conditions where the internal concentrations of ATP and sulfate would permit ATP sulfurylase to operate at about 70% of its V(max). Cell-free extracts of P. chrysogenum growing rapidly on excess sulfate contained 0.22 U of ATP sulfurylase per g (dry weight). Thus, in spite of the relatively low specific activity of homogeneous ATP sulfurylase (0.13 U/mg of protein, corresponding to an active site turnover of 7.15 min(-1)), the mycelial content of the enzyme was sufficient to account for the observed growth rate of the organism on inorganic sulfate as the sole sulfur source.     

Immobilization of Acetobacter sp. CCTCC M209061 for efficient asymmetric reduction of ketones and biocatalyst recycling

ABSTRACT: BACKGROUND: The bacterium Acetobacter sp. CCTCC M209061 is a promising whole-cell biocatalyst with exclusive anti-Prelog stereoselectivity for the reduction of prochiral ketones that can be used to make valuable chiral alcohols such as (R)-4-(trimethylsilyl)-3-butyn-2-ol. Although it has promising catalytic properties, its stability and reusability are relatively poor compared to other biocatalysts. Hence, we explored various materials for immobilizing the active cells, in order to improve the operational stability of biocatalyst. RESULTS: It was found that Ca-alginate give the best immobilized biocatalyst, which was then coated with chitosan to further improve its mechanical strength and swelling-resistance properties. Conditions were optimized for formation of reusable immobilized beads which can be used for repeated batch asymmetric reduction of 4[prime]-chloroacetophenone. The optimized immobilized biocatalyst was very promising, with a specific activity of 85% that of the free-cell biocatalyst (34.66 mumol/min/g dw of cells for immobilized catalyst vs 40.54 mumol/min/g for free cells in the asymmetric reduction of 4[prime]-chloroacetophenone). The immobilized cells showed better thermal stability, pH stability, solvent tolerance and storability compared with free cells. After 25 cycles reaction, the immobilized beads still retained >50% catalytic activity, which was 3.5 times higher than degree of retention of activity by free cells reused in a similar way. The cells could be recultured in the beads to regain full activity and perform a further 25 cycles of the reduction reaction. The external mass transfer resistances were negligible as deduced from Damkohler modulus Da < <1, and internal mass transfer restriction affected the reduction action but was not the principal rate-controlling step according to effectiveness factors eta < 1 and Thiele modulus 0.3<[empty set] <1. CONCLUSIONS: Ca-alginate coated with chitosan is a highly effective material for immobilization of Acetobacter sp. CCTCC M209061 cells for repeated use in the asymmetric reduction of ketones. Only a small cost in terms of the slightly lower catalytic activity compared to free cells could give highly practicable immobilized biocatalyst.     

Kinetics of mucopolysaccharide and glycoprotein synthesis by chick embryo chondrocytes. Effect of D-glucose concentration in the culture medium.

Late log cultures of chick embryo vertebral chondrocytes in Dulbecco's Modified Eagle's Medium with 10% fetal calf serum consume D-glucose from the culture medium at a rate of approximately 0.40 mumol per h per 10(6) cells. When the D-glucose concentration in the medium drops below 1 mumol per ml the glycogen stores are rapidly exhausted, and cell growth ceases. 35SO4(2)- is incorporated into chondroitin-6-SO4 and chondroitin-4-SO4 at linear rates of 1.2 and 0.4 nmol per h per 10(6) cells, respectively, until the D-glucose level in the medium drops below 1 mumol per ml, but there is always a slight lag in the initial appearance of chondroitin-4-SO4. Throughout the period of 35SO4 2- labeling, the amount of chondroitin-6-SO4 that is recovered in the cells exceeds the amount that is recovered in the medium, but the opposite is true for chondroitin-4-SO4. However, when cells prelabeled with 35SO4(2-) are then transferred to a label-free medium, the secretion of chondroitin sulfates proceeds at much slower rates, and the kinetics of chondroitin-6-SO4 and chondroitin-4-SO4 secretion are very similar. In this chase experiment the chondroitin sulfates are recovered quantitatively after a 24-h incubation period, indicating that these embryonic chondrocytes do not degrade the chondroitin sulfates under these culture conditions. The rate of incorporation of counts from D-[14C]glucosamine into mucopolysaccharides and glycoproteins increase with time. This nonlinear rate results from a progressive increase in the specific activity of the UDP-N-acetyl-D-[14C]hexosamine pool as the D-glucose in the culture medium is depleted. A linear relationship is demonstrated between the logarithm of the 14C counts per min per nmol of UDP-N-acetylhexosamine and the logarithm of the concentration of D-glucose in the culture medium over a range of 1 to 20 mumol of D-glucose per ml. The relative rates of appearance of counts from 35SO4(2-) and D-[14]glucosamine in chondroitin 4-SO4 and chondroitin-6-SO4 are used to calculate the specific activity of the UDP-N-acetyl-D-[14C]hexosamine pool at each stage in the labeling period. The resulting values are then used to calculate the rates of synthesis of the nonsulfated polymers, namely, chondroitin, hyaluronic acid, and glycoprotein.     

Purification and properties of NADH-specific dihydropteridine reductase from human erythrocytes

NADH-specific dihydropteridine reductase (EC 1.6.99.7) has been purified from human erythrocytes in essentially homogeneous form. The molecular weight of the enzyme was estimated to be 46,000 by Sephadex G-100 gel filtration. The enzyme reacted with antiserum against NADH-specific dihydropteridine reductase from bovine liver and formed a single immunoprecipitin line in the Ouchterlony double-diffusion system. This precipitin line completely fused with that formed between the human liver enzyme and the antiserum. With use of 5,6,7,8-tetrahydro-6-methylpterin, Km values of the erythrocyte enzyme for NADH and NADPH were determined to be 0.94 and 47 mumol/l, respectively. Vmax values were 58.7 mumol/min/mg with NADH and 6.41 mumol/min/mg with NADPH. The average activity of NADH-specific dihydropteridine reductase of 9 human blood samples from healthy males (20-25 years old) was calculated to be approximately 600 mU/g of hemoglobin, 1.8 mU per 20 microliters of blood, or 1.9 mU per 10(8) erythrocytes.