Biogas production from boreal herbaceous grasses – Specific methane yield and methane yield per hectare

The objective of this study was to determine the specific methane yields of four grass species (cocksfoot, tall fescue, reed canary grass and timothy) cultivated under boreal conditions as well as how harvesting time and year of cultivation affects the specific methane yields per ha. The specific methane yields of all grasses and all harvests varied from 253 to 394 Nl CH₄/kg volatile solids (VS) added. The average specific methane yield of the 1st harvest of all grasses was higher than the 2nd harvests. In this study the methane and energy yields from different harvest years were ranged from 1200 to 3600 Nm³ CH₄/ha/a, corresponding from 12 to 36 MWh_CH4${\text{MWh}}_{{\text{CH}}_4}$/ha/a. The methane yield per hectare of the 1st harvest was always higher than that of the 2nd harvest per hectare because of the higher dry matter yield and specific methane yield. High biomass yield per hectare, good digestibility and regrowth ability after harvesting are important factors when choosing grass species for biogas production. If 30% of fallow and the second harvest of grassland were cultivated grasses and harvested for biogas production in Finland, the energy produced could be 4.9 TWh_CH4${\text{TWh}}_{{\text{CH}}_4}$.     

Methane production through anaerobic digestion of various energy crops grown in sustainable crop rotations

Biogas production is of major importance for the sustainable use of agrarian biomass as renewable energy source. Economic biogas production depends on high biogas yields. The project aimed at optimising anaerobic digestion of energy crops. The following aspects were investigated: suitability of different crop species and varieties, optimum time of harvesting, specific methane yield and methane yield per hectare. The experiments covered 7 maize, 2 winter wheat, 2 triticale varieties, 1 winter rye, and 2 sunflower varieties and 6 variants with permanent grassland. In the course of the vegetation period, biomass yield and biomass composition were measured. Anaerobic digestion was carried out in eudiometer batch digesters. The highest methane yields of 7500-10200 m(N)(3)ha(-1) were achieved from maize varieties with FAO numbers (value for the maturity of the maize) of 300 to 600 harvested at "wax ripeness". Methane yields of cereals ranged from 3200 to 4500 m(N)(3)ha(-1). Cereals should be harvested at "grain in the milk stage" to "grain in the dough stage". With sunflowers, methane yields between 2600 and 4550 m(N)(3)ha(-1) were achieved. There were distinct differences between the investigated sunflower varieties. Alpine grassland can yield 2700-3500 m(N)(3)CH(4)ha(-1). The methane energy value model (MEVM) was developed for the different energy crops. It estimates the specific methane yield from the nutrient composition of the energy crops. Energy crops for biogas production need to be grown in sustainable crop rotations. The paper outlines possibilities for optimising methane yield from versatile crop rotations that integrate the production of food, feed, raw materials and energy. These integrated crop rotations are highly efficient and can provide up to 320 million t COE which is 96% of the total energy demand of the road traffic of the EU-25 (the 25 Member States of the European Union).     

Miscanthus for biogas production: Influence of harvest date and ensiling on digestibility and methane hectare yield

The 8,000 biogas plants currently in operation in Germany are mainly fed with biomass from annual crops. However, feedstock from perennial crops such as miscanthus is expected to be more environmentally benign. If miscanthus is to be used in greater amounts as a substrate for anaerobic digestion, storage will become a relevant topic, as a continuous supply of biomass throughout the year is necessary. The objective of this study was to identify the miscanthus harvest time that best balances the simultaneous achievement of high silage quality, high digestibility and high methane hectare yields. For this purpose, biomass from four miscanthus genotypes with varying senescence characteristics was harvested on three different dates in autumn 2017. Part of the biomass was ensiled, and the methane yield of both ensiled and non‐ensiled biomass was analysed in a biogas batch test to assess the effect of ensiling on the methane hectare yield and digestion velocity. The ensiled biomass was found to have an up to 7% higher substrate‐specific methane yield and also showed a higher digestion velocity than the non‐ensiled biomass. The silage quality was best when miscanthus was harvested in mid‐October, due to highest lactic acid content (average: 3.0% of DM) and lowest pH (average: 4.39) compared to the harvests in mid‐September and beginning of October. Mass losses during ensiling (as high as 7.6% of fresh matter for the M. sinensis genotype Sin55) were compensated for by a higher substrate‐specific methane yield (up to 353 Nml CH₄ (g oDM)^?1) in ensiled miscanthus. This resulted in non‐significantly different methane hectare yields for non‐ensiled (average: 4.635 Nm³ CH₄/ha) and ensiled miscanthus biomass (4.803 Nm³ CH₄/ha). A comparison of the four genotypes suggests that Miscanthus x giganteus is the most suitable genotype for ensiling as it had the best silage quality.     

Effects of nitrogen and potassium combinations on yields and infestations of maize by Busseola fusca (Lepidoptera: Noctuidae) in the humid forest of Cameroon

Field trials were set up in the humid forest zone of Cameroon to investigate the effects of combinations of different rates of nitrogen (N) (0, 60, and 120 kg N ha(-1)) and potassium (K) (0, 80, and 160 kg K ha(-1)) applied to the soil on the incidence and damage of the noctuid stemborer Busseola fusca (Fuller), and on maize, Zea mays L., yield. Each N/K combination had an insecticide control to assess yield losses due to borers. In contrast to N, K had no effect on plant growth and borer incidence and damage. Across seasons and days after planting, total plant dry matter (DM) production increased with N level and it was 1.2-1.9 and 1.7-2.2 times, respectively, higher at 60 and 120 kg N ha(-1) compared with 0 kg N ha(-1). Total DM at harvest was strongly related to the N content of the plant at 63 d after planting. At the early growth stage, borer abundance and stem tunneling tended to increase with N level, but percentages of dead hearts did not vary with treatment. Maize grain yields increased linearly with N level, but grain yield losses decreased depending on season. Grain yield losses were 11-18.2 times higher with 0 kg N ha(-1) compared with 120 kg N ha(-1). The findings so far indicated that, soil application of N improves the nutritional status of maize, which consequently enhanced its tolerance to stemborer attacks. Improving soil fertility can thus be a very effective means of complementing integrated stemborer control in the humid forest zone of Cameroon.     

Species composition of semi-natural mesic grasslands as a factor influencing the methane yield of plant biomass (Central Europe)

Semi-natural lowland and mountain mesic meadows are grasslands rich in species, and their conservation status depends on treatments such as mowing or grazing livestock. In many countries, the condition of grasslands is deteriorating because of their inappropriate use or abandonment. This study aimed to determine the effects of the species composition of plant communities and functional plant groups on the methane yield from biomass harvested from mesic grasslands in the Sudetes Mountains. Biogas potential analysis was performed based on biomass samples collected from Poland and the Czech Republic. The biogas potential was determined in 40 day-long batch anaerobic digestion tests. The average methane yield obtained from the biomass was 246 ± 16 NL CH₄ kg^?1 VS, whereas the methane yield per hectare was 870 ± 203 m³ CH₄ ha^?1. Plant communities comprising different dominant species had no effect on the methane yield but affected the methane yield per hectare. Additionally, the species composition of grasslands with a higher percentage of forbs had lower biomass yield, resulting in lower methane yields per hectare. The continuity of the low-intensity management of mountain grassland, which can be provided by the utilization of their biomass for bioenergy production, sustains high biodiversity and ensures appropriate meadow conservation.     

Anaerobic batch co-digestion of sisal pulp and fish wastes

Co-digestion of various wastes has been shown to improve the digestibility of the materials and biogas yield. Batchwise digestion of sisal pulp and fish waste was studied both with the wastes separately and with mixtures in various proportions. While the highest methane yields from sisal pulp and fish waste alone were 0.32 and 0.39 m3 CH4/kg volatile solids (VS), respectively, at total solid (TS) of 5%, co-digestion with 33% of fish waste and 67% of sisal pulp representing 16.6% of TS gave a methane yield of 0.62 m3 CH4/kg VS added. This is an increase of 59-94% in the methane yield as compared to that obtained from the digestion of pure fractions at 5% TS.     

Methane from cattle waste: Effects of temperature, hydraulic retention time, and influent substrate concentration on kinetic parameter (k)

The effects of temperature (35 and 55 degrees C), influent volatile solids (VS) concentration (S(0) = 43, 64, 82, 100, and 128 kg VS/m(3)) and hydraulic retention time (HRT = 4, 5, 8, 10, 15, and 25 days) on methane (CH(4)) production from cattle waste were evaluated using 3-dm(3) laboratoryscale fermentors. The highest CH(4) production rate achieved was 6.11 m(3) CH(4) m(-3) fermentor day(-1) at 55 degrees C, four days HRT, and S(0) = 100 kg VS/m(3). Batch fermentations showed an ultimate CH(4) yield (B(0)) of 0.42 m(3) CH(4)/kg VS fed. The maximum loading rates for unstressed fermentation were 7 kg VS m(-3) day(-1) at 35 degrees C and 20 kg VS m(-3) day(-1) at 55 degrees C. The kinetic parameter (K, an increasing K indicates inhibition of fermentation) increased exponentially as S(0) increased, and was described by: K = 0.8 + 0.0016 e(0.06S(0) ). Temperature had no significant effect on K for S(0) between 40 and 100 kg VS/m(3). The above equation predicted published K values for cattle waste within a mean standard error of 7%.     

Nutrient Uptake by ‘Alamo’ Switchgrass Used as an Energy Crop

Field studies were conducted in 2000 and 2001 to examine yields and nutrient removal by Alamo switchgrass (Panicum virgatum L.) grown at eight locations within five states in the upper southeastern USA. Plots, which had been established for >5 years as part of a larger study, were cut either once (late fall) or twice (midsummer and late fall). Plots cut once received 50 kg N per hectare per year, while twice-cut plots received 100 kg N per hectare per year. Nutrient concentrations of and nutrient removal by harvested biomass were determined. Partitioning of nutrients into leaf and stem fractions was determined at the time of the midsummer harvest in 2000. Biomass production during 2000 and 2001 averaged 15.9 Mg/ha per year across all sites and was as high as 21.7 Mg/ha per year at one site. Two cuttings plus the additional 50 kg N per hectare did not generally increase seasonal yields; and, in one quite productive location, that management caused a yield reduction. Nitrogen removal with two cuts was much higher than with a single cut due largely to the higher N content in the midsummer harvest. Over the 2 years, twice as much N was removed with the two annual cuts as with one cut. Nitrogen removal exceeded the amounts of N applied in both managements, suggesting N was being supplied via mineralization or other processes. Phosphorus removal also increased significantly with the two-cut management. Seasonal K and Ca removals were more similar between the two managements. Nitrogen and P concentrations generally declined basipetally in tillers, with older leaves and internodes having lower concentrations of both nutrients. Potassium was more uniformly distributed than N throughout the tiller components (leaf and stem). Calcium was higher in older leaf blades. Levels of soil P, K, and Ca at most locations appeared not to be limiting biomass production and were adequate for long-term productivity.     

Effect of stocking rate on soil-atmosphere CH4 flux during spring freeze-thaw cycles in a northern desert steppe, China

BACKGROUND: Methane (CH(4)) uptake by steppe soils is affected by a range of specific factors and is a complex process. Increased stocking rate promotes steppe degradation, with unclear consequences for gas exchanges. To assess the effects of grazing management on CH(4) uptake in desert steppes, we investigated soil-atmosphere CH(4) exchange during the winter-spring transition period. METHODOLOGY/MAIN FINDING: The experiment was conducted at twelve grazing plots denoting four treatments defined along a grazing gradient with three replications: non-grazing (0 sheep/ha, NG), light grazing (0.75 sheep/ha, LG), moderate grazing (1.50 sheep/ha, MG) and heavy grazing (2.25 sheep/ha, HG). Using an automatic cavity ring-down spectrophotometer, we measured CH(4) fluxes from March 1 to April 29 in 2010 and March 2 to April 27 in 2011. According to the status of soil freeze-thaw cycles (positive and negative soil temperatures occurred in alternation), the experiment was divided into periods I and II. Results indicate that mean CH(4) uptake in period I (7.51 μg CH(4)-C m(-2) h(-1)) was significantly lower than uptake in period II (83.07 μg CH(4)-C m(-2) h(-1)). Averaged over 2 years, CH(4) fluxes during the freeze-thaw period were -84.76 μg CH(4)-C m(-2) h(-1) (NG), -88.76 μg CH(4)-C m(-2) h(-1) (LG), -64.77 μg CH(4)-C m(-2) h(-1) (MG) and -28.80 μg CH(4)-C m(-2) h(-1) (HG). CONCLUSIONS/SIGNIFICANCE: CH(4) uptake activity is affected by freeze-thaw cycles and stocking rates. CH(4) uptake is correlated with the moisture content and temperature of soil. MG and HG decreases CH(4) uptake while LG exerts a considerable positive impact on CH(4) uptake during spring freeze-thaw cycles in the northern desert steppe in China.     

Energetic analysis of the growth of Methanobrevibacter arboriphilus A2 in hydrogen-limited continuous cultures

Hydrogen-limited chemostat cultures of Methanobrevibacter arboriphilus A2 were carried out. The available electron balance and carbon balance in M. arboriphilus A2 and other methanogenic strains grown on various substrates were well satisfied. This indicates that no extracellular organic products were formed during methanogenic growth. The molar growth yields for methane (Y(X/CH(4) )) were calculated as 1.06-1.42 g cell/mol CH(4) at dilution rate (0.21-0.43 day(-1)). The smaller Y(X/CH(4) ) of M. arboriphilus A2 compared with that of the other methanogenic strains was probably owing to the low growth rate of M. arboriphilus A2. The low value of Y(X/CH(4) ) may be favorable for methane fermentation because less sludge accumulation is expected. The efficiency of free energy transduction to ATP during methane formation from H(2) + CO(2) was 12-17% at the dilution rate (0.21-0.43 day(-1)) assuming that Y(ATP) was 6.5 g/mol and the free energy change of CO(2) reduction to methane with H(2) was -62.8 kJ/mol under physiological conditions.     

Increasing biomass in Amazonian forest plots

A previous study by Phillips et al. of changes in the biomass of permanent sample plots in Amazonian forests was used to infer the presence of a regional carbon sink. However, these results generated a vigorous debate about sampling and methodological issues. Therefore we present a new analysis of biomass change in old-growth Amazonian forest plots using updated inventory data. We find that across 59 sites, the above-ground dry biomass in trees that are more than 10 cm in diameter (AGB) has increased since plot establishment by 1.22 +/- 0.43 Mg per hectare per year (ha(-1) yr(-1), where 1 ha = 10(4) m2), or 0.98 +/- 0.38 Mg ha(-1) yr(-1) if individual plot values are weighted by the number of hectare years of monitoring. This significant increase is neither confounded by spatial or temporal variation in wood specific gravity, nor dependent on the allometric equation used to estimate AGB. The conclusion is also robust to uncertainty about diameter measurements for problematic trees: for 34 plots in western Amazon forests a significant increase in AGB is found even with a conservative assumption of zero growth for all trees where diameter measurements were made using optical methods and/or growth rates needed to be estimated following fieldwork. Overall, our results suggest a slightly greater rate of net stand-level change than was reported by Phillips et al. Considering the spatial and temporal scale of sampling and associated studies showing increases in forest growth and stem turnover, the results presented here suggest that the total biomass of these plots has on average increased and that there has been a regional-scale carbon sink in old-growth Amazonian forests during the previous two decades.     

Management of Warm- and Cool-Season Grasses for Biomass on Marginal Lands: I. Yield and Soil Fertility Status

Switchgrass (Panicum virgatum L.), tall fescue [Lolium arundinaceum (Schreb.)], and reed canarygrass (Phalaris arundinacea L.) are known for high biomass productivity and for various traits that make these species more suitable for marginal environmental growing conditions. The goal of this study was to evaluate the impact of organic vs. inorganic fertilizer application on grass biomass production and soil nutrient status. Switchgrass, tall fescue, and reed canarygrass were established on a sandy soil and a clay soil at the Cornell University Willsboro Research Farm in Willsboro, NY. The experiment was a split-split plot randomized block design with six replicates. Sites were whole plots, grass species were subplots, and fertility treatments were sub-subplots. The six treatments were (1) 168 kg ha^?1 of N fertilizer for cool-season grasses, 84 kg ha^?1 for switchgrass; (2) 56 kg ha^?1 of 0-46-0 P fertilizer plus N (#1); (3) 112 kg ha^?1 of 0-0-60 K fertilizer plus N (#1); (4) 89.6 Mg dairy manure ha^?1; (5) 44.8 Mg dairy manure compost ha^?1; and (6) no fertilizer applied (control plots). Switchgrass with a single harvest per season yielded on average 13.0 Mg ha^?1, while tall fescue and reed canarygrass averaged 8.4 and 7.7 Mg ha^?1, respectively, under two-cut systems. Switchgrass with no fertilization produced 84% of maximum yield of fertilized treatments. Application of a similar amount of organic N with fresh and composted dairy manure resulted in greater yields for fresh dairy manure. Organic fertilizers strongly impacted the P and K status of soils. Switchgrass is capable of high yields in marginal environments and can provide a land base for environmentally acceptable application of animal manure, although from a yield standpoint it is not very responsive to fertilizer applications.     

The effect of incubation conditions on the laboratory measurement of the methane producing capacity of livestock wastes

The effects of incubations conditions (dilution, mixing, incubation time and inoculum amount and origin) on the determination of the maximum methane producing capacity (B(0)) from various livestock slurries were evaluated. For this purpose, the methane yields of different livestock slurries were determined using batch anaerobic incubations performed at 30 degrees C as regard these different conditions. The B(0) and the methane (CH(4)) generation as a function of time were used to study the processes and to determine the best incubation conditions. Methanogenesis was identified as the major rate-limiting step during the anaerobic degradation of slurries, probably due to inhibition by volatile fatty acids. In some cases, high free NH(3) concentrations were suspected to inhibit the hydrolysis process. The addition of inoculum and/or the dilution of the substrate reduced the inhibition and allowed to reach the B(0) more rapidly. However, the addition of inoculum must be minimized to reduce the possible errors made by considering a similar production by the inoculum with and without the substrate. All experiments performed during this study allowed to define the incubation conditions required for the determination of the B(0) from livestock slurries. Applying these conditions, the B(0) values determined for swine slurries varied from 244 to 343L CH(4)kg V(added)(-1), from 204 to 296L CH(4)kg V(added)(-1) for dairy cattle slurries and equalled 386 and 319L CH(4)kg VS(added)(-1) respectively for calves and duck slurries.     

Nitrogen use and carbon sequestered by corn rotations in the northern corn belt,U.S

Diversified crop rotation may improve production efficiency, reduce fertilizer nitrogen (N) requirements for corn (Zea mays L.), and increase soil carbon (C) storage. Objectives were to determine effect of rotation and fertilizer N on soil C sequestration and N use. An experiment was started in 1990 on a Barnes clay loam (U.S. soil taxonomy: fine-loamy, mixed, superactive, frigid Calcic Hapludoll) near Brookings, SD. Tillage systems for corn-soybean ( Glycine max [L.] Merr.) rotations were conventional tillage (CS) and ridge tillage (CSr). Rotations under conventional tillage were continuous corn (CC), and a 4-year rotation of corn-soybean-wheat ( Triticum aestivum L.) companion-seeded with alfalfa ( Medicago sativa L.)-alfalfa hay (CSWA). Additional treatments included plots of perennial warm season, cool season, and mixtures of warm and cool season grasses. N treatments for corn were corn fertilized for a grain yield of 8.5 Mg ha(-1) (highN), of 5.3 Mg ha(-1) (midN), and with no N fertilizer (noN). Total (1990-2000) corn grain yield was not different among rotations at 80.8 Mg ha(-1) under highN. Corn yield differences among rotations increased with decreased fertilizer N. Total (1990-2000) corn yields with noN fertilizer were 69 Mg ha-1 under CSWA, 53 Mg ha(-1) under CS, and 35 Mg ha(-1) under CC. Total N attributed to rotations (noN treatments) was 0.68 Mg ha(-1) under CSWA, 0.61 Mg ha(-1) under CS, and 0.28 Mg ha(-1) under CC. Plant carbon return depended on rotation and N. In the past 10 years, total C returned from above- ground biomass was 29.8 Mg ha(-1) under CC with highN, and 12.8 Mg ha(-1) under CSWA with noN. Soil C in the top 15 cm significantly increased (0.7 g kg(-1)) with perennial grass cover, remained unchanged under CSr, and decreased (1.7 g kg(-1)) under CC, CS, and CSWA. C to N ratio significantly narrowed (-0.75) with CSWA and widened (0.72) under grass. Diversified rotations have potential to increase N use efficiency and reduce fertilizer N input for corn. However, within a corn production system using conventional tillage and producing (averaged across rotation and N treatment) about 6.2-Mg ha(-1) corn grain per year, we found no gain in soil C after 10 years regardless of rotation.     

The effects of digestion temperature and temperature shock on the biogas yields from the mesophilic anaerobic digestion of swine manure

In order to obtain basic design criteria for anaerobic digesters of swine manure, the effects of different digesting temperatures, temperature shocks and feed loads, on the biogas yields and methane content were evaluated. The digester temperatures were set at 25, 30 and 35 degrees C, with four feed loads of 5%, 10%, 20% and 40% (feed volume/digester volume). At a temperature of 30 degrees C, the methane yield was reduced by only 3% compared to 35 degrees C, while a 17.4% reduction was observed when the digestion was performed at 25 degrees C. Ultimate methane yields of 327, 389 and 403 mL CH(4)/g VS(added) were obtained at 25, 30 and 35 degrees C, respectively; with moderate feed loads from 5% to 20% (V/V). From the elemental analysis of swine manure, the theoretical biogas and methane yields at standard temperature and pressure were 1.12L biogas/g VS(destroyed) and 0.724 L CH(4)/g VS(destroyed), respectively. Also, the methane content increased with increasing digestion temperatures, but only to a small degree. Temperature shocks from 35 to 30 degrees C and again from 30 to 32 degrees C led to a decrease in the biogas production rate, but it rapidly resumed the value of the control reactor. In addition, no lasting damage was observed for the digestion performance, once it had recovered.     

An integrated biogeochemical and economic analysis of bioenergy crops in the Midwestern United States

This study integrates a biophysical model with a county‐specific economic analysis of breakeven prices of bioenergy crop production to assess the biophysical and economic potential of biofuel production in the Midwestern United States. The bioenergy crops considered in this study include a genotype of Miscanthus, Miscanthus×giganteus, and the Cave‐in‐Rock breed of switchgrass (Panicum virgatum). The estimated average peak biomass yield for miscanthus in the Midwestern states ranges between 7 and 48 metric tons dry matter per hectare per year ( t DM ha^?1 yr^?1), while that for switchgrass is between 10 and 16 t DM ha^?1 yr^?1. With the exception of Minnesota and Wisconsin, where miscanthus yields are likely to be low due to cold soil temperatures, the yield of miscanthus is on average more than two times higher than yield of switchgrass. We find that the breakeven price, which includes the cost of producing the crop and the opportunity cost of land, of producing miscanthus ranges from $53 t^?1 DM in Missouri to $153 t^?1 DM in Minnesota in the low‐cost scenario. Corresponding costs for switchgrass are $88 t^?1 DM in Missouri to $144 t^?1 DM in Minnesota. In the high‐cost scenario, the lowest cost for miscanthus is $85 t^?1 DM and for switchgrass is $118 t^?1 DM, both in Missouri. These two scenarios differ in their assumptions about ease of establishing the perennial crops, nutrient requirements and harvesting costs and losses. The differences in the breakeven prices across states and across crops are mainly driven by bioenergy and row crop yields per hectare. Our results suggest that while high yields per unit of land of bioenergy crops are critical for the competitiveness of bioenergy feedstocks, the yields of the row crops they seek to displace are also an important consideration. Even high yielding crops, such as miscanthus, are likely to be economically attractive only in some locations in the Midwest given the high yields of corn and soybean in the region.     

Harvest date and leaf:stem ratio determine methane hectare yield of miscanthus biomass

The suitability of miscanthus biomass for anaerobic digestion has already been confirmed by several studies. However, it is rarely used as feedstock in biogas plants, mainly due to uncertainty about the optimal harvest regime with regard to the long‐term methane hectare yield and resilience of the crop to green cutting. The recommended green‐cut date for the only commercially available genotype Miscanthus × giganteus (M×g) ranges from September to November. This timeframe is too broad for agricultural practice and needs to be both narrowed down and further specified for different genotypes. The aim of this study was to identify the most suitable harvest window for an autumn green cut of miscanthus, which delivers both a high dry matter and methane yield while securing the long‐term productivity of the crop. A further objective was to quantify the effect of genotypic differences, such as leaf to stem ratio, on the substrate‐specific biogas and methane yield. For these purposes, a field trial with four genotypes (M×g, GNT1, GNT3, Sin55) was conducted over 2 years (2016/2017) and harvested at 2‐week intervals on three dates between mid‐September to mid‐October. Methane hectare yield ranged from 3,183 m³ CH₄ ha^?1 a^?1 (Sin55) to 5,265 m³ CH₄ ha^?1 a^?1 (M×g), which is mainly influenced by dry matter yield. The substrate‐specific methane yield was higher for the leaf (311.0 ml CH₄ (g oDM)^‐1) than the stem fraction (285.1 ml CH₄ (g oDM)^‐1) in all genotypes due to lower lignin content of leaves. Of all genotypes, M×g showed the highest and Sin55 the lowest nutrient use efficiency. We conclude that miscanthus in Germany should be harvested in October to maximize methane yields and nutrient recycling and minimize yield reduction. Additionally, to increase methane hectare yields even further, future miscanthus breeding should focus on a higher leaf proportion.     

Novel membrane bioreactor: Able to cope with fluctuating loads, poorly water soluble VOCs, and biomass accumulation

We determined the effect of different mixing intensities on the performance, methanogenic population dynamics, and juxtaposition of syntrophic microbes in anaerobic digesters treating cow manure from a dairy farm. Computer automated radioactive particle tracking in conjunction with computational fluid dynamics was performed to quantify the shear levels locally. Four continuously stirred anaerobic digesters were operated at different mixing intensities of 1,500, 500, 250, and 50 revolutions per min (RPM) over a 260-day period at a temperature of 34 +/- 1 degrees C. Animal manure at a volatile solids (VS) concentration of 50 g/L was fed into the digesters daily at five different organic loading rates between 0.6 and 3.5 g VS/L day. The different mixing intensities had no effect on the biogas production rates and yields at steady-state conditions. A methane yield of 0.241 +/- 0.007 L CH(4)/g VS fed was obtained by pooling the data of all four digesters during steady-state periods. However, digester performance was affected negatively by mixing intensity during startup of the digesters, with lower biogas production rates and higher volatile fatty acids concentrations observed for the 1,500-RPM digester. Despite similar methane production yields and rates, the acetoclastic methanogenic populations were different for the high- and low-intensity mixed digesters with Methanosarcina spp. and Methanosaeta concilii as the predominant methanogens, respectively. For all four digesters, epifluorescence microscopy revealed decreasing microbial floc sizes beginning at week 4 and continuing through week 26 after which no microbial flocs remained. This decrease in size, and subsequent loss of microbial flocs did not, however, produce any long-term upsets in digester performance.     

The effect of temperature variation on biomethanation at high altitude

The aim of the current study was to examine effects of daily temperature variations on the performance of anaerobic digestion. Forced square-wave temperature variations (between 11 and 25, 15 and 28, and 19 and 32 degrees C) were imposed on a bench-scale digester using a mixture of llama-cow-sheep manure in a semi-continuous process. The volumetric biogas production rate, methane yield, and the volatile solid reductions were compared with the results obtained from anaerobic digestion (AD) at constant temperatures. The forced cyclic variations of temperature caused large cyclic variations in the rate of gas production and the methane content. As much as 94-97% of the daily biogas was obtained in the 12h half-cycle at high temperature. The values for volumetric biogas production rate and methane yield increased at higher temperatures. The average volumetric biogas production rate for cyclic operation between 11 and 25 degrees C was 0.22Ld(-1)L(-1) with a yield of 0.07m3CH4kg(-1) VS added (VSadd), whereas for operation between 15 and 29 degrees C the volumetric biogas production rate increased by 25% (to 0.27Ld(-1)L(-1) with a yield of 0.08m3CH4kg(-1) VSadd). In the highest temperature region a further increase of 7% in biogas production was found and the methane yield was 0.089m(3)CH(4)kg(-1) VSadd. The employed digester showed an immediate response when the temperature was elevated, which indicates a well-maintained metabolic capacity of the methanogenic bacteria during the period of low temperature. Overall, periodic temperature variations appear to give less decrease in process performance than a priori anticipated.     

川中丘陵区冬灌田甲烷和氧化亚氮排放研究

采用静态暗箱/气相色谱法对川中丘陵区冬灌田CH₄和N₂O排放特征进行连续一年的田间原位测定.结果表明,种植水稻区(种植区)在水稻生长季平均CH₄排放速率为22.76±2.76 mg·m^-2·h^-1,休闲期平均为1.43±0.20 mg·m^-2·h^-1,全年平均为9.64±1.17 mg·m^-2·h^-1;全年CH₄排放主要集中在水稻生长季,其累计CH₄排放量占全年总CH₄排放量的91.2%未种植水稻区(对照区) 全年CH₄平均排放速率为2.03±0.18 mg·m^-2·h^-1,水稻生长季CH₄排放量占全年总排放量的86.2%.N₂O的排放在稻田落干时呈现脉冲排放.在水稻生长季,对照区CH₄和N₂O的季节排放速率分别为4.53±0.38mg·m^-2·h^-1和32.01±5.02 μg·m^-2·h^-1,而种植区则分别为22.76±2.76 mg·m^-2·h^-1和73.04±5.03 μg·m^-2·h^-1,植株参与导致CH₄和N₂O排放速率分别增加302%和128%.CH₄和N₂O的排放随土水分条件的变化呈互为消长关系.在冬灌田中,即使考虑500年的时间尺度,全年N₂O排放产生的全球增温潜势也只有CH₄的7.9%,与CH₄相比,冬灌田排放的N₂O所产生的温室效应很小.