Chemical composition and standardized ileal digestibility of crude protein and amino acid in whole yeast and autolyzed yeast derived from sugarcane ethanol production fed to growing pigs

ObjectiveThis research determined the chemical composition and the apparent and standardized ileal digestibility (AID and SID) of crude protein (CP) and amino acids (AA) in whole yeast and autolyzed yeast derived from sugarcane ethanol production fed to growing pigs.MethodsSix growing pigs were randomly allocated in a replicated 3×3 Latin square design with 3 diets and 3 periods of 7 days each, resulting in a total of 6 experimental replications. Three assay diets were formulated using whole yeast, autolyzed yeast, or soybean meal as the sole sources of dietary CP and AA. Pigs were allowed to adapt to the assay diets for 5 days. Thereafter, ileal digesta samples were collected continuously for 8 hours on days 6 and 7.ResultsThere was no difference in the chemical composition between whole yeast and autolyzed yeast, but whole yeast had low digestibility of CP and AA due to the presence of a rigid cell wall. As conducting autolysis can induce cell wall damage, the AID and SID of CP and AA were greater in autolyzed yeast than in whole yeast.ConclusionThe information obtained on the SID of CP and AA in both yeast products can be used for the accurate estimation of the bioavailability of CP and AA in feed formulations. The yeast products derived from sugarcane ethanol production are an alternative protein source in pig diets.     

Effect of crude protein and phosphorus level on growth performance, bone mineralisation and phosphorus, calcium and nitrogen utilisation in grower-finisher pigs

Two experiments in a 2 x 2 factorial arrangement were conducted to evaluate the effect of crude protein (CP) (130 vs. 200 g/kg) and phosphorus (P) (4.0 vs. 6.0 g total P/kg) level in a phytase supplemented diet (500 FTU [phytase units]/kg) in grower-finisher pigs. Owing to the design of the experiment, as dietary P level increased, there was also an increase in dietary calcium (Ca) level in order to maintain a dietary Ca to P ratio of 1.6:1. In Experiment 1, four diets were fed to 56 pigs (n = 14, initial body weight [BW] 36.7 +/- 4.2 kg) to investigate the interaction between CP and P on growth performance, bone mineralisation and digesta pH. Experiment 2 consisted of 16 entire male pigs (n = 4; offered identical diets to that offered in Experiment 1) for the determination of total tract apparent digestibility and nitrogen (N), P and Ca utilisation. There was an interaction between CP and P level on bone ash, bone P and bone Ca concentrations (p < 0.05). Pigs offered low CP-low P diets had a higher bone ash, P and Ca concentrations than pigs offered high CP-low P diets. However, there was no effect of CP level at high P levels on bone ash, P and Ca concentrations. Pigs offered low P diets had a lower ileal pH compared with pigs offered high P diets (p < 0.05). In conclusion, offering pigs a high CP-low P, phytase-supplemented diet resulted in a decrease in bone mineralisation.     

Determination of standardized ileal crude protein and amino acid digestibilities in protein supplements for piglets

The objective of the study was to determine standardized ileal digestibilities (SID) of crude protein (CP) and amino acids (AA) in six ingredients commonly used in weanling pigs diets. The ingredients consisted of extruded soybeans (SBe), high-protein soybean meal (SBMhp), soy protein concentrate (SPC), hydrolyzed wheat gluten (WGh), conventional fish meal 1 (FM1) and extracted fish meal 2 (FM2e). Each assay feed ingredient was added to a purified cornstarch-based basal diet supplemented with casein and crystalline AA, and SID of CP and AA of assay ingredients were estimated using the difference method. A total of 12 3-week-old barrows were surgically fitted with T-cannulas at the distal ileum. The piglets were allocated to four simultaneous 3 × 3 Latin-square designs with three animals and three periods each, resulting in six observations per assay diet. After 3 to 5 days recovery from surgery, each assay diet was fed at a level of 30 g/kg body weight. Each experimental period consisted of 5 days for adaptation to the assay diets and 2 days for ileal digesta collection. The SID of CP, Lys, Met, Thr and Trp were 73%, 78%, 76%, 66% and 71% in SBe; 80%, 84%, 87%, 75% and 81% in SBMhp; 86%, 89%, 89%, 78% and 83% in SPC; 87%, 60%, 88%, 76% and 79% in WGh; 87%, 92%, 94%, 86% and 86% in FM1; and 79%, 86%, 89%, 80% and 74% in FM2e, respectively. The greatest SID of indispensable AA were observed for FM1 and SPC (SID 85% for most indispensable AA), followed by WGh, FM2e and SBMhp (SID 80% for most indispensable AA) and the smallest SID were obtained for SBe (SID < 80% for most indispensable AA). The SID of CP and indispensable AA in both types of fish meal, SBMhp and WGh were similar to SPC (P = 0.063 to 0.855), except for Arg (P = 0.010) and Lys (P = 0.001) in WGh, and Phe (P = 0.044) and Trp (P = 0.037) in FM2e. The SID of CP and indispensable AA were smaller in SBe compared with SPC (P < 0.001 to P = 0.017), except for Lys (P = 0.136). The SID of CP and indispensable AA were consistently smaller in FM2e compared with FM1 with significant differences for CP (P = 0.035), Phe (P = 0.028) and Trp (P = 0.008). Digestibility values measured in the present study can be used to formulate diets for piglets based on standardized ileal digestible contents of CP and AA.     

Evaluation through literature data on standardized ileal digestibility and basal ileal endogenous loss of amino acids associated with barley in pigs

This meta-analysis aimed to estimate the standardized ileal digestibility (SID) and the basal ileal endogenous amino acid losses (IAA_end) in barley for growing pigs. In total, 38 different barley treatments published in 26 peer-reviewed papers were used for the meta-analysis containing information on dietary composition including amino acid (AA) contents of the assay diets, and (or) barley samples, as well as apparent ileal digestibility (AID) of AA in barley. The SID of AA was determined by either correcting AID of AA for their IAA_end or by regression analysis between the apparent ileal digestible and total dietary AA contents. The SID values obtained by correcting the AID values for their IAA_end amounted to 70%, 77%, 74% and 63% for Lys, Met, Thr and Trp, whereas those based on regression analysis method were 82%, 82%, 69% and 55%, respectively. Estimates of basal ileal endogenous loss of CP in ileal digesta varied considerably and averaged 11.84 g/kg dry matter intake (DMI), whereas IAA_end for indispensable AA ranged from 0.05 g/kg DMI for Trp to 1.90 g/kg DMI for Leu. In most cases, these estimates were considerably higher than previously reported values for IAA_end. The results of the present regression analysis indicate for most AA higher SID values compared with SID of most AA that were obtained by correcting AID values for IAA_end. In view of the observed high variations in IAA_end and the low CP content of the barley samples, estimating SID of AA based on literature data by means of the regression method may improve accuracy of SID coefficients for barley. In contrast, transformation of AID values into their corresponding SID values by using a constant correction factor for IAA_end adds an additional source of error, thereby reducing the precision in estimating SID of AA.     

Apparent protein digestibility and recovery of endogenous nitrogen at the terminal ileum of pigs fed diets containing various soyabean products, peas or rapeseed hulls

Effects of the use of three different soyabean products (soya concentrate and two different soyabean meals), peas or rapeseed hulls in the diet on the apparent ileal digestibility of CP (N × 6.25) and recovery of ileal endogenous nitrogen (N) in weanling pigs were investigated. Ileal endogenous N was measured using the ¹⁵N-isotope dilution method. Thirteen castrated male pigs (BW of 12–23 kg) were fed maize starch-based diets containing either soya concentrate (SC), purified rapeseed hulls (pRH) and SC (SRH diet), soyabean meal (SBM), a mixture of toasted and untoasted soyabean meal (mSBM) or peas. The apparent ileal digestibility (AID) of dry matter (DM) for the SC, SRH, SBM, mSBM and pea diets was 82.1, 74.3, 83.3, 80.0 and 74.9% (P < 0.05), respectively. The AID of CP for these diets was 82.4, 67.6, 81.6, 68.0 and 76.9% (P < 0.05), respectively. Similar differences in the AID for amino acids (AA) in the diets were found. The AID for CP and for the sum of AA in the pRH, as calculated by the difference between the SC and SRH diet, were 26 and 41%, respectively. For the SC, SRH, SBM, mSBM and pea diet, ileal recovery (g/kg of DM intake) for endogenous N were 2.79, 3.46, 2.73, 4.89 and 3.29 (P < 0.05), respectively, and for dietary N 1.16, 4.11, 1.64, 4.15 and 2.53 (P < 0.05), respectively. For the SC, SBM and mSBM diets, differences in AID of CP and AA were associated with differences in both the ileal recovery of endogenous N and the recovery of undigested dietary N. Differences in trypsin inhibitor activity (TIA) of the soya products were likely associated with these observations. It was also concluded that fibre (Neutral Detergent Fibre; NDF) in pea could be at least in part responsible for the relatively low AID of CP and AA and the high recovery of ileal endogenous N in the pea diet. The low AID of CP and AA of pRH was likely related to the association of protein to the fibre matrix in the fibre-rich rapeseed hulls.     

Dietary supplementation with Chinese herbal powder enhances ileal digestibilities and serum concentrations of amino acids in young pigs

This study was designed to determine the effect of ultra-fine Chinese herbal powder as a dietary additive on serum concentrations and apparent ileal digestibilities (AID) of amino acids (AA) in young pigs. In Experiment 1, 60 Duroc x Landrace x Yorkshire piglets weaned at 21 days of age were randomly assigned to one of three treatments, representing supplementation with 0 or 2 g/kg of the powder, or 0.2 g/kg of colistin (an antibiotic) to corn- and soybean meal-based diets (n = 20 per group). Blood samples from five piglets per group were collected on days 7, 14, and 28 to determine serum AA concentrations. In Experiment 2, 12 barrows with an average initial body weight of 7.64 kg were randomly assigned to one of the three dietary treatments, followed by surgical placement of a simple T-cannula at the terminal ileum. All of the diets contained 0.1% titanium oxide as a digestibility marker. The samples of terminal ileal digesta were collected on day 7 for determining AID of AA. Results show that dietary supplementation with the herbal powder increased (P < 0.05) serum concentrations and AID of most AA by 10-50% and 10-16%, respectively. As an indicator of improved intestinal function, AID values of calcium were also enhanced in piglets supplemented with the herbal powder. Dietary supplementation of colistin increased serum concentrations and AID values of some AA by 8-44% and 10-15%, respectively, in comparison with the non-supplemented group. These novel findings demonstrate that the herbal powder can enhance the digestibility of dietary protein and the intestinal absorption of AA into the systemic circulation in post-weaning pigs, therefore providing a new mechanism for its growth- and immunity-promoting efficacy.     

Effect of crude protein concentration and sugar-beet pulp on nutrient digestibility, nitrogen excretion, intestinal fermentation and manure ammonia and odour emissions from finisher pigs

A 2 × 2 factorial experiment was conducted to investigate the interaction between high and low dietary crude protein (CP) (200 v. 150 g/kg) and sugar-beet pulp (SBP) (200 v. 0 g/kg) on nutrient digestibility, nitrogen (N) excretion, intestinal fermentation and manure ammonia and odour emissions from 24 boars (n = 6, 74.0 kg live weight). The diets were formulated to contain similar concentrations of digestible energy (13.6 MJ/kg) and lysine (10.0 g/kg). Pigs offered SBP-containing diets had a reduced (P < 0.05) digestibility of dry matter, ash, N, gross energy and an increased (P < 0.001) digestibility of neutral-detergent fibre compared with pigs offered diets containing no SBP. There was an interaction between CP and SBP on urinary N excretion and the urine : faeces N ratio. Pigs offered the 200 g/kg CP SBP-based diet had reduced urine : faeces N ratio (P < 0.05) and urinary N excretion (P < 0.05) compared with those offered the 200 g/kg CP diet without SBP. However, there was no effect of SBP in pigs offered 150 g/kg CP diets. Manure ammonia emissions were reduced by 33% from 0 to 240 h (P < 0.01); however, odour emissions were increased by 41% (P < 0.05) when pigs were offered SBP diets. Decreasing dietary CP to 150 g/kg reduced total N excretion (P < 0.001) and ammonia emissions from 0 to 240 h (P < 0.05). There was an interaction between dietary CP and SBP on branched-chain fatty acids (P < 0.001) in caecal digesta. Pigs offered the 200 g/kg CP SBP-containing diet reduced branched-chain fatty acids in the caecum compared with pigs offered the 200 g/kg CP diet containing no SBP. However, there was no effect of SBP in the 150 g/kg CP diet. In conclusion, pigs offered SBP-containing diets had a reduced manure ammonia emissions and increased odour emissions compared with diets containing no SBP. Pigs offered the 200 g/kg CP SBP-containing diet had a reduced urine : faeces N ratio and urinary N excretion compared with those offered the 200 g/kg CP diet containing no SBP.     

Ileal amino acids digestibility of sorghum in weaned piglets and growing pigs

The objective of the study was to determine the coefficients of ileal apparent digestibility (CIAD) of sorghum protein and amino acids (AA) in weaned piglets and growing pigs. Digestibility coefficients were estimated using the regression and difference methods for the weaned piglets; and the direct and difference methods for the growing pigs. To test the hypothesis that CP and AA digestibility of sorghum is lower in weaned piglets than in growing pigs, two experiments were conducted. In experiment one, 20 weaned piglets were fitted with a 'T' cannula at 21 days of age and were fed for 2 weeks one of five dietary treatments: a reference or control diet providing 200 g of CP/kg from casein (C) as the sole protein source, and four casein-sorghum (C-S) diets kept isoproteic to C by the appropriate adjustment of C and maize starch proportions; the amount of sorghum (S) in these diets was 135, 307, 460 and 614 g/kg. In experiment 2, fifteen castrated pigs weighing 57.8 ± 2.8 kg were used and randomly allotted to one of three dietary treatments: a reference casein-maize starch diet containing C as the sole protein source, a C-S diet, both diets containing 160 g of CP/kg, and a fortified S diet containing 68 g of CP/kg. In piglets the CIAD for CP and AA decreased linearly (P < 0.05) as the amount of S in the diet increased. The average ileal digestibility of AA from C was 0.858 ± 0.111, and decreased to 0.663 ± 0.191 at the higher S level. The CIAD estimated using the regression or difference methods were similar for leucine, cysteine, glutamic acid, serine, alanine and tyrosine, and different for the other AA. In growing pigs the CIAD of protein and AA (except alanine and cysteine) were similar (P > 0.05) for the C and the C-S diets, but higher (P < 0.05) than those for the S diet. The CIAD for S obtained by the difference method were higher (P < 0.05) than those obtained using the direct method, except for lysine, isoleucine, valine, methionine, threonine and cysteine. The results indicate that except for lysine and cysteine, growing pigs' ability to digest AA and protein is superior than weaned piglets.     

Effect of crude protein and phosphorus level on growth performance,bone mineralisation and phosphorus,calcium and nitrogen utilisation in grower-finisher pigs

Two experiments in a 2?×?2 factorial arrangement were conducted to evaluate the effect of crude protein (CP) (130 vs. 200 g/kg) and phosphorus (P) (4.0 vs. 6.0 g total P/kg) level in a phytase supplemented diet (500 FTU [phytase units]/kg) in grower-finisher pigs. Owing to the design of the experiment, as dietary P level increased, there was also an increase in dietary calcium (Ca) level in order to maintain a dietary Ca to P ratio of 1.6:1. In Experiment 1, four diets were fed to 56 pigs (n?=?14, initial body weight [BW] 36.7?±?4.2 kg) to investigate the interaction between CP and P on growth performance, bone mineralisation and digesta pH. Experiment 2 consisted of 16 entire male pigs (n?=?4; offered identical diets to that offered in Experiment 1) for the determination of total tract apparent digestibility and nitrogen (N), P and Ca utilisation. There was an interaction between CP and P level on bone ash, bone P and bone Ca concentrations (p?<?0.05). Pigs offered low CP–low P diets had a higher bone ash, P and Ca concentrations than pigs offered high CP–low P diets. However, there was no effect of CP level at high P levels on bone ash, P and Ca concentrations. Pigs offered low P diets had a lower ileal pH compared with pigs offered high P diets (p?<?0.05). In conclusion, offering pigs a high CP–low P, phytase-supplemented diet resulted in a decrease in bone mineralisation.     

Effects of feeding low protein diets to piglets on plasma urea nitrogen, faecal ammonia nitrogen, the incidence of diarrhoea and performance after weaning

This study evaluated the effects of feeding pigs low protein (LP) diets for different lengths of time after weaning on indices of protein fermentation, the incidence of postweaning diarrhoea (PWD), growth performance, and total-tract apparent digestibility. Sixty weaner pigs weighing 6.1 +/- 0.13 kg (mean +/- SEM) were used in a completely randomised design having five treatments: (i) a high protein diet (HP, 243 g/kg CP) fed for 14 d after weaning (HP14); (ii) a low protein diet (LP, 173 g CP/kg) fed for 5 d after weaning (LP5); (iii) LP diet fed for 7 d after weaning (LP7); (iv) LP diet fed for 10 d after weaning (LP10), and (v) LP diet fed for 14 d after weaning (LP14). All diets were supplemented with lysine, methionine, tryptophan and threonine, with all LP diets additionally fortified with crystalline isoleucine and valine to conform to a proposed ideal amino acid (AA) pattern. A second-stage diet (215 g CP/kg) was fed to pigs at the conclusion of each treatment. None of the diets contained antimicrobial compounds. Feeding a LP diet, regardless of duration of feeding, decreased plasma urea nitrogen (p < 0.001) and faecal ammonia-nitrogen (p < 0.001) contents. Feeding a LP diet, irrespective of feeding duration, decreased the incidence of PWD at day 8 after weaning (p = 0.044), and pigs fed diets LP7, LP010 and LP14 had firmer faeces (p = 0.030, p = 0.047 and p = 0.007, respectively) between days 10 and 12 after weaning. Treatments LP5, LP7, LP10 and LP14 did not reduce (p > 0.05) growth performance up to 106 days after weaning compared to pigs fed the HP diet. Total-tract apparent digestibility of dry matter, energy and crude protein were similar (p > 0.05) between treatments. Our data suggest that feeding a LP diet, supplemented with AA to conform to an ideal AA pattern, for 7-10 days after weaning can reduce PWD in pigs fed antibiotic-free diets without compromising production.     

Effects of dietary sulfur amino acids and crude protein on the performance of finishing broilers

The effects of different combinations of dietary methionine+cystine (Met+Cys) and dietary crude protein (CP) in finishing broilers were investigated in two growth studies. In Exp. 1, male broilers 29 to 42 days of age were fed 18 diets containing 16.9%, 18.7%, or 20.4% CP with six levels of Met+Cys within each protein level. Similarly, in Exp. 2 another 12 diets containing either 18.0 or 21.5% CP were fed to male broilers 29 to 48 days of age.

In general, the Met+Cys requirement for optimum feed conversion was higher than for maximum growth. In both experiments, between 0.80% and 0.85% methionine+cystine optimized feed conversion. These dietary levels were valid for a 13.05 MJ ME/kg diet fed to broilers growing from 1.2 kg to 2.2 kg (Exp. 1), or for a 13.60 MJ ME/kg diet fed to broilers growing from 1.3 kg to 3.0 kg (Exp. 2).

The Met+Cys requirement was not consistently affected by the dietary CP content in Exp. 1. In Exp. 2, increasing dietary CP from 18.0% to 21.5% tended to increase the Met+Cys requirement for optimum feed conversion.

A dietary CP level of 18.0% to 18.7% supported performance and carcass fat deposition equal to diets containing 20.4% or 21.5% CP, respectively, when the sulfur amino acid content was adequate.     

Effects of dietary crude protein level on odour from pig manure

The objective of this study was to determine the effects of dietary crude protein (CP) level on odour emission, odour intensity, hedonic tone, and ammonia emission from pig manure and on manure composition (pH, total nitrogen, ammonium, volatile fatty acids, indolic, phenolic and sulphur-containing compounds). An experiment was conducted with growing pigs (n = 18) in a randomised complete-block design with three treatments in six blocks. Treatment groups were 12%, 15% and 18% CP diets. Barley was exchanged for soya-bean meal. Crystalline amino acids (AA) were included in the 12% CP diet up to the level of pigs' requirement; the same amount of AA was added to the 15% and 18% CP diets. Pigs with an initial body weight (BW) of 36.5 ± 3.4 kg (mean ± s.d.) were individually penned in partly slatted floor pens and offered a daily feed allowance of 2.8 × maintenance requirement for net energy (NE: 293 kJ/kg BW^0.75). Feed was mixed with water, 1/2.5 (w/w). Faeces and urine of each pig were accumulated together in a separate manure pit under the slatted floor. After an adaptation period of 2 weeks, the manure pits were cleaned and manure was collected. In the 5th week of the collection period, air samples for odour and ammonia analyses, and manure samples were collected directly from each manure pit. Air samples were analysed for odour concentration and for hedonic value and intensity above odour detection threshold. Manure samples were analysed for volatile fatty acids, and indolic, phenolic and sulphurous compounds, ammonium and total nitrogen concentrations. Reducing dietary CP from 18% to 12% lowered odour emission ( P < 0.05) and ammonia emission ( P = 0.01) from pig manure by 80% and 53%, respectively. Reduced dietary CP decreased total nitrogen, methyl sulphide, carbon disulphide, ethanethiol, phenol, 4-ethyl phenol, indole and 3-methyl indole concentrations in the manure ( P < 0.05). Volatile fatty acids and cresols concentrations in the manure of pigs fed different dietary CP levels were similar. A reduction of dietary CP and at the same time providing essential AA is an option to reduce odour emission as well as ammonia emission from pig manure.     

The effect of high and low dietary crude protein and inulin supplementation on nutrient digestibility, nitrogen excretion, intestinal microflora and manure ammonia emissions from finisher pigs

A 2 × 2 factorial experiment was performed to investigate the interaction between a high- and low-crude-protein (CP) diet (200 v. 140 g/kg) and inulin supplementation (0 v. 12.5 g/kg) on nutrient digestibility, nitrogen (N) excretion, intestinal microflora, volatile fatty acid (VFA) concentration and manure ammonia emissions from 24 boars (n = 6, 74.0 kg live weight). The diets were formulated to contain similar concentrations of digestible energy and lysine. Pigs offered the high-CP diets had a higher excretion of urinary N (P < 0.001), faecal N (P < 0.01) and total N (P < 0.001) than the pigs offered the low-CP diets. Inulin supplementation increased faecal N excretion (P < 0.05) and decreased the urine N : faeces N ratio (P < 0.05) compared with the inulin-free diets. There was no effect (P > 0.05) of dietary treatment on N retention. There was an interaction (P < 0.05) between dietary CP concentration and inulin supplementation on caecal Enterobacteria spp. Pigs offered the diet containing 200 g/kg of CP plus inulin decreased the population of Enterobacteria spp. compared to those with the inulin-supplemented 140 g/kg CP diet. However, CP level had no significant effect on the population of Enterobacteria spp. in the unsupplemented diets. Inulin supplementation increased caecal Bifidobacteria (P < 0.01) compared with the inulin-free diets. There was no effect of inulin supplementation on VFA concentration or intestinal pH (P > 0.05). Pigs offered the 200 g/kg CP diets had higher (P < 0.05) manure ammonia emissions from 0 to 240 h of storage than pigs offered the 140 g/kg CP. In conclusion, inulin supplementation resulted in an increase in Bifidobacteria concentration and a reduction in Enterobacteria spp. at the high CP level indicating that inulin has the ability to beneficially manipulate gut microflora in a proteolytic environment.     

Effect of low-protein amino acid-supplemented diets on the growth performance, gut morphology, organ weights and digesta characteristics of weaned pigs

A 21-day study was conducted to determine whether isoleucine might limit the performance of piglets fed low-crude protein (CP), amino acid (AA)-supplemented diets and to investigate the potential benefits of low-CP diets on gastrointestinal health in weaned pigs. Ninety-six piglets (initial BW = 6.44 ± 0.14 kg), housed four per pen, were randomly assigned to one of four diets, resulting in six replicate pens per diet. Dietary treatments were as follows: (1) 210 g/kg CP diet, (2) 190 g/kg CP diet deficient in isoleucine, (3) 190 g/kg CP diet supplemented with crystalline isoleucine up to the level in the 210 g/kg CP diet and (4) 170 g/kg CP diet supplemented with isoleucine and valine on the ideal protein ratio basis (60% and 70% relative to lysine, respectively). Pigs were allowed to adapt to the new environment for 4 days before the experiment commenced. Overall, pigs fed the 210 g/kg CP diet had higher (P < 0.05) average daily gain and lower (P < 0.05) feed : gain ratio compared with those fed the other diets. The faecal consistency score of pigs fed the 210 g/kg CP diet was higher (P < 0.05) than those fed the other diets. Pigs fed the 170 g/kg diet had lower (P=0.02) small intestine weight than those fed the 210 g/kg CP diet. Pigs fed the 210 g/kg CP diet had deeper (P < 0.05) crypt in the duodenum and ileum and higher (P < 0.05) ammonia N concentration in caecal digesta than those fed the other diets. There were no effects of diet on microbial population and volatile fatty acid concentration in the caecal digesta except for propionic acid whose concentration was higher (P < 0.05) for pigs fed the 170 g/kg diet than those fed the 190+isoleucine and the 210 g/kg CP diets. The results indicate that the low-CP, AA-supplemented diet reduced crypt hypertrophy, ammonia N concentration in the caecal digesta, small intestine weight and the performance of piglets. Also, the results of the current study were inconclusive with respect to whether isoleucine may limit the performance of pigs fed a low-CP, AA-supplemented diet.     

Effect of dietary crude protein levels in a commercial range, on the nitrogen balance, ammonia emission and pollutant characteristics of slurry in fattening pigs

An experiment was conducted to investigate the effect of dietary levels of crude protein (CP), close to the range used commercially and to the European Commission recommended values, on the nitrogen (N) balance, ammonia (NH(3)) emission and pollutant characteristics of the slurry from growing and finishing pigs. Three feeding programmes with different CP levels were compared during the growing and the finishing periods of fattening. Diets were formulated to be isoenergetic and for the digestible lysine : metabolisable energy ratio to be similar in all the diets for each phase, but differed in CP concentration (160, 150 and 140 g CP/kg for the growing phase and 155, 145 and 135 g CP/kg for the finishing phase). Faeces and urine from barrows (eight replicates per diet) allocated in metabolism cages were collected separately for 5 days to calculate the N balance and for 2 days to measure NH(3) emission in a laboratory system for 240 h. Excreta were analysed for pH, volatile fatty acids (VFA), total N, electrical conductivity (EC), total solids (TS), volatile solids (VS), biochemical oxygen demand (BOD(5)), chemical oxygen demand (COD) and NH(4)-N reduction of dietary CP content led to a linear decrease of urinary (P < 0.05) and total (P < 0.05) N excretion, and N excretion/feed intake (P < 0.001). The emission of NH3 was similar in all diets (P > 0.05) during the 240 h of study. However, in the growing phase, the NH(3)-N level in slurry was lower (P < 0.05) for the low-CP diet. In addition, the CP level had no significant effect (P > 0.05) on total VFA, EC, TS, VS, COD or BOD(5) contents of excreta. These parameters were higher (P < 0.05) in slurry from the finishing phase than from the growing phase. However, NH(4)-N in the slurry decreased (P < 0.05) by 20.3% and 28.4% when the CP level was decreased by 9.30 or 21.40 g/kg, respectively. It is concluded that lowering dietary CP levels even by small amounts and using CP levels close to these used in commercial diets and close to the European Commission recommended values will decrease urinary and total N excretion in the slurry of growing-finishing pigs. The slurry from finishing pigs is more concentrated than that from growing pigs.     

Endogenous ileal losses of nitrogen and amino acids in pigs and piglets fed graded levels of casein

In order to determine ileal losses of nitrogen (N) and amino acids (AA) and the coefficients of apparent and true ileal digestibility (AID, TID) of N and AA from casein in piglets and pigs, two experiments were conducted. In Experiment 1, 24 piglets were used. The piglets were weaned at 17 days of age, weighing 6.4 kg and cannulated at terminal ileum. Ileal digesta was collected at 28-29 and 35-36 days of age in period 1 and 2, respectively. Feed intake was 150 and 300 g x d(-1) during the first and second period. In Experiment 2, 16 castrates weighing 52.5 kg and cannulated at terminal ileum were used. The intake level of digestible energy was 2.5 times their maintenance requirement. The experiment lasted 7 days and ileal digesta was collected on day 6-7. Treatments consisted of four levels of N from casein: 8, 16, 24 and 32 g N x kg(-1) feed, respectively. Results showed that N level did not increase N or AA ileal losses. In piglets, N and AA ileal losses were similar between periods, except for period 2, where losses per kg DMI were about 47 and 64% higher for glycine and proline, respectively (p < 0.05). When ileal losses from pigs and piglets were compared, piglets had higher (p < 0.05) ileal losses of N and AA (excepted glutamic acid and alanine). A lower (p < 0.05) AID was observed in piglets in period 2 for N, methionine, glutamic acid, glycine and proline. With exception of glycine in pigs, all values for TID of N and AA of casein were superior to 0.90. Piglets had higher TID of N, leucine, isoleucine, valine and phenylalanine. These results showed that piglets have higher ileal losses than pigs.     

Effects of keratinase supplementation of corn-soybean meal based diets on apparent ileal amino acid digestibility in growing pigs and serum amino acids, cytokines, immunoglobulin levels and loin muscle area in nursery pigs

Two experiments were conducted to evaluate effects of keratinase for growing and nursery pigs. In Exp. 1, six pigs (32.3 +/- 2.8 kg body weight), fitted with a simple T-cannula at the distal ileum, were assigned to one of two 3 x 3 Latin squares involving three periods and three diets including a basal diet and the same diets supplemented with 0, 0.05 or 0.1% keratinase. Dietary keratinase supplementation increased the apparent ileal digestibility of crude protein (CP), arginine, histidine, isoleucine, leucine, lysine, methionine, phenylalanine, threonine, tryptophan, alanine, glutamic acid and proline (p < 0.05). Digestibility coefficients did not differ between pigs fed 0.05 and 0.1% keratinase. In Exp. 2, 24 piglets weaned at 30 +/- 2 d of age were used in a 2 x 2 factorial design experiment with two CP concentrations (19 vs. 22%) and two levels of keratinase supplementation (0 vs. 0.05%). Keratinase supplementation increased (p < 0.05) average daily gain, serum arginine concentration and loin muscle area but decreased (p < 0.05) serum interleukin-10 concentrations. The reduction in dietary CP level decreased (p < 0.05) serum urea nitrogen concentrations, isoleucine, serine and proline concentrations, but increased serum arginine concentrations. Few interactions between keratinase supplementation and dietary CP concentration were observed. This study indicated that dietary keratinase supplementation improved apparent ileal amino acid digestibility for growing pigs and had a positive effect on weight gain, immune response and loin muscle area for nursery pigs.     

Low protein diets without medicinal zinc oxide for weaned pigs reduced diarrhea treatments and average daily gain

The use of medicinal zinc oxide (ZnO) in post-weaning diets must be phased out in the European Union by 2022, resulting in urgent needs for alternative strategies to prevent diarrhea in pigs. The objective of this study was to test the effect of four different dietary protein strategies with different amino acid profiles on diarrhea frequency and pig performance as alternative diet plans when medicinal ZnO was will be excluded from the diet. A total of 6 800 Duroc x (Danish Landrace x Yorkshire) pigs, weaned around 28 days of age, were randomly assigned by sex and size to six dietary treatments. The treatments were; standard CP levels (191, 184, 184 g/kg CP) and allocated 2 500 ppm ZnO in phase 1 (PC = positive control), standard CP levels (191, 184, 184 g/kg CP) and no added ZnO in phase 1 (NC = negative control), CP levels of 166, 184, 184 g/kg (LSS = low-standard-standard), CP levels of 166, 162, 192 g/kg (LLH = low-low-high), CP levels of 140, 193, 192 g/kg (VHH = very low-high-high), and lastly 140, 174, 192 g/kg CP levels (VMH = very low-medium-high). The pigs entered the trial at ~ 7 kg BW and exited at ~ 30 kg BW. As expected, the PC treatment resulted in 42% fewer diarrhea pen treatments in the total trial period compared to the NC group (P < 0.05), whereas both PC and LLH had fewer diarrhea treatment days per pig compared to NC pigs (P < 0.05). Additionally, at the point of treatment, the NC pens had 33% fecal floor samples positive for pathogens, compared to 80% samples positive for pathogens in the PC pens. This suggests that ZnO has a particular positive effect on non-infectious diarrhea without bacterial involvement. A reduction in dietary CP levels in phase 1 led to a reduced average daily gain (ADG) in LLH and VMH pigs and a poorer feed conversion ratio (FCR) in VHH pigs during the overall study period compared to the NC pigs (P < 0.05). Conclusively, a diet with low CP levels from weaning to about 15 kg BW had a reducing effect on diarrhea, but decreased ADG without affecting the FCR.     

Evaluating standardized ileal digestibility of amino acids in growing pigs

The ileal digestibility coefficient (CSID) of amino acids (AA) and crude protein (CP) in 40 feedstuffs for growing pigs were determined with the protein-free (PF) and enzyme-hydrolyzed casein (EHC) methods. The 40 feedstuffs that were used earlier were 10 samples of cereals and cereal by-products, 12 samples of legumes, 6 samples of animal protein feedstuff and 12 samples of oil seed meals. Six growing pigs (initial body weight of 35 ± 1.5 kg), fitted with T-cannula at the terminal ileum, were randomly allocated to either a PF or a EHC diet according to a crossover design during two ileal digesta collection periods. In each period, pigs were adjusted to the experimental diets for 5 days. On days 6 and 8, ileal digesta were collected continuously for 24 h to determine ileal endogenous AA and CP losses. Pigs fed the EHC diet had a higher ileal flow of endogenous CP and of most of AA (P<0.05) than pigs fed the PF diet. Among the ileal endogenous AA flows (g/kg dry matter intake for pigs), methionine excretion was the lowest in pigs (0.09 and 0.25 g/kg dry matter intake) fed the PF and EHC diet, respectively, whereas glutamate (1.83 g/kg dry matter intake) and proline (1.22 g/kg dry material intake) excretion were the highest in pigs fed the EHC and the PF diet, respectively. Endogenous losses of CP and AA determined in the current study and previously published data on apparent ileal digestibility [Yin, Y.L., Huang, R.L., Zhong, H.Y., Chen, C.M., Li, T.J., Pan, Y.F., 1993. Nutritive value of feedstuffs and diets for pigs: 1. Chemical composition, apparent ileal and fecal digestibilities. Anim. Feed Sci. Technol. 44, 1–27] were used to calculate CSID coefficients. For most cereals and cereal by-products, the CSID coefficients of CP determined by the EHC method were higher than those determined by the PF method. Arginine, lysine, methionine, threonine, valine, alanine, aspartate, glutamate, glycine, proline and serine in some cereals and cereal by-products; methionine, valine, alanine and proline in some legumes; and methionine, alaline and proline in some oilseed meals had higher CSID determined by the EHC method than the PF method indicating that there are methodological differences when evaluating the CSID of feed ingredients.     

Determination of Apparent Ileal Amino Acid Digestibility in Rapeseed Meal and Cake Processed at Different Temperatures Using the Direct and Difference Method with Growing Pigs

Studies were conducted with ten barrows, average initial body weight 34.5 ± 2.1kg, fitted with a T-cannula at the distal ileum, to study the accuracy of determination of the apparent ileal digestibility (AID) values of crude protein (CP) and amino acids (AA) in rapeseed meal and cake and the effects of processing, using the difference method. Five corn starch-based diets in the studies were formulated to contain 17.7% CP and based on soybean meal, prepress-extraction rapeseed meal, prepress-extraction rapeseed meal plus soybean meal, high-temperature press rapeseed cake plus soybean meal, or low-temperature press rapeseed cake plus soybean meal as the sole source of dietary protein. The design was an incomplete Latin Square involving two three-week periods and five-treatments. It was found that the AID values of CP and most AA determined with the difference or direct method were significantly lower in rapeseed meal or cakes than soybean meal. The AID values of CP and most AA in prepress-extraction rapeseed meal, high-temperature press or low-temperature cakes determined with the difference method were no difference from those in prepress-extraction rapeseed meal determined with the direct method. The AID values of CP and AA in rapeseed meal and cake determined with the difference method were accurate, when the contribution of CP and AA from rapeseed was more than 50%. The AID values of CP and AA (especially lysine) were lower in the high-temperature press rapeseed cake than in the low-temperature press cake or the prepress-extraction meal.