Monitoring of the glucose concentration during microbial fermentation using a novel mass-producible biosensor suitable for on-line use

A flow-injection analysis system was combined with a mass producible, disposable biosensor and was used to monitor glucose concentrations during several microbial fermentations. The biosensor was manufactured using thick film, screen printing technology. Unlike previous devices of this type, the biosensor was designed to make multiple measurements over extended periods rather than to operate as a “one-shot” sensor. One yeast, one lactic acid, and three E. coli bioreactor cultures were tested using either defined or complex media. Results from the sensor were compared with a standard spectrophotometric test kit. In samples containing glucose concentrations within the range of the biosensor and the test kit, good correlations were obtained between the two methods. In addition to glucose, microbial growth and pH were recorded.     

Estimation of ethanol in fermentation broth by solvent extraction and gas chromatography

Ethanol from fermentation is usually estimated by gas chromatography after centrifuging or distilling the broth. In this paper a more efficient and rapid method is described in which ethanol is extracted by an organic solvent such as n-butanol and the extract is analysed by gas chromatography. The distribution factor determined has a value close to unity and is dependent on ethanol concentration, but independent of sugar concentration.     

Saccharification and fermentation of Sugar Cane bagasse by Klebsiella oxytoca P2 containing chromosomally integrated genes encoding the Zymomonas mobilis ethanol pathway

Pretreatment of sugar cane bagasse is essential for a simultaneous saccharification and fermentation (SSF) process which uses recombinant Klebsiella oxytoca strain P2 and Genencor Spezyme CE. Strain P2 has been genetically engineered to express Zymomonas mobilis genes encoding the ethanol pathway and retains the native ability to transport and metabolize cellobiose (minimizing the need for extracellular cellobiase). In SSF studies with this organism, both the rate of ethanol production and ethanol yield were limited by saccharification at 10 and 20 filter papaer units (FPU) g(-1) acid-treated bagasse. Dilute slurries of biomass were converted to ethanol more efficiently (over 72% of theoretical yield) in simple batch fermentations than slurries containing high solids albeit with the production of lower levels of ethanol. With high solids (i.e., 160 g acid-treated bagasse L(-1)), a combination of 20 FPU cellulase g(-1) bagasse, preincubation under saccharification conditions, and additional grinding (to reduce particle size) were required to produce ca. 40 g ethanol L(-1). Alternatively, almost 40 g ethanol L(-1) was produced with 10 FPU cellulase g(-1) bagasse by incorporating a second saccharification step (no further enzyme addition) followed by a second inoculation and short fermentation. In this way, a theoretical ethanol yield of over 70% was achieved with the production of 20 g ethanol 800 FPU(-1) of commercial cellulase. (c) 1994 John Wiley & Sons, Inc.     

Fermentation of sugar cane bagasse hemicellulosic hydrolysate and sugar mixtures to ethanol by recombinant Escherichia coli KO11

Escherichia coli KO11, carrying the ethanol pathway genes pdc (pyruvate decarboxylase) and adh (alcohol dehydrogenase) from Zymomonas mobilis integrated into its chromosome, has the ability to metabolize pentoses and hexoses to ethanol, both in synthetic medium and in hemicellulosic hydrolysates. In the fermentation of sugar mixtures simulating hemicellulose hydrolysate sugar composition (10.0 g of glucose/l and 40.0 g of xylose/l) and supplemented with tryptone and yeast extract, recombinant bacteria produced 24.58 g of ethanol/l, equivalent to 96.4% of the maximum theoretical yield. Corn steep powder (CSP), a byproduct of the corn starch-processing industry, was used to replace tryptone and yeast extract. At a concentration of 12.5 g/l, it was able to support the fermentation of glucose (80.0 g/l) to ethanol, with both ethanol yield and volumetric productivity comparable to those obtained with fermentation media containing tryptone and yeast extract. Hemicellulose hydrolysate of sugar cane bagasse supplemented with tryptone and yeast extract was also readily fermented to ethanol within 48 h, and ethanol yield achieved 91.5% of the theoretical maximum conversion efficiency. However, fermentation of bagasse hydrolysate supplemented with 12.5 g of CSP/l took twice as long to complete. This revised version was published online in November 2006 with corrections to the Cover Date.     

Lack of metabolic racemisation of ropivacaine,determined by liquid chromatography using a chiral AGP column

Ropivacaine hydrochloride monohydrate (ropivacaine) is a new local anaesthetic agent which is administered exclusively as the (-)-(S)-form. The aim of the study was to determine whether metabolic racemisation of (-)-(S)-ropivacaine occurs. This was tested in man, rat, dog, and sheep after different routes of administration. The enantiomers of ropivacaine and two of the major metabolites, 3-hydroxy-ropivacaine and 2′,6′-pipecoloxylidide (PPX), were determined in urine samples by liquid chromatography on a Chiral AGP column after liquid–liquid extraction. It was possible to detect <1% of the (+)-(R)-enantiomer of both ropivacaine and the two major metabolites. In the samples examined, no trace of metabolic racemisation was observed. In pharmacokinetic, pharmacodynamic, toxicological, and metabolic studies, therefore, nonchiral assays are considered to be adequate. © 1995 Wiley-Liss, Inc.     

Enantiomeric separation of five amino acids by high-performance liquid chromatography on a chiral crown ether column

A chiral liquid chromatographic method was validated to analyze the D-and L-enantiomers of five amino acids contained in a commercial solution: aspartic acid, leucine, lysine, phenylalanine, and valine. These 10 compounds were separated on a chiral crown ether column with a mobile phase composed of water adjusted to pH 1.5 with perchloric acid, with ultraviolet detection at 220 nm. The method was applied to the commercial amino acid solution before and after sterilization by 5 kGy irradiation; no stereoconversion was observed following sterilization. Chirality 9:150–152, 1997. © 1997 Wiley-Liss, Inc.     

Ethanol production by continuous fermentation of D-(+)-cellobiose, D-(+)-xylose and sugarcane bagasse hydrolysate using the thermoanaerobe Caloramator boliviensis

The recently isolated anaerobic bacterium Caloramator boliviensis with an optimum growth temperature of 60 °C can efficiently convert hexoses and pentoses into ethanol. When fermentations of pure sugars and a pentose-rich sugarcane bagasse hydrolysate were carried out in a packed bed reactor with immobilized cells of C. boliviensis, more than 98% of substrates were converted. Ethanol yields of 0.40-0.46 g/g of sugar were obtained when sugarcane bagasse hydrolysate was fermented. These features reveal interesting properties of C. boliviensis in producing ethanol from a renewable feedstock.     

应用HPLC一反相色谱法测定米根霉乳酸发酵液中的有机酸

提出了一种利用高效液相色谱法分析米根霉乳酸发酵液中有机酸的方法,应用反相Wakosil-II 5C18RS色谱柱,以0．01mol/L磷酸（pH25)作为流动相,发酵液经稀硫酸预处理后直接进样分离定量,在10min内把其中的乳酸,苹果酸,富马酸等完全分离定量,各种酸回收率大于97％。经多次实验结果证明：本方法是测定乳酸发酵液中各有机酸的快速,有效的定量测定方法。     

Improvement of direct ethanol fermentation from woody biomasses by the Antarctic basidiomycetous yeast, Mrakia blollopis, under a low temperature condition

The Antarctic basidiomycetous yeast Mrakia blollopis SK-4 can quite uniquely ferment various sugars under low temperature conditions. When strain SK-4 fermented lignocellulosic biomass using the direct ethanol fermentation (DEF) technique, approximately 30% to 65% of the theoretical ethanol yield was obtained without and with the addition of the non-ionic surfactant Tween 80, respectively. Therefore, DEF from lignocellulosic biomass with M. blollopis SK-4 requires the addition of a non-ionic surfactant to improve fermentation efficiency. DEF with lipase converted Eucalyptus and Japanese cedar to 12.6 g/l, and 14.6 g/l ethanol, respectively. In the presence of 1% (v/v) Tween 80 and 5 U/g-dry substrate lipase, ethanol concentration increased about 1.4- to 2.4-fold compared to that without Tween 80 and lipase. We therefore consider that the combination of M. blollopis SK-4 and DEF with Tween 80 and lipase has good potential for ethanol fermentation in cold environments.     

In vivo, continuous and automatic monitoring of extracellular ascorbic acid by microdialysis and on-line liquid chromatography

A system for in vivo, automatic, continuous monitoring of organ extracellular ascorbic acid in anesthetized rat is described. This system involves microdialysis perfusion and a LC system equipped with an electrochemical detector. Microdialysate, eluted from a microdialysis probe implanted in the brain cortex or in the left ventricular myocardium of anesthetized rats was collected in the sample loop of an on-line injector for direct injection onto the LC system. This automated method provides a shortened sample processing time. This system was utilized to investigate the effect of cerebral ischemia on cortex extracellular ascorbic acid and the effect of myocardial ischemia on left ventricular myocardium extracellular ascorbic acid in anesthetized rats. Basal ascorbic acid concentrations in the cortex and left ventricular myocardium ranged from 9.7 to 15.4 μM (mean±S.D. 12.7±2.5 μM from the results of eight rats) and from 9.3 to 36.0 μM (mean±S.D., 24.3±8.9 μM from the results of twelve rats), respectively. Cerebral ischemia significantly elevated ascorbic acid levels in the cortex extracellular space, while myocardial ischemia did not significantly alter ascorbic acid levels in the left ventricular myocardium extracellular space.     

Applications of thin layer chromatography,high performance liquid chromatography and mass spectrometry in the fermentation and isolation of the antibiotic nybomycin

Summary Thin layer chromatography (TLC), high performance liquid chromatography (HPLC) and mass spectrometry (MS) methods have been developed for the analysis of the antibiotic nybomycin, its derivatives deoxynybomycin and nybomycin acetate, during the fermentation and isolation of nybomycin. Using a quantitative HPLC based assay, the time course of nybomycin production (nybomycin titers) in 1000 liter fermentations was determined. Desorption chemical ionization mass spectrometry (DCI/MS) of standard nybomycin samples, fermentation broth samples and purified fractions suggested the co-production of deoxynybomycin which was not reported previously from this organism. TLC and HPLC were used to confirm the presence of deoxynybomycin in the crude extracts of fermentation broths.     

An automated flow injection analysis system for on-line monitoring of glucose and L-lactate during lactic acid fermentation in a recycle bioreactor

The study concerns on-line sequential analysis of glucose and L-lactate during lactic acid fermentation using a flow injection analysis (FIA) system. Enzyme electrodes containing immobilized glucose oxidase and L-lactate oxidase were used with an amperometric detection system. A 12-bit data acquisition card with 16 analog input channels and 8 digital output channels was used. The software for data acquisition was developed using Visual C++, and was devised for sampling every hour for sequential analyses of lactate and glucose. The detection range was found to be 2–100 g l^–1 for glucose and 1–60 g l^–1 for L-lactate using the biosensors. This FIA system was used for monitoring glucose utilization and L-lactate production by immobilized cells of Lactobacillus casei subsp. rhamnosus during a lactic acid fermentation process in a recycle batch reactor. After 13 h of fermentation, complete sugar utilization and maximal L-lactate production was observed. A good agreement was observed between analysis data obtained using the biosensors and data from standard analyses of reducing sugar and L-lactate. The biosensors exhibited excellent stability during continuous operation for at least 45 days.     

Increased productivity of <Emphasis Type="Italic">Clostridium acetobutylicum</Emphasis> fermentation of acetone,butanol, and ethanol by pervaporation through supported ionic liquid membrane

Pervaporation proved to be one of the best methods to remove solvents out of a solvent producing Clostridium acetobutylicum culture. By using an ionic liquid (IL)-polydimethylsiloxane (PDMS) ultrafiltration membrane (pore size 60 nm), we could guarantee high stability and selectivity during all measurements carried out at 37°C. Overall solvent productivity of fermentation connected with continuous product removal by pervaporation was 2.34 g l⁻¹ h⁻¹. The supported ionic liquid membrane (SILM) was impregnated with 15 wt% of a novel ionic liquid (tetrapropylammonium tetracyano-borate) and 85 wt% of polydimethylsiloxane. Pervaporation, accomplished with the optimized SILM, led to stable and efficient removal of the solvents butan-1-ol and acetone out of a C. acetobutylicum culture. By pervaporation through SILM, we removed more butan-1-ol than C. acetobutylicum was able to produce. Therefore, we added an extra dose of butan-1-ol to run fermentation on limiting values where the bacteria would still be able to survive its lethal concentration (15.82 g/l). After pervaporation was switched off, the bacteria died from high concentration of butan-1-ol, which they produced.     

Structural characterization of oligosaccharides by high-performance liquid chromatography, fast-atom bombardment-mass spectrometry, and exoglycosidase digestion

A method for structural characterization of oligosaccharides after preparing uv-absorbing derivatives is described. The derivatives can be rapidly analyzed and purified by high-performance liquid chromatography, with separation of various structures determined primarily by size and sugar composition. Derivatization requires as little as 0.5-1.0 nmol of oligosaccharide, and detection of down to 50 pmol of oligosaccharide is possible by monitoring absorbance at 229 nm. In addition, the carbohydrate portion of the derivative was found to retain its sensitivity to exoglycosidases, allowing sequential enzymatic digestions for determination of sugar sequence and anomerity to be performed. The derivatives also possessed a site of potential positive charge, making them amenable to analysis by fast-atom bombardment-mass spectrometry. Permethylation of the derivatives permitted their separation by capillary gas chromatography, thus allowing investigation of their structures by gas chromatography-mass spectrometry. The combination of these techniques will allow almost the complete structure of small amounts of oligosaccharides to be determined.     

Direct and simultaneous analysis of loxoprofen and its diastereometric alcohol metabolites in human serum by on-line column switching liquid chromatography and its application to a pharmacokinetic study

A simple, rapid, and accurate column-switching liquid chromatography method was developed and validated for direct and simultaneous analysis of loxoprofen and its metabolites (trans- and cis-alcohol metabolites) in human serum. After direct serum injection into the system, deproteinization and trace enrichment occurred on a Shim-pack MAYI-ODS pretreatment column (10 mm x 4.6 mm i.d.) by an eluent consisting of 20 mM phosphate buffer (pH 6.9)/acetonitrile (95/5, v/v) and 0.1% formic acid. The drug trapped by the pretreatment column was introduced to the Shim-pack VP-ODS analytical column (150 mm x 4.6 mm i.d.) using acetonitrile/water (45/55, v/v) containing 0.1% formic acid when the 6-port valve status was switched. Ketoprofen was used as the internal standard. The analysis was monitored on a UV detector at 225 nm. The chromatograms showed good resolution, sensitivity, and no interference by human serum. Coefficients of variations (CV%) and recoveries for loxoprofen and its metabolites were below 15 and over 95%, respectively, in the concentration range of 0.1-20 microg/ml. With UV detection, the limit of quantitation was 0.1 microg/ml, and good linearity (r = 0.999) was observed for all the compounds with 50 microl serum samples. The mean absolute recoveries of loxoprofen, trans- and cis-alcohol for human serum were 89.6 +/- 3.9, 93.5 +/- 3.2, and 93.7 +/- 4.3%, respectively. Stability studies showed that loxoprofen and its metabolites in human serum were stable during storage and the assay procedure. This analytical method showed excellent sensitivity with small sample volume (50 microl), good precision, accuracy, and speed (total analytical time 18 min), without any loss in chromatographic efficiency. This method was successfully applied to the pharmacokinetic study of loxoprofen in human volunteers following a single oral administration of loxoprofen sodium (60 mg, anhydrate) tablet.     

Plasma proteomics of lung cancer by a linkage of multi-dimensional liquid chromatography and two-dimensional difference gel electrophoresis

To investigate aberrant plasma proteins in lung cancer, we compared the proteomic profiles of serum from five lung cancer patients and from four healthy volunteers. Immuno-affinity chromatography was used to deplete highly abundant plasma proteins, and the resulting plasma samples were separated into eight fractions by anion-exchange chromatography. Quantitative protein profiles of the fractionated samples were generated by two-dimensional difference gel electrophoresis, in which the experimental samples and the internal control samples were labeled with different dyes and co-separated by two-dimensional polyacrylamide gel electrophoresis. This approach succeeded in resolving 3890 protein spots. For 364 of the protein spots, the expression level in lung cancer was more than twofold different from that in the healthy volunteers. These differences were statistically significant (Student's t-test, p-value less than 0.05). Mass spectrometric protein identification revealed that the 364 protein spots corresponded to 58 gene products, including the classical plasma proteins and the tissue-leakage proteins catalase, clusterin, ficolin, gelsolin, lumican, tetranectin, triosephosphate isomerase and vitronectin. The combination of multi-dimensional liquid chromatography and two-dimensional difference gel electrophoresis provides a valuable tool for serum proteomics in lung cancer.     

Separation of the optical isomers of a new 1,4-dihydropyridine calcium channel blocker (LF 2.0254) by liquid and supercritical fluid chromatography

The four optical isomers of a new calcium channel blocker LF 2.0254 (developed by Laboratoires Fournier) are resolved by chromatography using chiral stationary phases. Two methods are proposed: the first one involving two chiral stationary phases [(S)-N-(2-naphthyl)alanine, a Pirkle type CSP and Chiralcel OJ, a cellulose derived CSP] in the liquid chromatographic mode, the second one involving a single CSP (Chiralcel OJ) in the supercritical fluid chromatographic mode. © 1994 Wiley-Liss, Inc.     

Determination of d- and l-aspartate in amino acid mixtures by high-performance liquid chromatography after derivatization with a chiral adduct of o-phthaldialdehyde

A sensitive and convenient method for the simultaneous determination of d- and l-aspartic acid in amino acid mixtures is described. The method involves derivatization of the mixture with a chiral fluorogen, followed by high-performance liquid chromatography on a reverse-phase column. The fluorogen used is an adduct of o-phthaldialdehyde with an optically active thiol, N-acetyl-l-cysteine. The sensitivity and accuracy of this method is similar to that using adducts of o-pthaldialdehyde with the achiral thiol, 2-mercaptoethanol. Five picomoles of d-aspartate can be accurately detected in the presence of a 100-fold excess of l-aspartate with a total analysis time (including derivatization) of 10 min.