Application of thermostable xylanase of Dictyoglomus sp. in enzymatic treatment of kraft pulps

Enzymatic treatment of pine and birch kraft pulps with a xylanase preparation from a thermophilic anaerobic bacterium Dictyoglomus sp. strain B1 was studied in order to improved pulp bleachability. Maximal solubilization of pulp xylan was obtained at 90°C and pH 6.0–7.0. The enzyme was also active in the alkaline pH range; at pH 9.0 xylan hydrolysis was decreased by only 18% from the maximum at pH 7.0. The positive effect of xylanase pretreatment at 80°C and pH 6.0 or 8.0 on bleachability of pine kraft pulp was demonstrated. The brightness was increased by two ISO units in one-stage peroxide delignification, which corresponds well to values obtained with other enzymes at lower temperatures and pH values. Thus, the Dictyoglomus xylanase is well suited for pulp treatments at elevated temperatures in neutral and alkaline conditions.Correspondence to: M. Rättö     

Production and biochemical characterization of xylanase from an alkalitolerant novel species Aspergillus niveus RS2

The novel fungus Aspergillus niveus RS2 isolated from rice straw showed relatively high xylanase production after 5 days of fermentation. Of the different xylan-containing agricultural by-products tested, rice husk was the best substrate; however, maximum xylanase production occurred when the organism was cultured on purified xylan. Yeast extract was found to be the best nitrogen source for xylanase production, followed by ammonium sulfate and peptone. The optimum pH for maximum enzyme production was 8 (18.2 U/ml); however, an appreciable level of activity was obtained at pH 7 (10.9 U/ml). Temperature and pH optima for xylanase were 50°C and 7.0, respectively; however the enzyme retained considerably high activity under high temperature (12.1 U/ml at 60°C) and high alkaline conditions (17.2 U/ml at pH 8 and 13.9 U/ml at pH 9). The enzyme was strongly inhibited by Hg²⁺, while Mn²⁺ was slight activator. The half-life of the enzyme was 48 min at 50°C. The enzyme was purified by 5.08-fold using carboxymethyl-sephadex chromatography. Zymogram analysis suggested the presence of a single candidate xylanase in the purified preparation. SDS-PAGE revealed a molecular weight of approximately 22.5 kDa. The enzyme had K _m and V _max values of 2.5 and 26 μmol/mg per minute, respectively.     

Characterization of a thermostable and alkaline xylanase from Bacillus sp. and its bleaching impact on wheat straw pulp

Delignification efficacy of xylanases to facilitate the consequent chemical bleaching of Kraft pulps has been studied widely. In this work, an alkaline and thermally stable cellulase-less xylanase, derived from a xylanolytic Bacillus subtilis, has been purified by a combination of gel filtration and Q-Sepharose chromatography to its homogeneity. Molecular weight of the purified xylanase was 61 kDa by SDS–PAGE. The purified enzyme revealed an optimum assay temperature and pH of 60°C and 8.0, respectively. Xylanase was active in the pH range of 6.0–9.0 and stable up to 70°C. Divalent ions like Ca²⁺, Mg²⁺ and Zn²⁺ enhanced xylanase activity, whereas Hg²⁺, Fe²⁺, and Cu²⁺ were inhibitory to xylanase at 2 mM concentration. It showed K _m and V _max values of 9.5 mg/ml and 53.6 μmol/ml/min, respectively, using birchwood xylan as a substrate. Xylanase exhibited higher values of turn over number (K _cat) and catalytic efficiency (K _cat/K _m) with birchwood xylan than oat spelt xylan. Bleach-boosting enzyme activity at 30 U/g dry pulp displayed the optimum bio-delignification of Kraft pulp resulting in 26.5% reduction in kappa number and 18.5% ISO induction in brightness at 55°C after 3 h treatment. The same treatment improved the pulp properties including tensile strength and burst index, demonstrating its potential application in pre-bleaching of Kraft pulp.     

Production and potential applications of a xylanase from a new strain of Streptomyces cuspidosporus

Enzyme production by a new mesophilic Streptomyces isolate was investigated which grew optimally on 1% (w/v) xylan and 10% (w/v) wheat bran at pH 7 and 37 °C. Xylan induced only CMCase (0.29 U/ml) besides xylanase (22–35 U/ml, 40–49 U/mg protein). Wheat bran induced xylanase (105 U/ml, 17.5 U/mg protein), CMCase (0.74 U/ml), -xylosidase (0.009 U/ml), -glucosidase (0.026 U/ml), -L-arabinofuranosidase (0.049 U/ml), amylase (1.6 U/ml) and phytase (0.432 U/ml). The isolate was amenable to solid state cultivation and produced increased levels of xylanase (146 U/ml, 28 U/mg protein). The pH and temperature optima of the crude xylanase activity were 5.5 and 65 °C respectively. The pI was 6.0 as determined by PEG precipitation. The crude enzyme was applied in treatment of paper pulp and predigestion of poultry feed and was found to be effective in releasing sugars from both and soluble phosphorus from the latter.     

The role of two Trichoderma reesei xylanases in the bleaching of pine kraft pulp

Summary The two major xylanases of Trichoderma reesei with different pI values and pH optima were compared for increasing the bleachability of pine kraft pulp. The efficiencies of the two enzymes acting on pulp substrate were very similar in hydrolysis yield, extraction kappa number or final brightness value. Only slight synergism between the two enzymes was observed in both hydrolysis and bleaching tests. The pH optimum of the pI 5.5 xylanase was similar in pulp treatment and in the hydrolysis of isolated substrates, and the bleaching result also correlated well with the hydrolysis of pulp xylan. By contrast, the pI 9.0 xylanase acted differently on pulp than on isolated xylans at different pH values and the pH optimum on pulp was increased. The bleachability of pulp by the pI 9.0 xylanase was improved more than expected at pH 7.0, although the hydrolysis of pulp xylan was substantially decreased. A similar phenomenon was also observed when the hydrolysis was performed in water instead of buffer. It thus appears that the degree of hydrolysis needed to obtain improved bleachability with pI 9.0 xylanase can be minimized by proper adjustment of the hydrolysis conditions. Correspondence to: J. Buchert     

Optimization of conditions for the production of lignocellulolytic enzymes by Sphingobacterium sp. ksn-11 utilizing agro-wastes under submerged condition

Abstract

The present work was aimed at studying the production of lignocellulolytic enzymes, namely cellulase, xylanase, pectinase, mannanase, and laccase by a newly isolated bacterium Sphingobacterium sp. ksn-11, utilizing various agro-residues as a substrate under submerged conditions. The production of lignocellulolytic enzymes was found to be maximum at the loading of 10%(w/v) agro-residues. The enzyme secretion was enhanced by two-fold at 2?mM CaCO_3, optimum pH 7, and temperature 40°. The Field Emission Gun-Scanning Electron Microscope (FEG-SEM) results have shown the degradative effect of lignocellulases; cellulase, xylanase, mannanase, pectinase, and laccase on corn husk with 3.55?U/ml, 79.22?U/ml, 12.43?U/ml, 64.66?U/ml, and 21.12?U/ml of activity, respectively. The hydrolyzed corn husk found to be good adsorbent for polyphenols released during hydrolysis of corn husk providing suitable conditions for stability of lignocellulases. Sphingobacterium sp. ksn is proved to be a promising candidate for lignocellulolytic enzymes in view of demand for enzymes in the biofuel industry.     

Penicillium brasilianum as an enzyme factory; the essential role of feruloyl esterases for the hydrolysis of the plant cell wall

The production of arabinoxylan-degrading enzymes by the fungus Penicillium brasilianum, grown on different carbon and nitrogen sources as well as different environmental conditions was investigated. Highest feruloyl esterase (225 mU/ml) and alpha-L-arabinofuranosidase (211 mU/ml) activities were obtained when P. brasilianum was grown on sugar beet pulp, whereas maximum xylanase (17 U/ml) activity was found during growth on oat spelt xylan. Yeast extract was the preferable nitrogen source for the production of all the three enzymes. Further optimization of the production of the crude enzyme mixture was examined by experimental design using a D-optimal quadratic model. Investigation of the microbial regulation of enzyme production showed that the presence of free ferulic acid further stimulated the production and pointing to that the fungal regulatory mechanism involved a coordinated production and secretion of feruloyl esterase, xylanase and alpha-L-arabinofuranosidase. Since agroindustrial by-products are a potential source of phenolic acids, crude enzyme mixtures of P. brasilianum were tested for their hydrolysis abilities against eight complex or model substrates. While total release of phenolic acids and pentoses was not observed, the synergistic enhancement of hydrolysis in the presence of feruloyl esterase was clearly demonstrated.     

Role of hydrolysis conditions in the enzyme-mediated release of reducing sugars from sulphite pulp

Summary The release of reducing sugars from sulphite pulp treated with an Aureobasidium pullulans xylanase preparation was studied. Hydrolysis conditions such as pH, buffer, temperature and time of enzyme treatment were optimized in terms of their effect on sulphite pulp for production of dissolving pulp with an improved quality. Enzyme hydrolysis of pulp was found to be most effective at a temperature of 55°C and at pH 4.7 using sodium acetate buffer.     

Enhanced production of a thermostable xylanase from Streptomyces sp. QG-11-3 and its application in biobleaching of eucalyptus kraft pulp

A thermostable and cellulase-free xylanase has been produced from Streptomyces sp. QG-11-3 in solid substrate fermentation using wheat bran and eucalyptus kraft pulp as the prime solid substrates. The maximum xylanase yield obtained using these two substrates were 2360 U/g and 1200 U/g dry solid substrate at substrate:moisture ratios of 1:3 and 1:2.5, respectively. In immobilized cell system using polyurethane foam (PUF) and three nonwoven fabrics, namely, polyester, silk, and cotton, the xylanase yields were enhanced by 2.5-fold (203 U/ml), 1.91-fold (155 U/ml), 1.54-fold (125 U/ml), and 1.47-fold (119 U/ml), respectively, compared to the xylanase yield in liquid-batch fermentation (81 U/ml). In the biobleaching experiments, the xylanase dose of 3.5 U/g moisture free pulp exhibited the optimum bleach boosting of eucalyptus kraft pulp at pH 8.5 and 50 degrees C after 2 h of treatment. When xylanase treated pulp was subsequently treated with 4.5% chlorine, it resulted in reduction of kappa number by 25%, enhanced the brightness (%ISO) by 20% and improved the pulp properties such as tensile strength and burst factor by up to 63% and 8%, respectively.     

The performance of fungal xylan-degrading enzyme preparations in elemental chlorine-free bleaching for Eucalyptus pulp

Cellulase-free xylan-degrading enzyme preparations from Acrophialophora nainiana, Humicola grisea var. thermoidea and two Trichoderma harzianum strains were used as bleaching agents for Eucalyptus kraft pulp, prior to a chlorine dioxide and alkaline bleaching sequence. In comparison to the control sequence (performed without xylanase pretreatment), the sequence incorporating enzyme treatment was more effective. Removal of residual lignin was indicated by a reduction in kappa number. Overall, enzyme preparations from T. harzianum were marginally more effective in reducing pulp viscosity and chlorine chemical consumption and improving the brightness of the kraft pulp. However, the highest reduction in pulp viscosity was mediated by the xylanase preparation from A. nainiana. Xylanase pretreatment compares very favorably with that of chemical pulping. Journal of Industrial Microbiology & Biotechnology (2002) 28, 204–206 DOI: 10.1038/sj/jim/7000227 Received 27 April 2001/ Accepted in revised form 03 November 2001     

Xylanases of marine fungi of potential use for biobleaching of paper pulp

Microbial xylanases that are thermostable, active at alkaline pH and cellulase-free are generally preferred for biobleaching of paper pulp. We screened obligate and facultative marine fungi for xylanase activity with these desirable traits. Several fungal isolates obtained from marine habitats showed alkaline xylanase activity. The crude enzyme from NIOCC isolate 3 (Aspergillus niger), with high xylanase activity, cellulase-free and unique properties containing 580 U l^–1 xylanase, could bring about bleaching of sugarcane bagasse pulp by a 60 min treatment at 55°C, resulting in a decrease of ten kappa numbers and a 30% reduction in consumption of chlorine during bleaching. The culture filtrate showed peaks of xylanase activity at pH 3.5 and pH 8.5. When assayed at pH 3.5, optimum activity was detected at 50°C, with a second peak of activity at 90°C. When assayed at pH 8.5, optimum activity was seen at 80°C. The crude enzyme was thermostable at 55°C for at least 4 h and retained about 60% activity. Gel filtration of the 50–80% ammonium sulphate-precipitated fraction of the crude culture filtrate separated into two peaks of xylanase with specific activities of 393 and 2,457 U (mg protein)^–1. The two peaks showing xylanase activity had molecular masses of 13 and 18 kDa. Zymogram analysis of xylanase of crude culture filtrate as well as the 50–80% ammonium sulphate-precipitated fraction showed two distinct xylanase activity bands on native PAGE. The crude culture filtrate also showed moderate activities of -xylosidase and -l-arabinofuranosidase, which could act synergistically with xylanase in attacking xylan. This is the first report showing the potential application of crude culture filtrate of a marine fungal isolate possessing thermostable, cellulase-free alkaline xylanase activity in biobleaching of paper pulp.     

Alkaline-active xylanase produced by an alkaliphilicBacillus sp isolated from kraft pulp

ABacillus sp (V1-4) was isolated from hardwood kraft pulp. It was capable of growing in diluted kraft black liquor at pH 11.5 and produced 49 IU (mol xylose min^–1 ml^–1) of xylanase when cultivated in alkaline medium at pH 9. Maximal enzyme activity was obtained by cultivation in a defined alkaline medium with 2% birchwood xylan and 1% corn steep liquor at pH 9, but high enzyme production was also obtained on wheat bran. The apparent pH optimum of the enzyme varied with the pH used for cultivation and the buffer system employed for enzyme assay. With cultivation at pH 10 and assays performed in glycine buffer, maximal activity was observed at pH 8.5; with phosphate buffer, maximal activity was between pH 6 and 7. The xylanase temperature optimum (at pH 7.0) was 55°C. In the absence of substrate, at pH 9.0, the enzyme was stable at 50°C for at least 30 min. Elecrophoretic analysis of the crude preparation showed one predominant xylanase with an alkaline pl. Biobleaching studies showed that the enzyme would brighten both hardwood and softwood kraft pulp and release chromophores at pH 7 and 9. Because kraft pulps are alkaline, this enzyme could be used for prebleaching with minimal pH adjustment.     

Application of thermoalkalophilic xylanase from Arthrobacter sp. MTCC 5214 in biobleaching of kraft pulp

A thermoalkalophilic and cellulase-free xylanase produced from Arthrobacter sp. MTCC 5214 by solid-state fermentation using wheat bran as a carbon source was evaluated for prebleaching of kraft pulp. The UV absorption spectrum of the compounds released by enzyme treatment showed a characteristic peak at 280 nm, indicating the presence of lignin in the released colouring matter. Enzymatic prebleaching of kraft pulp showed 20% reduction in kappa number of the pulp without much change in viscosity. Enzymatic treatment reduced the amount of chlorine by 29% without any decrease in brightness. The viscosity of xylanase treated pulp was 4.0 p, whereas the viscosity of the pulp treated exclusively with chlorine was 4.1 p.     

Production of thermostable pectinase and xylanase for their potential application in bleaching of kraft pulp

A very high level of alkalophilic and thermostable pectinase and xylanase has been produced from newly isolated strains of Bacillus subtilis and Bacillus pumilus respectively. Enzyme production for pectinase was carried out under SSF using combinations of cheap agricultural residues while xylanase was produced under submerged fermentation using wheat bran as substrate to minimize the cost of production of these enzymes Among the various substrates tested, the highest yield of pectinase production was observed by using combination of WB + CW (6592 U/g of dry substrate) supplemented with 4% yeast extract when incubated at 37 °C for 72 h using deionized water of pH 7.0 as moistening agent. The biobleaching effect of these cellulase free enzymes on kraft pulp was determined. Both xylanase and pectinase showed stability over a broad range of pH from 6 to 10 and temperature from 55 to 70 °C. The bleaching efficiency of the pectinase and xylanase on kraft pulp was maximum after 150 min at 60 °C using enzyme dosage of 5 IU/ml of each enzyme at 10% pulp consistency with about 16% reduction in kappa number and 84% reduction in permanganate number. Enzyme treated pulp when subjected to CDED₁D₂ steps, 25% reduction in chlorine consumption and upto 19% reduction in consumption of chlorine dioxide was observed for obtaining the same %ISO brightness. Also an increase of 22 and 84% in whiteness and fluorescence respectively and a decrease of approximately 19% in the yellowness of the biotreated pulp were observed by pretreatment of the pulp with our enzymatic mixture.     

Isolation of mutants of Aspergillus awamori with enhanced production of extracellular xylanase and β-xylosidase

Plate screening tests were designed for the selection and isolation of mutant strains of the fungus Aspergillus awamori CMI 142717 showing over-production and constitutive synthesis of xylanase and -xylosidase. Following mutation by N-methyl-N-nitro-N-nitrosoguanidine, nitrous acid and UV (254 nm), two generations of mutants were isolated and cultured in shake fiasks containing glucose, ball-milled oat straw or oat speit xylan as carbon source. Growth of a number of selected mutants in shake flask culture on medium containing oat spelt xylan produced the highest titres of xylanase and -xylosidase. Thus, xylanase producton by mutant AANTG43 was 132 U/ml when the Somogyl-Nelson (alkaline copper) method of measuring reducing sugar released was used, or 1160 U/ml using the dinitrosalicylic acid method of reducing sugar analysis. These values were 8-fold higher than those produced by the wild type. A 20-fold improvement in -xylosidase production was produced by mutant AANO19 (3.51 U/ml). The titres for these two enzyme activities are the highest recorded so far in the literature. Mutant AANTG43 also produced high levels of xylanase (49.8 U/ml) in submerged culture in a fermenter and showed a substantial improvement in the overall productivity of enzyme compared to the wild type strain.The authors are with the Rowett Research Institute, Bucksburn, Aberdeen AB2 9SB, UK.     

Purification of extracellular alkaline phosphatase released by Escherichia coli excretory mutants

Summary Alkaline phosphatase (APase) is the major protein released into the extracellular medium by strain 706, a periplasmic-excretory (lky) mutant of Escherichia coli K12. We developed a rapid three step procedure for APase purification from culture supernatants of lky mutants. Two ultrafiltration stages and an heat treatment were sufficient to obtain a 99% pure enzyme preparation. Batch culture conditions of strain 706 in a 15 l fermentor leading to an extracellular APase yield of 1250 U/ml were determined.Abbreviation APase E. coli alkaline phosphatase     

Enhanced production of cellulase-free thermostable xylanase by Bacillus pumilus ASH and its potential application in paper industry

A very high level of cellulase-free, thermostable xylanase has been produced from newly isolated strain of Bacillus pumilus under submerged fermentation in a basal medium supplemented with wheat bran (2%, w/v) pH 8.0 and at 37 °C. After optimization of various production parameters, an increase of nearly 13-fold in xylanase production (5407 IU/ml) was achieved. The produced xylanase is stable in neutral to alkaline pH region at 70 °C. The suitability of this xylanase for use in the bioleaching of eucalyptus Kraft pulp was investigated. A xylanase dose of 5 IU/g of oven dried pulp of 10% consistency exhibited the optimum bleach boosting of the pulp at pH 7.0 and 60 °C after 180 min of treatment. An increase of 5% in brightness along with an increase of 21% and 28% in whiteness and fluorescence respectively, whereas 18% decrease in the yellowness of the biotreated pulp was observed. Enzyme treated pulp when subjected to chemical bleaching, resulted in 20% reduction in chlorine consumption and up to 10% reduction in consumption of chlorine dioxide. Also a reduction of about 16% in kappa number and 83% in permanganate number, along with a reduction in COD value and significant improvement in various pulp properties, viz. viscosity, tensile strength, breaking length, burst factor, burstness, tear factor and tearness were observed in comparison to the conventional chemical bleaching.     

枯草芽孢杆菌内切木聚糖酶的分离纯化与鉴定

目的：建立一种简便、快速的木聚糖酶分离和提取方法。方法：采用活性聚丙烯酰胺凝胶电泳和均质提取法相结合,分离纯化枯草芽孢杆菌(Bacillus subtilis)固体培养基发酵产物中的木聚糖酶,进一步用薄层色谱和高压液相色谱对木聚糖酶进行鉴定。结果：采用活性聚丙烯酰胺凝胶电泳和均质提取法相结合,从枯草芽孢杆菌(Bacillus subtilis)固体培养基发酵产物中分离得到了两种内切木聚糖酶,酶解桦木木聚糖的产要产物以木二糖和木三糖为主。结论：活性聚丙烯酰胺凝胶电泳和均质提取法相结合是一种新的分离纯化木聚糖酶的简便、有效方法。     

Characterization and biobleaching effect of hemicellulases produced by thermophilic fungi

The culture supernatant of Thermomyces lanuginosus strains MED 2D and MED 4B1 had high activities of xylanase with low inducible activities of -xylosidase. The crude xylanase was optimally active at 70 °C and at pH 6.0 to 6.5. Subsequently Eucalyptus kraft pulp was treated with MED 2D supernatant at 10 IU per gram pulp resulting in a 10.5% reduction in Kappa number. XECEDED-Refined bleached pulp resulted in handsheets with increased brightness compared to the control (X = xylanase treatment; E = alkaline extraction; C = Cl2 treatment; D = ClO2 treatment).     

Xylanase production using inexpensive agricultural wastes and its partial characterization from a halophilic <Emphasis Type="Italic">Chromohalobacter</Emphasis> sp. TPSV 101

A halophilic and alkali-tolerant Chromohalobacter sp. TPSV 101 with an ability to produce extracellular halophilic, alkali-tolerant and moderately thermostable xylanase was isolated from solar salterns. Identification of the bacterium was done based upon biochemical tests and 16S rRNA sequence. The culture conditions for higher xylanase production were optimized with respect to NaCl, pH, temperature, substrates and metal ions and additives. Maximum xylanase production was achieved in the medium with 20% NaCl, pH-9.0 at 40°C supplemented with 1% (w/v) sugarcane bagasse and 0.5% feather hydrolysate as carbon and nitrogen sources. Sugarcane bagasse (250 U/ml) and wheat bran (190 U/ml) were the best inducer of xylanase when used as carbon source as compared to xylan (61 U/ml). The xylanase that was partially purified by protein concentrator had a molecular mass of 15 kDa approximately. The xylanase from Chromohalobacter sp. TPSV 101 was active at pH 9.0 and required 20% NaCl for optimal xylanolytic activity and was active over a broad range of temperature 40–80°C with 65°C as optimum. The early stage hydrolysis products of sugarcane bagasse were xylose and xylobiose, after longer periods of incubation only xylose was detected.