Influence of Environmental Factors and Medium Composition on Vibrio gazogenes Growth and Prodigiosin Production

Vibrio gazogenes ATCC 29988 growth and prodigiosin synthesis were studied in batch culture on complex and defined media and in chemostat cultures on defined medium. In batch culture on complex medium, a maximum growth rate of 0.75 h⁻¹ and a maximum prodigiosin concentration of 80 ng of prodigiosin · mg of cell protein⁻¹ were observed. In batch culture on defined medium, maximum growth rates were lower (maximum growth rate, 0.40 h⁻¹), and maximum prodigiosin concentrations were higher (1,500 ng · mg of protein⁻¹). In batch culture on either complex or defined medium, growth was characterized by a period of logarithmic growth followed by a period of linear growth; on either medium, prodigiosin biosynthesis was maximum during linear growth. In batch culture on defined medium, the initial concentration of glucose optimal for growth and pigment production was 3.0%; higher levels of glucose suppressed synthesis of the pigment. V. gazogenes had an absolute requirement for Na⁺; optimal growth occurred in the presence of 100 mM NaCl. Increases in the concentration of Na⁺ up to 600 mM resulted in further increases in the concentration of pigment in the broth. Prodigiosin was synthesized at a maximum level in the presence of inorganic phosphate concentrations suboptimal for growth. Concentrations of KH₂PO₄ above 0.4 mM caused decreased pigment synthesis, whereas maximum cell growth occurred at 1.0 mM. Optimal growth and pigment production occurred in the presence of 8 to 16 mg of ferric ion · liter⁻¹, with higher concentrations proving inhibitory to both growth and pigment production. Both growth and pigment production were found to decrease with increased concentrations of p-aminobenzoic acid. The highest specific concentration of prodigiosin (3,480 ng · mg protein⁻¹) was observed in chemostat cultures at a dilution rate of 0.057 h⁻¹. The specific rate of prodigiosin production at this dilution rate was approximately 80% greater than that observed in batch culture on defined medium. At dilution rates greater than 0.057 h⁻¹, the concentration of cells decreased with increasing dilution rate, resulting in a profile comparable to that expected for linear growth kinetics. No explanation could be found for the linear growth profiles obtained for both batch and chemostat cultures.     

Influence of environmental factors on endo-β-1,4-glucanase production by Bacillus HR68, isolated from a Zimbabwean hot spring

The production of endo-β-1,4-glucanase by a Bacillus strain isolated from a hot spring in Zimbabwe was studied in batch culture, chemostat culture, and carbon dioxide-regulated auxostat (CO₂-auxostat). The bacteria produced the enzyme in the presence of excess glucose or sucroso, but not under carbon-limited conditions in a chemostat using mineral medium. There was a specific growth rate dependent linear increase in enzyme production in glucose excess, nitrogen-limited chemostat cultures. A high specific growth rate of 2.2 h^-1 and a high rate of enzyme production of 362 nkat (mg dry mass h)^-1 were attained under nutrient rich conditions in the CO₂-auxostat. The bacteria had the highest specific growth rate and endo-β-1,4-glucanase enzyme production at 50° C. The maximum specific growth rate and the rate of enzyme production increased when yeast extract and tryptone were added in increasing amounts to the mineral medium used for cultivation in separate experiments. Increasing the glucose concentration in the CO₂-auxostat cultures increased the rate of enzyme production but did not affect the specific growth rate.     

Enzyme production in continuous cultivation by the thermophilic fungus, Thermomyces lanuginosus

The production of extracellular enzymes by the thermophilic fungus Thermomyces lanuginosus was studied in chemostat cultures at a dilution rate of 0.08 h^–1 in relation to variation in the ammonium concentration in the feed medium. Under steady state conditions, three growth regimes were recognised and the production of several extracellular enzymes from T. lanuginosus was recorded under different nutrient limitations ranging from nitrogen limitation to carbon/energy limitation. The range and the production of carbohydrate hydrolysing enzymes and lipase increased from Regime I (NH₄Cl 600 mg l^–1) to Regime III (NH₄CI 1200 mg l^–1), whereas production of protease was highest in Regime II (600 mg l^–1 < NH₄Cl <1200 mg l^–1).     

Xylitol production using recombinant Saccharomyces cerevisiae containing multiple xylose reductase genes at chromosomal δ-sequences

Xylitol production from xylose was studied using recombinant Saccharomyces cerevisiae 2805 containing xylose reductase genes (XYL1) of Pichia stipitis at chromosomal δ-sequences. S. cerevisiae 2805-39-40, which contains about 40 copies of the XYL1 gene on the chromosome, was obtained by a sequential transformation using a dominant selection marker neo^r and an auxotrophic marker URA3. The multiple XYL1 genes were stably maintained on the chromosome even after 21 and 10 days in the non-selective sequential batch and chemostat cultures, respectively, whereas S. cerevisiae 2805:pVTXR, which harbors the episomal plasmid pVTXR having the XYL1 gene, showed mitotic plasmid instability and more than 95% of the cells lost the plasmid under the same culture conditions. In the first batch (3 days) of the sequential batch culture, volumetric xylitol productivity was 0.18 g l⁻¹ h⁻¹ for S. cerevisiae 2805-39-40, as compared to 0.21 g l⁻¹ h⁻¹ for S. cerevisiae 2805:pVTXR. However, the xylitol productivity of the latter started to decrease rapidly in the third batch and dropped to 0.04 g l⁻¹ h⁻¹ in the seventh batch, whereas the former maintained the stable xylitol productivity at 0.18 g l⁻¹ h⁻¹ through the entire sequential batch culture. The xylitol production level in the chemostat culture was about 8 g l⁻¹ for S. cerevisiae 2805-39-40, as compared to 2.0 g l⁻¹ for S. cerevisiae 2805:pVTXR after 10 days of cultures even though the xylitol production level of the latter was higher than that of the former for the first 5 days. The results of this experiment indicate that S. cerevisiae containing the multiple XYL1 genes on the chromosome is much more efficient for the xylitol production in the long-term non-selective culture than S. cerevisiae harboring the episomal plasmid containing the XYL1 gene.     

Influence of the concentrations of d-xylose and yeast extract on ethanol production by Pachysolen tannophilus

To determine the most favorable conditions for the production of ethanol by Pachysolen tannophilus, this yeast was grown in batch cultures with various initial concentrations of two of the constituents of the culture medium: d-xylose (s_o), ranging from 1 g·l⁻¹ to 200 g·l⁻¹, and yeast extract (l_o), ranging from 0 g·l⁻¹ to 8 g·l⁻¹. The most favorable conditions proved to be initial concentrations of S_o=25 g·l⁻¹ and l_o=4 g·l⁻¹, which gave a maximum specific growth rate of 0.26 h⁻¹, biomass productivity of 0.023 g·l⁻¹·h⁻¹, overall biomass yield of 0.094 g·g⁻¹, specific xylose-uptake rate (q_s) of 0.3 g·g⁻¹·h⁻¹ (for t=50 h), specific ethanol-production rate (q_E) of 0.065 g·g⁻¹·h⁻¹ and overall ethanol yield of 0.34 g·g⁻¹; q_s values decreased after the exponential growth phase while q_E remained practically constant.     

Production of l-Methionine-enriched cells of a mutant derived from a methylotrophic yeast,Candida boidinii

l-Methionine-enriched cells production of an ethionine-resistant mutant of Candida boidinii no. 2201 was greatly improved by the control of pH and by feeding of methanol and other medium components during cultivation in a jar fermentor. Under the optimal conditions, 38.5 g (as dry weight)_of cells abd 282 mg of pool methionine (intracellular pool of free l-methionine) per l of culture broth were obtained after 11 d of cultivation.The culture conditions for production of l-methionine-enriched cells in continuous culture were investigated. With limited methanol in continuous cultivation, pool methionine productivity reached a maximum value of 1.14 mg·l⁻¹·h⁻¹ at a dilution rate of 0.05·h⁻¹. During methanol-limited growth in continuous cultivation, the pool methionine content of the mutant was about 20–35% higher than that in batch cultivation.     

Selection of sulfur source for methane production by Methanobacterium thermoautotrophicum

Sulfur sources capable of replacing sulfide were surveyed for biomethanation from H₂ and CO₂ by thermoautotrophic methanogen, Methanobacterium thermoautotrophicum. Among sulfur containing compounds tested, l-cysteine, thiosulfate and coenzyme M gave poor growth when added as sulfur sources, whereas simultaneous addition of two sulfur sources, l-cysteine+thiosulfate, l-cysteine+l-methionine or l-cysteine+coenzyme M stimulated the growth.In a pressure-controlled fermentor system developed to obtain stoichiometry between input and output gases, the ratio of H₂ and CO₂ consumption to CH₄ production was almost stoichiometric, and when l-cysteine and thiosulfate or l-methionine were used in place of sulfide (control) similar growth patterns were observed. In a culture with continuous supply of substrates gases (1.3 vvm) and sulfur sources of 1 mM l-cysteine+2 mM thiosulfate, specific growth rate and specific methane production rate were 0.35 h⁻ and 3.24 l g⁻¹h⁻¹, respectively, compared to 0.22 h⁻¹ and 5.76 l g⁻h⁻¹ with Na₂ S.     

Influence of electron acceptor,carbon, nitrogen,and phosphorus on polyhydroxyalkanoate (PHA) production by <Emphasis Type="Italic">Brachymonas</Emphasis> sp. P12

Polyhydroxyalkanoates (PHAs), intracellular carbon and energy reserve compounds in many bacteria, have been used extensively in biodegradable plastics. PHA formation is influenced by nutrient limitations and growth conditions. To characterize the PHA accumulation in a new denitrifying phosphorus-removing bacterium Brachymonas sp. P12, batch experiments were conducted in which the electron acceptor (oxygen or nitrate) was varied and different concentrations of carbon (acetate), nitrogen (NH₄Cl), and phosphorus (KH₂PO₄) were used. Polyhydroxybutyrate (PHB) was the dominant product during PHA formation when acetate was the sole carbon source. The PHB content of aerobically growing cells increased from 431 to 636 mg PHB g⁻¹ biomass, but the PHB concentration of an anoxic culture decreased (−218 mg PHB g⁻¹ biomass), when PHB was utilized simultaneously with acetate as an electron donor for anoxic denitrification. The specific PHB production rate of the carbon-limited batch, 158.2 mg PHB g⁻¹ biomass h⁻¹, was much greater than that of batches with normal or excess carbon. The effects of phosphorus and nitrogen concentrations on PHB accumulation were clearly less than the effect of carbon concentration. According to the correlation between the specific PHB production rate and the specific cell growth rate, PHB accumulation by Brachymonas sp. P12 is enhanced by nutrient limitation, is growth-associated, and provides additional energy for the biosynthesis of non-PHB cell constituents to increase the cell growth rate beyond the usual level.     

Continuous high-ethanol fermentation from cane molasses by a flocculating yeast

Repeated-batch fermentation by a flocculating fusant, Saccharomyces cerevisiae HA 2, was done in a molasses medium that contained 20% (w/v) total sugar, at 30°C in an automatically controlled fermentor, and the effects of ethanol concentration on the specific growth rate and the specific production rate of ethanol were studied. Both the specific growth rate and the specific production rate of ethanol fell with increase of ethanol concentration, and there was a linear correlation between each rate and the concentration of thanol. The maximum specific growth rate (μ_max) and the maximum specific production rate of ethanol (q_max) were 0.12 h⁻¹ and 0.1 g ethanol/10⁹ cells·h, respectively. The specific growth rate and the specific production rate of ethanol fell to zero at ethanol concentration of 89 g/l and 95 g/l, respectively. The number of viable cells, calculated from the linear inhibition equation, was 1.3 × 10⁹ cells/ml for production of 85 g/l ethanol at a dilution rate (D₁) of 0.2 h⁻¹. Based on this estimation, a laboratory-scale continuous fermentation, using two fermentors in series, was done. In the second fermentor, 85 g/l ethanol was produced at a dilution rate (D₁) of 0.2 h⁻¹ by the active feedig of the fermented mash from the first fermentor into the second fermentor by pumping (hereafter called active feeding). To maintain the number of viable cells above 10⁹ cells/ml in the second fermentor, a active feeding ratio of more than 23% was required. Under these conditions, 81 g/l ethanol was produced in the second fermentor at a dilution rate (D_t) of 0.25 h⁻¹, and the high ethanol productivity of 20.3 g/l·h could be achieved. A bench-scale continuous fermentation, using two fermentors in series, with a active feeding ratio of 25% was done. An ethanol concentration of 84 g/l in the second fermentor at a dilution rate (D_t) of 0.25 h⁻¹ was achieved, just as it was in the laboratory-scale fermentation test.     

Enhanced production of peroxidase in continuous culture of Arthromyces ramosus by selective bleeding of mycelium

A new method of continuous culture with selective bleeding of mycelia using 9-mesh screen was developed to improve the production rate of peroxidase (POD) by Arthromyces ramosus. At the dilution rate of 0.05 h⁻¹ with the mycelium leakage rate of 60%, a high production rate (average value was 1.67 U·ml⁻¹·h⁻¹) was maintained for over 100 h: the rate was 3.2 times that in a glucose-fed batch culture. At the same dilution rate, the volumetric and specific production rates of POD in the continuous culture without the screen were lower than those in the first continuous culture and decreased gradually in the later phase of the culture. In the continuous culture with low mycelium leakage rate of 1.6%, the POD production rate was not improved further, although the mycelial concentration (43 g·l⁻¹) increased 2.9 times. It is suggested that the high agitation rate required to meet the oxygen demand is unfavorable for the POD production.     

Phosphate limitation stress induces xylitol overproduction by Debaryomyces hansenii

The physiological responses of xylose-grown Debaryomyces hansenii were studied under different nutritive stress conditions using continuous cultivation at a constant dilution rate of 0.055 h⁻¹. Metabolic steady-state data were obtained for xylose, ammonium, potassium, phosphate and oxygen limitation. For xylose and potassium limitation, fully oxidative metabolism occurred leading to the production of biomass and CO₂ as the only metabolic products. However, potassium-limiting cultivation was the most severe nutritional stress of all tested, exhibiting the highest xylose and O₂ specific consumption rates along with the lowest biomass yield, 0.22 g g⁻¹ xylose. It is suggested that carbon was mainly channelled to meet the cellular energy requirements for potassium uptake. For the other limiting nutritional conditions increasing amounts of extracellular xylitol were found for ammonium, phosphate and oxygen limitation. Although xylitol excretion is not significant for ammonium limitation, the same is not true for phosphate limitation where the xylitol productivity reached 0.10 g l⁻¹ h⁻¹, about half of that found under oxygen-limiting conditions, 0.21 g l⁻¹ h⁻¹. This work is the first evidence that xylitol production by D. hansenii might not only be a consequence of a redox imbalance usually attained under semi-aerobic conditions, but additional physiological mechanisms must be involved, especially under phosphate limitation. Cell yields changed drastically as a function of the limiting nutrient, being 0.22, 0.29, and 0.39 g g⁻¹ xylose for potassium, oxygen and phosphate limitation, respectively, and are a good indicator of the severity of nutritive stress.     

Use of chemostat data for modelling extracellular-inulinase production by Kluyveromyces marxianus in a high-cell-density fed-batch process

Production of extracellular inulinase by low-cell-density (2 kg dry weight·m⁻³) sucrose-limited chemostat cultures of Kluyveromyces marxianus obeyed saturated kinetics at dilution rates ranging from 0.02 to 0.5 h⁻¹. A non-structured Monod-type equation, describing the relation between specific growth rate and specific extracellular-inulinase production rate, was used to fit experimental data. THis equation was subsequently incorporated in a model for the production of biomass and extracellular inulinase in a high-cell-density (> 100 kg dry weight·m⁻³) fed-batchculture of K. marxianus grown on sucrose. The model adequately described biomass production in the fed-batch culture. However, the production of extracellular inulinase in the fed-batch process was slightly higher than predicted by the model. This observation may be related to differences in growth conditions between in the chemostat and fed-batch cultures.     

Factors affecting l-arginine production in the continuous culture of an l-arginine producer of Corynebacterium acetoacidophilum

The effects of culture conditions on l-arginine production by continuous culture were studied using a stable l-arginine hyperproducing strain of Corynebacterium aceto-acidophilum, SC-190. Strain SC-190 demonstrated a volumetric productivity of 35 g l⁻¹·h⁻¹ at a dilution rate of 0.083h⁻¹ and feeding sugar concentration of 8%, and a product yield of 29.2% at a dilution rate 0.021h⁻¹ and feeding sugar concentration of 15%. The corresponding values for fed-batch culture are 0.85 g·l⁻¹·h⁻¹ and 26%. However, the product yield decreased with an increase in the volumetric productivity. To achieve stable l-arginine production, aeration and agitation conditions sufficient to maintain an optimal level of redox potential (>−100 mV) were necessary. The addition of phosphate to the feeding medium led to a decrease in l-arginine production. It was confirmed in the steady state that growth and l-arginine formation were inhibited by a high concentration of l-arginine.     

Rifamycin B production by Nocardia mediterranei immobilized in a dual hollow fibre bioreactor

Continuous production of rifamycin B was studied using Nocardia mediterranei (ATCC 21789) immobilized in a dual hollow fibre bioreactor designed for cultivating aerobic cells. In the reactor operation the volumetric productivity based on the volume occupied by the immobilized cells was 108 mg l⁻¹ h⁻¹ when air was used for aeration and was 143 mg l⁻¹ h⁻¹ with pure oxygen. These corresponded to 22 and 30-fold increases over the productivity of the comparable batch system. These high productivities were due to the high cell mass density of 550 g l⁻¹. However, the specific productivity of the cell was 30–40% of that in the shake flask culture. As the residence time of medium in the reactor increased, pH of effluent rose to an alkaline region that was outside its optimum condition (pH 6.5–7.0) and the yield and productivity decreased.     

The regulatory effect of fermentable sugar levels on the production of leukotoxin by Actinobacillus actinomycetemcomitans

The relationship between sugar availability and RTX (repeats in toxin) cytotoxin (leukotoxin) production in the periodontopathic bacterium, Actinobacillus actinomycetemcomitans, was investigated using a chemostat. A. actinomycetemcomitans 301-b produced significant amounts of leukotoxin in anaerobic fructose-limited chemostat cultures at a dilution rate of 0.15 h⁻¹ and at pH 7.0. When the growth limitation was relieved by pulsing the cultures with 50 or 150 mM fructose (final concentrations), leukotoxin production immediately stopped and the amount of cellular leukotoxin decreased until the culture was returned to fructose-limited conditions. Leukotoxin synthesis was also repressed in the chemostat cultures by pulsing with glucose but not with the non-fermentable sugar analog, α-methyl-d-glucoside. Leukotoxin production was also repressed by fructose in chemostat cultures of ATCC 33384, which is generally recognized as a non-leukotoxin-producing or minimally leukotoxic strain.     

Protease and lipase production by a strain ofSerratia marcescens (532 S)

Summary Production of both exolipase and exoprotease activities bySerratia marcescens 532 S isolated from an aerobic fixed-biomass reactor were strongly influenced by nutritional factors which acted as inducers or repressors. In batch culture, protease and lipase activities were produced after the exponential phase. NH₄Cl, amino acids and simple carbon sources caused repression of protease activity. At a concentration of 1.5 g L^–1, the individual addition of maltose, mannitol, acetate, fructose or glucose, repressed exoprotease production, with the greatest effect by glucose. An inverse relationship existed between exoprotease synthesis and increasing glucose concentrations. Lipids activated lipase production, the most significant increase occurred when Tween 80 was added in the medium. Thus, glucidolytic, proteolytic and lipolytic activities could be efficiently expressed in batch cultures only successively.At low dilution rate of chemostat cultures with a constant glucose input concentration of 2 g L^–1, glucidolytic, proteolytic and lipolytic activities were produced, but did not have the same regulation: atD values <0.08 h^–1, the level of protease activity dropped while that of lipase showed a corresponding increase. Above these values, increasingD led to a decrease of the two hydrolase activities, at the level of the specific activities as well as in the specific rate of biosynthesis of each enzyme. Similar results were obtained in chemostat culture with a constant specific growth rate of 0.04 h^–1 with increasing glucose input concentrations, i.e. protease and lipase activities decreased when the specific glucose uptake rates were enhanced.     

Influence of Carbon Source on Nitrate Removal by Nitrate-Tolerant Klebsiella oxytoca CECT 4460 in Batch and Chemostat Cultures

The nitrate-tolerant organism Klebsiella oxytoca CECT 4460 tolerates nitrate at concentrations up to 1 M and is used to treat wastewater with high nitrate loads in industrial wastewater treatment plants. We studied the influence of the C source (glycerol or sucrose or both) on the growth rate and the efficiency of nitrate removal under laboratory conditions. With sucrose as the sole C source the maximum specific growth rate was 0.3 h⁻¹, whereas with glycerol it was 0.45 h⁻¹. In batch cultures K. oxytoca cells grown on sucrose or glycerol were able to immediately use sucrose as a sole C source, suggesting that sucrose uptake and metabolism were constitutive. In contrast, glycerol uptake occurred preferentially in glycerol-grown cells. Independent of the preculture conditions, when sucrose and glycerol were added simultaneously to batch cultures, the sucrose was used first, and once the supply of sucrose was exhausted, the glycerol was consumed. Utilization of nitrate as an N source occurred without nitrite or ammonium accumulation when glycerol was used, but nitrite accumulated when sucrose was used. In chemostat cultures K. oxytoca CECT 4460 efficiently removed nitrate without accumulation of nitrate or ammonium when sucrose, glycerol, or mixtures of these two C sources were used. The growth yields and the efficiencies of C and N utilization were determined at different growth rates in chemostat cultures. Regardless of the C source, yield carbon (Y_C) ranged between 1.3 and 1.0 g (dry weight) per g of sucrose C or glycerol C consumed. Regardless of the specific growth rate and the C source, yield nitrogen (Y_N) ranged from 17.2 to 12.5 g (dry weight) per g of nitrate N consumed. In contrast to batch cultures, in continuous cultures glycerol and sucrose were utilized simultaneously, although the specific rate of sucrose consumption was higher than the specific rate of glycerol consumption. In continuous cultures double-nutrient-limited growth appeared with respect to the C/N ratio of the feed medium and the dilution rate, so that for a C/N ratio between 10 and 30 and a growth rate of 0.1 h⁻¹ the process led to simultaneous and efficient removal of the C and N sources used. At a growth rate of 0.2 h⁻¹ the zone of double limitation was between 8 and 11. This suggests that the regimen of double limitation is influenced by the C/N ratio and the growth rate. The results of these experiments were validated by pulse assays.     

Growth characteristics and oxidative capacity of<Emphasis Type="Italic"> Acetobacter aceti</Emphasis> IFO 3281: implications for <Emphasis Type="SmallCaps">l</Emphasis>-ribulose production

We studied the growth characteristics and oxidative capacities of Acetobacter aceti IFO 3281 in batch and chemostat cultures. In batch culture, glycerol was the best growth substrate and growth on ethanol occurred only after 6 days delay, although ethanol was rapidly oxidized to acetic acid. In continuous culture, both glycerol and ethanol were good growth substrates with similar characteristics. Resting cells in a bioreactor oxidized ribitol to l-ribulose with a maximal specific rate of 1.2 g g^–1 h^–1). The oxidation of ribitol was inhibited by ethanol but not by glycerol. Biomass yield (Y_SX; C-mmol/C-mmol) on ethanol and glycerol was low (0.21 and 0.17, respectively). In the presence of ribitol the yield was somewhat higher (0.25) with ethanol but lower (0.13) with glycerol, with respectively lower and higher CO₂ production. In chemostat cultures the oxidation rate of ribitol was unaffected by ethanol or glycerol. Cell-free extract oxidized ethanol very slowly but not ribitol; the oxidative activity was located in the cell membrane fraction. Enzymatic activities of some key metabolic enzymes were determined from steady-state chemostat with ethanol, glycerol, or ethanol/glycerol mixture as a growth limiting substrate. Based on the measured enzyme activities, metabolic pathways are proposed for ethanol and glycerol metabolism.     

Effect of tannins on growth and amylase production by Calvatia gigantea

The effect of tannins was investigated on growth and α-amylase (α-1,4-glucan 4-glucanohydrolase, EC 3.2.1.1) production by the edible fungal species Calvatia gigantea, grown in a laboratory-scale fermenter on acorn starch media containing up to 2 g tannins l⁻¹. No inhibition of both growth and amylase excretion was observed when the fungus was cultivated on media containing 40 to 100 times higher tannin concentration than that reported to inhibit microbial growth. Amylase excretion was enhanced when starch was dry sterilized but specific growth rate was higher when starch was wet sterilized. Biomass and amylase production increased with increasing substrate concentration and specific growth rate reached its maximum value at 20 g l⁻¹ starch concentration. The optimum pH of biomass and amylase productionwas 5.0–5.5 and 6.0−6.5 respectively and that of temperature was 29–32 and 29–30°C respectively. Maximum yields of 68 250 U amylase and 0.58–0.60 g biomass g⁻¹ acorn were obtained at optimum growth conditions. A plot of reciprocal growth rate vs. reciprocal starch concentration made it possible to calculate K_s = 0.84 g acorn starch l⁻¹ and μ_max = 0.249 h⁻¹.