有机硅橡胶固定化细胞进行的生物转化

有机硅橡胶固定化细胞进行的生物转化潘冰峰,戴学倩,冯青,李祖义（中国科学院上海有机化学研究所,２０００３２）关键词硅橡胶;白地霉;固定化细胞;生物转化近年来,有机化学领域的一个重要进展是用酶或微生物进行生物转化反应。其中研究和应用较多的是碳基还原,特...     

Improvement of the enantioselectivity and activity of lipase from Pseudomonas sp. via adsorption on a hydrophobic support: kinetic resolution of 2-octanol

Pseudomonas sp. lipase (PSL) was successfully immobilized on a novel hydrophobic polymer support through physical adsorption and the immobilized PSL was used for resolution of (R,S)-2-octanol with vinyl acetate as acyl donor. Enhanced activity and enantioselectivity were observed from the immobilized PSL compared with free PSL. The effects of reaction conditions such as temperature, water activity, substrate molar ratio and the amount of immobilized lipase were investigated. Under optimum conditions, the residual (S)-2-octanol was recovered with 99.5% enantiomeric excess at 52.9% conversion. The results also indicated that the immobilized PSL could maintain 94% of its initial activity even after reusing it five times.     

Asymmetric reduction of 3-chloropropiophenone to (S)-3-chloro-1-phenylpropanol using immobilized Saccharomyces cerevisiae CGMCC 2266 cells

(S)-3-Chloro-1-phenylpropanol is an important chiral precursor for numerous antidepressants such as tomoxetine. A high enantiomeric excess (e.e.) of (S)-3-chloro-1-phenylpropanol can be achieved by asymmetric reduction of 3-chloropropiophenone using Saccharomyces cerevisiae CGMCC 2266 cells immobilized in calcium alginate. Thermal pretreatment of the immobilized cells at 50 °C for 30 min resulted in high enantioselectivity (99% e.e.) and good percent conversion (80%). The effects of various conditions on the reduction reaction were investigated. The optimal conditions were found to be as follows: sodium alginate concentration, 2%; bead diameter, 2 mm; temperature, 30 °C; re-culture time, 24 h; and batch addition of the substrate. After reusing these three times, the immobilized cells retained approximately 60% of their original catalytic activity with their enantioselectivity intact.     

Highly enantioselective reduction of 4-(trimethylsilyl)-3-butyn-2-one to enantiopure (R)-4-(trimethylsilyl)-3-butyn-2-ol using a novel strain Acetobacter sp. CCTCC M209061

The biocatalytic reduction of 4-(trimethylsilyl)-3-butyn-2-one to enantiopure (R)-4-(trimethylsilyl)-3-butyn-2-ol was successfully conducted with high enantioselectivity using immobilized whole cells of a novel strain Acetobacter sp. CCTCC M209061, newly isolated from kefir. Compared with other microorganisms that were investigated, Acetobacter sp. CCTCC M209061 was shown to be more effective for the bioreduction reaction, and afforded much higher yield and product enantiomeric excess (e.e.). The optimal buffer pH, co-substrate concentration, reaction temperature, substrate concentration and shaking rate were 5.0, 130.6 mM, 30 °C, 6.0 mM and 180 r/min, respectively. Under the optimized conditions, the maximum yield and the product e.e. were 71% and >99%, respectively, which are much higher than those reported previously. Additionally, the established biocatalytic system proved to be efficient for the bioreduction of acetyltrimethylsilane to (R)-1-trimethylsilylethanol with excellent yield and product e.e. The immobilized cells manifested a good operational stability under the above reaction conditions since they retained 70% of their catalytic activity after ten cycles of use.     

Asymmetric reduction of (<Emphasis Type="Italic">S</Emphasis>)-3-chloro-1-phenylpropanol from 3-chloropropiophenone by preheated immobilized <Emphasis Type="Italic">Candida</Emphasis> <Emphasis Type="Italic">utilis</Emphasis>

An efficient method for asymmetric reduction of (S)-3-chloro-1-phenylpropanol from 3-chloropropiophenone was developed using preheated Candida utilis cells immobilized in calcium alginate gel beads. Heating the immobilized cells (bead diameter 1.5 mm) at 45°C for 50 min allowed the reaction to proceed with 99.5% enantiomeric excess (ee) and an 85% yield with 1 g substrate l⁻¹ (batch addition in three aliquots) in 48 h. The immobilized cells retained approximately 50% of their original catalytic activity after being reused three times.     

Parametric Studies on Batch Degradation of a Plasticizer Di-n-Butylphthalate by Immobilized Bacillus sp

Summary Di-n-butylphthalate (DBP) is one of the phthalate esters (PAEs) used in the manufacture of plasticizers, insect repellents and synthetic fibres and contributes to environmental pollution. We report a novel bacterium belonging to the genus, Bacillus (NCIM 5220), which has the ability to utilize DBP as the sole source of carbon and energy. This bacterium was immobilized in alginate. The degradation of DBP by immobilized cells was compared with free cells. The effects on the degradation of DBP of different factors like gel (alginate) concentration, gel bead size, temperature, and pH were investigated. Oxygen uptake in the presence of DBP by free and immobilized cells was also studied. The results showed that the degradation of DBP by immobilized cells was more efficient than by free cells. Further, the effect of various factors tested on the degradation of DBP by alginate-immobilized cells showed that the degradation of DBP was remarkably affected by alginate concentration between 2 and 5% and drastically decreased between bead size 2 and 5 mm. A change of 10 °C of reaction temperature from 30 to 40 °C did not alter the degradation of DBP, and maximum degradation was appeared to be favoured over a broad pH range of 6.5–7.5 for immobilized cells as compared to free cells, which showed an optimum temperature of about 35 °C and pH of 7.0. The immobilized cells showed higher oxidation of DBP than free cells. Thus more efficient degradation of DBP could be achieved by immobilizing Bacillus sp. in alginate beads.     

Resolution of 2-octanol by SBA-15 immobilized Pseudomonas sp. lipase

Lipase from Pseudomonas sp. (PSL) was immobilized on SBA-15 (a highly ordered hexagonal array mesoporous silica molecular sieve) through physical adsorption and the immobilized PSL was used in resolution of (R,S)-2-octanol with vinyl acetate as acyl donor. Enhanced activity and enantioselectivity were observed for the immobilized PSL compared with those of the free one. The effects of reaction conditions, such as solvents, temperature, water activity and substrate ratio were investigated. Under the optimum conditions, the residual (S)-2-octanol was recovered with 99% enantiomeric excess at 52% conversion. The results also indicated that the immobilized PSL maintained 90% of its initial activity even after reusing it five times.     

High production of (2s,3s)-3-hydroxy-2-methylbutanoate by immobilized plant cells of Marchantia polymorpha

Cultured plant cells of Marchantia polymorpha were examined for their ability to reduce beta-keto ester, 2-methyl-3-oxobutanoate. The cells reduced ethyl 2-methyl-3-oxobutanoate to predominantly yield the anti-product, ethyl (2S,3S)-3-hydroxy-2-methylbutanoate, with 92% diastereomeric excess and over 99% enantiomeric excess. The use of immobilized cells of M. polymorpha in calcium alginate gel improved the diastereomeric excess of the product (97% de). In addition, the large-scale reduction of 75 g of ethyl 2-methyl-3-oxobutanoate with immobilized M. polymorpha gave the product with 97% de and >99% ee in 92% yield.     

Arthrobacter sp. lipase immobilization for improvement in stability and enantioselectivity

Arthrobacter sp. lipase (ABL, MTCC no. 5125) is being recognized as an efficient enzyme for the resolution of drugs and their intermediates. The immobilization of ABL on various matrices for its enantioselectivity, stability, and reusability has been studied. Immobilization by covalent bonding on sepharose and silica afforded a maximum of 380 and 40 IU/g activity, respectively, whereas sol–gel entrapment provided a maximum of 150 IU/g activity in dry powder. The immobilized enzyme displayed excellent stability in the pH range of 4–10 and even at higher temperature, i.e., 50–60°C, compared to free enzyme, which is unstable under extreme conditions. The resolution of racemic auxiliaries like 1-phenyl ethanol and an intermediate of antidepressant drug fluoxetine, i.e., ethyl 3-hydroxy-3-phenylpropanoate alkyl acylates, provided exclusively R-(+) products (∼99% ee, E=646 and 473), compared to cell free extract/whole cells which gave a product with ∼96% ee (E=106 and 150). The repeated use (ten times) of covalently immobilized and entrapped ABL resulted in no loss in activity, thus demonstrating its prospects for commercial applications.     

Enantioselective behavior of lipases from <Emphasis Type="Italic">Aspergillus niger</Emphasis> immobilized in different supports

Considering the extraordinary microbial diversity and importance of fungi as enzyme producers, the search for new biocatalysts with special characteristics and possible applications in biocatalysis is of great interest. Here, we report the performance in the resolution of racemic ibuprofen of a native enantioselective lipase from Aspergillus niger, free and immobilized in five types of support (Accurel EP-100, Amberlite MB-1, Celite, Montmorillonite K10 and Silica gel). Amberlite MB-1 was found to be the best support, with a conversion of 38.2%, enantiomeric excess of 50.7% and enantiomeric ratio (E value) of 19 in 72 h of reaction. After a thorough optimization of several parameters, the E value of the immobilized Aspergillus niger lipase was increased (E = 23) in a shorter reaction period (48 h) at 35°C. Moreover, the immobilized Aspergillus niger lipase maintained an esterification activity of at least 80% after 8 months of storage at 4°C and could be reused at least six times.     

Enantioselective esterification of ibuprofen in supercritical carbon dioxide by immobilized lipase

The enantioselective esterification of racemic ibuprofen with n-propanol by immobilized Mucor miehel lipase in supercritical carbon dioxide was studied. The enantiomeric excess of the product (ee_p) was 70 % at 15...20 % conversion. The enantioselectivity was faintly affected by temperature and the concentration of ibuprofen and lipase. The optimum temperature was 45 °C. The initial reaction rate increased with pressure, but enantioselectivity was not affected by pressure changes. The reaction rates in supercritical carbon dioxide at optimized conditions and in n-hexane were similar.     

Isolation and characterization of Acinetobacter sp. ES-1 excreting a lipase with high enantioselectivity for (S)-ketoprofen ethyl ester

A new Acinetobacter sp. ES-1, grown on triolein, tryptone and Triton X-100, excreted a lipase that hydrolyzed 10m M (R,S)-ketoprofen ethyl ester into (S)-ketoprofen. The crude lipase had an activity of 10Uml^-1 and, at 30°C and pH7 over 48h, gave a conversion yield of 35% with an enantiomeric excess for the product 96%.     

Kinetic resolution of α-lipoic acid via enzymatic differentiation of a remote stereocenter

Kinetic resolution of α-lipoic acid, a case of remote stereocenter discrimination, was accomplished using lipase from Aspergillus oryzae WZ007. Performance of this lipase was investigated for enantioselective esterification of (S)-α-lipoic acid, leaving the target product (R)-α-lipoic acid in unreacted form. The effects of chain length of alcohol, type of solvent, molar ratio of alcohol:acid, and reaction temperature were studied. The optimum reaction conditions were found to be esterification with n-octanol at 50°C in heptane with an alcohol:acid molar ratio of 5:1. The conversion rate of α-lipoic acid was 75.2%, with an enantiomeric excess of 92.5% towards unreacted substrate in a reaction time of 48 h.     

Stereochemical Control in Microbial Reduction. Part 10. Asymmetric Reduction of Alkyl 3-Methyl-2-Oxobutanoate with Immobilized Bakers' Yeast in Hexane

Esters of 3-methyl-2-oxobutanoic acid are reduced with bakers' yeast by three methods: free bakers' yeast in water, immobilized bakers' yeast in water, and immobilized bakers' yeast in hexane. Although (R)-hydroxy esters are obtained in all cases, the enantiomeric excess varies from 3% (reduction of the methyl ester with free bakers' yeast in water) to 93% (reduction of the butyl ester with immobilized bakers' yeast in hexane) depending on the structure of substrate and on the reaction conditions. The mechanism of the present stereochemical control is discussed.     

Microbial production of optically active β-phenylalanine ethyl ester through stereoselective hydrolysis of racemic β-phenylalanine ethyl ester

The ability to produce (R)- or (S)-β-phenylalanine ethyl ester (3-amino-3-phenylpropionic acid ethyl ester, BPAE) from racemic BPAE through stereoselective hydrolysis was screened for in BPAE-assimilating microorganisms. Sphingobacterium sp. 238C5 and Arthrobacter sp. 219D2 were found to be potential catalysts for (R)- and (S)-BPAE production, respectively. On a 24-h reaction, with 2.5% (w/v) racemic BPAE (130 mM) as the substrate and wet cells of Sphingobacterium sp. 238C5 as the catalyst, 1.15% (w/v) (R)-BPAE (60 mM) with enantiomeric purity of 99% e.e. was obtained, the molar yield as to racemic BPAE being 46%. On a 48-h reaction, with 2.5% (w/v) racemic BPAE (130 mM) as the substrate and wet cells of Arthrobacter sp. 219D2 as the catalyst, 0.87% (w/v) (S)-BPAE (45 mM) with enantiomeric purity of 99% e.e. was obtained, the molar yield as to racemic BPAE being 35%. The enzyme stereoselectively hydrolyzing (S)-BPAE was purified to homogeneity from the cell-free extract of Sphingobacterium sp. 238C5. The enzyme was a monomeric protein with a molecular mass of about 42,000. The enzyme catalyzed hydrolysis of β-phenylalanine esters, while the common aliphatic and aromatic carboxylate esters were not catalyzed.     

Parameters influencing asymmetric synthesis of (R)-mandelonitrile by a novel (R)-hydroxynitrile lyase from Eriobotrya japonica

(R)-Mandelonitrile was successfully synthesized by an enzymatic transcyanation reaction of benzaldehyde and acetone cyanohydrin catalyzed by a hydroxynitrile lyase from Eriobotrya japonica (EjHNL) in an aqueous-organic biphasic system. The effects of pH, temperature, organic solvent, substrate concentration and enzyme concentration on the initial activity and enantioselectivity of the enzyme were studied. Both pH and temperature had a large effect on the initial velocity and enantiomeric excess (e.e.) of the product, (R)-mandelonitrile. High enantiomeric purity of the product was observed at low pH and temperature because the non-enzymatic reaction producing racemates of mandelonitrile was almost suppressed. The optimum pH and temperature to obtain high e.e. were pH 4.0 and 10 °C, respectively. Surprisingly, the organic solvents had a significant influence on the initial velocity of the reaction but less influence on the enantiomeric purity of product. The EjHNL was very stable in ethyl acetate, diethyl ether, methyl-t-butyl ether, diisopropyl ether, dibutyl ether and hexane for 12 h. The best solvent for the highest initial velocity and e.e. was diethyl ether with an optimum aqueous phase content of 50% (v/v). The initial reaction rate increase as the aqueous phase content rose, but when the content was more than 50%, a reduction of e.e. was observed. Increasing the concentration of the substrates accelerated the initial velocity, but caused a slight decrease in the e.e. of the product. Under the optimized conditions, the conversion and e.e. of (R)-mandelonitrile for 3 h were 40 and 99%, respectively. The aqueous phase containing the enzyme also showed considerably efficient reusability for 4 batch reactions.     

Resolution of 2-octanol via immobilized Pseudomonas sp. lipase in organic medium

Abstract

Pseudomonas sp. lipase (PSL) immobilization was performed using three different protocols. Lipase immobilized on Diaion HP20 (HP20-PSL) exhibited the highest catalytic activity and stability in the kinetic resolution of racemic 2-octanol. The reaction rate of HP20-PSL was approximately 20 times higher than that of free PSL and the residual activities of HP20-PSL and free PSL were respectively 84% and 19% after incubation in the reaction medium for 72 h. A study of the effect of different reaction parameters on HP20-PSL-catalyzed resolution of (R,S)-2octanol showed that the optimal water content of the immobilized matrix and the optimal molar ratio of vinyl acetate to 2-octanol were 60 ± 5% and 2.5:1, respectively. Under the optimized reaction conditions, (S)-2-octanol of high optically purity (enantiomeric excess > 99%) could be recovered at 53% conversion rate, and HP20-PSL could be reused for ten cycles without significant decrease in its activity and enantioselectivity.     

Stereochemical Control in Microbial Reduction. Part 10. Asymmetric Reduction of Alkyl 3-Methyl-2-Oxobutanoate with Immobilized Bakers' Yeast in Hexane

Esters of 3-methyl-2-oxobutanoic acid are reduced with bakers' yeast by three methods: free bakers' yeast in water, immobilized bakers' yeast in water, and immobilized bakers' yeast in hexane. Although (R)-hydroxy esters are obtained in all cases, the enantiomeric excess varies from 3% (reduction of the methyl ester with free bakers' yeast in water) to 93% (reduction of the butyl ester with immobilized bakers' yeast in hexane) depending on the structure of substrate and on the reaction conditions. The mechanism of the present stereochemical control is discussed.     

Enhancing the catalytic potential of nitrilase from Pseudomonas putida for stereoselective nitrile hydrolysis

(R)-mandelic acid was produced from racemic mandelonitrile using free and immobilized cells of Pseudomonas putida MTCC 5110 harbouring a stereoselective nitrilase. In addition to the optimization of culture conditions and medium components, an inducer feeding approach is suggested to achieve enhanced enzyme production and therefore higher degree of conversion of mandelonitrile. The relationship between cell growth periodicity and enzyme accumulation was also studied, and the addition of the inducer was delayed by 6 h to achieve maximum nitrilase activity. The nitrilase expression was also authenticated by the sodium dodecyl phosphate-polyacrylamide gel electrophoresis analysis. P. putida MTCC 5110 cells were further immobilized in calcium alginate, and the immobilized biocatalyst preparation was used for the enantioselective hydrolysis of mandelonitrile. The immobilized system was characterized based on the Thiele modulus (ϕ). Efficient biocatalyst recycling was achieved as a result of immobilization with immobilized cells exhibiting 88% conversion even after 20 batch recycles. Finally, a fed batch reaction was set up on a preparative scale to produce 1.95 g of (R)-(-)-mandelic acid with an enantiomeric excess of 98.8%.     

Enantioselective hydrolysis of (R)-2, 2-dimethylcyclopropane carboxamide by immobilized cells of an R-amidase-producing bacterium, Delftia tsuruhatensis CCTCC M 205114, on an alginate capsule carrier

Immobilized cells of Delftia tsuruhatensis CCTCC M 205114 harboring R-amidase were applied in asymmetric hydrolysis of (R)-2, 2-dimethylcyclopropane carboxamide (R − 1) from racemic (R, S)-2, 2-dimethylcyclopropane carboxamide to accumulate (S)-2, 2-dimethylcyclopropane carboxamide (S − 1). Maximum R-amidase activity of 13.1 U/g wet cells (0.982 U/g beads) was obtained under conditions of 3% sodium alginate, 2.5% CaCl₂, 15 h crosslinking and 2 mm bead size, which was 53.9% of that of free cells (24.3 U/g wet cells). In addition, characterization of the immobilized cells was examined. The optimum R − 1 hydrolysis conditions were identified as follows: substrate concentration 10 mM, pH 8.5, temperature 35°C and time course 40 min. Under optimum conditions, the maximum yield and enantiomeric excess of (R)-2, 2-dimethylcyclopropanecarboxylic acid were 49.5% and >99%, respectively. This afforded S − 1 with a yield >49% and an e.e. of 97.7%. With good operational stability and excellent enanotioselectivity, the immobilized cells could be potentially utilized in industrial production of S − 1.