Identification of Mycelium-Associated Cellulase from Streptomyces reticuli

Among 180 Streptomyces strains tested, 25 were capable of hydrolyzing microcrystalline cellulose (Avicel) at 30°C. Streptomyces reticuli was selected for further studies because of its ability to grow at between 30 and 50°C on Avicel. Enzymatic activities degrading Avicel, carboxymethyl cellulose, and cellobiose were found both in the culture supernatant and in association with the mycelium and crystalline substrate. The bound enzymes were efficiently solubilized by repeated washes with buffer of low ionic strength (50 mM Tris hydrochloride [pH 7.5]) and further purified by fast protein liquid chromatography. A high-molecular-weight Avicelase of >300 kilodaltons could be separated from carboxymethyl cellulase (CMCase) and β-glucosidase activities (molecular mass, 40 to 50 kilodaltons) by gel filtration on Superose 12. The CMCase fraction was resolved by Mono Q anion-exchange chromatography into two enzymes designated CMCase 1 and CMCase 2. The β-glucosidase activity was found to copurify with CMCase 2. The purified cellulase components showed optimal activity at around pH 7.0 and temperatures of between 45 and 50°C. Avicelase (but not CMCase) activity was stimulated significantly by the addition of CaCl₂.     

Adsorption of cellulase from Trichoderma viride on cellulose

The adsorption of cellulase from Trichoderma viride (Meicelase CEP) on the surface of pure cellulose was studied. The adsorption was found to obey apparently the Langmuir isotherm. From the data concering the effects of temperature and the crystallinity of cellulose on the Langmuir adsorption parameters, the characteristics of the adsorption of the individual cellulase components, namely CMCase (endoglucanase) and Avicelase (exoglucanase), were discussed. While beta-glucosidase also adsorbed on the surface of cellulose at 5 degrees C, it did not at 50 degrees C.     

New isolate of Streptomyces sp. with novel thermoalkalotolerant cellulases

A Streptomyces sp. was isolated that produced novel thermoalkalotolerant cellulase activity after growth on crystalline cellulose at 50°C. Three major components of the cellulases (CMCase, Avicelase and cellobiase) were produced with maximal activities (11.8, 7.8 and 3.9 IU/ml) and maximum specific activities 357, 276 and 118 IU/mg protein, respectively, after 120 h growth. Maximum CMCase activity was between 50 and 60°C measured over 3 h. The enzyme also retained 88% of its maximum activity at 70°C and pH 5, and 80% of the activity at pH 10 and 50°C when assayed after 1 h. After incubation at 40°C for 1 h with commercial detergent (Tide) at pH 11, 95% activity was retained. The enzyme mixture produced glucose from crystalline cellulose.     

Production and Purification of Thermostable Cellulases from Humicola insolens YH-8

Humicola insolens YH-8, a thermophilic fungus isolated from manure and compost heaps, produced a significant amount of thermostable cellulases in cultures on wheat bran medium (50°C, 4 days). The mold bran extract hydrolyzed Avicel, CMC and newsprint at 90%, 45% and 35%, respectively, to glucose. Then, Avicelase and CMCase were purified from the culture extract by adsorption onto Avicel, heat and acid treatment and consecutive column chromatographies to a homogeneous state on polyacrylamide gel disc electrophoresis. The purified cellulases, especially CMCase, was found highly thermostable. The optimal temperature of both enzymes was 50°C. Avicelase was stable after heating at 65°C for 5 mm and CMCase retained 45% of the original activity after heating at 95°C for 5 min.     

Production and characterization of thermostable cellulases from Streptomyces transformant T3-1

A total of 26 thermophilic isolates, selected from a compost of agricultural waste, which was mostly composed of vegetable, corncob and rice straw, were cultivated at 50 °C for further studies of thermostable cellulase production. The thermostable cellulase gene from the chromosomal DNA of actinomycetes isolate no. 10 was shotgun-cloned and transformed into Streptomyces sp. IAF 10-164. A transformant, T3-1, was found to be a good strain for the production of thermostable cellulases. Cultivation of T3-1 in modified Mandels–Reese broth containing 1% carboxymethylcellulose (CMC)-sodium salt and the optimal condition for microbial growth were studied. Batch cultivation in a flask revealed that CMCase and Avicelase production reached the maximum between the third to fifth day, whereas maximum -glucosidase production occurred on the ninth day. Microbial biomass increased from the first day to the fifth day and then decreased. The crude enzyme had the highest activity at 50 °C and at pH 6.5. The enzyme was shown to be a thermostable cellulase whose activities were stable at 50 °C for more than 7 days.     

Comparison of Cellulolytic Activities in Clostridium thermocellum and Three Thermophilic, Cellulolytic Anaerobes

Avicelase, carboxymethyl cellulase (CMCase), and β-glucosidase activities have been compared between Clostridium thermocellum and three extremely thermophilic, cellulolytic anaerobes, isolates TP8, TP11, and KT8. The three isolates were all small, gram-negative staining, oval-ended rods which occurred singly and, at exponential phase, in long chains. They were nonflagellated and no spores were visible. The KT8 and TP11 isolates caused clumping of the cellulose during growth. In all four organisms the CMCase activity paralleled cell growth; however, in C. thermocellum and TP8 the avicelase activity did not increase until early stationary phase. Total CMCase activity in C. thermocellum was significantly higher than in the three isolates; however, avicelase activities were much more comparable among the four organisms. C. thermocellum produced higher levels of ethanol, and all four organisms produced similar concentrations of acetate. The amounts of free and bound CMCase and avicelase activities were investigated. In C. thermocellum and TP8 most of the CMCase and avicelase activities were bound to the cellulose in the medium. In contrast, most of the CMCase activity in TP11 and KT8 was free in the culture supernatant; a significant percentage of avicelase activity was also free. The TP8 isolate was also grown on a defined medium with urea as sole nitrogen source and cellulose serving as the carbon source. Under these conditions the pattern of enzyme production was the same as that in the enriched medium, although the level of that production was considerably reduced.     

Carboxymethylcellulase and avicelase activities from a cellulolytic Clostridium strain A11

The extracellular cellulase enzyme system of Clostridium A11 was fractionated by affinity chromatography on Avicel: 80% of the initial carboxymethylcellulase (CMCase) activity was adhered. This cellulase system was a multicomponent aggregate. Several CMCase activities were detected, but the major protein P1 had no detectable activity. Adhered and unadhered cellulases showed CMCase activity with the highest specific activity in Avicel-adhered fraction. However, only afhered fractions could degrade Avicel. Thus, efficiency of the enzymatic hydrolysis of Avicel was related to the cellulase-adhesion capacity. Carboxymethylcellulase and Avicelase activities were studied with the extracellular enzyme system and cloned cellulases. Genomic libraries from Clostridium A11 were constructed with DNA from this Clostridium, and a new gene cel1 was isolated. The gene(s) product(s) from cel1 exhibited CMCase and p-nitrophenylcellobiosidase (pNPCbase) activities. This cloned cellulase adhered to cellulose. Synergism between adhered enzyme system and cloned endoglucanases was observed on Avicel degradation. Conversely, no synergism was observed on CMC hydrolysis. Addition of cloned endoglucanase to cellulase complex led to increase of the V_max without significant K _m variation. Cloned endoglucanases can be added to cellulase complexes to efficiently hydrolyze cellulose.     

Studies on cellulase production by a Bacillus subtilis

Bacillus subtilis AU-1 was found to produce carboxymethylcellulase (CMCase) and Avicelase activities in the culture supernatant when grown on a variety of carbohydrates as major carbon source. Maximum CMCase production was obtained in a liquid medium containing 0.2% D (+) raffinose as inducer, 0.5% each of yeast extract, casamino acids and proteose peptone at 50 °C and at an initial pH of 6.0. CMCase activity was detected at early log phase of growth, and reached the maximum level at early stationary phase of growth which occurred at the 10th hour of cultivation. The optimal temperature for CMCase activity was 65 °C, and the enzyme was highly stable up to 60 °C. CMCase synthesis was subjected to catabolite repression by glucose and cellobiose.     

Optimization of pretreatment and fermentation conditions for production of extracellular cellulase complex using sugarcane bagasse

Sugarcane bagasse (SCB), a lignocellulosic byproduct of juice extraction from sugarcane, is rich in cellulose (40-42%). This could be used as a substrate for the production of cellulase complex. Fermentation conditions were optimized for production of cellulase complex (CMCase, Cellulobiase and FPase) by wild type Trichoderma sp. using sugarcane bagasse as sole carbon source. Alkaline treatment (2% NaOH) of bagasse (AlSCB) was found suitable for the production of reducing sugar over the acidic pretreatment method. After 5 days of incubation period, 5% substrate concentration at pH 5.0 and 400C resulted in maximum production of CMCase (0.622 U), while maximum (3.388 U) production of cellulobiase was obtained at 300C. The CMCase was precipitated and purified to the extent of 59.06 fold by affinity chromatography with 49.09% recovery. On 12% SDS-PAGE, a single band corresponding to 33 kDa was observed. The Km and Vmax for CMCase from Trichoderma was found 507.04 mg/ml and 65.32 mM/min, respectively. The enzyme exhibited maximum activity at 300C at pH-5.0 (0.363 U) and was stable over range of 20-60°C and pH 5.0-7.5.     

Subcellulosome preparation with high cellulase activity from Clostridium thermocellum

We have prepared a much simpler cellulase preparation than that of cellulosomes from the extracellular broth of Clostridium thermocellum. This "subcellulosome" preparation from C. thermocellum was obtained by column chromatography on CM-Bio-Gel A and then on a lectin-affinity material (Jacalin). The subcellulosome preparation is a macromolecular complex, composed of six main protein subunits (molecular weight, 210,000 to 58,000) revealed on sodium dodecyl sulfate-polyacrylamide gel electrophoresis. The specific activities of carboxymethylcellulase (CMCase) and Avicelase are 15- and 8-fold-higher, respectively, than those of crude extracellular cellulase. We could not further fractionate this preparation without denaturing it. The optimum pH and temperature of the subcellulosome preparation are 5.5 to 7.0 and 70 degrees C for CMCase and 5.5 to 7.0 and 65 degrees C for Avicelase. The subcellulosome preparation acted on various types of carboxymethyl cellulose, cellulose, and p-nitrophenyl-beta-D-cellobioside but not on p-nitrophenyl-beta-D-glucoside. Sulfhydryl reagents and N-bromosuccinimide inhibited both CMCase and Avicelase activities, whereas EDTA and o-phenanthroline inhibited Avicelase activity only.     

Purification and characterization of endoglucanase and exoglucanase components from Trichoderma viride

Major cellulase components—four endoglucanases (Endo I, II, III and IV) and one exoglucanase (Exo II)—were isolated from a commercial cellulase preparation derived from Trichoderma viride by a series of chromatographic procedures. The average molecular weights were determined by SDS-polyacrylamide gel electrophoresis. Endos I, III and IV, with M_rs of 52,000, 42,000 and 38,000, respectively, exhibited a more random hydrolytic mode on carboxymethylcellulose (CMC) than Endo II, which has an M_r of 60,000. Endo II showed low activity towards CMC, but out of the four purified endoglucanases this enzyme had the highest specific activity against Avicel. In the hydrolysis of H₃PO₄-swollen cellulose by Endos I, III and IV, cellobiose was the major product, but equimolar amounts of glucose and cellobiose were formed by Endo II. Exo II, with an M_r of 62,000, released cellobiose as the main product in the hydrolysis of H₃PO₄-swollen cellulose, but glucose was negligible. The combination of Endo I, II, III or IV with Exo II resulted in a synergistic effect in the degradation of Avicel at various combination ratios of these enzymes; the specific optimum ratio of endoglucanase to exoglucanase was largely dependent upon the random hydrolytic mode of the endoglucanase. On the other hand, adsorption of cellulase components was found apparently to obey the Langmuir isotherm, and the thermodynamic parameter (ΔH) was calculated from the adsorption equilibrium constant (K). The enthalpies of adsorption of the endoglucanases were in the range of −2.6–−7.2 KJmol⁻¹, much smaller than that of Exo II (−19.4 KJmol⁻¹). This suggest that Exo II shows stronger preferential adsorption than endoglucanases, and that the enthalpy of adsorption will be effective in distinguishing endoglucanase from exoglucanase.     

Subcellulosome preparation with high cellulase activity from Clostridium thermocellum.

We have prepared a much simpler cellulase preparation than that of cellulosomes from the extracellular broth of Clostridium thermocellum. This "subcellulosome" preparation from C. thermocellum was obtained by column chromatography on CM-Bio-Gel A and then on a lectin-affinity material (Jacalin). The subcellulosome preparation is a macromolecular complex, composed of six main protein subunits (molecular weight, 210,000 to 58,000) revealed on sodium dodecyl sulfate-polyacrylamide gel electrophoresis. The specific activities of carboxymethylcellulase (CMCase) and Avicelase are 15- and 8-fold-higher, respectively, than those of crude extracellular cellulase. We could not further fractionate this preparation without denaturing it. The optimum pH and temperature of the subcellulosome preparation are 5.5 to 7.0 and 70 degrees C for CMCase and 5.5 to 7.0 and 65 degrees C for Avicelase. The subcellulosome preparation acted on various types of carboxymethyl cellulose, cellulose, and p-nitrophenyl-beta-D-cellobioside but not on p-nitrophenyl-beta-D-glucoside. Sulfhydryl reagents and N-bromosuccinimide inhibited both CMCase and Avicelase activities, whereas EDTA and o-phenanthroline inhibited Avicelase activity only.     

A simple method of cellulase immobilization on a modified silica support

Two types of cellulase (Robillarda sp. Y-20 and Trichoderma reesei) were immobilized on Aminosilica-1 by physical adsorption. Enzymes were quickly immobilized and stable on the support. Specific activities of two types of immobilized cellulase were 0.24 U/mg support with Robillarda cellulase and 0.15 U/mg support with the Trichoderma one as CMCase. The pH-activity curves of both cellulase shifted slightly to lower pH on immobilization. Both immobilized cellulases showed essentially the same pH stabilities as their free forms. However, the immobilized enzymes were less stable than the free forms at temperatures higher than 50°C.     

A Shortcut to the Optimization of Cellulase Production Using the Mutant Trichoderma reesei YC-108

Trichoderma reesei YC-108, a strain isolated by a kind of newly invented plate was found to over produce cellulase and it was then used as a cellulase producer. To get the maximum amount of cellulase, the combination of the medium ingredients, which has a profound influence on metabolic pathway was optimized using response surface methodology. The optimum composition was found to be 24.63 g/L wheat bran, 30.78 g/L avicel, and 19.16 g/L soya-bean cake powder. By using the optimized medium, the filter paper activity (FPA) increased nearly five times to 15.82 IU/mL in a 30 L stirred fermenter, carboxymethyl cellulase activity (CMCase) was increased from 83.02 to 628.05 IU/mL and the CMCase/FPA ratio was nearly doubled compared with the parent strain at initial medium.     

Production of cellulase enzymes during the solid-state fermentation of empty palm fruit bunch fiber

Penicillium verruculosum COKE4E is a fungal strain isolated from bituminous coal. The microorganism cultivated in a minimal medium supplemented with Avicel, carboxymethylcellulose, and oat spelt xylan produced cellulase enzymes as exhibiting carboxymethylcellulase (CMCase), Avicelase, xylanase, and cellobiosidase activities. In this study, the productivity of the extracellular enzymes in the strain was evaluated by using empty palm fruit bunch fiber (EPFBF), a lignocellulosic biomass, as a substrate for solid-state bioconversion. The highest cellulase activities were observed after 6 days of fermentation at pH 6.0 and 30 °C. The enzymes were secreted as cellulosomes for the degradation of EPFBF as a sole carbon source. Focused ion beam analysis showed that P. verruculosum COKE4E produced cellulolytic enzymes that were able to effectively biodegrade EPFBF during solid-state fermentation. In this process, 6.5 U of CMCase, 6.8 U of Avicelase, and 8.8 U of xylanase per gram of dry solid EPFBF were produced. These results demonstrate that EPFBF may be a potential raw material in solid-state fermentation for the production of cellulase enzymes to be used for biofuel production.     

表面活性剂对绿色木霉产纤维素酶影响

利用绿色木霉,以稻草为唯一碳源,采用液态发酵的方法,分别加入生物表面活性剂鼠李糖脂和化学表面活性剂Tween 80,重点研究了生物表面活性剂对绿色木霉产纤维素酶的影响。实验分析了加入不同浓度的表面活性剂时滤纸酶活、羧甲基纤维素酶活、微晶纤维素酶活及酶液的表面张力随时间的变化情况。结果表明,添加鼠李糖脂能够促进绿色木霉产酶,分别使滤纸酶活、羧甲基纤维素酶活、微晶纤维素酶活最大提高了1.08倍,1.6倍和1.03倍。与Tween 80相比,鼠李糖脂促进产酶的效果明显优于Tween 80。     

Hexavalent chromium removal from aqueous solution by adsorption on treated sawdust

The studies on adsorption of hexavalent chromium were conducted by varying various parameters such as contact time, pH, amount of adsorbent, concentration of adsorbate and temperature. The kinetics of adsorption of Cr(VI) ion followed pseudo second order. Langmuir adsorption isotherm was employed in order to evaluate the optimum adsorption capacity of the adsorbent. The adsorption capacity was found to be pH dependant. Sawdust was found to be very effective and reached equilibrium in 3 h (adsorbate concentration 30 mg l⁻¹). The rate constant has been calculated at 303, 308, 313 and 318 K and the activation energy (E_a) was calculated using the Arrhenius equation. Thermodynamic parameters such as standard Gibbs energy (ΔG°) and heat of adsorption (ΔH_r) were calculated. The ΔG° and ΔH_r values for Cr(VI) adsorption on the sawdust showed the process to be exothermic in nature. The percentage of adsorption increased with decrease in pH and showed maximum removal of Cr(VI) in the pH range 4.5–6.5 for an initial concentration of 5 mg l⁻¹.     

Determination of endoglucanase activity of paper decaying fungi from an old library at the ancient Medina of Fez

Paper from an ancient library of the cultural city of Fez (Morocco) is exposed to rapid deterioration by variety of microorganisms, especially cellulolytic fungi. For this, ten isolates fungi previously isolated from historical biodeteriorated paper were screened for their ability to produce endoglucanase (CMCase), amylase, polygalacturonase and ligninase enzymes. The CMCase activity of cellulolytic strains was essayed in liquid media at 25°C for 10 days. Influence of temperature and pH were assessed for the production of CMCase by all the fungus isolated from decaying paper. The research findings from the present study demonstrate that all the tested isolates had cellulase, amylase, pectinase and ligninase activities. It was found that Mucor racemosus PF15, Aspergillus niger, and Aspergillus oryzae exhibited the maximum endoglucanase activity in liquid medium (0.256, 0.236, and 0.216 UI/mL in descending order) for six days. Temperature profiling revealed optimum endoglucanase activity at 25 and 30°C. Maximum activity was observed at pH 5 and pH 6.     

Effect of Host Diet and Hindgut Microbial Composition on Cellulolytic Activity in the Hindgut of the American Cockroach, Periplaneta americana

Cellulase activity measured as filter paper digesting activity (FPase) and carboxymethyl cellulase (CMCase) was demonstrated in hindgut extracts of the cockroach Periplaneta americana. The highest activities measured amounted to 0.89 and 0.12 U · ml^-1 for CMCase and FPase, respectively. The cellulolytic capacity of the hindgut population increased dramatically when protozoa were present, and the activities were found to vary depending on the feeding regimen. Cellulose-rich diets induced high protozoal numbers, resulting in a high cellulase activity. A close correlation was found between the number of Nyctotherus ovalis organisms, the major protozoans in the hindgut, and both FPase and CMCase activity. Since the numbers of this protozoan also correlated with the methane production of the insect, it appears that N. ovalis is responsible for the major part of cellulolytic and methanogenic activity found in the hindgut of P. americana.     

The cellulolytic and hemi-cellulolytic system of Bacillus licheniformis SVD1 and the evidence for production of a large multi-enzyme complex

The cellulolytic and hemi-cellulolytic system of Bacillus licheniformis SVD1 was isolated and characterised in birchwood xylan cultures. The predominant activity in the crude culture was xylanase activity, but the crude culture also displayed Avicelase, carboxymethylcellulase (CMCase), mannanase, and pectinase activity. Most of the xylanase activity was found in the culture supernatant, but some activity was cell-associated. Using Sepharose 4B size exclusion chromatography, a 2000 kDa multi-enzyme complex (MEC) was purified. The MEC contained predominantly xylanase activity, as well as significant levels of mannanase and CMCase activity, but no Avicelase activity. SDS-PAGE revealed up to eight visible bands in the MEC while zymograms of the MEC displayed two xylanase active bands at 21 kDa and 45 kDa, and two CMCase active bands at 25 kDa and 30 kDa. More active bands were visible in the crude supernatant with an additional xylanase active band at 40 kDa and an additional CMCase active band at 55 kDa. Using thin layer chromatography (TLC), it was established that the crude fraction could release xylose from insoluble birchwood xylan, while the MEC was only able to produce xylobiose from this substrate. The MEC was further able to bind to insoluble xylan, but was unable to bind to crystalline cellulose. This MEC lacks many of the characteristic features of a cellulosome and is most likely a different type of complex. The presence of both high xylanase and mannanase activity makes this MEC unusual.