Biosensor system for continuous flow determination of enzyme activities. II. Simultaneous determination of plural enzyme activities.

A biosensor system for continuous flow determination of plural enzyme activities was prepared from the combination of two pyruvate sensors, a prereactor and a flow cell. This system was applied to the simultaneous determination of lactic dehydrogenase (LDH) and glutamic-pyruvic transaminase (GPT) activities in the same sample. These enzyme activities can be determined by measuring pyruvate produced by the enzyme reactions as follows. The amount of pyruvic acid can also be determined from the amount of oxygen consumed upon oxidation of pyruvic acid by pyruvate oxidase. (Formula: see text). Therefore, both of the detectors for the determination of lactic dehydrogenase and glutamic-pyruvic transaminase activities were prepared from the combination of a pyruvate oxidase membrane and an oxygen electrode. Pyruvate oxidase was covalently immobilized on a membrane prepared from cellulose triacetate. A linear relation was obtained between the output current and LDH or GPT activities in the range of 50 to 3,600 IU l-1 or 6 to 1,000 IU l-1, respectively. Each assay of these enzyme activities was completed within 15 min. The results obtained had a precision of ca. 4%. The sensor was stable for more than 25 days at 5 degrees C.     

Enzyme-entrapping membranes for biosensors obtained by radiation-induced polymerization

A new method of physically immobilizing enzymes in poly(2-hydroxyethyl methacrylate) membranes was developed in order to obtain suitable biosensors. It was possible to prepare an enzyme sensor based on an oxygen Clark electrode and on glucose oxidase immobilized by low-temperature gamma radiation-induced polymerization. Temperature and pH effects on the activity of immobilized enzyme are described and the response characteristics of the resulting biosensor are summarized. The determination of glucose in standard solutions was carried out and a linear calibration curve, with an R² value of 0·9993, from the detection limit 5 × 10⁻⁵ to 1·2 × 10⁻³ was obtained. The biosensor was employed to analysis of control sera and the results were compared to those obtained by enzymatic-spectrophotometric detection.     

Strain improvement and metabolic flux analysis in the wild-type and a mutant Lactobacillus lactis strain for L(+)-lactic acid production

The effects of initial glucose concentration and calcium lactate concentration on the lactic acid production by the parent strain, Lactobacillus lactis BME5-18, were studied. The results of the experiments indicated that glucose and lactate repressed the cell growth and the lactic acid production by Lactobacillus lactis BME5-18. A L(+)-lactic acid overproducing strain, Lactobacillus lactis BME5-18M, was screened by mutagenizing the parent strain with ultraviolet (UV) light irradiation and selecting the high glucose and lactate calcium concentration repression resistant mutant. Starting with a concentration of 100g L(-1) glucose, the mutant produced 98.6 g L(-1) lactic acid after 60 h in flasks, 73.9% higher than that of the parent strain. The L(+)-lactic acid purity was 98.1% by weight based on the amount of total lactic acid. The culture of the parent strain could not be analyzed well by conventional metabolic flux analysis techniques, since some pyruvate were accumulated intracellularly. Therefore, a revised flux analysis method was proposed by introducing intracellular pyruvate pool. Further studies demonstrate that there is a high level of NADH oxidase activity (12.11 mmol mg(-1) min(-1)) in the parent strain. The molecular mechanisms of the strain improvement were proposed, i.e., the high level of NADH oxidase activity was eliminated and the uptake rate of glucose was increased from 82.1 C-mmol (g DW h)(-1) to 98.9 C-mmol (g DW h)(-1) by mutagenizing the parent strain with UV, and therefore the mutant strain converts mostly pyruvate to lactic acid with a higher productivity (1.76 g L(-1) h(-1)) than the parent strain (0.95 g L(-1) h(-1)).     

Physiological role of pyruvate oxidase in the aerobic metabolism of Lactobacillus plantarum.

Under aerobic growth conditions Lactobacillus plantarum produced acetic acid in addition to lactic acid. It was found that lactic acid was predominantly produced at first, and then when the carbohydrate was nearly exhausted, lactic acid was metabolized further to acetic acid. The most likely enzyme involved in the aerobic metabolism of L. plantarum is pyruvate oxidase. Its activity is enhanced in the presence of oxygen and is reduced in the presence of glucose. The specific activity of pyruvate oxidase is highest at the beginning of the stationary-growth phase, where a strong increase in acetic acid production was also observed.     

Organic charge transfer complex based printable biosensor

This paper describes the preparation of an organic charge transfer complex (CTC) based printable enzyme electrode. CTC crystals were prepared by mixing TCNQ powder with TTF solution (in acetonitrile). Glucose oxidase (GOD) was adsorbed at the CTC crystal surface in a monolayer. A printable paste was prepared by mixing GOD-adsorbed crystals with a binder and a solvent. This paste was applied to an electrode cavity and vacuum dried. A thin layer of gelatin was cast on the paste filled dried electrode, and cross-linked with glutaraldehyde in the dry condition. The sensors were fixed in a flow injection system, and continuously polarized at 0·15 V and 37°C, and the samples were automatically injected every 30 min. The developed sensors produced a huge response curren with an extended linear range of detection (0–100 mM) and the response was unaffected by the presence of normal oxygen in the buffer solution. The sensor showed excellent stability. The performance of the sensors was significantly influenced by the binder used.     

Pyruvic acid production by a lipoic acid auxotroph of Escherichia coliW1485

A lipoic acid auxotroph of Escherichia coli K-12, strain W1485lip2 (ATCC25645), produced pyruvic acid aerobically from glucose under the lipoic acid-deficient conditions, while the prototrophic parent strain, W1485 (ATCC12435), produced 2-oxoglutaric acid as the main product. The mechanism of the pyruvic acid production by strain W1485lip2 was found to be the impaired oxidative decarboxylation of pyruvic acid caused by the decrease in the activity of pyruvate dehydrogenase complex under the conditions of lipoic acid deficiency. Under the optimum culture conditions using the pH-controlled jar fermentor, 25.5?g/l pyruvic acid was obtained from 50?g/l glucose after the culture for 32–40?h at pH?6.0. The relationship between the pyruvic acid productivity and the pyruvate dehydrogenase complex activity in jar-fermentor culture was discussed.     

Pyruvic acid production by a lipoic acid auxotroph of Escherichia coliW1485

A lipoic acid auxotroph of Escherichia coli K-12, strain W1485lip2 (ATCC25645), produced pyruvic acid aerobically from glucose under the lipoic acid-deficient conditions, while the prototrophic parent strain, W1485 (ATCC12435), produced 2-oxoglutaric acid aas the main product. The mechanism of the pyruvic acid production by strain W1485lip2 was found to be the impaired oxidative decarboxylation of pyruvic acid caused by the decrease in the activity of pyruvate dehydrogenase complex under the conditions of lipoic acid deficiency. Under the optimum culture conditions using the pH-controlled jar fermentor, 25.5 g/l pyruvic acid was obtained from 50 g/l glucose after the culture for 32–40 h at pH6.0. The relationship between the pyruvic acid productivity and the pyruvate dehydrogenase complex activity in jar-fermentor culture was discussed.     

Efficient homolactic fermentation by Kluyveromyces lactis strains defective in pyruvate utilization and transformed with the heterologous LDH gene.

A high yield of lactic acid per gram of glucose consumed and the absence of additional metabolites in the fermentation broth are two important goals of lactic acid production by microrganisms. Both purposes have been previously approached by using a Kluyveromyces lactis yeast strain lacking the single pyruvate decarboxylase gene (KlPDC1) and transformed with the heterologous lactate dehydrogenase gene (LDH). The LDH gene was placed under the control the KlPDC1 promoter, which has allowed very high levels of lactate dehydrogenase (LDH) activity, due to the absence of autoregulation by KlPdc1p. The maximal yield obtained was 0.58 g g(-1), suggesting that a large fraction of the glucose consumed was not converted into pyruvate. In a different attempt to redirect pyruvate flux toward homolactic fermentation, we used K. lactis LDH transformant strains deleted of the pyruvate dehydrogenase (PDH) E1alpha subunit gene. A great process improvement was obtained by the use of producing strains lacking both PDH and pyruvate decarboxylase activities, which showed yield levels of as high as 0.85 g g(-1) (maximum theoretical yield, 1 g g(-1)), and with high LDH activity.     

Schistosomatium douthitti: carbohydrate metabolism in the adults.

Pathways of carbohydrate metabolism in the adults of Schistosomatium douthitti: were investigated. Histochemical reactions for adenosinetriphosphatase (EC 3.6.1.3) glucose 6-phosphate dehydrogenase (EC 1.1.1.49), phosphogluconate dehydrogenase (EC 1.1.1.43), glycerol-3-phosphate dehydrogenase (EC 1.1.1.8), lactate dehydrogenase (EC 1.1.1.27, 1.1.2.3) isocitrate dehydrogenase (EC 1.1.1.41), succinate dehydrogenase (EC 1.3.99.1), malate dehydrogenase (EC 1.1.1.37), cytochrome oxidase (EC 1.9.3.1), and adenosine triphosphatase (EC 3.6.1.3) were found in the adult worms. Glycogen deposits occurred in the parenchyma.Low oxygen tension immobilized the worms. Tartar emetic, sodium cyanide reduced adult motility in vitro. Manometric experiments demonstrated a respiratory quotient of approximately one. Oxygen uptake was completely inhibited by tartar emetic and partially inhibited by sodium fluoracetate and sodium cyanide. Inhibition by sodium fluoroacetate was partially counteracted by citric acid in the medium.Adults demonstrated an oxygen debt following anaerobic incubation. A maximum of 52% of the glucose consumed under aerobic conditions was excreted as lactic acid. Under anaerobic conditions the amount of lactic acid excreted increased. Acids other than lactic acid were also released. Results indicate that although glycolysis is the major pathway, two additional aerobic pathways also exist, one which is cyanide sensitive and the other cyanide insensitive.     

Effect of Anaplerotic Pathways Activation on CO<Subscript>2</Subscript>-dependent Anaerobic Glucose Utilization by <Emphasis Type="Italic">Escherichia coli</Emphasis> Strains Deficient in the Main Pathways of Mixed Acid Fermentation

The effect of anaplerotic pathways activation on CO₂-dependent anaerobic glucose utilization by Escherichia coli strains deficient in the main fermentation pathways and possessing a modified system of glucose transport and phosphorylation was studied. Intracellular CO₂ generation in the strains was ensured resulting from oxidative decarboxylation of pyruvic acid by pyruvate dehydrogenase. Sodium bicarbonate dissolved in the medium was used as an external source of CO₂. The genes of heterologous pyruvate carboxylase and native NADH-dependent malic enzyme were overexpressed in the strains to allow anaplerotic carboxylation of pyruvic acid to oxaloacetic or malic acid. The ability of the strains to reoxidize NADH utilizing carboxylation products was additionally increased due to enhanced expression of malate dehydrogenase gene. In the case of endogenous CO₂ formation, the activation of anaplerotic pathways did not cause a notable increase in the anaerobic glucose consumption by the constructed strains. At the same time, the expression of pyruvate carboxylase led to a pronounced decrease in the secretion of pyruvic acid with the concomitant increase in the yield of four-carbon metabolites. Further enhancement of NADH-dependent malic enzyme expression provoked activation of a pyruvate–oxaloacetate–malate–pyruvate futile cycle in the strains. The availability in the medium of the external CO₂ source sharply increased the anaerobic utilization of glucose by strains expressing pyruvate carboxylase. The activity of the futile cycle has raised with the increased malic enzyme expression and dropped upon enhancement of malate dehydrogenase expression. As a result, the efficiency of CO₂-dependent anaerobic glucose utilization coupled to the formation of four-carbon carboxylation products increased in the studied strains resulting from the primary anaplerotic conversion of pyruvic acid into oxaloacetic acid followed by the involvement of the precursor formed in NADH-consuming biosynthetic reactions dominating over the reactions of the revealed futile cycle.     

The function of a hydrogen peroxide-detecting electroenzymatic glucose electrode is markedly impaired in human sub-cutaneous tissue and plasma

Electroenzymatic glucose sensors implanted into sub-cutaneous (s.c.) tissue of human subjects and experimental animals exhibit lower sensitivities to glucose than in buffer solutions before implantation. The mechanism of the decrease of sensitivity is not known. Sensors used in this study were fabricated from platinum wires (diameter 0.125 mm) with covalently bound glucose oxidase at the tip of the wire. After coating the tip with polyurethane, wires were placed into 27 gauge steel needles. Sensors were operated potentiostatically at 700 mV against Ag/AgCl pseudo-reference electrodes. These sensors were implanted s.c. in 6 diabetic patients for 7 h. In 4 patients, sensors were responsive to successive increases of plasma glucose levels. Mean sensitivity to glucose in s.c. tissue was 29% of in vitro sensitivity. In 2 patients there was a sudden decrease of sensor currents, unrelated to glucose, shortly after implantation. Sensors were inhibited in human plasma to a similar extent. When sensors were exposed to native plasma and to plasma ultrafiltrate (mol. wt. <10 kDa) for 10 h, identical decreases of signals were found. Exposure to dialysed plasma (mol. wt. >12 kDa) caused much less decrease of sensor signals. Losses of sensor sensitivities to glucose in s.c. tissue and in plasma were totally reversible upon re-exposure of sensors to buffer solutions. We conclude that sensor inactivation in plasma and possibly in s.c. tissue is caused by low molecular weight substances not retained by the polyurethane membrane.     

Utilization of pyruvate and pyruvate precursors by normal and carcinogen-altered rat tracheal epithelial cells in culture

The metabolism of [14C]pyruvate, [14C]glucose, [14C]glutamine and [14C]alanine was compared between normal rat tracheal epithelial cells and carcinogen-altered cells derived from dimethylbenz(a)anthracene-exposed tracheal implants. Normal primary cultures (NPC) of tracheal cells are distinguished by their need for pyruvate-supplemented medium for growth and survival. The altered cells were selected out by their survival in the unsupplemented medium. Compared to the selected primary cultures (SPC), the NPC showed a three- to four-fold higher incorporation of radioactivity from [2-14C]pyruvate in all the macromolecular fractions, as well as in all the metabolites isolated from the acid soluble fraction and from lactic acid isolated from the medium. [U-14C]glucose was also incorporated at higher levels into lactic acid isolated from the acid soluble fraction and the medium of NPC. These data indicate a higher rate of glycolysis in the normal tracheal cells. This was supported by the findings of a two-fold greater glucose consumption and two-fold higher production of lactic acid isolated from the NPC medium. Lactate dehydrogenase activity was also two-fold higher in NPC. Thus, despite the apparently higher level of pyruvate production in the NPC, exogenous pyruvate is necessary to satisfy the metabolic needs of NPC. The utilization of [U-14C]glutamine or [U-14C]alanine was not markedly different between NPC and SPC. Furthermore, radioactivity from both of the amino acids was recovered in lactic acid in the medium, indicating that both cell types can derive pyruvic acid from either glutamine or alanine. SPC apparently do not use these routes to supply higher levels of pyruvic acid for survival in culture. The oxidation of none of the radioactive metabolites into CO2 was distinctly different between NPC and SPC except for the 1.7-fold higher utilization of [1-14C]glucose along the oxidative arm of the pentose cycle in the normal cells.     

乳酸菌风味代谢物质的基因调控

乳酸菌的主要风味代谢物质包括丁二酮,乙醛以及各种氨基酸。利用基因工程和代谢工程的相关技术提高乙醛和丁二酮产量,是当前乳酸菌研究的热点之一。乙醛的代谢调控主要是针对丝氨酸羟甲基转移酶的表达进行调控,或是针对丙酮酸脱羧酶和NADH氧化酶的表达采用联合调控策略;而丁二酮的代谢调控则主要集中于乳酸脱氢酶、NADH氧化酶、α-乙酰乳酸合成酶和α-乙酰乳酸脱羧酶中任意两种关键酶基因间的联合调控,并且存在进行乳酸脱氢酶,α-乙酰乳酸合成酶和α-乙酰乳酸脱羧酶3种关键酶基因联合调控的可行性。     

Glucose metabolism and NADH recycling by Treponema hyodysenteriae, the agent of swine dysentery.

Glucose metabolism and the mechanisms of NADH oxidation by Treponema hyodysenteriae were studied. Under an N2 atmosphere, washed cell suspensions of the spirochete consumed glucose and produced acetate, butyrate, H2, and CO2. Approximately twice as much H2 as CO2 was produced. Determinations of radioactivity in products of [14C]glucose and [14C]pyruvate metabolism and analyses of enzyme activities in cell lysates revealed that glucose was catabolized to pyruvate via the Embden-Meyerhof-Parnas pathway. The results of pyruvate exchange reactions with NaH14CO3 and Na14COOH demonstrated that pyruvate was converted to acetyl coenzyme A (acetyl-CoA), H2, and CO2 by a clostridium-type phosphoroclastic mechanism. NADH:ferredoxin oxidoreductase and hydrogenase activities were present in cell lysates and produced H2 from NADH oxidation. Phosphotransacetylase and acetate kinase catalyzed the formation of acetate from acetyl-CoA. Butyrate was formed from acetyl-CoA via a pathway that involved 3-hydroxybutyryl-coenzyme A (CoA) dehydrogenase, butyryl-CoA dehydrogenase, and butyryl-CoA transferase. T. hyodysenteriae cell suspensions generated less H2 and butyrate under 10% O2-90% N2 than under 100% N2. Cell lysates contained NADH oxidase, NADH peroxidase, and superoxide dismutase activities. These findings indicated there are three major mechanisms that T. hyodysenteriae cells use to recycle NADH generated from the Embden-Meyerhof-Parnas pathway--enzymes in the pathway from acetyl-CoA to butyrate, NADH:ferredoxin oxidoreductase, and NADH oxidase. Versatility in methods of NADH oxidation and an ability to metabolize oxygen could benefit T. hyodysenteriae cells in the colonization of tissues of the swine large bowel.     

Amplifying the cellular reduction potential of Streptococcus zooepidemicus

The valuable pharmaceutical polymer, hyaluronic acid, is produced industrially using the gram-positive bacterium Streptococcus zooepidemicus. Synthesis of this polymer is a significant energetic burden upon the microorganism hence the native NADH oxidase gene was cloned and overexpressed to increase the energy yield of catabolism during aerobic cultivation on glucose. Elevated NADH oxidase levels led to a decline in lactic acid generation and prevented ethanol formation, leaving acetate as the main fermentation product. Biomass yield increased due to the energy gained from the formation of acetate. Evaluation of the acetate flux control coefficient over a range of NADH oxidase expression levels revealed that acetate production was sensitive to the NADH oxidase level. However, at high NADH oxidase levels, the acetate flux was mainly influenced by another factor. The concomitant excretion of pyruvate at high NADH oxidase levels suggested that the flux through the pyruvate dehydrogenase enzyme complex was limiting the conversion of pyruvate to acetate.     

Amperometric glucose sensor based on coimmobilization of glucose oxidase and Poly(p-phenylenediamine) at a platinum microdisk electrode

A miniaturized glucose biosensor in which glucose oxidase (GOD) and poly(p-phenylenediamine) (poly-PPD) were coimmobilized at the surface of a platinum microdisk electrode was developed and used successfully for amperometric determination of glucose. The performance of sensors prepared at different monomer concentrations and polymerization potentials with different media was investigated in detail. It was found that similarly to poly(o-phenylenediamine) (poly-OPD), (poly-PPD) noticeably eliminated the electrochemical interference of ascorbic acid, uric acid, and l-cysteine. The amperometric response of glucose with the biosensor under optimal conditions exhibited a linear relationship in the range of 5.0 x 10(-5) to 3.0 x 10(-3) M with correlation coefficient 0.9995. According to the Michaelis-Menten equation, the apparent Michaelis constant for glucose and the maximum steady-state current density of the poly-PPD/GOD-modified microelectrode were 3.94 mM and 607.5 microA cm(-2), respectively. The current density of the sensor responding to glucose in the linear range can reach 160 microA cm(-2) mM(-1), which is far greater than that obtained using poly-OPD and poly(phenol) film. In addition, the stability of the sensor was examined over a 2-month period.     

Glucose metabolism and dehydrogenase activities in the cytosol and mitochondria of mouse LS cells in chemostat culture

Summary Energy metabolism has been examined in mouse LS cells growing under steady-state conditions in chemostat culture. The metabolic quotient of glucose oxidized (glucose consumed, but not fermented) remained constant, independent of growth rate between cell doubling times of 6 days and 1.2 days. Specific activities of cytochrome oxidase and malate dehydrogenase in the mitochondria remained constant at different growth rates, in accord with the constancy of the glucose oxidation rate. Cytosolic malate dehydrogenase activity was about fourfold greater than the mitochondrial isozyme. The steady-state rate of lactate production fluctuated because of technical limitations but correlated well with cytosolic lactate dehydrogenase activity. This work was supported by Grant A-3458 from the National Sciences and Engineering Research Council Canada.     

Optimization of a polypyrrole glucose oxidase biosensor

An amperometric glucose biosensor was fabricated by the electrochemical polymerization of pyrrole onto a platinum electrode in the presence of the enzyme glucose oxidase in a KCl solution at a potential of + 0·65 V versus SCE. The enzyme was entrapped into the polypyrrole film during the electropolymerization process. Glucose responses were measured by potentio-statting the enzyme electrode at a potential of + 0·7 V versus SCE in order to oxidize the hydrogen generated by the oxidation of glucose by the enzyme in the presence of oxygen. Experiments were performed to determined the optimal conditions of the polypyrrole glucose oxidase film preparation (pyrrole and glucose oxidase concentrations in the plating solution) and the response to glucose from such electrodes was evaluated as a function of film thickness, pH and temperature. It was found that a concentration of 0·3 M pyrrole in the presence of 65 U/ml of glucose oxidase in 0·01 M KCl were the optimal parameters for the fabrication of the biosensor. The optimal response was obtained for a film thickness of 0·17 μm (75 mC/cm²) at pH 6 and at a temperature of 313 K. The temperature dependence of the amperometric response indicated an activation energy of 41 kJ/mole. The linearity of the enzyme electrode response ranged from 1·0 mM to 7·5 mM glucose and kinetic parameters determined for the optimized biosensors were 33·4 mM for the K_m and 7·2 μA for the I_max. It was demonstrated that the internal diffusion of hydrogen peroxide through the polypyrrole layer to the platinum surface was the main limiting factor controlling the magnitude of the response of the biosensor to glucose. The response was directly related to the enzyme loading in the polypyrrole film. The shelf life and the operational stability of the optimized biosensor exceed 500 days and 175 assays, respectively. The substrate specificity of the entrapped glucose oxidase was not altered by the immobilization procedure.     

Glucose-sensing carbon paste electrode containing polyethylene glycol-modified glucose oxidase

Polyethylene glycol-modified glucose oxidase (PEG-GOD) was prepared. Carbon paste (CP) containing PEG-GOD retained enzyme activity of 0·02 U cm⁻². Anodic and cathodic peak currents of modified GOD in CP matrix were observed on the differential pulse voltammograms at the potential of −0·36 and −0·36 V vs. Ag/AgCl, respectively. The addition of glucose to a test solution brought about an increase in the anodic current on the PEG-GOD-based electrode at the potential as low as 0·0 V vs. Ag/AgCl. The current increase was proportional to the concentration of glucose up to 50 mM.     

Stable mediated amperometric biosensors using a graphite electrode embedded with tetrathiafulvalene in silicone oil

A new method has been developed to incorporate the mediator, tetrathiafulvalene (TTF), to the electrode/solution interface of an amperometric biosensor. TTF was dissolved in methylphenyl polysiloxane (silicone oil) and embedded in a graphite disc electrode. The mediator was able to diffuse to the electrode surface at an electrocatalytically significant speed. The storage of TTF in the inert polysiloxane provided a long-lasting and stable mediator supply.

TTF-silicone oil electrodes with immobilized glucose oxidase, xanthine oxidase, or amino acid oxidase exhibited sensitive, fast and reproducible responses. The glucose oxidase electrode was very stable for at least 2 months when stored at 4°C. Together with flow injection analysis (FIA), the enzyme electrodes were reused for at least 500 repeated analyses during a 25 h operation without losing their initial activity.