内生真菌Preussia sp.液体发酵生产抗肿瘤活性产物Spiropreussione A 的研究

螺光黑壳菌酮A(Spiropreussione A,SP-A)是编号为AS-5的光黑壳属内生真菌Preussia sp.的代谢产物。体外实验表明SP-A对人卵巢癌细胞A2780和人肝癌细胞BEL-7404的半数抑制浓度(IC50)分别为2.4和3.0μmol/L。以SP-A的含量为主要指标,结合AS-5的生物量,通过单因素实验和正交实验,优化确定了适合SP-A积累的AS-5液体发酵培养基和培养条件。研究结果表明:AS-5发酵生产SP-A的最优培养基为葡萄糖2%,麦麸3%,磷酸二氢钾0.3%,硫酸镁0.15%,pH7.0;该菌株最佳摇瓶发酵条件为250mL摇瓶装125mL培养基,接种6片直径9mm的PDA菌片,培养温度25℃,发酵周期16d。在此条件下发酵,SP-A的含量可以达到(25.02±1.02)mg/瓶,比优化前的含量[(17.08±3.24)mg/瓶]提高了46.5%。     

Laccase production in solid‐state and submerged fermentation by Pleurotus ostreatus

A solid‐state fermentation (SSF) system for production of an industrially important enzyme laccase by Pleurotus ostreatus was developed by using potato dextrose yeast extract medium and polyurethane foam as a supporting material. The maximum laccase production in the SSF system was as high as 3×10⁵ U/L. Addition of inducers, such as copper and ferulic acid, further enhanced the laccase production in SSF. Moreover, the time required for the maximum laccase production was reduced to 6 days compared to 10 days reported earlier. The improvement achieved by the SSF system was investigated by comparing it to a submerged fermentation system (SmF), both experimentally and by using a standard theoretical model along with a parameter sensitivity analysis. Laccase production in SSF was found to be twice of that in SmF. One of the main reasons for higher laccase production in SSF compared to SmF was possibly due to the presence of higher proteolytic activity in SmF. Strong proteolytic activity in SmF presumably caused subsequent laccase degradation, which lowered the ultimate laccase production in SmF compared to SSF.     

Utilization of tannery solid waste for protease production by Synergistes sp. in solid‐state fermentation and partial protease characterization

Synergistes sp. DQ560074 produced a protease in submerged fermentation (SmF) at 400–420 U/mL and in solid‐state fermentation (SSF) at 745–755 U/g. The protease, which belongs to the aspartic protease class, was active over a wide range of pH (5–7) and at high temperatures (25–45°C). The protease is stable and active in various polar protic solvents (50% v/v) like ethanol, isopropanol, n–butanol, in polar aprotic solvents (50% v/v) like acetonitrile, and in non‐polar solvents (50% v/v) such as ethylacetate and toluene, but not in hydrophilic organic solvents (methyl alcohol and acetone). As far as we know, this is the first contribution to the production of a mesophilic protease with solvent stability in SSF using a proteinaceous solid waste.     

美丽镰刀菌培养液对东北红豆杉悬浮细胞防御反应及紫杉醇合成的影响

美丽镰刀(Fusarium mairei)是一分离自南方红豆杉(Taxus chinensis var.mairei)的产紫杉醇内生真菌,用B5培养基培养6 d,去菌尘幺后制得美丽镰刀菌培养液,并从中提取其胞外多糖.研究了4%(V/V)美丽镰刀菌培养液及4%(W/V)胞外多糖两种处理,对东北红豆杉(T.cuspidata)悬浮细胞防御反应及紫杉醇合成的影响.结果表明:两种处理均能诱导东北红豆杉细胞的防御反应.但美丽镰刀菌培养液的影响明显大于胞外多特(P<0.05).另外,两种处理均可促进东北红豆杉细胞紫杉醇的合成与释放.美丽镰刀菌培养液处理得到的紫杉醇与其释放率分别是对照的2.5倍8.8倍,而胞外多糖处理得到的紫杉醇与其释放率则分别是对照的1.5倍与3倍.     

Optimization of cellulase production by a brown rot fungus Fomitopsis sp. RCK2010 under solid state fermentation

Culture conditions for enhanced cellulase production from a newly isolated brown rot fungus, Fomitopsis sp. RCK2010 were optimized under solid state fermentation. An initial pH of 5.5 and moisture ratio of 1:3.5 (solid:liquid) were found to be optimal for maximum enzyme production. Of the different carbon sources tested wheat bran gave the maximum production of CMCase (71.526 IU/g), FPase (3.268 IU/g), and β-glucosidase (50.696 IU/g). Among the nitrogen sources, urea caused maximum production of CMCase (81.832 IU/g), where as casein and soyabean meal gave the highest FPase (4.682 IU/g) and β-glucosidase (69.083 IU/g) production, respectively. Among amino acids tested glutamic acid gave the highest production for CMCase (84.127 IU/g); however 4-hydroxy-l-proline stimulated maximum FPase production (6.762 IU/g). Saccharification of pretreated rice straw and wheat straw by crude enzyme extract from Fomitopsis sp. RCK2010 resulted in release of 157.160 and 214.044 mg/g of reducing sugar, respectively.     

Aspergillus niger var. taxi, a new species variant of taxol-producing fungus isolated from Taxus cuspidata in China

Aims:  To characterize and identify a new taxol-producing fungal strain HD86-9 isolated from Taxus cuspidata in China.
Methods and Results:  Taxol extracted from strain HD86-9 was identified by HPLC and MS analyses. Strain HD86-9 was cultured and its morphology and phenotypes were described. HD86-9 displayed morphology most similar to that of Aspergillus niger but presented differences in the shape and size of the conidia. The growth evaluation showed that the maximal tolerable temperature of the new strain was 43°C, higher than that of the model Aspergillus niger . The 18S rDNA and the internal transcribed spacer region including the 5·8S rDNA of HD86-9 were amplified by PCR; molecular analysis of these sequences revealed their high similarity of 98% to those of Aspergillus niger .
Conclusions:  The morphology and molecular analysis identified HD86-9 as a new variant of taxol-producing endophytic fungi, and it was named Aspergillus niger var. taxi D.P. Zhou, K. Zhao and W.X. Ping, var. nov.
Significance and Impact of the Study:  As the first report of a taxol-producing variant of Aspergillus niger species, this study offers important information and a new resource for the production of an important anticancer drug by endofungus fermentation.     

南方红豆杉内生真菌的抗肿瘤产物震颤毒素的研究

从红豆杉内生真菌青霉菌Penicillum sp. H⑥.1发酵产物中自然析出一种化合物,经图谱检测和文献比对,鉴定为震颤毒素Penitrem A。四唑盐（MTT）比色法研究表明Penitrem A对恶性黑色素瘤细胞A375有一定的抑制作用,且抑制作用随浓度的增大而增强,IC₅₀为27.24μg/mL。本研究是首次从红豆杉内生真菌发酵产物中分离得到震颤毒素Penitrem A,为抗肿瘤药物开发提供了理论参考。     

A practical method for overcoming the dormancy of <Emphasis Type="Italic">Taxus baccata</Emphasis> isolated embryos under <Emphasis Type="Italic">in vitro</Emphasis> conditions

Conditions for obtaining an efficient mass propagation procedure to overcome isolated Taxus baccata embryo dormancy were investigated. The protocol herein described was efficient for overcoming the dormancy of T. baccata isolated embryos under in vitro conditions, enabling the conservation and propagation of this species. T. baccata seeds were unable to germinate directly after collection under in vitro conditions. Very good sterility and germination was achieved by soaking seeds in distilled water at a low temperature (+4°C) at least for 48 h instead of leaching them for 7 d under running water, followed by maintaining isolated embryos on the Murashige and Skoog medium (MS) supplemented with 5 g l⁻¹ activated charcoal. That treatment allowed one to shorten the time of the experiment and gave almost 100% sterility. The best germination was observed in darkness, but to obtain worthy seedlings, it was necessary to place cultures in a 16-h photoperiod after a 2-wk incubation. There was no significant difference in germination between seeds collected from different populations of Southern Poland.     

Effect of the plant peptide regulator, phytosulfokine-alpha, on the growth and Taxol production from Taxus sp. suspension cultures

Phytosulfokine-alpha (PSK-alpha) is a small plant peptide (5 amino acids) that displays characteristics typically associated with animal peptide hormones. PSK-alpha was originally isolated based on its mitogenic activity with plant cultures; it has been reported to increase production of tropane alkaloids from Atropa belladonna, although its general influence on secondary metabolite production is unknown. The studies reported in this article were initiated to evaluate the effects of PSK-alpha supplementation on production of Taxol (paclitaxel) from plant cell cultures of Taxus sp. particularly when methyl jasmonate (MeJA) is added as an elicitor of secondary metabolism. The response to PSK-alpha supplementation was cell line dependent. Taxus cuspidata P93AF showed no statistically significant response to PSK-alpha supplementation while Taxus canadensis C93AD and T. cuspidata PO93X displayed a concentration-dependent response (up to 100 nM PSK-alpha added in first 24 h of culture) with a decrease in initial growth rate, an increase in cell density (dry weight/fresh weight), and increased Taxol production. More remarkably with T. canadensis (C93AD), a very strong synergistic response of PSK-alpha (100 nM) and methyl jasmonate (MeJA, 100 microM) elicitation was observed, resulting in Taxol level of 35.3 +/- 2.1 mg/L or 1.83 +/- 0.02 mg Taxol/g dry cell weight achieved at day 21, a level of approximately 10-fold higher than for either treatment by itself. Although the level of Taxol production achieved is not remarkable, this synergistic treatment was able to partially revive taxane production in cultures that have lost productivity due to extended time (over 10 years) in continuous subculture.     

Absolute configuration of fusarone, a new azaphilone from the endophytic fungus Fusarium sp. isolated from Melia azedarach, and of related azaphilones

A new azaphilone derivative, named fusarone (1), has been isolated from the ethyl acetate soluble extract of the fermentation broth of an endophytic fungus, Fusarium sp. LN-12, isolated from the leaves of Melia azedarach Linn. The structure of the new compound was established on the basis of extensive spectroscopic analysis, including 1D-NMR and 2D-NMR ((1) H-(1)H COSY, TOCSY, HSQC, HMBC, and NOESY) experiments. The absolute configurations of fusarone (1) and of a second related azaphilone were determined by means of electronic circular dichroism spectroscopy and optical rotation calculations.     

浙贝母内生真菌Nectria sp. JZ6分泌抑菌活性代谢产物的初步研究

Nectria sp.JZ6是从浙贝母新鲜鳞茎中首次分离到的一株内生真菌,其发酵液具有抑菌活性。为建立该真菌稳定分泌抑菌活性成分的发酵体系,本研究利用单因素实验和正交实验确定了发酵培养基的配方并初步优化了发酵条件。结果表明,将活化后的菌种接种于改良查氏培养基(8%葡萄糖,0.5%蛋白胨,0.05%KCl,0.1%K2HPO4,0.15%MgSO4,pH6.5)中,28℃、150r/min振荡培养6d后获得的发酵液抑菌活性比优化前提高了26%。该发酵液经100℃水浴30min不失活,在pH1-5时抑菌活性相对稳定,其后逐渐减弱,并在pH9.0及以上时丧失。Nectriasp.JZ6发酵液的乙酸乙酯浸膏抑菌活性最强,对金黄色葡萄球菌、藤黄八叠球菌、枯草芽孢杆菌、绿脓杆菌和大肠杆菌的最低抑菌浓度(MIC)分别为0.625、0.625、1.25、1.25和1.25mg/mL。     

Survival of anaerobic fungus Caecomyces sp. in various preservation methods: a comparative study

The present investigation was designed to observe the survival of the anaerobic fungus Caecomyces sp. in various routine preservation methods. Among all the treatments, cryopreservation of fungi at ?70°C with glycerol was found to be most effective for long-term maintenance (more than 90 days) of rumen fungi, followed by dimethyl sulfoxide (DMSO) and ethylene glycol (up to 60 days). In contrast, at ?196°C, DMSO showed maximum survival (more than 90 days), followed by glycerol (up to 90 days) and ethylene glycol (up to 30 days). At 39°C, maximum survival (up to 30 days) was observed with soft agar and wheat straw; at refrigeration temperature, preservation with Orpin's media containing straw showed maximum survival (up to 30 days).     

Structural elucidation of an exopolysaccharide from mycelial fermentation of a Tolypocladium sp. fungus isolated from wild Cordyceps sinensis

A novel polysaccharide designated EPS-1A with an average molecular weight around 40 kDa was fractionated and purified by anion-exchange and gel-filtration chromatography from the crude exopolysaccharide (EPS) isolated from fermentation broth of Cs-HK1, a Tolypocladium sp. fungus isolated from wild Cordyceps sinensis. The structural characteristics of EPS-1A were determined with various methods (e.g. GC, GC–MS, FT-IR, ¹H NMR and ¹³C NMR) and through acid hydrolysis, methylation, periodate-oxidation and Smith degradation. The results suggested that EPS-1A was composed of glucose, mannose and galactose at 15.2:3.6:1.0 M ratio. EPS-1A was a slightly branched polysaccharide and its backbone was composed of (1 → 6)-α-d-glucose residues (77%) and (1 → 6)-α-d-mannose residues (23%). Branching occurred at O-3 position of (1 → 6)-α-d-mannose residues of the backbone with (1 → 6)-α-d-mannose residues and (1 → 6)-α-d-glucose residues, and terminated with β-d-galactose residues.     

Production and optimization of process parameters for alkaline protease production by a newly isolated Bacillus sp. under solid state fermentation

Production of alkaline protease employing the laboratory isolate, Bacillus sp. under solid state fermentation (SSF) was optimized. The effect of wheat bran and lentil husk was examined. Wheat bran showed highest enzyme production. The appropriate incubation time, inoculum size, moisture level and buffer solution level were determined. Maximum yields of 429.041 and 168.640 U g⁻¹ were achieved by employing wheat bran and lentil husk as substrates in 0.1 M carbonate/bicarbonate buffer at pH 10 with 30 and 40% initial moisture level at 24 h. Inoculum size and buffer solution level were found to be 20 and 25% and 0.5:1 for wheat bran and lentil husk, respectively.     

Pilot production of Clonostachys rosea conidia in a solid‐state fermentor optimized using response surface methodology

The nonpathogenic, saprophytic fungus Clonostachys rosea is one of the most powerful fungal biological control agents (BCAs). However, the production of fungal BCAs is still a major constraint for their large‐scale use and commercialization. Here, we developed a novel solid‐fermentation reactor that is light transparent and ventilated both at the top and the bottom, and optimized C. rosea cultivation conditions in solid‐state fermentation using response surface methodology. The growth area of spores provided by the novel fermentor was two times that of the traditional one. A quadratic polynomial model was developed, which indicated the effects of variables on the conidia yield. The greatest spore production of 3.50 × 10¹⁰ spores/g‐dry‐matter was obtained after 11 days at the initial moisture content of 69.2% w/w, the medium thickness of 3.84 cm, and the porosity of 0.37%. The optimized spore yield was increased by one order of magnitude. The fermentation time was shortened from 15 to 11 days. With the novel solid‐fermentation reactor, increase in C. rosea spores production and decrease in fermentation time were achieved. Current data imply that both the novel solid‐fermentation reactor designed and the optimized fermentation conditions are suitable for industrial‐scale C. rosea spore production.     

Brefeldin A,a cytotoxin produced by Paecilomyces sp. and Aspergillus clavatus isolated from Taxus mairei and Torreya grandis

Paecilomyces sp. and Aspergillus clavatus, which were isolated from Taxus mairei and Torreya grandis from southeast China, produced toxic metabolites when grown in liquid culture. Nuclear magnetic resonance techniques, infrared spectrometry, electrospray ionization mass spectroscopy and X-ray analysis identified brefeldin A, a bioactive metabolite produced by a number of fungal species belonging to the genera Alternaria, Ascochyta, Penicillium, Curvularia, Cercospora and Phyllosticta. This is the first report of the isolation of the cytotoxin from Paecilomyces sp. and A. clavatus. The relevance of brefeldin A to the association between these fungi and their host plants is discussed.