Submerged organ culture: An improved method

Summary Explants of whole ovaries and oviducts from postnatal rats were completely submerged during cultivation as organ cultures in chemically defined medium. The oxygen concentration in the culture chamber was raised to over 90%, and the stainless steel platform, used for cultures at the surface of the medium, was abandoned and excluded from further use. Thus, all of the periphery of an explant had equal access to nutrients and oxygen. Throughout the ovarian explants the tissues appeared uniformly viable, and mitotic figures were distributed evenly. These observations are in contrast to those on organs cultivated at the surface of the medium where a lack of structural uniformity had been detected. The method has general application to a variety of organs.     

印楝愈伤组织形成及其印楝素含量测定

取印楝（AzadirachtaindicaA．Juss）不同器官作外植体,研究培养基和继代次数对愈伤组织生长及其印楝素（Azadirachtin）生物合成的影响．印楝的不同器官（根、叶、茎及皮）均能诱导出愈伤组织,这些愈伤组织均有合成印楝素的能力．其中以叶诱导的愈伤组织生长速率及印楝素含量为最高．含有较低按盐的B5培养基有利于细胞生长,含有较高铵盐的MS培养基有利于印楝素积累,不含铰盐的White培养基对两者均不利．愈伤组织继代2—3代,有利于愈伤组织生长和印楝素合成。     

Characterization of nerolidol biotransformation based on indirect on-line estimation of biomass concentration and physiological state in batch cultures of Aspergillus niger

Biotransformation of the sesquiterpenoid trans-nerolidol by Aspergillus niger has previously been investigated as a method for the formation of 12-hydroxy-trans-nerolidol, a precursor in the synthesis of the industrially interesting flavor alpha-sinensal. We characterized biotransformations of cis-nerolidol, trans-nerolidol, and a commercially available cis/trans-nerolidol mixture in repeated batch cultures of A. niger grown in computer-controlled bioreactors. On-line quantification of titrant addition in pH control allowed characterization of (1) maximal specific growth rate in exponential growth phases, (2) exponential induction of acid formation in postexponential phases, (3) inhibition of organic acid formation after nerolidol addition, and (4) exponential recovery from this inhibition. Addition of a (+/-)-cis/trans-nerolidol mixture during exponential or postexponential phase to cultures grown in minimal medium at high dissolved oxygen tension (above 50% air saturation), to cultures at low dissolved oxygen tension (5% air saturation), or to cultures grown in rich medium demonstrated that the physiological state before nerolidol addition had a major influence on biotransformation. The maximal molar yield of 12-hydroxy-trans-nerolidol (9%) was obtained by addition of a (+/-)-cis/trans-nerolidol mixture to the culture in the postexponential phase at high dissolved oxygen tension in minimal medium. Similar yields were obtained in rich medium, where the rate of biotransformation was doubled.     

Injury to primary cultures of rat heart endothelial cells by hypoxia and glucose deprivation

Primary cultures of rat heart endothelial cells were subjected to simulated conditions of ischemia: hyposia and glucose deprivation for 4 and 24 hr. Cellular injury was evaluated by measuring changes in viability, total protein, cellular morphology, and leakage of cytoplasmic enzymes from the cells into the culture medium. Deprivation of oxygen and glucose for 4 or 24 hr did not lethally injure the cells as noted by no change in cell viability, morphology, and total protein when compared to controls. However, reversible or non-lethal cellular injury was produced as reflected by a significant release of lactate dehydrogenase (LDH) from the cells into the medium after treatment with hypoxia and glucose deprivation for 4 or 24 hr. When the cultures were deprived of glucose, but were oxygenated, cellular injury was not evident after 24 hr. Deprivation of oxygen but not glucose resulted in significant loss of LDH after 4 or 24 hr. When the cultures were allowed to recover after oxygen and glucose deprivation in complete medium containing 1000 mg glucose per 1 and a normal atmosphere of 20% O2, they had levels of LDH leakage comparable to those of control cultures.     

The Dissolved Oxygen and Respiration Rates in Pellicle and Submerged Cultures of Corynebacterium diphtheriae

S ummary . The concentration of dissolved oxygen in submerged and static cultures of Corynebacterium diphtheriae was measured with a cathode ray polarograph. In a pellicle culture of the type frequently used for production of diphtheria toxin the concentration of dissolved oxygen in the medium below the pellicle fell sharply after the third or fourth day, and growth then proceeded in a medium which contained only minimal amounts of dissolved oxygen, in spite of the fact that only a cotton wool plug separated the atmosphere above the medium from the outside air.
The measurement of dissolved oxygen in submerged cultures was applied to the determination of respiration rates in growing cultures. The respiration rate for the test organisms varied at different stages in the period of a submerged batch culture. The rate was greatest at the start of the logarithmic phase, and thereafter declined until a steady state was reached.     

Effects of oxygen and nutrients limitation on ajmalicine production and related enzyme activities in high density cultures of Catharanthus roseus

Oxygen and nutrient limitation was investigated in order to identify the origin of a lower specific ajmalicine production in Catharanthus roseus cultures at high cell densities in an induction medium. The effect of oxygen limitation was explored by comparing two identically aerated and agitated high cell density bioreactor cultures with dissolved oxygen (DO) concentration of 15% and 85% of air saturation, with respect to alkaloid formation and related enzymes activities. Oxygen had an evident effect on ajmalicine production: in the high DO cultures production was more than 5 times higher than in the low DO cultures. The difference in ajmalicine production between high and low DO could not be explained by the enzyme activity profiles. Moreover, the productivity in the high density culture could not restored to the level of a low density culture (at a high DO) by increasing the DO alone. The effect of nutrient limitation was studied with response surface methodology in shake flask cultures. Nutrient limitation could not be demonstrated to be responsible for the productivity loss. Alkaloid and enzyme measurements in the shake flask cultures supported previous findings that the tryptamine pathway may regulate alkaloid production, provided that the terpenoid pathway is sufficiently active. (c) 1994 John Wiley & Sons, Inc.     

Growth studies on Mycobacterium BCG: establishment of growth curves and measurement of the oxygen tension of the growth medium

Mycobacterium BCG grew exponentially in shallow, static volumes of culture medium for approximately 10 days; the oxygen tension of the medium at all stages of growth was 100% saturation. Higher yields were obtained from Dubos than from glycerol-free medium. In static cultures, the oxygen tension of the culture and consequently the growth rate of BCG was dependent on the depth of the medium; active growth ceased at an oxygen tension of less than 40% saturation. BCG grew actively in a cell sediment, while cells growing in suspension made a negligible contribution to the yield.     

Strategies for enhancing monoclonal antibody accumulation in plant cell and organ cultures.

Various strategies aimed at improving IgG(1) antibody accumulation in transgenic tobacco cell and organ cultures were tested. The form of tissue had a significant effect on antibody levels; shooty teratomas were less productive than hairy roots or suspended cells. Although there were several disadvantages associated with hairy roots compared with suspensions, such as slower growth, slower antibody production, and formation of a greater number of antibody fragments, the roots exhibited superior long-term culture stability. Antibody accumulation in hairy root cultures was improved by increasing the dissolved oxygen tension to 150% air saturation, indicating the need for effective oxygen transfer in root reactors used for antibody production. Preventing N-linked glycosylation using tunicamycin or inhibition of subsequent glycan processing by castanospermine reduced antibody accumulation in the biomass and/or medium in cell suspensions. Loss of antibody from the cultures after its secretion and release into the medium was identified as a major problem. This effect was minimized by inhibiting protein transport in the secretory pathway using Brefeldin A, resulting in antibody accumulation levels up to 2.7 times those in untreated cells. Strategies for protecting secreted antibody, such as addition of poly(vinylpyrrolidone) and periodic harvesting from the medium using hydroxyapatite resin, also increased antibody titers. The mechanisms responsible for the disappearance of antibody from plant culture media were not clearly identified; degradation by proteases and conformational modification of the antibody, such as formation of aggregates, provided an explanation for some but not all the phenomena observed. This work demonstrates that the manipulation and control of culture conditions and metabolic processes in plant tissue cultures can be used to improve the production of foreign proteins. However, loss of secreted antibody from plant culture medium is a significant problem that may limit the feasibility of using product recovery from the medium to reduce downstream processing costs relative to agricultural systems.     

Effect of oxygen supply on passaging, stabilising and screening of recombinant Hansenula polymorpha production strains in test tube cultures

Twenty-four Hansenula polymorpha transformants were passaged and stabilised in glucose medium and screened in glycerol medium for recombinant phytase in shaken test tubes. The cultivations were performed under either limited or non-limited oxygen supply. Maximum oxygen transfer capacities of test tubes were assessed by sulfite oxidation. Oxygen-limited glucose cultures resulted in a partially anaerobic metabolism and formation of 4.1 g ethanol l(-1), which was subsequently aerobically metabolised. Non-limited oxygen supply led to overflow metabolism and to accumulation of 2.1 g acetic acid l(-1), reducing the biomass yield. The use of glycerol in the screening main cultures prevented by-product formation irrespective of oxygen supply. Preculturing in glucose medium under non-limited oxygen supply resulted in a 20-h lag phase of the screening main culture. This lag phase was not observed when preculturing was performed under oxygen limitation. Phytase activity was on average 25% higher in cultures passaged, stabilised and screened under limited oxygen supply than in cultures under non-limited oxygen supply.     

Ischemic myocardial injury in cultured heart cells: Leakage of cytoplasmic enzymes from injured cells

Summary An in vitro model of myocardial ischemia has been established with primary monolayer cultures of postnatal rat myocardial cells. Ischemic conditions were simulated in vitro by subjecting the myocardial cell cultures to various levels of oxygen and glucose deprivation. The experimental protocol consisted of treatment with 20% or 0% O₂ and 1000, 500 or 0 mg glucose per 1 of medium for 4 or 24 hr. Control cultures were treated with 20% O₂ and 1000 mg glucose. After the ischemic treatments, cultures of beating muscle (M) cells were evaluated for signs of injury, i.e. leakage of cytoplasmic enzymes into the culture medium. Differences were found in leakage of lactate dehydrogenase (LDH) and creatine phosphokinase (CPK) from the cultures that were exposed to partial ischemia of glucose deprivation and from those cultures that were exposed to total ischemia of oxygen and glucose deprivation. Glucose deprivation alone resulted in a slight-to-moderate loss of LDH and CPK from the cells, whereas total ischemia resulted in a significant release of the two cytoplasmic enzymes. When the cultures were allowed to recover after ischemic treatment in complete medium (1000 mg glucose) and a normal atmosphere of 20% O₂, they had levels of LDH leakage comparable to those of control cultures. Cell viability and total protein content of the ischemic cultures did not differ significantly from controls. This study was supported by Research Grant HL 18647 from the National Heart, Lung, and Blood Institute.     

Intra-particle oxygen diffusion limitation in solid-state fermentation

Oxygen limitation in solid-state fermentation (SSF) has been the topic of modeling studies, but thus far, there has been no experimental elucidation on oxygen-transfer limitation at the particle level. Therefore, intra-particle oxygen transfer was experimentally studied in cultures of Rhizopus oligosporus grown on the surface of solid, nutritionally defined, glucose and starch media. The fungal mat consisted of two layers--an upper layer with sparse aerial hyphae and gas-filled interstitial pores, and a dense bottom layer with liquid-filled pores. During the course of cultivation ethanol was detected in the medium indicating that oxygen was depleted in part of the fungal mat. Direct measurement of the oxygen concentrations in the fungal mat during cultivation, using oxygen microelectrodes, showed no oxygen depletion in the upper aerial layer, but revealed development of steep oxygen concentration gradients in the wet bottom layer. Initially, the fungal mat was fully oxygenated, but after 36.5 hours oxygen was undetectable at 100 microm below the gas-liquid interface. This was consistent with the calculated oxygen penetration depth using a reaction-diffusion model. Comparison of the overall oxygen consumption rate from the gas phase to the oxygen flux at the gas-liquid interface showed that oxygen consumption of the microorganisms occurred mainly in the wet part of the fungal mat. The contribution of the aerial hyphae to overall oxygen consumption was negligible. It can be concluded that optimal oxygen transfer in SSF depends on the available interfacial gas-liquid surface area and the thickness of the wet fungal layer. It is suggested that the moisture content of the matrix affects both parameters and, therefore, plays an important role in optimizing oxygen transfer in SSF cultures.     

Oxygen toxicity in Streptococcus mutans: manganese, iron, and superoxide dismutase.

When cultured anaerobically in a chemically defined medium that was treated with Chelex-100 to lower its trace metal content, Streptococcus mutans OMZ176 had no apparent requirement for manganese or iron. Manganese or iron was necessary for aerobic cultivation in deep static cultures. During continuous aerobic cultivation in a stirred chemostat, iron did not support the growth rate achieved with manganese. Since the dissolved oxygen level in the chemostat cultures was higher than the final level in the static cultures, manganese may be required for growth at elevated oxygen levels. In medium supplemented with manganese, cells grown anaerobically contained a low level of superoxide dismutase (SOD) activity; aerobic cultivation increased SOD activity at least threefold. In iron-supplemented medium, cells grown anaerobically also had low SOD activity; aerobic incubation resulted in little increase in SOD activity. Polyacrylamide gel electrophoresis of the cell extracts revealed a major band and a minor band of SOD activity in the cells grown with manganese; however, cells grown with iron contained a single band of SOD activity with an Rf value similar to that of the major band found in cells grown with manganese. None of the SOD activity bands were abolished by the inclusion of 2 mM hydrogen peroxide in the SOD activity strain. S. mutans may not produce a separate iron-containing SOD but may insert either iron or manganese into an apo-SOD protein. Alternatively, iron may function in another activity (not SOD) that augments the defense against oxygen toxicity at low SOD levels.     

Effects of paddle impeller geometry on power input and mass transfer in small-scale animal cell culture vessels

Process scaleup for stirred-tank animal cell cultures such as suspension and microcarrier cultures often begins at the bench scale in small spinner vessels. In order to initiate process development under the proper conditions, it is essential to know the physical conditions under which the cells are grown. In this article, power inputs and surface oxygen transfer rates to culture medium in 500-mL Corning spinner vessels were determined as a function of the impeller geometry, impeller height, and agitation speed. The results obtained indicate that power dissipation dependency differs from literature correlations and may compromise scale up at constant power input from these vessels. These results are of general utility to researchers using small-scale vessels.     

Injury to primary cultures of rat heart endothelial cells by hypoxia and glucose deprivation

Summary Primary cultures of rat heart endothelial cells were subjected to simulated conditions of ischemia: hypoxia and glucose deprivation for 4 and 24 hr. Cellular injury was evaluated by measuring changes in viability, total protein, cellular morphology, and leakage of cytoplasmic enzymes from the cells into the culture medium. Deprivation of oxygen and glucose for 4 or 24 hr did not lethally injure the cells as noted by no change in cell viability, morphology, and total protein when compared to controls. However, reversible or nonlethal cellular injury was produced as reflected by a significant release of lactate dehydro-genase (LDH) from the cells into the medium after treatment with hypoxia and glucose deprivation for 4 or 24 hr. When the cultures were deprived of glucose, but were oxygenated, cellular injury was not evident after 24 hr. Deprivation of oxygen but not glucose resulted in significant loss of LDH after 4 or 24 hr. When the cultures were allowed to recover after oxygen and glucose deprivation in complete medium containing 1000 mg glucose per l and a normal atmosphere of 20% O₂, they had levels of LDH leakage comparable to those of control cultures. This study was supported by Research Grant HL 18647 from the National Heart, Lung, and Blood Institute and by a National Chicano Council on Higher Education Post-Doctoral Fellowship awarded to D. Acosta from the Ford Foundation. Additional support was provided to D. Acosta by a Faculty Research Assignment Award from the University of Texas Research Institute.     

Regeneration of plants from tissue- and cell suspension cultures of Symphytum officinale L. and effect of in vitro culture on pyrrolizidine alkaloid production

Primary calluses were induced from various organs of Symphytum officinale L. (comfrey) plants on solid MS and B5 medium supplemented with plant growth regulators. The callus was further subcultured on B5 medium. Cell suspension cultures were derived from B5 grown calluses by transfer to liquid B5 medium. Calluses as well as cell suspension cultures could be induced to regenerate whole plants on solid MS medium. Plants regenerated from short term cultures were identical with plants from which cultures were initiated in morphology and chromosome number. Production of pyrrolizidine alkaloids ceased on prolonged subculturing of suspensions although polyamines, which might act as precursors, were still detectable. However, regenerated plants produced the original alkaloids.     

Effect of ascorbate on oxygen uptake and growth of Escherichia coli B

The addition of ascorbate to aerobically growing cultures of Escherichia coli B caused only a short pause in growth and no subsequent change in the rate or extent of growth. The effect of ascorbate on oxygen uptake varied from inhibition in minimal medium to stimulation in rich medium. Cyanide-resistant growth and oxygen uptake were stimulated by ascorbate. Both the rate and extent of anaerobic growth were stimulated in proportion to the amount of ascorbate added when fumarate was the terminal electron acceptor. Ascorbate had no effect on any aspect of anaerobic growth in the absence of a terminal electron acceptor or in the presence of nitrate.     

Morphological and ultrastructural variations inAzotobacter vinelandii growing in oxygen-controlled continous culture

Membrane development as a response to growth at different oxygen tensions (from about 1% to 100% saturation of the medium with air) was determined inAzotobacter vinelandii strain OP. The organisms were grown in a carbonlimited chemostat either on atmospheric nitrogen or on ammonium as nitrogen sources. Both types of cultures increased not only the number of intracytoplasmic membrane vesicles per cell but also the cell volume with aeration. As the ratio of length per width stayed largely constant increases of volume resulted in decreases of the cell surface area, representing the surface area of the peripheral cytoplasmic membrane, per cell volume. While in nitrogen-fixing cells the proportion of intracytoplasmic membrane surface area per cytoplasmic membrane surface area increased from 1:2 to 3:1 the ratio stayed almost constant in ammonium-assimilating cells. The data suggest that oxygen controls changes in the ratio of intracytoplasmic to cytoplasmic membrane surface areas only under conditions of nitrogen fixation.Abbreviations CM Cytoplasmic membrane - ICM intracytoplasmic membrane     

Loss of secreted antibody from transgenic plant tissue cultures due to surface adsorption

The role of surface adsorption in the disappearance of secreted foreign proteins from the medium of transgenic plant cell and organ cultures was investigated. When mouse monoclonal IgG1 was added to sterile plant culture media in glass shake flasks, the antibody concentration declined rapidly demonstrating that antibody was labile in the plant culture environment even in the absence of biomass and proteases. Elution of bound antibody from the surfaces of the flasks indicated that adsorption had contributed to the observed loss of antibody from solution. Antibody retention in sterile plant culture media was improved significantly when protein-resistant polymer coatings were applied to the glass vessels containing the antibody solutions. Pluronic F127 applied at a concentration of 1 mg mL(-1) to a primary dimethyldichlorosilane layer on glass yielded the best results in sterile Murashige and Skoog medium. When this coating was used in shake flasks for culture of transgenic tobacco hairy roots, there was a significant improvement in the accumulation of secreted recombinant antibody in the medium consistent with a reduction in antibody adsorption. Medium antibody levels eventually declined, however, as medium protease concentrations rose rapidly towards the end of the culture period. This work demonstrates that surface adsorption reduces the medium antibody titre observed in transgenic plant tissue cultures.     

Toxic Prorocentrum lima induces abnormal behaviour in juvenile sea bass

Juveniles of the European sea bass Dicentrarchus labrax were exposed to both cell-free medium and whole cell cultures of the dinoflagellate Prorocentrum lima strain PL2V. Fish were also fed a commercial fish diet in tanks containing live P. lima, and Artemia that had ingested the alga. Fish exposed to the cell-free medium and to whole cell cultures were stressed and behaved abnormally when compared to the behaviour of control fish, fish in normal seawater. Stress-related behaviours included hyperactivities (jumps, fast let-right turns, surface swims, etc), poor feeding reflexes and abstinence from feeding. Fish that directly ingested the alga or that ingested Artemia containing the alga died. Histological studies revealed that gills and liver of treated fish were impacted, as opposed to the normal conditions of same tissues in control fish. The diseased organs could have been responsible for the abnormal behaviours and death of treated fish. The aquaculture and ecological implications of the results are discussed.