Intracellular Accumulation of Trehalose Protects Lactococcus lactis from Freeze-Drying Damage and Bile Toxicity and Increases Gastric Acid Resistance

Interleukin-10 (IL-10) is a promising candidate for the treatment of inflammatory bowel disease. Intragastric administration of Lactococcus lactis genetically modified to secrete IL-10 in situ in the intestine was shown to be effective in healing and preventing chronic colitis in mice. However, its use in humans is hindered by the sensitivity of L. lactis to freeze-drying and its poor survival in the gastrointestinal tract. We expressed the trehalose synthesizing genes from Escherichia coli under control of the nisin-inducible promoter in L. lactis. Induced cells accumulated intracellular trehalose and retained nearly 100% viability after freeze-drying, together with a markedly prolonged shelf life. Remarkably, cells producing trehalose were resistant to bile, and their viability in human gastric juice was enhanced. None of these effects were seen with exogenously added trehalose. Trehalose accumulation did not interfere with IL-10 secretion or with therapeutic efficacy in murine colitis. The newly acquired properties should enable a larger proportion of the administered bacteria to reach the gastrointestinal tract in a bioactive form, providing a means for more effective mucosal delivery of therapeutics.     

Evaluation of the anti-inflammatory effect of milk fermented by a strain of IL-10-producing Lactococcus lactis using a murine model of Crohn's disease

Interleukin-10 (IL-10) is the most important anti-inflammatory cytokine at intestinal level, and its absence is involved in inflammatory bowel diseases. However, oral treatment with IL-10 is difficult because of its low survival in the gastrointestinal tract and systemic treatments lead to undesirable side effects. The aim of this paper was to evaluate the anti-inflammatory effect of the administration of milks fermented by Lactococcus lactis strains that produce IL-10 under the control of the xylose-inducible expression system using a trinitrobenzenesulfonic acid-induced colitis murine model. Mice that received milks fermented by L. lactis strains producing IL-10 in the cytoplasm (Cyt strain) or secreted to the product (Sec strain) showed lower damage scores in their large intestines, decreased IFN-γ levels in their intestinal fluids and lower microbial translocation to liver, compared to mice receiving milk fermented by the wild-type strain or those not receiving any treatment. The results obtained in this study show that the employment of fermented milks as a new form of administration of IL-10-producing L. lactisis effective in the prevention of inflammatory bowel disease in a murine model.     

Engineering trehalose synthesis in Lactococcus lactis for improved stress tolerance

Trehalose accumulation is a common cell defense strategy against a variety of stressful conditions. In particular, our team detected high levels of trehalose in Propionibacterium freudenreichii in response to acid stress, a result that led to the idea that endowing Lactococcus lactis with the capacity to synthesize trehalose could improve the acid tolerance of this organism. To this end, we took advantage of the endogenous genes involved in the trehalose catabolic pathway of L. lactis, i.e., trePP and pgmB, encoding trehalose 6-phosphate phosphorylase and β-phosphoglucomutase, respectively, which enabled the synthesis of trehalose 6-phosphate. Given that L. lactis lacks trehalose 6-phosphate phosphatase, the respective gene, otsB, from the food-grade organism P. freudenreichii was used to provide the required activity. The trehalose yield was approximately 15% in resting cells and in mid-exponential-phase cells grown without pH control. The intracellular concentration of trehalose reached maximal values of approximately 170 mM, but at least 67% of the trehalose produced was found in the growth medium. The viability of mutant and control strains was examined after exposure to heat, cold or acid shock, and freeze-drying. The trehalose-producing strains showed improved tolerance (5- to 10-fold-higher survivability) to acid (pH 3) and cold shock (4°C); there was also a strong improvement in cell survival in response to heat shock (45°C), and no protection was rendered against dehydration. The insight provided by this work may help the design of food-grade strains optimized for the dairy industry as well as for oral drug delivery.     

Commercial baker's yeast stability as affected by intracellular content of trehalose, dehydration procedure and the physical properties of external matrices

The effects of vacuum-drying and freeze- drying on the cell viability of a commercial baker's yeast, Saccharomyces cerevisiae, strain with different endogenous contents of trehalose were analyzed. An osmotolerant Zygosaccharomyces rouxii strain was used for comparative purposes. Higher viability values were observed in cells after vacuum-drying than after freeze-drying. Internal concentrations of trehalose in the range 10–20% protected cells in both dehydration processes. Endogenous trehalose concentrations did not affect the water sorption isotherm nor the T _g values. The effect of external matrices of trehalose and maltodextrin was also studied. The addition of external trehalose improved the survival of S. cerevisiae cells containing 5% internal trehalose during dehydration. Maltodextrin (1.8 kDa) failed to protect vacuum-dried samples at 40 °C. The major reduction in the viability during the freeze-drying process of the sensitive yeast cells studied was attributed to the freezing step. The suggested protective mechanisms for each particular system are vitrification and the specific interactions of trehalose with membranes and/or proteins. The failure of maltodextrins to protect cells was attributed to the fact that none of the suggested mechanisms of protection could operate in these systems. Received: 6 December 1999 / Received revision: 8 May 2000 / Accepted: 19 May 2000     

Stimulation of respiratory immunity by oral administration of Lactococcus lactis

This work demostrates that nonrecombinant Lactococcus lactis NZ, administered by the oral route at the proper dose, is able to improve resistance against pneumococcal infection. Lactococcus lactis NZ oral administration was able to improve pathogen lung clearance, increased survival of infected mice, and reduced lung injuries. This effect was related to an upregulation of the respiratory innate and specific immune responses. Administration of L. lactis NZ improved production of bronchoalveolar lavage (BAL) fluid TNF-alpha, enhanced recruitment of neutrophils into the alveolar spaces, and induced a higher activation of BAL phagocytes compared with the control group. Lactococcus lactis NZ administered orally stimulated the IgA cycle, increased IgA+ cells in intestine and bronchus, and improved production of BAL IL-4 and IL-10 during infection. Moreover, mice treated with L. lactis NZ showed higher levels of BAL anti-pneumococcal IgA and IgG. Taking into consideration that orally administered L. lactis NZ stimulates both the innate and the specific immune responses in the respiratory tract and that bacterial and viral antigens have been efficiently produced in this strain, L. lactis NZ is an excellent candidate for the development of an effective pneumococcal oral vaccine.     

Effects of cryoprotectants on viability of <Emphasis Type="Italic">Lactobacillus reuteri</Emphasis> CICC6226

Freeze-drying is commonly used to preserve probiotics, but it could cause cell damage and loss of viability. The cryoprotectants play an important role in the conservation of viability during freeze-drying. In this study, we investigated the survival rates of Lactobacillus reuteri CICC6226 in the presence of cryoprotectants such as sucrose, trehalose, and reconstituted skim milk (RSM). In addition, we determined the activities of hexokinase (HK), pyruvate kinase (PK), lactate dehydrogenase (LDH), and ATPases immediately following the freeze-drying. The results showed that the differences in HK and PK activities with and without the cryoprotectants during freeze-drying were not significant, but cell viability and activities of LDH and ATPase were significantly different (P<0.01) prior to and after freeze-drying. Meanwhile, the results showed that the maintenance of the membrane integrity and fluidity was improved in the presence of the 10% trehalose or 10% RSM than other treatments during freeze-drying. These results have provided direct biochemical and metabolic evidence of injured cell during freeze-drying. Freeze-drying damaged membrane structure and function of cell and inactivated enzymes (LDH and ATPases). The results imply that LDH and ATPases are key markers and could be used to evaluate the effect of cryoprotectants on viability and metabolic activities of L. reuteri CICC6226 during freeze-drying.     

Use of alginate and cryo-protective sugars to improve the viability of lactic acid bacteria after freezing and freeze-drying

Summary In the present paper, the effect of cryo-protective sugars on the survival rate of different strains of Lactic Acid Bacteria (LAB, Lactobacillus acidophilus, Lactobacillus delbrueckii subspbulgaricus, Streptococcus salivarius subsp.thermophilus), after freezing or freeze-drying procedures, was compared. The cells were incubated at 4 °C in 32% final concentration sugar solutions (trehalose, maltose, sucrose, glucose and lactose), and viability was evaluated by the enumeration of colony-forming units. All sugars tested showed a protective effect on cell viability as compared to isotonic solution, especially after freeze-drying procedures (log c.f.u./ml ranging between 1.16 and 2.08, P < 0.001). Furthermore, the resistance to different stress agents (lysozyme, pepsin, bile salts) was estimated. Trehalose was the most effective sugar in preserving bacterial viability [% (log c.f.u. trehalose/log c.f.u. isotonic solution) ranging between 124 and 175, P < 0.001] although each strain showed a different sensitivity. Finally, the protective effect of immobilization of LAB in Ca-alginate beads was compared to that exercised by trehalose. The immobilization induced a good survival rate but lower as compared to the trehalose effect, mainly after freeze-drying in the presence of the selective agents [% (log c.f.u. alginate/log c.f.u. trehalose ranging between 81.1 and 94.5, P < 0.0001]. The protective effect of trehalose was evident in particular for Lactobacillus delbrueckii subsp. bulgaricus in presence of lysozyme. Therefore, because of its chemical inertness and low cost, trehalose could be easily utilized as excellent bacterial preservative, both to improve the viability of starter cultures and to obtain probiotic formulations more resistant to a variety of stressful conditions.     

Optimisation of initial cell concentration enhances freeze-drying tolerance of Pseudomonas chlororaphis

The freeze-drying tolerance of Pseudomonas chlororaphis, an antifungal bacterium used as biocontrol agent was investigated. P. chlororaphis is freeze-drying sensitive and the viability drops more than 3 log units in the absence of protective freeze-drying medium. Of the freeze-drying media tested, lactose, sucrose, trehalose, glutamate, sucrose with glutamate, skimmed milk, and skimmed milk with trehalose, skimmed milk gave the lowest survival (0.6+/-0.2%) and sucrose the highest (6.4+/-1.2%). Cellular accumulation of sucrose from the freeze-drying medium and the protective effect of sucrose were dependent on sucrose concentration. The effect of initial cell concentration, from 1 x 10(7) to 5 x 10(10) CFU/ml, on survival after freeze-drying was studied for carbon starved cells with sucrose as freeze-drying medium. The highest freeze-drying survival values, 15-25%, were obtained for initial cell concentrations between 1 x 10(9) and 1 x 10(10) CFU/ml. For cell concentrations outside this window more than 10 times lower survival values were observed. P. chlororaphis was cultivated to induce stress response that could confer protection against freeze-drying inactivation. Carbon starvation and, to a lesser extent, heat treatment enhanced freeze-drying tolerance. By combining optimal cell concentration, optimal sucrose concentration and carbon starvation the survival after freeze-drying was 26+/-6%.     

Biological containment of genetically modified Lactococcus lactis for intestinal delivery of human interleukin 10

Genetically modified Lactococcus lactis secreting interleukin 10 provides a therapeutic approach for inflammatory bowel disease. However, the release of such genetically modified organisms through clinical use raises safety concerns. In an effort to address this problem, we replaced the thymidylate synthase gene thyA of L. lactis with a synthetic human IL10 gene. This thyA- hIL10+ L. lactis strain produced human IL-10 (hIL-10), and when deprived of thymidine or thymine, its viability dropped by several orders of magnitude, essentially preventing its accumulation in the environment. The biological containment system and the bacterium's capacity to secrete hIL-10 were validated in vivo in pigs. Our approach is a promising one for transgene containment because, in the unlikely event that the engineered L. lactis strain acquired an intact thyA gene from a donor such as L. lactis subsp. cremoris, the transgene would be eliminated from the genome.     

Some observations in freeze-drying of recombinant bioluminescent Escherichia coli for toxicity monitoring

A recombinant bioluminescent bacteria, containing a fabA::luxCDABE fusion gene, has been used to characterize freeze-drying methods, which may be conveniently used as a tool for the development of a portable biosensor. Through residual water, viability, biosensing activity and scanning electron microscopy analyses, the characteristics that four cryoprotectants, trehalose, sucrose, sorbitol, and mannitol, conferred on freeze-dried samples were elucidated, including the morphology, water content and activity of the cells. It was found that trehalose showed the best freeze-drying efficiency among the tested cryoprotectants and it might have a specific capacity limitation in protection of the cells during the freeze step. Humidity might result in damage to the cells, according to the viability, when exposed to air during storage, while the water remaining post freeze-drying showed good correlation with damage to the freeze-dried cells when under air-tight storage conditions. The results with other recombinant bioluminescent bacteria indicated that these findings might be general features of the freeze-drying processes.     

Preservation of frozen yeast cells by trehalose.

Two different methods commonly used to preserve intact yeast cells-freezing and freeze-drying-were compared. Different yeast cells submitted to these treatments were stored for 28 days and cell viability assessed during this period. Intact yeast cells showed to be less tolerant to freeze-drying than to freezing. The rate of survival for both treatments could be enhanced by exogenous trehalose (10%) added during freezing and freeze-drying treatments or by a combination of two procedures: a pre-exposure of cells to 40 degrees C for 60 min and addition of trehalose. A maximum survival level of 71.5 +/- 6.3% after freezing could be achieved at the end of a storage period of 28 days, whereas only 25.0 +/- 1.4% showed the ability to tolerate freeze-drying treatment, if both low-temperature treatments were preceded by a heat exposure and addition of trehalose to yeast cells. Increased survival ability was also obtained when the pre-exposure treatment of yeast cells was performed at 10 degrees C for 3 h and trehalose was added: these treatments enhanced cell survival following freezing from 20.5 +/- 7. 7% to 60.0 +/- 3.5%. Although both mild cold and heat shock treatments could enhance cell tolerance to low temperature, only the heat treatment was able to increase the accumulation of intracellular trehalose whereas, during cold shock exposure, the intracellular amount of trehalose remained unaltered. Intracellular trehalose levels seemed not to be the only factor contributing to cell tolerance against freezing and freeze-drying treatments; however, the protection that this sugar confers to cells can be exerted only if it is to be found on both sides of the plasma membrane.     

Freeze-drying of live attenuated Vibrio anguillarum mutant for vaccine preparation

Vibrio anguillarum MVAV6203 is a mutant strain as a candidate of live attenuated vaccine. In vaccine preparation, the freeze-drying conditions of the strain were investigated to improve the survival after freeze-drying, including the protectant, rehydration medium, freezing temperature, and initial cell concentration. Vibrio anguillarum MVAV6203 is sensitive to freeze-drying and the viability was only 0.03% in the absence of protectant. Of the tested protectants, 5% trehalose with 15% skimmed milk gave the highest viability of 34.2%. Higher cell survival was obtained by quick freezing at -80 degrees C than slow freezing at -20 degrees C. Initial cell concentration was another important factor, preferable for 1-3 x 10(10)CFU/ml. The supplementation of 10% skimmed milk in rehydration medium improved obviously freeze-drying viability. The combination of the optimal conditions achieved 51.4% cell viability after freeze-drying.     

Viability and thermal stability of a strain of Saccharomyces cerevisiae freeze-dried in different sugar and polymer matrices

The viability and thermal stability of a freeze-dried yeast strain were studied in relation to some physical properties of the matrices in which the cells were freeze-dried. Samples of inoculum with solutions of the matrix components [polyvinylpyrrolidone (PVP), maltose, trehalose, maltodextrins, or mixtures of maltodextrin and trehalose] and controls without matrices were freeze-dried and then equilibrated at several relative humidities. Viability was determined before and after freeze-drying and after heat treatment (100 min at 70 °C). Freeze-drying with trehalose, PVP, maltose or 1.8-kDa maltodextrin, and mixtures of maltodextrin/trehalose increased viability in comparison with controls. The 3.6-kDa maltodextrin was ineffective at protecting the cells during freeze-drying. The glass transition temperature (T _g), which depends on moisture content, was indicated as a possible factor to determine the stability of labile materials. Protective effects of the excipients during thermal treatment were analysed in relation to the physical changes (collapse or structural shrinkage) which were dependent on the T _g of the systems. The presence of a certain amount of amorphous disaccharides during freeze-drying and heating was found to be a critical factor for ensuring cell viability, which was protected even in rubbery (above T _g) matrices. Received: 4 December 1998 / Received last revision: 2 March 1999 / Accepted: 14 March 1999     

Survival of freeze-dried Lactobacillus plantarum and Lactobacillus rhamnosus during storage in the presence of protectants

No significant differences were observed in the viability of Lactobacillus plantarum and Lactobacillus rhamnosus cells during freeze-drying in the presence or absence of inositol, sorbitol, fructose, trehalose, monosodium glutamate and propyl gallate. However, survival was higher during storage when drying took place in the presence of these compounds. Sorbitol produced more significant effects than the other compounds toward maintaining viability of freeze-dried L. plantarum and L. rhamnosus.     

A crucial role for the vitamin D receptor in experimental inflammatory bowel diseases

The active form of vitamin D (1,25D3) suppressed the development of animal models of human autoimmune diseases including experimental inflammatory bowel disease (IBD). The vitamin D receptor (VDR) is required for all known biologic effects of vitamin D. Here we show that VDR deficiency (knockout, KO) resulted in severe inflammation of the gastrointestinal tract in two different experimental models of IBD. In the CD45RB transfer model of IBD, CD4+/CD45RBhigh T cells from VDR KO mice induced more severe colitis than wild-type CD4+/CD45RBhigh T cells. The second model of IBD used was the spontaneous colitis that develops in IL-10 KO mice. VDR/IL-10 double KO mice developed accelerated IBD and 100% mortality by 8 wk of age. At 8 wk of age, all of the VDR and IL-10 single KO mice were healthy. Rectal bleeding was observed in every VDR/IL-10 KO mouse. Splenocytes from the VDR/IL-10 double KO mice cells transferred IBD symptoms. The severe IBD in VDR/IL-10 double KO mice is a result of the immune system and not a result of altered calcium homeostasis, or gastrointestinal tract function. The data establishes an essential role for VDR signaling in the regulation of inflammation in the gastrointestinal tract.     

Combined effects of endo- and exogenous trehalose on stress tolerance and biocontrol efficacy of two antagonistic yeasts

Effects of endo- and exogenous trehalose on viability of two antagonistic yeasts, Cryptococcus laurentii (Kuffer.) Skinner and Rhodotorula glutinis (Fresen.) Harrison, were investigated after being treated with rapid-freezing, slow-freezing and freeze-drying, respectively. The accumulation of intracellular trehalose in the two yeasts was induced by culturing the yeast cells in trehalose-containing medium, which significantly enhanced viabilities of both yeasts in the slow-freezing test. Trehalose, as an exogenous protectant, at the concentration of 5% or 10% could markedly increase survivals of the two yeasts when subjected to freeze-drying. When combined with exogenous trehalose as a protective substance, the yeasts containing high intracellular trehalose level showed higher viabilities as compared to those containing low levels under both freezing and freeze-drying stresses. The highest survival of C. laurentii and R. glutinis were 90% and 97% after freeze-drying, respectively, compared to 63% and 28% for the yeasts with lower intracellular trehalose levels. These results may be due to the fact that a combined effect occurred between endo- and exogenous trehalose of yeast cells. The combined effect on C. laurentii and R. glutinis also resulted in the highest level of biocontrol efficacy against blue mold in apple fruit caused by Penicillium expansum Link, and reduced the disease indexes to 45 and 56, respectively, compared to 94 and 81 in the untreated control. Meanwhile, the combination of endo- and exogenous trehalose significantly increased population of both yeasts in apple wounds, especially at the first 48 h after inoculation, which might explain the reason of the improvement in biocontrol effects of the two yeasts.     

Optimisation and comparison of liquid and dry formulations of the biocontrol yeast <Emphasis Type="Italic">Pichia anomala</Emphasis> J121

The biocontrol yeast Pichia anomala J121 can effectively reduce mould growth on moist cereal grains during airtight storage. Practical use of microorganisms requires formulated products that meet a number of criteria. In this study we compared different formulations of P. anomala. The best way to formulate P. anomala was freeze-drying. The initial viability was as high as 80%, with trehalose previously added to the yeast. Freeze-dried products could be stored at temperatures as high as 30 °C for a year, with only a minor decrease in viability. Vacuum-drying also resulted in products with high storage potential, but the products were not as easily rehydrated as freeze-dried samples. Upon desiccating the cells using fluidised-bed drying or as liquid formulations, a storage temperature of 10 °C was required to maintain viability. Dependent on the type of formulation, harvesting of cells at different nutritional stresses affected the initial viabilities, e.g. the initial viability for fluidised-bed-dried cells was higher when the culture was fed with excess glucose, but for freeze-drying it was superior when cells were harvested after depletion of carbon. Using micro-silos we found that the biocontrol activity remained intact after drying, storage and rehydration for all formulations.     

Effects of freeze-drying on cytology, ultrastructure, DNA fragmentation, and fertilizing ability of bovine sperm

Freeze-drying sperm is an alternative to cryopreservation. Although sperm from various species has been freeze-dried, there are few reports for bovine sperm. The primary objective of this study was to evaluate the protective effect of various freeze-drying media on the structural and functional components of bovine sperm. The media tested were composed of TCM 199 with Hanks salts supplemented with 10% fetal calf serum (FCS) and TCM 199 with Hanks salts supplemented with 10% FCS and 0.2 M trehalose and EGTA solution. The efficiency of each medium on the preservation of freeze-dried sperm structures was evaluated with conventional and electron microscopy, DNA integrity was analyzed by a TUNEL assay, and fertilizing ability of lyophilized sperm was determined with ICSI. Although the plasma membrane was damaged in all media tested, mitochondria were similarly preserved in all freeze-drying treatments. The acrosome was best preserved in the media that contained trehalose (other treatments also conserved this structure). In contrast, media containing EGTA or trehalose most effectively preserved the nuclei in freeze-dried sperm, with only 2 and 5%, respectively, of cells with fragmented DNA. Furthermore, sperm conserved with these media also had higher (P<0.05) rates of sperm head decondensation (32.5 and 27.5%), pronucleus formation (37.5 and 45.0%) and blastocyst formation (19.4 and 18.3%) than medium supplemented with FCS (15.0, 20.0 and 10.2%, respectively). In conclusion, media with EGTA and trehalose adequately protected bovine sperm during freeze-drying by preserving the viability of their nuclei.     

Soy isoflavone equol perpetuates dextran sulfate sodium-induced acute colitis in mice

The effects of the soy isoflavones, genistein, daidzein and equol, on experimental colitis were examined. Equol severely perpetrated dextran sulfate sodium (DSS)-induced colitis as evaluated by the weight loss. Production of the anti-inflammatory cytokine, IL-10, from T cells was decreased in the equol-treated mice. The results show that the soy isoflavone, equol, played an important role in the inflammatory response in the gastrointestinal tract.     

Fate and efficacy of lacticin 3147-producing Lactococcus lactis in the mammalian gastrointestinal tract

Gastrointestinal survival of the bacteriocin-producing strain, Lactococcus lactis DPC6520, was evaluated systematically in vitro and in vivo with a view to using this strain to deliver biologically active lacticin 3147, a broad-spectrum bacteriocin, to the gut. The activity of the lacticin 3147 producer was also evaluated against two clinically relevant pathogens: Clostridium difficile and Listeria monocytogenes. When suspended in an appropriate matrix, the lactococcal strain is capable of surviving simulated gastrointestinal juices similar to the porcine probiotic, Lactobacillus salivarius DPC6005. Upon administration of L. lactis DPC6520 to pigs (n=4), excretion rates of ～10(2) -10(5) CFU g(-1) faeces were observed by day 5. Although passage through the gastrointestinal tract (GIT) did not affect lacticin 3147 production by L. lactis DPC6520 isolates, activity was undetectable in faecal samples by an agar well diffusion assay. Furthermore, L. lactis DPC6520 had no inhibitory effect on C. difficile or other bacterial populations in a human distal colon model, while lactococcal counts declined 10,000-fold over 24 h. The lacticin 3147 producer failed to prevent L. monocytogenes infection in a mouse model, even though a mean L. lactis DPC6520 count of 4.7 × 10(4) CFU g(-1) faeces was obtained over the 5-day administration period. These data demonstrate that L. lactis DPC6520 is capable of surviving transit through the GIT, and yet lacks antimicrobial efficacy in the models of infection used.