嗜热子囊菌利用短链有机酸生产角质酶

以嗜热子囊菌(Thermobifida fusca WSH03-11)发酵生产角质酶为模型,研究微生物利用市政污泥厌氧酸化所产短链有机酸为碳源发酵生产高附加值产品的可能。发现：(1)以丁酸、丙酸和乙酸为碳源时,有机酸和氮元素浓度分别为8.0 g/L和1.5 g/L有利于角质酶的生产;而以乳酸为碳源时,最适有机酸和氮源浓度分别为3.0 g/L和1.0 g/L;(2)改变诱导物角质的浓度,以丁酸、丙酸、乙酸和乳酸为碳源,分别比优化前提高了31.0%、13.3%、43.8%和73.2%;(3)在四种有机酸中,T. fusca WSH03-11利用乙酸的速率最快,平均比消耗速率是丙酸的1.3倍,丁酸的2.0倍及乳酸的2.2倍;以丁酸为碳源时的酶活(52.4 U/mL)是乳酸的1.7倍、乙酸的2.5倍和丙酸的3.2倍;角质酶对乳酸的得率(12.70 u/mg)分别是丁酸的1.4倍、丙酸的3.0倍和乙酸的3.8倍;(4)以混合酸为碳源生产角质酶,T. fusca WSH03-11优先利用乙酸,而对丁酸的利用受到抑制。进一步研究发现,混合酸中0.5 g/L的乙酸将导致丁酸的消耗量降低66.7%。这是首次利用混合酸作碳源发酵生产角质酶的研究报道。这一研究结果进一步确证了利用市政污泥厌氧酸化所产有机酸为碳源发酵生产高附加值产品的可行性,为以廉价碳源生产角质酶奠定了良好的基础。     

嗜热子囊菌利用短链有机酸生产角质酶

以嗜热子囊菌(Thermobifida fusca WSH03-11)发酵生产角质酶为模型,研究微生物利用市政污泥厌氧酸化所产短链有机酸为碳源发酵生产高附加值产品的可能。发现：(1)以丁酸、丙酸和乙酸为碳源时,有机酸和氮元素浓度分别为8.0 g/L和1.5 g/L有利于角质酶的生产;而以乳酸为碳源时,最适有机酸和氮源浓度分别为3.0 g/L和1.0 g/L;(2)改变诱导物角质的浓度,以丁酸、丙酸、乙酸和乳酸为碳源,分别比优化前提高了31.0%、13.3%、43.8%和73.2%;(3)在四种有机酸中,T. fusca WSH03-11利用乙酸的速率最快,平均比消耗速率是丙酸的1.3倍,丁酸的2.0倍及乳酸的2.2倍;以丁酸为碳源时的酶活(52.4 U/mL)是乳酸的1.7倍、乙酸的2.5倍和丙酸的3.2倍;角质酶对乳酸的得率(12.70 u/mg)分别是丁酸的1.4倍、丙酸的3.0倍和乙酸的3.8倍;(4)以混合酸为碳源生产角质酶,T. fusca WSH03-11优先利用乙酸,而对丁酸的利用受到抑制。进一步研究发现,混合酸中0.5 g/L的乙酸将导致丁酸的消耗量降低66.7%。这是首次利用混合酸作碳源发酵生产角质酶的研究报道。这一研究结果进一步确证了利用市政污泥厌氧酸化所产有机酸为碳源发酵生产高附加值产品的可行性,为以廉价碳源生产角质酶奠定了良好的基础。     

Assessment of toxicity of volatile fatty acids to Photobacterium phosphoreum

The toxicity of four volatile fatty acids (VFAs) as anaerobic digestion (AD) intermediates was investigated at pH 7. Photobacterium phosphoreum T3 was used as an indicator organism. Binary, ternary and mixtures of AD intermediates were designated by letters A (acetic acid + propionic acid), B (acetic acid + butyric acid), C (acetic acid + ethanol), D (propionic acid + butyric acid), E (propionic acid + ethanol), F (butyric acid + ethanol), G (acetic acid + propionic acid + butyric acid), H (acetic acid + propionic acid + ethanol), I (acetic acid + butyric acid+ ethanol), J (propionic acid + butyric acid + ethanol) and K (acetic acid + propionic acid + butyric acid + ethanol) to assess the toxicity through equitoxic mixing ratio method. The IC₅₀ values of acetic acid, propionic acid, butyric acid and ethanol were 9.812, 7.76, 6.717 and 17.33 g/L respectively, displaying toxicity order of: butyric acid > propionic acid > acetic acid > ethanol being additive in nature. The toxic effects of four VFAs could be designated as synergistic and one additive in nature.     

Growth and pectate-lyase activity of the ruminal bacterium Lachnospira multiparus in the presence of short-chain organic acids

AIMS: Acetic, propionic, butyric and lactic acids are end products of feed fermentation by rumen microbes. The effects of these short chain acids on growth and pectate-lyase (PL) activity of Lachnospira multiparus were studied. METHODS AND RESULTS: The bacterial strain used was L. multiparus D32. Acids were tested between 50 and 300 mmol l(-1). Growth and PL activity were measured by the increase in total protein content and by the increase in absorbance at 235 nm in the reaction medium respectively. With the exception of lactic acid, all acids decreased bacterial growth rates; generally, these effects were more pronounced at higher concentrations and with acids of longer chains. PL activity was inhibited by all the acids except by butyric acid at 50 and 100 mmol l(-1). Enzyme inhibition increased with the concentrations of the acids and lactic acid was the most inhibitory. CONCLUSIONS: High concentrations of short chain acids can differentially inhibit the growth rate and the PL activity of L. multiparus. SIGNIFICANCE AND IMPACT OF THE STUDY: Products of fermentation generated by the ruminal microbiota could modify the degradation of pectic substances by this bacterium.     

Anaerobic degradation of dehydrodiisoeugenol by rumen bacteria

The degradation of dehydrodiisoeugenol (DDIE) by cow rumen bacteria was studied under strictly anaerobic conditions. After two days of cultivation, about 23% of DDIE (1.2 mM) was degraded to volatile fatty acids (VFA) such as acetic acid, propionic acid and butyric acid. The aromatic intermediates were vanillic acid, 5-methylvanillin and 3-methyl-4-hydroxybenzaldehyde, which suggested that the coumaran ring in DDIE was cleaved during degradation. These results indicate that the rumen anaerobes can degrade this lignin-related dimer to monoaromatic compounds and VFA.     

Effects of phenolic monomers on the enzymes activities and volatile fatty acids production of Neocallimastix frontalis B9

The effects of phenolic monomers (i.e. rho-coumaric acid, ferulic acid, rho-hydroxybenzaldehyde and vanillin) on the enzymes and fermentation activities of Neocallimastix frontalis B9 grown in ball-milled filter paper and guinea grass media were studied. The enzymes studied were carboxymethylcellulase (CMCase), filterpaperase (FPase), xylanase and beta-glucosidase. At 96 h of incubation, N. frontalis grown in ball-milled filter paper medium produced comparable xylanase and CMCase activities (0.41, 0.5 micromol/min/mg protein) while in guinea grass medium, N. frontalis produced higher xylanase activity than that of CMCase activity (2.35, 0.05 micromol/min/mg protein). The other enzymes activities were low. When N. frontalis was grown in ball-milled filter paper medium, only acetic acid was produced. However, when grown in guinea grass medium, the major end-product was acetate, but propionic, butyric and isovaleric were also produced in lesser amount. Vanillin showed the least inhibitory effects to enzyme activities of N. frontalis B9 grown in both ball-milled filter paper and guinea grass media. For total volatile fatty acid production, all phenolic monomers showed inhibitory effects, but rho-coumaric and ferulic acids were the stronger inhibitors than rho-hydroxybenzaldehyde and vanillin.     

Efect of the volatile fatty acids on phosphate uptake parameters by pure cultures of Acinetobacter

E.RUSTRIAN, J.P. DELGENES AND R. MOLETTA. 1996. Experiments were performed to examine the effect of volatile fatty acids(VFA) as carbon source, on the phoshate uptake parameters in four Acinetobacter strains. Acetic and butyric acids were equally good carbon sources for phosphate removal, while propionic acid was the least efficient substrate. The best ratios of assimilated phosphate vs VFA consumed were 0-178 wit acetic acid by Ac.calcoaceticus NRRL 4270, 0.21 with propionic acid by Ac.calcoaceticus NRRL 4270 AND 0.187 with butyric acid by Acinetobacter sp.SUCT 5.     

Effect in the cow of intraruminal infusions of volatile fatty acids and of lactic acid on the secretion of the component fatty acids of the milk fat and on the composition of blood

1. The effects in the cow of intraruminal infusions of acetic acid, propionic acid or butyric acid on the secretion of the component fatty acids of the milk fat, and of these acids and of lactic acid on the composition of the blood plasma of the jugular vein, have been studied. 2. The infusion of acetic acid or butyric acid increased the yield of the C₄–C₁₆ acids of milk fat but decreased the yield of C₁₈ acids. The infusion of propionic acid decreased the yields of all major component acids except palmitic acid and possibly lauric acid. 3. The changes in the concentrations in blood plasma of glucose and of ketone bodies were consistent with the glucogenic effect of propionic acid and the ketogenic effects of butyric acid and acetic acid. The effects of lactic acid were not consistent from cow to cow. Only with the infusion of acetic acid was a significant increase in the concentration of total volatile fatty acids in blood plasma found. Infusions of butyric acid and of propionic acid tended to depress the concentration of citric acid in the blood plasma and infusion of acetic acid increased it. No consistent effects of the infused acids on the concentration in blood plasma of esterified cholesterol, free cholesterol, triglyceride or phospholipid were observed. 4. The possibility is discussed that the effects of the infused acids on milk-fat secretion are caused through an alteration of the concentrations of precursors of milk fat in mammary arterial blood.     

Anaerobic digestion of swine manure under natural zeolite addition: VFA evolution, cation variation, and related microbial diversity

Batch experiments were carried out on anaerobic digestion of swine manure under 10 % of total solids and 60 g/L of zeolite addition at 35 °C. Four distinctive volatile fatty acid (VFAs) evolution stages were observed during the anaerobic process, i.e., VFA accumulation, acetic acid (HAc) and butyric acid (HBu) utilization, propionic acid (HPr) and valeric acid (HVa) degradation, and VFA depletion. Large decreases in HAc/HBu and HPr/HVa occurred respectively at the first and second biogas peaks. Biogas yield increased by 20 % after zeolite addition, about 356 mL/g VS_added with accelerated soluble chemical oxygen demand degradation and VFA (especially HPr and HBu) consumption in addition to a shortened lag phase between the two biogas peaks. Compared with Ca²⁺ and Mg²⁺ (100–300 mg/L) released from zeolite, simultaneous K⁺ and NH₄ ⁺ (580–600 mg/L) adsorptions onto zeolite particles contributed more to the enhanced biogasification, resulting in alleviated inhibition effects of ammonium on acidogenesis and methanogenesis, respectively. All the identified anaerobes could be grouped into Bacteroidetes and Firmicutes, and zeolite addition had no significant influence on the microbial biodiversity in this study.     

Effect of Organic Acids on Shrimp Pathogen, <Emphasis Type="Italic">Vibrio harveyi</Emphasis>

Shrimp farming accounts for more than 40% of the world shrimp production. Luminous vibriosis is a shrimp disease that causes major economic losses in the shrimp industry as a result of massive shrimp kills due to infection. Some farms in the South Asia use antibiotics to control Vibrio harveyi, a responsible pathogen for luminous vibriosis. However, the antibiotic-resistant strain was found recently in many shrimp farms, which makes it necessary to develop alternative pathogen control methods. Short-chain fatty acids are metabolic products of organisms, and they have been used as food preservatives for a long time. Organic acids are also commonly added in feeds in animal husbandry, but not in aquaculture. In this study, growth inhibitory effects of short-chain fatty acids, namely formic acid, acetic acid, propionic acid, and butyric acid, on V. harveyi were investigated. Among four acids, formic acid showed the strongest inhibitory effect followed by acetic acid, propionic acid, and butyric acid. The minimum inhibitory concentration (MIC) of 0.035% formic acid suppressed growth of V. harveyi. The major inhibitory mechanism seems to be the pH effect of organic acids. The effective concentration 50 (EC₅₀) values at 96 h inoculation for all organic acids were determined to be 0.023, 0.041, 0.03, and 0.066% for formic, acetic, propionic, and butyric acid, respectively. The laboratory study results are encouraging to formulate shrimp feeds with organic acids to control vibrio infection in shrimp aquaculture farms.     

Short-chain fatty acids enhance diffusional ca transport in the epithelium of the rat cecum and colon

We examined the effect of short-chain fatty acids (SCFAs) on Ca absorption from the large intestine in rats in vitro. An Ussing-type chamber technique was used to determine the net transport of Ca from the luminal side to the basolateral side of isolated epithelium in cecum and colon preparations. The concentration of Ca in the serosal and mucosal Tris buffer solution was 1.25 mM and 10 mM, respectively. Both solutions were warmed at 37 degrees C and bubbled with 95% O2 and 5% CO2. During and after the incubation period (30 min or 60 min), the Ca concentration in the serosal medium was determined and the net transepithelial Ca transport was evaluated. The addition of 80 mM acetic acid, 40 mM propionic acid and 10 mM butyric acid to the mucosal medium increased net Ca absorption (about 300%) in the cecum and colon. An individual application of acetic, propionic or butyric acid (0.01 to 100 mM) to the mucosal medium also increased net Ca absorption at doses of 10 mM and /or 100 mM in the cecum and colon. An increase in solute concentration in the mucosal medium by addition of glycerol or PGE400, or a decrease in pH (7.0-3.0) by addition of HCl did not affect transepithelial Ca transport. We concluded that SCFAs affect the epithelial tissue and promote Ca absorption from the large intestine in vitro. The enhancement of Ca transport induced by SCFAs might be involved in the paracellular transport mechanism.     

Microbiological Degradation of Malodorous Substances of Swine Waste under Aerobic Conditions

Phenol, p-cresol, and volatile fatty acids (VFA; acetic, propionic, isobutyric, butyric, isovaleric, and valeric acids) were used as odor indicators of swine waste. Aeration of the waste allowed the indigenous microorganisms to grow and degrade these malodorous substances. The time required for degradation of these substances varied according to the waste used, and it was not necessarily related to their concentrations. Using a minimal medium which contained one of the malodorous compounds as sole carbon source, we have selected from swine waste microorganisms that can grow in the medium. The majority of these microorganisms were able to degrade the same substrate when inoculated in sterilized swine waste but with an efficiency varying from one strain to the other. None of these strains was able to degrade all malodorous substances studied. Within 6 days of incubation these selected strains degraded the following: Acinetobacter calcoaceticus, phenol and all VFA; Alcaligenes faecalis, p-cresol and all VFA; Corynebacterium glutamicum and Micrococcus sp., phenol, p-cresol, and acetic and propionic acids; Arthrobacter flavescens, all VFA. On a laboratory scale, the massive inoculation of swine waste with C. glutamicum or Micrococcus sp. accelerated degradation of the malodorous substances. However, this effect was not observed with all of the various swine wastes tested. These results suggest that an efficient deodorization process of various swine wastes could be developed at the farm level based on the aerobic indigenous microflora of each waste.     

The ability of the rumen protozoan <Emphasis Type="Italic">Eudiplodinium maggii</Emphasis> to utilize chitin

The ability was determined of the rumen ciliate Eudiplodinium maggii to utilize chitin from fungal cell wall. Cultivation experiments shoved that the population concentration (number of ciliates in vitro) was positively correlated with chitin doses. Cell extract prepared from the bacteria-free ciliates degraded colloidal chitin releasing 2.0 μmol reducing sugar per mg protein per h. End products of this reaction were chitotriose and N-acetylglucosamine. Incubation of the bacteria-free ciliates with chitin resulted in an increase in the concentration of acetic, propionic and butyric acids in the incubation medium. The production rate of total volatile fatty acids (VFA) by ciliates incubated with and without chitin was 45.0 and 30.5 pmol VFA per protozoan, respectively, the molar proportion of particular acids remaining unchanged.     

Volatile fatty acid concentrations in the digestive tract of the West Indian manatee, Trichechus manatus

1. Digesta samples were collected from five West Indian manatees, Trichechus manatus, for volatile fatty acid (VFA) analysis. 2. Mean total VFA concentrations were low in the stomach and duodenum (18.6 and 12.3 mM/l, respectively). Mean VFA concentrations were considerably higher in the cecum and colon (220.6 and 307.3 mM/l, respectively). 3. The relative proportions of the individual VFA's shifted from predominantly acetic acid in the foregut to a mixture of acetic, butyric and propionic acids in the hindgut. 4. The VFA concentrations in the manatee are similar to those in the dugong, Dugong dugon, and the green sea turtle, Chelonia mydas. 5. The mean total VFA concentrations indicate that the cecum and colon of the manatee are sites of microbial cellulose fermentation. The contribution of VFAs to the manatees' total energy requirements could not be calculated, but it is probably considerable.     

Response surface methodology analysis of anaerobic syntrophic degradation of volatile fatty acids in an upflow anaerobic sludge bed reactor inoculated with enriched cultures

Anaerobic oxidation of volatile fatty acids (VFAs) as the key intermediates is restricted thermodynamically. Presently, enriched acetogenic and methanogenic cultures were used for syntrophic anaerobic digestion of VFAs in an upflow anaerobic sludge bed reactor fed with acetic, propionic, and butyric acids at maximum concentrations of 5.0, 3.0, and 4.0 g/L, respectively. Interactive effects of propionate, butyrate and acetate were analyzed. Hydraulic retention time (HRT) and acetate oxidizing syntrophs and methanogen (hydrogenotrophs) to syntrophic bacteria (propionate- and butyrate-oxidizing bacteria) population ratio (M/A) were investigated as key microbiological and operating variables of VFA anaerobic degradations. M/A did not affect the size distribution and had little effect on extracellular polymer contents of the granules. Granular sludge with close spatial microbial proximity enhanced syntrophic degradation of VFAs compared to other cultures, such as suspended cultures. Optimum conditions were found to be propionate = 1.93 g/L, butyrate = 2.15 g/L, acetate = 2.50 g/L, HRT = 22 h, and M/A = 2.5 corresponding to maximum VFA removal and biogas production rate. Results of verification experiments and predicted values from fitted correlations were in close agreement at the 95% confidence interval. Granules seemed to be smaller particles and less stable in construction with an irregular fractured surface compared to the original granules.     

Inhibitory effect of medium-chain-length fatty acids on synthesis of polyhydroxyalkanoates from volatile fatty acids by Ralstonia eutropha

Medium-chain-length fatty acids, such as nonanoic (9:0) and octanoic (8:0) acids, are more toxic to Ralstonia eutropha than volatile fatty acids such as acetic, propionic and butyric acids. Nonanoic acid was degraded to acetic and propionic acids via -oxidation by Ralstonia eutropha for cell growth and synthesis of polyhydroxyalkanoates (PHAs). In a mixture of the fatty acids, utilization of nonanoic acid was depressed by acetic and propionic acids, and vice versa. The PHA accumulation from the volatile fatty acids was decreased from 53% (w/w) of dry cell mass to 23% due to the nonanoic acid. Similar phenomena were also observed with octanoic acid and its metabolic intermediates, acetic and butyric acids.     

Strategies for the development of a side stream process for polyhydroxyalkanoate (PHA) production from sugar cane molasses

A three-stage process was developed to produce polyhydroxyalkanoates (PHAs) from sugar cane molasses. The process includes (1) molasses acidogenic fermentation, (2) selection of PHA-accumulating cultures, (3) PHA batch accumulation using the enriched sludge and fermented molasses. In the fermentation step, the effect of pH (5–7) on the organic acids profile and productivity was evaluated. At higher pH, acetic and propionic acids were the main products, while lower pH favoured the production of butyric and valeric acids. PHA accumulation using fermented molasses was evaluated with two cultures selected either with acetate or fermented molasses. The effect of organic acids distribution on polymer composition and yield was evaluated with the acetate selected culture. Storage yields varied from 0.37 to 0.50 Cmmol HA/Cmmol VFA. A direct relationship between the type of organic acids used and the polymers composition was observed. Low ammonia concentration (0.1 Nmmol/l) in the fermented molasses stimulated PHA storage (0.62 Cmmol HA/Cmmol VFA). In addition, strategies of reactor operation to select a PHA-accumulating culture on fermented molasses were developed. The combination of low organic loading with high ammonia concentration selected a culture with a stable storage capacity and with a storage yield (0.59 Cmmol HA/Cmmol VFA) similar to that of the acetate-selected culture.     

Using enriched cultures for elevation of anaerobic syntrophic interactions between acetogens and methanogens in a high-load continuous digester

Volatile fatty acids (VFAs) are key intermediates in anaerobic digestion. Enriched acetogenic and methanogenic cultures were used for syntrophic anaerobic digestion of VFAs in a high-load continuous reactor fed with acetic (HAc), propionic (HPr) and butyric (HBu) acids at maximum concentrations of 5, 3 and 4 g/L, respectively. Interactive effects of HPr, HBu and HAc were analyzed. Furthermore, hydraulic retention time (HRT) and methanogen to acetogen population ratio (M/A) were investigated as key microbiological and operating variables of VFA anaerobic degradations. Optimum conditions were found to be HPr = 1125.0 mg/L, HBu = 1833.4 mg/L, HAc = 1727.4 mg/L, HRT = 21 h and M/A = 2.5 (corresponding to maximum VFA removal and biogas production rate (BPR)). Results of verification experiments and predicted values from fitted correlations were in close agreement at 95% confidence interval. HRT and M/A had positive effects on VFA removal and BPR. M/A was the most important factor that affected BPR. All VFAs inhibited VFA removals.     

Growth characteristics of Geotrichum ingens on propionic acid and acetic acid in batch and continuous culture

Growth of Geotrichum ingens in batch cultures was completely inhibited by 47 g acetic acid/l or 33 g propionic acid/I. With mixtures of acetic and propionic acids, however, growth only ceased at 55 g/l. Acetic acid inhibited growth linearly, whereas propionic acid inhibited growth non-linearly. In continuous culture, two steady states at each dilution rate were observed at high dilution rates for acetic acid and propionic acid. The highest yield coefficient (0.69 g cells/g substrate) was achieved with propionic acid as substrate. On both substrates and their mixtures, the protein content of the biomass increased when the dilution rate was increased.The authors are with the Department of Microbiology and Biochemistry, University of the Orange Free State, P.O. Box 339, Bloemfontein 9300, South Africa