The use of the bacteriocin, nisin, as a preservative in ricotta-type cheeses to control the food-borne pathogen Listeria monocytogenes

The efficacy of nisin to control the food-borne pathogen Listeria monocytogenes in ricotta-type cheeses over long storage (70 d) at 6–8°C was determined. Cheeses were prepared from unpasteurized milk by direct acidification with acetic acid (final pH 5·9) and/or calcium chloride addition during heat treatment. Nisin was added in the commercial form of Nisaplin^® pre-production to the milk. Each batch of cheese was inoculated with 10²–10³ cfu g⁻¹ of a five-strain cocktail of L. monocytogenes before storage. Shelf-life analysis demonstrated that incorporation of nisin at a level of 2·5 mg l⁻¹ could effectively inhibit the growth of L. monocytogenes for a period of 8 weeks or more (dependent on cheese type). Cheese made without the addition of nisin contained unsafe levels of the organism within 1–2 weeks of incubation. Measurement of initial and residual nisin indicated a high level of retention over the 10-week incubation period at 6–8°C, with only 10–32% nisin loss.     

Nisin induces changes in membrane fatty acid composition of Listeria monocytogenes nisin-resistant strains at 10°C and 30°C

Listeria monocytogenes isolates resistant to 10⁵ IU ml^-1 nisin were obtained at 30°C (NR30) and at 10°C (NR10). Nisin prolonged the lag phase of isolate NR30 at 10°C. Isolates NR30 and NR10 did not produce a nisinase. Protoplasts of isolate NR30 were unaffected by exposure to nisin. The fatty acid composition from the wild-type strain and NR isolates was determined. As expected, temperature-induced differences in the C15/C17 fatty acid ratios were found. Growth of the NR strains in the presence of nisin resulted in significantly different C15/C17 ratios and a significant increase in the percentage of C16:0, C16: 1, C18:0 and C18: 1 fatty acids at 10°C and 30°C. Both the NR10 and NR30 isolates had similar growth rates at low temperatures, but these were slower than the wild-type strain. These results indicate that 'nisin resistance'is an environmentally defined phenotype and that nisin induces changes in the fatty acid composition of the membrane in L. monocytogenes nisin-resistant isolates regardless of the growth temperature.     

Sensitivity of Bacillus coagulans spores to combinations of high hydrostatic pressure, heat, acidity and nisin

We investigated the combined effects of pressure, temperature, pH, initial spore concentration and the presence of nisin on the survival of spores of Bacillus coagulans. Spores were more sensitive to pressure both at lower pH and at higher treatment temperatures. An additional 1.5-log₁₀ reduction in cfu ml^-1 was observed when pH was lowered from 7.0 to 4.0 during pressurization at 400 Mpa and 45°C. A 4-log₁₀ cfu ml^-1 reduction was observed when the temperature was increased from 25°C to 70°C during pressurization at 400 Mpa. The spores were sensitive to nisin at concentrations as low as 0.2 IU ml^-1. At least a 6-log₁₀ reduction was generally achieved with pressurization at 400 Mpa in pH 4.0 buffer at 70°C for 30 min when plated in nutrient agar containing 0.8 IU ml^-1 nisin.     

Use of bacteriocinogenic lactic acid bacteria to inhibit spontaneous nisin-resistant mutants of Listeria monocytogenes Scott A

Nisin is a bacteriocin with a broad antibacterial spectrum including strains of Listeria monocytogenes . Populations of L. monocytogenes , however, frequently contain spontaneous nisin-resistant mutants. When a culture of L. monocytogenes Scott A was exposed to nisin concentrations between 10 and 500 IU ml⁻¹, the initial decrease in viable numbers was followed by regrowth of survivors to nisin. Nisin-resistant mutants of L. monocytogenes Scott A were isolated after a single exposure to nisin at 100 IU ml⁻¹ and were shown to be sensitive to the non-nisin bacteriocins, sakacin A and enterocin B, produced by Lactobacillus sake Lb 706 and Enterococcus faecium BFE 900, respectively. The regrowth of L. monocytogenes Scott A following the initial decrease due to exposure to nisin was prevented by nisin-resistant Lact. sake Lb 706–1a and to a somewhat lesser extent, by Ent. faecium BFE 900–6a. Listerial cells surviving nisin action were thus inhibited by the bacteriocin-producing strains that might be used as starter or protective cultures in foods. Growth of a nisin-resistant mutant of L. monocytogenes Scott A (Li3) was also suppressed by the bacteriocinogenic cultures. Use of nisin in combination with a starter culture producing a non-nisin antilisterial bacteriocin may therefore prevent the emergence of nisin-resistant mutants of L. monocytogenes .     

Nisin, temperature and pH effects on growth and viability of Pectinatus frisingensis, a Gram-negative, strictly anaerobic beer-spoilage bacterium

Pectinatus frisingensis , a Gram-negative and strictly anaerobic beer spoilage bacterium is sensitive to nisin. An increase in nisin concentration (0 to 1100 IU ml⁻¹) added to the culture medium prolonged the lag phase, and decreased the growth rate of the bacterium. In addition, late exponential cells of P. frisingensis exposed to low concentrations of nisin lost immediately a part of their intracellular K⁺. Presence of Mg²⁺ up to 15 mmol l⁻¹ did not protect P. frisingensis from nisin-induced loss of viability and K⁺ efflux. Potassium leaks were also measured in P. frisingensis late exponential phase cells exposed to combined effects of nisin addition (100–500 IU ml⁻¹), 10 min mild heat-treatment (50 °C) or rapid cooling (2 °C), and pH (4·0 and 6·2). Net K⁺ efflux from both starving and glucose-metabolizing cells, was more important at pH 6·2, whatever the temperature treatment and nisin addition. Reincubation at 30 °C of P. frisingensis glucose-metabolizing cells exposed to a preliminary combination of nisin addition and mild heat or cooling down treatment, showed that cells exposed to rapid cooling reaccumulated more K₊ than heat-treated cells, whatever the pH conditions. A combination of nisin and mild heat-treatment could thus be of interest to prevent P. frisingensis growth in beers.     

Factors affecting the growth of Listeria monocytogenes on minimally processed fresh endive

The influence of various factors on the fate of Listeria monocytogenes on cut leaves of broad-leaved endive has been studied. Factors considered were temperature, characteristics of the leaves (age, quantity and quality of the epiphytic microflora) and characteristics of the L. monocytogenes inoculum (concentration, strain). The increases in numbers of L. monocytogenes were lower than those of the aerobic mesophilic microflora at 3°, 6°, 10° and 20°C. Doubling times of the populations of L. monocytogenes were in the same order of magnitude as those of aerobic bacteria at 10° and 20°C, but longer at 3° and 6°C. There were positive significant correlations between growth of L. monocytogenes and populations of aerobic bacteria, and between growth of L. monocytogenes and extent of spoilage on the leaves.
Of 225 bacteria isolated from the leaves, 84% were identified as fluorescent pseudomonads; there was no difference in the species isolated from leaves that showed a low growth of L. monocytogenes and leaves that showed a high growth of L. monocytogenes. Populations of L. monocytogenes increased faster during the first 2 and 4 d of storage at 10°C on leaves inoculated with 10–10³ cfu g^-1 than on leaves inoculated with about 10⁵ cfu g^-1, but the population reached after 7 d was lower. The behaviour of L. monocytogenes was similar among the three strains tested.     

Production of a nisin Z/pediocin mixture by pH-controlled mixed-strain batch cultures in supplemented whey permeate

The conditions for high production of nisin Z and pediocin during pH-controlled, mixed-strain batch cultures in a supplemented whey permeate medium with Lactococcus lactis subsp. lactis biovar. diacetylactis UL719, a nisin Z producer strain, and variant T5 of Pediococcus acidilactici UL5, a pediocin-producing strain resistant to high concentrations of nisin, were studied. Mixed cultures were performed at 37 °C and pH 5·5 by first inoculating with variant T5 and then with L. diacetylactis UL719 after 8 h incubation, and were compared with single-strain batch cultures. High productions of both nisin Z and pediocin were obtained after 18 or 16 h incubation during mixed cultures, with titres of 3000 and 730 AU ml⁻¹, or 1060 and 1360 AU ml⁻¹, respectively, corresponding to approximately 75 and 55, or 25 and 100 mg l⁻¹ of pure nisin Z and pediocin, respectively. In pure cultures, nisin Z and pediocin productions were higher than in mixed cultures, and maximum activities were obtained after 10 h incubation, with approximately 10 000 AU ml⁻¹ (250 mg l⁻¹ pure nisin Z) and 2500 AU ml⁻¹ (190 mg l⁻¹ pure pediocin). During mixed cultures, significant pediocin degradation was observed in the culture supernatant fluid after 16 h incubation, together with a sharp drop in Ped. acidilactici UL5 cell viability. In the test conditions, the feasibility of producing a nisin/pediocin mixture by mixed-strain fermentation was demonstrated. The bacteriocin mixture produced in a supplemented whey permeate medium could be used as a natural food-grade biopreservative with a broad activity spectrum.     

Behaviour of Staphylococcus aureus strains, producers of enterotoxins C1 or C2, during the manufacture and storage of Burgos cheese

Burgos cheese was manufactured from pasteurized ewes milk inoculated with Staphylococcus aureus strains FRI 137 and FRI 361, at levels of ca 10³ and 10⁵ cfu/ml and stored at 4°, 10° and 15°C and at room temperature (10°-15°C). Populations of Staph. aureus and mesophilic aerobes, pH, and production of thermonuclease and enterotoxins C₁ and C₂ were investigated. Aerobic counts increased during cheese-making and storage. With both test strains, important growth was observed only during the storage period, the larger levels corresponding to the higher temperatures. Although Staph. aureus strains attained populations of over 10⁸ cfu/g, no enterotoxin was detected. Strain FRI 361 reached 10⁷ cfu/g without production of a detectable amount of thermonuclease. With strain FRI 137, the minimal population associated with enzyme activity was influenced by the inoculum size. Staphylococcus aureus counts are better indicators of staphylococcal growth in Burgos cheese than the thermonuclease test.     

Isolation and characterization of nisin-producing Lactococcus lactis subsp. lactis from bean-sprouts

Bacterial isolates from bean-sprouts were screened for anti- Listeria monocytogenes bacteriocins using a well diffusion method. Thirty-four of 72 isolates inhibited the growth of L.monocytogenes Scott A. One, HPB 1688, which had the biggest inhibition zone against L.monocytogenes Scott A, was selected for subsequent analysis. Both ribotyping and DNAsequencing of 16S ribosomal RNA gene demonstrated that the isolate was Lactococcus lactis subsp. lactis . Polymerase chain reaction and nucleotide sequencing revealed that thegenomic DNA of the bean-sprout isolates contained a nisin Z structural gene. In MRS broth,bean-sprout isolate HPB 1688 survived at 3–4·5°C for at least 20 d, grew at 4°Cand produced anti-listerial compoundsat 5°C. When co-cultured with L. monocytogenes in MRS broth, the isolate inhibited thegrowth of L. monocytogenes at 4°C after 14d and at 10°C after 2 d. When co-inoculatedwith 10²cells g⁻¹ of L.monocytogenes on fresh-cut ready-to-eat Caesar salad, L. lactis subsp. lactis (10⁸cells g⁻¹) was able to reduce the number of L. monocytogenes by 1–1·4 logs after storage for 10 d at 7° and 10°C. A bacteriocin-producing Enterococcusfaecium was also able to reduce the numbers of L. monocytogenes onCaesar salad, butdid not act synergistically when co-inoculated with L. lactis subsp. lactis .     

Susceptibility of bifidobacteria to nisin

A collection of 17 bifidobacteria was tested for sensitivity or resistance to lantibiotic nisin. Minimal inhibitory concentration of the strain tested was highly variable, ranging from 4·88 to 10 000 IU ml⁻¹. In general, strains isolated from faecal samples were more resistant than those purchased from culture collections. These results could be useful in the production of foods containing both bifidobacteria and nisin.     

Effects of gaseous environment and temperature on the storage behaviour of Listeria monocytogenes on chicken breast meat

Portions of skinless chicken breast meat (pH 5·8) were inoculated with a strain of Listeria monocytogenes and stored at 1, 6 or 15°C in (1) aerobic conditions; (2) 30% CO₂+ air; (3) 30% CO₂+ N₂; and (4) 100% CO₂. When samples were held at 1°C the organism failed to grow under any of the test conditions, despite marked differences between treatments in spoilage rate and ultimate microflora. At 6°C counts of L. monocytogenes increased ca 10-fold in aerobic conditions before spoilage of the meat, but only when the inoculum culture was incubated at 1°C rather than 37°C. In CO₂ atmospheres growth of L. monocytogenes was inhibited on meat held at 6°C, especially under 100% CO₂. By contrast, storage at 15°C led to spoilage of the meat within 2 d, in all gaseous environments, and listeria levels increased up to 100-fold. Differences in the behaviour of L. monocytogenes on poultry and red meats are discussed.     

The survival of Listeria monocytogenes in cottage cheese

Because of the difficulty of ensuring that cottage cheese is produced in conditions that prevent contamination with Listeria monocytogenes , the ability of this bacterium to survive in cottage cheese from three sources was investigated (a) during shelf-life at chill temperature and (b) in conditions of temperature abuse. Three batches of creamed cottage cheese, from three sources, received within 24 h of production, were inoculated with L. monocytogenes strain F6861 and stored at 4, 8 or 12°C for 14 d. The three batches differed in their initial pH, titratable acidity and content of lactic acid and of lactic acid bacteria. No increase in numbers of L. monocytogenes occurred in the cottage cheeses during storage in these conditions. The numbers of listeria decreased; the rate of decrease differed in products from the three sources and was least in the product with the highest pH and lowest content of lactic acid. Acid formation by lactic acid bacteria during storage of the products probably contributed to the inhibition of listeria.     

Inhibition of Listeria innocua in cheddar cheese by addition of nisin Z in liposomes or by in situ production in mixed culture

The effect of addition of purified nisin Z in liposomes to cheese milk and of in situ production of nisin Z by Lactococcus lactis subsp. lactis biovar diacetylactis UL719 in the mixed starter on the inhibition of Listeria innocua in cheddar cheese was evaluated during 6 months of ripening. A cheese mixed starter culture containing Lactococcus lactis subsp. lactis biovar diacetylactis UL719 was selected for high-level nisin Z and acid production. Experimental cheddar cheeses were produced on a pilot scale, using the selected starter culture, from milk with added L. innocua (10(5) to 10(6) CFU/ml). Liposomes with purified nisin Z were prepared from proliposome H and added to cheese milk prior to renneting to give a final concentration of 300 IU/g of cheese. The nisin Z-producing strain and nisin Z-containing liposomes did not significantly affect cheese production and gross chemical composition of the cheeses. Immediately after cheese production, 3- and 1.5-log-unit reductions in viable counts of L. innocua were obtained in cheeses with encapsulated nisin and the nisinogenic starter, respectively. After 6 months, cheeses made with encapsulated nisin contained less than 10 CFU of L. innocua per g and 90% of the initial nisin activity, compared with 10(4) CFU/g and only 12% of initial activity in cheeses made with the nisinogenic starter. This study showed that encapsulation of nisin Z in liposomes can provide a powerful tool to improve nisin stability and inhibitory action in the cheese matrix while protecting the cheese starter from the detrimental action of nisin during cheese production.     

A comparison of immunomagnetic and surface adhesion immunofluorescent techniques for the rapid detection of Listeria monocytogenes and Listeria innocua in meat

an immunomagnetic immunofluorescent method was investigated for the rapid detection of Listeria monocytogenes and Listeria innouca . This technique involved enrichment of the suspect sample at 30°C overnight. Listeria monocytogenes cells were isolated from the enriched sample using immunomagnetic separation and Listeria were subsequently visualized using an immunofluorescent microscopy technique. This technique was used in the detection of Listeria cells from pure culture, inoculated beef mince samples and naturally contaminated retail beef mince samples. A detection level of approximately 1×10³ cfu ml⁻¹ was achieved. When compared with traditional detection methods no false negatives or positives were recorded for L. monocytogenes or L. innocua . The immunomagnetic immunofluorescent technique had a detection level similar to a previously described surface adhesion immunofluorescent technique. Isolation of the Listeria cells by surface adhesion involved dipping a membrane attached to a microscope slide into the enriched sample for 10 min. This was quicker and simpler to perform than the immunomagnetic separation technique which took 2 h to carry out.     

The lethal effect of carrot on Listeria species

When shredded or sliced carrots were inoculated with Listeria monocytogenes the number of viable listerias decreased rapidly. On carrot slices stored at 8°C there was a decrease after 3 d followed by an increase, after 7 d, to numbers similar to those present initially. The numbers of spoilage micro-organisms increased throughout storage at 8°C. Carrots macerated in a Stomacher Lab Blender also showed an antilisterial activity which resulted in a decrease in number of viable bacteria and in sublethal damage. The effect was shown by five carrot cultivars and acted on nine strains of L. monocytogenes and single strains of L. innocua, L. ivanovii, L. seeligeri, L. welshimeri . This antilisterial effect was heat-labile, was inactivated after a few hours at 4°C or at 30°C and was active over the pH range 5.8 to 7.0. Maceration of carrots in an Atomix blender for 1 min or in liquid nitrogen destroyed the antilisterial activity.     

Inhibition of Listeria monocytogenes in cottage cheese manufactured with a lacticin 3147-producing starter culture

The efficacy of using a lacticin 3147-producing starter as a protective culture to improve the safety of cottage cheese was investigated. This involved the manufacture of cottage cheese using Lactococcus lactis DPC4268 (control) and L. lactis DPC4275, a bacteriocin-producing transconjugant strain derived from DPC4268. A number of Listeria monocytogenes strains, including a number of industrial isolates, were assayed for their sensitivity to lacticin 3147. These strains varied considerably with respect to their sensitivity to the bacteriocin. One of the more tolerant strains, Scott A, was used in the cottage cheese study; the cheese was subsequently inoculated with approximately 10(4) L. monocytogenes Scott A g-1. The bacteriocin concentration in the curd was measured at 2560 AU ml-1, and bacteriocin activity could be detected throughout the 1 week storage period. In cottage cheese samples held at 4 degrees C, there was at least a 99.9% reduction in the numbers of L. monocytogenes Scott A in the bacteriocin-containing cheese within 5 d, whereas in the control cheeses, numbers remained essentially unchanged. At higher storage temperatures, the kill rate was more rapid. These results demonstrate the effectiveness of lacticin 3147 as an inhibitor of L. monocytogenes in a food system where post-manufacture contamination by this organism could be problematic.     

Heat resistance of Listeria: strain differences and effects of meat type and curing salts

The heat resistances of 27 strains of Listeria monocytogenes and two strains of L. innocua were compared in broth heated at 57°C. No strain was exceptionally resistant. The heat resistance of a representative isolate of L. monocytogenes was compared in fresh and cured beef and chicken, and an equation was derived to predict the time necessary to achieve a '7D' inactivation at temperatures between 50 and 70°C.     

Antibacterial activities of nisin Z encapsulated in liposomes or produced in situ by mixed culture during cheddar cheese ripening

This study investigated both the activity of nisin Z, either encapsulated in liposomes or produced in situ by a mixed starter, against Listeria innocua, Lactococcus spp., and Lactobacillus casei subsp. casei and the distribution of nisin Z in a Cheddar cheese matrix. Nisin Z molecules were visualized using gold-labeled anti-nisin Z monoclonal antibodies and transmission electron microscopy (immune-TEM). Experimental Cheddar cheeses were made using a nisinogenic mixed starter culture, containing Lactococcus lactis subsp. lactis biovar diacetylactis UL 719 as the nisin producer and two nisin-tolerant lactococcal strains and L. casei subsp. casei as secondary flora, and ripened at 7 degrees C for 6 months. In some trials, L. innocua was added to cheese milk at 10(5) to 10(6) CFU/ml. In 6-month-old cheeses, 90% of the initial activity of encapsulated nisin (280 +/- 14 IU/g) was recovered, in contrast to only 12% for initial nisin activity produced in situ by the nisinogenic starter (300 +/- 15 IU/g). During ripening, immune-TEM observations showed that encapsulated nisin was located mainly at the fat/casein interface and/or embedded in whey pockets while nisin produced by biovar diacetylactis UL 719 was uniformly distributed in the fresh cheese matrix but concentrated in the fat area as the cheeses aged. Cell membrane in lactococci appeared to be the main nisin target, while in L. casei subsp. casei and L. innocua, nisin was more commonly observed in the cytoplasm. Cell wall disruption and digestion and lysis vesicle formation were common observations among strains exposed to nisin. Immune-TEM observations suggest several modes of action for nisin Z, which may be genus and/or species specific and may include intracellular target-specific activity. It was concluded that nisin-containing liposomes can provide a powerful tool to improve nisin stability and availability in the cheese matrix.     

The impact of nisin on sensitive and resistant mutants of Listeria monocytogenes in cottage cheese

Aims: Listeria monocytogenesΔgadD1 and ΔlisK mutants display enhanced and reduced sensitivity, respectively, to the food preservative nisin in laboratory media. However, the behaviour of these strains in a nisin‐containing food has not been assessed. Here we use cottage cheese as a model food to address this issue. Materials and Results: Antibiotic‐resistant forms of the wild‐type and mutant strains were employed to investigate the behaviour of multiple strains in a single food sample, thereby eliminating the problem of intersample variation. Using this approach, it was established that percentage survival of the ΔlisK mutant was greater than the parent strain in the absence of nisin and that this relative difference became even more dramatic in cottage cheese supplemented with nisin. The numbers of the ΔgadD1 mutant decreased more rapidly than the parent in cottage cheese without nisin, but surprisingly this trend was reversed in nisin‐supplemented cheese. Upon the addition of 10 mmol l^?1 monosodium glutamate, a substrate for the glutamate decarboxylase (GAD) system, the wild‐type LO28 strain regained its relative advantage over ΔgadD1. Conclusions: Care needs to be taken when predicting the behaviour of mutants of L. monocytogenes with altered resistance to nisin in food as experiments in laboratory media are not always a good indicator of how the strains will behave in such food environments. Significance and impact of the Study: This study further emphasizes the importance of utilizing food matrices to confirm observations made using laboratory media.     

Behaviour of Listeria monocytogenes during the traditional manufacture of water-buffalo Mozzarella cheese

F. VILLANI, O. PEPE, G. MAURIELLO, G. MOSCHETTI, L. SANNINO AND S. COPPOLA. 1996. The behaviour of a four-strains mixture of Listeria monocytogenes (strains Scott A, V7, OH and Cal) during the traditional manufacture of water-buffalo Mozzarella cheese was investigated at two levels of inoculation: ca 10⁵and 10³cfu ml^-1of vat milk. No significant change in Listeria counts was observed during the curd ripening (4.0–4.5 h), at the end of which the pH ranged between 4.83 and 4.91. A decrease of about 2 log was observed after stretching of the curd in hot water (95°C), followed by complete elimination of Listeria after 48 and 24 h of storage of the final cheese in the conditioning liquid (skim water resulting from the stretching, pH ca 4.0) with initial high and low contamination of the cheese milk respectively. Results also indicated that a 1.7 log reduction of L. monocytogenes could be achieved during the preparation of the natural whey culture utilized as starter in cheesemaking.