The production of foot-and-mouth disease virus from BHK 21 C 13 cells grown on the surface of glass spheres.

In view of the advantages which are associated with the use of the BHK monolayer cell for the production of foot-and-mouth disease (FMD) virus, a unit system using glass spheres was developed to grow BHK monolayer cells and to test the susceptibility of such cells to FMD virus. The yield of cells and their susceptibility compares favorably with GREEN BHK monolayer cells which have been grown in Roux bottles.     

Decigram quantities of pure foot-and-mouth disease virus from cell cultures

Baby-hamster kidney (BHK) cell cultures grown in rolling 2-liter Baxter bottles are used for the production of foot-and-mouth disease virus (FMDV) which is subsequently purified. The bottles are held securely in round wire racks (19 per rack) and rotated on a three-tiered roller mill. The use of a strongly buffered growth medium makes changes of the medium unnecessary. A sheet of aluminum foil is used to seal the cultures. It is pressed tightly over all the bottles in a rack by means of a polyurethane foam sheeting bonded to the underside of a rigid snap-on cover. Special equipment eliminates removing the bottles from the racks at any stage in their use. The loaded racks fit directly onto headers of a glassware washer. Spent cell growth media and virus fluids are collected by inverting an entire rack of bottles-Current production is 400 BHK cultures (21 racks) containing 8 × 10⁸ cells each after 6 days growth. About 344 of these cultures (18 racks) are used to grow virus. The purification process yields about 113 mg of pure FMDV per week; the overall recovery based on infectivity is 32%. The projected maximum production of purified virus in the present facilities is approximately 2.5 times greater than this amount.     

Induction of antibody to foot-and-mouth disease virus in presensitized mouse spleen cell cultures.

Cultures of spleen cells from immunized mice were stimulated in vitro by soluble preparations of purified foot-and-mouth disease virus. Virus-specific antibody, as detected by an enzyme-linked immunosorbent assay, was produced by immune spleen cells but not by normal, nonimmune cells. The optimal specific response was obtained with 1 microgram of virus per ml of culture; as the virus concentration was increased, the production of specific antibody was reduced. For very low concentrations of virus (less than 0.01 microgram per culture), there was tentative evidence of suppression of the specific antibody response. The levels of specific antibody induced were dependent on the source and number of plastic-adherent cells present in the cultures. We intend to use this model system to study further the basis of immunity to foot-and-mouth disease virus.     

The production of foot-and-mouth disease virus from BHK 21 C 13 cells grown on the surface of DEAE sephadex A50 beads.

Methods are described which make possible the production of foot-and-mouth disease (FMD) virus from BHK 21 C13 monolayer cells which have been grown on the surface of serum coated DEAE Sephadex A50 beads. The yield of cells and their susceptibility to infection by FMD virus are equivalent to conventional Roux monolayer systems. The potential for the commercial application of the DEAE Sephadex A50 system is discussed in relation to other unit process monolayer systems and in particular to the system in which cells are cultured in a deep bed of small glass spheres.     

Inhibition of foot-and-mouth disease virus infections in cell cultures with antisense morpholino oligomers

Foot-and-mouth disease (FMD) is a highly contagious viral disease of cloven-hoofed ungulates that can lead to severe losses in the livestock production and export industries. Although vaccines have been extensively used to control FMD, there is no antiviral therapy available to treat ongoing infections with FMD virus (FMDV). Six peptide-conjugated morpholino oligomers (PPMOs) with sequences complementary to various 21-nucleotide segments of the 5' and 3' untranslated regions (UTRs) of the FMDV genome (strain A(24) Cruzeiro/Brazil/1955 [A(24)Cru]) were evaluated in cell cultures. Three of the PPMOs, targeting domain 5 of the internal ribosome entry site (5D PPMO), and the two translation start codon regions (AUG1 and AUG2 PPMOs), showed high levels of anti-FMDV activity. A dose-dependent and sequence-specific reduction in viral titers of greater than 5 log(10), with a concomitant reduction of viral protein and RNA expression, was achieved at low micromolar concentrations. Under identical conditions, three other PPMOs targeting the 5'-terminal region of the genome, the cis-acting replication element in the 5' UTR, and the 3' "ab" stem-loop showed less dramatic titer reductions of 1.5 log(10) to 2 log(10). Treatment with 5D PPMO reduced the titers of FMDV strains representing five different serotypes by 2 log(10) to 4 log(10) compared to those of the controls. A(24)Cru-infected BHK-21 cells treated repeatedly with 5D or AUG2 PPMO generated resistant viruses for which phenotypic and genotypic properties were defined. Notably, three passages with low concentrations of the AUG1 PPMO extinguished all traces of detectable virus. The results indicate that PPMOs have potential for treating FMDV infections and that they also represent useful tools for studying picornaviral translation and evolution.     

Effect of the replication of rubella virus on the protein biosynthesis of BHK 21 cell cultures]

The protein biosynthesis of BHK-21/C 13 cell cultures under the influence of multiplying rubella virus was studied by the uptake and incorporation of 14C leucine. The uptake of 14C leucine by the cells of virus-infected cultures was found to increase up to the third day after infection; no further increase was detectable on the fourth day. Control cultures maintained under the same conditions showed a similar behaviour up to the second and on the fourth day. On the third day, the virus-infected cultures exhibited significantly higher uptake than the controls. It may be that the virus infection causes damage to the cellular wall, the nature of which has yet to be elucidated. The protein incorporation of 14C leucine slightly increases in the virus-infected cultures 36 hrs after infection. This increase is not equally pronounced in the control cultures, but the differences were not significant.     

The supply of oxygen to submerged cultures of BHK 21 cells

Oxygen solution rates were measured in 4, 30, and 100 liter culture vessels, and the oxygen demand of growing BHK 21 cells estimated. This data was used to calculate the minimal sparged air rates necessary to satisfy oxygen demand throughout the cell growth cycle, and in this way adequate oxygen was supplied without the damaging effects of excessive sparging. Comparable results were obtained when oxygen was supplied by this method and when pO₂ was controlled at 80 mmHg, but both cell growth rate and maximum cell density were reduced when pO₂ was controlled at other values.     

口蹄疫病毒样颗粒诱导表达型载体的构建及其BHK-21细胞池的筛获

瞬时表达是目前利用哺乳动物细胞表达口蹄疫病毒(foot-and-mouth disease virus, FMDV)衣壳蛋白的主流方法。为实现染色体稳定表达FMDV衣壳蛋白并高效组装出病毒样颗粒(virus like particles, VLPs)，本研究构建了piggyBac (PB)转座-组成型表达、PB转座-四环素(tetracycline, Tet)诱导型表达两套质粒。利用荧光蛋白标记技术，验证了质粒的功能。通过抗生素筛选得到了组成型表达P12A3C (WT/L127P)基因的BHK-21细胞池(C-WT、C-L127P)和诱导型表达P12A3C (WT/L127P)基因的BHK-21细胞池(I-WT、I-L127P)。荧光观察和PCR检测证明了绿色荧光蛋白、3C蛋白酶、反向四环素转录激活因子等基因的稳定整合。Western blotting、酶联免疫吸附法(enzyme linked immunosorbent assay, ELISA)实验证明了细胞池I-L127P具有更强的衣壳蛋白和VLPs生产能力。本研究首次实现了哺乳动物细胞染色体诱导表达FMDV衣壳蛋白，有助于推动哺乳动物生产FMDV VLPs疫苗的技术工艺，也为构建其他蛋白的哺乳动物细胞诱导型表达系统提供了参考。     

应用BHK21细胞检测汉坦病毒中和抗体方法的建立

本文报道应用汉坦病毒（HV）Ⅰ型76－118、Chen、J3、J5、J12,和Ⅱ型UR、R22、L99等8株病毒在BHK21细胞上培养和观察,发现病毒感染BHK21细胞后可规律出现病变,且可测出病毒滴度。分别应用BHK21细胞与Vero-E6细胞同时做空斑减少中和试验（PRNT）检测同批血清的抗体中和效价,结果一致,且稳定性特异性好,因此BHK21细胞可作为研究HV的另一个敏感实验细胞系,对研究HV的某些生物学特性及实验方法均有实用价值。     

Exposure of in vitro-produced bovine embryos to foot-and-mouth disease virus

The aim of this study was to investigate whether foot and mouth disease virus (FMDV) interacts with in vitro produced (IVP) bovine embryos. One milliliter of a suspension of FMDV (2 x 10(7) TCID50/mL) was added to several batches of these embryos 7 d after in vitro fertilization, by which time they had either developed to the morula/blastocyst stage (n = 256) or degenerated (n = 260). Six experiments were performed in which developed or degenerated batches of embryos were incubated with FMDV for periods of 1 h (3), 2 h (2) or 4h (1). After this, the embryos were washed 10 times according to the International Embryo Transfer Society (IETS), then pooled and ground up to form a suspension, and assayed on cell cultures for FMDV. The cell cultures were observed daily for cytopathic effects for 3 d post exposure. In addition to the cell culture method, the polymerase chain reaction (PCR) technique was used to assay for the presence of the virus in the washing fluids. Assays for FMDV were also conducted on the first and second wash and on the pooled sample constituting the eight, ninth and tenth wash. With the exception of the second wash from a batch of embryos exposed to FMDV for 2 h, all samples of the first and second wash produced FMDV cytopathic effects, but none occurred with the pooled samples of the 8th, 9th and 10th wash. FMDV was also isolated from all but 1 of the batches of embryos after 1 h of incubation, from 1 of 4 batches after 2 h of incubation and from all batches after 4 h incubation. By contrast, the presence of virus could not be demonstrated by PCR based on the technique used here. These results show that 7 d old IVP bovine embryos can retain FMDV after washing, unlike in vivo-derived embryos, which do not appear to carry risks of FMDV transmission when washed according to IETS recommendations. Stricter controls are, therefore, necessary when using IVP embryos from cattle in a non-FMD-free zone in domestic or international trade.     

The acidic amino acid transport system of the baby hamster kidney cell line BHK21-C13

The uptake of L-glutamate into BHK21-C13 cells in culture has been studied. This amino acid appears to be transported via a relatively high affinity, low capacity, Na+-dependent transport system capable of the rapid accumulation of substrate amino acids. Kinetic studies of the inhibition of L-glutamate uptake has provided information as to the substrate and the molecular configuration required for transport via the glutamate transport system. This system exhibited marked substrate specificity and was only capable of transporting L-glutamate and aspartate and certain closely related acidic amino acid analogues.     

The thermal death time curve for foot-and-mouth disease virus contained in primarily infected milk

Whole and skim milk obtained from cows after intramammary and intravenous inoculation with foot-and-mouth disease virus (primarily infected milk) were exposed to various temperatures ranging from 80 to 148 degrees C for various times ranging from 2.5 s to 27 min then tested for viral infectivity. The average pretreatment titre of the 53 lots of milk used was 10(5.9) plaque-forming units of virus per millilitre 10(3.7)-10(6.8)). A thermal death time curve was plotted using the data obtained. The curve demonstrates that in order to inactivate the virus, times of over 20 min are necessary at 'low' temperatures (100 degrees C) while 2.5 s is sufficient at a temperature of 148 degrees C.