Some factors affecting production of pectic enzymes by Aspergillus niger

The effects of varying cultural conditions were assessed for the production of pectic enzymes in a strain of Aspergillus niger, isolated from decaying orange fruit. Polygalacturonase and pectinmethylesterase were found to be inducible by polygalacturonic acid and pectin in the medium, respectively. Ammonium sulphate was the best nitrogen source for the production of both enzymes. There were variations in enzyme levels produced in culture filtrates with age of the culture, the highest levels being in 4-day-old cultures. The temperature and pH also had marked effects on the production of pectic enzymes with the best conditions being 40°C and pH 5, respectively. Surface culture technique gave appreciable enzyme yield, while agitation had an inhibitory effect on enzyme production.     

柚子皮黑曲霉的分离鉴定及产酶特性研究

对柚子皮上自然生长的黑曲霉进行分离鉴定,并探讨其产酶特性。以平板稀释法从柚子皮上分离出一株霉菌菌株,通过观察其形态特征和培养特征,对照《真菌鉴定手册》判定该菌株的种属;采用鉴定培养基法对其产酶特性进行分析。根据柚子皮的成分特性,以干柚子皮为主要原料,该菌为生产菌株,采用固态发酵法探究培养基的成分、柚子皮含量、培养基初始含水量及发酵时间4个因素对纤维素酶活力的影响。结果表明,该菌株为黑曲霉(Aspergillus nige),可产淀粉酶、蛋白酶、纤维素酶、果胶酶;固态发酵培养基中添加柚子皮12g,麸皮0.5 g和(NH_4)_2SO_40.5 g,培养基初始含水量保持在68.5 mL/100 g,培养时间控制在60 h左右时纤维素酶产量较高。     

过表达Na,K-ATPase基因增强了黑曲霉对硅灰石的风化能力

【目的】探究和证实黑曲霉钠钾ATP酶(NKA)在硅灰石风化过程中的作用。【方法】以野生型黑曲霉(WT)为原始菌株构建黑曲霉Na,K-ATPaseα1基因(NKAα1)高表达菌株oeNKA。通过测定不同时间点(0d、2d、4d、6d)oeNKA和WT生物量、培养液pH值和矿物风化释放的Ca~(2+)浓度,并用X-ray diffraction (XRD)对风化后的矿物残渣进行检测,比较oeNKA和WT菌株对硅灰石这种硅酸盐矿物的风化效果。【结果】oeNKA菌株的NKAα1基因相对表达量和酶活分别为WT菌株的103倍和1.76倍。在持续6d的培养过程中,oeNKA与WT的菌丝体生物量变化趋势相同,在培养第2天时WT显著高于oeNKA,随时间差异逐渐缩小并在第6天达到最低;培养液pH值变化趋势相同,分别下降至3.64和3.87;oeNKA风化硅灰石时所释放Ca~(2+)浓度(1011.36±47.78μg/g)约为WT (248.30±25.21μg/g)的4倍;XRD检测图谱显示菌株oeNKA对硅灰石风化作用更明显。【结论】NKAα1过表达菌株oeNKA对硅灰石的风化能力显著高于WT菌株,且黑曲霉的NKA与硅灰石的风化有密切关联。     

响应面法优化黑曲霉固定化条件及其对土壤中溴氰菊酯的降解特性研究

【目的】通过研究吸附包埋法固定黑曲霉(Aspergillus niger)的最佳制备工艺,初步探讨固定化黑曲霉对溴氰菊酯(deltamethrin, DM)及其中间产物3-苯氧基苯甲酸(3-phenoxybenzoic acid,3-PBA)的降解机制,并将其应用于农业种植中以评价固定化黑曲霉的实际应用效果。【方法】以生物炭、海藻酸钠为固定化载体,通过单因素和响应面试验对固定化黑曲霉(immobilized Aspergillusniger)的制备工艺进行优化。同时,利用高效液相色谱法分析DM和3-PBA的含量变化。【结果】海藻酸钠浓度、生物炭浓度和菌液接种量为DM去除率的显著影响因子,当三者分别为25.27、1.28和125.28 g/L时,是黑曲霉固定化的最佳制备条件;在施加固定化黑曲霉后,土壤中DM半衰期由7.6d缩短至5.2d,黑曲霉对3-PBA也具有降解作用,在21h达到最低浓度1.45mg/kg;修复后的土壤可显著提高番茄种子发芽率,株高、根长等6个生长指标较DM单独处理组也有不同程度的恢复;在经固定化黑曲霉修复28 d后,污染土壤根系酶活和微生物数量均得到不同程度改善。【...     

黑曲霉产木聚糖酶的分离纯化与鉴定研究

木聚糖酶的分离纯化是对其进行酶学研究和分子改良研究的基础。利用实验室选育的黑曲霉菌株Aspergillus niger SM24/a进行木聚糖酶发酵,粗酶液经过(NH_4)_2SO_4分级沉淀Bio-Gel P6除盐、UNO sphere Q阴离子交换和Enrich SEC70凝胶色谱层析四个步骤的分离纯化,成功获得了3种木聚糖酶蛋白定义为X-Ⅰ、X-Ⅱ和X-Ⅲ。随着纯化步骤的增加,各组分酶比活力得到显著提高,其数值分别为37.41、34.56和53.96 U/mg,纯化倍数分别为3.96、3.66和5.72。经质谱分析和蛋白氨基酸序列比对,初步认定X-Ⅰ属于糖基水解酶第十家族内切-β-1,4-木聚糖酶,X-Ⅱ和X-Ⅲ均属于糖基水解酶第十一家族木聚糖酶。     

Biodegradation of organochlorine pesticide, endosulfan, by a fungal soil isolate, Aspergillus niger

Endosulfan is a chlorinated pesticide widely used in India for the protection of cotton, tea, sugarcane and vegetables. The persistence of endosulfan in environment and toxic effects on biota necessitate its removal. The role of soil fungi in recycling organic matter prompted us to attempt biodegradation of endosulfan using fungi. This study aims at enrichment, isolation and screening of fungi capable of metabolizing endosulfan. In all, 16 fungal isolates were obtained by enrichment of soil samples that had seems exposed to endosulfan before. Isolates were screened by a gradient plate assay, and results were confirmed by broth assay. On the basis of tolerance to endosulfan, an isolate, identified as Aspergillus niger was selected for further studies. The culture could tolerate 400 mg ml⁻¹ of technical grade endosulfan. Complete disappearance of endosulfan was seen on 12 days of incubation. Evolution of carbon dioxide during endosulfan metabolism has indicated the complete mineralization of endosulfan. Change in pH of culture broth to acidic range supported the biological transformation. Thin layer chromography (TLC) analyses revealed the formation of various intermediates of endosulfan metabolism including endosulfan diol, endosulfan sulfate, and an unidentified metabolite. The toxic intermediate, endosulfan sulfate, was also metabolized, further resulting in complete mineralization of endosulfan. Direct desulfurization of endosulfan sulfate or a novel pathway could be the mechanism of endosulfan and endosulfan sulfate degradation in Aspergillus niger. The fungal strain isolated by us could prove valuable for bioremediation of endosulfan contaminated soils and waters.     

黑曲霉菌渣综合利用研究进展

黑曲霉菌渣是黑曲霉经过工业发酵所需产物之后的副产物,资源储量丰富。目前利用黑曲霉生产的制剂种类繁多,对菌渣综合利用的报道却相对较少。已有的研究表明黑曲霉菌渣不仅可作为饲料添加剂、有机肥料或土壤改良剂得到直接应用,也可用于精制,作为食品、药品和化妆品等行业的主要原材料,实现高附加值转化应用。还可作为生物吸附剂用于去除水体中的污染物等。本文结合目前国内外对黑曲霉菌渣在各领域研究及利用现状,综述了黑曲霉菌渣高附加值转化与利用的研究进展,可以为工业发酵废渣资源化利用提供理论参考。     

黑曲霉RAF106菌丝球形成的影响因素及对结晶紫的吸附作用

【背景】黑曲霉（Aspergillus niger）作为一种代表性丝状真菌已被广泛用于酶制剂、有机酸、抗生素等高价值代谢产物的工业生产、食品发酵、环境治理等行业,其代谢能力、发酵性能等与菌体形态密切相关。然而,黑曲霉对染料、重金属等的吸附能力与菌体形态的关系鲜有报道。【目的】探究黑曲霉菌丝球形成的影响因素及其对结晶紫的吸附作用。【方法】以从普洱茶分离的黑曲霉RAF106为研究对象,实时监测马铃薯葡萄糖培养液中黑曲霉菌丝球的形成过程;探究培养液的初始pH （4.0-10.0）、培养温度（25-45°C）、孢子接种量（5×10⁴-5×10⁶个/m L）、摇床转速（140-220 r/min）、碳源（葡萄糖、蔗糖、果糖、乳糖、醋酸钠）和氮源（硝酸钠、胰蛋白胨、酵母提取粉、氯化铵）对菌丝球形成的影响;以结晶紫为对象,研究不同菌体形态及菌丝球大小对黑曲霉吸附废水染料能力的影响。【结果】在黑曲霉RAF106中,孢子聚集、菌丝聚集均可形成菌丝球;菌丝球的大小与培养液初始p H、孢子接种量成反比,与摇床转速无关;当温度低于35°C时,菌丝球大小与温度成正比,...     

一种高效无选择标记的黑曲霉基因组编辑方法

黑曲霉(Aspergillus niger)是一种重要的工业生产菌株,被广泛地应用于生产酶制剂和有机酸,但仍需要进行基因组改造提高它的应用潜力。CRISPR/Cas9技术是一种被广泛采用的黑曲霉基因组编辑技术,但由于需要在基因组中整合选择标记或基因编辑效率还有待提高,影响了其在工业菌株改造中的应用。本研究建立了一种基于CRISPR/Cas9技术的高效无选择标记的基因编辑方法。首先,利用5S rRNA启动子启动sgRNA的表达,构建了一个含有AMA1(autonomously maintained in Aspergillus)复制起始片段的sgRNA和Cas9共表达质粒;同时通过敲除kusA基因构建非同源末端连接(non-homologous end joining pathway,NHEJ)修复缺陷的高效同源重组菌株;最后利用含有AMA1片段质粒的不稳定性,通过无抗平板传代丢失含有sgRNA和Cas9共表达质粒。利用该方法,在采用同源臂长度仅为20bp的无选择标记供体DNA进行基因编辑时,基因编辑效率可达到100%。该方法为黑曲霉基因功能的研究和细胞工厂的构建奠定了基础。     

Cloning, sequencing and heterologous expression of the monoamine oxidase gene from Aspergillus niger

The gene encoding the flavin-containing monoamine oxidase (MAO-N) of the filamentous fungus Aspergillus niger was cloned. MAO-N is the first nonvertebrate monoamine oxidase described to date. Three partial cDNA clones, isolated from an expression library, were used to identify and clone the structural gene (maoN) from an A. niger genomic DNA library. The maoN gene was sequenced, and analysis revealed an open reading frame that codes for a protein of 495 amino acids with a calculated molecular mass of 55.6 kDa. Sequencing of an internal proteolytic fragment of the purified enzyme confirmed the derived amino acid sequence. Analysis of the deduced amino acid sequence indicates that MAO-N is structurally related to the human monoamine oxidases MAO-A and MAO-B. In particular, the regions known to be involved in the binding of the FAD cofactor show a high degree of homology; however, the conserved cysteine residue to which the flavin cofactor is covalently bound in the mammalian forms is absent in the fungal enzyme. MAO-N has the C-terminal tripeptide Ala-Arg-Leu, which corresponds to the consensus targeting sequence found in many peroxisomal enzymes. The full-length cDNA for MAO-N was expressed in Escherichia coli from the T7 promoter of the expression vector pET3a, yielding a soluble and fully active enzyme form.     

Biosorption behavior of heavy metals in bioleaching process of MSWI fly ash by Aspergillus niger

In this study, it was considered that the biosorption of heavy metals by biomass might occur during the bioleaching of fly ash. This work is focused on the biosorption behavior of Al, Fe, Pb and Zn by Aspergillus niger during the bioleaching process. The fungal biomass was contacted with heavy metals solution which extracted from fly ash by using gluconic acid as leaching agent. The equilibrium time for biosorption was about 120 min. The biosorption experiment data at initial pH 6.5 was used to fit the biosorption kinetics and isotherm models. The results indicated that the biosorption of Al, Fe and Zn by A. niger biomass were well described by the pseudo-first order kinetic model. The pseudo-second order kinetic model was more suitable for that of Pb. The Langmuir isotherm model could well describe the biosorption of Fe, Pb and Zn while the Freundlich model could well describe the biosorption of Al. Furthermore, the biosorption of metal ions decreased evidently in the presence of fly ash as compared to that in the absence of fly ash. This research showed that although the biomass sorption occurred during the bioleaching process, it did not inhibit the removal of Al, Fe, Pb and Zn evidently from fly ash.     

Citric acid production and morphology of Aspergillus niger as functions of the mixing intensity in a stirred tank and a tubular loop bioreactor

The relationship between Aspergillus niger morphology and citric acid production was investigated in two reactor systems with different configurations, a tubular loop and a stirred tank bioreactor, with operating volumes of 6 and 8 dm³, respectively. Morphology was quantified by image analysis. In each system, morphology, characterized by the parameter P (mean convex perimeter of clumps), and citric acid production, were agitation-dependent and closely linked. Increased agitation caused a reduction of clump sizes and results when both reactors demonstrate that the parameter P should not exceed a threshold value in order to achieve increased productivities. The results obtained from the two reactors were in agreement, both qualitatively and quantitatively. Reducing the fundamentally different mixing conditions of the two bioreactors to the order of the dimensionless mixing parameter relative mixing time (τ_m), results showed that the loop simulated the stirred tank. Also, relationships valid for one system accurately described the results obtained from the other system, demonstrating the validity of the relationship between morphology and productivity for the particular fermentation, regardless of the reactor type. Previous attempts to evaluate the use of loop configurations as scale-up tools and their performance as bioreactors, neglected the morphology of the producer micro-organisms. This study demonstrated the close link between morphology and productivity for citric acid production by A. niger, and identified a morphology parameter that was used successfully to characterize the process performance.     

新一代糖化酶高产菌株的选育及其工业应用

【目的】建立对糖化酶生产菌种黑曲霉随机突变文库进行筛选的方法,以获得糖化酶酶活提高的突变菌株。【方法】以一株可产糖化酶的黑曲霉菌株Aspergillus niger X1为出发菌株,经硫酸二乙酯诱变获得突变文库,采用葡萄糖的结构类似物——2-脱氧葡萄糖进行筛选,并在筛选过程中逐渐提高2-脱氧葡萄糖浓度,定向选育具有2-脱氧葡萄糖抗性、高产糖化酶的突变株。【结果】获得的高产突变菌株DG36摇瓶发酵糖化酶产量比出发菌株A.niger X1提高22.2%–33.8%,经工业水平50 m~3罐发酵测试,突变株DG36发酵128 h糖化酶活可达49094 U/m L,在相同发酵时间内,其酶活较出发菌株A.niger X1提高32.8%,发酵时间缩短16.9%。【结论】本研究开发了一种以2-脱氧葡萄糖为抗性标记选育高产糖化酶突变株的方法,所得突变株DG36遗传性状稳定,与出发菌相比具有菌丝粗壮、产酶期提前、糖化酶活高、发酵时间短、有利于发酵后处理的优点。     

Enhancement glucose oxidase production by solid-state fermentation of Aspergillus niger on polyurethane foams using mussel processing wastewaters

In the present work, studies of glucose oxidase (GOD) production in solid-state fermentation on polyurethane foams, using mussel processing wastewaters (MPW) as culture media, were carried out. Initially, the results generated in this experimental modality were compared with those that were obtained in conventional submerged fermentation. Later on, cultures were tested in solid state with fed-batch performance, defining suitable conditions of operation. These conditions were finally corroborated in experiments with a bioreactor of own design, in which GOD production was improved 13 times regarding to the initial cultures.     

高温高压条件下黑曲霉孢子的失活参数计算

高温高压灭菌是黑曲霉孢子灭活的主要方式。通过研究黑曲霉孢子在高温高压过程中的死亡率,计算黑曲霉孢子的比热死速率常数和活化能。结果表明,黑曲霉孢子在97、115、121 ℃时的比热死速率常数分别为0.028 39、0.041 59、0.065 92/min,热死的活化能为38 324.479 4 J/mol。为利用高温高压灭活大量曲霉孢子提供了理论基础。     

黑曲霉菌剂不同处理对西瓜根际细菌群落及土壤理化性质的影响

【背景】针对我国设施栽培西瓜土传病害发生严重、土壤理化性质劣变等问题,探究微生物菌剂对西瓜根际土壤微生物群落调控及土壤营养改良的作用。【目的】研究黑曲霉菌剂不同处理方式对设施栽培西瓜根际细菌多样性、群落结构及土壤理化性质的影响。【方法】通过高通量测序分析黑曲霉菌剂不同处理对西瓜根际土壤细菌多样性和群落结构的影响;采用分析化学方法测定西瓜根际土壤理化性质并解析驱动西瓜根际细菌群落动态变化的主要理化因素。【结果】黑曲霉菌剂(Y)、氨基寡糖素水剂(A)及黑曲霉菌剂与氨基寡糖素水剂配施(YA)处理,细菌α多样性指数如Chao1、Ace和Shannon等较对照均有所增加;不同处理西瓜根际优势细菌在门水平包括变形菌门(Proteobacteria)、放线菌门(Actinobacteriota)、绿弯菌门(Chloroflexi)、酸杆菌门(Acidobacteriota)等,其中Proteobacteria相对丰度最高,依次为A (28.26%)>Y (26.74%)>YA (22.61%);黑曲霉菌剂处理西瓜根际土壤芽单胞菌科(Gemmatimonadaceae)和类诺卡氏菌科(Nocardioidaceae)相对丰度较对照明显提高到4.06%和2.43%,氨基寡糖素水剂处理中根际土壤假单胞菌属(Pseudomonas)丰度显著提高(P<0.05),不同处理组微枝形杆菌属(Microvirga)相对丰度较对照均有所提高;黑曲霉菌剂单独或与氨基寡糖素水剂配施处理,西瓜根际土壤全氮、全磷及速效磷含量明显提高;冗余分析(redundancy analysis, RDA)表明,土壤pH、全氮、速效磷、速效钾与西瓜根际细菌群落结构具有显著相关性(P<0.05);Spearman相关性分析表明,根际假单胞菌科相对丰度与土壤全氮、全磷、速效磷、速效钾呈显著或极显著正相关。【结论】黑曲霉菌剂在设施栽培西瓜种植中单独或与氨基寡糖素水剂配施处理,具有提高西瓜根际土壤细菌多样性、增加有益菌群相对丰度、改良土壤理化性质从而提高土壤肥力的作用,该结果为黑曲霉菌剂产品开发及在设施栽培西瓜种植中合理应用提供了科学依据。     

The isolation of Ant1, a transposable element from Aspergillus niger

A transposable element has been isolated from the industrially important fungus Aspergillus niger (strain N402). The element was identified as an insertion sequence within the coding region of the nitrate reductase gene. It had inserted at a TA site and appeared to have duplicated the target site upon insertion. The isolated element was found to be 4798 by in length and contained 37-bp inverted, imperfect, terminal repeats (ITRs). The sequence of the central region of the element revealed an open reading frame (designated ORF1) which showed similarity, at the amino acid level, to the transposase of the Tc1/mariner class of DNA transposons. Another sequence within the central region of the element showed similarity to the 3 coding and downstream untranslated region of the amyA gene of A. niger. Sequence homology and structural features indicate that this element, which has been named Ant1 (A. niger transposon 1), is related to the Tc1/mariner group of DNA transposons. Ant1 is apparently present as a single copy in strain N402 of A. niger.     

米曲霉异源蛋白表达系统研究进展及展望

米曲霉作为一种重要的工业微生物,在异源蛋白表达方面已有广泛应用,受限于被表达蛋白的修饰及分泌过程,目前实际生产使用的基因供体主要局限于其他真菌,尤其是丝状真菌。当外源基因来源于植物、昆虫和哺乳动物时,米曲霉所生产的异源蛋白产量及生物活性往往不尽如人意。本文综述了米曲霉作为宿主表达异源蛋白的研究进展,包括其现有的遗传操作手段及异源表达方面的应用及探索,重点介绍了应用过程中面临的挑战和解决策略,另外,对米曲霉表达异源蛋白的应用前景及发展方向进行了展望。     

米曲霉（Aspergillus oryzae）果胶酸内切水解酶（PGA）在原核系统中重组表达

果胶酶具有广阔的商业用途,在食品工业上主要用于果汁和酒类的澄清、提高植物油的提取率、提高水果的硬度和植物纤维脱胶。米曲霉（Aspergillus oryzae）一直用于传统发酵食品的生产,自然条件下其果胶酶的产量较低。文献报道的果胶酶的重组表达成功的例子较少,且活性较低。通过RT-PCR 的方法,获得不含信号肽的果胶酸内切水解酶A(polygalacturonase A, PGA) 的cDNA,PGA cDNA 连入pET-28a (+)载体, 构建 pET-28a (+)-pga 质粒。pET-28a (+)-pga 转化Turner (DE3) placⅠ细胞,得到转化子pET-28a (+)-pga-Turner (DE3) placⅠ,首次实现了米曲霉PGA在大肠杆菌系统中过表达,进一步对PGA在大肠杆菌系统中表达的条件进行了研究。在37℃、220 r/min条件培养pET-28a (+)-pga-Turner (DE3) placⅠ细胞,OD₆₀₀至 0.8左右时,用500μmol/L isopropyl β-D-thiogalactogalactopyranoside (IPTG)进行诱导表达,在15℃和170r/min条件下继续培养24 h,表达效果最好,相对于每毫升培养基而言,产酶可达到70u/mL,是米曲霉自然条件产酶量的87.5倍,远优于文献报道的重组表达的PGA酶活     

米曲霉（Aspergillus oryzae）果胶酸内切水解酶（PGA）在原核系统中重组表达

果胶酶具有广阔的商业用途,在食品工业上主要用于果汁和酒类的澄清、提高植物油的提取率、提高水果的硬度和植物纤维脱胶。米曲霉（Aspergillus oryzae）一直用于传统发酵食品的生产,自然条件下其果胶酶的产量较低。文献报道的果胶酶的重组表达成功的例子较少,且活性较低。通过RT-PCR 的方法,获得不含信号肽的果胶酸内切水解酶A(polygalacturonase A, PGA) 的cDNA,PGA cDNA 连入pET-28a (+)载体, 构建 pET-28a (+)-pga 质粒。pET-28a (+)-pga 转化Turner (DE3) placⅠ细胞,得到转化子pET-28a (+)-pga-Turner (DE3) placⅠ,首次实现了米曲霉PGA在大肠杆菌系统中过表达,进一步对PGA在大肠杆菌系统中表达的条件进行了研究。在37℃、220 r/min条件培养pET-28a (+)-pga-Turner (DE3) placⅠ细胞,OD₆₀₀至 0.8左右时,用500μmol/L isopropyl β-D-thiogalactogalactopyranoside (IPTG)进行诱导表达,在15℃和170r/min条件下继续培养24 h,表达效果最好,相对于每毫升培养基而言,产酶可达到70u/mL,是米曲霉自然条件产酶量的87.5倍,远优于文献报道的重组表达的PGA酶活