黄孢原毛平革菌对RBBR脱色降解及其降解机制

为研究白腐真菌对蒽醌染料的生物降解机制,以白腐真菌黄孢原毛平革菌为脱色降解菌株,分析了蒽醌染料活性艳蓝KN-R(RBBR)的浓度、金属离子及脱色参数对染料脱色的影响;采用紫外-可见光谱、红外光谱、气相色谱-质谱(GC-MS)分析和植物种子毒性实验进行降解产物分析,以揭示RBBR可能的降解路径及其产物的毒性结果表明:在p...     

白腐菌对染料脱色和降解作用的研究进展

白腐菌应用于废水处理始于二十世纪八十年代。本文对印染废水的处理方法、白腐菌及其对污染物的降解机理作了简要概述 ,着重介绍了白腐菌对染料脱色和降解作用的研究进展。白腐菌对染料的脱色解降作用机理有部分尚待进一步研究 ;同时 ,白腐菌的吸附作用亦不容忽视。     

白腐菌对染料脱色和降解作用的研究进展

白腐菌应用于废水处理始于二十世纪八十年代,本文对印染废水的处理方法,白腐菌及其对污染物的降解机理作了简要概述,着重介绍了白腐菌对染料脱色和降解作用的研究进展。白腐菌对染料的脱色解降作用机理有部分尚待进一步研究;同时,白腐菌的吸附作用亦不容忽视。     

白腐真菌的木质素降解酶

简述了白腐真菌木质素降解酶的概念、催化反应机理及在纸浆的生物漂白和染料脱色中的应用。     

白腐真菌生物法处理染料亚甲基蓝的研究

实验采用白腐菌降解染料亚甲基蓝,研究了在不同振荡条件下,不同浓度的亚甲基蓝、染料废水的不同培养时间、不同转速、碳源的不同浓度等条件对染料亚甲基蓝的脱色效果的影响。实验结果表明,白腐菌在无氮条件下,染料亚甲基蓝浓度为4mg/L,振荡速度为120rpm,碳源浓度为2.0%时,其降解能力达到最大,脱色率为78.5%。     

白腐真菌对酸性橙7的脱色降解

偶氮染料广泛应用于纺织、造纸和包装等行业,因其具有三致性、结构稳定且难降解,已成为染料废水处理的研究热点之一。本研究以白腐真菌作为脱色菌株,考察了不同白腐真菌对偶氮类染料酸性橙7(acid orange 7,AO7)的脱色降解,探讨了AO7染料的浓度、pH、温度以及脱色时间对染料脱色率的影响,同时应用紫外-可见光谱吸收法、红外光谱吸收法、高效液相色谱法和气相色谱-质谱法对AO7的降解产物进行分析,并对其产物进行植物毒性实验,以推断AO7可能的降解途径及其降解产物的毒性。结果表明:在pH 4.5、28℃条件下,刺芹侧耳(Pleurotus eryngii)和杂色云芝(Trametes versicolor)的混合菌丝脱色降解100 mg/L AO7,24 h脱色率可达93.46%。推测AO7可能的生物降解途径:AO7偶氮键断裂生成对氨基苯磺酸和1-氨基-2-萘酚;接着对氨基苯磺酸脱去磺酸基,生成对苯二酚;同时1-氨基-2-萘酚开环生成邻苯二甲酸和对羟基苯甲醛,之后进一步降解生成苯甲酸;最后对苯二酚和苯甲酸继续氧化成其他小分子中间体、H2O和CO_(2)。植物毒性实验表明,P.eryngii和T.versicolor混合菌丝对AO7脱毒效果较好。以上研究为探究白腐真菌在工业废水中降解偶氮类染料的应用奠定基础。     

微生物染料脱色研究进展*

近年来,利用微生物对各种染料及染料废水脱色的研究报道很多,包括细菌、真菌等,脱色机制包括吸附脱色和降解脱色。综述了国内外有关这两大类微生物脱色研究的最新进展,对各种脱色机制在实际染料废水处理中的应用现状和研究方向进行了讨论。     

微生物染料脱色研究进展

近年来,利用微生物对各种染料及染料废水脱色的研究报道很多,包括细菌、真菌等,脱色机制包括吸附脱色和降解脱色。综述了国内外有关这两大类微生物脱色研究的最新进展,对各种脱色机制在实际染料废水处理中的应用现状和研究方向进行了讨论。     

三种白腐真菌脱色噻嗪染料亚甲基蓝

本研究通过含亚甲基蓝染料的固体培养基,从19株白腐真菌菌株中分离获得3个脱色能力较强的菌株,其在平板上的脱色圈大小分别为7.5cm、6.8cm和5.5cm。鉴定其为：云芝栓孔菌Trametes versicolor（ZT-197）,绒毛栓孔菌Trametes pubescens（ZT-230）和亚黑管孔菌Bjerkandera fumosa（ZT-307）。其中,ZT-230对染料亚甲基蓝的脱色能力最强,可以将染料浓度为50mg/L的100mL液体培养基在6d之内100%脱色,而ZT-197和ZT-307在接种第10天时的脱色率为98%和80%。同时测定了3株白腐真菌在降解染料过程中的漆酶、锰过氧化物酶和木素过氧化物酶3种酶活力的规律：ZT-197和ZT-230均可分泌Lac和MnP两种酶,ZT-307只分泌LiP。本研究说明绒毛栓孔菌ZT-197在印染废水治理方面具有较好的应用前景。     

茅草菇菌丝球对铬黑T的脱色降解性能及毒性评价

[目的]利用真菌茅草菇菌丝球对染料铬黑T(EBT)进行脱色和降解,探究在不同环境条件下对染料脱色性能的影响及作用机制.[方法]采用单因素分析探究真菌的最佳脱色能力,分光光度法测定真菌酶活,小麦种子萌发、大肠杆菌接触抑制试验及秀丽隐杆线虫毒性试验测定脱色前后废水的毒性.[结果]茅草菇菌丝球受摇床温度和转速影响较小,在pH...     

白囊耙齿菌对茜素红脱色条件优化及其毒性变化检测

白囊耙齿菌Irpex lacteus是分离自倒木上的一株可以分泌漆酶和锰过氧化物酶的白腐真菌。利用I. lacteus对固体条件下的活性黑、活性红、结晶紫、茜素红和孔雀石绿进行脱色能力的检测,通过单因素和正交试验优化I. lacteus对茜素红的脱色条件,并以3种作物发芽率为指标测定茜素红被I. lacteus脱色前后的毒性变化。结果显示,I. lacteus对5种染料均可脱色,其中对茜素红染料的脱色更为彻底;单因素和正交试验优化I. lacteus对茜素红的脱色条件为：pH 7.0、葡萄糖10.0g/L、硫酸铵0.66g/L、接种量2片（Φ=8.0mm）、100.0mL三角瓶装液20.0mL,优化条件下I. lacteus对茜素红脱色10d时的脱色率为88.26%,与未优化前的脱色率相比提高了60.50%;茜素红染料被I. lacteus脱色前后毒性大小排序为：染料原液>染料脱色后>PDB培养基处理,表明茜素红染料存在一定的毒性,I. lacteus脱色茜素红后可以使其毒性减弱。通过本研究,为I. lacteus在茜素红等染料废水脱色以及降低染料废水毒性方面的应用奠定基础。     

Decolorization of Turquoise Blue HFG by Coprinus plicatilis for Water Bioremediation

Synthetic dyes are extensively used in textile dyeing, paper printing, color photography, and the pharmaceutical, food, cosmetic, and leather industries. Most synthetic dyes are toxic and highly resistant to removal due to their complex chemical structures. There is a need for investigation of the biological treatment of synthetic dyes at a low cost and in the shortest possible time; synthetic dyes are used especially in the dye and textile industries and are an important polluting agent in the wastewater dumped into the environment by these industries. White rot fungus contains a variety of extracellular enzymes, and these enzymes are used for biological degradation of organic matter. The aim of the present work is to evaluate removal of the textile dye Turquoise Blue HFG by Coprinus plicatilis. Coprinus plicatilis was able to enzymatically decolorize 100% of the dye (dye concentration 10.0 and 25.0 mg L^?1). Ultraviolet–visible (UV-vis) spectrophotometric analyses, before and after decolorization, suggest that decolorization was due to biodegradation. There was an attempt to identify metabolites with Fourier transform infrared (FT-IR) spectroscopy and gas chromatography–mass spectrometry (GC-MS) at the end of the decolorization process. These results indicate that the samples did not include any detectable metabolite. Therefore, this fungus can be used as an economical and eco-friendly tool to minimize the pollution by industries to a significant extent.     

一色齿毛菌对刚果红的脱色优化及其毒性变化研究

一色齿毛菌Cerrena unicolor是分离自野外的一株能够降解木质素的白腐真菌。为明确一色齿毛菌对染料的脱色能力及脱色前后染料毒性的变化,本研究利用一色齿毛菌对固体条件下4种染料进行脱色能力的检测,筛选出较易脱色的染料后,对该染料的脱色条件进行优化,并以3种豆类发芽率为指标测定该染料脱色前后的毒性变化。结果表明,一色齿毛菌对4种染料均可脱色,其中对刚果红的脱色效果最为明显;一色齿毛菌对刚果红脱色条件的优化结果为：20g/L麦芽糖,1g/L硝酸铵,1mmol/L硫酸镁,接种9块直径1cm菌饼,10mg/L染料浓度,pH 7时脱色效果最好;刚果红染料脱色前后毒性测试结果显示：染料脱色前发酵液毒性>染料脱色后发酵液毒性>清水处理毒性,表明刚果红染料存在一定的毒性,但在被一色齿毛菌脱色后,染料毒性有所降低。本研究为一色齿毛菌在染料废水脱色方面的应用及降低染料废水毒性提供一定的参考依据。     

The role of enzymes produced by white-rot fungus Irpex lacteus in the decolorization of the textile industry effluent

The textile industry wastewater has been decolorized efficiently by the white rot fungus, Irpex lacteus, without adding any chemicals. The degree of the decolorization of the dye effluent by shaking or stationary cultures is 59 and 93%, respectively, on the 8th day. The higher level of manganese-dependent peroxidase (MnP) and non-specific peroxidase (NsP) was detected in stationary cultures than in the cultures shaken. Laccase activities were equivalent in both cultures and its level was not affected significantly by the culture duration. Neither lignin peroxidase (LiP) nor Remazol Brilliant Blue R oxidase (RBBR ox) was detected in both cultures. The absorbance of the dye effluent was significantly decreased by the stationary culture filtrate of 7 days in the absence of Mn (II) and veratryl alcohol. In the stationary culture filtrate, three or more additional peroxidase bands were detected by the zymogram analysis.     

一色齿毛菌漆酶的酶学特性及染料脱色研究

染料由于具有复杂的化学结构通常难以降解。本文从白腐菌一色齿毛菌LS0547中纯化出胞外漆酶并用于染料脱色实验。SDS-PAGE结果显示纯化的漆酶分子量大小为63.7kDa。漆酶氧化底物ABTS的最适pH为2.2,最适温度为50℃。叠氮钠可强烈抑制漆酶活性,半胱氨酸和二硫苏糖醇可部分抑制漆酶活性。漆酶氧化ABTS,丁香醛连氮和2,6-二甲氧基苯酚的米氏常数分别为0.217,0.306和0.199mmol/L。粗酶和纯化的漆酶用于不同化学结构的染料的脱色研究,结果表明一色齿毛菌纯化漆酶可快速对RB亮蓝进行脱色,偶氮胭脂红和结晶紫的脱色效果低于RB亮蓝,测试的三种染料均可在没有介体存在的条件下被漆酶脱色,显示出一色齿毛菌漆酶在染料废水处理中的应用前景。     

Implication of mycelium-associated laccase from Irpex lacteus in the decolorization of synthetic dyes

The white rot fungus Irpex lacteus is able to decolorize such synthetic dyes as Reactive Orange 16 and Remazol Brilliant Blue R. Here, we demonstrate that this type of dye decolorization is mainly related to a laccase-like enzyme activity associated with fungal mycelium. In its bound form, the enzyme detected showed a pH optimum of 3.0 for the oxidation of ABTS, DMP and guaiacol, and a pH of 7.0 for syringaldazine. The highest enzymatic activity was obtained with ABTS as substrate. Enzyme activity was fully inhibited with 50mM NaN(3). Depending on the chemical structure of dyes, redox mediators had a positive effect on the dye decolorization by fungal mycelium. Enzyme isolated from fungal mycelium was able to decolorize synthetic dyes in vitro.     

藜芦醇和吐温80对白腐菌产木质素降解酶的影响及在偶氮染料脱色中的作用

担子菌PM2在限氮液体培养下,分泌木质素过氧化物酶和锰过氧化物酶;藜芦醇、吐温 80的补充,提高了该菌锰过氧化物酶的产生,获得的最大锰过氧化物酶Mnp酶活为254.2u/L、190.2 u/L,分别是对照的3.4倍和2.5倍。选择三种偶氮染料,在染料体系下,进一步分析藜芦醇、吐温 80对担子菌PM2产过氧化物酶及染料脱色的影响。结果表明,担子菌PM2分泌的锰过氧化物酶Mnp与染料脱色有关,脱色程度受其分子结构特征影响;吐温80的补充,更有利于染料的脱色降解,48h后三种染料均可达到80%以上的脱色率。     

Synthetic dye decolorization by white rot fungus, Ganoderma sp. WR-1

Decolorization of recalcitrant dyes by an indigenous strain of white rot fungus isolated from bark of dead tree, WR-1 identified as Ganoderma sp. was investigated. The fermentation medium was optimized using a combination of one factor at a time and orthogonal array method. Maximum decolorization (96%) of 100 ppm amaranth was achieved in 8 h with optimized medium containing 2% starch and 0.125% yeast extract. Rate of dye decolorization by the indigenous isolate Ganoderma sp. WR-1 was very high compared to the most widely used strains of Trametes versicolor and Phanerochaete chrysosporium. The broad-spectrum decolorization efficiency of the isolate was assessed using chemically different dyes. The isolate was further evaluated for the decolorization of industrial effluent. Complete decolorization was achieved in 12 days.     

Biological color stripping: A novel technology for removal of dye from cellulose fibers

This research work was carried out to compare the color stripping efficiency of optimized biological method with the chemical stripping, commonly employed in the textile industries. Knitted fabric dyed with Reactive black B dye in 2, 4 and 6% shades strengths was subjected to chemical and biological stripping processes individually. Biological stripping process was found many fold superior to chemical one. It was noted that shade strength does not showed any pronounced effect on the bursting strength of fabric but biological and chemical treatment affect the quality of fabrics in terms of bursting strength/durability of fabric. White rot fungus Ganoderma lucidum IBL-05 showed good potential for decolorization/color stripping of cotton fabric dyed with Reactive black B under optimized set of conditions. The chemical stripping technology is inferior to biological stripping process regarding the quality of fabric and percent color removal from cotton fabric dyed with Reactive black B dye.