Screening of <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis> wine strains for the production of acetic acid

In this study 80 wine strains of Saccharomyces cerevisiae were characterized for the production of acetic acid. A significant variability in the production levels was determined among the strains, which produced from a few mg/l to more than 1 g/l. Fifteen strains, differing in acetic acid production, were tested in fermentation of grape musts of different varieties (Aglianico Basilicata, Aglianico Apulia, Cannonau, Bombino nero, Nero d'Avola, Vermentino, Fiano). The results emphasized a great strain variability, but the best strain behaviour was strictly related to the must composition, which is a determinant factor on the expression of the best strain potentiality. Therefore, this study, confirming the high/low production of acetic acid as a strain characteristic, demonstrated also that the inoculated fermentation becomes more advantageous when the starter culture is chosen in relation to the interaction of yeast strain/vine variety.     

Influence of the curing of the killer phenotype inSaccharomyces cerevisiae wine strains on their fermentative behaviour

Fermentative behaviour and cell growth have been studied in grape juice inoculated either with two killerSaccharomyces cerevisiae wild strains or with their Acridine Orange-cured isogenic counterparts. The number of viable cells/ml at the beginning of the fermentation, as well as during exponential growth, were higher in grape juices inoculated with the cured strains. The CO₂ production, fermentative rate and ethanol and acetic acid production were also higher in the cured strains, particularly during the stage of active fermentation. These differences, however, were minimal at the end of the fermentations.     

Metabolic diversity of Saccharomyces cerevisiae strains from spontaneously fermented grape musts

One hundred and fifteen Saccharomyces cerevisiae strains from Aglianico del Vulture, a red wine produced in Southern Italy, were characterized for the production of some secondary compounds involved in the aroma and taste of alcoholic beverages. The strains exhibited a uniform behaviour in the production levels of n-propanol, active amyl alcohol and ethyl acetate, whereas isobutanol, isoamyl alcohol and acetaldehyde were formed with a wide variability. Only five strains produced wines close to the reference Aglianico del Vulture wine for the traits considered. Of these, two strains were selected, underwent to tetrad analysis and the single spore cultures were tested in grape must fermentation. The progeny of one strain showed a significant metabolic variability, confirming the necessity to test starter cultures for the segregation of traits of technological interest. Our findings suggest the selection of specific strains for specific fermentations as a function of the vine variety characteristics in order to take the major advantage from the combination grape must/S. cerevisiae strain.     

Cell-recycle batch fermentation using immobilized cells of flocculent Saccharomyces cerevisiae wine strains

Five, highly flocculeng strains of Saccharomyces cerevisiae, isolated from wine, were immobilized in calcium alginate beads to optimize primary must fermentation. Three cell-recycle batch fermentations (CRBF) of grape musts were performed with the biocatalyst and the results compared with those obtained with free cells. During the CRBF process, the entrapped strains showed some variability in the formation of secondary products of fermentation, particularly acetic acid and acetaldehyde. Recycling beads of immobilized flocculent cells is a good approach in the development and application of the CRBF system in the wine industry.     

Biodiversity of wild strains of <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis> as tool to complement and optimize wine quality

The principal agent in winemaking is the yeast Saccharomyces cerevisiae, which is characterized by a significant strain biodiversity. Here we report the characterization of 80 wild S. cerevisiae strains, isolated from grapes of different varieties in southern Italy, for genetic and technological variability. By PCR amplification with M13 primer a significant polymorphism was recorded and 12 different biotypes were identified among the strains. The specific strain-pattern could be used to follow the dynamics of different biotypes during the fermentation process. The analysis of experimental wines obtained by inoculated fermentations with the 80 strains showed significant differences among the wines. The level of each compound was a function of the strain performing the fermentative process. The main variables for the strain differentiation were the production of acetaldehyde and acetic acid, which ranged from 53 to 282 mg/l and from 0.20 to 1.88 g/l, respectively. Selected strains were tested in fermentation with two different grape musts, yielding experimental wines differing in the levels of secondary compounds and polyphenol content, in function of the interaction “grape must composition/yeast strain”. This finding has an applicative value for the potentiality of utilizing the resource of strain variability as a tool to individuate suitable starter cultures, which are able to complement and optimize grape quality.     

Fermentation behaviour and volatile compound production by agave and grape must yeasts in high sugar Agave tequilana and grape must fermentations

Few studies have been performed on the characterization of yeasts involved in the production of agave distilled beverages and their individual fermentation properties. In this study, a comparison and evaluation of yeasts of different origins in the tequila and wine industries were carried out for technological traits. Fermentations were carried out in high (300 g l⁻¹) and low (30 g l⁻¹) sugar concentrations of Agave tequilana juice, in musts obtained from Fiano (white) and Aglianico (red) grapes and in YPD medium (with 270 g l⁻¹ of glucose added) as a control. Grape yeasts exhibited a reduced performance in high-sugar agave fermentation, while both agave and grape yeasts showed similar fermentation behaviour in grape musts. Production levels of volatile compounds by grape and agave yeasts differed in both fermentations.     

Metabolic characterization of Kloeckera apiculata strains from star fruit fermentation

A total of 37 strains of Kloeckera apiculata was isolated during the spontaneous fermentation of star fruit must. Each strain was differentiated from the others on the basis of its capacity to produce acetaldehyde, ethyl acetate, higher alcohols, acetoin and acetic acid. All the strains were characterized by the low production of higher alcohols and the high production of ethyl acetate, whereas consistent differences in the production of acetaldehyde, acetoin and acetic acid served to differentiate star fruit apiculate strains into six different phenotypes, present at different stages of the fermentation process. The metabolic strain diversity found can be interpreted as a natural consequence of environmental conditions, which influenced the frequency and selection of specific apiculate strains. From the biotechnological point of view the different metabolic biotypes represent an important source of strains for potential use as starter cultures for star fruit fermentation.     

Acetaldehyde production in Saccharomyces cerevisiae wine yeasts

Abstract Eighty-six strains of Saccharomyces cerevisiae were investigated for their ability to produce acetaldehyde in synthetic medium and in grape must. Acetaldehyde production did not differ significantly between the two media, ranging from a few mg/l to about 60 mg/l, and was found to be a strain characteristic. The fermentation temperature of 30°C considerably increased the acetaldehyde produced. This study allowed us to assign the strains to different phenotypes: low, medium and high acetaldehyde producers. The low and high phenotypes differed considerably also in the production of acetic acid, acetoin and higher alcohols and can be useful for studying acetaldehyde production in S. cerevisiae , both from the technological and genetic point of view.     

Influence of Williopsis saturnus yeasts in combination with Saccharomyces cerevisiae on wine fermentation

Aim: To examine the growth and survival of Williopsis saturnus strains along with wine yeast Saccharomyces cerevisiae in grape must. Methods and Results: For this study, fermentations were performed in sterilized grape must at 18°C. Inoculum level was 5 × 10⁶ cells per ml for each yeast. The results showed that W. saturnus yeasts exhibited slight growth and survival depending on the strain, but they died off by day 5. Saccharomyces cerevisiae, however, dominated the fermentation, reaching the population of about 8 log CFU ml^?1. It was observed that ethanol formation was not affected. The concentrations of acetic acid, ethyl acetate and isoamyl acetate were found higher in mixed culture experiments compared to control fermentation. The results also revealed that higher alcohols production was unaffected in general. Conclusion: Fermentations did not form undesirable concentrations of flavour compounds, but production of higher levels of acetic acid in mixed culture fermentations may unfavour the usage of W. saturnus in wine making. Significance and Impact of the Study: This study provides information on the behaviour of W. saturnus together with S. cerevisiae during the alcoholic fermentation.     

The impact of acetate metabolism on yeast fermentative performance and wine quality: reduction of volatile acidity of grape musts and wines

Acetic acid is the main component of the volatile acidity of grape musts and wines. It can be formed as a by-product of alcoholic fermentation or as a product of the metabolism of acetic and lactic acid bacteria, which can metabolize residual sugars to increase volatile acidity. Acetic acid has a negative impact on yeast fermentative performance and affects the quality of certain types of wine when present above a given concentration. In this mini-review, we present an overview of fermentation conditions and grape-must composition favoring acetic acid formation, as well the metabolic pathways leading to its formation and degradation by yeast. The negative effect of acetic acid on the fermentative performance of Saccharomyces cerevisiae will also be covered, including its role as a physiological inducer of apoptosis. Finally, currently available wine deacidification processes and new proposed solutions based on zymological deacidification by select S. cerevisiae strains will be discussed.     

Evolution of Yeasts and Lactic Acid Bacteria During Fermentation and Storage of Bordeaux Wines

The levels of yeasts and lactic acid bacteria that naturally developed during the vinification of two red and two white Bordeaux wines were quantitatively examined. Yeasts of the genera Rhodotorula, Pichia, Candida, and Metschnikowia occurred at low levels in freshly extracted grape musts but died off as soon as fermentation commenced. Kloeckera apiculata (Hanseniaspora uvarum), Torulopsis stellata, and Saccharomyces cerevisiae, the dominant yeasts in musts, proliferated to conduct alcoholic fermentation. K. apiculata and eventually T. stellata died off as fermentation progressed, leaving S. cerevisiae as the dominant yeast until the termination of fermentation by the addition of sulfur dioxide. At least two different strains of S. cerevisiae were involved in the fermentation of one of the red wines. Low levels of lactic acid bacteria (Pediococcus cerevisiae, Leuconostoc mesenteroides, and Lactobacillus spp.) were present in grape musts but died off during alcoholic fermentation. The malolactic fermentation developed in both red wines soon after alcoholic fermentation and correlated with the vigorous growth of at least three different strains of Leuconostoc oenos.     

Assimilable nitrogen utilisation and production of volatile and non-volatile compounds in chemically defined medium by <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis> wine yeasts

Surveys conducted worldwide have shown that a significant proportion of grape musts are suboptimal for yeast nutrients, especially assimilable nitrogen. Nitrogen deficiencies are linked to slow and stuck fermentations and sulphidic off-flavour formation. Nitrogen supplementation of grape musts has become common practice; however, almost no information is available on the effects of nitrogen supplementation on wine flavour. In this study, the effect of ammonium supplementation of a synthetic medium over a wide range of nitrogen values on the production of volatile and non-volatile compounds by two high-nitrogen-demand wine fermentation strains of Saccharomyces cerevisiae was determined. To facilitate this investigation, a simplified chemically defined medium that resembles the nutrient composition of grape juice was used. Analysis of variance revealed that ammonium supplementation had significant effects on the concentration of residual sugar, L-malic acid, acetic acid and glycerol but not the ethanol concentration. While choice of yeast strain significantly affected half of the aroma compounds measured, nitrogen concentrations affected 23 compounds, including medium-chain alcohols and fatty acids and their esters. Principal component analysis showed that branched-chain fatty acids and their esters were associated with low nitrogen concentrations, whereas medium-chain fatty esters and acetic acid were associated with high nitrogen concentrations.     

Impact of different malolactic fermentation inoculation scenarios on Riesling wine aroma

During malolactic fermentation (MLF), lactic acid bacteria influence wine aroma and flavour by the production of volatile metabolites and the modification of aroma compounds derived from grapes and yeasts. The present study investigated the impact of different MLF inoculation strategies with two different Oenococcus oeni strains on cool climate Riesling wines and the volatile wine aroma profile. Four different timings were chosen for inoculation with bacteria to conduct MLF in a Riesling must/wine with a high acidity (pH 2.9–3.1). Treatments with simultaneous inoculation showed a reduced total fermentation time (alcoholic and malolactic) compared to the sequential inoculations. No negative impact of simultaneous alcoholic and malolactic fermentation on fermentation success and on the final wine volatile aroma composition was observed. Compared to sequential inoculation, wines with co-inoculation tended to have higher concentrations of ethyl and acetate esters, including acetic acid phenylethylester, acetic acid 3-methylbutylester, butyric acid ethylester, lactic acid ethylester and succinic acid diethylester. Results of this study provide some alternatives to diversify the number of wine styles by safely conducting MLF in low-pH, cool-climate white musts with potential high alcohol content.     

The vinification of partially dried grapes: a comparative fermentation study of Saccharomyces cerevisiae strains under high sugar stress

AIMS: The study of the fermentation performance of Saccharomyces cerevisiae strains under high sugar stress during the vinification of partially dried grapes. METHODS AND RESULTS: Microvinification of partially dried grape must with sugar concentration of 35 degrees Brix was performed using four commercial strains to carry out alcoholic fermentation. A traditional red vinification without nutrients addition was applied. Yeasts displayed different efficiency to convert sugar in ethanol and varied in glycerol yield. Sugar consumption and ethanol level were attested at 80-87% and 143.5-158.0 g l(-1) respectively. High correlation between sugar and assimilable nitrogen consumption rate was observed. Statistical treatment of data by principal component analysis highlighted the different behaviours that strains exhibited in regard to the production of higher alcohols and other compounds important to wine quality. CONCLUSIONS: Saccharomyces cerevisiae strains displayed appreciable capability to overcome osmotic stress and to yield ethanol fermenting high sugar concentration grape must in winemaking condition. SIGNIFICANCE AND IMPACT OF THE STUDY: The results provided insights on the strain contribution to wine quality subordinate to stress condition. This investigation is of applicative interest for winemaking and processing industry that use high sugar concentration musts.     

Improvement of Nitrogen Assimilation and Fermentation Kinetics under Enological Conditions by Derepression of Alternative Nitrogen-Assimilatory Pathways in an Industrial Saccharomyces cerevisiae Strain

Metabolism of nitrogen compounds by yeasts affects the efficiency of wine fermentation. Ammonium ions, normally present in grape musts, reduce catabolic enzyme levels and transport activities for nonpreferred nitrogen sources. This nitrogen catabolite repression severely impairs the utilization of proline and arginine, both common nitrogen sources in grape juice that require the proline utilization pathway for their assimilation. We attempted to improve fermentation performance by genetic alteration of the regulation of nitrogen-assimilatory pathways in Saccharomyces cerevisiae. One mutant carrying a recessive allele of ure2 was isolated from an industrial S. cerevisiae strain. This mutation strongly deregulated the proline utilization pathway. Fermentation kinetics of this mutant were studied under enological conditions on simulated standard grape juices with various nitrogen levels. Mutant strains produced more biomass and exhibited a higher maximum CO₂ production rate than the wild type. These differences were primarily due to the derepression of amino acid utilization pathways. When low amounts of dissolved oxygen were added, the mutants could assimilate proline. Biomass yield and fermentation rate were consequently increased, and the duration of the fermentation was substantially shortened. S. cerevisiae strains lacking URE2 function could improve alcoholic fermentation of natural media where proline and other poorly assimilated amino acids are the major potential nitrogen source, as is the case for most fruit juices and grape musts.     

Dynamics of the yeast strain population during spontaneous alcoholic fermentation determined by CHEF gel electrophoresis

Wine yeasts were isolated from spontaneous alcoholic fermentations performed with white and red grape musts from vintages 1991 and 1992. Yeast cells were analysed by physiological tests and gel electrophoretic karyotyping. It was shown that there is a succession of different strains in the yeast population during the time course of the fermentation process. Furthermore, the composition of the yeast strain population differs from grape must to grape must and from year to year, and may therefore be considered vineyard (terrain)- and vintage-dependent.     

Contribution of different natural yeasts to the aroma of two alcoholic beverages

The aroma formation in the fermentation of two types of natural musts by 12 different yeasts has been analysed. In grape must fermentation Pichia fermentans Colección Española de Cultivos Tipo (CECT) 11773, Clavispora lusitaniae OJ6 and Pichia anomala OJ5 produced the best balance between concentrations of ethyl acetate and high alcohols. When orange juice was fermented with the 12 yeasts, Pichia fermentans CECT 11773, Rhodotorula mucilaginosa OJ2 and Hanseniaspora uvarum CECT 10885 produced a good beverage with low alcoholic grade. For both types of natural musts Pichia fermentans CECT 11773 increased the presence of higher alcohols and ethyl acetate. After using this strain both alcoholic beverages obtained the highest evaluation in the sensory analysis.     

Development of alcoholic and malolactic fermentations in highly acidic and phenolic apple musts

This work reports the influence of the high acidity and high phenolic content in apple musts on the development of alcoholic and malolactic fermentations and on the final chemical and microbiological composition of the ciders. Four different musts were obtained by pressing several varieties and proportions of cider apples from the Basque Country (Northern Spain). Specially acidic and phenolic varieties were selected. Three musts were obtained in experimental stations and the fourth one, in a cider factory following usual procedures. The evolution of these musts was monitored during five months by measuring 18 parameters throughout eight samplings. In the most acidic of the three experimental musts, yeasts were added to complete the alcoholic fermentation. In the rest of the musts, alcoholic and malolactic fermentations took place spontaneously due to natural microflora and no chemical was added to control these processes. Malolactic fermentation (MLF) finished before alcoholic fermentation in the three tanks obtained in experimental stations, even in the most acidic and phenolic one (pH 3.18, 1.78 g tannic acid/l). After four months, these ciders maintained low levels of lactic acid bacteria (10(4)CFU/ml) and low content of acetic acid (<0.60 g/l). Both fermentations began simultaneously in the must obtained in the cider factory, but MLF finished 10 days after alcoholic fermentation. Subsequently, this must maintained a high population of lactic acid bacteria (>10(6)CFU/ml), causing a higher production of acetic acid (>1.00 g/l) than in the other ciders. These results show the possible advantages of MLF finishing before alcoholic fermentation.     

Isolation and clonal pre-selection of enological Saccharomyces

The aim of the present study was to perform a fast pre-selection from a great number of wine yeasts using a simple phenotypic-based methodology that allows many different strains to be simultaneously tested. A total of 150 elliptic yeasts, isolated from must and wine from black grapes of a distinctive Italian variety, were studied. Yeasts were identified to genus level by assessing their ability to ferment glucose and their production of spores on acetate agar. The Saccharomyces strains were seeded on BiGGY agar to determine their H(2)S production, on calcium carbonate agar to test their acetic acid production, and on grape-skin agar and on grape-seed agar to assess their interaction with phenolic compounds. The Saccharomyces strains were also examined for fermentative vigor after 2 d or 7 d both with and without the addition of 100 mg L(-1) of SO(2) in must at 20 degrees brix and pH 3.20. At the end of fermentation, the wines produced by the 18 best yeasts were analyzed and the strains were studied for additional biochemical and technological characteristics. The resistance of the strains to simultaneous acid-stress and osmotic-stress was studied carrying out in duplicate winemaking tests in must at 30 degrees brix and pH 2.60. A remarkable heterogeneity among the 150 autochthonous yeasts studied was demonstrated. The phenotypical biodiversity is particularly interesting for several technological characteristics useful in winemaking, such as fermentation vigor, acetic acid production and malic acid content of the wines. The vast majority of the elliptic wine yeasts isolated did not show suitable characteristics, so only 18 strains, 12% of the total, remained for the final tests. Many of the strains that had passed the preliminary screenings revealed some defects when they were studied for fermentation performance, both in standard winemaking and under stressors. Two strains exhibited particularly interesting performances: one strain for winemaking of normal musts and the other for winemaking of musts from dried grapes or under stressful conditions.     

A Soil Flavobacterium sp. that Degrades Sulphanilamide and Asulam

Eight strains belonging to Thermobacterium have been isolated from high temperature (between 40° and 43°C) fermenting grape musts. They resemble Lactobacillus acidophilus very closely. Four other thermophilic homofermentative strains are somewhat different: they ferment arabinose and ribose with production of more than 90% of the end product carbon as lactate. This last result involves a metabolic pathway undescribed among lactic acid bacteria.