Improvement of hydrogenase enzyme activity by water-miscible organic solvents

Both stability and catalytic activity of the HynSL Thiocapsa roseopersicina hydrogenase in the presence of different water-miscible organic solvents were investigated. For all organic solvents under study the substantial raise in hydrogenase catalytic activity was observed. The stimulating effect of acetone and acetonitrile on the reaction rate rose with the increase in solvent concentration up to 80%. At certain concentrations of acetonitrile and acetone (60–80%, v/v in buffer solution) the enzyme activity was improved even 4–5 times compared to pure aqueous buffer. Other solvents (aliphatic alcohols, dimethylsulfoxide and tetrahydrofuran) improved the enzyme activity at low concentrations and caused enzyme inactivation at intermediate concentrations. The long-term incubation of the hydrogenase with aliphatic alcohols, dimethylsulfoxide and tetrahydrofuran at intermediate concentrations of the latter caused enzyme inactivation. The reduced form of hydrogenase was found to be much more sensitive to action of these organic solvents than the enzyme being in oxidized state. The hydrogenase is rather stable at high concentrations of acetone or acetonitrile during long-term storage: its residual activity after incubation in these solvents upon air within 30 days was about 50%, and immobilized enzyme remained at the 100% of its activity during this period.     

NAD+-dependent hydrogenase from the hydrogen oxidizing bacterium Alcaligenes eutrophus Z1. Stabilization against temperature and urea induced inactivation

Chemical modification of the NAD+-dependent hydrogenase from the hydrogen oxidizing bacterium Alcaligenes eutrophus Z1 results in considerable enzyme stabilization towards urea and temperature induced inactivation. The stabilizing effect was shown to originate from the suppression of hydrogenase tetramer dissociation. The magnitudes of the stabilizing effects (5-fold and more) were in agreement with the values predicted on the basis of the enzyme thermoinactivation mechanism postulated earlier. Hydrophobic interactions are considered to be critical for the stability of the enzyme quaternary structure. Various methods of hydrogenase immobilization were tested. The enzyme was immobilized with a high retention of activity on aminated silochrom via its carboxylic groups.     

Immobilization and stability of the NAD-dependent hydrogenase from alcaligenes eutrophus and of whole cells

Summary The purified soluble NAD-dependent hydrogenase from Alcaligenes eutrophus was immobilized to porous glass beads according to the glutaraldehyde method retaining about 80% of its original activity. Entrapment of the purified hydrogenase in photo-crosslinkable prepolymers led to apparent activity yields of 10–80% dependent on the thickness of the gel film. The storage stability of entrapped hydrogenase (t/2 = 4 d) was considerably lower than that of glass-bound hydrogenase (t/2 = 150 d). During continuous production of NADH (turnover conditions), the half-life of entrapped hydrogenase was not longer than 10 h. Whole cells of A. eutrophus entrapped in a polyurethane matrix were used to produce NADH with hydrogen gas as electron donor. After 18 runs for 4h each and storage periods overnight the residual activity was still about 50%.     

Tyrosine hydroxylase activity of immobilized tyrosinase on enzacryl-AA and CPG-AA supports: Stabilization and properties

Frog epidermis tyrosinase has been immobilized on Enzacryl-AA (a polyacrylamide-based support) and CPG(zirclad)-Arylamine (a controlled pore glass support) in order to stabilize the tyrosine hydroxylase activity of the enzyme; in this way, the immobilized enzyme could be used to synthesize L-dopa from L-tyrosine. The activity immobilization yield Y(IME) (act) (higher than 86%), coupling efficiency (up to 90%), storage stability (no loss in 120 days), and reaction stability (t(1/2) was higher than 20 h in column reactors) were measured for tyrosinase after its immobilization. The results showed a noticeable improvement (in immobilization yield, coupling efficiency, and storage and operational stabilities) over previous reports in which tyrosinase was immobilized for L-dopa production. The activity and stability of immobilized enzyme preparations working in three different reactor types have been compared when used in equivalent conditions with respect to a new proposed parameter of the reactor (R(p)), which allows different reactor configurations to be related to the productivity of the reactor during its useful life time. The characteristic reaction inactivation which soluble tyrosinase shows after a short reaction time has been avoided by immobilization, and the stabilization was enhanced by the presence of ascorbate. However, another inactivation process appeared after a prolonged use of the immobilized enzyme. The effects of reactor type and operating conditions on immobilized enzyme activity and stability are discussed.     

Kinetics and stability of immobilized chicken liver xanthine dehydrogenase.

Xanthine dehydrogenase (EC 1.2.1.37) was isolated from chicken livers and immobilized by adsorption to a Sepharose derivative, prepared by reaction of n-octylamine with CNBr-activated Sepharose 4B. Using a crude preparation of enzyme for immobilization it was observed that relatively more activity was adsorbed than protein, but the yield of immobilized activity increased as a purer enzyme preparation was used. As more activity and protein were bound, relatively less immobilized activity was recovered. This effect was probably due to blocking of active xanthine dehydrogenase by protein impurities. The kinetics of free and immobilized xanthine dehydrogenase were studied in the pH range 7.5-9.1. The Km and V values estimated for free xanthine dehydrogenase increase as the pH increase; the K'm and V values for the immobilized enzyme go through a minimum at pH 8.1. By varying the amount of enzyme activity bound per unit volume of gel, it was shown that K'm is larger than Km are result of substrate diffusion limitation in the pores of the support material. Both free and immobilized xanthine dehydrogenase showed substrate activation at low concentrations (up to 2 microM xanthine). Immobilized xanthine dehydrogenase was more stable than the free enzyme during storage in the temperature range of 4-50 degrees C. The operational stability of immobilized xanthine dehydrogenase at 30 degrees C was two orders of magnitude smaller than the storage stability, t 1/2 was 9 and 800 hr, respectively. The operational stability was, however, better than than of immobilized milk xanthine oxidase (t 1/2 = 1 hr). In addition, the amount of product formed per unit initial activity in one half-life, was higher for immobilized xanthine dehydrogenase than for immobilized xanthine oxidase. Unless immobilized milk xanthine oxidase can be considerable stabilized, immobilized chicken liver xanthine dehydrogenase is more promising for application in organic synthesis.     

Immobilization of adenosine deaminase onto agarose and casein

In the present study adenosine deaminase (ADA) was immobilized onto two different polymeric materials, agarose and casein. The factors affecting the amount of enzyme attachment onto the polymeric supports such as incubation time were investigated. The maximum amount of enzyme immobilized onto different polymeric supports occurred at incubation pH value 7.5 and ADA concentration 42 units/g and the incubation time needed for the maximum amount of enzyme attachment to the polymeric supports was found to be 8 h. Some phsicochemical properties of the free and immobilized ADA such as operational stability, optimum temperature and thermal stability, pH optimum and stability, storage stability, and the effect of gamma-radiation were studied. The operational stability of the free and immobilized enzyme showed that the enzyme immobilized by a cross-linking technique using gultaric dialdehyde showed poor durability and the relative activity decreased sharply due to the leakage after repeated washing, while the enzymes immobilized by covalent bonds to the carriers showed a slight decrease in most cases in the relative activity (around 20%) after being used 10 times. Storage for 4-6 months, showed that the free enzyme lost its activity, while the immobilized enzyme showed the opposite behavior. Subjecting the immobilized enzyme to a dose of gamma radiation of 0.5-10 Mrad showed complete loss in the activity of the free enzyme at a dose of 5 Mrad, while the immobilized enzymes showed relatively high resistance to gamma radiation up to a dose of 5 Mrad.     

Citrate determination with aconitase immobilized on solid support

Pig heart aconitase has been immobilized on Enzacryl AA solid support and its kinetic behaviours were studied by using a stirred bath reactor with continuous recycling. In this reactor, the best flow rate has been determined to eliminate diffusional problems. Kinetics constants, thermic stability and pH variations have been compared between the soluble and immobilized aconitase for determination of enzyme-Enzacryl AA effectivity. Stability of the soluble and immobilized aconitase was also studied after repeated use and long-time storage. While the soluble form loses its activity after 24 hr storage, the immobilized form preserves its full activity after repeated usage and long-lasting storage. Finally, an easily measurable parameter has been found to quantitate citrate. The maximum increase of absorbance, is proportional to citrate concentration in a range between 0.2 and 3.2 mM. In conclusion, these results show that the immobilized aconitase system can be used for the determination of citrate with reproductility and great sensitivity. In addition to the simplicity of the assay, great economy in enzyme consumption has been demonstrated, in contrast to the traditional methods of quantitative citrate analysis.     

环氧交联剂和氨基载体固定化海洋假丝酵母脂肪酶*

游离酶经过固定化后,稳定性和环境耐受性得到提高,在食品、医药、化工、环境和皮革等领域可以很好的提高酶的利用率并降低生产成本,具有极大的应用潜力。新型交联剂在固定化酶工艺的应用极大推进了固定化酶研究的深入。借助新型交联剂聚乙二醇二缩水甘油醚(PEGDGE),利用氨基载体LX-1000HA固定化海洋假丝酵母脂肪酶,结合单因素和正交试验优化得到交联及固定化条件为:交联温度30℃,交联2h,交联剂浓度0.75%,pH7.0,加酶量800U,载体量0.5g,固定化2h,固定化温度45℃。根据上述最佳固定化工艺,制备得到固定化酶LX-1000HA-PEGDGE-CRL在最适条件下测得酶活达到160.81U/g,约为此前制备的固定化酶LX-1000HA-GA-CRL(由LX-1000HA和戊二醛交联脂肪酶得到)和LX-1000EA-PEGDGE-CRL(由短链氨基载体LX-1000EA和PEGDGE交联脂肪酶得到)酶活的2倍,发现固定化酶LX-1000HA-PEGDGE-CRL的最适反应温度相比于游离酶提高15℃;在70℃的环境中3h后酶活仍存留70%;循环使用6次后残留65%左右的酶活;酸碱耐受性和储存稳定性也表现良好,4℃保存30天后剩余约70%的初始酶活。同时,将制备的固定化酶LX-1000HA-PEGDGE-CRL与游离酶、固定化酶LX-1000HA-GA-CRL、固定化酶LX-1000EA-PEGDGE-CRL进行了比较,发现固定化酶LX-1000HA-PEGDGE-CRL在温度耐受性和重复使用性等方面具有更好的使用效果。     

Immobilization of Desulphovibrio desulphuricans: cell-associated hydrogenase in beaded matrices

The immobilization of the hydrogenase (cytochrome c₃ hydrogenase, hydrogen: ferricytochrome c₃ oxidoreductase, EC 1.12.2.1) activity associated with Desulphovibrio desulphuricans whole cells is described. The periplasmic hydrogenase was prevented from leaking from the cells by glutaraldehyde treatment. This modification left the hydrogenase activity of the cells unchanged. The resulting whole-cell preparation was then immobilized in beaded gels formed by either calcium alginate or low temperature radiation-polymerized polyacrylamide(s). The alginate matrix was used to study the effect of bead diameter and retention of hydrogenase activity after immobilization. Polyacrylamide matrices were used to study the effects of immobilization on hydrogenase activity vs. pH profiles and also matrix charge effects on enzymatic activity and long-term storage.     

Adsorption of peroxidase on Celite 545 directly from ammonium sulfate fractionated white radish (Raphanus sativus) proteins

This paper demonstrates the direct immobilization of peroxidase from ammonium sulfate fractionated white radish proteins on an inorganic support, Celite 545. The adsorbed peroxidase was crosslinked by using glutaraldehyde. The activity yield for white radish peroxidase was adsorbed on Celite 545 was 70% and this activity was decreased and remained 60% of the initial activity after crosslinking by glutaraldehyde. The pH and temperature-optima for both soluble and immobilized peroxidase was at pH 5.5 and 40°C. Immobilized peroxidase retained higher stability against heat and water-miscible organic solvents. In the presence of 5.0 mM mercuric chloride, immobilized white radish peroxidase retained 41% of its initial activity while the free enzyme lost 93% activity. Soluble enzyme lost 61% of its initial activity while immobilized peroxidase retained 86% of the original activity when exposed to 0.02 mM sodium azide for 1 h. The K_m values were 0.056 and 0.07 mM for free and immobilized enzyme, respectively. Immobilized white radish peroxidase exhibited lower V_max as compared to the soluble enzyme. Immobilized peroxidase preparation showed better storage stability as compared to its soluble counterpart.     

Preparation and characterization of urease immobilized onto porous chitosan beads for urea hydrolysis

Urease was covalently immobilized onto porous chitosan beads via primary amine groups connected to the backbone via a six-carbon linear alkyl spacer. The optimum conditions for enzyme immobilization are activating the beads with 1%(w/w) glutaraldehyde, reacting the activated beads in pH 7 buffer with the enzyme, using an enzyme to bead weight ratio of 25, and without lyophilization. Chitosan-bound urease was found to fully retain its specific activity. Properties of the immobilized urease were characterized under batch and flow conditions. Increased optimum reaction temperature, enhanced thermal stability and storage stability, and excellent reusability were found after enzyme immobilization. Continuous hydrolysis of urea solution was studied in a column packed with the enzyme-containing beads for its possible application in regenerating dialysate solution during hemodialysis.     

Stabilization of activity of oxidoreductases by their immobilization onto special functionalized glass and novel aminocellulose film using different coupling reagents

Glucose oxidase (GOD), horseradish peroxidase (HRP), and lactate oxidase (LOD) were covalently immobilized on special NH(2)-functionalized glass and on a novel NH(2)-cellulose film via 13 different coupling reagents. The properties of these immobilized enzymes, such as activity, storage stability, and thermostability, are strongly dependent on the coupling reagent. For example, GOD immobilized by cyanuric chloride on the NH(2)-cellulose film loses approximately half of its immobilized activity after 30 days of storage at 4 degrees C or after treatment at 65 degrees C for 30 min. In contrast, GOD immobilized by L-ascorbic acid onto the same NH(2)-cellulose film retains 90% of its initial activity after 1 year of storage at 4 degrees C and 92% after heat treatment at 65 degrees C for 30 min. Unlike GOD, in the case of LOD only immobilization on special NH(2)-functionalized glass, e.g., via cyanuric chloride, led to a stabilization of the enzyme activity in comparison to the native enzyme. The operational stability of immobilized HRP was up to 40 times higher than that of the native enzyme if coupling to the new NH(2)-cellulose film led to an amide or sulfonamide bond. Regarding the kinetics of the immobilized enzymes, the coupling reagent plays a minor role for the enzyme substrate affinity, which is characterized by the apparent Michaelis constant (K(M,app)). The NH(2)-functionalized support material as well as the immobilized density of the protein and/or immobilized activity has a strong influence on the K(M,app) value. In all cases, K(M,app) decreases with increasing immobilized enzyme protein density and particularly drastically for GOD.     

The mechanism of cobalamin binding to hog intrinsic factor

Chicken brain Arylsulfatase A (E.C.3.1.6.1) was immobilized by interaction with Concanavalin A. The immobilized enzyme retained its catalytic activity and this enzyme can be reused without appreciable loss of activity. The storage stability of bound and soluble enzymes was comparable and binding of enzyme to Concanavalin A increases its thermal stability. Kinetic studies indicated that bound enzyme shows similar anomalous kinetics as that of free enzyme but slight change was observed in relation to pH optima, Km value and activation energy.     

The potential of immobilized bacterial α-amylase on coconut coir,a smart carrier for biocatalysts

Purified α-amylase from a soil bacterium Bacillus sp. SKB4 was immobilized on coconut coir, an inexpensive cellulosic fiber, with the cross-linking agent glutaraldehyde. The catalytic properties and stability of the immobilized enzyme were compared with those of its soluble form. The enzyme retained 97.2% of its activity and its catalytic properties were not drastically altered after immobilization. The pH optimum and stability of the immobilized enzyme were shifted towards the alkaline range compared to the free enzyme. The optimum temperature for enzymatic activity was 90°C in both forms of the enzyme. The soluble and immobilized enzyme retained 19% and 70% of original activity, respectively, after pre-incubation for 1 h at 90°C. Immobilized amylase was less susceptible to attack by heavy metal ions and showed higher K_m and V_max values than its free form. The bound enzyme showed significant activity and stability after 6 months of storage at 4°C. All of these characteristics make the new carrier system suitable for use in the bioprocess and food industries.     

Immobilization of β-galactosidase on modified polypropilene membranes

A new immobilized system: β-galactosidase-modified polypropylene membrane was created. It was obtained 13 different carriers by chemical modification of polypropylene membranes by two stages. The first stage is treatment with K(2)Cr(2)O(7) to receive carboxylic groups on membrane surface. The second stage is treatment with different modified agents ethylendiamine, hexamethylenediamine, hydrazine dihydrochloride, hydroxylamine, o-phenylenediamine, p-phenylenediamine, N,N'-dibenzyl ethylenediamine diacetate to receive amino groups. The quantity of the amino groups, carboxylic groups and the degree of hydrophilicity of unmodified and modified polypropilene membranes were determined. β-Galactosidase was chemically immobilized on the obtained carries by glutaraldehyde. The highest relative activity of immobilized enzyme was recorded at membrane modified with 10% hexamethylenediamine (Membrane 5) - 92.77%. The properties of immobilized β-galactosidase on different modified membranes - pH optimum, temperature optimum, pH stability and thermal stability were investigated and compared with those of free enzyme. The storage stability of all immobilized systems was studied. It was found that the most stable system is immobilized enzyme on Membrane 5. The system has kept 90% of its initial activity at 300th day (pH=6.8; 4°C). The stability of the free and immobilized β-galactosidase on the modified membrane 5 with 10% HMDA in aqueous solutions of alcohols - mono-, diol and triol was studied. The kinetics of enzymatic reaction of free and immobilized β-galactosidase on the modified membrane 5 at 20°C and 40°C and at the optimal pH for both forms of the enzyme were investigated. It was concluded that the modified agent - hexamethylenediamine, with long aliphatic chain ensures the best immobilized β-galactosidase system.     

Effects of immobilization on the kinetics of enzyme-catalyzed reactions. I. Glucose oxidase in a recirculation reactor system.

Glucose oxidase from Aspergillus niger was immobilized on nonporous glass beads by covalent bonding and its kinetics were studied in a packed-column recycle reactor. The optimum pH of the immobilized enzyme was the same as that of soluble enzyme; however, immobilized glucose oxidase showed a sharper pH-activity profile than that of the soluble enzyme. The kinetic behavior of immobilized glucose oxidase at optimum pH and 25 degrees C was similar to that of the soluble enzyme, but the immobilized material showed increased temperature sensitivity. Immobilized glucose oxidase showed no loss in activity on storage at 4 degrees C for nearly ten weeks. On continuous use for 60 hr, the immobilized enzyme showed about a 40% loss in activity but no change in the kinetic constant.     

Properties of Stable Hydrogenase from the Purple Sulfur Bacterium Lamprobacter modestohalophilus

Some properties of a hydrogenase from the recently isolated phototrophic sulfur bacterium Lamprobacter modestohalophilus strain Syvash and its resistance to a number of inactivating factors have been investigated. The enzyme consists of two subunits, 64 and 30 kD; pI = 4.5. The optimal pH was 8.5-9.5 for hydrogen uptake and 4.0 for H2 evolution. Hydrogenase preparations were resistant to the effects of O2, CO, and temperature, revealing high stability under storage. A considerable inactivation of the enzyme was observed at temperatures above 80 degrees C; the temperature optimum of methyl viologen reduction by H2 was 85 degrees C. Inhibitory effects of Ni2+, Cd2+, and Mg2+ on the hydrogenase activity were shown to be reversible and competitive with respect to methyl viologen in the hydrogen oxidation reaction.     

SMA基微孔膜固定化β-半乳糖苷酶的研究

以超临界二氧化碳（SCCO2）为分散介质在聚偏氟乙烯（PVDF）微孔膜表面和孔内进行马来酸酐和苯乙烯的接枝共聚,合成出超高分子量的苯乙烯/马来酸酐交替共聚物（SMA）基微孔PVDF膜。以SMA基PVDF膜为载体通过酸酐基和酶分子上的氨基偶联,制备出具有酶催活性的功能性分离膜。考察了影响酶固定化的因素,确定其最佳固定化条件为: 温度,4oC;pH,8.2; 酶/膜,1:10;反应时间,6h。固定化酶膜的最适温度为55oC,最适pH为7.8,均比自由酶稍高;Km（0.3mM/L）与自由酶接近。固定化酶膜活力达13.5 U/cm2 膜, 比活为280.0 U/mg 蛋白,蛋白载量为68.2 g/cm2 膜,相对活力为89.0%。固定化酶膜表现出良好的操作稳定性和储存稳定性,SMA基PVDF微孔酶膜超滤制备低乳糖牛奶实验表明该技术应用前景广阔。     

Immobilization and stabilization of α-galactosidase on Sepabeads EC-EA and EC-HA

α-Galactosidase from tomato has been immobilized on Sepabead EC-EA and Sepabead EC-HA, which were activated with ethylendiamino and hexamethylenediamino groups, respectively. Two strategy was used for the covalent immobilization of α-galactosidase on the aminated Sepabeads: covalent immobilization of enzyme on glutaraldehyde activated support and cross-linking of the adsorbed enzymes on to the support with glutaraldehyde. By using these two methods, all the immobilized enzymes retained very high activity and the stability of the enzyme was also improved. The obtained results showed that, the most stable immobilized α-galactosidase was obtained with the second strategy. The immobilized enzymes were characterized with respect to free counterpart. Some parameters effecting to the enzyme activity and stability were also analyzed. The optimum temperature and pH were found as 60 °C and pH 5.5 for all immobilized enzymes, respectively. All the immobilized α-galactosidases were more thermostable than the free enzyme at 50 °C. The stabilities of the Sepabead EC-EA and EC-HA adsorbed enzymes treated with glutaraldehyde compared to the stability of the free enzyme were a factor of 6 for Sepabead EC-EA and 5.3 for Sepabead EC-HA. Both the free and immobilized enzymes were very stable between pH 3.0 and 6.0 and more than 85% of the initial activities were recovered. Under the identical storage conditions the free enzyme lost its initial activity more quickly than the immobilized enzymes at the same period of time. The immobilized α-galactosidase seems to fulfill the requirements for different industrial applications.     

Vermiculite as an economic support for immobilization of neutral protease

A new and cheap support, vermiculite was successfully used to immobilize neutral protease by adsorption and hexamethylene diamine mediated coupling using glutaraldehyde as a bifunctional agent. Neutral protease immobilized on vermiculite by adsorption showed maximum retained activity than HMD mediated coupling. The optimum temperature for both free and immobilized neutral protease was found to be 45°C. However, the pH and thermal stabilities of immobilized neutral protease was observed to be better than that of the free enzyme. The storage stability of the immobilized enzyme was also studied.